Monitoring the effects of high pressure processing and temperature on selected beef quality attributes

The combined effects of high pressure processing (HPP) and temperature on meat quality attributes were assessed in bovine M. pectoralis profundus, with particular focus on lipid oxidation and fatty acid composition. Beef samples were pressurised at 200, 300 and 400 MPa at two different temperatures 20 °C and 40 °C. Both pressure and temperature regimes had significant effects on colour, cook loss and lipid oxidation. Pressurisation at 200 MPa had a lower impact on colour parameters than higher pressurisation levels. Cook loss also increased when higher levels of pressure were applied. Across all pressure conditions, lower cook loss was observed at 40 °C compared to 20 °C. An increase in TBARS values was observed at the higher pressure levels (300, 400 MPa). While some alterations of individual fatty acids were observed, high pressure had no effect on polyunsaturated/saturated fatty acid (PUFA/SFA) or omega 6/omega 3 (n6/n3) ratio. The temperature at which HPP was applied had a significant effect on the sum of saturated (SFA), monounsaturated (MONO) and polyunsaturated (PUFA) fatty acids. HPP at 40 °C showed higher SFA and PUFA and lower MONO compared to HPP at 20 °C. These results show that high pressure at low or moderate temperatures improves the microbiological quality of the meat with minimal affects on meat quality.     

High-pressure processing decelerates lipolysis and formation of volatile compounds in ovine milk blue-veined cheese

Enzyme-rich cheeses are prone to over-ripening during refrigerated storage. Blue-veined cheeses fall within this category because of the profuse growth of Penicillium roqueforti in their interior, which results in the production of highly active proteinases, lipases, and other enzymes responsible for the formation of a great number of flavor compounds. To control the excessive formation of free fatty acids (FFA) and volatile compounds, blue-veined cheeses were submitted to high-pressure processing (HPP) at 400 or 600 MPa on d 21, 42, or 63 after manufacture. Cheeses were ripened for 30 d at 10°C and 93% relative humidity, followed by 60 d at 5°C, and then held at 3°C until d 360. High-pressure processing influenced the concentrations of acetic acid and short-chain, medium-chain, and long-chain FFA. The effect was dependent on treatment conditions (pressure level and cheese age at the time of treatment). The lowest concentrations of acetic acid and FFA were recorded for cheeses treated at 600 MPa on d 21; these cheeses showed the lowest esterase activity values. Acetic acid and all FFA groups increased during ripening and refrigerated storage. The 102 volatile compounds detected in cheese belonged to 10 chemical groups (5 aldehydes, 12 ketones, 17 alcohols, 12 acids, 35 esters, 9 hydrocarbons, 5 aromatic compounds, 3 nitrogen compounds, 3 terpenes, and 1 sulfur compound). High-pressure processing influenced the levels of 97 individual compounds, whereas 68 individual compounds varied during refrigerated storage. Total concentrations of all groups of volatile compounds were influenced by HPP, but only ketones, acids, esters, and sulfur compounds varied during refrigerated storage. The lowest total concentrations for most groups of volatile compounds were recorded for the cheese pressurized at 600 MPa on d 21. A principal component analysis combining total concentrations of groups of FFA and volatile compounds discriminated cheeses by age and by the pressure level applied to HPP cheeses.     

Significant influence of particular unsaturated fatty acids and pH on the volatile compounds in meat-like model systems

The present study aimed to investigate the effects of particular unsaturated fatty acids and pH on volatile compounds in the meat-like model systems containing 21 amino acids and ribose. We have chosen oleic acid (C18:1n-9), linoleic acid (C18:2n-6) and linolenic acid (C18:3n-3) for the present investigation. The effect on the volatile compounds was evaluated at two different pH 5.5 and 6.2. The addition of C18:2n-6 and C18:3n-3 to the Maillard reaction mixtures inhibited the formation of many Maillard compounds or produced in low amount. Whereas, the addition of C18:1n-9 resulted in an increase in the amount of many Maillard compounds. The thiols and thiophenes were preferentially formed at pH 5.5 whereas pyrazines were preferentially favored at pH 6.2. Based on our results, it is suggested that a high level of C18:2n-6 and C18:3n-3 in meat probably causes an undesirable flavor. The pH value of 5.5 was found to be ideal for the formation of volatile compounds associated with desirable flavor of meat.     

Effect of high pressure processing and cooking treatment on the quality of Atlantic salmon

The effect of high pressure treatment (HPP) (150 MPa and 300 MPa for 15 min) and cooking on quality of Atlantic salmon based on microbial activity, lipid oxidation, fatty acid profile, colour and texture during 6 days of storage was studied. High pressure and cooking significantly (p < 0.05) reduced microbial growth. The 300 MPa treatment and cooking showed higher L∗ and b∗ values but lower a∗ values for dark muscle compared to control and samples treated at 150 MPa. An increase in pressure resulted in an increase in hardness, gumminess and chewiness parameters, and a decrease in adhesiveness compared to control and cooked samples. Whereas cooking and 150 MPa led to similar oxidation development as control in dark muscle, the 300 MPa treatment effectively reduced the samples susceptibility to oxidation. Fatty acid profile of cooked Atlantic salmon dark muscle showed significantly (p < 0.05) lower amounts of total saturated, n−3 Polyunsaturated fatty acids (PUFA) and n−6 PUFA and significantly (p < 0.05) higher amounts of monoenes than HPP treated samples during the entire storage period. However, the most important finding of this study was that there was no significant (p > 0.05) difference between control and HPP treated samples in terms of total saturated, monoenes, n−3 PUFA and n−6 PUFA fatty acid profile. This demonstrates that HPP is a very mild process in terms of its effect on fatty acids.     

Effect of the dietary supplementation of essential oils from rosemary and artemisia on muscle fatty acids and volatile compound profiles in Barbarine lambs

Eighteen Barbarine lambs (3 months of age), were assigned for 95 days to 3 treatments: six lambs were fed a barley-based concentrate plus oat hay ad libitum (control group, C); other lambs received the control diet plus essential oil (400 ppm DM) either of Rosmarinus officinalis (R400 group; n = 6) or of Artemisia herba alba (A400 group; n = 6). At slaughter the muscle longissimus dorsi was sampled and subjected to fatty acid and volatile organic compounds (VOC) analyses. The A400 lambs presented a greater amount of vaccenic, rumenic and linolenic acids and of polyunsaturated fatty acids (PUFA) in meat than the C and R400 animals. Essential oils supplementation did not affect meat VOC profile though the sesquiterpenes copaene and β-caryophyllene were detected only in the meat of R400 and A400 lambs. It is concluded that the supplementation of rosemary or artemisia essential oils does not produce detrimental effects on lamb meat VOC profile. The supplementation of artemisia can improve meat healthy properties.     

Effect of dietary conjugated linoleic acid in combination with monounsaturated fatty acids on the composition and quality traits of cooked loin

Three levels (0%, 1% and 2%) of a conjugated linoleic acid oil (CLA) were combined with two levels of monounsaturated fatty acids (MUFA) (low – 19% average and high – 39% average) for pig feeding (n = 48, eight animals per treatment). The composition and quality traits (fat content, cooking losses, lipid oxidation, fatty acid profile, volatile profile and sensory analysis) of cooked loin, as affected by dietary CLA, MUFA, and CLA × MUFA interaction were studied. CLA and CLA × MUFA did not affect the intramuscular fat content, cooking losses, lipid oxidation, volatile profile and sensory traits of cooked meat. Therefore, CLA could be supplemented to the pig diet without detriment of the measured quality traits of cooked meat, and regardless of the MUFA level of pig diets. Dietary CLA increased the content of SFA and decreased the level of MUFA of meat, and led to a CLA enrichment, regardless the MUFA level of pig diets, but the content of CLA isomers of fresh meat decreased after the cooking process.     

Effect of high pressure on moisture and NaCl diffusion into turkey breast

High-pressure processing (HPP) affects food component diffusion. This study evaluated pressure (0.1-300 MPa) effect on the diffusion of NaCl and water into turkey breast at 25 °C. NaCl and water diffusion were found to be a function of pressure and holding time. During the pressure come-up-time, diffusion of water and NaCl into the sample was enhanced as compared to control. The diffusion coefficient of moisture infusing out of the sample was found to be a minimum at 150 MPa. The diffusion coefficient of NaCl infusing into the sample was maximum at 150 MPa. Within the range of experimental conditions studied, 150 MPa treatment (up to 15 min holding time) yielded meat samples with minimum hardness, gumminess, and chewiness. Ultrastructure images revealed that 150 MPa treatments caused swelling of myofibrils, disappearance of the M-line, reduced difference in the density of the A-band and I-band and breaking of segments of Z-line. HPP could be a useful technique for the salting of turkey meat.     

Volatile compounds in low-acid fermented sausage “espetec” and sliced cooked pork shoulder subjected to high pressure processing. A comparison of dynamic headspace and solid-phase microextraction

Two extraction techniques, dynamic headspace extraction (DHE) and solid-phase microextraction (SPME), were compared to assess the effect of high-pressure treatment (400 MPa, 10 min, 12 °C) on the volatile compounds of low-acid fermented sausage “espetec” and sliced cooked pork shoulder stored at 4 °C. DHE was more efficient at extracting low-boiling compounds such as ethanal, 2,3-butanedione and alcohols, while SPME extracted more efficiently a higher number of chemical families, especially fatty acids. The effect of pressurisation on the volatile fraction of “espetec” was better categorized by DHE, whereas SPME was more appropriate for cooked pork shoulder. The volatile fraction of “espetec” changed slightly after pressurisation, mainly showing a decrease in the levels of lipid-derived compounds, like linear alkanes, aldehydes, or 1-alcohols in pressurised samples. The volatile profile of cooked pork shoulder underwent substantial changes during refrigerated storage, mainly due to microbial metabolism, most of these changes being limited by HPP.     

High pressure induced changes on sarcoplasmic protein fraction and quality indicators

The combined effect of pressure and mild temperature treatments on bovine sarcoplasmic proteins and quality parameters was assessed. M. longissimus dorsi samples were pressurised in a range of 200–600 MPa and 10–30 °C. High Pressure Processing (HPP) induced a reduction of protein solubility (p < 0.001) compared to non-treated controls (NT), more pronounced above 200 MPa. HPP at pressures higher than 200 MPa induced a strong modification (p < 0.001) of meat colour and a reduction of water holding capacity (WHC). SDS–PAGE analysis demonstrated that HPP significantly modified the composition of the sarcoplasmic protein fraction. The pressurisation temperature mainly affected protein solubility and colour; a smaller effect was observed on protein profiles. Significant correlations (p < 0.001) between sarcoplasmic protein solubility and both expressible moisture (r = −0.78) and colour parameters (r = −0.81 to −0.91) suggest that pressure induced denaturation of sarcoplasmic proteins could influence to some extent WHC and colour modifications of beef. Changes in protein band intensities were also significantly correlated with protein solubility, meat lightness and expressible moisture. These results describe the changes induced by HPP on sarcoplasmic proteins and confirm a relationship between modification of the sarcoplasmic protein fraction and alteration of meat quality characteristics.     

High pressure induced changes in beef muscle proteome: Correlation with quality parameters

The relationship between pressure induced changes on individual proteins and selected quality parameters in bovine longissimus thoracis et lumborum (LTL) muscle was studied. Pressures ranging from 200 to 600 MPa at 20 °C were used. High pressure processing (HPP) at pressures above 200 MPa induced strong modifications of protein solubility, meat colour and water holding capacity (WHC). The protein profiles of non-treated and pressure treated meat were observed using two dimensional electrophoresis. Proteins showing significant differences in abundance among treatments were identified by mass spectrometry. Pressure levels above 200 MPa strongly modified bovine LTL proteome with main effects being insolubilisation of sarcoplasmic proteins and solubilisation of myofibrillar proteins. Sarcoplasmic proteins were more susceptible to HPP effects than myofibrillar. Individual protein changes were significantly correlated with protein solubility, L*, b* and WHC, providing further insights into the mechanistic processes underlying HPP influence on quality and providing the basis for the future development of protein markers to assess the quality of processed meats.     

Hydroperoxide formation in different lean meats

Peroxide is one of the compounds that are indicated to be toxic in the human digestion system. Lean fresh meat samples were collected from beef, lamb, pork and chicken to investigate their hydroperoxide formation potential. Total peroxides of fresh comminuted raw meat were determined by analysing protein-bound peroxides and hydroperoxide compounds in water–methanol and chloroform extracted phases. The amount of total peroxides was ranked as: beef > pork > lamb > chicken. Hydroperoxide formation was examined at different pH values and at different incubation times, using beef and chicken samples. All peroxides were transient, with a maximum value after 2–4 h of incubation at 37 °C. When pH fell from 7 to 1.5, the different peroxides fell by 10–20%. Non-polar peroxide formation could largely (70%) be described by variation in fatty acid composition and hemin content of the meat, while protein-bound peroxide variation was less explained by these variables. Liposome addition increased (40%) the amount of protein-bound peroxides.     

Effect of dietary supplementation with either red wine extract or vitamin E on the volatile profile of lamb meat fed with omega-3 sources

The effect of dietary supplementation with either vitamin E (300 ppm) or a red wine extract rich in polyphenols (900 ppm) in an omega-3 enriched concentrate on the volatile fraction of lamb meat was assessed. The effect of refrigerated storage (0 and 6 days) under high-oxygen atmospheres (70% O₂/30% CO₂) was also studied. Extraction and analysis of the volatile compounds was carried out by headspace solid-phase microextraction (HS-SPME) and GC–MS, respectively. Vitamin E supplementation led to lower levels of lipo-oxidation compounds, such as 2-heptanone and 1-penten-3-ol. The red wine extract was less efficient against lipid oxidation than vitamin E but more efficient than the control (no added antioxidants). The levels of numerous lipid-derived compounds were found to be lower after 6 days of storage which could be due to further interactions with protein-related compounds.     

Effect of gamma irradiation on microbial load and quality characteristics of minced camel meat

The effect of gamma irradiation on microbial load, chemical and sensory characteristics of camel meat has been evaluated. Camel meat was irradiated at doses of 0, 2, 4 and 6 kGy of gamma irradiation. Irradiated and non-irradiated meat was kept in a refrigerator (1–4 °C). General composition and sensory evaluation of camel meat was done two days after irradiation, whereas, microbiological and chemical analysis was done immediately after irradiation and throughout the storage periods. The results indicated that all doses of gamma irradiation reduced the total mesophilic aerobic plate counts (TPCs) and total coliforms of camel meat. Thus, the microbiological shelf-life of camel meat was significantly extended from less than 2 weeks (control) to more than 6 weeks (samples irradiated with 2, 4 or 6 kGy). No significant differences in moisture, protein, fat, thiobarbituric acid (TBA) values, total acidity and fatty acids of camel meat were observed due to irradiation. There were slight effects of gamma irradiation in both total volatile basic nitrogen (VBN) and lipid oxidation values in camel meat. Sensory evaluation showed no significant differences between irradiated and non-irradiated camel meats.     

Functional milk beverage fortified with phenolic compounds extracted from olive vegetation water, and fermented with functional lactic acid bacteria

Functional milk beverages (FMB100 and FMB200) fortified with phenolic compounds (100 and 200 mg/l) extracted from olive vegetable water, and fermented with γ-amino butyric acid (GABA)-producing (Lactobacillus plantarum C48) and autochthonous human gastro-intestinal (Lactobacillus paracasei 15N) lactic acid bacteria were manufactured. A milk beverage (MB), without addition of phenolic compounds, was used as the control. Except for a longer latency phase of FMB200, the three beverages showed an almost similar kinetic of acidification, consumption of lactose and synthesis of lactic acid. Apart from the beverage, Lb. plantarum C48 showed a decrease of ca. Log 2.52-2.24 cfu/ml during storage. The cell density of functional Lb. paracasei 15N remained always above the value of Log 8.0 cfu/ml. During fermentation, the total concentration of free amino acids markedly increased without significant (P > 0.05) differences between beverages. The concentration of GABA increased during fermentation and further storage (63.0 ± 0.6-67.0 ± 2.1 mg/l) without significant (P > 0.05) differences between beverages. After fermentation, FMB100 and FMB200 showed the same phenolic composition of the phenol extract from olive vegetable water but a different ratio between 3,4-DHPEA and 3,4-DHPEA-EDA. During storage, the concentrations of 3,4-DHPEA-EDA, p-HPEA and verbascoside of both FMB100 and FMB200 decreased. Only the concentration of 3,4-DHPEA increased. As shown by SPME-GC-MS analysis, diactetyl, acetoin and, especially, acetaldehyde were the main volatile compounds found. The concentration of phenolic compounds does not interfere with the volatile composition. Sensory analyses based on triangle and paired comparison tests showed that phenolic compounds at the concentrations of 100 or 200 mg/l were suitable for addition to functional milk beverages.     

Effect of dietary carnosic acid on the fatty acid profile and flavour stability of meat from fattening lambs

Thirty-two lambs were fed with barley straw supplemented by a concentrate alone, or a concentrate enriched with either vitamin E (VITE006: 0.6 g kg⁻¹ feed concentrate) or carnosic acid (CARN006: 0.6 g kg⁻¹ feed concentrate; or CARN012: 1.2 g kg⁻¹ feed concentrate). In order to elucidate the influence of the dietary supplementation of carnosic compared with a reference diet antioxidant (vitamin E), the animals were slaughtered and the longissimus thoracis were lyophilised to determine the FAs profile and the phenolic compounds. In addition, longissimus lumborum slices were stored in a modified atmosphere package for 3 days and then grilled to determine volatile compounds. Dietary carnosic acid did not modify the FAs profile, but had a clear effect on the production of volatile compounds, in a dose-dependent manner. These results have implications for the food industry, since dietary carnosic acid seems to extend the shelf life of lamb meat.     

Relationship between the solubility,dosage and antioxidant capacity of carnosic acid in raw and cooked ground buffalo meat patties and chicken patties

Antioxidant capacity of oil soluble and water dispersible carnosic acid (CA) extracted from dried rosemary leaves using HPLC was evaluated at two different dosages (22.5 ppm vs 130 ppm) in raw and cooked ground buffalo meat patties and chicken patties. Irrespective of total phenolic content, CA extracts reduced (p < 0.05) the thiobarbituric acid reactive substances (TBARS) by 39%–47% and 37%–40% in cooked buffalo meat and chicken patties at lower dosage (22.5 ppm) relative to control samples. However, at higher dosage (130 ppm) the TBARS values were reduced (p < 0.05) by 86%–96% and 78%–87% in cooked buffalo meat and chicken patties compared to controls. The CA extracts were also effective in inhibiting (p < 0.05) peroxide value and free fatty acids in cooked buffalo meat and chicken patties. The CA extracts when used at higher dosage, were also effective in stabilizing raw buffalo meat color.     

Non-volatile taste active compounds in the meat of Chinese mitten crab (Eriocheir sinensis)

The non-volatile taste active compounds, including soluble sugars, succinic acid, free amino acids and flavour 5′-nucleotides in the meat of Chinese mitten crab (Eriocheir sinensis) were analyzed, and their taste impacts were evaluated by taste active values (TAVs) and equivalent umami concentration (EUC) methods. The total free amino acid content of crab meat was 20.9 mg/g. Arginine, glycine and alanine were the major free amino acids, accounting for more than 70% of the total free amino acids. 5′-Adenosine monophosphate (AMP) was the main flavour 5′-nucleotide (75.3 mg/100 g), followed by 5′-inosine monophosphate (IMP) (34.4 mg/100 g) and 5′-guanosine monophosphate (GMP) (2.3 mg/100 g). Arginine, glycine, alanine, glutamic acid, IMP and AMP were of high TAV (greater than one), and they had strong taste impacts on the crab meat flavour. Glycine and alanine contributed to the major sweet taste, while glutamic acid, IMP and AMP contributed to the strong umami taste. As the TAVs of soluble sugar, succinic acid and bitter free amino acids were lower than one, thus those compounds are likely to have insignificant impact on the taste of the crab meat. The EUC was 4.2 g MSG/100 g crab meat, which meant that the umami taste of the crab meat was very intense.     

Influence of type of muscles on nutritional value of foal meat

The effect of type of muscle on nutritional characteristic (fatty acid profile, amino acid content, cholesterol and major and minor mineral) of foal meat was investigated. Six muscles: longissimus dorsi (LD), semimembranosus (SM), semitendinosus (ST), biceps femoris (BF), triceps brachii (TB) and psoas major & minor (PM) from twelve foals slaughtered at 15 months from an extensive production system in freedom regimen were extracted for this study. Horse meat is characterized by low fat, low cholesterol content, rich in iron and in vitamin B. Statistical analysis showed that the cholesterol content did not show significant differences (P > 0.05) among muscle with mean value range between 0.62 and 0.57 mg/100 g. Most fatty acid presented significant differences (P < 0.05) with respect to the type of muscle. The obtained results showed that except for the polyunsaturated linoleic acid, the highest contents of fatty acids were found in the hindquarter muscles. Regarding amino acid profile, significant differences (P < 0.05) were observed among muscles and our results indicated that, 100 g of foal meat covered from 80.6 to 86.7% for the daily requirement for an adult man weighing 70 kg for essential amino acids for ST and LD muscles, respectively. Statistical analysis showed significant differences (P = 0.050) for the EAA (essential amino acids) index, which was highest for TB muscle, followed by BF and SM muscles, while the lowest values were reported by ST muscle. Finally, foal meat seems to be a very good nutritional source of major and minor minerals. The higher nutritional value of foal meat will be of great importance in the promotion of this meat.     

Volatile compounds of fresh and dry-cured loin as affected by dietary conjugated linoleic acid and monounsaturated fatty acids

Three levels (0%, 1% and 2%) of an enriched conjugated linoleic acid oil (CLA) were combined with two levels of monounsaturated fatty acids (MUFA) (low (19%) average and high (39%) average) for pig feeding. The profile of volatile compounds of fresh and dry-cured loin as affected by dietary CLA, MUFA and CLA × MUFA interaction was studied by headspace-solid phase microextraction coupled to gas chromatography–mass spectrometry. A total of 27 and 69 compounds were identified in fresh loin and dry-cured loin, respectively. Identified compounds were alcohols, aldehydes, aliphatic hydrocarbons, aromatic hydrocarbons, esters, furans, ketones, nitrogen compounds, sulphur compounds and terpenes. No qualitative differences in volatile compounds caused by the assayed treatments were found neither in fresh loin nor in dry-cured loin. Dietary CLA, MUFA and their interaction did not affect the level of most detected volatiles. Nevertheless, in fresh loin, the level of heptanal significantly increased due to dietary CLA (p = 0.001) and the area units (AU) for ethyl benzene and 1,3-dimethyl benzene increased at 1% CLA (p < 0.05). In the case of dry-cured loin, the AU of heptanal, nonanal and 2-nonenal contents increased due to dietary CLA (p = 0.016, 0.024 and 0.019, respectively).     

Aroma compounds generated from thermal reaction of l-ascorbic acid with l-cysteine

The reaction of l-ascorbic acid with l-cysteine in heated aqueous solution (141 ± 1 °C) at five different pH values (5.00, 6.00, 7.00, 8.00, or 9.00) for 2 h, resulted in the formation of a complex mixture of aroma volatiles. The volatile compounds generated were analysed by SPME–GC–MS. The results gave 43 aroma compounds. The reaction between l-ascorbic acid and l-cysteine led mainly to the formation of alicyclic sulphur compounds, thiophenes, thienothiophenes, thiophenones, thiazoles and pyrazines, most of which contain sulphur. Many of these volatiles had meaty flavour. The origin of many of the compounds was explained. The studies showed that thienothiophenes and thienones were formed mainly at acidic pH. In contrast, higher pH values could promote the production of thiophenes, thiazoles and pyrazines.