Thermal inactivation kinetics of Shiga toxin-producing Escherichia coli in buffalo Mozzarella curd

The use of raw milk in the processing of buffalo Mozzarella cheese is permitted, but the heat treatment used for stretching the curd must ensure that the final product does not contain pathogens such as Shiga toxin-producing Escherichia coli (STEC) that may be present on buffalo dairy farms. This study carried out challenge tests at temperatures between 68°C and 80°C for 2 to 10 min to simulate curd temperatures during the stretching phase. Curd samples were inoculated with 2 STEC strains (serotypes O157 and O26), and their inactivation rates were assessed in the different challenge tests. The curd samples were digested with papain to ensure a homogeneous dispersion of bacteria. The STEC cells were counted after inoculation (range 7.1–8.7 log cfu/g) and after heat treatments using the most probable number (MPN) technique. A plot of log MPN/g versus time was created for each separate experiment. The log linear model with tail was used to provide a reasonable fit to observed data. Maximum inactivation rate (k_max, min⁻¹), residual population (log MPN/g), decimal reduction time (min), and time for a 4D (4-log₁₀) reduction (min) were estimated at each temperature tested. A 4D reduction of the O26 STEC strain was achieved when curd was heated at 68°C for 2.6 to 6.3 min or at 80°C for 2.1 to 2.3 min. Greater resistance was observed for the O157 strain at 68°C because k_max was 1.48 min⁻¹. The model estimates can support cheesemakers in defining appropriate process criteria needed to control possible STEC contamination in raw milk intended for the production of Mozzarella.     

Combining ultraviolet light and mild temperatures for the inactivation of Escherichia coli in orange juice

It is difficult to guarantee the effectiveness of UV technology to reach 5 Log₁₀ cycles of inactivation of Escherichia coli in a large amount of fruit juices with high absorption coefficients and turbidities, such as orange juice. The aim of this work was to overcome this limitation by combining UV light and mild temperatures. UV treatments were carried out in an equipment with eight individual annular thin film flow-through reactors connected sequentially and submerged in a thermostatic water bath. A treatment of 13.55 J/mL reached 0.25 ± 0.04, 0.41 ± 0.13, 0.84 ± 0.32, 0.96 ± 0.12, 2.57 ± 0.05, 5.41 ± 0.23, and more than 6 Log₁₀ cycles of inactivation of E. coli STCC 4201 suspended in commercial sterilized orange juice at 25.0, 40.0, 50.0, 52.5, 55.0, 57.5, and 60.0 °C, respectively. The comparison of UV resistance at 25 °C with heat resistance at mild temperatures demonstrated a synergistic effect of both technologies applied simultaneously. The maximum synergistic lethal effect was reached at 55 °C (68.03%).     

Survival of Escherichia coli O157:H7 and non-pathogenic E. coli on irradiated and non-irradiated beef surfaces

This study examined changes in numbers of pathogenic (PEC) and non-pathogenic (NPEC) Escherichia coli during storage at 10 °C on the surfaces of irradiated (IR) and non-irradiated (NIR) meat pieces excised from the neck, brisket and rump of beef carcasses and in Brain Heart Infusion Broth (BHI) and Maximum Recovery Diluent (MRD). On irradiated meat pieces, there were significant differences between mean PEC and NPEC counts at all sites. Differences in counts were also observed between IR and NIR surfaces and among the three meat sites for both E. coli types. These differences occurred only on IR samples, suggesting that the irradiation associated reductions in normal beef surface flora influenced survival of both E. coli types. PEC and NPEC counts increased during storage in BHI, but only NPEC counts increased in MRD. The results of this study highlight the impact of meat surface type and the presence/absence of the normal beef carcass surface flora on E. coli survival and/or growth during meat storage. Such previously unreported effects, and their precise mechanisms, have direct implications in the development and application of accurate models for the prediction of the safety and shelf life of stored meat.     

Lactic acid resistance of Shiga toxin-producing Escherichia coli and multidrug-resistant and susceptible Salmonella Typhimurium and Salmonella Newport in meat homogenate

This study compared lactic acid resistance of individual strains of wild-type and rifampicin-resistant non-O157 Shiga toxin-producing Escherichia coli (STEC) and of susceptible and multidrug-resistant (MDR) and/or MDR with acquired ampC gene (MDR-AmpC) Salmonella against E. coli O157:H7. After inoculation of sterile 10% beef homogenate, lactic acid was added to a target concentration of 5%. Before acid addition (control), after acid addition (within 2 s, i.e. time-0), and 2, 4, 6 and 8 min after addition of acid, aliquots were removed, neutralized, and analyzed for survivors. Of wild-type and of rifampicin-resistant non-O157 STEC strains, irrespective of serogroup, 85.7% (30 out of 35 strains) and 82.9% (29 out of 35 strains), respectively, reached the detection limit within 0–6 min. Of Salmonella strains, 87.9% (29 out of 33 isolates) reached the detection limit within 0–4 min, irrespective of antibiotic resistance phenotype. Analysis of non-log-linear microbial survivor curves indicated that non-O157 STEC serogroups and MDR and susceptible Salmonella strains required less time for 4D-reduction compared to E. coli O157:H7. Overall, for nearly all strains and time intervals, individual strains of wild-type and rifampicin-resistant non-O157 STEC and Salmonella were less (P < 0.05) acid tolerant than E. coli O157:H7.     

The growth,survival and thermal inactivation of Escherichia coli O157:H7 in a traditional South African sausage

This study investigated the growth and survival of Escherichia coli O157:H7 inoculated into boerewors models with (B + P) and without (B − P) sulphur dioxide preservative at a low (L) and high (H) inoculum followed by storage at 0, 4 and 10 °C for 10 days. The pathogen’s thermal inactivation at 50, 60, 65 and 70 °C was also evaluated in B + P. The B − P at both low and high inocula had significantly higher recoveries at all temperatures compared to B + P. The BL + P and BH + P had significant reductions in recoveries at 0 °C, declining to below detectable limits at days 8 and 10, respectively. At 4 °C, the BL + P and BH + P recoveries declined significantly at day 10. At 10 °C, significant increases were observed from days 0 to day 10 in both models and at low and high inocula. At 0 °C, the BL − P and BH − P treatments had significant declines in recoveries. The combination of sulphur dioxide preservative and low temperature demonstrated the best efficacy against E. coli O157:H7 survival. Thermal inactivation of E. coli O157:H7 was 60 min at 60 °C, 80 s at 65 °C and 60 s at 70 °C. This study demonstrated that E. coli O157:H7 can survive in boerewors with and without preservative and is more sensitive to heat treatment at 70 °C.     

Application of caffeine, 1,3,7-trimethylxanthine,to control Escherichia coli O157:H7

The objective of this research was to determine the effectiveness of caffeine on inactivation of Escherichia coli O157:H7 in brain heart infusion (BHI) broth. Overnight samples of five E. coli O157:H7 strains of (E0019, F4546, H1730, 944 and Cider) were used in this study. These strains were individually inoculated at an initial inoculum level of 2 log CFU/ml into BHI broth containing caffeine at different concentrations (0.00%, 0.25%, 0.50%, 0.75%, 1.00%, 1.25%, 1.50%, 1.75%, and 2.00%). Samples were then incubated at 37 °C for 24 h. Bacterial growth was monitored at different time intervals by measuring turbidity at 610 nm using a spectrophotometer. Results revealed that the addition of caffeine inhibited the growth of E. coli O157:H7. Significant growth inhibition was observed with concentration levels of 0.50% and higher. These results indicate that caffeine has potential as an antimicrobial agent for the treatment of E. coli O157:H7 infection and should be investigated further as a food additive to increase biosafety of consumable food products.     

Inhibition of polymerase chain reaction for the detection of Escherichia coli O157:H7 and Salmonella enterica on walnut kernels

The aim of this study was to determine whether Escherichia coli O157:H7 can be reliably detected and isolated from walnut kernels using standard methods of analysis. The limit of detection approached 1 cell per analytical unit (25 g) for E. coli O157:H7 on walnut kernels enriched in modified tryptic soy broth with 20 μg/ml novobiocin and plating onto selective agar media. The presence of PCR inhibitors in walnut kernels was indicated by the failure to detect E. coli O157:H7 from culture positive enrichment broths analysed by PCR, with two separate polymerase and reagent compositions (Dupont BAX E. coli O157:H7 MP system, Promega GoTaq Green for stx) and three methods of template preparation (DuPont BAX, Qiagen DNeasy, Bio-Rad InstaGene). PCR inhibition was overcome by 1:100 dilution in TE buffer of the DNeasy or InstaGene template. PCR inhibition was not relieved by dilution of the BAX template. Similar results were observed for walnut kernels inoculated with Salmonella enterica and analysed for invA, indicating that PCR inhibition is not specific to the organism or primer/template. These results indicate that analysis of walnut kernels for pathogens should be with culture based methods or use protocols for DNA template preparation modified to remove or dilute inhibitors and the need for internal amplification controls in PCR methods.     

Antimicrobial activity of lactic acid and copper on growth of Salmonella and Escherichia coli O157:H7 in laboratory medium and carrot juice

Outbreaks of food-borne pathogens, such as Escherichia coli O157:H7 and Salmonella, continue to draw public attention to food safety. Several reports have demonstrated the efficacy of using natural ingredients to control the growth of food-borne pathogens. The objective of this study was to investigate antimicrobial effects of lactic acid and copper, alone and in combination, on the survival and growth of Salmonella spp. and E. coli O157:H7 in laboratory medium and carrot juice. Survival and growth of 38 Salmonella spp. and six E. coli O157:H7 strains were compared when grown in brain heart infusion (BHI) broth and carrot juice under conditions including either lactic acid (0.2%) alone, copper sulfate (50 ppm) alone or the combination of the two. The growth inhibition was negligible when copper sulfate was added to BHI broth and carrot juice. Lactic acid (0.2%) retarded the growth of bacterial strains. However, the growth of bacterial strains was significantly inhibited when both lactic acid and copper were in BHI broth and carrot juice within the time frame of this study. These findings indicated that lactic acid, in combination with copper sulfate, could be used to inhibit the growth of pathogens. Natural ingredients, such as lactic acid and low dose of copper ions, can be used to improve the safety of food products.     

Effects of different sanitizing treatments on biofilms and attachment of Escherichia coli and Listeria monocytogenes on green leaf lettuce

The effects of ozone (2 mg/L), chlorine (100 mg/L) and organic acid (0.25 g/100 g citric acid plus 0.50 g/100 g ascorbic acid) treatments at 10 °C for 2 min on the removal of Escherichia coli and Listeria monocytogenes cells embedded inside biofilms on the surface of lettuce leaves were studied. None of the sanitizing treatments were found effective in removing the bacterial biofilms. Initiation of biofilms was observed after 24 h of incubation. Bacterial cells appeared as individual cells, rather than clusters after 6 h incubation, thus 99.9% reductions in both E. coli and L. monocytogenes counts were achieved with all the three treatments. However, after 48 h incubation, none of the treatments resulted in higher than 90% reduction in microbial counts. Biofilm formation was demonstrated for the 48 h incubated samples with SEM images.     

Fate of Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella on fresh-cut celery

Illnesses from Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella have been associated with the consumption of numerous produce items. Little is known about the effect of consumer handling practices on the fate of these pathogens on celery. The objective of this study was to determine pathogen behavior at different temperatures under different storage conditions. Commercial fresh-cut celery was inoculated at ca. 3 log CFU/g onto either freshly cut or outer uncut surfaces and stored in either sealed polyethylene bags or closed containers. Samples were enumerated following storage for 0, 1, 3, 5, and 7 days when held at 4 °C or 12 °C, and after 0, 8, and 17 h, and 1, and 2 days when held at 22 °C. At 4 °C, all populations declined by 0.5–1.0 log CFU/g over 7 days. At 12 °C, E. coli O157:H7 and Salmonella populations did not change, while L. monocytogenes populations increased by ca. 0.5 log CFU/g over 7 days. At 22 °C, E. coli O157:H7, Salmonella, and L. monocytogenes populations increased by ca. 1, 2, or 0.3 log CFU/g, respectively, with the majority of growth occurring during the first 17 h. On occasion, populations on cut surfaces were significantly higher than those on uncut surfaces. Results indicate that populations are reduced under refrigeration, but survive and may grow at elevated temperatures.     

Efficacy of enrofloxacin in the treatment of naturally occurring acute clinical Escherichia coli mastitis

The efficacy of the combination of systemic enrofloxacin (5 mg/kg twice with a 24-h interval, first dose i.v., second dose s.c.) and the nonsteroidal antiinflammatory agent ketoprofen (3 mg/kg i.m. or 4 mg/kg per os daily for 1 to 3 d) treatment was compared with antiinflammatory treatment only in dairy cows with naturally occurring acute clinical Escherichia coli mastitis. A total of 132 cows with acute clinical mastitis and with confirmed growth of E. coli in a pretreatment milk sample were randomly allocated to 1 of 2 treatment groups. Response to treatment was evaluated clinically and by bacteriological culturing and determination of N-acetyl-β-d-glucosaminidase (NAGase) activity on d 2 and 21 posttreatment. Enrofloxacin treatment did not increase bacteriological (90.5% of treated vs. 86.8% of nontreated cured) or clinical cure (46.7% of treated vs. 57.1% of nontreated cured), cow survival (95.3% of treated vs. 92.7% of nontreated), or quarter milk production assessed 21 d posttreatment (21.8 vs. 29.3% return to preinfection level for nontreated cows), nor did it decrease mammary gland tissue damage estimated using determination of milk NAGase activity (24.0 ± 0.3 vs. 18.3 ± 1.3 pmol of 4-methylumbelliferone per min per μL for nontreated cows). Treatment did not influence the number of study cows remaining in the herd after 6 mo (71.9% of treated vs. 80.6% of nontreated). The only significant effects of enrofloxacin were enhancing the bacteriological cure (odds ratio = 3.32 for treated cows) and decreasing the clinical cure (odds ratio = 0.05 for treated cows) on d 2 posttreatment. Our results did not support the use of enrofloxacin to treat acute clinical E. coli mastitis.     

Adhesion of enterotoxigenic Escherichia coli strains to neoglycans synthesised with prebiotic galactooligosaccharides

Enterotoxigenic (ETEC) Escherichia coli (E. coli) causes traveller’s diarrhoea and high mortality among baby animals. ETEC adhesion is mediated by lectins (adhesins) that bind to glycoconjugates on the surface of host cells. Glycans that compete for adhesion could be used for disease prevention. Neoglycans of porcine albumin (PSA) that were conjugated with prebiotic galactooligosaccharides (GOS) were synthesised using the Maillard reaction. PSA glycation was confirmed by a reduction in the number of available free amino groups, decreased tryptophan intrinsic fluorescence, increased molecular mass and Ricinus communis lectin recognition. The adhesion of four ETEC strains (E. coli H10407, CFA⁺, K99 and K88) to PSA–GOS was examined by an enzyme-linked lectin assay. E. coli K88 bound to PSA–GOS with greater affinity (P < 0.05) than did E. coli H10407, CFA⁺ and K99. In addition, PSA–GOS partially inhibited the adherence of the K88 strain to intestinal mucins. Pig ETEC strain was unable to ferment galactooligosaccharide–neoglycans. These results suggest that neoglycans obtained by the Maillard reaction may serve in the prophylaxis of ETEC K88 diarrhoea.