The effect of muscle, cooking method and final internal temperature on quality parameters of beef roast

The aim of the study was to evaluate the influence of cooking conditions (dry air and steam) and final internal temperature (75, 85, 95°C) on the physico-chemical properties of beef infraspinatus (INF) and semimembranosus (SEM) muscles as well as their tenderness and juiciness. Cooking method and temperature influenced moisture, total collagen content in cooked meat and cooking loss, whereas muscle type affected fat, total collagen content and cooking loss. Warner-Bratzler shear force values were affected by cooking method, which also influenced juiciness of roasts. Temperature affected tenderness and juiciness, whereas muscle type influenced juiciness. The most desirable tenderness had INF heated in steam and dry air to 95°C. Processing SEM in dry air to 85 and 95°C lowered the juiciness of the roasts. There were significant correlations between physico-chemical, sensorial and image attributes, however high accuracy of prediction (r(2)>0.8) was achieved only for SEM muscle.     

PSE肉和DFD肉中糖原含量变化分析

利用蒽酮比色法进行检测正常肉、PSE肉和DFD肉中糖原含量的变化。糖原标液水解率为95.8%～98.7%,平均值为97.46%,相对标准偏差为1.25%。在0h,正常肉、PSE肉和DFD肉中糖原的平均含量分别为0.7560、0.7456、0.5284mg/g,RSD为0.3689%～0.7566%。PSE肉中糖原含量2h后下降到0.0420mg/g,RSD为2.3890%。正常肉和DFD肉的糖原含量在72h后分别下降到0.0608mg/g和0.0794mg/g,RSD为2.1445%和4.5931%。     

Differences in quality characteristics of normal, PSE and DFD pork

Differences in water-holding capacity, colour and tenderness/toughness were studied in 21 pork loins belonging to three quality categories, i.e. dark firm dry (DFD), normal and pale soft exudative (PSE). The division into the three groups was based upon the ultimate pH-values of the loins (< pH 5·5, pH 5·5-6·0, pH > 6·4). The PSE loins were characterized by a poor waterholding capacity, higher cooking loss and paler colour in contrast to the DFD category. The normal loins took an intermediate position. Neither sarcomere length, determined on fresh muscle tissue, nor Armour tenderometer values showed significant differences between the various quality categories. This was in contrast to the Warner-Bratzler (W-B) shear force values, determined on cooked loins, which had the lowest values in the DFD category. A strong relationship between the W-B values and the cooking losses was found. It was concluded that neither sarcomere length nor Armour tenderometer measurements were able to predict the shear force values of cooked pork loins.     

The effect of cooking conditions on the eating quality of pork

Two experiments were conducted to examine the effects of cooking parameters, including final internal temperature (65, 72·5 or 80°C), on the eating quality of pork. Assessments were made by a 10-member trained taste panel. In Experiment 1 on loin steaks (m. longissimus) from 28 carcasses weighing 66 ± 1·9 (SD) kg, increasing the final internal temperature from 65 to 80°C had the following effects on mean scores (1-8): tenderness -1·0; juiciness -1·5, pork flavour +0·6 and abnormal flavour -0·5. The medium temperature of 72·5°C was suggested as ideal. In Experiment 2 on leg roasts (m. gluteobiceps) from 96 carcasses weighing 65 + 2·7 (SD) kg, increasing the final internal temperature from 65 to 80°C had the following effects on mean scores (1-8): tenderness -0·2 (not significant), juiciness -0·6, pork flavour +0·3 and abnormal flavour -0·5. The effects of final internal temperature were therefore smaller in roasts and temperatures towards the upper end of the range would be recommended for ideal eating quality, balancing small losses in tenderness and juiciness against gains in flavour scores. Although the experiments were not designed to examine source and sex effects there was evidence that tenderness can be improved through the use of Duroc genes and pelvic suspension of carcasses and no evidence of differences in eating quality between entire males and females.     

Physico-chemical, textural and structural characteristics of sous-vide cooked pork cheeks as affected by vacuum, cooking temperature, and cooking time

This paper describes the influence of different factors on sous-vide cooked pork. Pork cheeks were cooked at different combinations of temperature (60 °C or 80 °C), time (5 or 12 h) and vacuum (vacuum or air packaged). Weight losses were lower and moisture content higher in samples cooked for a shorter time (P = 0.054) and at a lower temperature (P < 0.001). Samples cooked at 60 °C showed more lightness (L*) and redness (a*) (P < 0.001). Lipid oxidation showed an interaction between cooking time and temperature (P = 0.007), with higher TBARs values for samples cooked for 12 h at 60 °C and lower for those cooked for 12 h at 80 °C. Samples cooked at 80 °C for 12 h showed lower (P < 0.05) values for most textural parameters than all the other types of samples. Vacuum packaging showed no influence on any of the studied variables. For the treatments evaluated, cooking temperature × time combination seems to be more important than vacuum packaging in the textural and colour parameters of pork cheeks.     

The effect of temperature on the drip,denaturation and extracellular space of pork longissimus dorsi muscle

Pork longissimus dorsi muscles were cut across the muscle into slices as soon as possible after slaughter. The slices were held at temperatures ranging from 10 to 37°C during the first 24 h post-mortem. 1–2% drip was obtained from slices held at 10°C and increased to 10–14% at 37°C. As the amount of drip increased, the protein concentration of the drip fell from about 150 mg/ml to 100 mg/ml. Some of this decrease could be attributed to the denaturation of sarcoplasmic protein, which amounted to a maximum of 19% in the samples with the highest drip. It is also suggested that diffusion of fluid from the myofilaments or sarcoplasmic reticulum could dilute the sarcoplasm. Denaturation of the myofibrillar proteins, as measured by their ATPase activity, was also observed but this was measurable only at holding temperatures above 30°C. The extracellular space which was 2–5% of the muscle section when the holding temperature was 10°C and drip was low, increased to a maximum of 16–25% at 37°C when drip was high. It is suggested that this is a contributory factor to the increase in drip with increasing temperatures.     

The effect of cooking conditions on the formation of volatile heterocyclic compounds in pork

Headspace volatiles from grilled, roast and boiled pork were entrained on Tenax GC and analysed by combined gas chromatography-mass spectrometry. Well-done grilled pork contained 66 heterocyclic compounds including pyrazines. thiazoles, thiophenes, furans and pyrroles, many of which had not previously been found in cooked pork. The pyrazines accounted for almost 80% of the total headspace volatiles, although most of the other heterocyclic compounds were present only in small amounts. Pork cooked by less severe grilling or by roasting or boiling contained considerably fewer heterocyclic compounds, and headspace volatiles were dominated by aldehydes and alcohols originating from thermal oxidation of lipid.     

Effect of carbon monoxide in modified atmosphere packaging, storage time and endpoint cooking temperature on the internal color of enhanced pork

The objective of this research was to evaluate the effects of gas atmosphere, refrigerated storage time, and endpoint temperature on internal cooked color of injection-enhanced pork chops. Enhanced chops were packaged in 0.36% CO/20.34% CO₂ (CO-MAP), 80% O₂/20% CO₂ (HO-MAP), or PVC-overwrapped (PVC-OW; controls), stored at 4 °C for 0, 12, 19 or 26 days, displayed for 2 days then cooked to six endpoint temperatures (54, 60, 63, 71, 77, and 82 °C). L^*, a^*, and b^* values, hue angle and chroma were determined on the internal cut surface of cooked chops. Chops packaged in CO-MAP had the highest a^* values; a^* value began increasing on day 14. The lowest hue angles occurred in chops cooked to lower endpoint temperatures. Chops in CO-MAP had lower hue angles and higher chroma than those in HO-MAP and PVC-OW. Above 71 °C, hue angle and chroma increased. Overall, CO-MAP packaged chops stored for longer time periods then cooked to lower endpoint temperatures appeared reddest. HO-MAP packaged chops were less red, did not change over time, and appeared more well done at lower endpoint temperatures than those in other gas atmospheres. CO-MAP packaged chops retained redness even after cooking at 82 °C.     

Effect of carbon monoxide in modified atmosphere packaging,storage time and endpoint cooking temperature on the internal color of enhanced pork

The objective of this research was to evaluate the effects of gas atmosphere, refrigerated storage time, and endpoint temperature on internal cooked color of injection-enhanced pork chops. Enhanced chops were packaged in 0.36% CO/20.34% CO₂ (CO-MAP), 80% O₂/20% CO₂ (HO-MAP), or PVC-overwrapped (PVC-OW; controls), stored at 4 °C for 0, 12, 19 or 26 days, displayed for 2 days then cooked to six endpoint temperatures (54, 60, 63, 71, 77, and 82 °C). L¹, a¹, and b¹ values, hue angle and chroma were determined on the internal cut surface of cooked chops. Chops packaged in CO-MAP had the highest a¹ values; a¹ value began increasing on day 14. The lowest hue angles occurred in chops cooked to lower endpoint temperatures. Chops in CO-MAP had lower hue angles and higher chroma than those in HO-MAP and PVC-OW. Above 71 °C, hue angle and chroma increased. Overall, CO-MAP packaged chops stored for longer time periods then cooked to lower endpoint temperatures appeared reddest. HO-MAP packaged chops were less red, did not change over time, and appeared more well done at lower endpoint temperatures than those in other gas atmospheres. CO-MAP packaged chops retained redness even after cooking at 82 °C.     

The effect of cooking temperature on mechanical properties of whole meat, single muscle fibres and perimysial connective tissue

The structural changes in beef semitendinosus caused by cooking were studied by performing tensile tests of the isolated meat components (i.e. single muscle fibres and perimysial connective tissue) and related to the toughness of the whole meat. Whole meat toughness was found to increase in two separate phases upon cooking from 40-50°C, and again from 60 to 80°C with a decrease in meat toughness between 50 and 60°C, in agreement with previous studies. The changes in whole meat toughness at temperatures below 60°C were found to correspond to changes in the mechanical properties of the perimysial connective tissue, whereas changes of whole meat toughness at temperatures above 60°C were found to correspond to increased breaking strength of single muscle fibres. The myofibrillar component explained approximately 47% of the variation in whole meat toughness upon cooking whereas inclusion of the connective tissue component increased the goodness of fit.     

The effect of conditioning on the myofibrillar proteins of pork muscle

Storage of pork muscle caused changes in the troponin complex of myofibrillar proteins. The changes were temperature dependent and progressive as conditioning proceeded. An alteration in actin also occurred but this became apparent only when myofibrils had been extracted with 5 mM Tris pH 8.2. About 60% of the proteins in an extract of myofibrils in 5 mM Tris pH 8.2 were bound to the precipitate formed with added F-actin. After conditioning of the pork muscle, the amount of proteins in a Tris extract which were bound to added F-actin was considerably reduced. Some of these changes were also observed in myofibrils which had been treated with a Ca²⁺ activated proteinase.     

Effect of exercise and pre-slaughter stress on pork muscle characteristics

The effects of exercise, stress and chill temperature on pork muscle characteristics were studied in a 3 × 2 × 2 factorial experiment in which treatments were assigned to blocks made up of six pigs of the same sex from the same litter. Pigs were fed a corn-soybean meal diet with the two littermate pigs on each treatment fed together. Treatments were (1) a control group receiving no exercise and fed in an 8 m(2) pen; (2) a treatment group fed in an 8 m(2) pen and driven 1·6 km/day for 100 days prior to slaughter; and (3) a treatment group fed in pens with 40 m(2) floor space with feeders placed 5 m from their waterers. When the animals averaged approximately 105 kg in weight, one animal from each pair treated alike was subjected to standardized stress. After slaughter, one side was chilled at 2-3°C and the other at 13-15°C for 24 h. Both sides were then chilled at 2-3°C for an additional 24 h. Exercise did not affect average daily gain (ADG), feed efficiency, yield of total wholesale cuts, muscle pH, protein solubility, fiber diameter and sarcomere length of the Longissimus dorsi (LD) and Quadriceps femoris (QF) muscles or the tenderness of the QF muscle. Exercise decreased backfat thickness and the subjective tenderness of the LD muscle. The effects of stress on the characteristics evaluated were consistent with those that have been previously reported. Chilling temperature and interactions involving chilling temperature did not affect any of the characteristics studied. No exercise × stress interactions were observed. Protein solubility values indicated that pale, soft exudative (PSE) muscle was not a factor in any of the treatments. It was concluded that exercise will produce leaner carcasses but less tender muscle and that exercise will not counteract the effects of pre-slaughter stress.     

The effect of sodium chloride content and temperature on pork meat isotherms

The knowledge of sorption isotherms is essential for understanding the drying process. Throughout the dry cured meat process, changes occur in the NaCl content and temperature on the surface of meat products. The aim of this study was to obtain the desorption isotherms from raw and salted meat at different air temperatures and NaCl content. The desorption characteristics were studied in the relative humidity range of 11.2 to 94.5 % at storage temperatures of 5, 13 and 26°C and at 0, 8, 20 and 30% (dm) of added salt (NaCl). The salted meat samples isotherms at 26°C shows a breaking point between water activities (a(w)) of 0.70 and 0.75. At a(w) lower than 0.70, NaCl content and temperature have only a slight effect on water content equilibrium. At a(w) above 0.75, water content equilibrium increased with the increase in NaCl content and the decrease in temperature. A significant NaCl*Temp interaction was detected at a(W) 0.903 and 0.946.     

The effect of different convection cooking methods on the instrumental quality and yield of pork Longissimus dorsi

The effect of different cooking methods (natural convection, NC, forced convection, FC and forced convection/steam combined, FC/S) on selected physical properties of cooked pork Longissimus dorsi samples were compared. FC/S treatment was significantly faster (19 min) than NC and FC cooking treatments (27 min). The overall cook values at the center of all samples (calculated taking into consideration the cooling phase) were comparable and might explain the similar tenderness found among samples that underwent significantly different thermal histories. The weight loss of the FC/S samples was significantly higher than in the other cooking methods while the color of the surface was paler than the NC and FC ones.     

Effects of muscle cortisol concentration on muscle fiber characteristics, pork quality, and sensory quality of cooked pork

The effect of muscle cortisol concentration on muscle fiber characteristics and technological and sensory quality of pork was investigated. With the exception of the percentage of type IIA fibers, muscle fiber characteristics were not associated to cortisol levels. However, muscle cortisol concentration was positively associated with muscle pH(24h) (r = 0.23, P<0.05) and negatively associated with drip loss (r = -0.49, P<0.001), lightness (r = -0.24, P<0.05), shear force (r = -0.25, P<0.05), and texture profile analysis-hardness (r = -0.35, P<0.01). Additionally, the water-holding capacity of meat samples was affected by cortisol levels, with lower cortisol concentrations associated with less tender samples. These results indicate that the concentration of cortisol in the muscle is related with meat quality as well as the sensory quality of cooked pork.     

The influence of pork quality traits and muscle fiber characteristics on the eating quality of pork from various breeds

The purpose of this study was to compare parameters associated with pork quality, muscle fiber, and eating quality among various breeds, and to examine if differences in eating quality were associated to pork quality and muscle fiber characteristics. For carcass and pork quality, although there were significant differences among breeds, the values of parameters in all pigs were assigned a normal quality class, a likely outcome of the similarity in the area percentage of type I and IIB fibers. For eating quality, pork loins from Berkshire pigs were more tender and full of pork flavor than Landrace and Yorkshire pigs. Except juiciness and mouth coating, over 20% of the variability in the eating quality parameters can be explained by pork quality traits and muscle fiber characteristics using multiple regression analysis. Furthermore, differences in muscle pH_24 h, cooking loss, shear force, and NPPC marbling score could explain a large proportion of variation in eating quality parameters associated with the texture of pork.     

Effect of freezing temperature, thawing and cooking rate on water distribution in two pork qualities

The effects of freezing temperature (-20 versus -80°C) in combination with long-term freezer storage (-20°C) on water mobility and distribution in pork of two qualities (normal and high ultimate pH) were explored using low-field NMR T(2) relaxometry. A marked effect of freezing temperature on the characteristics of intra- and extramyofibrillar water (T(2) relaxation times) in the thawed pork was demonstrated, implying that the freezing temperature in combination with prolonged freezer storage affects the distribution and chemical-physical state of water in the thawed meat. Determination of technological properties (thawing and cooking loss) revealed that the observed T(2) variations related to water distribution and water properties, which were found to be consistent with the degree of structural damage assessed by light microscopy, also were reflected in the technological quality of the meat. Low freezing temperature in combination with prolonged freezer storage was associated with increased thawing and cooking loss. In addition, pH in the fresh meat had a pronounced effect on the distribution of myofibrillar water, as a more homogenous pore size distribution was evident in meat with high pH compared with normal pH. A clear effect of cooking rate on the T(2) relaxation characteristics in the cooked pork was also demonstrated, probably reflecting a cooking rate-induced effect on the myofibrillar structures. The effect of cooking rate on water distribution resulted in a significantly lower cooking loss upon a slow cooking rate (0.5°C/min from 25 to 65°C and 0.3°C/min from 65 to 80°C) compared with a fast cooking rate (1°C/min).     

不同食盐添加量和蒸煮温度对猪肉糜品质的影响

食盐添加量和蒸煮温度影响猪肉糜的加工特性和肉制品品质。该文主要分析不同食盐添加量(质量分数为1%、2%和3%)和蒸煮温度(70、80和90℃)猪肉糜的色差、蒸煮得率、质构和流变性,研究食盐和蒸煮温度对猪肉糜凝胶性能的影响。猪肉糜的L*值、蒸煮得率和硬度、弹性、内聚性均随食盐添加量的增加显著(p0.05)升高,而b*值显著(p0.05)下降;从25℃加热到95℃,食盐添加量(质量分数)为3%的猪肉糜的储能模量(G')最高。在相同食盐添加量的猪肉糜中,蒸煮得率和弹性在70℃时最高,随着温度的升高而降低,而b*值和内聚性随着温度的升高而显著增加(p0.05);G'在89℃时达到最大值,之后显著下降。综上所述,采用合适的食盐添加量和蒸煮温度有利于提高猪肉糜制品的品质。     

The effect of cooking and washing temperature during pilot-scale rennet casein manufacture on casein hydration characteristics in disodium orthophosphate solution

Variations were observed in the hydration behaviour of rennet caseins in a solution (0.4%, w/w) of disodium orthophosphate (DSP). These caseins were manufactured on a pilot scale from curds cooked at 45, 65 or 75°C and from curds washed at a hot-wash temperature of 60, 70, 78 or 86°C. The influence of cooking temperature and hot-wash temperature on various compositional characteristics, the electrophoretic resolution and particle size parameters of the milled rennet caseins were determined. Relationships between all of these parameters and hydration characteristics in DSP solution were also investigated. Cooking temperature or hot-wash temperature did not influence electrophoretic resolution, the level of Maillard reaction compounds or the particle size parameters of the caseins. Increasing the cooking temperature increased whey protein levels and decreased calcium levels in the curd, leading to slower hydration rates. This suggested that increased whey protein denaturation and its precipitation onto the rennet casein curd retarded subsequent rennet casein hydration. Hot-wash temperature influenced certain aspects of rennet casein hydration in 0.4% (w/w) DSP; however, the hydration characteristics of these caseins did not appear to be related to any of the other characteristics investigated.