Pelvic suspension and fast post-mortem chilling: Effects on technological and sensory quality of pork - A combined NMR and sensory study

The effects of pre-rigor excision, which results in a fast post-mortem chilling; pelvic suspension, which results in a muscular stretching; control treatment of m. longissimus dorsi on water distribution measured by (1)H NMR relaxometry and on sensory properties were investigated in two sub-studies including a total of 16 pigs. Determination of sarcomere length revealed significant effects of the treatments on the degree of contraction, as pre-rigor excision and pelvic suspension resulted in shorter and longer sarcomere length, respectively. In addition, an effect of treatment on pH measured at 24h post-mortem was found, as pre-rigor excision was associated with a higher ultimate pH. NMR measurements revealed that water distribution in the meat was affected to a minor degree by the various treatments. However, an interaction between treatment and ageing period was observed, as the data demonstrated an effect of pre-rigor excision on water distribution in the cooked samples when meat was only aged for 2 days, but this effect was eliminated when meat was aged for 5 days. The effect of pre-rigor excision on water distribution in cooked meat after 2 days of ageing is suggested to reflect structural constraints in the meat that are eliminated during ageing. Sensory analyses demonstrated strong interactions between treatment and position on the muscle and between treatment and ageing period. However, in general pre-rigor-excised meat was sensed as significantly juicier compared with the other two treatments. Accordingly, the study demonstrates that under the present conditions the ultimate pH is more important for juiciness than the sarcomere length.     

Animal welfare at markets and during transport and slaughter

This review highlights some recent developments in our understanding of stress and physical injuries that occur before and during transport to slaughter, during handling at livestock markets, and at the time animals are put-up for slaughter within abattoirs. Stress in pigs during transfer to the stunning point within the abattoir has important effects on meat quality, and there is growing evidence that strenuous exercise or CO(2) stunning can contribute to oxidative rancidity in pigs, poultry and fish. In the EU, putting cattle through a crush in order to check that their eartag numbers correspond to their passport numbers is imposing additional stress, and there are reports that it is leading to greater hide contamination with Escherichia coli O157. Recent developments in stunning and slaughter include a better understanding of the causes of variation in captive bolt gun performance, the effectiveness of poll instead of frontal shooting in water buffalo, the prevalence of false aneurysms in carotid arteries during shechita and halal slaughter, and the stress effects of CO(2) stunning in fish. Stunning pigs with 90% CO(2) leads to less PSE meat than 80% CO(2). There have been concerns about the physical activity that cattle show following electrical stunning with an electrically induced cardiac arrest, and with electrical stunning using DC waveforms in broiler chickens. There is also growing concern about the hygiene problems that exist in wet markets, where animals are slaughtered alongside meat that is on display to customers.     

The effect of growth rate and ultimate pH on meat quality of lambs

Entire male Romney lambs (n = 60) were grown slowly (67 g/day) and slaughtered at 14 months of age at an anticipated carcass weight of 18 kg. Another group of ram lambs (n = 15) from the same genetic background (born 7 months later) were grown rapidly (162 g/day) for 7 months and slaughtered at the same time and at a similar carcass weight. Preslaughter shearing (20 days prior to slaughter) and swim washing (3 times) were variously imposed upon the 14-month old lambs to give them a graded preslaughter stress. The lambs were head-only electrically stunned and slaughtered. Dressed carcasses were electrically stimulated at 20 min post mortem for 90 s at 14·3 pulses/s, 1·8-2 A and 1130 V peak, then held at 12°C for 2 h and frozen so that the deep leg reached -4°C in 12 h. The ultimate pH was measured for the longissimus dorsi, and loin samples were assessed by tenderometer and a sensory panel. The groups with the greatest stresses imposed had the highest ultimate pH. The most tender meat came either from carcasses with an ultimate high pH greater than 6·3 or from young lambs with an ultimate pH from 5·5-5·7. While 7-month old lambs were slightly more tender than the 14-month old lambs of iso pH, the 14-month old lambs of high pH were the most tender. This suggests that age-related connective tissue effects were minimal for the loin. The shear force values and taste panel tenderness scores were linearly related. When the shear force and panellists' tenderness scores were expressed in relation to ultimate pH, there was a decreased acceptance of meat with a moderate ultimate pH between 5·8 and 6·0. Panel texture assessments showed a less clearly defined, but statistically significant decrease in acceptance at pH 5·8-6·0. Other sensory attributes of flavour, juiciness and aroma were uniform across the whole ultimate pH spectrum.     

Salmonella status of pigs at slaughter--bacteriological and serological analysis

Apart from Salmonella monitoring of pig herds during the period of growth to evaluate the efficacy of control programmes, monitoring at harvest level is of relevance to assess the Salmonella status of fattening pigs and the associated risk of introducing Salmonella organisms in the slaughter process. Samples from 1830 fattening pigs were gathered at slaughter. Ileocaecal lymph nodes, rectal and caecal content as well as tonsils were collected for bacteriological examinations, and a part of the diaphragm pillar muscle was taken to gain meat-juice for serological analysis. Salmonella spp. was recovered from 13.8% of all pigs examined. Salmonella Typhimurium and Derby were the dominating serovars. The highest detection rates were found in caecal content followed by ileocaecal lymph nodes. By analysing both organs nearly 90% of all Salmonella positive pigs could be identified. Serological examination revealed 9.6% of the pigs as positive using a cut-off value of OD % ≥ 40. Only one quarter of all Salmonella positive pigs showed also a positive serological result. A reduction of the cut-off value does not necessarily result in a higher compliance between bacteriologically and serologically positive slaughter pigs. Detection of antibodies is useful to verify whether pig herds were previously exposed to Salmonella organisms. However, the Salmonella status of pigs at time of slaughter and the associated risk of dissemination of Salmonella organisms can only be assessed by bacteriological examinations which should include both lymph nodes and caecal content.     

Effect of stunning conditions on occurence of PSE defects in hams of rn+/RN(-) pigs

Pigs of the same genetic type at the RN and HAL loci, i.e. rn⁺RN⁻/NN were reared in similar conditions of feeding and housing. They were slaughtered in two abattoirs (referred to as A1 and A2) using a mixture of air (30%) and CO₂ (70%), at a rate of 300 pigs per hour per slaughterline. One hundred and thirty-two pigs from 11 farms were slaughtered in A1 using a corusinga restrainer and 127 pigs from 5 farms were slaughtered in A2 with the backloading technique. pH at 40 min, 2.5 h and 24 h after slaughter and colour (L*, a*, b*) at 24 h after slaughter were measured in the semimembranosus muscle. Meat quality of the ham was scored as follows: 1, no PSE-zone; 2, doubtful; 3, PSE-zones in the semimembranosus and sometimes on the internal flexor muscles; 4, PSE-zones in all the flexor muscles. The muscle pH value was higher in A2 than in A1 at 40 min post mortem (P<0.01), but not at 2.5 and 24 h. L* (P<0.001) and b* (P<0.05) were higher in A1 than in A2. There was a remarkable difference in meat quality scores, with 50% of the hams scoring 3 or 4 in A1, vs 13% in A2. Lairage time before slaughter affected (P<0.01) the pH value at 2.5 h (5.69 vs 5.93). The values of pH1 and pH2.5 decreased with increasing the meat quality score. The values of L* and b* increased markedly with the score. The results of the present study indicate that the method of bringing the slaughter pigs to the stunning device affects the frequency and importance of PSE meat in the ham. The automated driving of groups of animals to the stunning machine combined with the backloading of a nacelle, compared to a traditional system driving pigs in single file using electrical goads and a restrainer was beneficial with respect to both meat quality and animal welfare.     

Effect of gender and castration of females and slaughter weight on performance and carcass and meat quality of Iberian pigs reared under intensive management systems

A total of 360 Iberian dam × Duroc sire pigs was used to study the influence of gender and castration of females (CM, castrated males; CF, castrated females; IF, intact females) and slaughter weight (SW; 145 and 156 kg body weight, BW) on performance and carcass and meat quality. Each treatment was replicated four times (15 pigs). Intact females ate less, tended to have better feed conversion and had less carcass fat and more primal cuts yield than CM and CF. Pigs slaughtered at 156 kg BW ate more feed and had worse feed conversion than pigs slaughtered at 145 BW. An increase in SW improved carcass yield, but tended to decrease trimmed ham yield. Intact females are an alternative to castrated females for intensive production of Iberian pigs. Also, the reduction in slaughter weight from 156 to 145 kg BW is recommended for this type of production.     

Elucidation of the relationship between cooking temperature, water distribution and sensory attributes of pork - a combined NMR and sensory study

Low-field NMR T(2) relaxation was measured continuously during cooking of pork samples (m. longissimus dorsi) to a final temperature of 75 °C. Simultaneously the remaining muscle was cooked in an oven to a core temperature of either 62 or 75 °C and subsequently evaluated by a sensory panel. Highly significant effects of final cooking temperature on the sensory attributes juiciness (initial and final), hardness, tenderness, crumbliness and chewing time were found. Juiciness and tenderness decreased with increasing temperature, while hardness, crumbliness and chewing time increased with increasing temperature. Distributed T(2) relaxation data revealed marked effects of temperature (62 vs. 75 °C) on the water distribution within the meat. Partial least squares (PLS) regressions were used to examine a potential prediction of sensory attributes from the distributed T(2) relaxation data, and high correlations were obtained. Moreover, loadings from the PLS regressions were analysed to evaluate the alterations in the water distribution as a function of temperature that contribute to changes in juiciness. This analysis revealed that the reduction in juiciness at 75 °C can be ascribed to changes in the size of the pores confining the myofibrillar water together with an expulsion of water.     

Effect of age at slaughter on chemical traits and sensory quality of Longissimus lumborum muscle in the rabbit

The effect of age on chemical composition and sensory quality of longissimus lumborum muscle was investigated in rabbits slaughtered at 11 weeks or 18 weeks of age. Intramuscular fat (IMF) content increased from 1.3 to 2.2%, crude protein content ranged from 23.4-26.9%, whereas water content declined from 74.0 to 69.3%, as the age increased. The sensory quality was assessed by a 10-member experienced sensory panel. The age was found to affect meat tenderness, whereas juiciness and flavour did not differ significantly between ages. A positive trend was observed between tenderness and IMF content, both within age and between ages. Therefore, differences in sensory quality of rabbit meat were at least partly related to IMF content.     

Effects of outdoor rearing and sire breed (Duroc or Yorkshire) on carcass composition and sensory and technological meat quality

The effects of outdoor rearing and sire breed on carcass composition and technological and sensory meat quality in pigs were studied in a trial with 102 crossbred slaughter pigs (Yorkshire, or Yorkshire × Landrace sows and Duroc or Yorkshire as terminal sire). Half of each litter were reared conventionally indoors, while the remainder were reared outdoors in a 50 000 m(2) area, as a single group. All pigs were fed ad libitum. Yorkshire sired pigs had significantly leaner carcasses and meat with lower IMF content and marbling scores, and higher shear force and water content. The sire breeds did not differ regarding pH(u), water-holding capacity, or colour. Meat from the Yorkshire crosses was more acid, less tender and gained lower overall acceptance scores in the sensory test. The outdoor-reared pigs had lower daily gain values and leaner carcasses. They produced meat with lower pH(u), higher drip loss, higher shear force values and higher internal reflectances. Their meat contained more lactate and crude protein and had a higher glycolytic potential, less IMF and less water. Regarding the sensory qualities, outdoor rearing impaired tenderness, juiciness and overall acceptance.     

Rest before slaughter ameliorates pre-slaughter stress-induced increased drip loss but not stress-induced increase in the toughness of pork

One factor affecting meat quality is pre-slaughter stress. We investigated the effects of exercise stress on drip loss and toughness in relation to resting times of 0, 1 or 3 h following exercise on a treadmill. This exercise stress was regarded as combined physical and physiological stress. Exercise stress increased the muscle temperature, reduced the creatine phosphate, ATP and glycogen content of pigs slaughtered immediately after stress exposure. These conditions lead to a reduced pH early post mortem and an increased drip loss, while only 1 h of rest after exercise stress normalised these effects. However, an overshooting effect was noted when pigs were rested for 1–3 h before slaughter, emphasising the importance of critical control of the resting period when studying exercise stress-induced effects on meat quality. Furthermore, meat from exercise stressed pigs, irrespective of resting, had increased toughness compared to controls, indicating that the toughness was not related to drip loss in meat from exercise stressed pigs.     

Effects of age and/or weight at slaughter on longissimus dorsi muscle: Biochemical traits and sensory quality in pigs

The effect of increasing either age alone through feed restriction, or both age and weight at slaughter, on the quality of the longissimus dorsi muscle (LM) was investigated. Starting at 83 days of age and 32 kg, 80 pigs were allotted within litter to four experimental groups. All pigs were free of RYR1 mutated gene. Pigs were fed either ad libitum (A100, A130) or restricted 30% (R100, R130) and slaughtered at either 100 kg (A 100, R100) or 130 kg (A130, R130) body weight. Restricting feed intake in order to increase age at the same weight resulted in slower growth, better feed efficiency and increased leanness, whereas increasing age and weight simultaneously elicited slower growth, reduced feed efficiency and fatter carcasses. Intramuscular fat (IMF) and muscle collagen concentration were reduced by restricted feeding. Increase in both age and weight of pigs resulted in lower water, and higher protein and IMF concentrations. Although pigs were free of RYR1 gene, the PSE condition (defined as pH1 ≤ 5.9) developed in 25 carcasses, with a higher incidence in restricted pigs. PSE animals were excluded from the subsequent analysis of meat quality data. Feed restriction resulted in higher drip loss and lower a^* and c^* (saturation index) values. Longer myofibril fragments in muscle of restricted pigs on day 1 post mortem are indicative of slower maturation, while longer fragments on day 4 in heavier pigs, suggest that the extent of post mortem tenderisation could be negatively affected by the elevation of slaughter weight. Feed restriction had no significant effect on meat sensory quality, whereas increase in both age and weight resulted in lower tenderness, chewiness and mouth coating scores. Our results indicate that increasing age at a given body weight, via feed restriction, reduced IMF and collagen concentrations, and the rate of post mortem proteolysis, however, this had no significant impact on pork quality assessed after 4 days of ageing. On the other hand, increasing both age and weight at slaughter could alter pork texture, in spite of elevated IMF concentration.     

Influence of dietary conjugated linoleic acids (CLA) and age at slaughtering on meat quality and intramuscular collagen in rabbits

To assess the effects of dietary conjugated linoleic acids (CLA) on meat composition and intramuscular collagen (IMC), 144 New Zealand White rabbits, half males half females, 55 days old (1.8 kg LW), were assigned to three weight- and sex- balanced groups and given the following dietary supplements: 0.5% sunflower oil, (C); 0.25% sunflower oil plus 0.25% CLA (T1); and 0.5% CLA (T2). The CLA was prepared from sunflower oil and contained 65% CLA isomers, half cis-9, trans-11 and half trans-10, cis-12. Six males and six females from each group (total 36) were slaughtered at 76, 90 and 104 days of age (corresponding to 2.5, 2.8, and 3.1 kg BW, respectively). The lean fraction was higher and the water content significantly higher in the meat of T2 compared to C and T1 for all ages combined. At the third slaughtering (104 days) the meat fat content was significantly lower in group T2. For all ages combined, IMC content, IMC hydroxylysylpyridinoline (HLP) concentration (index of collagen cross-linking) and IMC maturity (HLP/IMC) were significantly lower in the intermediate supplementation group (T1) compared to C and T2, and were also lower in animals slaughtered at 90 days. CLA supplementation has limited effects on the chemical composition of rabbit meat, with positive effects on meat texture and tenderness after supplementation up to 35 days at 0.25%, and a significant decrease in fat content only at high slaughter weight and high supplementation level (0.5%).     

Relationships between sensory perception and water distribution determined by low-field NMR T(2) relaxation in processed pork - impact of tumbling and RN(-) allele

The relationships between water distribution, measured with low-field NMR (LF-NMR) transverse (T₂) relaxometry and sensory properties in tumbled and non-tumbled cured-smoked loins from 30 female Hampshire crossbred pigs were investigated. Upon distributed analysis of the T₂ relaxation, three populations centred at about 2, 40 and 600–800 ms, respectively, were detected. Clear differences in the characteristics of the intermediate population (T₂₁) were observed between loins from carriers and non-carriers of the RN⁻ allele, which implies differences in water–protein interactions between the two genotypes. PLS regressions between NMR T₂ variables and sensory attributes revealed significant correlations between NMR T₂ variables and the sensory attributes juiciness, acidulous taste and meat taste, which mainly could be ascribed to the T₂₁ time constant. In addition, the number of unappealing pores assessed by the sensory panel was highly related to the relative T₂ populations, implying that the microstructure is directly reflected in the NMR T₂ populations. However, prediction of the processing yield from NMR T₂ variables was poor. The correlation improved when RN genotypes and tumbling conditions were included as predictors. Thus, other effects of tumbling treatments and RN genotypes unrelated to NMR T₂ relaxation were observed.     

Assessment of beef production from Brahman × Thai native and Charolais × Thai native crossbred bulls slaughtered at different weights. II: Meat quality

The objective was to assess meat quality of Brahman × Thai native (BRA) and Charolais × Thai native (CHA) crossbred bulls. In total 34 BRA and 34 CHA under practical farm conditions were randomly assigned for slaughter at 500, 550 and 600 kg live weight, respectively. Longissimus dorsi muscle was taken for meat quality and sensory evaluations. CHA meat had higher intramuscular fat, exhibited higher marbling scores and relatively better colour than BRA meat. Although muscle fiber area was similar for both genotypes, shear force values were higher for CHA meat. Water holding capacity was better for CHA meat shown by lower 7-day ageing, thawing and grilling losses. However, the sensory evaluation ratings were similar for both genotypes. Increasing slaughter weight from 500 kg up to 600 kg had no significant effect on meat quality. In conclusion, meat quality of CHA was superior to BRA.     

Microbiological conditions of meats from large game animals and birds

Large game animals and birds used for the commercial production of meat include deer of various species, wild boar and feral pigs, ostriches, emus and rheas, crocodiles and alligators, bison, and kangaroos. Meat from feral pigs and kangaroos is obtained from wild animals only, but much or most meat from the other game animals or birds is obtained from farmed animals. The microbiological conditions of meats from hunted animals can be compromised by poor placement of shots, the usual evisceration and sometimes further dressing of carcass in the field, and ageing of carcasses at ambient temperatures. However, the general microbiological conditions of carcasses from farmed game animals or birds slaughtered and dressed at suitable abattoirs can be comparable with or better than the microbiological conditions of carcasses from domestic animals or birds. The incidences of enteric pathogens on meat from wild or farmed game animals or birds can be less than those for meat from intensively reared domestic animals, but infection of some game meats with Trichinella or other foodborne parasites may occur.     

Effects of genotype and slaughter weight on the meat quality of Criollo Cordobes and Anglonubian kids produced under extensive feeding conditions

Physicochemical and organoleptic characteristics of meat (longissimus muscle) from Criollo Cordobes (CC) and Anglonubian (AN) suckling kids were analysed to determine the effects of genotype and slaughter weight. Forty suckling entire male kids, 20 CC and 20 AN were assigned to two age/slaughter weight groups (I: 60 + 2 days old and ?11 kg, and II: 90 + 2 days old and >11 kg). Colour, shear force and cholesterol levels of meat were affected by breed. Tenderness decreased and cholesterol increased with age/slaughter weight. Fatty acid profiles were affected primarily by genotype. The sensory attributes were perceived as medium-high intensity, and meat from CC and AN goat kids was valued as tender. However, initial tenderness and connective tissue varied with genotype. The main effect due to the increase in age/slaughter weight was a decrease in tenderness (initial and overall), as observed for instrumental shear force.     

伊拉兔生长过程中肉品质特性变化

为探讨生长过程中伊拉兔肉品质的变化,以伊拉兔配套系公兔为研究对象,测定不同日龄兔肉的食用品质和营养特性。结果表明：不同日龄下,伊拉兔肉的L*、pH值变化差异不显著（P＞0.05）;随着饲养时间的增加,水分含量显著下降（P＜0.05）,而蛋白质、粗脂肪和不饱和脂肪酸的含量显著升高（P＜0.05）;伊拉兔肉胆固醇的含量随日龄升高呈先上升后下降的趋势,且显著低于其他畜禽肉类;在75 d时,兔肉系水力、熟肉率、氨基酸总量及多不饱和脂肪酸/饱和脂肪酸的比值均最高,表明75 d的伊拉兔肉具有良好的加工特性且营养价值较高。     

不同日龄鹅肉卤制后的理化性质

卤鹅因其独特的风味特点和口感而备受消费者欢迎,为了解其品质随日龄的变化,测定70、80、90 日 龄卤鹅胸肌和腿肌肉的理化指标。结果表明：日龄对卤鹅肉的粗蛋白质、粗灰分和非必需氨基酸含量有显著影响 （P＜0.05）;部位对卤鹅肉的pH值、亮度值、红度值、粗脂肪、饱和脂肪酸、单不饱和脂肪酸、多不饱和脂肪酸 和非必需氨基酸含量有显著影响（P＜0.05）;各理化指标在不同日龄和部位之间的变化具有一定波动性,无一致 的规律性;不同日龄鹅肉卤制后的理化性质在聚类关系上趋同性强,而不同部位鹅肉卤制后理化性质的聚类关系较 远。综上所述,日龄和部位对卤鹅肉物理性状的影响较小,对营养成分的影响较大,并且部位是影响卤鹅肉品质的 主要因素。综合来看,80 日龄卤鹅肉的营养价值较高,且腿肌肉比胸肌更有营养。     

屠宰日龄对伊拉兔胴体和肉质量的影响

对伊拉兔在60、70、80 日龄屠宰的胴体和肉质量进行比较研究,结果表明：宰前活质量、热胴体质量、冷却胴体质量、参考胴体质量、屠宰率、肾周脂肪质量/参考胴体质量、可解剖脂肪质量/参考胴体质量均随日龄的增加而明显增大（P＜0.05）;胴体的滴水损失随日龄增大而明显减少（P＜0.05）;pH24 h值随日龄增加有下降趋势;股二头肌L*、a*值在70 日龄和80 日龄组间无显著差异（P＞0.05）,背最长肌L*、a*值在各日龄组间无显著差异（P＞0.05）;背最长肌系水力和剪切力在70 日龄和80 日龄组间无显著差异（P＞0.05）,且均大于60 日龄;背最长肌的蒸煮损失随日龄增加而明显减小（P＜0.05）;背最长肌和后腿肌的粗蛋白、粗灰分含量在各日龄组间无显著差异（P＞0.05）,粗脂肪含量随日龄增大而明显增加（P＜0.05）,而水分含量有一定减小。伊拉兔在60 日龄屠宰生长潜力未充分发挥,70 日龄屠宰效益好,80 日龄屠宰改善了胴体和肉的品质。