Evaluation of the effects of ultraviolet light on bacterial contaminants inoculated into whole milk and colostrum,and on colostrum immunoglobulin G

Raw milk and colostrum can harbor dangerous microorganisms that can pose serious health risks for animals and humans. According to the USDA, more than 58% of calves in the United States are fed unpasteurized milk. The aim of this study was to evaluate the effect of UV light on reduction of bacteria in milk and colostrum, and on colostrum IgG. A pilot-scale UV light continuous (UVC) flow-through unit (45 J/cm²) was used to treat milk and colostrum. Colostrum and sterile whole milk were inoculated with Listeria innocua, Mycobacterium smegmatis, Salmonella serovar Typhimurium, Escherichia coli, Staphylococcus aureus, Streptococcus agalactiae, and Acinetobacter baumannii before being treated with UVC. During UVC treatment, samples were collected at 5 time points and bacteria were enumerated using selective media. The effect of UVC on IgG was evaluated using raw colostrum from a nearby dairy farm without the addition of bacteria. For each colostrum batch, samples were collected at several different time points and IgG was measured using ELISA. The UVC treatment of milk resulted in a significant final count (log cfu/mL) reduction of Listeria monocytogenes (3.2 ± 0.3 log cfu/mL reduction), Salmonella spp. (3.7 ± 0.2 log cfu/mL reduction), Escherichia coli (2.8 ± 0.2 log cfu/mL reduction), Staph. aureus (3.4 ± 0.3 log cfu/mL reduction), Streptococcus spp. (3.4 ± 0.4 log cfu/mL reduction), and A. baumannii (2.8 ± 0.2 log cfu/mL reduction). The UVC treatment of milk did not result in a significant final count (log cfu/mL) reduction for M. smegmatis (1.8 ± 0.5 log cfu/mL reduction). The UVC treatment of colostrum was significantly associated with a final reduction of bacterial count (log cfu/mL) of Listeria spp. (1.4 ± 0.3 log cfu/mL reduction), Salmonella spp. (1.0 ± 0.2 log cfu/mL reduction), and Acinetobacter spp. (1.1 ± 0.3 log cfu/mL reduction), but not of E. coli (0.5 ± 0.3 log cfu/mL reduction), Strep. agalactiae (0.8 ± 0.2 log cfu/mL reduction), and Staph. aureus (0.4 ± 0.2 log cfu/mL reduction). The UVC treatment of colostrum significantly decreased the IgG concentration, with an observed final mean IgG reduction of approximately 50%. Development of new methods to reduce bacterial contaminants in colostrum must take into consideration the barriers imposed by its opacity and organic components, and account for the incidental damage to IgG caused by manipulating colostrum.     

Bactericidal activity of lauric arginate in milk and Queso Fresco cheese against Listeria monocytogenes cold growth

Lauric arginate (LAE) at concentrations of 200 ppm and 800 ppm was evaluated for its effectiveness in reducing cold growth of Listeria monocytogenes in whole milk, skim milk, and Queso Fresco cheese (QFC) at 4°C for 15 to 28 d. Use of 200 ppm of LAE reduced 4 log cfu/mL of L. monocytogenes to a nondetectable level within 30 min at 4°C in tryptic soy broth. In contrast, when 4 log cfu/mL of L. monocytogenes was inoculated in whole milk or skim milk, the reduction of L. monocytogenes was approximately 1 log cfu/mL after 24 h with 200 ppm of LAE. When 800 ppm of LAE was added to whole or skim milk, the initial 4 log cfu/mL of L. monocytogenes was nondetectable following 24 h, and no growth of L. monocytogenes was observed for 15 d at 4°C. With surface treatment of 200 or 800 ppm of LAE on vacuum-packaged QFC, the reductions of L. monocytogenes within 24 h at 4°C were 1.2 and 3.0 log cfu/g, respectively. In addition, the overall growth of L. monocytogenes in QFC was decreased by 0.3 to 2.6 and by 2.3 to 5.0 log cfu/g with 200 and 800 ppm of LAE, respectively, compared with untreated controls over 28 d at 4°C. Sensory tests revealed that consumers could not determine a difference between QFC samples that were treated with 0 and 200 ppm of LAE, the FDA-approved level of LAE use in foods. In addition, no differences existed between treatments with respect to flavor, texture, and overall acceptability of the QFC. Lauric arginate shows promise for potential use in QFC because it exerts initial bactericidal activity against L. monocytogenes at 4°C without affecting sensory quality.     

Antimicrobial activity of acid-hydrolyzed Citrus unshiu peel extract in milk

Citrus fruit (Citrus unshiu) peels were extracted with hot water and then acid-hydrolyzed using hydrochloric acid. Antimicrobial activities of acid-hydrolyzed Citrus unshiu peel extract were evaluated against pathogenic bacteria, including Bacillus cereus, Staphylococcus aureus, and Listeria monocytogenes. Antilisterial effect was also determined by adding extracts at 1, 2, and 4% to whole, low-fat, and skim milk. The cell numbers of B. cereus, Staph. aureus, and L. monocytogenes cultures treated with acid-hydrolyzed extract for 12 h at 35°C were reduced from about 8 log cfu/mL to <1 log cfu/mL. Bacillus cereus was more sensitive to acid-hydrolyzed Citrus unshiu peel extract than were the other bacteria. The addition of 4% acid-hydrolyzed Citrus unshiu extracts to all types of milk inhibited the growth of L. monocytogenes within 1 d of storage at 4°C. The results indicated that Citrus unshiu peel extracts, after acid hydrolysis, effectively inhibited the growth of pathogenic bacteria. These findings indicate that acid hydrolysis of Citrus unshiu peel facilitates its use as a natural antimicrobial agent for food products.     

Fate of Staphylococcus aureus in cheese treated by ultrahigh pressure homogenization and high hydrostatic pressure

We evaluated the influence of ultrahigh pressure homogenization (UHPH) treatment applied to milk containing Staphylococcus aureus CECT 976 before cheese making, and the benefit of applying a further high hydrostatic pressure (HHP) treatment to cheese. The evolution of Staph. aureus counts during 30 d of storage at 8°C and the formation of staphylococcal enterotoxins were also assessed. Milk containing approximately 7.3 log₁₀ cfu/mL of Staph. aureus was pressurized using a 2-valve UHPH machine, applying 330 and 30 MPa at the primary and the secondary homogenizing valves, respectively. Milk inlet temperatures (T_in) of 6 and 20°C were assayed. Milk was used to elaborate soft-curd cheeses (UHPH cheese), some of which were additionally submitted to 10-min HHP treatments of 400 MPa at 20°C (UHPH+HHP cheese). Counts of Staph. aureus were measured on d 1 (24 h after manufacture or immediately after HHP treatment) and after 2, 15, and 30 d of ripening at 8°C. Counts of control cheeses not pressure-treated were approximately 8.5 log₁₀ cfu/g showing no significant decreases during storage. In cheeses made from UHPH treated milk at T_in of 6°C, counts of Staph. aureus were 5.0 ± 0.3 log₁₀ cfu/g at d 1; they decreased significantly to 2.8 ± 0.2 log₁₀ cfu/g on d 15, and were below the detection limit (1 log₁₀ cfu/g) after 30 d of storage. The use of an additional HHP treatment had a synergistic effect, increasing reductions up to 7.0 ± 0.3 log₁₀ cfu/g from d 1. However, for both UHPH and UHPH+HHP cheeses in the 6°C T_in samples, viable Staph. aureus cells were still recovered. For samples of the 20°C T_in group, complete inactivation of Staph. aureus was reached after 15 d of storage for both UHPH and UHPH+HHP cheese. Staphylococcal enterotoxins were found in controls but not in UHPH or UHPH+HHP treated samples. This study shows a new approach for significantly improving cheese safety by means of using UHPH or its combination with HHP.     

Fat content increases the lethality of ultra-high-pressure homogenization on Listeria monocytogenes in milk

Listeria monocytogenes CCUG 15526 was inoculated at a concentration of approximately 7.0 log₁₀ cfu/mL in milk samples with 0.3, 3.6, 10, and 15% fat contents. Milk samples with 0.3 and 3.6% fat content were also inoculated with a lower load of approximately 3.0 log₁₀ cfu/mL. Inoculated milk samples were subjected to a single cycle of ultra-high-pressure homogenization (UHPH) treatment at 200, 300, and 400 MPa. Microbiological analyses were performed 2 h after the UHPH treatments and after 5, 8, and 15 d of storage at 4°C. Maximum lethality values were observed in samples treated at 400 MPa with 15 and 10% fat (7.95 and 7.46 log₁₀ cfu/mL), respectively. However, in skimmed and 3.6% fat milk samples, complete inactivation was not achieved and, during the subsequent 15 d of storage at 4°C, L. monocytogenes was able to recover and replicate until achieving initial counts. In milk samples with 10 and 15% fat, L. monocytogenes recovered to the level of initial counts only in the milk samples treated at 200 MPa but not in the milk samples treated at 300 and 400 MPa. When the load of L. monocytogenes was approximately 3.0 log₁₀ cfu/mL in milk samples with 0.3 and 3.6% fat, complete inactivation was not achieved and L. monocytogenes was able to recover and grow during the subsequent cold storage. Fat content increased the maximum temperature reached during UHPH treatment; this could have contributed to the lethal effect achieved, but the amount of fat of the milk had a stronger effect than the temperature on obtaining a higher death rate of L. monocytogenes.     

Lactose oxidase: An enzymatic approach to inhibit Listeria monocytogenes in milk

Listeria monocytogenes is a ubiquitous pathogen that can cause morbidity and mortality in immunocompromised individuals. Growth of L. monocytogenes is possible at refrigeration temperatures due to its psychrotrophic nature. The use of antimicrobials in dairy products is a potential way to control L. monocytogenes growth in processes with no thermal kill step, thereby enhancing the safety of such products. Microbial-based enzymes offer a clean-label approach for control of L. monocytogenes outgrowth. Lactose oxidase (LO) is a microbial-derived enzyme with antimicrobial properties. It oxidizes lactose into lactobionic acid and reduces oxygen, generating H₂O₂. This study investigated the effects of LO in UHT skim milk using different L. monocytogenes contamination scenarios. These LO treatments were then applied to raw milk with various modifications; higher levels of LO as well as supplementation with thiocyanate were added to activate the lactoperoxidase system, a natural antimicrobial system present in milk. In UHT skim milk, concentrations of 0.0060, 0.012, and 0.12 g/L LO each reduced L. monocytogenes counts to below the limit of detection between 14 and 21 d of refrigerated storage, dependent on the concentration of LO. In the 48-h trials in UHT skim milk, LO treatments were effective in a concentration-dependent fashion. The highest concentration of LO in the 21-d trials, 0.12 g/L, did not show great inhibition over 48 h, so concentrations were increased for these experiments. In the lower inoculum, after 48 h, a 12 g/L LO treatment reached levels of 1.7 log cfu/mL, a reduction of 1.3 log cfu/mL from the initial inoculum, whereas the control grew out to approximately 4 log cfu/mL, an increase of 1 log cfu/mL from the inoculum on d 0. When a higher challenge inoculum of 5 log cfu/mL was used, the 0.12 g/L and 1.2 g/L treatments reduced the levels by 0.2 to 0.3 log cfu/mL below the initial inoculum and the 12 g/L treatment by >1 log cfu/mL below the initial inoculum by hour 48 of storage at refrigeration temperatures. After the efficacy of LO was determined in UHT skim milk, LO treatments were applied to raw milk. Concentrations of LO were increased, and the addition of thiocyanate was investigated to supplement the effect of the lactoperoxidase system against L. monocytogenes. When raw milk was inoculated with 2 log cfu/mL, 1.2 g/L LO alone and combined with sodium thiocyanate reduced ~0.8 log cfu/mL from the initial inoculum on d 7 of storage, whereas the control grew out to >1 log cfu/mL from the initial inoculum. Furthermore, in the higher inoculum, 1.2 g/L LO combined with sodium thiocyanate reduced L. monocytogenes counts from the initial inoculum by >1 log cfu/mL, whereas the control grew out 2 log cfu/mL from the initial inoculum. Results from this study suggest that LO is inhibitory against L. monocytogenes in UHT skim milk and in raw milk. Therefore, LO may be an effective treatment to prevent L. monocytogenes outgrowth, increase the safety of raw milk, and be used as an effective agent to prevent L. monocytogenes proliferation in fresh cheese and other dairy products. This enzymatic approach is a novel application to control the foodborne pathogen L. monocytogenes in dairy products.     

Detection and enumeration of Staphylococcus aureus from bovine milk samples by real-time polymerase chain reaction

The aim of this study was to develop and evaluate a real-time quantitative PCR (qPCR)-based method to detect and quantify Staphylococcus aureus in bronopol-preserved milk samples from subclinical intramammary infections (IMI). Serial dilutions of milk artificially inoculated with Staph. aureus ATCC 29213 were used to establish a standard curve (cfu/mL) of the qPCR assay targeting the Staph. aureus thermonuclease-encoding gene nuc according to the strain plate count. The analytical sensitivity, specificity, and repeatability of the qPCR assay were determined. A total of 60 milk samples, collected from mammary quarters without abnormal appearance and with positive isolation of Staph. aureus, were submitted to both the qPCR protocol and Staph. aureus plate counting and results from both methods were compared. Staphylococcus aureus from bronopol-preserved, subclinical IMI milk samples were not accurately enumerated by qPCR compared with plate counting of the nonpreserved, raw milk sample. The detection limit of the qPCR protocol of inoculated Staph. aureus ATCC 29213 in bronopol-preserved milk samples was 1.04 × 10¹ cfu/mL. The qPCR protocol can be a high-throughput and rapid diagnostic assay to accurately detect Staph. aureus IMI from bronopol-preserved milk samples compared with a traditional culturing method. However, the proposed qPCR protocol is not accurate for counting of Staph. aureus in bronopol-preserved milk samples from naturally infected mammary glands.     

Effect of heat and high-pressure treatments on microbiological quality and immunoglobulin G stability of caprine colostrum

Caprine colostrums (6 batches) were subjected to heat (56°C for 60 min and 63°C for 30 min) and high-pressure (400 and 500 MPa for 10 min at 20°C) treatments at laboratory scale, and analyses of the main microbial groups and the extent of IgG denaturation (determined by immunodiffusion) were performed. Overall mean microbial values in raw colostrums were: total count, 5.55 log cfu/mL; Enterobacteriaceae, 2.64 log cfu/mL; lactococci, 5.41 log cfu/mL; lactobacilli, 2.34 log cfu/mL; and enterococci, 4.06 log cfu/mL. Neither Salmonella spp. nor Listeria monocytogenes were detected, whereas coagulase-positive staphylococci were found in various colostrum samples with an overall mean of 1.02 log cfu/mL. Heat and high-pressure treatments significantly reduced total count (1.47 log), lactococci (1.45 log), enterococci (2.47 log), and Enterobacteriaceae, whereas lactobacilli and coagulase-positive staphylococci counts were reduced to undetectable levels, but differences between technological treatments were not statistically significant. High-pressure treatments were as efficient in reducing the bacterial population as were heat pasteurization treatments: 95.50 and 96.93% for pressure treatments of 400 and 500 MPa, and 91.61 and 97.59% for heat treatments of 56°C for 60 min and 63°C for 30 min, respectively. All treatments assayed produced a reduction in colostrum IgG concentration (27.53, 23.58, 23.33, 22.09, and 17.06 mg/mL for raw, heat-treated at 56°C for 60 min or 63°C for 30 min, and pressure-treated at 400 and 500 MPa, respectively), but differences were only observed between raw colostrums and those pressure-treated at 500 MPa. This laboratory-scale study indicated that 20- to 30-mL volumes of goat colostrum could be heated and pressure-treated (400 MPa) to produce hygienic colostrum without affecting IgG concentration.     

Microbiological quality of raw milk used for small-scale artisan cheese production in Vermont: Effect of farm characteristics and practices

This study 1) evaluated the overall milk quality and prevalence of 4 target pathogens (Listeria monocytogenes, Staphylococcus aureus, Salmonella spp., and Escherichia coli O157:H7) in raw milk used for small-scale artisan cheesemaking and 2) examined specific farm characteristics and practices and their effect on bacterial and somatic cell counts (SCC). Raw milk samples were collected weekly from 21 artisan cheese operations (6 organic) in the state of Vermont that manufactured raw-milk cheese from cow (12), goat (5), or sheep (4) milk during the summer of 2008. Individual samples were examined for standard plate counts (SPC), coliform counts (CC), and SCC. Samples were also screened for target pathogens both quantitatively and qualitatively by direct plating and PCR. Overall, 86% of samples had SPC <10,000 cfu/mL, with 42% <1,000 cfu/mL. Additionally, 68% of samples tested were within pasteurized milk standards for coliform bacteria under the United States’ Grade A Pasteurized Milk Ordinance at <10 cfu/mL. Log₁₀ SPC and CC did not differ significantly among species. Similarly, method of sample delivery (shipped or picked up), farm type (organic or conventional), and duration of milking (year-round or seasonal) did not have significant effects on farm aggregated mean log₁₀ SPC, CC, or SCC. Strong positive correlations were observed between herd size and mean log₁₀ SPC and between log₁₀ SPC and CC as well as SCC when data from all animal species were combined. Although SCC for cow milk were significantly lower than those for goat and sheep milk, 98, 71, and 92% of cow, sheep, and goat milk samples, respectively, were within the compliance limits of the United States’ Grade A Pasteurized Milk Ordinance for SCC. Fourteen of the 21 farms (67%) were positive for Staph. aureus, detected in 38% of samples at an average level of 20 cfu/mL. Neither L. monocytogenes, E. coli O157:H7, or Salmonella spp. were detected or recovered from any of the 101 samples tested. Our results indicate that the majority of raw milk produced for small-scale artisan cheesemaking was of high microbiological quality with no detectable target pathogens despite the repeat sampling of farms. These data will help to inform risk assessments that evaluate the microbiological safety of artisan and farmstead cheeses, particularly those manufactured from raw milk.     

Short communication: Changes in micromineral, magnesium, cytokine, and cortisol concentrations in blood of dairy goats following intramammary inoculation with Staphylococcus aureus

The aim of this study was to investigate mineral metabolism and immune response in dairy goats following intramammary inoculation with varying doses of Staphylococcus aureus. Blood samples were collected at 0, 2, 4, 8, 12, 24, 48, and 72 h after intramammary inoculation. Lowered plasma Fe concentrations were observed from 12 to 24 h postinoculation in groups SAA (Staph. aureus at 10⁴ cfu, n = 5) and SAB (Staph. aureus at 10⁸ cfu, n = 5). Plasma Cu concentrations increased in group SAB 2 h after inoculation and maintained greater concentrations until the end of the experiment compared with the control group (phosphate-buffered saline, n = 5). Increased plasma Zn concentrations in group SAB were observed 48 h after inoculation, and the concentration was still greater 72 h after inoculation compared with the control group. Greater plasma Mg concentrations were detected in groups SAA and SAB compared with the control group at all timepoints after inoculation. Plasma Mg concentrations were generally greater in group SAA than in group SAB through 72 h (except at 2 h). Plasma tumor necrosis factor-alpha concentrations were unchanged following intramammary inoculation with Staph. aureus throughout the study. Plasma IL-6 concentrations in groups SAA and SAB increased gradually compared with the control group and peaked at 48 h after inoculation. In group SAB, serum cortisol concentrations started to increase from 8 h postinoculation and peaked at 12 h postinoculation. In conclusion, increasing the inoculum dose does not induce more rapid proinflammatory cytokine responses, whereas the data indicate that mineral metabolic alterations occur during the course of Staph. aureus mastitis in the goat.     

Risk factors associated with selected indicators of milk quality in semiarid northeastern Brazil

The aim of this study was to gain information on quality traits, mainly bacterial and somatic cell counts of bulk milk, produced by small- and medium-scale producers in a semiarid northeastern region of Brazil and to identify and characterize possible risk factors associated with those quality traits. A cross-sectional study was performed on 50 farms. Bulk milk samples were collected for bacterial and somatic cell counts. Additionally, information about farm demographics, general management practices, hygiene, and milking procedures was also obtained. Multivariable analysis using logistic regression was performed with predictors previously identified by univariate analysis using a Fisher's Exact test. Aerobic mesophilic bacteria counts varied from 3.59 log to 6.95 log cfu/mL, with geometric mean of 5.27 log cfu/mL. Mean total coliform count was 3.27 log (1.52 log to 5.89 log) most probable number (MPN)/mL, whereas mean thermotolerant coliforms was 2.38 log (1.48 log to 4.75 log) MPN/mL. A high positive correlation was observed between aerobic mesophilic bacteria and coliform counts. Although most farms met the standard for the current regulations for total bacteria (88%) and somatic cell counts (94%), nearly half of the producers (46%) would have problems in achieving the 2012 threshold limit for total bacteria count if no improvement in milk quality occurs. Mean value for staphylococci was 3.99 log (2.31 log to 6.24 log) cfu/mL, and Staphylococcus aureus was detected in 33 (66%) farms. Premilking teat-end wash procedure (odds ratio = 0.191) and postmilking teat dip (odds ratio = 0.67) were associated with lower aerobic mesophilic bacteria and Staphylococcus aureus counts in bulk milk, respectively. Considering that the farm characteristics in this study are representative of the semiarid northeastern region, these findings encourage further investigations for supporting intervention measures intended to improve the quality of milk produced by smallholders.     

Characterization of cottage cheese using Weissella cibaria D30: Physicochemical,antioxidant, and antilisterial properties

This study aimed to evaluate the potential of Weissella cibaria D30 as an adjunct culture in cottage cheese, including an assessment of antioxidant, antilisterial, and compositional parameters. Cottage cheese samples were manufactured using a commercial starter culture and probiotic strains Lactobacillus rhamnosus GG (GG) or W. cibaria D30 (W) and without probiotic (control). Samples were stored at 4 ± 1°C for 28 d. Bacterial cell counts (log cfu/g) of control, GG, and W samples were counted at 0, 7, 14, 21, and 28 d. Counts of W. cibaria D30 in the W samples remained at 6.85 log cfu/g after 28 d. Total solids, fat, protein, ash, and pH were measured and no significant differences were observed in compositional parameters or pH after 28 d of storage in all cheeses except those inoculated to Listeria monocytogenes. To measure the antilisterial effect, Listeria monocytogenes was inoculated into the cottage cheese samples and bacterial cell counts were obtained at 0, 6, 12, 24, 48, 72, 96, 120, and 144 h. Listeria monocytogenes counts were less than the analytical limit of detection (<10 cfu/g) in the inoculated GG and W samples, whereas the counts of L. monocytogenes in the inoculated control sample remained at 3.0 log cfu/g after 144 h. We used the DPPH (2,2-diphenyl-1-picrylhydrazyl) and ABTS [2,2′-azino-bis(3-ethylbenzothiazoline-6-sulfonic acid)] radical scavenging activity assays to assess antioxidant activity: GG and W samples exhibited significant increases in antioxidant activity compared with the control sample. These results indicate that W. cibaria D30 has potential as an adjunct culture in the dairy industry.     

Risk factors associated with bulk tank standard plate count,bulk tank coliform count,and the presence of Staphylococcus aureus on organic and conventional dairy farms in the United States

The purpose of this study was to assess the association of bulk tank milk standard plate counts, bulk tank coliform counts (CC), and the presence of Staphylococcus aureus in bulk tank milk with various management and farm characteristics on organic and conventional dairy farms throughout New York, Wisconsin, and Oregon. Data from size-matched organic farms (n = 192), conventional nongrazing farms (n = 64), and conventional grazing farms (n = 36) were collected at a single visit for each farm. Of the 292 farms visited, 290 bulk tank milk samples were collected. Statistical models were created using data from all herds in the study, as well as exclusively for the organic subset of herds. Because of incomplete data, 267 of 290 herds were analyzed for total herd modeling, and 173 of 190 organic herds were analyzed for the organic herd modeling. Overall, more bulk tanks from organic farms had Staph. aureus cultured from them (62% of organic herds, 42% conventional nongrazing herds, and 43% of conventional grazing herds), whereas fewer organic herds had a high CC, defined as ≥50 cfu/mL, than conventional farms in the study. A high standard plate count (×1,000 cfu/mL) was associated with decreased body condition score of adult cows and decreased milk production in both models. Several variables were significant only in the model created using all herds or only in organic herds. The presence of Staph. aureus in the bulk tank milk was associated with fewer people treating mastitis, increased age of housing, and a higher percentage of cows with 3 or fewer teats in both the organic and total herd models. The Staph. aureus total herd model also showed a relationship with fewer first-lactation animals, higher hock scores, and less use of automatic takeoffs at milking. High bulk tank CC was related to feeding a total mixed ration and using natural service in nonlactating heifers in both models. Overall, attentive management and use of outside resources were useful with regard to CC on organic farms. In all models except the organic CC model, we observed an association with the average reported somatic cell count from 3 mo before the herd visit, indicating that many of the regularly tested milk quality parameters are interconnected. In conclusion, we found that conventional and organic farms are similar in regard to overall herd management, but each grazing system faces unique challenges when managing milk quality.     

Nonstarter lactic acid bacteria biofilms and calcium lactate crystals in Cheddar cheese

A sanitized cheese plant was swabbed for the presence of nonstarter lactic acid bacteria (NSLAB) biofilms. Swabs were analyzed to determine the sources and microorganisms responsible for contamination. In pilot plant experiments, cheese vats filled with standard cheese milk (lactose:protein = 1.47) and ultrafiltered cheese milk (lactose:protein = 1.23) were inoculated with Lactococcus lactis ssp. cremoris starter culture (8 log cfu/mL) with or without Lactobacillus curvatus or Pediococci acidilactici as adjunct cultures (2 log cfu/mL). Cheddar cheeses were aged at 7.2 or 10°C for 168 d. The raw milk silo, ultrafiltration unit, cheddaring belt, and cheese tower had NSLAB biofilms ranging from 2 to 4 log cfu/100 cm². The population of Lb. curvatus reached 8 log cfu/g, whereas P. acidilactici reached 7 log cfu/g of experimental Cheddar cheese in 14 d. Higher NSLAB counts were observed in the first 14 d of aging in cheese stored at 10°C compared with that stored at 7.2°C. However, microbial counts decreased more quickly in Cheddar cheeses aged at 10°C compared with 7.2°C after 28 d. In cheeses without specific adjunct cultures (Lb. curvatus or P. acidilactici), calcium lactate crystals were not observed within 168 d. However, crystals were observed after only 56 d in cheeses containing Lb. curvatus, which also had increased concentration of d(−)-lactic acid compared with control cheeses. Our research shows that low levels of contamination with certain NSLAB can result in calcium lactate crystals, regardless of lactose:protein ratio.     

Real-time polymerase chain reaction for the quantitative detection of tetA and tetB bacterial tetracycline resistance genes in food

A new, rapid, sensitive and specific method was developed to directly detect and quantify tetA and tetB in food. Both tet genes are two of the most frequently present tetracycline resistance genes in Gram-negative bacteria. A set of primers and Taqman probes was designed for each gene. The standard curves were performed using Escherichia coli BM13 (C600 RifR)/RP4 and E. coli NCTC 50365, which carry tetA and tetB, respectively. Meat and fish samples inoculated with these reference strains were used as a matrix to construct the standard curves for the analysis of 20 samples of chicken meat and 10 samples of hake (Merlucius merlucius). The limits of detection in pure culture were 5 cfu/mL (0.7 log cfu/mL) in the case of tetA, 50 cfu/mL (1.7 log cfu/mL) for tetB and 5 × 10² cfu/g (2.7 log cfu/g) for both genes in food samples. The results obtained by real-time quantitative polymerase chain reaction (qPCR) were compared to counts of tetracycline-resistant bacteria obtained by plating extracts of poultry and hake samples in culture media supplemented with 16 mg/L of tetracycline. Counts of tetracycline-resistant bacteria obtained by qPCR showed a positive correlation, especially interesting when compared with microbiological counts of tetracycline-resistant Enterobacteriaceae in poultry meat (r = 0.5509) and with tetracycline-resistant mesophilic aerobic bacteria in hake samples (r = 0.7146). The obtained results demonstrate that this method could be a useful tool for the direct quantification of the amount of bacterial strains that carry tetA and/or tetB genes in food samples.     

The effect of sodium reduction with and without potassium chloride on the survival of Listeria monocytogenes in Cheddar cheese

Sodium chloride (NaCl) in cheese contributes to flavor and texture directly and by its effect on microbial and enzymatic activity. The salt-to-moisture ratio (S/M) is used to gauge if conditions for producing good-quality cheese have been met. Reductions in salt that deviate from the ideal S/M range could result in changing culture acidification profiles during cheese making. Lactococcus lactis ssp. lactis or Lc. lactis ssp. cremoris are both used as cultures in Cheddar cheese manufacture, but Lc. lactis ssp. lactis has a higher salt and pH tolerance than Lc. lactis ssp. cremoris. Both salt and pH are used to control growth and survival of Listeria monocytogenes and salts such as KCl are commonly used to replace the effects of NaCl in food when NaCl is reduced. The objectives of this project were to determine the effects of sodium reduction, KCl use, and the subspecies of Lc. lactis used on L. monocytogenes survival in stirred-curd Cheddar cheese. Cheese was manufactured with either Lc. lactis ssp. lactis or Lc. lactis ssp. cremoris. At the salting step, curd was divided and salted with a concentration targeted to produce a final cheese with 600 mg of sodium/100 g (control), 25% reduced sodium (450 mg of sodium/100 g; both with and without KCl), and low sodium (53% sodium reduction or 280 mg of sodium/100 g; both with and without KCl). Potassium chloride was added on a molar equivalent to the NaCl it replaced to maintain an equivalent S/M. Cheese was inoculated with a 5-strain cocktail of L. monocytogenes at different times during aging to simulate postprocessing contamination, and counts were monitored over 27 or 50 d, depending on incubation temperature (12 or 5°C, respectively). In cheese inoculated with 4 log₁₀ cfu of L. monocytogenes/g 2 wk after manufacture, viable counts declined by more than 3 log₁₀ cfu/g in all treatments over 60 d. When inoculated with 5 log₁₀ cfu/g at 3 mo of cheese age, L. monocytogenes counts in Cheddar cheese were also reduced during storage, but by less than 1.5 log₁₀ cfu/g after 50 d. However, cheese with a 50% reduction in sodium without KCl had higher counts than full-sodium cheese at the end of 50 d of incubation at 4°C when inoculated at 3 mo. When inoculated at 8 mo postmanufacture, this trend was only observed in 50% reduced sodium with KCl, for cheese manufactured with both cultures. This enhanced survival for 50% reduced-sodium cheese was not seen when a higher incubation temperature (12°C) was used when cheese was inoculated at 3 mo of age and monitored for 27 d (no difference in treatments was observed at this incubation temperature). In the event of postprocessing contamination during later stages of ripening, L. monocytogenes was capable of survival in Cheddar cheese regardless of which culture was used, whether or not sodium had been reduced by as much as 50% from standard concentrations, or if KCl had been added to maintain the effective S/M of full-sodium Cheddar cheese.     

Effect of high-pressure processing on reduction of Listeria monocytogenes in packaged Queso Fresco

The effect of high-hydrostatic-pressure processing (HPP) on the survival of a 5-strain rifampicin-resistant cocktail of Listeria monocytogenes in Queso Fresco (QF) was evaluated as a postpackaging intervention. Queso Fresco was made using pasteurized, homogenized milk, and was starter-free and not pressed. In phase 1, QF slices (12.7 × 7.6 × 1 cm), weighing from 52 to 66 g, were surface inoculated with L. monocytogenes (ca. 5.0 log₁₀ cfu/g) and individually double vacuum packaged. The slices were then warmed to either 20 or 40°C and HPP treated at 200, 400, and 600 MPa for hold times of 5, 10, 15, or 20 min. Treatment at 600 MPa was most effective in reducing L. monocytogenes to below the detection level of 0.91 log₁₀ cfu/g at all hold times and temperatures. High-hydrostatic-pressure processing at 40°C, 400 MPa, and hold time ≥15 min was effective but resulted in wheying-off and textural changes. In phase 2, L. monocytogenes was inoculated either on the slices (ca. 5.0 log₁₀ cfu/g; ON) or in the curds (ca. 7.0 log₁₀ cfu/g; IN) before the cheese block was formed and sliced. The slices were treated at 20°C and 600 MPa at hold times of 3, 10, and 20 min, and then stored at 4 and 10°C for 60 d. For both treatments, L. monocytogenes became less resistant to pressure as hold time increased, with greater percentages of injured cells at 3 and 10 min than at 20 min, at which the lethality of the process increased. For the IN treatment, with hold times of 3 and 10 min, growth of L. monocytogenes increased the first week of storage, but was delayed for 1 wk, with a hold time of 20 min. Longer lag times in growth of L. monocytogenes during storage at 4°C were observed for the ON treatment at hold times of 10 and 20 min, indicating that the IN treatment may have provided a more protective environment with less injury to the cells than the ON treatment. Similarly, HPP treatment for 10 min followed by storage at 4°C was the best method for suppressing the growth of the endogenous microflora with bacterial counts remaining below the level of detection for 2 out of the 3 QF samples for up to 84 d. Lag times in growth were not observed during storage of QF at 10°C. Although HPP reduced L. monocytogenes immediately after processing, a second preservation technique is necessary to control growth of L. monocytogenes during cold storage. However, the results also showed that HPP would be effective for slowing the growth of microorganisms that can shorten the shelf life of QF.     

Control of Listeria monocytogenes in whole milk using antimicrobials applied individually and in combination

Dairy product recalls and dairy-related illnesses are often the result of contamination with Listeria monocytogenes, which can occur throughout the dairy production and supply chains. The use of antimicrobial compounds is one practical approach for controlling pathogen survival and growth in foods. The goal of this study was to use fluid milk as a model system to identify listeristatic or listericidal treatments that show promise for application in fluid milk and for further evaluation in other dairy products (e.g., cheese). Caprylic acid (CA), ε-polylysine (EPL), hydrogen peroxide, lauric arginate (LAE), and sodium caprylate (SC) were added individually or in combination to whole milk inoculated with L. monocytogenes at ?4 log₁₀ cfu/mL. Samples were stored at 7°C for 21 d, and L. monocytogenes counts were determined weekly. Inhibitory concentrations of LAE (800 mg/L) and EPL (100–400 mg/L), as well as SC and CA (3,200 mg/L each), were identified. The addition of EPL at 800 mg/L reduced L. monocytogenes counts by >3 log₁₀ cfu/mL from initial inoculation levels after 21 d. Addition of hydrogen peroxide to milk reduced counts by >3 log₁₀ cfu/mL from initial inoculation within 24 h (400 and 800 mg/L) or by d 7 (200 mg/L). Although the combinatory treatments of EPL + CA, EPL + LAE, and LAE + SC were characterized as indifferent, EPL + SC worked synergistically to reduce L. monocytogenes populations in milk over 21 d. Overall, these data identify potential antimicrobial treatments to control L. monocytogenes in milk and serve as a foundation for the continued development of antimicrobial controls for L. monocytogenes in dairy products.     

Clinical outcomes and molecular genotyping of Staphylococcus aureus isolated from milk samples of dairy primiparous Mediterranean buffaloes (Bubalus bubalis)

Staphylococcus aureus is one of the most important pathogens causing mastitis in dairy cows and in Mediterranean buffaloes. Genotype B (GTB) is contagious in dairy cows and may occur in up to 87% of cows of a dairy herd. It was the aim of this study to evaluate genotypes present, clinical outcomes, and prevalence of Staph. aureus in milk samples of primiparous Mediterranean dairy buffaloes. Two hundred composite milk samples originating from 40 primiparous buffaloes were collected from May to June 2012, at d 10, 30, 60, 90, and 150 d in milk (DIM) to perform somatic cell counts and bacteriological cultures. Daily milk yields were recorded. Before parturition until 40 to 50 DIM, all primiparous animals were housed separated from the pluriparous animals. Milking was performed in the same milking parlor, but the primiparous animals were milked first. After 50 DIM, the primiparous were mixed with the pluriparous animals, including the milking procedure. Individual quarter samples were collected from each animal, and aliquots of 1 mL were mixed and used for molecular identification and genotyping of Staph. aureus. The identification of Staph. aureus was performed verifying the presence of nuc gene by nuc gene PCR. All the nuc-positive isolates were subjected to genotype analysis by means of PCR amplification of the 16S-23S rRNA intergenic spacer region and analyzed by a miniaturized electrophoresis system. Of all 200 composite samples, 41 (20.5%) were positive for Staph. aureus, and no genotype other than GTB was identified. The prevalence of samples positive for Staph. aureus was 0% at 10 DIM and increased to a maximum of 22/40 (55%) at 90 DIM. During the period of interest, 14 buffaloes tested positive for Staph. aureus once, 6 were positive twice, and 5 were positive 3 times, whereas 15 animals were negative at every sampling. At 90 and 150 DIM, 7 (17.5%) and 3 buffaloes (7.5%), respectively, showed clinical mastitis (CM), and only 1 (2.5%) showed CM at both samplings. At 60, 90, and 150 DIM, 1 buffalo was found with subclinical mastitis at each sampling. At 30, 60, 90, and 150 DIM, 2.5 (1/40), 22.5 (9/40), 35 (14/40), and 10% (4/40) were considered affected by intramammary infection, respectively. Buffaloes with CM caused by Staph. aureus had statistically significantly higher mean somatic cell count values (6.06 ± 0.29, Log₁₀ cells/mL ± standard deviation) and statistically significantly lower mean daily milk yields (7.15 ± 1.49, liters/animal per day) than healthy animals (4.69 ± 0.23 and 13.87 ± 2.64, respectively), buffaloes with IMI (4.82 ± 0.23 and 11.16 ± 1.80, respectively), or with subclinical mastitis (5.47 ± 0.10 and 10.33 ± 0.68, respectively). Based on our knowledge, this is the first time that Staph. aureus GTB has been identified in milk samples of dairy Mediterranean buffaloes.     

Antibacterial effects of natural tenderizing enzymes on different strains of Escherichia coli O157:H7 and Listeria monocytogenes on beef

This study determined the efficacy of actinidin and papain on reducing Listeria monocytogenes and three mixed strains of Escherichia coli O157:H7 populations on beef. The average reduction of E. coli O157:H7 was greater than that of L. monocytogenes and higher concentrations of either protease yielded greater reduction in bacterial populations. For instance, actinidin at 700 mg/ml significantly (p ≤ 0.05) reduced the population of L. monocytogenes by 1.49 log cfu/ml meat rinse after 3 h at 25 & 35 °C, and by 1.45 log cfu/ml rinse after 24 h at 5 °C, while the same actinidin concentration significantly reduced the populations of three mixed strains of E. coli O157:H7 by 1.81 log cfu/ml rinse after 3 h at 25 & 35 °C, and 1.94 log cfu/ml rinse after 24 h at 5 °C. These findings suggest that, in addition to improving the sensory attributes of beef, proteolytic enzymes can enhance meat safety when stored at suitable temperatures.