Influence of dietary oils and protein level on pork quality. 1. Effects on muscle fatty acid composition, carcass, meat and eating quality

This study evaluated the effects of three dietary oils - palm kernel (PKO), palm (PO) and soyabean (SBO) - and two protein levels - high (HP) and low (LP) in a 3×2 factorial design involving 60 pigs on growth performance, muscle fatty acid composition and content, carcass, meat and eating qualities. Oil type did not have a significant effect on growth and carcass quality. PKO significantly reduced the polyunsaturated (PUFA) to saturated (SFA) fatty acid (P:S) ratio in longissimus muscle (P<0.001). PKO increased the concentrations of lauric (12:0), myristic (14:0), palmitic (16:0) and stearic (18:0) fatty acids and decreased linoleic acid (18:2). The LP diet increased intramuscular fat (IMF) from 1.7g/100g muscle in HP to 2.9g/100g (P<0.001), increased tenderness by 0.6 units (P<0.01) and juiciness by 0.5 units (P<0.01) on the 1-8 scale, but at the expense of lower daily weight gain (P<0.01), lower feed conversion efficiency (P<0.01), reduced P:S ratio (P<0.001) and increased lipid oxidation (P<0.01). The results suggest that PKO and PO could be used in tropical developing countries as cheaper alternatives to SBO for the production of good quality and healthy pork, but their limits of inclusion need to be determined.     

Significance of fat supplemented diets on pork quality - Connections between specific fatty acids and sensory attributes of pork

The influence of two diets with different fatty acid compositions has been studied with regard to overall pork quality and significance of specific fatty acids on sensory attributes in fried chops and oven roasts. Twenty castrates and 20 females were in a balanced experimental set-up fed with a standard diet supplemented with α-tocopherol (200mg/kg feed) where the fat source was either 3% of palm oil or 3% rapeseed oil. After slaughter, despite differences in lipid composition and sensory attributes, no significant difference in overall meat quality parameters and flavour precursors was found. Comparison of the two diets showed that supplementation with rapeseed oil resulted in a significantly higher content of C18:3n-3 (polar lipid (PL), neutral lipid (NL)), C18:2n-6c (NL) and C20:2 (NL) in LD and C18:1n-9c, C18:2n-6c, C18:3n-3, C20:3n-3, C22:5n-3 in backfat, while supplementation with palm oil resulted in a higher content of C16:0 (NL), C16:1 (PL), C18:1n-9t (NL) in LD and C16:0, C17:0, C18:0, C16:1, C20:4n-6 in backfat. A positive and significant correlation between the contents of C18:2n-6c, C20:3n-6 in the PL fraction and the sensory attributes fried meat odour and sweet odour were found in fried pork chops from female pigs. Likewise, positive correlations were seen between the content of C18:1n-9c in the PL fraction and sensory attributes such as sourish odour, piggy odour and piggy flavour in whole oven roasts. These data substantiate the view that specific fatty acids in the PL fraction influences flavour attributes in pork.     

Sensory quality of short- and long-term frozen stored pork products. Influence of diets varying in polyunsaturated fatty acid (PUFA) content and iodine value

Predicting aspects of pork quality is becoming increasingly important from a nutritional as well as a technological point of view. Here, the influence of increasing PUFA and iodine values (IV) in feed and pigs on sensory qualities of short- and long-term frozen stored products was investigated. Entire male and female grower-finisher pigs were fed diets with iodine value products of 48 (LowIVP), 77 (MedIVP) or 99 (HighIVP) according to a restricted feeding scale. Ribs, chops and meat balls were short- (0-3 months) and long-term (6-9 months) frozen stored before sensory profiling. C18:2n−6 increased linearly in backfat with increased dietary inclusion. No negative effect on sensory quality was found in short-term stored products. After long-term storage the lean chops was the product most affected. Increasing the dietary IVP led to an increased rancid and total odour and flavour intensity, and to reduced meat and sour odour and flavour.     

Effect of visual marbling on sensory properties and quality traits of pork loin

Pork loins (N = 53) were selected from a commercial packing plant to determine the influence of subjective marbling score on sensory attributes and eating quality properties. The pork loins were obtained from commercially raised hybrid barrows (average carcass weight = 67.7 kg), originating from nine cooperating herds, and fed similar diets throughout the finishing period. Carcass quality measurements, trained sensory panel analyses, fatty acid composition, thiobarbituric acid-reactive substance (TBARS) index, and cholesterol content were assessed and analyzed on the individual pork loins. With an increase in marbling level, there was a corresponding decrease in drip loss (P = 0.049) and observed increases in pH (P = 0.001), sensory tenderness (P = 0.001), and sensory juiciness scores (P = 0.017). The most notable results demonstrated that protein concentrations were reduced as marbling levels amplified (P = 0.012). The increase in marbling score was observed to be a significant source of variation in polyunsaturated fatty acid (PUFA) concentrations. Linoleic and arachidonic acids decreased in both raw and cooked samples as marbling score increased. The data demonstrated that visual marbling score does have an influence on sensory properties and pork quality.     

Effects of triticale-based diets on finishing pig performance and pork quality in deep-bedded hoop barns

Effects of triticale diets on pig performance and pork quality were evaluated in summer and winter. Diets were: corn-soy, 40% triticale, or 80% triticale. Pigs (72 kg) were fed 49 d. Loins were evaluated for meat and fat quality and sensory evaluation. Average daily gain decreased as triticale inclusion increased (P < 0.01). Feed intake was similar. Pigs fed corn-soy had the greatest and those fed 80% triticale had least gain:feed ratio (P < 0.05). In summer, pigs fed corn-soy had largest and those fed 80% triticale diet had smallest loin muscle area (P < 0.05) based on ultrasound scan. During summer, ultimate pH was higher (P ? 0.001) and, loin purge and shear force were lower (P < 0.05). Diet did not affect sensory evaluation or fatty acid profile of loins. During summer, total MUFA were more and total PUFA were less (P ? 0.01). Triticale fed to pigs in hoop barns slightly decreased growth without compromising pork quality.     

Factors affecting the eating quality of pork

In the last decade studies with the specific objective of improving the sensory quality of pork have come to the forefront of meat research, likely a result of consumer complaints of blandness levelled against modern lean meat and the frequent reference to the more strongly flavored meat that was available years ago. Regardless of the lack of scientific evidence to substantiate or refute these claims, the consumer perception of deteriorated quality is real and presents a challenge for the pork industry. Hence, this review has been undertaken with the aim of providing insight into potential sources of amelioration of the eating quality of fresh pork. Existing works are collated, encompassing animal effects, such as, species, breed, muscle type, fat, and ultimate pH, as well as environmental influences, including pre-slaughter conditions of and housing and exercise, and post-slaughter parameters, such as, electrical stimulation, chilling, and cooking.     

Effects of muscle cortisol concentration on muscle fiber characteristics, pork quality, and sensory quality of cooked pork

The effect of muscle cortisol concentration on muscle fiber characteristics and technological and sensory quality of pork was investigated. With the exception of the percentage of type IIA fibers, muscle fiber characteristics were not associated to cortisol levels. However, muscle cortisol concentration was positively associated with muscle pH(24h) (r = 0.23, P<0.05) and negatively associated with drip loss (r = -0.49, P<0.001), lightness (r = -0.24, P<0.05), shear force (r = -0.25, P<0.05), and texture profile analysis-hardness (r = -0.35, P<0.01). Additionally, the water-holding capacity of meat samples was affected by cortisol levels, with lower cortisol concentrations associated with less tender samples. These results indicate that the concentration of cortisol in the muscle is related with meat quality as well as the sensory quality of cooked pork.     

Production systems and influence on eating quality of pork

The present paper reviews the available information on the eating quality of pork from the perspective of production systems considered at farm level. Among the specifications differentiating systems having a claim on eating quality, breed, feeding strategy, rearing conditions and slaughter age/weight of the pigs may influence pork eating quality. Specific genetic X environment interactions such as the use of slow growing-fat local breeds reared in extensive conditions, as encountered in local Mediterranean systems, lead to high eating quality of pork and pork products Organic production per se has little influence on the eating quality of pork. Welfare-oriented specifications such as enriched living environment, outdoor access or free-range rearing have limited consequences on pork quality. Because boar taint negatively impacts the consumer acceptability of pork, a total ban on castration to improve animal welfare would be a real challenge for the management of pork quality in those countries where entire male pig production is not currently common.     

The influence of carcass backfat and intramuscular fat level on pork eating quality

To evaluate the contribution of fatness level towards pork eating quality, carcass and meat eating quality data were analysed from 721 pigs of three genotypes (with 0, 0.25 and 0.50 Duroc inclusion level). Animals (entire male and female) were reared from 30 to 90 kg liveweight on one of seven feeding regimens which involved combinations of diet formulation and feeding level, so as to produce carcasses of widely differing fatness levels. This experimental design produced coefficients of variation for classification P₂ backfat thickness of 21.11 (mean 11.59 mm, SE 0.093) and intramuscular fat (IMF) of 63.60 (mean 13.4 g kg⁻¹, SE 0.33). The treatments also produced considerable variation for eating quality as assessed by trained sensory panel (1–8 scale) and objectively (shear force) as shown by the following coefficients of variation: shear force 22.01% (mean 334 N, SE 2.77), juiciness 16.12% (mean 4.95, SE 0.297), tenderness 19.65% (mean 5.06, SE 0.370), pork flavour 13.22% (mean 4.56, SE 0.225), abnormal flavour 34.46% (mean 2.02, SE 0.259) and overall acceptability 18.42% (mean 4.78, SE 0.328). Correlation coefficients between carcass fatness measurements and eating quality characteristics were calculated. Although shear force was significantly correlated with both classification P₂(r = −0.213) and IMF (r = − 0.189), taste panel tenderness was not significantly correlated to fatness level. Of the taste panel parameters evaluated, only juiciness showed a significant correlation (P < 0.05) with classification P₂(r = − 0.086). None of the eating quality characteristics as evaluated by taste panel correlated significantly with IMF. These results do not support the belief that fatness level per se has a major influence on pork eating quality. © 2000 Society of Chemical Industry     

Effect of fat quality on sausage processing,texture, and sensory characteristics

Fresh pork sausage was manufactured to determine the effects of animal diet (unsaturated or control) and inclusion of corn oil during processing (0% and 14% fat replacement). Bologna was manufactured to investigate only diet effects. Processing, textural, sensory, visual, and storage characteristics were evaluated. Processing yield was improved 2.9 percentage units in fresh sausage but reduced 1.8 units in bologna in unsaturated compared with control diets. Break strength of fresh sausage was reduced 0.6 kg by oil inclusion. Both unsaturated fat and including oil during processing resulted in softer texture of fresh sausage, while increased unsaturation in bologna resulted in firmer or unchanged textural properties. Fresh sausage with oil was lighter colored (5.3 L* units increased) with more fat smearing. In fresh sausage, lipid oxidation remained below 1 mg/kg MDA during 12 weeks frozen storage. Overall, changes in fat quality minimally affected sausage quality, likely providing acceptable products to consumers.     

Effect of dietary antioxidant and fatty acid supply on the oxidative stability of fresh and cooked pork

The effect of dietary oil (linseed or soybean oil) and antioxidant treatment (α-tocopheryl acetate (AT; 40ppm) versus a cocktail (AOC; 200ppm): α-tocopheryl acetate+rosemary+citric acid+gallic acid) on colour, lipid and protein oxidation of fresh and processed pork was investigated. No effect of oil source on different parameters of oxidation was seen. No effect of antioxidant treatment on colour stability of fresh longissimus thoracis (LT) or cooked cured ham (CCH) was observed. For both antioxidant treatments, lipid oxidation in fresh LT and CCH was well controlled during display. However, lipid oxidation increased significantly in pre-frozen uncured cooked meat under aerobic conditions. No unambiguous effect of antioxidant treatment on protein oxidation was observed. There seemed to be no clear link between colour, protein and lipid oxidation. At the dose used in this study, no additional or synergistic effects of the extra components of the AOC on the different oxidation parameters was found.     

肌内脂肪与背最长肌肉质、脂肪酸组成的关系

研究肌内脂肪（IMF）含量与肉质以及脂肪酸含量和组成比例之间的关系。以北京黑猪背最长肌（n=20）为实验材料,测定肌内脂肪含量、肉质以及脂肪酸含量和组成。结果显示,肌内脂肪含量与滴水损失呈显著正相关（p<0.05）,与蒸煮损失、剪切力、肉色的相关性不显著（p>0.05）。随着肌内脂肪含量升高,除长链多不饱和脂肪酸(C_20:3n6、C_20:4n6)以外的大多数脂肪酸含量增加,相对比例也上升;多不饱和脂肪酸的含量增加,但是相对比例下降;长链多不饱和脂肪酸的含量和相对比例都降低。随着肌内脂肪含量的升高,饱和脂肪酸（SFA）和单不饱和脂肪酸（MUFA）的含量升高,回归方程斜率分别为197.3和248.31,多不饱和脂肪酸（PUFA）增加的幅度不大,回归方程的斜率为11.43。结果提示:肌内脂肪含量较低时（本实验平均值2.86%）,对肉质的影响不显著。随着肌内脂肪含量升高,总脂肪酸含量（TFA）增加,主要归因于SFA和MUFA含量的增加。PUFA的含量相对稳定,受肌内脂肪含量变化的影响较小。      

Trained sensory perception of pork eating quality as affected by fresh and cooked pork quality attributes and end-point cooked temperature

The present study evaluated individual and interactive influences of pork loin (n = 679) ultimate ph (pH), intramuscular fat (IMF), Minolta L∗ color (L∗), Warner-Bratzler shear force (WBSF), and internal cooked temperatures (62.8 °C, 68.3 °C, 73.9 °C, and 79.4 °C) on trained sensory perception of palatability. Logistical regression analyses were used, fitting sensory responses as dependent variables and quality and cooked temperature as independent variables, testing quadratic and interactive effects. Incremental increases in cooked temperature reduced sensory juiciness and tenderness scores by 3.8% and 0.9%, respectively, but did not influence sensory flavor or saltiness scores. An increase of 4.9 N in WBSF, from a base of 14.7 N (lowest) to 58.8 N (greatest) was associated with a 3.7% and 1.8% reduction in sensory tenderness and juiciness scores, respectively, with predicted sensory tenderness scores reduced by 3.55 units when comparing ends of the WBSF range. Modeled sensory responses for loins with pH of 5.40 and 5.60 had reduced tenderness, chewiness, and fat flavor ratings when compared with responses for loins with pH of 5.80 to 6.40, the range indicative of optimal sensory response. Loin IMF and L∗ were significant model effects; however, their influence on sensory attributes was small, with predicted mean sensory responses measurably improved only when comparing 6% and 1% IMF and L∗ values of 46.9 (dark) when compared with 65.0 (pale). Tenderness and juiciness scores, were related to a greater extent to loin WBSF and pH, and to a lesser extent to cooked temperature, IMF and L∗.     

The influence of pork quality traits and muscle fiber characteristics on the eating quality of pork from various breeds

The purpose of this study was to compare parameters associated with pork quality, muscle fiber, and eating quality among various breeds, and to examine if differences in eating quality were associated to pork quality and muscle fiber characteristics. For carcass and pork quality, although there were significant differences among breeds, the values of parameters in all pigs were assigned a normal quality class, a likely outcome of the similarity in the area percentage of type I and IIB fibers. For eating quality, pork loins from Berkshire pigs were more tender and full of pork flavor than Landrace and Yorkshire pigs. Except juiciness and mouth coating, over 20% of the variability in the eating quality parameters can be explained by pork quality traits and muscle fiber characteristics using multiple regression analysis. Furthermore, differences in muscle pH_24 h, cooking loss, shear force, and NPPC marbling score could explain a large proportion of variation in eating quality parameters associated with the texture of pork.     

Correlations of trained panel sensory values of cooked pork with fatty acid composition,muscle fiber type,and pork quality characteristics in Berkshire pigs

The objective was to examine the relationship of trained panel sensory scores of cooked pork with fatty acid composition, muscle fiber type, and meat quality characteristics from Berkshire pigs. No or few associations were found between the panel sensory scores of cooked meat, especially tenderness attributes, and fatty acid composition; however, intramuscular fat content positively correlated with off-flavor score (r = 0.31). On the other hand, the morphological characteristics of muscle fibers were correlated with panel sensory values. Muscles with smaller cross-sectional area and higher density of fibers were more closely associated with softer, more tender panel scores and a lower number of chews than muscles with larger fiber area and lower density of fibers. The water holding capacity test of filter-paper fluid uptake was moderately correlated with panel scores of softness (r = 0.33), initial tenderness (r = 0.38), chewiness (r = 0.40), juiciness (r = − 0.27), flavor intensity (r = − 0.23), and off-flavor (r = 0.30). Panel sensory values of Berkshire pig meat was moderately related to postmortem meat quality, especially water holding capacity. A more thorough understanding of the relationships between fatty acid composition and muscle fiber type with palatability is needed.     

Association between polymorphisms of the heart fatty acid binding protein gene and intramuscular fat content,fatty acid composition,and meat quality in Berkshire breed

The objective of this study was to examine the relationship between polymorphisms of the heart fatty acid binding protein (H-FABP) gene and variation in intramuscular fat (IMF) content, fatty acid composition, and meat quality in Berkshire breed. We detected an association between IMF content and H-FABP HinfI restriction fragment length polymorphism (RFLP) genotype. The HH genotype showed the greatest IMF content among the genotype classes (P < 0.05). Regarding meat quality traits, only drip loss was significantly different among the H-FABP HinfI RFLP genotype classes (P < 0.01). In the case of fatty acid composition, the degree of saturation of fatty acids was greater in hh-genotype pigs than in HH and Hh genotypes. The H-FABP MspI RFLP genotype affected unsaturated fatty acid content, and the ratio of polyunsaturated fatty acid to saturated fatty acid (P < 0.05), whereas the H-FABP HaeIII RFLP genotype had no effect on fatty acid characteristics.     

Changes in fatty acid composition and improved sensory quality of backfat and meat of pigs fed bacterial protein meal

A total of 48 pigs (11.4 and 107.2 kg initial and final weight) were used to evaluate increasing dietary levels of bacterial protein meal (BPM) produced on natural gas (0, 50, 100, or 150 g kg⁻¹) on fatty acid composition, sensory properties, and susceptibility of pork to lipid oxidation. Increasing levels of BPM to diets increased the content of C16:1 fatty acids in backfat and muscle and total monounsaturated fatty acids in muscle, but decreased the content of polyunsaturated fatty acids and iodine value in backfat and muscle. Pigs fed diets containing BPM had reduced thiobarbituric acid reactive substances (TBARS) value in backfat and muscle, reduced intensity of odor and rancid odor and taste in pork after short-time storage, and reduced off-odor and off-taste after intermediate-time storage. To conclude, adding BPM to diets for pigs changed the fatty acid profile, improved the oxidative stability, and sensory quality of pork.     

Consumer perceptions of pork eating quality as affected by pork quality attributes and end-point cooked temperature

The study evaluated the interactive and individual effects of fresh pork loin (n = 679) ultimate pH (pH), intramuscular fat (IMF), Minolta L^* color (L^*), Warner–Bratzler shear force (WBS), and four cooked temperatures (62.8 °C, 68.3 °C, 73.9 °C, and 79.4 °C) on consumer (n = 2280) perception of eating quality (n = 13,265 observations). Data were analyzed using ordered logistical regression. Predicted mean responses were consistently near or under five on the 1–8-point end-anchored scale, indicating a neutral perception of pork eating quality regardless of fresh quality or cooked temperature. Responses improved as IMF and pH increased and WBS decreased, whereas L^* did not contribute significantly to variation in responses. Increasing IMF resulted in a very small incremental improvement in responses, but was of practical size only when comparing the least (1%) to the greatest (6%) levels. Loin pH and WBS were primary contributors to consumer perceptions, whereby an incremental increase in pH (0.20 unit) and decrease in WBS (4.9 N) resulted in a 4–5% reduction in the proportion of consumers rating pork as 6 (favorable) on the 8-point scale. No interactions between quality and temperature effects were observed. Increased cooked temperature was negatively (P < 0.05) associated with Overall-Like and Tenderness ratings, but the incremental effect was small. Juiciness-Like and Level responses decreased by 0.50 units as temperature increased across the range. Consumer responses favor pork with lower WBS, greater pH and IMF, and pork cooked to a lower temperature.     

Effect of source of dietary fat on pig performance,carcass characteristics and carcass fat content,distribution and fatty acid composition

Seventy gilts were used to compare the effect of including 10% tallow (T), high-oleic sunflower oil (HOSF), sunflower oil (SFO), linseed oil (LO), a fat blend (FB), or an oil blend (OB) in finishing diets vs. feeding a semi-synthetic diet with no added fat (NF) on pig performance, carcass traits and carcass fatty acid (FA) composition. Carcasses from SFO-fed gilts had greater fat and lower lean compositions than carcasses from T-fed gilts. Gilts fed NF had greater loin fat than FB-fed gilts, and greater flare fat, loin intermuscular fat and fat:lean than T-fed gilts. Bellies from NF-fed gilts had lower lean and higher intermuscular fat and fat:lean than other diets except HOSF. Fat source had minor effects on animal performance, carcass characteristics and carcass fat content and distribution, whereas feeding NF resulted in carcasses and major cuts with higher fat content. Diets rich in polyunsaturated FA (PUFA) did not reduce fat deposition in separable fat depots with respect to monounsaturated FA (MUFA) and saturated FA (SFA). Carcasses from gilts fed NF had a high degree of saturation (40.6% SFA) followed by carcasses of T- and FB-fed gilts. Feeding HOSF, SFO and LO enriched diets elevated the percentages of MUFA (56.7%), n−6 (30.0%) and n−3 (16.6%) PUFA, respectively, whereas carcasses from gilts fed OB had greater percentages of n−3 FA (14.8% n−3, 0.9% EPA, 1.0% DPA, 3.1% DHA) than gilts fed FB (6.72% n−3, 0.1% EPA, 0.4% DPA, 0.1% DHA).     

Influence of dietary inclusion level of manganese on pork quality during retail display

Boneless pork loins (n = 112) were used to test the influence of dietary manganese (Mn) inclusion level on pork quality traits during retail display. Crossbred barrows and gilts were fed diets formulated with 0, 20, 40, 80, 160, or 320 ppm Mn from Availa^®Mn (AvMn; a Mn–amino acid complex) from 23.8 to 106.8 kg live weight. At approximately 48 h postmortem, boneless pork loins were fabricated into longissimus thoracis et lumborum (LM) chops, which were subsequently placed in open-topped, coffin-chest display cases (2.6 °C) under continuous warm-white, fluorescent lighting (1600 lx) for 7 days. Dietary Mn level had no effect on LM pH (P = 0.47), purge volume (P = 0.60) and loss (P = 0.53), or moisture loss (P = 0.95) during retail display. Chops from pigs fed 80 ppm Mn received higher (P < 0.05) American and Japanese color scores than pigs fed 0 and 40 ppm Mn. Even though the LM from pigs fed 80, 160, and 320 ppm Mn tended to be darker (lower L^* values; P = 0.07) than chops from pigs fed 40 ppm Mn, a^* (redness) and b^* (yellowness) values, as well as hue angle and chroma, were not (P  0.19) affected by dietary Mn. On days 0 and 1, the reflectance ratio of 630 nm/580 nm was similar (P > 0.05) among dietary Mn supplementation levels; yet, by day 4 of retail display, chops from pigs fed 80 ppm Mn had higher (P < 0.05) reflectance ratios than chops from pigs fed 0, 20, 40, and 160 ppm, whereas LM chops from pigs fed 40 ppm Mn had lower (P < 0.05) reflectance ratios than all other dietary treatments on day 7 (Mn supplementation level × display day; P = 0.04). Although TBARS were greater (P < 0.001) on day 7 than 0 of retail display, TBARS values did not (P = 0.43) differ among dietary Mn levels. Results indicate that supplementing swine diets with 80 ppm Mn may improve pork color during retail display without increasing the likelihood of lipid oxidation.