Effects of early post-mortem pH and temperature on beef tenderness

The tenderness of loin steaks, prepared from beef sides after chilling, is strongly influenced by muscle temperature in the first 3 h after slaughter. Maintenance of about 37°C within the Longissimus muscle during this time, whether by heavy fat cover or by ambient-temperature manipulation, results in appreciable tenderness enhancement. Early post-mortem muscle pH (which varies over a wide range) also affects tenderness significantly; provided early and exceptionally fast chilling does not induce cold shortening, slow glycolysis promotes tenderness. Low-frequency (2 Hz) electrical stimulation, which accelerates glycolysis but causes negligible tissue disruption, significantly toughens the loin; in its normal mode (50–60 Hz), therefore, stimulation produces its desirable tenderising effect mainly—and perhaps solely—by fibre fracture.     

Effect of stress-induced high post-mortem pH on protease activity and tenderness of beef

Forty-four Swiss Brown young bulls were stressed by regrouping unfamiliar animals before slaughter. M. longissimus thoracis (6-9th ribs) of carcasses were analysed for post-mortem pH, protease activities (m- and α-calpain, calpastatin and cathepsin B + L), Warner-Bratzler shear force and sensory tenderness and juiciness. Muscles were classified into three groups, according to ultimate pH values: > 6.3, 6.3-5.8 and < 5.8. The most significant difference related to high pH was a higher activity of m-calpain at 7th day post mortem. It was also found that meat showing the highest pH was significantly more tender and juicy. Sensory tenderness was highly correlated with activity of m-calpain at 7th day post mortem (r = 0.776) and with ultimate pH (r = 0.708). It is concluded that high ultimate pH induced by stress significantly increases m-calpain activity, and this results in a greatly enhanced tenderisation of beef meat.     

氯化钙处理对牛肉嫩度影响的研究

对宰后8h的牛肉分别注射200、250、300mmol／LCaCl2溶液(注射量为肉重的3％),然后将处理样品在4℃下分别腌制12h、24h、48h,通过对其剪切力值的测定,研究注射氯化钙及腌制时间对牛肉嫩度的影响。结果表明,与未注CaCl2溶液组相比,注射CaCl2溶液组牛肉嫩度显著提高(P<0.05),但不同水平CaCl2溶液处理之间牛肉嫩度差异不显著(P>005);不同腌制时间对牛肉嫩度的影响差异不显著(P>0.05)。综合分析,200mmol/L的CaCl2溶液处理浓度、48h的腌制时间改善牛肉的嫩度是可行的。     

Effects of temperature on post-mortem metabolism in beef muscle

Changes in pH and in the levels of some phosphate fractions with time were examined in beef muscle stored at 1°, 15° and 37° soon after slaughter. At 15° the fall in pH of the muscle and decreases in concentration of creatine phosphate and of other acid-labile phosphate occurred more slowly than at 37° and there was also a slower increase in the concentration of inorganic phosphate. Not all of these changes occurred more slowly at 1° than at 15°, however. The alkali-labile phosphate concentration remained virtually constant at 37° but increased at each of the other two temperatures, the increase at 1° being greater than that at 15°. These changes in alkali-labile phosphate concentration were attributable to the accumulation of hexose-6-phosphate. An effect of temperature on the metabolism of an organic phosphate fraction stable to both acid and alkali was noted.     

Effect of pre rigor stretching on beef tenderness development

The objective of this study was to determine effects of pre rigor stretching on beef tenderness development. Beef loins (M. longissimus dorsi; n=24) were assigned to either stretching or non-stretching treatments and aged for 14days at -1.5°C. Sarcomere length, shear force, water-holding capacity and proteolysis were determined for the loins at 1, 7 and 14days of ageing. Stretching increased the length of the loins by 33% resulting in a trend of increasing sarcomere length (P=0.19). However, no significant differences for shear force values, purge, drip and cooking losses between treatments were found. Shear force values decreased with ageing times (P<0.05). Western blot assay found that stretching did not affect the extent of desmin degradation. The findings from the present study suggest that pre rigor stretching with the current increase in length will not contribute to tenderness improvement of the beef loins.     

Effect of pre rigor stretching on beef tenderness development

The objective of this study was to determine effects of pre rigor stretching on beef tenderness development. Beef loins (M. longissimus dorsi; n = 24) were assigned to either stretching or non-stretching treatments and aged for 14 days at − 1.5 °C. Sarcomere length, shear force, water-holding capacity and proteolysis were determined for the loins at 1, 7 and 14 days of ageing. Stretching increased the length of the loins by 33% resulting in a trend of increasing sarcomere length (P = 0.19). However, no significant differences for shear force values, purge, drip and cooking losses between treatments were found. Shear force values decreased with ageing times (P < 0.05). Western blot assay found that stretching did not affect the extent of desmin degradation. The findings from the present study suggest that pre rigor stretching with the current increase in length will not contribute to tenderness improvement of the beef loins.     

Effects of electrical stimulation and temperature on beef quality and tenderness

Beef carcasses were stimulated with either 50 or 500 V and exposed to three chilling temperatures during the first 3 to 9 h post mortem. Both high (HV) and low voltage (LV) electrical stimulation (ES) treatments improved lean maturity scores, lowered the pH values at 2 h through 12 h and reduced the time required for the ATP level to reach minimum values. Both HV-ES and LV-ES treatments influenced firmness, fragmentation and connective tissue (CT) residue as measured by sensory panel and reduced Instron shear value (ISV) of loin steaks. The 30°C temperature treatment had an adverse effect while the 20°C temperature treatment had a beneficial effect on ISV and panel ratings for firmness and CT residue. There was an interaction between conditioning treatments and ES for ISV and sensory panel traits. The LV-ES-20C treatment resulted in the lowest ISV and superior panel ratings; however, the LV-ES-30C treatment had ISV and sensory panel ratings that were similar to the NES-2C (control) group.     

焦磷酸钠处理对牛肉嫩度和系水力影响的研究

向牛肉切块中注入10mmol／L、20mmol／L、30mmol／L3种不同浓度的焦磷酸钠（注射量占肉重0．3％）．然后在0～4℃条件下腌制24h,通过测定剪切力、煮熟率。分析不同浓度焦磷酸钠对牛肉嫩度和系水力的影响。结果表明,焦磷酸钠对牛肉剪切力影响极显著（P〈0．01）。牛肉嫩度有显著的改善作用;焦磷酸钠的适宜浓度为20mmol／L。焦磷酸钠处理对牛肉煮熟率的影响无显著差异（P〉0．05）,焦磷酸钠处理对牛肉系水力无影响。     

Effect of processing temperature on tenderness,colour and yield of beef steaks subjected to high-hydrostatic pressure

Our aim was to achieve a single-step pressure-heat process that would produce tender, juicy beef steaks from meat that would otherwise be tough when cooked. Steak portions (25 mm thick) from hind-quarter muscles were subjected to heat treatment at 60, 64, 68, 72 or 76 °C for 20 min, with or without simultaneous application of high pressure (200 MPa). Control steaks were heated at 60 °C for 20 min with or without pressure and cooked at 80 °C for 30 min. Compared with heat alone, pressure treatment resulted in higher lightness scores at all temperatures and overall yield was improved by pressure treatment at each temperature. Even at 76 °C, the overall water losses were < 10% compared with > 30% for heat alone. Meat tenderness (peak shear force) was improved for the pressure–heat samples at temperatures above 64 °C, and was optimal at 76 °C. Therefore, subject to microbial evaluation, this single-step pressure-heat process could be used to produce tender, high moisture content steaks ready for consumption.     

Early post-mortem conditions and the calpain/calpastatin system in relation to tenderness of double-muscled beef

Early post mortem temperature, pH, sarcomere length, colour, water holding capacity, calpain/calpastatin activities and myofibrillar protein concentrations (semi-quantative SDS-PAGE), measured at different times post mortem on 153 double-muscled Belgian Blue White bulls, were related to shear force (SF) measurements. The M. longissimus thoracis tenderised up to 8 days post mortem. SF was slightly correlated with temperature at 3 h post mortem (r = 0.20, p = 0.015), but not with pH early post mortem. Higher ultimate pH values measured at 24 h post mortem were related to darker meat, lower cooking losses and shorter sarcomere lengths. Sarcomere length was significantly related to SF, even after 12 days of ageing, suggesting that proteolytic activity was not able to overcome shortening. Up to 12 days post mortem, calpastatin and m-calpain activities were significantly correlated with SF suggesting a considerable role of calpains in meat tenderization of double-muscled Belgian Blue White bulls, although at 24 h post mortem, μ-calpain could no longer be detected. Titin, nebulin, filamin and troponin-T were degraded during the ageing period. Troponin-T was degraded by 80% between day 1 and 8. At 8 days post mortem its concentration was significantly correlated with 30 kDa (r = 0.63, p = 0.00), shear force (r = 0.39, p = 0.00), calpastatin activity at 1 day post mortem (r = 0.29, p = 0.01) and with the m-calpain/ calpastatin activity ratio at 1 day post mortem (r = -0.43, p = 0.00).     

Effect of age and cut on tenderness of South African beef

The tenderness characteristics of 15 primal cuts of beef of three different age groups were assessed, and the most reliable cut to predict carcass tenderness was determined. Fifteen wholesale cuts from each age group, representing the full variation in fatness, were aged, cooked and underwent sensory evaluation, shear force resistance and proximate analysis. Collagen content and solubility was determined. Percentage fat was used as a covariant during statistical analyses. Tenderness, residue and collagen solubility of all cuts decreased significantly with animal age. Collagen solubility was the largest discriminant between the three age groups, while animal age had no significant effect on collagen content. Tenderness of primal cuts from the same carcass varied considerably, with collagen content and shear force resistance as the largest discriminants between the cuts. Cuts most representative of total carcass tenderness were M. vastus lateralis, M. semimembranosus, M. gluteobiceps, M. semitendinosus and M. triceps brachii caput longum.     

Effect of muscle and post-mortem rate of pH and temperature fall on antioxidant enzyme activities in beef

The aim of this study was to investigate the effect of muscle, inner and outer Musculus biceps femoris (IBF and OBF respectively) and Musculus longissimus dorsi (LD), on the post-mortem rate of pH and temperature fall, and the activity of superoxide dismutase (SOD), catalase (CAT) and glutathione peroxidase (GSH-Px) during simulated retail display. At day 0 of display (2 days post-mortem), the CAT and GSH-Px activities were lower in IBF than in OBF and LD (P < 0.001), and the SOD activity was lower in OBF compared to IBF and LD (P < 0.001). At day 10 of display, SOD and CAT activities had decreased in all three muscles compared to day 0 (P < 0.001), whereas the GSH-Px activity did increase with time of display. Across muscles, there were significant relationships between temperature fall, colour, lipid and colour stability and antioxidant enzyme activities.     

Intramuscular variation in beef tenderness

Intramuscular variation of beef tenderness was investigated in three muscles: Semitendinosus (ST), Triceps brachii (TB) and Rectus femoris (RF). The aim of the study was to evaluate a French process (called "affranchi") used to improve meat tenderness. Two groups of 72 muscles (24 ST, 24 TB and 24 RF) aged 10 and 14 days respectively, were assessed for tenderness by sensory analysis and compression measurements. For all three muscles, sensory evaluation showed a significant intramuscular variation in tenderness with a longitudinal gradient. Compression measurements on the raw meat showed similar results but of reduced accuracy. It appears that the process "affranchi" which consists in removing a part of the muscle, is very useful to improve meat tenderness and could be used by meat processors. The low relationship between compression measurements and sensory evaluation suggest compression measurements on raw meat are not suitable to predict meat tenderness as perceived by consumers.     

Tensile properties of cooked beef in relation to rigor temperature and tenderness

A study of the tensile properties of cooked strips from beef sternomandibularis which had gone into rigor at various temperatures showed no clear relationships with earlier observed variations in shear force with rigor temperature. A consistent feature of the load extension curves was a sudden increase in extensibility at a ‘change point’ of about 1 kg/cm². Some curves, particularly those for strips cooked under restraint, showed a third intermediate extensibility. Evidence points to modification of a myofibrillar component as the reason for the sudden changes.     

Effect of shortening during cooking on the tenderness and histology of beef

In muscles which have gone into rigor at 15°C or 37°C without shortening, prevention of cooking shortening leads to greater toughness than in samples cooked free. This tenderness difference is not seen in cold shortened muscles. A histological study showed that heat shrinkage of collagen imposes an irregular “cooking crimp” in unshortened muscle, cooked free. This is quite distinct from cold induced crimp. Cooking cold shortened muscle under restraint completely removes the cold crimp. A striking “crossed-diagonal” orientation of the perimysial collagen in the cooked meat is described.     

Effects of low-frequency electrical stimulation on beef tenderness

The application of 2 Hz, 500 V electrical stimulation to early post-mortem beef sides causes rapid muscle glycolysis, yet produces no trace of the extensive tissue rupture effected by 60 Hz current. By means of this low frequency technique, coupled with a mild or delayed-chill routine, we have examined the supposed tenderizing effect of rapid pH decline alone, without concurrent fiber fracture or cold-shortening intervention. Loin steaks from sides receiving this treatment were significantly tougher than those from paired control sides, an observation strongly suggesting that tenderization is hindered by rapid glycolysis. In other experiments, 60 Hz 500-V current was found to produce very extensive fracturing with breaks appearing (on average) every 6 mm of fiber length; this treatment resulted in a very significant tenderizing relative to that observed in the unstimulated control sides. It is concluded that, apart from its ability to prevent cold-shortening, normal-frequency high-voltage stimulation exerts its beneficial tenderizing action by fracturing the fibres; the accompanying acceleration of glycolysis actually causes a small, but definite, negative effect on eating quality.     

无磷酸盐制剂对牛肉嫩度和保水性的影响

研究一种新的制剂替代磷酸盐达到对牛肉保水嫩化的效果。通过L9(34)正交实验确定了制剂的最佳配比为苹果酸钠4%、醋酸钠1.5%、氯化钠1.5%、水93%。结果表明,此制剂具有较好的保水效果及嫩化能力,使牛肉的蒸煮损失率降低至14.79%(P<0.05),剪切力减少到22.90N(P<0.05)。     

Effects of early-postmortem glycolytic rate on beef tenderness

Electrical stimulation (ES) was applied at 500 V to one side from each of 60 beef carcasses at 30 to 40 min postmortem. Wide ranges of early-postmortem glycolytic and cooling rates were produced in the musculature by use of three different forms of ES (in addition to non-ES treatment of the contralateral sides) and application of chilling routines of four different degrees of severity. Panel and Warner-Bratzler shear evaluations of loin steaks from all 120 sides showed that tenderness was highest when glycolysis had proceeded at an intermediate rate (corresponding to the attainment of a 3-h pH of about 6·1) and was appreciably lower on both sides of this mid-value. The toughening effect of rapid glycolysis (relative to that of a moderately increased glycolytic rate) persisted through 14 days of aging at 2°C.

These observations appear to be incompatible with the view that lysosomal enzymes contribute significantly to ES-induced tenderization. They also indicate that the effect of ES on tenderness is highly dependent on the subsequent cooling rate, very slow chilling sometimes accelerating the already high rate of pH fall to such an extent that the tissue is significantly toughened. Finally, they suggest that the goal of maximizing the early-postmortem rate of pH decline in bovine muscle is misguided and, if attained, will cause sub-optimal tenderness.     

Early-postmortem cooling rate and beef tenderness

Four distinct early-postmortem cooling rates (as measured within the longissimus muscle) were obtained by exposing one side of each of five fat and five lean steers to moving air at -2° and the other to 9° static air. Loin steaks of the fastest cooling group were found to be the least tender and to have the shortest sarcomeres; the three remaining groups differed significantly from each other in tenderness but not in sarcomere length. For all twenty sides, regardless of treatment group, tenderness was highly dependent on, and almost linearly related to, the muscle temperature attained at 2 hours post mortem (27-40°), the relationship deteriorating rapidly as longer time intervals and lower temperature ranges were considered. The results indicate that (1) except in very rapidly chilled lean carcasses, cold shortening is not a significant determinant of tenderness; (2) the enhanced tenderness of slowly chilled beef is not due primarily to the relatively prolonged avoidance of shortening-inducive temperatures but to the accompanying retardation of cooling during the first 2-4 hours post mortem, when muscle temperatures are still far above those associated with cold shortening and (3) the generally recognised superior tenderness of well-finished beef is largely (and perhaps entirely) a consequence of slower cooling during this very early-postmortem period.     

Effect of ion fluid injection on beef tenderness in association with calpain activity

Sodium pyrophosphate plus sodium chloride (PPi) was injected into pre-rigor, hot boned biceps femoris (BF) and semimembranosus (SM) muscle from 12 heifer carcasses. The PPi injection caused higher pH values between 10 and 48 h post-mortem than found in the controls for both muscles (P<0.05). PPi injection resulted in faster decreases in the activities of μ-calpain and calpastatin than in the control for both muscles with time post-mortem (P<0.05). There were significant differences between treatments in both the BF and SM (P<0.05). There was evidence that PPi-injection elevated pH, and accelerated activation of calpains, resulting in improved tenderness. The rates of degradation of titin and troponin-T as well as the appearance of 95 and 30 kDa peptides were faster in the PPi-injected muscles than the controls. PPi-injection elevated muscle pH, which was attributed to acceleration of the calpain activation. It is concluded that PPi-injection improved beef tenderness by accelerating activation of calpain.