A comparison between tensile and shear adhesive strength of meat-myosin junctions

A model meat-myosin gel junction was used to compare the adhesive strength of binding junctions when subject to tensile or shear forces. This comparison was made on junctions cooked to 80°C with three different alignments of muscle fibres with respect to the junction plane. Tensile adhesive strength (TAS) and shear adhesive strength (SAS) did not differ significantly when fibres in both of the bound pieces of meat were perpendicular to the plane of the myosin gel function (90°/90° junction). However, SAS was higher than TAS if the muscle fibres in one or both of the meat pieces were parallel to the plane of the junction. This suggests that tensile failure of binding junctions is the more likely mode of failure. Differences between SAS and TAS in any one junction orientation were small compared to the effect of muscle fibre orientation with respect to the junction; both TAS and SAS were highest for 90°/90° junctions and lowest when muscle fibres in both meat pieces were parallel to the junction (0°/0° junctions).     

The influence of varying degrees of adhesion as determined by mechanical tests on the sensory and consumer acceptance of a meat product

The adhesion between meat pieces in meat products, varied by the addition of different concentrations of a crude myosin solution, was measured by a trained sensory panel and by two instrumental tests: tensile adhesive strength (TAS) and punch and die. A consumer trial was used to find which level of adhesion was preferred. Results from the sensory panel showed that the adhesion could be detected as highly significant (P < 0·001) differences in three tactile measurements and in the two eating qualities, ease of fragmentation and rubberines. TAS measurements gave larger differences between treatments than punch and die, and had very high correlations with ease of fragmentation and crumblines on cutting. The small consumer study revealed no overall preference for any one product. Hence, although differences in adhesion between meat pieces in a meat product are detectable subjectively and can be measured objectively by TAS tests, preference for any particular strength varies between individuals.     

Effect of slaughter weight and/or age on histological characteristics of pig longissimus dorsi muscle as related to meat quality

The effect of increasing both weight and age or age alone through feed restriction on muscle longissimus dorsi histological characteristics were studied in relation to fresh and cooked meat quality. Starting at 83 days (32 kg) 80 crossbred Duroc × (Large White×Landrace) barrows were allotted within litter to 4 experimental groups (A100, R100, A130, R130). Pigs were fed either ad libitum (A) or were restricted 30% (R) and slaughtered either at 100 kg or 130 kg. Muscle fibres were classified as βR, αR or αW according to Ashmore and Doerr (1971)(Ashmore, C.R., &; Doerr, L. (1971). Comparative aspects of muscle fibre types in different species. Experimental Neurology, 31, 408–418.). Percentages (PC), cross-sectional areas (CSA) and relative areas (RA) of each fibre type were evaluated. Phenotypic correlations between histological traits showed that RA of a particular fibre type depends essentially on its numerical abundance. Increasing weight together with age led to enlargement of βR and αW muscle fibres, without changing muscle histochemical profile. When age was increased at the same weight (restriction), higher RA of βR fibres was observed. Low, but significant correlation between loin eye area and CSA was observed, but not within experimental group. The phenotypic correlations between histological and meat quality traits were generally low. This material showed some significant correlations suggesting that increasing PC or CSA of overall αW fibres can be beneficial for water holding capacity of fresh meat and juiciness of cooked meat. ©     

De electricitatis catholici musculari - Concerning the electrical properties of muscles, with emphasis on meat quality

This study aims to explore the potential of evoked non-invasive surface electromyography (SEMG) analysis, in predicting meat quality traits in livestock. Evoked SEMG is a system that records, transdermally, electrical signals generated in muscle fibres upon external stimulation. These signals are reported as compound muscle action potentials (CMAP). CMAP parameters of LD correlated negatively and significantly to ultimate pH (pH 24 h) at day 61, but not at day 153 after birth, and a similar albeit positive correlation was observed for muscle glycogen content. Muscle glycogen content and pH 24 h correlated negatively in LD and BF. Negative significant correlations between CMAP parameters and shear force were found in LD at day 153 after birth, which might, in the range of the recording electrodes, reflect the combined effect of large cross-sectional area fibres and reduced perimysium content per unit volume of muscle. The fact that correlations between CMAP characteristics and quality traits of both metabolic and non metabolic origin could be established, warrants a fuller investigation of this method in terms of its potential as a predictive tool for meat quality traits in live animals.     

Effects of carcass weight and muscle on texture, structure and myofibre characteristics of wild boar meat

Texture, histology and muscle fibre characteristic of selected muscles: m. quadriceps femoris (QF), m. biceps femoris (BF), and m. semimembranosus (SM) of wild boars of different carcass weight (20±2 and 60±3kgSD) were compared. Muscle texture (hardness, cohesiveness, springiness, chewiness) was determined with the double penetration test performed with the Instron 1140 apparatus. Structural elements (muscle fibre cross-section area, perimysium and endomysium thickness) and percentage of myofibres of each type: I (slow oxidative), IIA (fast oxidative-glycolytic) and IIB (fast glycolytic) per muscle fibre bundle, were measured in muscle samples using a computer image analysis program. The young wild boar muscles showed significantly lower values for the textural parameters (p<0.05). The muscle fibre cross-sectional areas of the juvenile wild boar muscles were significantly lower and the perimysium and endomysium thinner (p<0.05) than those in the old wild boar meat, while the percentage of type IIB fibres was higher. Of all the wild boar muscles tested, the highest hardness and chewiness values were found in BF which, at the same time, showed the highest fibre cross-sectional area and the thickest perimysium and endomysium. The highest percentage of I and IIA fibre types was typical of BF and SM either in young or in old wild boars with the lowest percentage of type I and the highest percentage of type IIB fibres being found in the QF. The results suggest that a higher hardness of wild boar muscles can be connected with a thicker perimysium and endomysium, fibres of higher cross-sectional area and probably a higher content of red fibres (type I).     

ACETIC ACID MARINADING—THE RHEOLOGICAL CHARACTERISTICS OF SOME RAW AND COOKED BEEF MUSCLES WHICH CONTRIBUTE TO CHANGES IN MEAT TENDERNESS

The tensile and adhesive characteristics of acetic acid marinaded bovine Ms sternomandibularis (StM), infraspinatus (IS), triceps brachii caput longum (TB), and psoas major (PM) were studied over the meat pH range 5.80 to 4.10 on both raw and cooked strips of muscle. In the raw muscle samples, tensile and adhesive characteristics were greatest around pH 5.0, progressively decreasing as muscle pH values approached 4.1. Cooking increased tensile strength, particularly around pH 5.0 where peak force values virtually doubled. Cooking had less influence on the adhesive characteristics of all muscle samples which tended to decrease below pH 4.5. In both raw and cooked muscle samples, intermuscular differences in adhesive characteristics were also much greater than those obtained for tensile characteristics. Irrespective of intermuscular differences in collagen content or its degree of maturity, the gradual decreases in tensile and adhesive characteristics below pH 5.0 could be related to the effect of acetic acid induced swelling on both muscle fibres and the connective tissue network. The influence of acetic acid marinading in promoting meat tenderness is due more to its effect on the behaviour of the muscle fibres during cooking than to its effect on the connective tissue network of different muscles.     

Modelling the effect of sarcomere length on collagen thermal shortening in cooked meat: consequence on meat toughness

Normal and contracted pieces of Semimembranosus and Longissimus Dorsi muscles from cull cows were cooked for 90 min at temperatures up to 80°C. For both muscles, at 50°C the normal samples have higher breaking stress than contracted samples. The breaking stress of normal samples decreases at 55°C. This decrease is not observed for contracted samples. The contracted samples become the tougher above 60°C. Drip and cooking losses are the highest in contracted samples. Sarcomere length decreases above 60°C whatever the raw sarcomere length. The amplitude of thermal shortening of perimysium collagen fibres in cooked meat has been calculated. This theoretical model takes into account the changes in the waviness of collagen fibres associated with changes in raw sarcomere length and the geometrical changes of fibre bundles due to drip, cooking losses and cooking shortening. The calculations lead to the conclusion that thermal shortening of collagen fibres at 60°C is lower in contracted samples than in normal samples. As the final modulus of collagen fibres decreases when their thermal shortening increases, this can explain part of the differences observed between the toughness of normal and contracted cooked meats. In particular, it can explain why contracted cooked meat becomes tougher than normal meat just above 60°C and why there is a decrease in normal meat toughness between 55 and 60°C. This work therefore emphasises the role of collagen in toughening associated with cold shortening.     

DIMENSIONAL CHANGES IN MEAT DURING COOKING

Continuous measurements of changes in meat fiber length with increasing temperature during cooking showed three zones where rates of length change are significantly different. The first (> 40°C) is attributed to myofibrillar change. The second (> 55 °C) is thought to be related to connective tissue shrinkage and shows differences with myofibrillar contraction state attributable to changes in spatial orientation of collagen fibers. The third zone (> 70 °C) is believed to be due to the interaction between myofibrillar and connective tissue contraction. Measurements of changes in cooking loss, length and cross-sectional area of samples of contracted and stretched muscle showed that cooking losses and the decrease in the cross-sectional area were greater in contracted samples, whilst length changes were greater in stretched samples. This has been attributed to differences in spatial orientation of connective tissue.     

Effects of massaging on hardness, rheological properties, and structure of four wild boar muscles of different fibre type content and age

Histochemistry (percentage number of three type fibres and their cross-sectional area) and changes in hardness, rheological properties (elastic and viscous moduli), and structural elements (mean fibre cross-sectional area and thickness of endomysium) of four wild boar muscles of different ages: biceps femoris (BF), semimembranosus (SM), quadriceps femoris (QF), and longissimus (L) subjected to effective massaging for 1, 2, 3, and 4 h were evaluated.

BF, with the high percentage of type I fibres, higher mean fibre cross-sectional area, thicker endomysium as compared with QF, SM and L, was harder, more elastic, and more viscous than the other three muscles. Muscles of older boars were found to contain higher percentages of type I fibres, lower percentages of type IIB fibres, bigger muscle fibre cross-sectional areas, thicker endomysium and higher values of hardness than the same muscles of young boars, whereas the percentage of type IIA fibres was about the same in the muscles of both groups. No effect of age on rheological properties was found. Muscle massaging resulted in an increase in the mean fibre cross-sectional area, changes in thickness of the endomysium, reduction in hardness and viscous moduli as well as in the elastic moduli of the muscles studied.

The lower the initial values of textural and structural parameters and percentage of type I fibres of a muscle were, the higher was the muscles susceptibility to massage. BF compared to SM, QF and L, of all the older boar muscles tested compared to those obtained from young boars were less susceptible to mechanical tenderization.     

Ice morphology in frozen beef

A histological study was made of pieces of meat which had been frozen from one side, in conditions where the direction of the heat flux was approximately unidirectional and perpendicular to the muscle fibres. The morphology of the ice crystals in tissue frozen under various conditions was studied, and the range of freezing velocities over which no intracellular ice existed, was established. The average diameter D , of ice crystals, measured in different experiments and at different levels in the same piece of meat was related to the characteristic freezing time t _c, by the equation:
D = a + b log t _c     

Tensile strength of heat-coagulated myosin fibres

Myosin fibres, formed by heat-coagulation under conditions of pH and ionic strength similar to those prevailing in post-rigor meat, exhibited tensile strengths which decreased with fibre diameter. Tensile strengths of the smaller diameter fibres (10-100 μm) ranged from 30 to 3 kg/cm(2). These values resemble breaking strengths reported for cooked meat (e.g. Davey & Gilbert, 1977) but are an order of magnitude higher than strengths reported for heat-set myosin gels (Nakayama & Sato, 1971) and myosin-bonded meat pieces (Macfarlane et al., 1977).     

Composition of muscle fibre types and connective tissue in bovine M. semitendinosus and its relation to tenderness

The distribution of muscle fibre types and connective tissue in bovine M. semitendinosus is described. A parallel increase in the volume fraction of type I muscle fibres (from 10% to 30%) and a decrease in the IIB volume fraction (from 58% to 34%) was recorded from superficial to deep layers. A positive correlation was observed between the frequency and the cross-sectional area of both type I and IIB fibres. The elastic fibres formed irregularly shaped bundles that made up about 50% of the volume of the perimysium. Thin elastic fibres extended into the endomysium. The relative proportion of elastic fibres in the perimysial connective tissue increased towards the deeper layers of the muscle. A taste panel evaluation of the sensory properties was performed and the data were correlated to the histological observations. A gradual decrease in scores of four tenderness-related traits was recorded from the superficial to the deep layer of the muscle. The superficial layer was rated as most tender, whereas the consecutive layers were rated less tender. The possible relationship between the composition of muscle and the meat quality is discussed.     

The effect of conditioning on the strength of perimysial connective tissue dissected from cooked meat

Tensile tests were carried out on ribbons of perimysial connective tissue dissected from slices of bovine semitendinosus muscles that had been conditioned or not conditioned and then cooked to a range of temperatures. A consistent reduction in the strength of the perimysia was seen in the conditioned samples, both in the raw meat and meat cooked to 50°C. At higher cooking temperatures (60-80°C), no effect of conditioning was seen. The content of collagen or total protein of mechanically extracted perimysia and the collagen content of the test pieces from conditioned and unconditioned muscles was not significantly different. It was concluded that conditioning decreases the breaking strength of the perimysial connective tissue in raw meat or in meat which is subsequently cooked to 50°C, but not in meat cooked to the temperatures normally employed by consumers. The tenderization observed in conditioned meat cooked to 60°C and above is, therefore, due to the weakening of muscle fibres within the fibre bundles.     

26—STRUCTURAL AND NON-STRUCTURAL EFFECTS IN THE OBSERVED STRESS-STRAIN CURVE FOR WET WOOL FIBRES

This paper describes a detailed theoretical and experimental investigation into the relationship between wool-fibre non-uniformities and stress-strain behaviour. The shape of the stress-strain curve in the yield region is closely related to the fibre cumulative cross-sectional-area distribution. The fibre-material yield slope is found to be nearly zero, and the changes from Hookean to yield region and from yield to post-yield region for the material are quite sharp. The observed relative yield slope (relative to the stress at 15% extension) and the coefficient of variation of area interact in the manner predicted except that there are quantitative differences between the experimentally and theoretically derived relationships; these deviations are interpreted as structural effects due to fluctuations in the stress at 15% extension along the fibres, a variation that is relatively independent of the changes in cross-sectional area along the fibres. The mean effective coefficient of variation of area due to this structural variation is found to be of the same magnitude as the mean coefficient of variation of area for the wool-fibre types examined.

Previous results relating crimp to the cross-sectional area and the Hookean slope are confirmed; within the fibre groups, thicker fibres have a higher crimp level and a lower relative Hookean slope (relative to the stress at 15% extension), whereas between groups the thicker fibres have a lower crimp level and a higher relative Hookean slope than thinner fibres. The stress at 15% extension is significantly different for the different wool-fibre types, which indicates real structural differences between the fibre types. As the fibre mean cross-sectional area increases, the fibres show a tendency to be structurally ‘stronger’, the magnitude of this effect agreeing with values obtained by other investigators. Thinner fibres, as well as being structurally ‘weaker’, tend to be more variable in cross-sectional area and less elliptical in cross-section.     

Relationships of myosin heavy chain fibre types to meat quality traits in traditional and modern pigs

Porcine skeletal muscle fibres were molecularly classified, using in situ hybridisation and immunocytochemistry, into four types, according to the isoform of myosin heavy chain (MyHC) that was present in each fibre (MyHC slow/I, MyHC 2a, MyHC 2x and MyHC 2b). The relationship between MyHC fibre types and meat quality traits between two phenotypically divergent muscles [longissimus dorsi (LD) and psoas], and between the same muscles of different breeds (traditional Berkshire and Tamworth, and modern Duroc-based and Large White-based) were examined. We found that the greater abundance of fast oxidative-glycolytic MyHC 2a and 2x fibres in the psoas was associated with superior meat quality traits, and that the greater presence of fast glycolytic MyHC 2b fibres in the LD could account for less favourable quality traits, both in terms of pH, drip loss, grain, colour, yield force and work done. Although significant correlations were found between specific fibre types and quality traits, within either the psoas or LD muscle of some breeds, no consistent correlation was found across both muscles and all breeds. This finding was in line with the view that a given fibre type could have considerable differences in phenotype between breeds, and between muscles. The observed inverse compositional and functional-meat quality relationship between MyHC 2b and 2x fibres, and MyHC 2b and 2a fibres could form a basis of fibre type manipulation to improve meat quality.     

Carcass and meat quality traits of four different pig crosses

The study compared properties of Finnish Landrace × Yorkshire crossbred sows mated with Finnish Landrace (FL), Norwegian Landrace (NL), Norwegian Duroc × Norwegian Landrace (NDL), or Swedish Hampshire (SH) boars. The focus was to study the cross-sectional area of loin, cross-sectional area and number of muscle fibres, loin colour and pH value as well as the ratio of water to protein in the loin.The four studied crosses were quite similar having only small differences in carcass and meat quality. The carcass lean content was the lowest in NDL. The loins of FL and NL were longer than the loins of NDL and of SH. The cross-sectional area of loin was the largest in SH. The loin of FL was lighter in colour and the loin of SH was redder than the loins of the other crosses studied. The protein content was lower and the ratio of water to protein higher in loin of SH than in the other crosses.     

Effects of wearing knitted or rubber gloves on the transfer of Escherichia cohi between hands and meat

On eight occasions, five volunteers each handled five pieces of meat with bare hands or while wearing dry or wet knitted gloves or rubber gloves after hands had been inoculated with Escherichia coli or after handling a piece of meat inoculated with E. coli. On each occasion, after all meat was handled, each piece of meat, glove, and hand were sampled to recover E. coli. When hands were inoculated, E. coli was recovered from all meat handled with bare hands, in lesser numbers from some pieces handled with knitted gloves, and from only one piece handled with rubber gloves. When pieces of inoculated meat were handled, the numbers of E. coli transferred to uninoculated meat from bare hands or rubber gloves decreased substantially with each successive piece of uninoculated meat, but decreases were small with knitted gloves. The findings indicate that, compared with bare hands, the use of knitted gloves could reduce the transfer of bacteria from hands to meat but could increase the transfer of bacteria between meat pieces, whereas the use of rubber gloves could largely prevent the first and greatly reduce the second type of bacteria transfer.     

FIBRE FRACTURE OF BOVINE M. PECTORALIS PROFUNDUS MUSCLE COOKED PRE- AND POSTRIGOR

The ultimate tensile strength and extensibility in the direction of the muscle fibres of cooked meat decreased exponentially during storage of the raw meat for up to 3 days at 15C. The mode of fracture was examined by light microscopy of longitudinal sections taken after testing to break. In meat cooked soon after stunning, 'brittle' fracture had been induced across the fibres and the high extensibility was proposed to be due to sequential fibre fracture. At 1 day postmortem, the fractures crossed several fibres occurring in a repetitive fashion every 30 μm along the fibres. This was thought to be due to a stiff fibre embedded in an extensible surface matrix connecting the fibres. In aged meat, discontinuous fractures were prominent within each fibre and which stopped at the surface of each fibre showing further weakening of the fibre and the composite matrix. All the myofibrils remained in register. These changes are consistent with a gradual reduction in cohesion within the meat and indicates that the weakening of the focal adhesions is primarily responsible for postmortem tenderisation.     

Effects of fibre type and kefir, wine lemon, and pineapple marinades on texture and sensory properties of wild boar and deer longissimus muscle

Fibre type percentage and changes in textural parameters, sensory properties as well as mean fibre cross sectional area (CSA), fibre shape, endomysium and perimysium thickness of wild boar and deer longissimus (L) muscle subjected to ageing with kefir, dry red wine, lemon and pineapple juice marinades for 4days were studied. Among the non-marinated and non-aged samples of muscles it was found that wild boar meat with its higher percentage of red fibres, higher CSA, thicker connective tissue as compared with deer meat, was harder, more springy and stringy. Muscles ageing, regardless of methods, resulted in a decrease in both the CSA and thickness of the connective tissue, and improve in fibre shape. As a consequence ageing caused a reduction in hardness, cohesiveness, springiness, and stringiness as well as in augmentation of tenderness, juiciness and general attractiveness of the muscles studied. As demonstrated by obtained data, regardless of ageing methods, deer L muscle contained more white fibres compared to wild boar muscle, were more susceptible to tenderization. The highest structural and textural changes, but the worst general attractiveness was found in muscles marinated with pineapple juice addition. Insignificantly lower changes in both quality traits were found in muscles aged with kefir marinade which at the same time were characterized by the high tenderness, the highest juiciness and general attractiveness.