Kinetics of haze formation and factors influencing the development of haze in clarified apple juice

The rate of haze formation in commercial clarified apple juice stored at 4, 25 and 37°C was monitored over a 16 to 35-week storage period. Changes in turbidity, tannin content and browning index were evaluated. The juice appeared virtually clear and had very little colloidal particles during the initial stages of storage. After 24 weeks, an increase in turbidity of 2.32 NTU was observed for juice samples stored at 37°C. An increase of 0.58 and 0.95 NTU was observed for samples stored at 25 and 4°C, respectively. There was a general decrease in tannin content and an increase in browning index with storage; this effect was most pronounced for samples stored at 37°C. The rate of haze formation and tannin depletion in juice samples followed first-order reaction kinetics. Light and headspace did not affect haze formation. NaCl and CaCl₂ increased haze development while sucrose (up to 60%), urea (0.5 M), and EDTA (up to 0.01 M) had little effect. Addition of sodium dodecyl sulfate retarded haze formation.     

Effect of storage on non‐enzymatic browning of liquid infant milk formulae

Furfural, hydroxymethylfurfural (HMF), furosine, lactulose, ascorbic acid and absorbance at 284 and 420 nm (A₂₈₄ and A₄₂₀) were all determined in two types of liquid infant formula prepared with different processing protocols. These browning indicators were used to assess the effects of storage and modified atmosphere on the shelf‐life of infant formulae. The study was carried out at 20 and 55 °C for 15, 30 and 90 days. At 20 °C, slight browning was observed and could be evaluated by furosine, furfural and total HMF indicators. At 55 °C, formula type A (pasteurised, spray‐dried and reconstituted) showed more browning in nitrogen storage conditions than did type B. Furfural, HMF, lactulose, A₂₈₄ and A₄₂₀ are useful indicators to control the extent of browning reactions in adverse storage conditions. © 2002 Society of Chemical Industry     

Changes in Muscadine Grape Juice Quality During Cold Stabilization and Storage of Bottled Juice

Muscadine grapes (Vitis rotundifolia, Michx.) of two cultivars (Noble and Carlos) were washed and extracted. The resulting juice was cold stabilized for 0, 7 and 60 days at 2°C, then treated, bottled, pasteurized and stored at 2°C and 24°C for 0, 4, 8, and 12 months. Carlos juice was lower in phenols and pH and higher in acidity than Noble. The high total anthocyanins and phenols in the Noble juice caused a significant loss in pigment during cold stabilization. Dilution of juice with 40% water and adjustment of the sugars was beneficial to flavor and color of Carlos, yet 40% dilution was too high for Noble juice. Treatment of either juice with CaCO₃ increased pH and decreased acidity. During 12 months storage, the Carlos juice became darker due to browning, while the Noble juice became lighter by losing pigment, especially at 24°C.     

Effect of storage on nonenzymatic browning reactions in carob pekmez

Carob pekmez was stored at 5, 25, 35 and 45 °C for studying the reaction kinetics of nonenzymatic browning reactions. Hydroxymethylfurfural (HMF) formation, browning index (A₄₂₀) and CIE (International Commission on Illumination) colour parameters were analysed to evaluate nonenzymatic browning reactions. HMF formation and A₄₂₀ values increased linearly with the storage time and temperature and both followed zero‐order reaction. No fitting model was found for the changes in visual CIE parameters. The dependence of rate constant of nonenzymatic reactions on temperature was represented by an Arrhenius equation and the activation values were found as 114.87 kJ mol^?1 and 86.62 kJ mol^?1 for HMF formation and A₄₂₀ values, respectively. The excellent linear correlations (r = 0.728–0.99) among colour parameters, browning index and HMF were found.     

Effects of dehydration temperatures on colour and polyphenoloxidase activity of Amasya and Golden Delicious apple cultivars

During dehydration at different temperatures (60, 70 and 80 °C) of Amasya and Golden Delicious apple cultivars, changes in colour, polyphenoloxidase activity (PPO), browning index and hydroxymethylfurfural (HMF) content were studied. Effects of dehydration time on the L* values of both cultivars were not significant. Only Amasya samples dehydrated at 80 °C were found to have significantly higher L* values than the remaining samples. In all cases, Golden Delicious samples had higher L* values than those of the Amasya cultivar. a* values of samples increased within the first hour of dehydration and then remained almost unchanged. The enzyme activity showed a rapid decrease in the first hour of dehydration and residual enzyme activities (%) reached 9.8%, 5.3% and 4.5% for Amasya, and 17.4%, 10.3% and 4.6% for the Golden Delicious cultivar at 60, 70 and 80 °C, respectively. In all final samples the residual enzyme activities were around 1%. The highest browning values were observed at the second hour of dehydration at 60 and 70 °C and the first hour of dehydration at 80 °C. In all conditions Amasya apples had a higher browning tendency. The presence of HMF was detected only at the 4th hour of dehydration at 80 °C for both cultivars. Effects of dehydration temperature on colour and PPO of the final product were insignificant. However, an important effect of temperature was determined on the browning index of Golden Delicious samples. The lowest browning tendency was measured on samples dehydrated at 80 °C. The results showed that cultivar and dehydration temperature had considerable effect on the browning of apple slices. Copyright © 2006 Society of Chemical Industry     

Nonenzymatic Browning in Pear Juice Concentrate at Elevated Temperatures

The effect of temperature and soluble solids (°Brix) on nonenzymatic browning in pear juice concentrate was determined by following absorbance at 420 nm (A₄₂₀) over the temperature range of 50–80°C. Browning could be modeled as a zero order rate process with rates of 22.2 × 10⁻⁴ (45.2 °Brix), 36.9 × 10⁻⁴ (55.4 °Brix), 53.5 × 10⁻⁴ (65.1 °Brix) and 107 × 10⁻⁴ (72.5 °Brix) A₄₂₀· min⁻¹ at 80°C. Temperature dependence was described by the Arrhenius relationship with an average activation energy of 21.9 kcal · mole⁻¹. Formol titration indicated a 20% loss of amino acids during heating 4.4 hr at 80°C and no loss of carbohydrates was observed after any heating period.     

Influence of ultra-high pressure homogenisation on physicochemical and sensorial properties of orange juice in comparison with conventional thermal processing

The effect of different ultra-high pressure homogenisation (UHPH) treatments on physicochemical and sensorial properties of orange juice was studied in comparison with thermal pasteurisation (90 °C, 1 min). UHPH treatments consisted on combinations of two inlet temperatures (10 or 20 °C) and three pressures (100, 200 and 300 MPa). Effect of treatments was assessed on general quality parameters (colour, pH, °Brix, titratable acidity, reducing sugars and non-enzymatic browning index), particle size distribution and cloud stability. None of the UHPH treatments caused significant differences in the °Brix, reducing sugars, pH and non-enzymatic browning index with respect of fresh or pasteurised juice. Only titratable acidity was significantly lower when inlet temperature of UHPH treatments was 20 °C. UHPH treatments significantly reduced the particle size and in consequence the cloudiness and the total colour value (∆E*) increased. The overall consumer acceptability of UHPH and pasteurised juices was similar.     

Heat Induced Browning of Clarified Apple Juice at High Temperatures

A procedure to determine deterioration reaction kinetics of fluid foods at elevated temperatures is described. With this method the nonenzymatic browning (NEB) measured as O.D. at 420 nm of Red Delicious (RD) and Granny Smith (GS) apple juices was examined. Color development at 15°, 30°, 50°, and 70° Brix and temperatures ranging from 90–108°C were compared over 60 min. Results indicated an apparent first order reaction rate depending on temperature, apple juice composition and soluble solids. Browning occurred at a more rapid rate in GS juice. NEB reaction rate was shown to depend critically on the total amino acid content. Temperature dependence followed the Arrenhius equation and the activation energy (E_a) ranged from 22.0–24.8 Kcal/mole.     

Effect of Heating Rate on Thermally Formed Myosin, Fibrinogen and Albumin Gels

Myosin, fibrinogen and albumin gels were formed by heating in pH 6.0 phosphate buffer at three heating rates. Turbidity (A_660nm) and solubility were monitored along with gel strength, as measured with an annular pump. Myosin and fibrinogen suspensions became turbid and solubility decreased as temperatures preceding the development of gel strength. Linearly increasing heating rates of 12°C/hr and 50°C/hr produced the strongest myosin and fibrinogen gels at 70°C, whereas albumin gels formed at 95°C by heating at 12°C/hr or constant heating for 20 min did not differ in strength.     

Multi-frequency power thermosonication treatments of clear strawberry juice: Impact on color,bioactive compounds,flavor volatiles,microbial and polyphenol oxidase inactivation

Strawberry juice is popular among consumers for its bright color, unique flavor and rich nutrition. The aim of this study was to explore the suitable multi-frequency power thermosonication (TS) treatments to meet the requirements of microbiological safety for strawberry juice while maximizing the preservation of its quality properties. The TS treatments included 60 °C /5 min and 55 °C /15 min under dual-frequency concentrated ultrasound (DCU) and 60 °C /15 min and 55 °C /20 min under sweep-frequency divergent ultrasound (SDU). The results showed that all treatments could meet the requirements of commercial sterility (at 90 °C for 1 min). Compared with thermal processing (TP) at 90 °C for 1 min, TS treatment significantly improved the color properties of strawberry juice. SDU-60 °C and SDU-55 °C greatly retained the active ingredients in the strawberry juice. TS treatments had a stronger ability to maintain the aroma compared to TP. Especially, SDU-60 °C was the best treatment at retaining quality properties of strawberry juice with the highest comprehensive sensory evaluation score (7.68). Therefore, the results can provide scientific basis for industrial production of strawberry juice.Industrial relevanceIn the current study, results showed that TS maximized the overall quality of strawberry juice while achieving the effect of sterilization and enzyme inactivation. Among them, SDU-60 °C was the best treatment method to maintain the quality characteristics of strawberry juice, which can effectively reduce the loss of approximately 70% of total phenolic content. Thus, it provides the theoretical basis and technical support for the industrial production of strawberry juice.     

Effects of thermosonication and orange by‐products extracts on quality attributes of carrot (Daucus carota) juice during storage

Effect of thermosonication on carrot juice containing peel (CJPL) and pulp (CJPP) extracts from orange at different concentration (0.5, 2.0 and 4.0 mg GAE per g extracts) of total phenolic contents (TPC) was evaluated for quality attributes. Thermosonication of juice was done at 52 °C, 6 min for CJPL and 60 °C, 5 min for CJPP (values based on our preliminary optimisation results of ultrasound process conditions of the juice) at 40 kHz and 110W. Effect of thermosonication and addition of peel and pulp extracts at highest concentration increased the TPC and antioxidant activity of the juice (P < 0.05). Highest inactivation of microorganisms and better sensory attributes was achieved in thermosonicated CJPP for 21 days. Titratable acidity, pH, browning index and viscosity were improved by thermosonication and at highest extract concentration. °Brix and total carotenoid were not significantly affected by treatments. Therefore, thermosonication at 60 °C and 4.0 mg GAE per g extract concentration of peel and pulp may be used in formulation of functional carrot juice with improved health properties.     

Kinetic modelling of non-enzymatic browning of apple juice concentrates differing in water activity under isothermal and dynamic heating conditions

The kinetics of non-enzymatic browning in apple juice concentrates were investigated. The effect of a_w (in the range of 0.74–0.99) and/or reactant concentration on brown pigment formation was monitored under isothermal heat treatment at four temperatures (60, 70, 80 and 90 °C) in apple juice solutions having either the same or different concentrations of reactant solutes. The extent of the Maillard reaction was evaluated by spectrophotometric measurements at 420 nm (A₄₂₀). The absorbance–time curves were fitted to five different kinetic models (zero and first order, weibull, logistic and the parabolic model) and estimates of browning rate constants and other model parameters were obtained. Regression analysis revealed that the logistic model was the most appropriate for describing browning in apple juice. The initial reactant concentration, but not water activity, had a significant effect on the colour change of apple juice. The processing temperature also had a strong impact on browning kinetics. Secondary models, expressing the dependence of the best fitted primary model parameters on temperature and a_w, were further developed and validated by comparing the predicted model parameters with the values observed in independent isothermal experiments. Finally, the derived model was further evaluated against the observed browning responses of apple juice under dynamic heating conditions, underlining the applicability of the developed model as a practical prediction tool for the study of non-enzymatic browning.     

Effects of Commercial-scale Pulsed Electric Field Processing on Flavor and Color of Tomato Juice

Effects of commercial‐scale pulsed electric field (PEF) processing on the flavor and color of tomato juice during storage at 4 deg;for 112 d were studied. Tomato juice was prepared by hot break at 88°C for 2 min and then thermally processed at 92° for 90 s or PEF processed at 40 kV/cm for 57 μs. The PEF‐processed tomato juice retained more flavor compounds of trans‐2‐hexenal, 2‐isobutylthiazole, cis‐3‐hexanol than thermally processed or unprocessed control tomato juice (P < 0.05). PEF‐processed juice had significantly lower nonenzymatic browning and higher redness than thermally processed or control juice (P < 0.05). Sensory evaluations indicated that the flavor of PEF‐processed juice was preferred to that of thermally processed juice (P < 0.01).     

Purification and properties of pectinesterase from papaya

Pectinesterase (PE) was partially purified from papaya pulp, and its biochemical properties were studied. The enzyme was eluted in a single peak after DEAE-cellulose and Sephadex G-100 chromatography. The PE had a molecular weight of 53000 and showed an optimum pH of 8.0. Its activity was dependent on an NaCl concentration of 0.2M . The enzyme was heat stable: approximately 80% of the original activity remained after 60 min of heating at 50°C but completely inactivated by incubation at 80°C for 1 min. The activity was linear with time and protein concentration. The maximum reaction in 3 min was found at 60°C and the initial rate increased 9-fold from 20 to 60°C. The estimated K_m was 0.12g litre^?1 with citrus pectin as the substrate. The kinetic study revealed that polygalactur-onic acid is a competitive inhibitor, and a K_i value of 0.07 g litre^?1 was determined. On the basis of this study, papaya PE properties resembled those of pectinesterase from other sources.     

Kinetic study of high pressure microbial and enzyme inactivation and selection of pasteurisation conditions for Valencia Orange Juice

Keeping quality of fresh orange juice is highly dependent on pectinolytic enzyme activity and the growth of spoilage microorganisms. The inactivation kinetics of indigenous pectin methylesterase (PME) and of the two more pressure resistant species of spoilage lactic acid bacteria (LAB) Lactobacillus plantarum and L. brevis in freshly squeezed Valencia orange juice under high hydrostatic pressure (100–500 MPa) combined with moderate temperature (20–40 °C) was investigated. PME inactivation followed first order kinetics with a residual PME activity (15%) at all pressure–temperature combinations used. The values of activation energy and activation volume were estimated at each pressure and at each temperature, respectively. Values of 90 kJ/mol and ?30 mL/mol at reference pressure of 300 MPa and reference temperature of 35 °C were estimated respectively. The corresponding z_T and z_P values of LAB inactivation were also estimated at all conditions tested. Values of 19.5 °C and 95 MPa at reference pressure of 300 MPa and reference temperature of 30 °C were estimated respectively for L. plantarum, while the corresponding values for L. brevis were 40 °C and 82 MPa, respectively, at the same reference conditions. Pressure and temperature were found to act synergistically both for PME and LAB inactivation. The PME and LAB inactivation rate constants were expressed as functions of the temperature and pressure process conditions. These functions allow the determination of the pressure/temperature conditions that achieve the target enzyme and microbial inactivation at a selected processing time. The process conditions of 350 MPa at 35 °C for 2 min are proposed as effective for Valencia orange juice cold pasteurisation.     

Enhanced inactivation of pectin methyl esterase in orange juice using modified supercritical carbon dioxide treatment

The aim of the study is to quantify the effect of ethanol addition and exposure surface on the inactivation of pectin methyl esterase (PME), a juice clarifying enzyme, in orange juice using supercritical carbon dioxide (SC‐CO₂). Addition of ethanol to the SC‐CO₂ at 2% (v/v) caused greater inactivation than SC‐CO₂ alone, with a maximum reduction of PME activity of 97% at 30 MPa and 40 °C for 60 min. As the surface area to volume ratio was increased, the rate of inactivation of PME increased. Analysis of first‐order reaction kinetic data revealed that D values were greatly influenced by ethanol addition and agitation. With the addition of 2% ethanol, the D value reduced by half, that is, 56 min from 109 min. With impeller agitation of the sample at 1100 ± 100 rpm, the D value for PME was further reduced to 43 and 30 min without and with ethanol, respectively. The activity of PME treated with SC‐CO₂ remained unchanged after 14 days of storage at 4 °C. Treatment did not significantly change pH or colour, but did significantly increase the cloud values of the juice, resulting in a cloud stabilised juice with similar qualities to fresh juice.     

Effect of Food Composition on the Heat Resistance of Yeast Ascospores

The ascospores of Saccharomyces cerevisiae were over 100-fold more resistant than vegetative cells of the same strain. The D₆₀ of spores in apple juice was 6.1 min and the z value was 3.8°C; in a Chenin blanc wine the D₅₅ was 0.57 min and the z value was 6.7°C. The presence of sugar in the heating medium increased spore resistance while alcohol reduced it; varying pH over the range 3.0 to 7.0 had little effect.     

EFFECT OF SUPERCRITICAL CARBON DIOXIDE ON MICROBIAL POPULATIONS IN SINGLE STRENGTH ORANGE JUICE1

The effect of supercritical carbon dioxide on aerobic total plate count (TPC) of fresh-squeezed and quick-frozen single strength orange juice from Valencia oranges was studied. Orange juice was treated with SC CO₂ at different temperatures (35° to 60°C) and pressures (8.3 to 33.1 MPa). SC CO₂ treatment at 35°C reduced the TPC by 2 log cycles after 1 h treatment at 33 MPa. At 45°C and 33 MPa 2 log cycles reduction required 45 mins, and 15 mins treatment was sufficient at 60°C. D values of temperature control samples decreased as temperature increased, while that of supercritically treated juice decreased as pressure increased. D values at 35, 45 and 60°C of the supercritically treated juice at 33.1 MPa were calculated as 28, 22.6 and 12.7 min, respectively. The calculated values of z were 180°C, 167°C and 72°C at 8.3 MPa, 20.7 MPa and 33.1 MPa, respectively.     

Effect of thermosonication on quality improvement of tomato juice

Inactivation of pectinmethylesterase (PME) and polygalacturonase (PG) is required to minimize quality loss in tomato products. Tomato juice was subjected to thermosonication (TS) (24 kHz), at amplitudes of 25, 50 and 75 μm at 60, 65 and 70 °C or heat only treatments. The TS treatment at 60 °C, 65 °C and 70 °C for 41.8, 11.7 and 4.3 min exposure, respectively reduced PME activity by 90%. The heat only treatment at 60 °C, 65 °C and 70 °C for 90.1, 23.5 and 3.5 min, respectively inactivated PME by 90%. TS treatments with 25–75 μm amplitude had no significant impact on the inactivation efficiency between 60 and 70 °C. After TS the average particle size decreased noticeably (< 30 μm) and viscosity increased 2–4 fold, compared to the heat treated or untreated juice (180 μm)_. These results suggest that TS at 60 and 65 °C could be useful to obtain tomato juice with a low residual PME activity and high viscosity.Industrial relevanceThe processed tomato industry is constantly in search for potential alternative processes to conventional “cold break” and “hot break” treatments that could inactivate the pectic enzymes of importance. The findings of this study would help the industry to inactivate pectinmethylesterase (PME) enzyme at a lower temperature range and also achieve a higher viscosity due to the mechanical effects of thermosonication. Low temperature treatment would enable the retention of fresh-like properties of tomato juice. Based on the findings of this study, thermosonication could be considered as a potential alternative to conventional “cold break” and “hot break” treatments of tomato juice.     

Influence of Water Activity on the Nonenzymatic Browning of Apple Juice Concentrate during Storage

Highly concentrated clarified apple juice was kept in storage at 37°C over a period of 100 days. The soluble solids content ranged from 65–90.5°Brix. Color development was monitored as O.D. at 420 nm. A maximum nonenzymatic browning rate (NEB_r) was found to occur between water activities 0.53 and 0.55. It was assumed that (1) dilution of reactants was responsible for the browning rate reduction at high water contents white (2) viscosity inhibited the color formation at low water activities. Viscosity ranged from 48 to 1.3 × 10⁶ cp and increased sharply when the commercial levels of concentration (70–72°Brix) were exceeded.