Total and soluble oxalate content in legume vegetables used in the preparation of frozen products for consumption

The aim of the investigation was to compare oxalate retention in two types of frozen product prepared for consumption after frozen storage: one obtained using the traditional method (blanching‐freezing‐frozen storage‐cooking) and a convenience food involving cooking‐freezing‐frozen storage‐defrosting and heating in microwave oven. The investigation included three species of legume vegetables: immature (wax‐stage maturity) seeds of broad bean and green pea, and French bean. Fresh broad bean seeds contained 53 mg total oxalates in 100 g fresh matter; pea 38 mg; and French bean 88 mg. Soluble oxalates comprised 53, 58 and 72% of total oxalates. The treatments applied resulted in reduction of the level of total and soluble oxalates, and oxalate to calcium ratio (broad bean and French bean); there was no influence on the level of calcium bound as calcium oxalate; true retention of oxalates was lower than apparent retention (green pea and French bean).     

Effect of preliminary and culinary processing on amino acid content and protein quality in frozen French beans

The aim of the study was to evaluate the content of amino acids and protein quality of French bean pods. The investigated material consisted of the raw vegetable, fresh pods cooked to consumption consistency, and two kinds of frozen products stored for 12 months at ?20 °C and then prepared for consumption: frozen beans obtained using the traditional method (blanching before freezing) and frozen products of the ready‐to‐eat type (cooking before freezing). A comparison of the amino acid content in the product prepared for consumption showed that the lowest quantities were found in French beans obtained using the traditional method; products obtained using the modified technology and beans cooked directly after harvest had similar levels of most amino acids. The content of amino acids in 16 g N was less varied than in 100 g of the product. The protein in all the three products prepared for consumption as well as that in fresh bean pods hardly differs, as confirmed by the values in the essential amino acid index (EAA). The first limiting amino acid was methionine with cystine and the second was lysine.     

Effect of precooking and polyphosphate treatment on the quality of catfish fillets cooked in pouch in boiling water

Cooking or reheating food in a vacuum‐sealed bag has been a common method of preparing vegetables, meats and poultry products. However, there are very few examples of vacuum‐sealed bags designed for cooking catfish fillets. The objective was to examine properties of raw frozen and precooked frozen catfish fillets that were cooked in a vacuum‐sealed pouch in boiling water. The effect of a commercial polyphosphate blend (IQF) on product properties was also evaluated. Sample analyses included weight loss, proximate content, colour (CIE L*a*b*), pH, mechanical texture and lipid peroxidation (TBARS) measurements. Both raw frozen and precooked frozen IQF fillets showed a significantly lower per cent moisture loss after cooking, of less than 2.7% relative to the fillets without polyphosphate (6.2–7.4%). Colour analysis showed a significantly higher b*(C) (yellowness) value for fillets without polyphosphate. Similar texture properties were observed between cooking treatments, with a harder texture (~1.3–1.7 times) determined for fillets without polyphosphate.     

Impact of the industrial freezing process on selected vegetables -Part II. Colour and bioactive compounds

In the present study, the impact of the different steps (i.e. blanching, freezing, storage following the industrial freezing process and the final cooking prior to consumption) of the industrial freezing process was evaluated on colour, chlorophylls, lutein, polyphenols and ascorbic acid content of asparagus, green beans and zucchini. In addition, the domestic boiling of raw samples was compared with the boiling of frozen storage vegetables.Results showed that the blanching treatment retained phytochemicals in all studied green vegetables and the frozen storage up to 2 months did not negatively affected phytochemicals, in particular lutein and flavonoids in almost all samples. On the contrary, colour significantly changed during blanching and frozen storage. The changes of b* (yellowness) and the shift of H° (hue angle) were not coherent with the increase of pheophytin. In addition, the greenness (− a*) was found to increase with the exception of boiled samples in all vegetables. Generally, in boiled frozen vegetables there was a better or comparable retention of bioactive compounds with respect to raw ones, and this was especially true for green beans and zucchini. Colour changes after cooking did not exhibit the same trends among vegetables, being more remarkable for frozen asparagus in comparison with those boiled from raw, but overall comparable for green beans and zucchini.In conclusion, the overall results of the present study suggest that, when the industrial freezing process is well performed, the boiled frozen vegetables do not have a lower nutritional value than the fresh ones.     

Effects of the methods of pre-treatment before freezing on the retention of chlorophylls in frozen leaf vegetables prepared for consumption

The investigation included kale, New Zealand spinach and spinach. The evaluation covered the raw material; the raw material after blanching; the raw material after cooking; and frozen products prepared for consumption after 0, 4, 8 and 12 months of refrigerated storage. Both the traditional method of freezing (blanching before freezing) and the modified method of freezing (cooked before freezing) were used in the experiment, as well as two storage temperatures, T = −20 °C and T = −30 °C. The content of chlorophylls in fresh kale was four times that in New Zealand spinach and 1.5 times that in spinach. With the exception of New Zealand spinach, blanching and cooking significantly reduced the content of chlorophylls. In kale products prepared for consumption, the content of chlorophylls decreased in each successive stage of the investigation. In products of New Zealand spinach and spinach, the losses were usually not significant. After 12 months of refrigerated storage, frozen kale products prepared for consumption retained 52–65% of total chlorophylls compared with the content in the raw material; products of New Zealand spinach and spinach retained 66–71%. In kale and New Zealand spinach, the content of chlorophyll a decreased more rapidly than that of chlorophyll b, while in spinach the converse was true. The kale products obtained using the modified method contained more chlorophylls, while in the two spinach species their content was lower. The lower storage temperature resulted in a higher retention of chlorophylls in vegetables.     

Retention of mineral constituents in frozen brassicas depending on the method of preliminary processing of the raw material and preparation of frozen products for consumption

The content of ash, P, K, Ca, Mg, Na, Fe, Zn, Mn, Cu, Cr and Ni was determined in four species of brassicas: Brussels sprouts, broccoli, and green and white cauliflowers. The investigation covered the raw material, the material blanched or cooked before freezing and frozen products after 12 months of refrigerated storage and prepared for consumption. Frozen products were obtained by the traditional method of freezing the blanched material or by the modified method of freezing the cooked material. The processing of vegetables before freezing (washing, grinding, blanching or cooking) caused statistically significant decreases in most constituents analysed. Blanching did not basically change the content of sodium and calcium; or that of chromium in both types of cauliflower; copper and nickel in white cauliflower; and nickel and phosphorus in Brussels sprouts. Cooking in brine, however, caused increases in the content of ash, sodium and calcium in white cauliflower, decreases in the content of potassium and iron and, in some species, of the remaining constituents. In comparison with the traditional method, a greater content of most analysed elements was found in frozen products obtained by the modified technology and prepared for consumption. However, no significant differences were noted in the level of chromium in all the samples; in the level of calcium in broccoli and green cauliflower; of nickel in broccoli; of nickel, copper and zinc in white cauliflower; and of copper in green cauliflower.     

Evaluation of the amino acid content and sensory value of flageolet bean seeds (Phaseolus vulgaris L.) as affected by preprocessing methods before freezing

The aim of the work was to evaluate the content of amino acids in flageolet bean seeds, prepared for consumption from frozen products obtained using different methods. One of the frozen products was obtained using the traditional method (blanching–freezing–frozen storage) and then cooked. The other was obtained using the modified technology (cooking–freezing–frozen storage), followed by defrosting and heating in a microwave oven. The culinary and technological processing applied brought about a pronounced decrease in tyrosine content (35–47% in 16 g N). The content of the remaining amino acids decreased or increased in relation to the raw material within the extremes of ?15% to +17%. Sulphur amino acid was the limiting amino acid. Product obtained using traditional method had the higher quality protein (EAA index 144–166) of seeds prepared for consumption. In sensory test products, blanched before freezing were evaluated a bit higher than those cooked before freezing (ready‐to‐eat).     

Effect of freezing and canning on the content of selected vitamins and pigments in seeds of two grass pea (Lathyrus sativus L.) cultivars at the not fully mature stage

Seeds of the grass pea (Lathyrus sativus L.) cultivars Derek and Krab, with a dry matter content of about 33%, were used for freezing and for canning. The content of vitamins C, B1, and B2 and of carotenoids, beta-carotene, and chlorophylls was determined in raw and blanched material, in frozen products after 6-month storage before and after cooking to consumption consistency, and in canned products after 6-month storage. In comparison with the cultivar Krab, raw seeds of Derek contained 45% more vitamin C, 14% more total chlorophylls, 13% less thiamine (vitamin B1), and 7% less riboflavin (vitamin B2). The level of carotenoids was similar. Blanching of seeds led to a statistically significant decrease only in the content of vitamin C. Freezing and frozen storage significantly lowered the level of vitamin C and chlorophylls. The cooking of frozen seeds and the production of canned products and their storage resulted in a statistically verified reduction in the content of components analysed in all the samples. Greater losses were found in products prepared from seeds of the cv. Krab. After cooking, frozen seeds contained more of all the analysed components than the canned products.     

Composition, Liquid Leakage, and Mechanical Properties of Farmed Rainbow Trout: Variation Between Fillet Sections and the Impact of Ice and Frozen Storage

ABSTRACT: Variation in quality characteristics within rainbow trout fillets, and changes in liquid leakage (LL) and mechanical properties during ice or frozen storage was studied. Fat, water, protein, and ash content, determined in frozen thawed samples, varied significantly among fillet sections. LL increased in the cranial-caudal direction, and it was highest following freezing. Dorsally, compression and puncturing resistance increased towards the tail (raw and baked), but puncture resistance of raw fillets was highest in the belly flap. The results indicated pronounced softening of the tail-half upon freezing. It is suggested that sectioning of trout fillets for different products or markets may improve utilization of intrinsic quality characteristics.     

Effects of storage condition and domestic cooking on the quality and nutrient content of African leafy vegetables (Cassia tora and Corchorus tridens)

BACKGROUND: The main objective of this research was to determine changes in nutrient content of two African leafy vegetables, Cassia tora and Corchorus tridens, on cooking and storage under different temperature conditions, i.e. room storage (20 °C), refrigerated storage (4 °C) and frozen storage (?18 °C). RESULTS: The leafy vegetables were analysed for moisture, colour (Hunter L, a, b), texture, total chlorophyll, ascorbic acid, dehydroascorbic acid and total phenolics. Results indicated that the degradation of ascorbic acid was highest as a result of frozen storage, followed by room temperature storage. The dehydroascorbic acid content was correspondingly high in frozen stored leafy vegetables, whereas it was undetectable in the room temperature and refrigerated stored materials. The total phenolic content of the leaves increased with storage time while the total chlorophyll content decreased under all storage conditions. Domestic cooking resulted in significant additional losses of ascorbic acid following storage under all temperature conditions, with only 1–10% retention in the leaves and 50–60% retention in the cooking water. The green colour of the leafy vegetables was retained best under refrigerated and frozen storage, while the peak force and toughness of the leaves increased upon storage under all conditions. The moisture content of the leafy vegetables did not show any significant difference on storage. CONCLUSION: This study is one of few to report nutrient content changes on the same raw material stored under various temperature conditions and cooked domestically. Refrigerated storage resulted in the highest retention of ascorbic acid and green colour in the leafy vegetables. Copyright © 2009 Society of Chemical Industry     

CHEMICAL, NUTRITIVE AND SENSORY CHARACTERISTICS OF TOMATOES BEFORE AND AFTER CONVENTIONAL AND MICROWAVE BLANCHING AND DURING FROZEN STORAGE

The objective of this study was to evaluate the effects of microwave blanching on chemical, physical and sensory characteristics of tomatoes prior to and after frozen storage. Tomatoes were blanched (4 min) using four treatments: conventional boiling water (BW), steam (ST), microwaved in a glass container (MW), and microwaved in boilable bags (MWB). The lowest moisture content occurred in MW‐blanched tomatoes before (92%) and after (86%) frozen storage. These tomatoes had the highest reduced ascorbic acid (RAA) content and the highest RAA retention (> 23 mg/100 g, >91%) after blanching and after frozen storage. After blanching, MWB‐blanched tomatoes were the lightest, while after frozen storage, ST‐blanched tomatoes were the lightest. BW‐blanched tomatoes had generally higher flavor, texture and appearance scores. This study demonstrated that though visual color and sensory attributes were highest for BW‐blanched tomatoes, MW‐blanched tomatoes retained more nutritive value in the finished product.     

Content of amino acids in raw and frozen broad beans (Vicia faba var. major) seeds at milk maturity stage,depending on the processing method

The aim of the present work was to evaluate the amino acid content in products obtained from broad bean seeds, at the milk maturity stage, and the quality of the protein in broad beans. The investigation included raw seeds, fresh seeds cooked to consumption consistency and two kinds of frozen products prepared for consumption: which were obtained using the traditional method (blanching the seeds before freezing) and the ready-to-eat type (cooking the seeds before freezing). Compared with the raw material, a similar (α = 0.01) content of amino acids in 100 g of the product was found in cooked fresh seeds. The seeds obtained from the ready-to-eat frozen product prepared for consumption contained higher amounts of all the amino acids than the traditional frozen product, and contained higher levels of some amino acids than were found in the product cooked from fresh seeds. Expressing the results per 16 g of N, the differences in the content of amino acids were much smaller. The limiting amino acid was cysteine with methionine (CS 74-86), the EAA index varying within the range 109–118.     

High-Pressure Treatment and Freezing of Raw Goat Milk Curd for Cheese Manufacture: Effects on Cheese Characteristics

High-pressure treatment of raw goat milk curd was investigated as an alternative to thermal treatment of milk in cheese manufacture, and curd freezing as a procedure to surmount the seasonality of goat milk production. Experimental cheeses were made by mixing (70:30) fresh cow milk curd with frozen curd from pasteurized goat milk (PGC), frozen curd from raw goat milk (RGC), or frozen pressurized curd from raw goat milk (PRGC). Control cheese was made from a mixture (70:30) of pasteurized cow and goat milk. RGC cheese showed the highest counts of staphylococci, Gram-negative bacteria and coliforms, whereas PRGC cheese had maximum aminopeptidase activity, esterase activity, and overall proteolysis. Control cheese exhibited the highest dry matter content and peptide levels, the lowest concentration of free amino acids, the highest concentration of volatile compounds such as free fatty acids, alcohols and esters, and the firmest texture. Differences in sensory characteristics between experimental and control cheeses were of minor importance. High-pressure treatment of curd allowed the production of cheese of bacteriological quality similar to that of control cheese made using pasteurized milk, while curd freezing did not alter the sensory characteristics of experimental cheeses with respect to control cheese.     

Effect of processing on the amino acid content of New Zealand spinach (Tetragonia tetragonioides Pall. Kuntze)

The aim of this work was to evaluate the effect of processing on the amino acid content and protein quality of New Zealand spinach (Tetragonia tetragonioides Pall. Kuntze). In this research, fresh and cooked New Zealand spinach as well as two frozen products prepared for consumption, one obtained using the traditional method (blanching–freezing–storage–cooking) and the other a convenience food product obtained using a modified process (cooking–freezing–storage–defrosting and heating in a microwave oven), were analysed. Glutamic acid was the dominant amino acid in fresh New Zealand spinach, and the limiting amino acids were cystine and methionine. Technological and culinary processing caused a significant increase in amino acid content in 100 g of edible portion, with the exception of methionine and cystine in frozen products prepared for eating. Changes in amino acid content expressed in g/16 g of N (which corresponded to 100 g tissue protein) were not significant, with the exception of the lower glutamic acid content in the frozen product obtained using traditional processing method.     

Effects of Freezing on Quality of Cold-smoked Salmon Based on the Measurements of Physiochemical Characteristics

ABSTRACT: How the quality of cold-smoked Atlantic salmon ( Salmo salar ) is affected by freezing the raw fish as whole fish, as gutted fish, and as fillets before smoking, and by freezing the finished product after smoking was studied. Freezing before smoking resulted in increased product yield and water content, but softer texture and increased K-value. Freezing reduced the content of astaxanthin but increased the lightness and the color intensity of the flesh. Gaping increased when the fish was frozen as fillets before smoking. Freezing only after smoking led to fewer changes in quality than freezing before smoking, whereas refreezing the finished products had little additional effect on quality.     

Content of amino acids and the quality of protein in as‐eaten green asparagus (Asparagus officinalis L.) products

The content of amino acids in fresh green spears and in three as‐eaten products was considered, i.e., in fresh asparagus after cooking and in two products obtained from frozen asparagus stored for 12 months at ?20 °C. One of the frozen products was obtained using the traditional method (blanching–freezing–frozen storage) and then cooked. The other was obtained using the modified technology (cooking–freezing–frozen storage); after the storage period the product was defrosted and heated to consumption temperature in a microwave oven. The limiting amino acid of the first order was methionine with cystine, and of the second order leucine. Essential amino acids constituted 40–43% of the total amino acid content. The dominant amino acids were aspartic acid and glutamic acid. The culinary and technological procedures applied brought about a drastic decrease (50–56% in 16 g N) in tyrosine content.     

Processed Tart Cherry Products—Comparative Phytochemical Content,in vitro Antioxidant Capacity and in vitro Anti‐inflammatory Activity

Abstract: Processing of fruits and vegetables affects their phytochemical and nutrient content. Tart cherries are commercially promoted to possess antioxidant and anti‐inflammatory activity. However, processing affects their phytochemical content and may affect their related health benefits. The current study compares the in vitro antioxidant capacity and anti‐inflammatory cyclooxygenase activity of processed tart cherry (Prunus cerasus) products—cherry juice concentrate, individually quick‐frozen cherries, canned cherries, and dried cherries. Cherry products were analyzed for total anthocyanin and proanthocyanidin content and profile. On a per serving basis, total anthocyanins were highest in frozen cherries and total proanthocyanidins were highest in juice concentrate. Total phenolics were highest in juice concentrate. Juice concentrate had the highest oxygen radical absorbance capacity (ORAC) and peroxynitrite radical averting capacity (NORAC). Dried cherries had the highest hydroxyl radical averting capacity (HORAC) and superoxide radical averting capacity (SORAC). Processed tart cherry products compared very favorably to the U.S. Dept. of Agriculture‐reported ORAC of other fresh and processed fruits. Inhibition of in vitro inflammatory COX‐1 activity was greatest in juice concentrate. In summary, all processed tart cherry products possessed antioxidant and anti‐inflammatory activity, but processing differentially affected phytochemical content and in vitro bioactivity. On a per serving basis, juice concentrate was superior to other tart cherry products. Practical Application: Processing of fruits and vegetables affects their chemical and nutrient content and perhaps their related health benefits. Comparative studies are valuable to ascertain the effects of processing on fruit and vegetable chemical content and bioactivity. Here we present tart cherries as a model for this type of detailed comparison.     

COMPARISON OF PHYSICAL METHODS FOR ESTIMATING THE MATURITY OF RAW, FROZEN AND COOKED PEAS

The back extrusion cell, Maturometer, Kramer shear press, FMC Tenderometer, and Ottawa Texture Measuring System wire extrusion cell gave useful estimates of the maturity of raw peas but, two viscosity methods gave unsatisfactory estimates. None of the instruments gave useful estimates of maturity of frozen peas that had been thawed or cooked because blanching conditions and the rate of freezing of the peas affected the readings. The most reliable estimate of raw pea maturity from thawed frozen peas was the alcohol insoluble solids content.     

反复冻融对缠丝兔加工过程中脂肪酸含量变化的影响

以反复冻融兔肉为原料,分析缠丝兔加工过程中的脂肪酸含量变化。结果表明：与新鲜原料兔肉对照,随着冻融次数增加,反复冻融原料兔肉及其腌制后和烘烤后的脂肪含量显著降低,硫代巴比妥酸值显著增加（P＜0.05）;原料兔肉检测出棕榈酸（C16∶0）、亚油酸（C18∶2）等脂肪酸,在缠丝兔加工过程中,脂肪降解产生了油酸（C18∶1）;反复冻融兔肉在腌制和烘烤后的脂肪酸也呈显著性变化（P＜0.05）;5 次冻融原料的缠丝兔脂肪含量最低（0.023 8%）、硫代巴比妥酸值最高（0.216 8 mg/kg）。表明兔肉反复冻融对缠丝兔的脂肪酸含量影响显著。     

Impact of the industrial freezing process on selected vegetables — Part I. Structure,texture and antioxidant capacity

In this work, the impact of the industrial freezing process on structure, texture and total antioxidant capacity was studied using green asparagus stems, zucchini and green beans. Samples were analysed as raw/uncooked, blanched, raw/boiled and industrially frozen/boiled.A consistent damage of the vegetable tissue was revealed by the histological analysis on vegetables boiled after freezing. The cells appeared to be dehydrated, contracted and separated at different levels depending on the anatomical structure of each vegetable.The initial textural quality was partially retained in all blanched vegetables, and enhanced in cut tested asparagus stems, in relation to the action of phenolic acids at cell wall level. Raw/boiled and industrially frozen/boiled asparagus stems exhibited comparable forces of penetration and cut tests. On the other hand, zucchini, both raw and frozen, completely softened after boiling making the texture measurement impossible. Industrially frozen/boiled green beans showed higher values of cut and penetration forces, probably due to a higher presence of swollen cell walls, in comparison to those raw/boiled.Blanching and boiling significantly increased the ferric reducing antioxidant power values of asparagus stems and green beans compared to uncooked/raw samples, while boiling after the freezing process significantly deprived both vegetables of the initial antioxidant capacity. On the other hand, boiling the frozen zucchini proved to be detrimental to the antioxidant capacity.In conclusion, manufacturers and researchers should join together to develop specific industrial freezing process conditions according to the matrix of each vegetable.