Efficacy of slightly acidic electrolyzed water in killing or reducing Escherichia coli O157:H7 on iceberg lettuce and tomatoes under simulated food service operation conditions

Abstract: The objective of this study was to evaluate the efficacy of slightly acidic electrolyzed (SAEO) water in killing or removing Escherichia coli O157:H7 on iceberg lettuce and tomatoes by washing and chilling treatment simulating protocols used in food service kitchens. Whole lettuce leaves and tomatoes were spot‐inoculated with 100 μL of a mixture of 5 strains of E. coli O157:H7. Washing lettuce with SAEO water for 15 s reduced the pathogen by 1.4 to 1.6 log CFU/leaf, but the treatments did not completely inactivate the pathogen in the wash solution. Increasing the washing time to 30 s increased the reductions to 1.7 to 2.3 log CFU/leaf. Sequential washing in SAEO water for 15 s and then chilling in SAEO water for 15 min also increased the reductions to 2.0 to 2.4 log CFU/leaf, and no cell survived in chilling solution after treatment. Washing tomatoes with SAEO water for 8 s reduced E. coli O157:H7 by 5.4 to 6.3 log CFU/tomato. The reductions were increased to 6.6 to 7.6 log CFU/tomato by increasing the washing time to 15 s. Results suggested that application of SAEO water to wash and chill lettuce and tomatoes in food service kitchens could minimize cross‐contamination and reduce the risk of E. coli O157:H7 present on the produce. Practical Application: SAEO water is equally or slightly better than acidic electrolyzed (AEO) water for inactivation of bacteria on lettuce and tomato surfaces. In addition, SAEO water may have the advantages over AEO water on its stability, no chlorine smell, and low corrosiveness. Therefore, SAEO water may have potential for produce wash to enhance food safety.     

Efficacy of Neutral pH Electrolyzed Water in Reducing Escherichia coli O157:H7 and Salmonella Typhimurium DT 104 on Fresh Produce Items using an Automated Washer at Simulated Food Service Conditions

The objective of this study was to determine the efficacy of neutral pH electrolyzed (NEO) water (155 mg/L free chlorine, pH 7.5) in reducing Escherichia coli O157:H7 and Salmonella Typhimurium DT 104 on romaine lettuce, iceberg lettuce, and tomatoes washed in an automated produce washer for different times and washing speeds. Tomatoes and lettuce leaves were spot inoculated with 100 μL of a 5 strain cocktail mixture of either pathogen and washed with 10 or 8 L of NEO water, respectively. Washing lettuce for 30 min at 65 rpm led to the greatest reductions, with 4.2 and 5.9 log CFU/g reductions achieved for E. coli O157:H7 and S. Typhimurium respectively on romaine, whereas iceberg lettuce reductions were 3.2 and 4.6 log CFU/g for E. coli O157:H7 and S. Typhimurium respectively. Washing tomatoes for 10 min at 65 rpm achieved reductions greater than 8 and 6 log CFU/tomato on S. Typhimurium and E. coli O157:H7 respectively. All pathogens were completely inactivated in NEO water wash solutions. No detrimental effects on the visual quality of the produce studied were observed under all treatment conditions. Results show the adoption of this washing procedure in food service operations could be useful in ensuring produce safety.     

The impact of extreme weather events on Salmonella internalization in lettuce and green onion

Salmonella internalization is an important issue in raw vegetable consumption because washing usually cannot remove or inactivate the internalized pathogens effectively. In this study, the impact of extreme weather events, drought and heavy rains, caused by climate change on the internalization of Salmonella Typhimurium was investigated. Two leafy green fresh produce, iceberg lettuce and green onion were chosen. Rhizosphere soil inoculation was conducted to mimic the contamination routes via soil and then root uptake. Most internalized S. Typhimurium were found in lettuce leaves and in the root portions of green onion under all three irrigation conditions (optimal, drought, storm). In general, high concentration of soil inoculation facilitated the internalization level in both lettuce and green onion. Under extreme weather conditions, the internalization of S. Typhimurium in lettuce occurred when the soil was contaminated with a high level of bacteria (8–9 log colony forming unit (CFU)/g soil) and under these conditions, the internalization level was higher than the lettuce grown at the optimal water condition, except with 8 log CFU/g contamination (storm). Under drought, the results showed high variation, but the level of internalization of S. Typhimurium in lettuce increased by 16 times (1.21 log CFU/g) and 27 times (1.43 log CFU/g) compared to the optimally irrigated group when the soil was contaminated with 8 log and 9 log CFU/g soil, respectively. Ten-fold increased internalization was observed in the over-irrigated lettuce leaves when the soil was contaminated with 9 log CFU/g soil. The green onion samples showed ~ 4 log CFU/g green onion of S. Typhimurium internalization when exposed to high level of contamination (> 7 log CFU/g soil), which is a much higher internalization rate than the lettuce (average 2–3 log CFU/g). However, from the green onion experiments, no apparent patterns of water stress that affect on the levels on the Salmonella internalization were observed.     

A field study of the microbiological quality of fresh produce

The Centers for Disease Control and Prevention has reported that foodborne disease outbreaks associated with fruits and vegetables increased during the past decade. This study was conducted to characterize the routes of microbial contamination in produce and to identify areas of potential contamination from production through postharvest handling. We report here the levels of bacterial indicator organisms and the prevalence of selected pathogens in produce samples collected from the southern United States. A total of 398 produce samples (leafy greens, herbs, and cantaloupe) were collected through production and the packing shed and assayed by enumerative tests for total aerobic bacteria, total coliforms, total Enterococcus, and Escherichia coli. These samples also were analyzed for Salmonella, Listeria monocytogenes, and E. coli O157:H7. Microbiological methods were based on methods recommended by the U.S. Food and Drug Administration. For all leafy greens and herbs, geometric mean indicator levels ranged from 4.5 to 6.2 log CFU/g (aerobic plate count); less than 1 to 4.3 log CFU/g (coliforms and Enterococcus); and less than 1 to 1.5 log CFU/g (E. coli). In many cases, indicator levels remained relatively constant throughout the packing shed, particularly for mustard greens. However, for cilantro and parsley, total coliform levels increased during the packing process. For cantaloupe, microbial levels significantly increased from field through packing, with ranges of 6.4 to 7.0 log CFU/g (aerobic plate count); 2.1 to 4.3 log CFU/g (coliforms); 3.5 to 5.2 log CFU/g (Enterococcus); and less than 1 to 2.5 log CFU/g (E. coli). The prevalence of pathogens for all samples was 0, 0, and 0.7% (3 of 398) for L. monocytogenes, E. coli O157:H7, and Salmonella, respectively. This study demonstrates that each step from production to consumption may affect the microbial load of produce and reinforces government recommendations for ensuring a high-quality product.     

Efficacy of disinfectants to reduce Listeria monocytogenes on precut iceberg lettuce

The efficacy of water, chlorinated water (100 ppm), peracetic acid solution (0.05%), and commercial citric acid-based produce wash (0.25%) to reduce the population of Listeria monocytogenes on precut lettuce was tested. Samples were inoculated with a mixture of equal amounts of five L. monocytogenes strains at a level of 4.7 log CFU/g, and analyzed on the day of washing and after 3 and 6 days of storage at 6 degrees C. Sanitizer reduced the number of L. monocytogenes at maximum 1.7 log CFU/g and number of L. monocytogenes reached the inoculation level during 6 days of storage. Thus, disinfectants do not eliminate L. monocytogenes on precut lettuce and cannot be solely relied on in producing precut lettuce safely. The inoculated L. monocytogenes strains were recovered at different rates after 6 days of storage; one of these strains was not recovered at all. Thus, strain-specific differences exist in the ability of L. monocytogenes to survive the washing treatments of the lettuce.     

生菜生产到消费全程金黄色葡萄球菌的定量风险评估

目的：评估即食生菜金黄色葡萄球菌（Staphylococcus aureus）引起食物中毒的风险,为风险管理措施的选择提供理论支持。方法：排查生菜在大棚和露地两种种植方式下各环境样本的污染率及污染水平,结合居民消费习惯和生菜中金黄色葡萄球菌的生长模型,描述生菜从农田到餐桌过程中金黄色葡萄球菌的变化,从危害识别、危害特征描述、暴露评估和风险特征描述4 方面评估我国即食生菜导致金黄色葡萄球菌中毒的风险。结果：大棚生菜的土壤中有金黄色葡萄球菌检出,检出率为0.04%,污染水平为－8.72～3.01（lg（CFU/g））,经过灌溉、采收、运输、销售、购买、贮藏及清洗等过程,生菜中金黄色葡萄球菌在食用前的污染平均值为－1.95（lg（CFU/g））,90%置信区间为－8.98～4.40（lg（CFU/g））。评估结果表明,我国因即食生菜导致金黄色葡萄球菌中毒的概率为2.72×10－4,每年因此引发的食物中毒病例约为77万 人。敏感性分析结果显示,土壤中金黄色葡萄球菌的初始污染水平对生菜中金黄色葡萄球菌的污染水平影响最大,其次为家庭贮藏温度及食用前清洗过程;控制生菜种植卫生环境、合理使用冰箱及清洗生菜可有效降低即食生菜引起金黄色葡萄球菌中毒的风险。     

Assessing the cross contamination and transfer rates of Salmonella enterica from chicken to lettuce under different food-handling scenarios

Cross contamination of foodborne pathogens from raw meats to ready-to-eat foods has caused a number of foodborne outbreaks. The cross contamination and transfer rates of Salmonella enterica from chicken to lettuce under various food-handling scenarios were determined. The following scenarios were tested: in scenario 1, cutting board and knife used to cut chicken (10⁶ CFU/g) were also used for cutting lettuce, without washing; in scenario 2, cutting board and knife were washed with water separately after cutting chicken, and subsequently used for cutting lettuce; and in scenario 3, cutting board and knife were thoroughly washed with soap and hot water after cutting chicken, and before cutting lettuce. In each scenario, cutting board, knife, chicken and lettuce were sampled for population of S. enterica. For scenario 1, both before and after cutting lettuce, the cutting board and knife each had about 2 logs CFU/cm² of S. enterica, respectively. The cut lettuce had about 3 logs CFU/g of S. enterica. In scenario 2, fewer organisms (0.5–2.4 logs CFU/g or cm²) were transferred. The transfer rates in both scenarios ranged from 0.02 to 75%. However, in scenario 3, <1 log CFU/g or cm² organisms were detected on lettuce, cutting board or knife, after washing and cutting lettuce. This shows that the FDA recommended practice for cleaning cutting boards is effective in removing S. enterica and preventing cross contamination.     

Electrostatic spraying of food-grade organic and inorganic acids and plant extracts to decontaminate Escherichia coli O157:H7 on spinach and iceberg lettuce

The prevalence of foodborne illnesses is continually on rise. In the U.S.A., Escherichia coli O157:H7 (E. coli) has been associated with several outbreaks in minimally processed foods. Spinach and lettuce pose higher food safety risks and recurring food recalls suggest the insufficiency of current disinfection strategies. We aimed at offering a natural antimicrobial alternative using organic acids (malic, tartaric, and lactic acids [MA, TA, and LA, respectively]) and grape seed extract (GSE) and a novel application method using electrostatic spraying to evenly distribute the antimicrobials onto produce. Spinach and lettuce samples were washed, sanitized with sodium hypochlorite solution (6.25 mL/L), dip inoculated in water containing E. coli (7.0 log CFU/mL) for 24 h, and rewashed with sterile water to remove nonadhered pathogens. The samples were sprayed electrostatically with MA, LA, and GSE alone and in combinations and for comparison, with phosphoric acid (PA) and pH controls with deionized water adjusted to 1.5/2.3/3.6 and stored at 4 °C. When combined with LA (3%), MA (3%) showed 2.1 to 4.0 log CFU/g reduction of E. coli between the days 1 and 14 on spinach and 1.1 to 2.5 log CFU/g reduction on lettuce. Treatment with PA (1.5%) and PA (1.5%)-GSE (2%) exhibited 1.1 to 2.1 log CFU/g inhibition of E. coli on spinach during the 14-d storage. Our findings demonstrated the efficacy of electrostatic spraying of MA, LA, and GSE on fresh produce to improve the safety and lower the public health burden linked to produce contamination. PRACTICAL APPLICATION: Electrostatic spraying is an emerging technique that can be adopted to improve the distribution and application of antimicrobials during fresh produce sanitation. Relatively simple and quick, the process can access most/all parts of produce surface and offer protection from food pathogens. The use of malic and lactic acids with or without grape seed extract can serve as effective antimicrobials when sprayed electrostatically, lowering the risk from postcontamination issues with spinach and iceberg lettuce. This application technology can be extended to improve the commercial food safety of other produce, fruits, poultry, and meat.     

Efficacy of ozonated and electrolyzed oxidative waters to decontaminate hides of cattle before slaughter

The hides of cattle are the primary source of pathogens such as Escherichia coli O157:H7 that contaminate preevisceration carcasses during commercial beef processing. A number of interventions that reduce hide contamination and subsequent carcass contamination are currently being developed. The objective of this study was to determine the efficacy of ozonated and electrolyzed oxidizing (EO) waters to decontaminate beef hides and to compare these treatments with similar washing in water without the active antimicrobial compounds. Cattle hides draped over barrels were used as the model system. Ozonated water (2 ppm) was applied at 4,800 kPa (700 lb in2) and 15 degrees C for 10 s. Alkaline EO water and acidic EO water were sequentially applied at 60 degrees C for 10 s at 4,800 and 1,700 kPa (250 lb in2), respectively. Treatment using ozonated water reduced hide aerobic plate counts by 2.1 log CFU/100 cm2 and reduced Enterobacteriaceae counts by 3.4 log CFU/100 cm2. EO water treatment reduced aerobic plate counts by 3.5 log CFU/100 cm2 and reduced Enterobacteriaceae counts by 4.3 log CFU/100 cm2. Water controls that matched the wash conditions of the ozonated and EO treatments reduced aerobic plate counts by only 0.5 and 1.0 log CFU/100 cm2, respectively, and each reduced Enterobacteriaceae counts by 0.9 log CFU/100 cm2. The prevalence of E. coli O157 on hides was reduced from 89 to 31% following treatment with ozonated water and from 82 to 35% following EO water treatment. Control wash treatments had no significant effect on the prevalence of E. coli O157:H7. These results demonstrate that ozonated and EO waters can be used to decontaminate hides during processing and may be viable treatments for significantly reducing pathogen loads on beef hides, thereby reducing pathogens on beef carcasses.     

Salmonella sensitivity to sodium hypochlorite and citric acid in washing water of lettuce residues

Salmonella spp. is one of the main lettuce pathogens and should be inactivated during the disinfection of these vegetables before consumption. In minimally processed vegetable industries, residues of organic matter can prevent the inactivation of this pathogen by disinfectants. The objective of the present work was to evaluate the inactivation of Salmonella isolated from organic lettuce to sodium hypochlorite (25 and 50 ppm) and citric acid (0.5 and 1%) in washing water added with lettuce residues. To do so, a washing water with lettuce residues was elaborated, and Salmonella was added in the order of 10⁶ CFU/ml. Thereafter, each sanitizer was added separately to evaluate its effect on reducing Salmonella counts. After 1, 2, 3, 4, 5, 10, and 15 min of contact with the sanitizers, serial dilutions using neutralizer (0.5% sodium thiosulfate) were performed and each dilution was sown in Xylose-Lysine-Desoxycholate medium. Total aerobic mesophilic counts of wash water with lettuce residues before testing (without Salmonella) and after 15 min of exposure to each sanitizer (with Salmonella) were also performed. In addition, the free chlorine still present in the samples after the contact of sodium hypochlorite with lettuce residues for 15 min. The results demonstrated that 50 and 25 ppm sodium hypochlorite could reduce 6 log CFU/ml of Salmonella in 1 and 3 min of contact, respectively, while 0.5 and 1% citric acid was able to reduce 1.26 and 1.74 log CFU/ml respectively from the same microorganism within 15 min of contact. The total aerobic mesophilic counts of the wash water before being tested were, on average, 1.5 log CFU/ml. After addition of Salmonella, with 15 min of contact with the sanitizer, the results of total counts showed the same magnitude as the Salmonella counts. Organic matter may have reacted with the free chlorine present, reducing chlorine concentrations, since values of 30.4 ppm were observed when the initial concentration should be 50 and 17.1 ppm when the initial concentration should be 25 ppm. Based on the results, sodium hypochlorite demonstrated a greater microbial reduction capacity in wash water with lettuce residues, indicating that it is more appropriate to avoid cross-contamination between batches during sanitation of lettuce in washing tanks.     

Microbiological performance of a food safety management system in a food service operation

The microbiological performance of a food safety management system in a food service operation was measured using a microbiological assessment scheme as a vertical sampling plan throughout the production process, from raw materials to final product. The assessment scheme can give insight into the microbiological contamination and the variability of a production process and pinpoint bottlenecks in the food safety management system. Three production processes were evaluated: a high-risk sandwich production process (involving raw meat preparation), a medium-risk hot meal production process (starting from undercooked raw materials), and a low-risk hot meal production process (reheating in a bag). Microbial quality parameters, hygiene indicators, and relevant pathogens (Listeria monocytogenes, Salmonella, Bacillus cereus, and Escherichia coli O157) were in accordance with legal criteria and/or microbiological guidelines, suggesting that the food safety management system was effective. High levels of total aerobic bacteria (>3.9 log CFU/50 cm(2)) were noted occasionally on gloves of food handlers and on food contact surfaces, especially in high contamination areas (e.g., during handling of raw material, preparation room). Core control activities such as hand hygiene of personnel and cleaning and disinfection (especially in highly contaminated areas) were considered points of attention. The present sampling plan was used to produce an overall microbiological profile (snapshot) to validate the food safety management system in place.     

Efficacy of home washing methods in controlling surface microbial contamination on fresh produce

Much effort has been focused on sanitation of fresh produce at the commercial level; however, few options are available to the consumer. The purpose of this study was to determine the efficacy of different cleaning methods in reducing bacterial contamination on fresh produce in a home setting. Lettuce, broccoli, apples, and tomatoes were inoculated with Listeria innocua and then subjected to combinations of the following cleaning procedures: (i) soak for 2 min in tap water, Veggie Wash solution, 5% vinegar solution, or 13% lemon solution and (ii) rinse under running tap water, rinse and rub under running tap water, brush under running tap water, or wipe with wet/dry paper towel. Presoaking in water before rinsing significantly reduced bacteria in apples, tomatoes, and lettuce, but not in broccoli. Wiping apples and tomatoes with wet or dry paper towel showed lower bacterial reductions compared with soaking and rinsing procedures. Blossom ends of apples were more contaminated than the surface after soaking and rinsing; similar results were observed between flower section and stem of broccoli. Reductions of L. innocua in both tomatoes and apples (2.01 to 2.89 log CFU/g) were more than in lettuce and broccoli (1.41 to 1.88 log CFU/g) when subjected to same washing procedures. Reductions of surface contamination of lettuce after soaking in lemon or vinegar solutions were not significantly different (P > 0.05) from lettuce soaking in cold tap water. Therefore, educators and extension workers might consider it appropriate to instruct consumers to rub or brush fresh produce under cold running tap water before consumption.     

Internalization of bacterial pathogens in tomatoes and their control by selected chemicals

The effect of different washing or sanitizing agents was compared for preventing or reducing surface and internal contamination of tomatoes by Salmonella Typhimurium and Escherichia coli O157:H7. The tomatoes were inoculated by dipping them in a bacterial suspension containing approximately 6.0 log CFU/ml of each pathogen and then rinsing them with tap water, hypochlorite solution (250 mg/liter), or lactic acid solution (2%, wt/vol). All treatments were applied by dipping or spraying, and solutions were applied at 5, 25, 35, and 55 degrees C. With the exception of the lactic acid dip at 5 degrees C, all treatments reduced both pathogens on the surfaces of the tomatoes by at least 2.9 cycles. No significantly different results were obtained (P > 0.05) with the dipping and spraying techniques. For internalized pathogens, the mean counts for tomatoes treated with water alone or with chlorine ranged from 0.8 to 2.1 log CFU/g. In contrast, after lactic acid spray treatment, all core samples of tomatoes tested negative for Salmonella Typhimurium and, except for one sample with a low but detectable count, all samples tested negative for E. coli O157:H7 with a plate count method. When the absence of pathogens was verified by an enrichment method, Salmonella was not recovered from any samples, whereas two of four samples tested positive for E. coli O157:H7 even though the counts were negative. Few cells of internalized pathogens were able to survive in the center of the tomato during storage at room temperature (25 to 28 degrees C). The average superficial pH of tomatoes treated with tap water, chlorine, or lactic acid was 4.9 to 5.2, 4.1 to 4.3, and 2.5, respectively (P < 0.05), whereas no differences were observed in the internal pH (3.6 to 3.7) of the tomatoes treated with different sanitizers. The general practice in the tomato industry is to wash the tomatoes in chlorinated water. However, chlorine is rapidly degraded by organic matter usually present in produce. Therefore, lactic acid sprays may be a more effective alternative for decontaminating tomato surfaces. The use of warm (55 degrees C) sprays could reduce pathogen internalization during washing.     

Prewashing with acidified sodium chlorite reduces pathogenic bacteria in lightly fermented Chinese cabbage

Efficacy of prewashing with acidified sodium chlorite (ASC) for the sanitation of lightly fermented Chinese cabbage was evaluated. The population of the natural microflora on the cabbage leaves was reduced about 2.0 log CFU/g just after washing with ASC, a significant reduction compared with the control distilled water wash (P < or = 0.05). In the control experiment, viable aerobic bacteria increased gradually when incubated at 10 degrees C; however, ASC-washed cabbage maintained a lower microbial concentration. The treatment of Chinese cabbage with ASC reduced the population of artificially inoculated Escherichia coli O157:H7, Salmonella Enteritidis, Staphylococcus aureus, and Listeria monocytogenes by 2.4 log CFU/g. The sanitation efficacy of ASC was 1.6 log CFU/g higher than that of distilled water washing. The viable cell counts of all pathogenic bacteria tested remained constant during 8 days of storage at 10 degrees C for both washing treatments, with the exception of L. monocytogenes, whose viable cell counts increased gradually with time for both treatments. No significant differences in color, odor, taste, and texture in raw leaves were observed after the ASC wash compared with after the distilled water wash. These results indicate that prewashing with ASC could control bacterial growth in lightly fermented Chinese cabbage without changing the product quality.     

Insight into the prevalence and distribution of microbial contamination to evaluate water management in the fresh produce processing industry

This study provided insight into the degree of microbial contamination in the processing chain of prepacked (bagged) lettuce in two Belgian fresh-cut produce processing companies. The pathogens Salmonella and Listeria monocytogenes were not detected. Total psychrotrophic aerobic bacterial counts (TPACs) in water samples, fresh produce, and environmental samples suggested that the TPAC is not a good indicator of overall quality and best manufacturing practices during production and processing. Because of the high TPACs in the harvested lettuce crops, the process water becomes quickly contaminated, and subsequent TPACs do not change much throughout the production process of a batch. The hygiene indicator Escherichia coli was used to assess the water management practices in these two companies in relation to food safety. Practices such as insufficient cleaning and disinfection of washing baths, irregular refilling of the produce wash baths with water of good microbial quality, and the use of high product/water ratios resulted in a rapid increase in E. coli in the processing water, with potential transfer to the end product (fresh-cut lettuce). The washing step in the production of fresh-cut lettuce was identified as a potential pathway for dispersion of microorganisms and introduction of E. coli to the end product via cross-contamination. An intervention step to reduce microbial contamination is needed, particularly when no sanitizers are used as is the case in some European Union countries. Thus, from a food safety point of view proper water management (and its validation) is a critical point in the fresh-cut produce processing industry.     

Influence of Exposure Time,Shear Stress,and Surfactants on Detachment of <Emphasis Type="Italic">Escherichia coli</Emphasis> O157:H7 from Fresh Lettuce Leaf Surfaces During Washing Process

Washing and sanitation of fresh produce are critical for detachment and inactivation of pathogenic and spoilage microorganisms. The overall goal of this study was to evaluate the influence of processing conditions such as washing time, shear stress, and a food grade surfactant on the detachment of Escherichia coli O157:H7 from lettuce leaf surfaces during a simulated washing process. A benchtop scale rotating disk washing device was designed to simulate the processing conditions used in commercial washing systems. Numerical simulations were carried out to calculate the flow profile and shear stress near the leaf surface. Removal of E. coli O157:H7 as a function of processing conditions in the rotating disk washing device was evaluated by enumeration of bacterial population using plate counting and changes in bioluminescence intensity and further confirmed by bioluminescence imaging. The results showed that shear stress was necessary to remove attached bacteria from inoculated leaf samples and simple incubation of inoculated leaves with wash water was not effective. Furthermore, detachment of bacteria from inoculated leaf samples increased with increasing shear stress and incubation time. Shear stress values in the range of 0 – 300 mPa were adequate to induce removal of approximately 1.5 log CFU/cm² of bacteria from inoculated samples. The addition of a surfactant increased the removal of bacteria from inoculated leaf samples by 0.5 log CFU/cm². Overall, these results may guide the design of new produce wash systems as well as current industrial practice related to flow conditions and use of surfactants during washing of fresh produce.     

On-farm and postharvest processing sources of bacterial contamination to melon rinds

Multistate and international foodborne illness outbreaks, particularly involving cantaloupe and often involving rare Salmonella spp., have increased dramatically over the past 13 years. This study assessed the sources and extent of melon rind contamination in production fields and at processing and packing facilities. In the spring of 1999, cantaloupe (Cucumis melo L. [reticulatus group] cv. Cruiser) sampled from two sites in the Rio Grande River Valley showed that postharvest-processed melon rinds often had greater plate counts of bacterial contaminants than field-fresh melons. Cantaloupe in the field had 2.5 to 3.5 log CFU g(-1) rind total coliforms by aerobic plate counts, whereas washed melons had 4.0 to 5.0 log CFU g(-1). In the fall of 1999, coliforms on honeydew melons (C. melo [inodorous group] cv. Honey Brew) ranged from 2.6 to 3.7 log CFU g(-1) after processing, and total and fecal coliforms and enterococci never fell below 2.5 log CFU g(-1). A hydrocooler at another site contaminated cantaloupe rinds with up to 3.4 log CFU g(-1) total and fecal enterococci; a secondary rinse with chlorinated water incompletely removed these bacteria. Sources of coliforms and enterococci were at high levels in melon production soils, especially in furrows that were flood irrigated, in standing water at one field, and in irrigation water at both sites. At one processing facility, wash water pumped from the Rio Grande River may not have been sufficiently disinfected prior to use. Because soil, irrigation water, and process water were potential sources of bacterial contamination, monitoring and management on-farm and at processing and packing facilities should focus on water quality as an important control point for growers and packers to reduce bacterial contamination on melon rinds.     

Modeling of Free Chlorine Consumption and Escherichia coli O157:H7 Cross‐Contamination During Fresh‐Cut Produce Wash Cycles

Controlling the free chlorine (FC) availability in wash water during sanitization of fresh produce enhances our ability to reduce microbial levels and prevent cross‐contamination. However, maintaining an ideal concentration of FC that could prevent the risk of contamination within the wash system is still a technical challenge in the industry, indicating the need to better understand wash water chemistry dynamics. Using bench‐scale experiments and modeling approaches, we developed a comprehensive mathematical model to predict the FC concentration during fresh‐cut produce wash processes for different lettuce types (romaine, iceberg, green leaf, and red leaf), carrots, and green cabbage as well as Escherichia coli O157:H7 cross‐contamination during fresh‐cut iceberg lettuce washing. Fresh‐cut produce exudates, as measured by chemical oxygen demand (COD) levels, appear to be the primary source of consumption of FC in wash water, with an apparent reaction rate ranging from L/mg·min for all produce types tested, at stable pH levels (6.5 to 7.0) in the wash water. COD levels increased over time as more produce was washed and the lettuce type impacted the rate of increase in organic load. The model parameters from our experimental data were compared to those obtained from a pilot‐plant scale study for lettuce, and similar reaction rate constant (5.38 × 10^-4 L/mg·min) was noted, supporting our hypothesis that rise in COD is the main cause of consumption of FC levels in the wash water. We also identified that the bacterial transfer mechanism described by our model is robust relative to experimental scale and pathogen levels in the wash water. Finally, we proposed functions that quantify an upper bound on pathogen levels in the water and on cross‐contaminated lettuce, indicating the maximum potential of water‐mediated cross‐contamination. Our model results could help indicate the limits of FC control to prevent cross‐contamination during lettuce washing.     

Survival of Enterobacter sakazakii on fresh produce as affected by temperature, and effectiveness of sanitizers for its elimination

A study was done to determine the survival characteristics of Enterobacter sakazakii on the surface of apples, cantaloupes, strawberries, lettuce, and tomatoes stored at 4, 12, and 25 degrees C for 8-28 days. Populations significantly decreased (por=50 microg/ml, were equivalent in killing E. sakazakii on apples. Populations of E. sakazakii on apples treated with 10 microg/ml chlorine dioxide for 1 or 5 min were significantly reduced (por=4.00 log CFU/apple. Reductions of >or=3.70 log CFU/tomato were achieved by treatment with 10 microg/ml chlorine or chlorine dioxide or 40 microg/ml Tsunami 200 for 5 min. Reductions in populations of E. sakazakii on lettuce treated with chlorine at 10, 50, and 100 microg/ml for 1 min ranged from 1.61 to 2.50 log CFU/sample (26+/-4 g), compared to populations remaining on lettuce washed with water. Chlorine was less effective in killing E. sakazakii on lettuce than on apples or tomatoes. Treatment of lettuce with Tsunami 200 (40 and 80 microg/ml) for 5 min caused a reduction of >or=5.31 log CFU/sample. Results provide insights to predicting survival characteristics of E. sakazakii on produce and the efficacy of sanitizers in killing the bacterium.