Free and immobilized Lactobacillus casei ATCC 393 on whey protein as starter cultures for probiotic Feta-type cheese production

The use of free and immobilized Lactobacillus casei ATCC 393 on whey protein as starter culture in probiotic Feta-type cheese production was evaluated. The probiotic cultures resulted in significantly higher acidity; lower pH; reduced counts of coliforms, enterobacteria, and staphylococci; and improved quality characteristics compared with cheese with no culture. Microbiological and strain-specific multiplex PCR analysis showed that both free and immobilized L. casei ATCC 393 were detected in the novel products at levels required for conferring a probiotic effect at the end of the ripening. The effect of starter culture on production of volatile compounds was investigated by the solid-phase microextraction gas chromatography-mass spectrometry analysis technique. The immobilized cells resulted in an improved profile of aroma-related compounds and the overall high quality of the novel products was ascertained by the preliminary sensory test. Finally, the high added value produced by exploitation of whey, which is an extremely polluting industrial waste, was highlighted and assessed.     

Lysis of Lactobacillus casei 5Mn 373 accelerates Grana cheese ripening

The influence of the adjunct of a peptidolytic Lactobacillus casei strain on Grana cheese ripening was studied. Strain erythromycin resistance enabled the monitoring of its growth and death kinetics during cheese maturation. Cell lysis was estimated by the dosage of intracellular X-prolyl-dipeptidyl aminopetidase in cheese extracts. L. casei growth reached a maximum level after the second month of cheese ripening when the initial added cell level was 5×10⁵ cfu/g cheese, while L. casei counts decreased from the beginning of the ripening period when the initial added cell level was 4.5×10⁷ cfu/g cheese. The maximum death rate occurred two months after the maximal cell growth, and bacterial lysis was observed approximately two months later. The characteristic amino acid pattern of control Grana cheese was obtained for all of the mature experimental cheeses independently of the inoculum size, and more rapidly when higher amounts of inocula were used due to L. casei cell lysis. The adjunct of the L. casei strain to cheese-milk substantially shortened the ripening time with no negative effects on cheese-making, chemical gross composition or flavour in the mature experimental cheeses compared to the control.     

Purification and characterization of intracellular proteinase from Lactobacillus casei ssp. casei LLG

The intracellular proteinase of Lactobacillus casei ssp. casei LLG was isolated in the cytoplasmic fraction with 0.05 M Tris-HCl buffer (pH 7.5). The enzyme was purified by the fast protein liquid chromatography system equipped with ion-exchange and gel filtration chromatographies. This proteinase comprised a single monomeric form and had a molecular weight of about 55 kDa and an isoelectric point near pH 4.9. The optimum pH and temperature for the enzyme activity were determined to be pH 6.5 and 37 degrees C, respectively. The enzyme was inactivated by metal-chelating compounds (EDTA, 1,10-phenanthroline) and less affected by serine proteinase inhibitors (diisopropylfluorophosphate, phenylmethylsulfonyl fluoride). Proteinase activity was increased by Ca++, Mn++, and Co++, and inhibited by Cu++, Mg++, and Zn++. The activity of this enzyme to hydrolyze casein appeared to be more active on beta-casein than alphas1-casein and kappa-casein as monitored by polyacrylamide gel electrophoresis.     

Selective enumeration of Lactobacillus delbrueckii ssp. bulgaricus,Streptococcus thermophilus,Lactobacillus acidophilus,bifidobacteria, Lactobacillus casei,Lactobacillus rhamnosus,and propionibacteria

Nineteen bacteriological media were evaluated to assess their suitability to selectively enumerate Lactobacillus delbrueckii ssp. bulgaricus, Streptococcus thermophilus, Lactobacillus casei, Lactobacillus rhamnosus, Lactobacillus acidophilus, bifidobacteria, and propionibacteria. Bacteriological media evaluated included Streptococcus thermophilus agar, pH modified MRS agar, MRS-vancomycine agar, MRS-bile agar, MRS-NaCl agar, MRS-lithium chloride agar, MRS-NNLP (nalidixic acid, neomycin sulfate, lithium chloride and paramomycine sulfate) agar, reinforced clostridial agar, sugar-based (such as maltose, galactose, sorbitol, manitol, esculin) media, sodium lactate agar, arabinose agar, raffinose agar, xylose agar, and L. casei agar. Incubations were carried out under aerobic and anaerobic conditions at 27, 30, 37, 43, and 45 degrees C for 24, 72 h, and 7 to 9 d. S. thermophilus agar and aerobic incubation at 37 degrees C for 24 h were suitable for S. thermophilus. L. delbrueckii ssp. bulgaricus could be enumerated using MRS agar (pH 4.58 or pH 5.20) and under anaerobic incubation at 45 degrees C for 72 h. MRS-vancomycine agar and anaerobic incubation at 43 degrees C for 72 h were suitable to enumerate L. rhamnosus. MRS-vancomycine agar and anaerobic incubation at 37 degrees C for 72 h were selective for L. casei. To estimate the counts of L. casei by subtraction method, counts of L. rhamnosus on MRS-vancomycine agar at 43 degrees C for 72 h under anaerobic incubation could be subtracted from total counts of L. casei and L. rhamnosus enumerated on MRS-vancomycine agar at 37 degrees C for 72 h under anaerobic incubation. L. acidophilus could be enumerated using MRS-agar at 43 degrees C for 72 h or Basal agar-maltose agar at 43 degrees C for 72 h or BA-sorbitol agar at 37 degrees C for 72 h, under anaerobic incubation. Bifidobacteria could be enumerated on MRS-NNLP agar under anaerobic incubation at 37 degrees C for 72 h. Propionibacteria could be enumerated on sodium lactate agar under anaerobic incubation at 30 degrees C for 7 to 9 d. A subtraction method was most suitable for counting propionibacteria in the presence of other lactic acid bacteria from a product. For this method, counts of lactic bacteria at d 3 on sodium lactate agar under anaerobic incubation at 30 degrees C were subtracted from counts at d 7 of lactic bacteria and propionibacteria.     

Discrimination of dairy industry isolates of the Lactobacillus casei group

Lactobacilli are a major part of the microflora of the gut and of many fermented dairy products, and are found in a variety of environments. Lactobacillus casei, Lactobacillus paracasei, Lactobacillus rhamnosus, and Lactobacillus zeae form a closely related taxonomic group within the facultatively heterofermentative lactobacilli. The classification and nomenclature of these bacteria are controversial. In this study, relationships between these species were investigated using type strains and dairy industry isolates examined with DNA-based techniques and conventional carbohydrate use tests. Carbohydrate use patterns gave poor discrimination of some species, but DNA PCR using specific primers targeted to sequences of the 16S rRNA gene discriminated 4 types consistent with the currently recognized species. Pulsed-field agarose gel electrophoresis of chromosomal NotI restriction fragments identified 18 different band patterns from 21 independent Lactobacillus isolates and confirmed the identity of L. casei strains from 2 culture collections (CSCC 5203 and ASCC 290), both representing the type strain of L. casei. Some isolates were reclassified as L. rhamnosus, suggesting that the prevalence of L. rhamnosus as a natural component of the microflora of dairy foods and dairy environments has previously been underestimated. These methods can provide a practical basis for discrimination of the species and identification of individual industrial strains.     

Intracellular esterase from Lactobacillus casei LILA: nucleotide sequencing,purification, and characterization

An esterase gene (estC) was isolated from a genomic library of Lactobacillus casei LILA. The estC gene consisted of a 777 bp open reading frame encoding a putative peptide of 28.9 kDa. A recombinant EstC fusion protein containing a C-terminal six-histidine tag was constructed and purified to electrophoretic homogeneity. Characterization of EstC revealed that it was a serine-dependent dimeric enzyme. Optimum temperature, NaCl concentration, and pH for EstC were determined to be 30 degrees C, 0% NaCl, and pH 5.5, respectively. EstC had significant activity under conditions simulating those of ripening cheese (10 degrees C, 4% NaCl, and pH 5.1). Kinetic constants (KM and Vmax) were determined for EstC action on a variety of ethyl esters and ester compounds consisting of substituted phenyl alcohols and short n-chain fatty acids. For comparison purposes, the previously studied EstA from Lactococcus lactis MG1363 was purified to electrophoretic homogeneity and its substrate selectivity determined in a similar fashion. Different substrate selectivities were observed for EstC and EstA.     

Nucleotide sequencing,purification, and biochemical properties of an arylesterase from Lactobacillus casei LILA

An esterase gene, designated estB, was isolated from a genomic library of Lactobacillus casei LILA. Nucleotide sequencing of the estB gene revealed a 954-bp open reading frame encoding a putative peptide of 35.7 kDa. The deduced amino acid sequence of EstB contained the characteristic GXSXG active-site serine motifidentified in most lipases and esterases. An EstB fusion protein containing a C-terminal 6-histidine tag was constructed and purified to electrophoretic homogeneity by affinity chromatography. The native molecular weight of EstB was 216.5 +/- 2.5 kDa, while the subunit molecular weight was 36.7 +/- 1.0 kDa. Optimum pH, temperature, and NaCl concentration for EstB were determined to be pH 7.0,50 to 55 degrees C, and 15% NaCl, respectively. EstB had significant activity under conditions simulating those of ripening cheese (pH 5.1, 10 degrees C, and 4% NaCl). Kinetic constants (KM and Vmax) were determined for EstB action on a variety of ethyl esters and ester compounds consisting of substituted phenyl alcohols and short n-chain fatty acids. For comparison purposes, EstA from Lb. helveticus CNRZ32 was purified to electrophoretic homogeneity and its substrate selectivity determined in a similar fashion. Different substrate selectivities were observed for EstB and EstA.     

Selective and differential enumerations of Lactobacillus delbrueckii subsp. bulgaricus, Streptococcus thermophilus, Lactobacillus acidophilus, Lactobacillus casei and Bifidobacterium spp. in yoghurt--a review

Yoghurt is increasingly being used as a carrier of probiotic bacteria for their potential health benefits. To meet with a recommended level of ≥ 10⁶ viable cells/g of a product, assessment of viability of probiotic bacteria in market preparations is crucial. This requires a working method for selective enumeration of these probiotic bacteria and lactic acid bacteria in yoghurt such as Streptococcus thermophilus, Lactobacillus delbrueckii subsp. bulgaricus, Lb. acidophilus, Lb. casei and Bifidobacterium. This chapter presents an overview of media that could be used for differential and selective enumerations of yoghurt bacteria. De Man Rogosa Sharpe agar containing fructose (MRSF), MRS agar pH 5.2 (MRS 5.2), reinforced clostridial prussian blue agar at pH 5.0 (RCPB 5.0) or reinforced clostridial agar at pH 5.3 (RCA 5.3) are suitable for enumeration of Lb. delbrueckii subsp. bulgaricus when the incubation is carried out at 45 °C for 72 h. S. thermophilus (ST) agar and M17 are recommended for selective enumeration of S. thermophilus. Selective enumeration of Lb. acidophilus in mixed culture could be made in Rogosa agar added with 5-bromo-4-chloro-3-indolyl-β-d-glucopyranoside (X-Glu) or MRS containing maltose (MRSM) and incubation in a 20% CO₂ atmosphere. Lb. casei could be selectively enumerated on specially formulated Lb. casei (LC) agar from products containing yoghurt starter bacteria (S. thermophilus and Lb. delbrueckii subsp. bulgaricus), Lb. acidophilus, Bifidobacterium spp. and Lb. casei. Bifidobacterium could be enumerated on MRS agar supplemented with nalidixic acid, paromomycin, neomycin sulphate and lithium chloride (MRS-NPNL) under anaerobic incubation at 37 °C for 72 h.     

High pressure effects on proteolytic and glycolytic enzymes involved in cheese manufacturing

The activity of chymosin, plasmin, and Lactococcus lactis enzymes (cell envelope proteinase, intracellular peptidases, and glycolytic enzymes) were determined after 5-min exposures to pressures up to 800 MPa. Plasmin was unaffected by any pressure treatment. Chymosin activity was unaffected up to 400 MPa and decreased at 500 to 800 MPa. Fifty percent of control chymosin activity remained after the 800 MPa treatment. The lactococcal cell envelope proteinase (CEP) and intracellular peptidase activities were monitored in cell extracts of pressure-treated cells. A pressure of 100 MPa increased the CEP activity, whereas 200 MPa had no effect. At 300 MPa, CEP activity was reduced, and 400 to 800 MPa inactivated the enzyme. X-Prolyl-dipeptidyl aminopeptidase was insensitive to 5-min pressure treatments of 100 to 300 MPa, but was inactivated at 400 to 800 MPa. Aminopeptidase N was unaffected by 100 and 200 MPa. However, 300 MPa significantly reduced its activity, and 400 to 800 MPa inactivated it. Aminopeptidase C activity increased with increasing pressures up to 700 MPa. High pressure did not affect aminopeptidase A activity at any level. Hydrolysis of Lys-Ala-p-NA doubled after 300-MPa exposure, and was eliminated at 400 to 800 MPa. Glycolytic enzyme activities of pressure-treated cells were evaluated collectively by determining the titratable acidity as lactic acid produced by cell extracts in the presence of glucose. The titratable acidities produced by the 100 and 200 MPa samples were slightly increased compared to the control. At 300 to 800 MPa, no significant acid production was observed. These data demonstrate that high pressure causes no effect, activation, or inactivation of proteolytic and glycolytic enzymes depending on the pressure level and enzyme. Pressure treatment of cheese may alter enzymes involved in ripening, and pressure-treating L. lactis may provide a means to generate attenuated starters with altered enzyme profiles.     

Probiotic beverage from cashew apple juice fermented with Lactobacillus casei

This study optimized the conditions of Lactobacillus casei NRRL B-442 cultivation in cashew apple juice, as well as, determined the proper inoculum amount and fermentation time. Moreover, it was investigated the survivability ability of L. casei in cashew apple juice during refrigerated storage (4 °C) for 42 days. The optimum conditions for probiotic cashew apple juice production were initial pH 6.4, fermentation temperature of 30 °C, inoculation level of 7.48 Log CFU/mL (L. casei) and 16 h of fermentation process. It was observed that the L. casei grew during the refrigerated storage. Viable cell counts were higher than 8.00 Log CFU/mL throughout the storage period (42 days). The values of lightness, yellowness and total color change increased and the values of redness reduced along the fermentation and refrigerated storage periods. The fermented juice with L. casei is a good and healthy alternative functional food containing probiotics. Cashew apple juice showed to be as efficient as dairy products for L. casei growth.     

Influence of starters on chemical, biochemical, and sensory changes in Turkish White-brined cheese during ripening

Turkish White-brined cheese was manufactured using Lactococcus strains (Lactococcus lactis ssp. lactis NCDO763 plus L. lactis ssp. cremoris SK11 and L. lactis ssp. lactis UC317 plus L. lactis ssp. cremoris HP) or without a starter culture, and ripened for 90 d. It was found that the use of starters significantly influenced the physical, chemical, biochemical, and sensory properties of the cheeses. Chemical composition, pH, and sensory properties of cheeses made with starter were not affected by the different starter bacteria. The levels of soluble nitrogen fractions and urea-PAGE of the pH 4.6-insoluble fractions were found to be significantly different at various stages of ripening. Urea-PAGE patterns of the pH 4.6-insoluble fractions of the cheeses showed that considerable degradation of α_s1-casein occurred and that β-casein was more resistant to hydrolysis. The use of a starter culture significantly influenced the levels of 12% trichloroacetic acid-soluble nitrogen, 5% phosphotungstic acid-soluble nitrogen, free amino acids, total free fatty acids, and the peptide profiles (reverse phase-HPLC) of 70% (vol/vol) ethanol-soluble and insoluble fractions of the pH 4.6-soluble fraction of the cheeses. The levels of peptides in the cheeses increased during the ripening period. Principal component and hierarchical cluster analyses of electrophoretic and chromatographic results indicated that the cheeses were significantly different in terms of their peptide profiles and they were grouped based on the use and type of starter and stage of ripening. Levels of free amino acid in the cheeses differed; Leu, Glu, Phe, Lys, and Val were the most abundant amino acids. Nitrogen fractions, total free amino acids, total free fatty acids, and the levels of peptides resolved by reverse phase-HPLC increased during ripening. No significant differences were found between the sensory properties of cheeses made using a starter, but the cheese made without starter received lower scores than the cheeses made using a starter. It was found that the cheese made with strains NCDO763 plus SK11 had the best quality during ripening. It was concluded that the use of different starter bacteria caused significant differences in the quality of the cheese, and that each starter culture contributed to proteolysis to a different degree.     

Lactobacillus helveticus SBT2171, a cheese starter,regulates proliferation and cytokine production of immune cells

Consumption of a Lactobacillus helveticus SBT2171 (LH2171)-containing cheese has been reported to exhibit immunoregulatory actions, including an increase in regulatory T cell population and reduction in proinflammatory cytokine production in mice. We examined the in vitro effects of LH2171 cells per se on immune cell function, specifically proliferation and cytokine production, which are primary reactions of the immune response. Immune cell fractions were prepared by mechanical disruption of mesenteric lymph nodes (MLN), Peyer’s patches (PP), and spleens (SP) of mice. The cell fractions were dispensed into a culture plate and stimulated with anti-CD3/CD28 antibody beads in place of antigen-presenting cells or lipopolysaccharide (LPS) in the presence or absence of heat-treated LH2171 cells and other bacterial strains for comparison. After incubation, proliferation, cytokine production, and cell viability of the immune cells were determined. The LH2171 significantly inhibited the proliferation of MLN immune cells stimulated with anti-CD3/CD28 compared with other bacterial strains. The antiproliferative potency of LH2171 was effective not only on MLN but also on PP and SP stimulated with anti-CD3/CD28 or LPS. The LH2171 also decreased LPS-stimulated IL-6 production from MLN, PP, and SP, and IL-1β production from SP, but LH2171 did not affect the viability of immune cells. The LH2171 inhibited immune cell proliferation and proinflammatory cytokine (IL-6 and IL-1β) production. The inhibitory actions were not due to cytotoxicity to immune cells, suggesting that LH2171 is a dairy Lactobacillus strain with beneficial immunoregulatory properties.     

Diversity of stress tolerance in Lactobacillus plantarum, Lactobacillus pentosus and Lactobacillus paraplantarum: A multivariate screening study

Sixty-three strains of the taxonomically related species Lactobacillus plantarum subsp. plantarum, L. plantarum subsp. argentoratensis, L. paraplantarum and L. pentosus isolated from sourdoughs and other food and non-food sources and 14 strains of other members of the genus Lactobacillus were screened for their tolerance of acid, alkaline, heat, oxidative, osmotic, detergent and starvation stresses in order to evaluate the diversity of stress response. Most strains of the L. plantarum group were highly tolerant of acid, alkaline and osmotic stress and highly sensitive to detergent stress, while a larger diversity was found for other stress. Multivariate analysis allowed grouping the strains in clusters with similar response patterns. Stress response patterns in the L. plantarum group were similar to those of species of the L. casei/L. paracasei group but clearly different from those of other mesophilic Lactobacillus. No relationship was found between grouping obtained on the basis of stress response patterns and by genotypic fingerprinting (rep-PCR), nor with the taxonomic position or isolation source of the strains. Further experiments with selected strains showed that exponential phase cells were generally but not always more sensitive than stationary phase cells. The ability to grow under stressful conditions showed a slightly better correlation with the ecological conditions prevailing in the isolation niches of the strains.This study will be the basis for further investigations to identify and exploit the basis of diversity in the stress response of lactic acid bacteria.     

Growth of Lactobacillus paracasei ATCC 334 in a cheese model system: a biochemical approach

Growth of Lactobacillus paracasei ATCC 334, in a cheese-ripening model system based upon a medium prepared from ripening Cheddar cheese extract (CCE) was evaluated. Lactobacillus paracasei ATCC 334 grows in CCE made from cheese ripened for 2 (2mCCE), 6 (6mCCE), and 8 (8mCCE) mo, to final cell densities of 5.9 × 10⁸, 1.2 × 10⁸, and 2.1 × 10⁷ cfu/mL, respectively. Biochemical analysis and mass balance equations were used to determine substrate consumption patterns and products formed in 2mCCE. The products formed included formate, acetate, and d-lactate. These data allowed us to identify the pathways likely used and to initiate metabolic flux analysis. The production of volatiles during growth of Lb. paracasei ATCC 334 in 8mCCE was monitored to evaluate the metabolic pathways utilized by Lb. paracasei during the later stages of ripening Cheddar cheese. The 2 volatiles detected at high levels were ethanol and acetate. The remaining detected volatiles are present in significantly lower amounts and likely result from amino acid, pyruvate, and acetyl-coenzyme A metabolism. Carbon balance of galactose, lactose, citrate, and phosphoserine/phosphoserine-containing peptides in terms of d-lactate, acetate, and formate are in agreement with the amounts of substrates observed in 2mCCE; however, this was not the case for 6mCCE and 8mCCE, suggesting that additional energy sources are utilized during growth of Lb. paracasei ATCC 334 in these CCE. This study provides valuable information on the biochemistry and physiology of Lb. paracasei ATCC 334 in ripening cheese.     

Binding of mutagens to exopolysaccharide produced by Lactobacillus plantarum mutant strain 301102S

Exopolysaccharide (EPS) was produced by Lactobacillus plantarum 301102 on exposure to the mutagenic action of acridine orange and novobiocin. The biological characteristics of this mutant strain 301102S were the same as those of the parent strain, but fermented milk prepared with the mutant strain showed antimutagenic activity on 3-amino-1,4-dimethyl-5H-pyrido indole. Only EPS-bound cells of strain 301102S showed binding ability to mutagens such as heterocyclic amines, and the mutagens were inactivated by binding to EPS. The binding ability was affected by pH; the greatest percentage binding was noted at pH 8.0. Addition of Mg²⁺ and sodium dodecyl sulfate, but not oxgall, inhibited the binding ability. Therefore, the binding mechanism of the EPS may consist of ion-exchange and hydrophobic bonds, and the EPS would bind mutagens in the intestine.     

Proteolysis of Hispanico cheese manufactured using lacticin 481-producing Lactococcus lactis ssp. lactis INIA 639

Hispánico cheese was manufactured using lacticin 481-producing Lactococcus lactis ssp. lactis INIA 639, bacteriocin-nonproducing L. lactis ssp. lactis INIA 437, or a combination of both strains, as starter cultures. Lactobacillus helveticus LH 92, a culture of high amino-peptidase activity sensitive to lacticin 481, was added to all vats. Milk inoculation with the bacteriocin producer promoted early lysis of Lb. helveticus cells in cheese. Cell-free aminopeptidase activity in cheese made with the 3 lactic cultures was 1.8 times the level reached in cheese made only with L. lactis strain INIA 437 and Lb. helveticus, after 15 d of ripening. Proteolysis (as estimated by the o-phthaldialdehyde method) in cheese made with the 3 lactic cultures was twice as high, and the level of total free amino acids 2.4 times the level found in cheese made only with L. lactis strain INIA 437 and Lb. helveticus, after 25 d of ripening. Hydrophobic and hydrophilic peptides and their ratio were at the lowest levels in cheese made with the 3 lactic cultures, which received the lowest scores for bitterness and the highest scores for taste quality.