Sorption of Acid Dyes onto Silica Modified with Cetyltrimethylammonium Cations

The sorption behavior of acid dyes onto cetyltrimethylammonium bromide (CTAB)- modified silica as a function of pH in the aqueous medium was studied. Single- and multi-solute sorption equilibria of orange Ⅱ(OR), phenol red (PR) and Eriochrome Black T (EBT) were studied at pH 3, unbuffered water pH and pH 11. Sorption behavior of EBT could not be conducted at pH 3 due to its aggregation in acidic medium. All the reaction conditions, experimental protocols and techniques remained the same throughout the sorption process. Sorption isotherms for single-solute system were fitted by the Langmuir model, while Langmuir competitive model (LCM) and the ideal adsorbed solution theory (IAST) coupled with Langmuir model (IAST/Langmuir) were used for the prediction of multisolute competitive sorption. Sorption affinities influenced by the factors like physical interactive forces between the molecules of CTA on silica and sorbate, structural limitations of the dyes based on their geometrical arrangement were investiga     

2-萘磺酸/硫酸在弱碱性树脂上的吸附平衡研究

Experiments for single and bisolute competitive adsorption were carried out to investigate the adsorption behavior of β-naphthalenesulfonic acid(NSA and sulfuric acid from their solution at 25℃ onto weakly basic resin D301R,Adsorption affinity of sulfuric acid on D301R was found to be much higher than that of NSA.The data of single-solute adsorption were fitted to the Langmuir model and the Freundlich adsorption model.The ideal adsorbed solution theory(IAST) coupled with the single-solute adsorption models were used to predict the bisolute competitive adsorption equilibria.The IAST coupled with the Langmuir and the Freundlich model for sulfuric acid and NSA.Respectively,yields the favorable representation of the bisolute competitive adsorption behavior.     

Adsorption of 2-naphthalenesulfonic acid/sulfuric acid/sulfurous acid from aqueous solution by iron-impregnated weakly basic resin:Equilibrium and model

Commercial grade weakly basic resin D301 was impregnated with iron through a simple method using ferric chloride. Experiments for single, bisolute and trinary competitive adsorption were carried out to investigate the adsorption behavior of 2-naphthalenesulfonic acid (NSA), sulfuric acid and sulfurous acid from their solution at 298K onto the novel hybrid iron impregnated D301(Fe-D301). Adsorption affinity of NSA on Fe-D301 was found to be much higher than that of sulfuric acid, while adsorption affinity of sulfuric acid was slightly higher than that of sulfurous acid. The data of single-solute adsorption were fitted to the Langmuir model and the Freundlich adsorption model. The non-ideal competitive adsorbed model coupled with the single-solute adsorp-tion models were used to predict the bisolute and trinary-solute competitive adsorption equilibria. The NICM coupled with the Langmuir model yields the favorable representation of the bisolute and trinary-solute compet-itive adsorption behavior.     

Characterization of recuperating talent of white-rot fungi cells to dye-contaminated soil/water

This study was purposed to explore the decolorization of dyes by fungi on either a soil or in a liquid medium and to determine the application through batch shaking system. Two commercial dyes were decolorized and studied with four fungal strains in three media. Fungal growth is the best in malt extract/glucose medium for all organisms. Decolorization of reactive blue 220 and methyl red was investigated in soil medium by Trametes versicolor. These dyes were removed 91% and 80% for methyl red and reactive blue 220 respectively(dye concentration; 100 mg·L~(-1)) by both organisms. Enzymatic activities were monitored. Laccase(Lac) and manganese peroxidase(Mn P) were detected. MnP enzyme had important role for the dye decolorization. This study demonstrates that it is possible to decolorize some synthetic dyes, which would be highly advanced for dye containing wastewater and soil. These applications could be used for dye bioremediation.     

Sorption and Diffusion Behavior of Carbon Dioxide into Poly（l-lactic acid） Films at Elevated Pressures

Equilibrium sorption amount, desorption diffusion coefficients and sorption diffusion coefficients of CO2 in poly（l-lactic acid） （PLLA） films at elevated pressures were determined by the gravimetric method, in which the Fick＇s diffusion model was applied to analyze both the desorption and sorption processes. The equilibrium sorption amount of CO2 in PLLA increased with lowering temperature and elevating pressure at the temperature range from 40 to 60 ℃ and pressure from 10^4 to 2x10^4 kPa. Desorption diffusion coefficients were greatly influenced by the equilibrium sorption amount, and they were in the same order of magnitude as the sorption diffusion coefficients. The scan electron microscope （SEM） photos demonstrated that there was no foaming phenomenon of the PLLA film during desorption and sorption processes. The XRD spectra implied that the crystalline degree of PLLA film decreased after CO2 processing. It was concluded that PLLA polymer could be well swollen and plasticized by supercritical CO2.     

Dowex50W-X树脂吸附硫酸溶液中的锶

In this study,strontium adsorption from sulfuric acid solution by different Dowex 50W-X ion exchange resins was investigated.Among these resins,Dowex 50W-X8 resin showed the maximum sorption of strontium from the aqueous solutions.The effect of pH,contact time,mass of resin,temperature,and concentration of interfering ions on strontium adsorption were evaluated to determine the optimum conditions of strontium sorption process.The kinetic models of sorption were analyzed using pseudo-first and pseudo-second order models.The results indicated that the pseudo-second order kinetic model was more appropriate than the other one.Moreover,the data obtained in this study were fitted into several sorption isotherm models and it was found that the Langmuir sorption isotherm shows the best fitting to the experimental data.     

Extraordinary adsorption of acidic fuchsine and malachite green onto cheap nano-adsorbent derived from eggshell

Removal of dyestuffs such as Acidic Fuchsine(AF) and Malachite Green(MG) being present in many forms in industries is vital to protect water reservoirs from their catastrophic effects on the ecosystem. This study attempts to effectively eliminate these dyes using a low-cost and eco-friendly material. Eggshell, as a biocompatible by-product,was initially characterized, then some modifications were conducted, and its morphology and chemical structure were then examined through(Atomic force microscopy) AFM,(Fourier-Transform Infrared Spectroscopy) FTIR,(Energy-Dispersive X-ray Spectroscopy) EDS and(Brunauer–Emmett–Teller) BET analyses. They revealed that the modifications on raw material gave rise to a natural nano-adsorbent presenting porous medium appropriate for targeted adsorbate molecules with the average particle size and average pore diameter of 54 and ～2 nm, respectively. Functional groups on the adsorbent surface were also of importance to assist the adsorption of AF and MG.The effect of contact time, adsorbent dose, solution p H and initial concentration was evaluated. Pseudo-second order model accurately correlated the experimental kinetic data for both dyes. Moreover, the participation of intra-particle diffusion along with film diffusion in controlling the process was suggested. Langmuir isotherm model fitted very well to the equilibrium data for both dyes and maximum monolayer adsorption capacity of AF and MG was accordingly calculated to be 5000 and 3333.33 mg·g~(-1) respectively. The inherent characteristics of eggshell make it a potential material to remove contaminants from wastewater in future applications.     

用于VOC回收的PVDMS-Al2O3中空纤维复合膜

Sorption isotherm of chloroform in polyvinyl dimethylsiloxane （PVDMS） polymer film was measured via the gravimetric method, and this film was confirmed experimentally to be good membrane material to recover chloroform from gas stream with high sorption capacity. A new PVDMS-Al2O3 composite hollow fibre membrane was further prepared by coating a PVDMS film on the outer surface of Al2O3 hollow fibre porpous substrate prepared by a dry/wet phase inversion method. Microstructure of the composite membranes was examined by scanning electron microscopy （SEM）, indicating the PVDMS coating layer was uniform, free of defects, and around 15μm thick. Performance of the PVDMS-Al2O3 composite hollow fibre membranes for chloroform recovery was investigated. By comparing the experimental data that derived from a mathematical model, the permeabilities of chloroform and nitrogen in the PVDMS polymer membrane were obtained. The effects of temperature and feed flow rate on the chloroform recovery and permeate concentration were investigated both experimentally and theoretically.     

PVDMS-Al_2O_3 Composite Hollow Fibre Membranes for Chloroform Recovery from Gas Streams

Sorption isotherm of chloroform in polyvinyl dimethylsiloxane(PVDMS)polymer film was measured via the gravimetric method,and this film was confirmed experimentally to be good membrane material to recover chloroform from gas stream with high sorption capacity.A new PVDMS-Al_2O_3 composite hollow fibre membrane was further prepared by coating a PVDMS film on the outer surface of Al_2O_3 hollow fibre porpous substrate prepared by a dry/wet phase inversion method.Microstructure of the composite membranes was examined by scanning electron microscopy(SEM),indicating the PVDMS coating layer was uniform,free of defects,and around 15μm thick.Performance of the PVDMS-Al_2O_3 composite hollow fibre membranes for chloroform recovery was investigated.By comparing the experimental data that derived from a mathematical model,the permeabilities of chloroform and nitrogen in the PVDMS polymer membrane were obtained.The effects of temperature and feed flow rate on the chloroform recovery and permeate concentration were investigated both experimentally and theoretically.     

pH控制在管状流动反应器中的应用(英文)

Tubular flow reactors are mainly used in chemical industry and waste water discharged units. Control of output variables is very difficult because of the existence of high dead-time in these types of reactors. In the present work, sodium hydroxide and acetic acid solutions were sent to the tubular flow reactor. The aim was to control pH at 7 in the nonlinear region. The pH control of a tubular flow reactor with high time delay and a highly nonlinear behavior in pH neutralization reaction was investigated experimentally in the face of the various load and set point changes. Firstly, efficiency of conventional Proportional-Integral-Derivative (PID) algorithm in the experiments was tested. Then self-tuning PID (STPID) control system was applied by using the ARMAX model. The model parameters were calculated from input–output data by using PRBS signal as disturbance and Bierman algorithm. Lastly, the experimental fuzzy control of pH based on fuzzy model was achieved to compare the success of fuzzy approach with the performance of other control cases studied.     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.     

Methyl 2,4,6-decatrienoates Attract Stink Bugs and Tachinid Parasitoids

Halyomorpha halys (Stål) (Pentatomidae), called the brown marmorated stink bug (BMSB), is a newly invasive species in the eastern USA that is rapidly spreading from the original point of establishment in Allentown, PA. In its native range, the BMSB is reportedly attracted to methyl (E,E,Z)-2,4,6-decatrienoate, the male-produced pheromone of another pentatomid common in eastern Asia, Plautia stali Scott. In North America, Thyanta spp. are the only pentatomids known to produce methyl 2,4,6-decatrienoate [the (E,Z,Z)-isomer] as part of their pheromones. Methyl 2,4,6-decatrienoates were field-tested in Maryland to monitor the spread of the BMSB and to explore the possibility that Thyanta spp. are an alternate host for parasitic tachinid flies that use stink bug pheromones as host-finding kairomones. Here we report the first captures of adult and nymph BMSBs in traps baited with methyl (E,E,Z)-2,4,6-decatrienoate in central Maryland and present data verifying that the tachinid, Euclytia flava (Townsend), exploits methyl (E,Z,Z)-2,4,6-decatrienoate as a kairomone. We also report the unexpected finding that various isomers of methyl 2,4,6-decatrienoate attract Acrosternum hilare (Say), although this bug apparently does not produce methyl decatrienoates. Other stink bugs and tachinids native to North America were also attracted to methyl 2,4,6-decatrienoates. These data indicate there are Heteroptera in North America in addition to Thyanta spp. that probably use methyl 2,4,6-decatrienoates as pheromones. The evidence that some pentatomids exploit the pheromones of other true bugs as kairomones to find food or to congregate as a passive defense against tachinid parasitism is discussed.     

2007～2008年世界塑料工业进展

收集了2007年7月～2008年6月世界塑料工业的相关资料,介绍了2007～2008年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况.按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯·硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、不饱和聚酯树脂、环氧树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍.     

2005～2006年国外塑料工业进展

收集了2005年7月～2006年6月国外塑料工业的相关资料,介绍了2005—2006年国外塑料工业的发展情况。提供了世界塑料产量、消费量及全球各类树脂生产量以及各国塑料制品的进出口情况。作为对比,介绍了中国塑料的生产情况。按通用热塑性树脂（聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂）、工程塑料（聚酰胺、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚）、通用热固性树脂（酚醛、聚氨酯、不饱和树脂、环氧树脂）、特种工程塑料（聚苯硫醚、液晶聚合物、聚醚醚酮）的品种顺序,对树脂的产量、消费量、供需状况及合成工艺、产品开发、树脂品种的延伸及应用的扩展作了详细的介绍。