CONTENT AND STABILITY OF HEXANE EXTRACTABLE LIPID AT VARIOUS STEPS OF PRODUCING MACARONI CONTAINING GROUND FLAXSEED

Research was conducted to determine changes in content and stability of hexane extractable lipid during processing of macaroni containing 15% (w/w) ground whole flaxseed and ground flaxseed hull. Dry mixture, hydrated mixture, extruded macaroni, dried macaroni and cooked macaroni were evaluated. Results were similar for macaroni containing ground whole flaxseed or ground flaxseed hull. Hydration decreased extractable lipid. Hydration decreased the amount of α-linolenic acid (ALA) and free fatty acid (FFA) and increased the amount of conjugated diene in the extracted lipid. Little or no conjugated triene was detected in lipid extracted from samples containing flaxseed, regardless of the processing step. Extruding, drying and cooking had little or no effect on the stability of lipids in macaroni containing flaxseed. The low levels of FFA, conjugated diene and conjugated triene indicate that lipid remained relatively stable during processing and cooking of macaroni containing ground flaxseed.     

Oxidative stability of alpha‐linolenic acid (ω‐3) in flaxseed oil microcapsules fortified market milk

The oxidative stability of α‐linolenic acid (ALA) was investigated in market milk fortified with flaxseed oil microcapsules. Milk was fortified at levels of 1, 2 and 3 g/100 mL using flaxseed oil powder, and optimised on the basis of sensory scores. No significant difference was observed between the control, 1 and 2 g/100 mL fortified milk samples. Therefore, 2 g/100 mL fortified milk was further evaluated for oxidative stability, fatty acids profile and sensory acceptability during 5 days of storage. The fortified milk was oxidatively stable and sensorially acceptable, retaining ~10.35% ALA, which indicated that 250 mL of milk could meet ~46% of the RDA for ω‐3 fatty acids.     

Enrichment of macaroni with cellulose-derivative protein complex from whey and corn steep liquor

Macaroni was prepared from semolina fortified with 3, 6 and 9% CMC-protein (CMC — carboxymethyl cellulose) or HEC-protein (HEC — hydroxyethyl cellulose) complexes from whey and corn steep liquor to increase the protein quality and quantity. Fortification increased the protein content up to 14.2% in DM (vs. 12.1% in control) for macaroni. Water absorption, dough weakening and mixing tolerance index were decreased, while dough development time and dough stability were increased when the amount of precipitated cellulose-protein complex from whey and corn steep liquor in the blends increased. Addition of both tested cellulose-protein complexes improved cooking quality by increasing the weight and volume of cooked macaroni, but cooking losses were greater. Sensory evaluation of the colour, flavour and appearance of macaroni were improved as a result of adding cellulose-protein complex from whey. Macaroni samples prepared from dough mixtures with 6 and 9% of cellulose-protein complex from corn steep liquor were less acceptable than those prepared from 100% semolina.     

Effect of flaxseed oil fortified with vitamin e and phytosterols on antioxidant defense capacities and lipids profile in rats

The main proposal of this study was to evaluate in vivo whether flaxseed oils fortified with micronutrients would have beneficial effects on lipid profile and antioxidant status in high-fat fed rats. Male Wistar rats were fed synthetic diets containing 10% of flaxseed oil (FO), phytosterols (PS) fortified FO (PS-FO), vitamin E (V(E) ) fortified FO (V(E) -FO), V(E) , and PS fortified FO (V(E) -PS-FO), respectively, for 4 wk. The results showed that V(E) fortified FO enhanced the enzymatic (SOD and GPX) and nonenzymatic (GSH and V(E)) antioxidant system, lowered the lipid peroxide (TBARS) concentration compared with FO (P < 0.05). And FO fortified with PS significantly reduced the plasma TG, TC and LDL-C levels, and hepatic TG and TC levels of rats compared with FO (P < 0.05), but had no significant effect on antioxidant defense capacities. Combined addition of V(E) and PS in FO had a synergetic effect. These results indicated that flaxseed oils fortified micronutrients V(E) and PS may contribute to reduce the risk factors of cardiovascular disease (CVD) by improving plasma antioxidant defenses and lipids profiles. PRACTICAL APPLICATION: Flaxseed oil usually contains greater than 50% of alpha-linolenic acid (ALA) and is a desire origin for n-3 PUFA. But consuming high dose of n-3 PUFA could lead to oxidative damage through free radical-chain reaction in cellular and subcellular membranes. Our studies showed that a regular intake of V(E) and PS fortified flaxseed oils increased antioxidant defenses and ameliorated lipids profile in high-fat fed rats, and these indicated that the flaxseed oil fortified with these micronutrients might reduce the incidence of CVD.     

Secoisolariciresinol diglucoside determination in flaxseed (Linum usitatissimum L.) oil and application to a shelf life study

A high-performance liquid chromatographic (HPLC) reliable and sensitive method with diode array detection (DAD) system has been developed for the determination of secoisolariciresinol diglucoside (SDG) in flaxseed oil. An analytical methodology based on the sample extraction with methanol/water (80:20, v/v), subsequent purification of the sample and analysis of the extract by HPLC/DAD is proposed for the determination of SDG in flaxseed oil. The coefficient of determination of the standard calibration curve was 0.999, the limit of detection was 0.08 μg/mL, and the limit of quantification was 0.27 μg/mL. The recovery test was conducted adding four different concentrations of standard solution to the blank sample. The recovery ranged from 90% to 95%. To our knowledge, the presence and quantification of SDG in flaxseed oil has never been reported. The proposed method was tested to study the variation in SDG content in flaxseed oil during a shelf-life test to verify its applicability in quality control for oil industries. The dark and the low temperature of storing together allowed to preserve SDG. A slight pro-oxidant effect was observed for the addition of antioxidant to the flaxseed oil.     

Dietary flaxseed lignan or oil combined with tamoxifen treatment affects MCF‐7 tumor growth through estrogen receptor‐ and growth factor‐signaling pathways

This study aimed to elucidate which component of flaxseed, i.e. secoisolariciresinol diglucoside (SDG) lignan or flaxseed oil (FO), makes tamoxifen (TAM) more effective in reducing growth of established estrogen receptor positive breast tumors (MCF‐7) at low circulating estrogen levels, and potential mechanisms of action. In a 2×2 factorial design, ovariectomized athymic mice with established tumors were treated for 8 wk with TAM together with basal diet (control), or basal diet supplemented with SDG (1 g/kg diet), FO (38.5 g/kg diet), or combined SDG and FO. SDG and FO were at levels in 10% flaxseed diet. Palpable tumors were monitored and after animal sacrifice, analyzed for cell proliferation, apoptosis, ER‐mediated (ER‐α, ER‐β, trefoil factor 1, cyclin D1, progesterone receptor, AIBI), growth factor‐mediated (epidermal growth factor receptor, human epidermal growth factor receptor‐2, insulin‐like growth factor receptor‐1, phosphorylated mitogen activated protein kinase, PAKT, BCL2) signaling pathways and angiogenesis (vascular endothelial growth factor). All treatments reduced the growth of TAM‐treated tumors by reducing cell proliferation, expression of genes, and proteins involved in the ER‐ and growth factor‐mediated signaling pathways with FO having the greatest effect in increasing apoptosis compared with TAM treatment alone. SDG and FO reduced the growth of TAM‐treated tumors but FO was more effective. The mechanisms involve both the ER‐ and growth factor‐signaling pathways.     

非传统通心面的研究（下）：烘干工艺对通心面品质的影响

试验表明在通心面烘干过程中,随着温度的提高,产品的色泽得以改善,烹煮重量、烹煮损失减小,煮面强度得以提高。通过三种不同的烘干温度(LT、CT 和 HT)和两种不同的高温试验(HT-A 和 HT-B)比较,本文推荐了适合非传统通心面的适宜烘干条件。本文对通心面干燥过程中水份转移理论及高温烘干过程中的物化变化情况作了探讨。     

Microwave assisted drying of short-cut (ditalini) macaroni: Drying characteristics and effect of drying processes on starch properties

Macaroni samples were dried by conventional hot air, microwave alone and hot air followed by microwave drying methods. The drying of macaroni samples took place in the falling rate period. Higher drying rates were observed with a higher microwave power level. A diffusion model was employed to fit the experimental drying data in order to characterize the drying rate of samples. Drying only with microwave energy (70 and 210 W) or hot air–microwave energy (70 and 210 W) resulted in substantial shortening of the drying time. The reduction was 61.8%, 87.3%, 61% and 78%, respectively, of the time to dry with hot air. All starch granules of semolina and hot air dried macaroni displayed a clear “Maltese cross” under polarized light. Starch granules of macaroni samples dried with microwave (70–210 W) and combined hot air–microwave (70–210 W) had irregular shapes but retained birefringence in about half or whole of each granule. The starch gelatinization enthalpies of macaroni samples dried with hot air, microwave alone (70 and 210 W) and combined hot air and microwave (70 and 210 W) drying were lower than that of semolina sample. This confirms that starch is not completely gelatinized during drying.     

The in vitro protein digestibility,microbiological quality and gelatinization behaviour of macaroni as affected by cowpea flour addition

Cowpeas were germinated, fermented, cooked, ground to flour and added to standard durum wheat semolina at 20% (w/w) level for macaroni production. Macaroni samples were analysed for in vitro protein digestibility, microbial count (total bacteria, mould and yeast) and gelatinization behaviour over a 6-month storage period at room temperature (<25 °C). Starch gelatinization behaviour of the samples was analysed using differential scanning calorimetry. Supplementing semolina with cowpea flour did not have a significant affect on in vitro protein digestibilities or aerobic plate counts of macaroni samples (p < 0.05). There was a small but significant increase in mold and yeast counts after 6 months of storage in cowpea treated samples. Two endothermic peaks were observed with significant differences in ΔH values of control and cowpea treated macaroni samples. The transition peak (T_p) temperatures were in the range of 66.9–67.9 and 86.9–100.4 °C for the first and second peaks, respectively. The transition enthalpies (ΔH) were in the range 2.41–4.21 and 1.71–3.86 J/g for the first and second peaks, respectively.     

The effective parameters for subcritical water extraction of SDG lignan from flaxseed (Linum usitatissimum L.) using accelerated solvent extractor

The aim of this study was to investigate the effective parameters for subcritical water extraction of secoisolariciresinol diglucoside (SDG) lignan from flaxseed using accelerated solvent extractor. For this aim, the influence of extraction parameters such as material shape (flaxseed, ground flaxseed meal and flaxseed meal sticks), temperature (120, 140, 160 and 180 °C), extraction time (15, 30, 60 and 90 min), pressure (1.500 and 2.000 psi), fresh water (5, 40 and 100 %) and sample amount (5 and 10 g) was studied. SDG lignan analysis has been carried out by LC–MS/MS. It was shown that material shape, temperature, extraction time and sample amount had significant effect on SDG lignan content in water extracts (p < 0.05). The highest amount (12.94 mg/g) and extraction yield (72.57 %) were obtained at 180 °C for 15 min, 1.500 psi and 40 % fresh water using 5 g of flaxseed meal sticks.     

非传统通心面品质改良的研究

本文论述了提高非传统通心面品质所取得的研究结果。试验分析表明杜伦普通小麦粉在蛋白质和淀粉方面差异很大。通过各种添加剂筛选试验,得到一个最佳复合添加剂Z(GCAZG),中试生产表明,CAZG能显著提高非传统通心面的强度、色泽与烹煮品质。相对于质量的提高,由CAZG带来生产成本的提高是极有限的。试验表明,随着温度的提高,产品的色泽得以改善,烹煮重量、烹煮损失减小,煮面强度得以提高。通过三种不同的烘干温度(LT、NT和HT)和两种不同的高温试验(HT-A和HT-B),本文推荐了适合非传统通心面的适宜烘干条件。     

开环异落叶松树脂酚的提取及其对乳液稳定性的影响研究

以含50%开环异落叶松树脂酚二葡萄糖苷(SDG)的亚麻木酚素粗提物(50%SDG)为水解原料,对制备开环异落叶松树脂酚(SECO)粗提物的HCl浓度和水解时间进行优化,进一步通过溶剂萃取、真空冷冻干燥工艺制备SECO粗提物,并将其应用于磷脂-亚麻籽油乳液体系中,研究水解前后亚麻木酚素粗提物对磷脂-亚麻籽油乳液在65℃高温储藏过程中稳定性的影响。结果表明:在HCl浓度1 mol/L、水解时间120 min的条件下水解,可制备SECO含量为65%的SECO粗提物(65%SECO);在磷脂-亚麻籽油乳液高温储藏(65℃)过程中,65%SECO组乳液粒径无显著变化,但对照组和50%SDG组乳液粒径增大;与对照组乳液相比,储藏7 d,65%SECO和50%SDG可分别将乳液中氢过氧化物含量降低11%和27%。由此可见,在磷脂-亚麻籽油乳液的高温储藏(65℃)过程中,50%SDG具有较好的抑制油脂氧化的效果,但通过水解制备的65%SECO能显著提高磷脂-亚麻籽油乳液的物理稳定性。     

Transfer rate of α-linolenic acid from abomasally infused flaxseed oil into milk fat and the effects on milk fatty acid composition in dairy cows

The objectives of the present study were to evaluate the transfer efficiency of α-linolenic acid (ALA) from the abomasum into milk fat, its interaction with milk fat content and yield, and the relationship between ALA and C16:0 in milk fat. Three rumen-fistulated multiparous Holstein cows at midlactation were used in a 3×3 Latin square design. Treatments consisted of abomasal infusion of (1) 110mL of water/d (control), (2) 110mL of flaxseed oil/d (low flaxseed oil, LFO), and (3) 220mL of flaxseed oil/d (high flaxseed oil, HFO). Experimental periods were continued for 2 wk and fat supplements were infused abomasally during the last 7 d of each period. Average dry matter intake and milk yield were not affected by oil infusion. Milk fat and lactose content tended to be greater with flaxseed infusion compared with the control. Plasma ALA was 2.9- and 4.0-fold greater with LFO and HFO, respectively. The apparent transfer efficiency of ALA to milk was 44.8 and 45.7% with LFO and HFO, respectively. The C16:0 content in milk fat was decreased by 3.59 and 5.25 percentage units, whereas the ALA content was increased by 1.68 and 3.09 percentage units with LFO and HFO, respectively. Similarly, C18:2n-6 was increased by 0.95 and 1.31 percentage units with LFA and HFO, respectively, without changes in other fatty acids (FA). Total polyunsaturated FA was 4.4 and 2.7% lower in the HFO and LFO, respectively, than in the control. Furthermore, C16:0 content in the milk fat was reduced to a greater extent than the increase in ALA content, as a 1.68 and 3.09 percentage unit increase occurred in ALA compared with a 3.6 and 5.25 percentage unit decrease in C16:0 for LFO and HFO, respectively, such that a negative correlation existed between ALA and C16:0 (r=-0.72). In conclusion, abomasal infusion of flaxseed oil dramatically increased the ALA content in plasma and milk fat. Because the replacement of C16:0 with ALA and C18:2n-6 occurred without changes in other FA presumed to be synthesized de novo in the mammary gland, this suggests that the preformed C16:0 was replaced, rather than being caused, by an overall suppression of de novo FA synthesis in the mammary gland.     

Microwave-Assisted Extraction of Secoisolariciresinol Diglucoside��Method Development

An optimized microwave-assisted extraction (MAE) method was developed for extracting secoisolariciresinol diglucoside (SDG) from flaxseed. This paper presents the optimization of factors for maximizing the extraction yield of SDG. This work was conducted using the experimental domain identified in a previous study by means of screening designs, that is, samples of 1 g defatted flaxseed meal (DFM) were extracted with 50 ml NaOH of concentration of 0.5–1 M, at microwave power levels of 60–360 W, for 3–9 min, with the microwave power applied intermittently (power on 30 s/min) and continuously (power on 60 s/min). The MAE of SDG was maximized when 1 g DFM was extracted with 50 ml 0.5 M NaOH, at 135 W, for 3 min in intermittent power mode (power on 30 s/min). The optimized MAE achieved a 6% increase in the extraction yield (21.45 mg SDG per gram DFM) as opposed to a direct hydrolysis method (20.22 mg SDG per gram DFM). The MAE of SDG was governed by the microwave–NaOH interaction, which had a curvilinear dependence on the microwave power level, and linear dependence on the NaOH concentration. The microwave-induced effects accounted for a 10% increase in the SDG extraction yield (21.45 mg SDG per gram DFM) as opposed to a microwaveless control method (19.45 mg SDG per gram DFM). The optimized MAE method has good repeatability, a 97% recovery of the target compound; it is fast and efficient and can be used for precise quantification of SDG in flaxseed.     

Composition,processing, and quality control of whole flaxseed products used to fortify foods

Whole flaxseed (flour) as a good source of omega-3 fatty acid and phytochemicals with excellent nutritional and functional attributes has been used to enrich foods for health promotion and disease prevention. However, several limitations and contemporary challenges still impact the development of whole flaxseed (flour)-enriched products on the global market, such as naturally occurring antinutritional factors and entrapment of nutrients within food matrix. Whole flaxseed (flour) with different existing forms could variably alter the techno-functional performance of food matrix, and ultimately affect the edible qualities of fortified food products. The potential interaction mechanism between the subject and object components in fortified products has not been elucidated yet. Hence, in this paper, the physical structure and component changes of flaxseed (flour) by pretreatments coupled with their potential influences on the edible qualities of multiple fortified food products were summarized and analyzed. In addition, several typical food products, including baked, noodle, and dairy products were preferentially selected to investigate the potential influencing mechanisms of flaxseed (flour) on different substrate components. In particular, the altered balance between water absorption of flaxseed protein/gum polysaccharides and the interruption of gluten network, lipid lubrication, lipid–amylose complexes, syneresis, and so forth, were thoroughly elucidated. The overall impact of incorporating whole flaxseed (flour) on the quality and nutritional attributes of fortified food products, coupled with the possible solutions against negative influences are aimed. This paper could provide useful information for expanding the application of whole flaxseed (flour) based on the optimal edible and nutritional properties of fortified food products.     

UHT乳贮藏期间理化特性和感官品质的变化

为探讨超高温瞬时杀菌(ultra-high temperature instantaneous sterilization,UHT)乳的营养价值随贮藏时间的变化,对不同贮藏期UHT乳的理化特性和感官品质进行监测。在6个月的贮藏期内,UHT乳中脂肪、蛋白质、乳糖以及固形物的总量并无明显变化,维生素C和泛酸的含量均损失了约25%,游离氨基酸和钙离子分别增加了5.35%和6.73%。不同贮藏期UHT乳的黏度变化不显著(P>0.05),但粒径大小强烈依赖于贮藏时间,乳脂肪球和酪蛋白胶束的尺寸在贮藏初期分别增加了约38 nm和14 nm,然后分别稳定在约173 nm和612 nm。贮藏1个月的UHT乳样品在风味和口感方面整体表现较好,贮藏6个月后,UHT乳的感官品质大幅下降,出现了许多不良风味。     

Gelation enhancement of soy protein isolate by sequential low‐ and ultrahigh‐temperature two‐stage preheating treatments

The effects of combined two heating steps with low (LT, 60 °C for 1 h) and ultrahigh (UHT, 130 or 140 °C for 4 s) temperatures on the thermal gelation of soy protein isolate (SPI) were studied. UHT pretreatments significantly increased protein solubility and enhanced the gelling potential of SPI. Yet, the two‐stage preheating treatment with LT and then UHT‐130 °C had a most remarkable effect: the gel strength of the SPI₆₀₊₁₃₀ sample was, respectively, 1.45‐, 1.64‐ and 3.19‐fold as strong as those of SPI₆₀, SPI₂₅₊₁₃₀, and SPI₂₅. In comparison with single LT or UHT treatments, this two‐stage heating also produced greater amounts of soluble protein aggregates stabilised predominantly by disulphide bonds and hydrophobic forces, contributing to the improved gel network structure.     

Proximal composition and in vitro starch digestibility in flaxseed‐added corn tortilla

BACKGROUND: The effect of addition of flaxseed flour (10:90, 15:85 and 20:80, w/w) on the chemical composition and starch digestibility of corn tortilla was investigated. Tortillas were baked and frozen in liquid nitrogen, freeze‐dried, ground and analyzed for fat, protein, ash, total starch (TS), available starch (AS) and resistant starch (RS) contents as well as for starch hydrolysis rate and predicted glycemic index (pGI). Tortillas made from commercial nixtamalized corn flour were used as control sample. RESULTS: Flaxseed flour addition increased the fat and protein content of tortilla, whereas TS and AS decreased. TS was 15.25% lower in the 20% flaxseed‐containing tortilla as compared to the control sample. The AS content was 12.65% lower in the composite tortilla. RS content in the samples ranged between 1.92% for the control sample and 5.08% for the tortilla containing 20% flaxseed. The reduced enzymatic starch hydrolysis rate and pGI recorded for the flaxseed‐added tortilla, indicated slow digestion features. CONCLUSIONS: Flaxseed‐added tortilla might be used to increase the consumption of α‐linolenic acid in the daily diet and modulate starch digestibility of corn tortilla. This kind of product may be used by people with special diet reqirements. Copyright © 2008 Society of Chemical Industry     

UHT Milk Processing and Effect of Plasmin Activity on Shelf Life: A Review

Abstract: The demand for ultra‐high‐temperature (UHT) processed and aseptically packaged milk is increasing worldwide. A rise of 47% from 187 billion in 2008 to 265 billon in 2013 in pack numbers is expected. Selection of UHT and aseptic packaging systems reflect customer preferences and the processes are designed to ensure commercial sterility and acceptable sensory attributes throughout shelf life. Advantages of UHT processing include extended shelf life, lower energy costs, and the elimination of required refrigeration during storage and distribution. Desirable changes taking place during UHT processing of milk such as destruction of microorganisms and inactivation of enzymes occur, while undesirable effects such as browning, loss of nutrients, sedimentation, fat separation, cooked flavor also take place. Gelation of UHT milk during storage (age gelation) is a major factor limiting its shelf life. Significant factors that influence the onset of gelation include the nature of the heat treatment, proteolysis during storage, milk composition and quality, seasonal milk production factors, and storage temperature. This review is focused on the types of age gelation and the effect of plasmin activity on enzymatic gelation in UHT milk during a prolonged storage period. Measuring enzyme activity is a major concern to commercial producers, and many techniques, such as enzyme‐linked immunosorbent assay, spectrophotometery, high‐performance liquid chromatography, and so on, are available. Extension of shelf life of UHT milk can be achieved by deactivation of enzymes, by deploying low‐temperature inactivation at 55 °C for 60 min, innovative steam injection heating, membrane processing, and high‐pressure treatments.     

亚麻籽水解物化学成分研究及SDG含量测定

亚麻是亚麻科亚麻属植物。亚麻籽水解物化学成分含有亚麻木酚素(SDG),该成分具有抗氧化、抗肿瘤、治疗糖尿病等作用。主要研究亚麻籽水解物,通过硅胶柱层析、C18反相层析分离出多种化合物。借助NMR技术鉴定得到5种,即3,4-二羟基苯基-丙烯酸甲酯(Ⅰ)、十九烷酸(Ⅱ)、松脂醇葡萄糖苷(Ⅲ)、开环异落叶松脂素二葡萄糖苷(Ⅳ)(亚麻木酚素,SDG)、β-胡萝卜苷(Ⅴ)。利用高效液相色谱分析亚麻木酚素的含量,结果显示其在亚麻籽水解物中的含量为22.5%。