首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到20条相似文献,搜索用时 359 毫秒
1.
研究了合金元素对双相不锈钢2101耐点蚀性能的影响规律。结果显示,2101系列合金的浸泡点蚀腐蚀速率在1.9~7.0 g/(m^2.h)之间,与304不锈钢在同一数量级;Mo是提高2101系双相不锈钢耐腐蚀性的关键元素,而N对耐腐蚀性的影响不大;点蚀起源和Thermo-Calc计算结果显示2101成分体系中,铁素体相是耐点蚀性较弱相,提高铁素体相耐蚀性是提高合金整体耐蚀性的关键;当Cr含量固定在21.5%时,Mo作为铁素体形成元素将在铁素体相中富集,提高铁素体相的耐点蚀性能,从而提高合金整体耐蚀性。  相似文献   

2.
利用Thermo-Calc热力学计算软件得到S32760(022Cr25Ni7Mo3WCuN)超级双相不锈钢凝固过程中的相图,确定了S32760双相钢是FA (铁素体-奥氏体)凝固模式,通过改变奥氏体和铁素体的形成元素的含量,确定在不同的化学成分下的热加工性能、Cr2N和σ相析出温度,得到S32760双相钢热加工温度区间随着奥氏体形成元素C、N、Ni、Mn含量的增加而变大,随着铁素体形成元素Si、Cr、Mo含量的增加而减小,而W对热加工性能没有影响。根据热力学计算,确定了最优的化学成分(/%:0.022C,0.30Si,0.80Mn,25.60Cr,6.20Ni,0.54Cu,3.50Mo,0.54W,0.27N),S32760双相钢最佳热塑性温度为1195℃, Cr2N相的析出温度为1050℃, σ相析出温度为1020℃,热加工区间为145℃,并且通过了后续的现场实践验证。  相似文献   

3.
苗华军 《特殊钢》2021,42(5):81-84
采用扫描电镜和X射线能谱仪研究了00Cr29Ni6Mo2N超级双相不锈钢1080℃30 min固溶+650~1000℃60 min时效后的显微组织.试验结果表明,在奥氏体和铁素体相界面上析出了Cr2N和σ相两种析出相,同时发现少量的Cr2N在铁素体相内.Cr2N析出优先于σ相,增加时效温度和时间对Cr2N的析出量没有显...  相似文献   

4.
摘要:采用光学显微镜、扫描电镜、透射电镜、弯曲共振试验机和万能材料试验机等分析了复合添加质量分数0.8%Ni元素和0.1%Nb元素的Fe-Cr-Mo合金组织和析出相的大小、形态,研究了Ni和Nb元素的添加对Fe-Cr-Mo合金力学性能和阻尼性能的影响。结果表明,Ni和Nb元素的加入不但使合金晶粒显著细化,而且有效抑制了富Cr析出物的析出,使析出物明显细化且分布弥散。晶粒和析出物的细化同时提高了合金的强度和塑韧性,尤其是显著地提高了材料的塑性。1000和1100℃退火后,Ni和Nb元素的加入将提高减振合金的矫顽力,降低磁致伸缩系数,使减振合金的阻尼性能降低。900℃退火后,Ni和Nb元素的添加虽然提高了合金的矫顽力,但由于Mo元素的回溶使磁致伸缩系数增大,阻尼性能获得提高。  相似文献   

5.
采用光学显微镜、扫描电镜、透射电镜、弯曲共振试验机和万能材料试验机等分析了复合添加质量分数0.8%Ni元素和0.1%Nb元素的Fe-Cr-Mo合金组织和析出相的大小、形态,研究了Ni和Nb元素的添加对FeCr-Mo合金力学性能和阻尼性能的影响。结果表明,Ni和Nb元素的加入不但使合金晶粒显著细化,而且有效抑制了富Cr析出物的析出,使析出物明显细化且分布弥散。晶粒和析出物的细化同时提高了合金的强度和塑韧性,尤其是显著地提高了材料的塑性。1 000和1 100℃退火后,Ni和Nb元素的加入将提高减振合金的矫顽力,降低磁致伸缩系数,使减振合金的阻尼性能降低。900℃退火后,Ni和Nb元素的添加虽然提高了合金的矫顽力,但由于Mo元素的回溶使磁致伸缩系数增大,阻尼性能获得提高。  相似文献   

6.
周保仓 《不锈》2005,(2):21-24
20世纪70年代,开发研制的最通用的双相不锈钢称之为2205的22Cr合金。2205双相不锈钢大约含22%Cr,5%Ni,3%Mo和0.16%N。在进行适当的退火后,双相不锈钢的显微组织由大致50%的铁素体和50%的奥氏体组成。这种显微组织使这种钢在许多用途中不仅在强度,而且在耐腐蚀方面优于传统的奥氏体不锈钢。但是,  相似文献   

7.
本文介绍了热处理工艺对超级双相不锈钢00Cr25Ni7Mo4N中两相的比例有影响,进而对该钢的耐腐蚀性能也造成影响的试验分析情况。试验结果表明,超级双相不锈钢00Cr25Ni7Mo4N中奥氏体和铁素体两相比例可因热处理工艺不同而差别较大,表现在耐腐蚀性能上也出现较大的不同。  相似文献   

8.
利用磁致伸缩空蚀试验机对Cr32Ni7Mo3N特级双相不锈钢在蒸馏水和人工海水中进行了空蚀实验,并采用扫描电镜跟踪观察了经不同时间段空蚀后试样的形貌.通过测量失重绘制了材料的累积失重量和失重率曲线.经电化学工作站测量了材料在静态与空蚀条件下的极化曲线和腐蚀电位变化.对比分析了Cr32Ni7Mo3N与SAF2205双相不锈钢在人工海水的抗空蚀能力.结果表明:Cr32Ni7Mo3N特级双相不锈钢空蚀破坏首先在铁素体薄弱区以及铁素体和奥氏体相界发生,并向铁素体内扩展,铁素体发生解离断裂脱落;奥氏体随着空蚀的进行,滑移线增多,显微硬度值增加,且人工海水中奥氏体显微硬度值比在蒸馏水中的高;铁素体大面积破坏后,奥氏体才失稳产生延性断裂脱落,奥氏体的存在延缓了破坏在整个材料表面上的扩展.空蚀与腐蚀交互影响导致材料在人工海水中加速破坏.Cr32Ni7Mo3N特级双相不锈钢在人工海水中的抗空蚀能力优于SAF2205双相不锈钢.   相似文献   

9.
本文通过XRD、扫描电镜和能谱研究了00Cr25Ni7Mo4N超级双相不锈钢在1200℃和1320℃不同热处理制度状态下的组织结构及α和γ两相中的主要化学成分含量。实验发现,在1200℃和1320℃附近00Cr25Ni7Mo4N超级双相不锈钢内无新相产生,随处理温度升高,00Cr25Ni7Mo4N超级双相不锈钢α相含量增加,α相和γ相中的Cr、Mo、Si、Ni含量相差越来越小,而Mn元素在α相和γ相中含量趋于一致。  相似文献   

10.
 通过Gleeble 1500D热模拟试验机高温拉伸试验,对比研究了17Cr2Ni2MoVNb和17Cr2Ni2Mo钢的高温性能。结果表明:因微合金元素V(0.1%,质量分数,下同)、Nb(0.036%)产生细晶强化及固溶强化,17Cr2Ni2MoVNb 钢的抗拉强度比17Cr2Ni2Mo钢稍高。在低N(0.0057%)含量的17Cr2Ni2MoVNb钢中,V和Nb对热塑性的危害很小。而高N(0.0130%)含量的17Cr2Ni2Mo钢在600~900 ℃及1050~1200 ℃温度区间塑性低于17Cr2Ni2MoVNb钢。N含量及相变温度不同导致第二期AlN析出量不同及铁素体先后析出,是造成两试验钢塑性差别的主要原因。  相似文献   

11.
转炉炉壳热应力分析   总被引:5,自引:1,他引:4  
任学平  郭志强  邹家祥 《炼钢》2001,17(6):47-49
根据实际转炉建立实体模型。以有限元为手段,考虑了炉衬和炉壳材料的物性参数随温度变化的特点和炉衬与炉壳之间膨胀间隙,计算了转炉炉壳在温度载荷和炉衬膨胀压力同时作用下的热应力。所得结果可为转炉炉壳设计提供依据。  相似文献   

12.
13.
通过对焦炭在高炉内的历程及其变化规律的剖析,阐述焦炭热性能指标的意义,形象地把焦炭在高炉内的损耗分为三部分(M1,M2,M3)。指出M2对焦比及焦炭价格有一定的指导作用。  相似文献   

14.
Cancer of the cardia is traditionally discussed with cardiac cancer of the lower portion of the esophagus and upper gastric cancer invading the esophagus, and the specific characteristics of cancer of the cardia have never been clearly defined. We reviewed the outcome of 172 patients with adenocarcinoma of the cardia who had undergone radical surgery between 1949 and 1994 in the Division of Gastrointestinal Surgery of the Cancer Institute Hospital. The centers of the tumors were located within 2 cm above and below the boundary between the esophagus and the stomach, and their longitudinal diameter was less than 8 cm. We divided the patients into an early period (1949-1979; n = 79) and a late period (1980-1994; n = 93), and focused on the historical transition. There were no differences in patient gender or histology between the two periods. However, the late period was associated with fewer cases of esophageal invasion and shorter longitudinal diameter, as the age of the population advanced. The number of advanced cancers such as the localized and infiltrative type had decreased, and early cancer and early clinical stage had become more common, but despite the fact that the number of early cancers had increased, extended dissection, such as thoracic and paraaortic lymph node dissection, was performed more frequently. By clinical stage, the long-term outcome markedly improved in Stage I patient in the late period, and tended to improve in Stage II and III patients. This appears to have been attributable to the prevention of micrometastasis by extended dissection, although the number of early cancers is another major potential cause. There were no differences in the outcome of Stage IV patients between the two periods, and further advances in multimodality therapy must be awaited. The range of resection is basically proximal gastrectomy, and if there are adequate indications, the prognosis is favorable. In view of the status of lymphatic flow and lymph node metastasis, and long-term results, lateroaortic lymph node dissection is important. Since the number of early cancer patients has been increasing, if intraabdominal recurrence is prevented, intrathoracic lymph node dissection will contribute greatly to the outcome of such patients.  相似文献   

15.
16.
Some theories of personality hold that an individual's perception of others is influenced by his own personality characteristics; more specifically, that a trait of low social value will be projected more into others, and that insight into the possession of these characteristics reduces this distortion. These 2 hypotheses were tested by having a group of college students rate each other (including themselves) on degree of friendliness or hostility. Agreement with group rating about self yielded the insight score. In general, the hypotheses were supported; the "friendly" Ss were most accurate in their perception of others, and insight was positively associated with accurate perception. From Psyc Abstracts 36:04:4HL16M. (PsycINFO Database Record (c) 2010 APA, all rights reserved)  相似文献   

17.
The effect of 20 different antibiotics on chemotaxis by human neutrophils was studied. Human leukocytes incubated with chloramphenicol, rifampin, sodium fusidate, and tetracyclines in vitro showed markedly depressed migration. The mechanisms by which these antibiotics affect leukotaxis are discussed.  相似文献   

18.
Usage of quality of life of psychiatric patients' relatives as the parameter of estimation of the quality of psychiatric care is considered. By means of standard questionnaire elaborated by the authors as well as by means of both individual and group conversations the quality of life was analyzed in 40 relatives which lived together with psychiatric patients. Different spheres of their life and difficulties (financial, social-psychologic, production) were examined in families with such patients. The defects of psychiatric care that had direct influence on the quality of life of the psychiatric patients' relatives are outlined.  相似文献   

19.
20.
设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号