Changes in the oxidative state of extra virgin olive oil used in baked Italian focaccia topped with different ingredients

Four different types of “focaccia” (Italian flat bread) prepared with the same dough and the same extra virgin olive oil but with different seasonings, were analyzed. Lipids were extracted from each sample using the Folch method. The indices commonly used to assess oil quality, the amounts of trans fatty acids and compounds of triglyceride polymerization, oxidation and hydrolysis, were determined in all the samples to better assess the degree of oxidation and hydrolysis of the oils. The findings showed that, once baked, the oil sampled from the different types of focaccias could not be included in the virgin category. The level of oxidation of the baked samples was greater than that in the uncooked oil. However the results obtained showed that the level of degradation of the extracted oils was lower than that found in edible refined oils and it seemed to be influenced by the topping used to flavour the focaccias.     

Bouillon cubes: assessment of the state of degradation of the lipid fraction

An experimental investigation was carried out to assess the oxidative and hydrolytic quality of the lipid fraction of bouillon cubes. Besides the routine analyses prescribed by EC regulations, determinations of fatty acid composition and unsaturated fatty acid trans isomers were also performed. From the lipid fraction extracted from each cube, polar compounds were separated by silica gel column chromatography and then submitted to HPSEC (high‐performance size exclusion chromatography) analysis to determine the classes of substances deriving from oxidation, polymerisation and hydrolysis of triglycerides. The data obtained showed that the determination of trans isomers and the subsequent HPSEC analysis of polar compounds enable one to ascertain the actual degradation of the lipid fraction of such food preparations. The degree of degradation of the lipid fraction of bouillon cubes was similar to that normally found in olive‐pomace oil, which is the poorest olive oil commercial class. Finally, the contents of trans isomers and triglyceride oligopolymers are shown to be significantly higher in hydrogenated than in non‐hydrogenated vegetable fats. Copyright © 2003 Society of Chemical Industry     

Formation of Heterocyclic Amines in Salami and Ham Pizza Toppings During Baking of Frozen Pizza

Heterocyclic amines (HAs) are formed as Maillard reaction products in the crust of meat products during heating processes. Two typical pizza toppings—salami and cooked ham—were analyzed for the presence of HAs after baking frozen pizzas at top and bottom temperatures of 250 and 230 °C, respectively. After baking pizza slices for 12 min, MeIQx (2‐amino‐3,4,8‐trimethylimidazo[4,5‐f]quinoxaline; 0.2 ng/g), 4,8‐DiMeIQx (2‐amino‐3,8‐dimethylimidazo[4,5‐f]quinoxaline; 0.5 ng/g), PhIP (2‐amino‐1‐methyl‐6‐phenylimidazo[4,5‐b]pyridine; 0.2 ng/g), norharman (4.5 ng/g), and harman (2.5 ng/g) were found in the ham toppings, whereas only the comutagenic norharman (107.4 ng/g) and harman (11.4 ng/g) were found in the salami toppings. The content of MeIQx and 4,8‐DiMeIQx in ham increased from 0.3 to 1.8 ng/g and 0.8 to 1.6 ng/g, respectively, when the recommended baking time was increased from 15 min (manufacturer's specification) to 18 min at 230 °C. MeIQx was formed in salami when the heating time was extended to 18 min. Moreover, higher concentrations of PhIP in salami or ham slices were found when baking temperatures were 250 °C rather than 230 °C (baking time of 12 min). However, sensory tests showed that panelists preferred longer‐baked pizzas due to an increased crispiness. Thus, results show that a substantial formation of HAs may occur in pizza toppings such as ham and salami, with ham being particularly susceptible when compared to salami. Formation of HAs increases with increasing baking time and temperature. The occurrence of the cupping of ham or salami slices during baking may also increase the formation of HAs.     

Effect of frying oils on the postprandial endoplasmic reticulum stress in obese people

The addition of antioxidants to frying oil reduces postprandial oxidative stress and the inflammatory response. ER stress may trigger both inflammation and oxidative stress processes. We aimed to determine the biological effects of the intake of four models of frying oils on postprandial ER stress in peripheral blood mononuclear cells. Twenty obese people received four breakfasts following a randomized crossover design, consisting of muffins made with different oils (virgin olive oil (VOO), sunflower oil (SFO), and a mixture of seed oils (SFO/canola oil) with either dimethylpolysiloxane (SOD) or natural antioxidants from olives (SOP) added), which were previously subjected to 20 heating cycles. ER stress was assessed by measuring the mRNA levels of sXBP1, BiP, CRT, and CNX in peripheral blood mononuclear cells. Our study showed that the intake of the muffins made with SFO induced the postprandial increase of the mRNA levels of the ER stress‐sensor sXBP1, and the ER stress related chaperones BiP and CRT (all p‐values <0.05). The harmful effects associated with the use of SFO as frying oil, in terms of inflammatory response and postprandial oxidative stress, may be partially mediated by the induction of postprandial ER stress.     

Physicochemical Property and Oxidative Stability of Whey Protein Concentrate Multiple Nanoemulsion Containing Fish Oil

The objectives of this research were to produce whey protein concentrate (WPC) multiple nanoemulsion (MNE) and to study how whey protein concentration level and antioxidant type affected the physicochemical properties and oxidative stability of fish oil in MNE. The morphological and physicochemical characteristics of MNE were investigated by using transmission electron microscopy and particle size analyzer, respectively. The oxidative stability of fish oil in MNEs was assessed by measuring peroxide value (PV), p‐anisidine value, and volatile compounds. The spherical forms of emulsions with size ranging from 190 to 210 nm were observed indicating the successful production of MNE. Compared with free fish oil, fish oil in MNE exhibited lower PV, p‐anisidine value, and formation of maker of oxidation of fish oil indicating the oxidative stability of fish oil in MNE was enhanced. PV, p‐anisidine value, and makers of oxidation of fish oil were decreased with increased WPC concentration level. The combined use of Vitamin C and E in MNE resulted in a reduction in PV and p‐anisidine value, and development of maker of oxidation. In conclusion, WPC concentration level and antioxidant type are key factors affecting the droplet size of MNE and oxidative stability of fish oil.     

Oxidative degradation and non-enzymatic browning due to the interaction between oxidised lipids and primary amine groups in different marine PL emulsions

Due to the beneficial health effects of marine phospholipids (PL) there is an increasing industrial interest in using them for nutritional applications including emulsified foods. This study was undertaken to investigate both oxidative and hydrolytic stability of marine PL emulsions in relation to the chemical composition of the marine PL used. Moreover, non-enzymatic browning reactions were also investigated. Emulsions were prepared by high pressure homogenizer using different concentrations and sources of marine PL. In some formulations, fish oil was added in order to study the effect of increasing levels of triglycerides in the emulsions. The oxidative and hydrolytic stability of emulsions was investigated through measurement of peroxide value, free fatty acids, and ³¹P NMR during storage at 2 °C for up to 32 days. The oxidative stability of marine PL emulsions during storage was further investigated through the measurement of secondary volatile compounds by solid-phase microextraction (SPME) and dynamic headspace (DHS) connected to gas chromatography (GC–MS). Non-enzymatic browning reactions were investigated through the measurement of Strecker derived volatiles, colour changes and pyrrole content. The results suggested that the oxidative stability of marine PL emulsions was significantly influenced by the chemical composition and the concentration of marine PL used to prepare them. Emulsions with good oxidative stability could be prepared from marine PL of high purity and high content of PL and antioxidant and low TAG content.     

Classification of Sunflower Oil Blends Stabilized by Oleoresin Rosemary (Rosmarinus officinalis L.) Using Multivariate Kinetic Approach

The sunflower oil–oleoresin rosemary (Rosmarinus officinalis L.) blends (SORB) at 9 different concentrations (200 to 2000 mg/kg), sunflower oil–tertiary butyl hydroquinone (SO_TBHQ) at 200 mg/kg and control (without preservatives) (SO_control) were oxidized using Rancimat (temperature: 100 to 130 °C; airflow rate: 20 L/h). The oxidative stability of blends was expressed using induction period (IP), oil stability index and photochemiluminescence assay. The linear regression models were generated by plotting ln IP with temperature to estimate the shelf life at 20 °C (SL₂₀; R² > 0.90). Principal component analysis (PCA) and hierarchical cluster analysis (HCA) was used to classify the oil blends depending upon the oxidative stability and kinetic parameters. The Arrhenius equation adequately described the temperature‐dependent kinetics (R² > 0.90, P < 0.05) and kinetic parameters viz. activation energies, activation enthalpies, and entropies were calculated in the range of 92.07 to 100.50 kJ/mol, 88.85 to 97.28 kJ/mol, ?33.33 to ?1.13 J/mol K, respectively. Using PCA, a satisfactory discrimination was noted among SORB, SO_TBHQ, and SO_control samples. HCA classified the oil blends into 3 different clusters (I, II, and III) where SORB₁₂₀₀ and SORB₁₅₀₀ were grouped together in close proximity with SO_TBHQ indicating the comparable oxidative stability. The SL₂₀ was estimated to be 3790, 6974, and 4179 h for SO_control, SO_TBHQ, and SORB₁₅₀₀, respectively. The multivariate kinetic approach effectively screened SORB₁₅₀₀ as the best blend conferring the highest oxidative stability to sunflower oil. This approach can be adopted for quick and reliable estimation of the oxidative stability of oil samples.     

BIOCATALYSIS OF CHLOROPHYLLASE IN CANOLA OIL USING ORGANIC SOLVENT SYSTEMS

The hydrolytic activity of a partially purified chlorophyllase, obtained from an algal source, was investigated in a refined-bleached-deodorized (RBD) canola oil model system using various organic solvent media, including water/miscible-organic, biphasic organic, and micellar ternary systems. Although the use of a ternary micellar system containing Span 85 was found to be the most appropriate medium for the hydrolysis of chlorophyll, the hydrolytic activity of chlorophyllase declined as oil content increased. The effects of various parameters, including surfactant concentration, hexane/buffer proportion, enzyme content, reaction time, incubation temperature, shaker speed, and activator concentration, on chloro-phyllase activity in the micellar ternary systems containing 20% RBD oil were also investigated. In addition, phytol displayed a noncompetitive inhibition in reaction media containing polysorbate 80 and Span 85. The plot of 1/v versus oil concentrations revealed that the oil had K _i values of 3.73 and 4.56% in the micellar systems containing polysorbate 80 and Span 85, respectively. Moreover, the presence of 10% oil in the micellar system containing span 85 and polysorbate 80 decreased V _max values of chlorophyllase activity by 6.2 and 9.6-fold, respectively.     

Vacuum-packed ripened sausages: Evolution of oxidative and hydrolytic degradation of lipid fraction during long-term storage and influence on the sensory properties

An experimental investigation was carried out with the aim to understand the oxidative and hydrolytic phenomena involving the lipid fraction of vacuum-packed sausages during long-term storage (5 months) and to verify their influence on the sensory characteristics. The data obtained pointed out that the oxidation was more pronounced in the initial stages of storage than in the further period, while the hydrolysis of lipid fraction significantly advanced during the whole storage time, supported by the high moisture level of the product. Both these phenomena resulted to be correlated with the sensory decay of the product. In particular, in the first stage of vacuum storage overall acceptability was found to be negatively correlated (p < 0.05) with rancid taste, acid value, and oxidized triacylglycerols. In the further stage the oxidative processes slowed down and affected in a lesser extent the sensory properties, which were more distinctly characterized by the onset of pungent perception attributed to compounds arising from multiple origins such as carbohydrate fermentation. This investigation confirmed the unreliability of thiobarbituric acid reactive substances test and the usefulness of high performance size exclusion chromatography analysis of the polar compounds of the lipid fraction to correctly determine the levels of the oxidative and hydrolytic degradation of the lipid fraction of vacuum-packed ripened sausages during long-term storage.     

Effect of an Ethanol Extract from Summer Savory (Saturejae hortensisL) on the Stability of Sunflower Oil at Frying Temperature

The effect of the ethanol extract from Saturejae hortensis L on the oxidative and thermal processes occurring in sunflower oil during its high-temperature treatment (180°C) was investigated. The changes during simulated deep fat frying were monitored by determination of the oxidation stability at 100°C, as well as by determination of unchanged triacylglycerols. It was established that the addition of 1 and 5 g kg^-1 ethanol extract from S hortensis L leads to a decrease in the oxidative and thermal changes in the oil. The ethanol extract from S hortensis L improved the oxidative stability of sunflower oil even after 50 h at 180°C and it inhibited the oxidative processes more than the thermal processes under these conditions. © 1997 SCI.     

Antioxidant efficiency of oregano during frying and storage of potato chips

The effect of oregano on the oxidative stability of cottonseed oil during frying of potato chips and on the storage stability of the produced chips was studied. The ground spice or an ethanol‐derived extract thereof was added to the oil at a concentration of 2 g l^?1 (dry basis) before frying. The results showed that both ground oregano and its ethanol‐derived extract decreased the rates of accumulation of conjugated dienes, polar compounds, polymerised triglycerides, dimeric triglycerides as well as p‐anisidine value (p‐AV) of the frying oil. The major decrease was observed in the accumulation of polymerised and dimeric triglycerides. The accumulation of oxidised triglycerides showed a low decrease with the addition of oregano, while the hydrolytic compounds formed during frying were not affected. No significant difference (at 95% significance level) between ground oregano and its ethanol‐derived extract was observed. The storage stability of potato chips removed from the fryer at various time intervals was estimated by the rates of increase in peroxide value and conjugated dienes of the oil absorbed in the chips. Both rates were depressed when oregano was added to the frying oil; the protective action of oregano extract was considerably greater (at 95% significance level) than that of ground oregano. Copyright © 2003 Society of Chemical Industry     

Physicochemical Properties and Volatile Profiles of Cold-Pressed Trichosanthes kirilowii Maxim Seed Oils

The physicochemical properties and volatile profiles of cold-pressed Trichosanthes kirilowii Maxim (T. kirilowii) seed oils from four regions in China were determined in this study. The total oil content and cold-pressed oil yield of the four different sourced seeds were 38.06–44.33% and 15.17–30.97%, respectively. All the cold-pressed oil samples were found to be rich in polyunsaturated fatty acids, with content ranging from 45.41 to 75.32% of the total fatty acids. Punicic, α-eleostearic and catalpic acids were the main conjugated linolenic acid isomers in the cold-pressed T. kirilowii seed oils. The results of melting and crystallization profiles indicated that each oil sample exhibited different transitions steps due to its triacylglycerol composition, crystal structure and total unsaturation. Analysis of volatile profiles showed that 2,4-nonadienal was one of the most important aldehydes in the cold-pressed T. kirilowii seed oils, and less short chain acids (0.20%) but more esters (5.48%) were found in the sample with high content of punicic acid (Hebei sample). Results of oil quality indices indicated that cold-pressed T. kirilowii seed oils were liable to be oxidized, and their stabilities reduced with the increase of acid values. In general, more attention should be paid to improve the oxidative stability of cold-pressed T. kirilowii seed oils in their further application in food industry.     

Lipase activity in different tissues of four species of fish: rohu (Labeo rohita Hamilton), oil sardine (Sardinella longiceps Linnaeus), mullet (Liza subviridis Valenciennes) and Indian mackerel (Rastrelliger kanagurta Cuvier)

Lipase activity in stomach and pyloric caeca, liver, intestine and red muscle of rohu (Labeo rohita Hamilton), oil sardine (Sardinella longiceps Linnaeus), mullet (Liza subviridis Valenciennes) and Indian mackerel (Rastrelliger kanagurta Cuvier) was studied. Distinct differences in lipolytic activity in different tissues of these fish were observed. Rohu showed the highest activity in all tissues in comparison with the other three species of fish. Among the three size groups of mullet, medium‐sized mullet showed higher activity than the other two groups in all tissues except intestine. Rohu hepatopancreatic lipase exhibited more hydrolytic activity on fish oil than rohu intestinal lipase. Copyright © 2003 Society of Chemical Industry     

Multivariate determination of free fatty acids and moisture in fish oils by partial least-squares regression and near-infrared spectroscopy

The oxidative and hydrolytic degradation of lipids in fish oil was monitored using partial least-squares (PLS) regression and near-infrared reflectance (NIR) spectroscopy. One hundred and sixty (n=160) fish oil samples from a fishmeal factory were scanned in transflectance by an NIR monochromator instrument (1100–2500 nm). Calibration models were performed for free fatty acids (FFA), moisture (M), peroxide value (PV) and anisidine value (AV). Coefficients of determination in calibration (R²) and standard errors of cross validation (SECV) were 0.96 (SECV: 0.59) and 0.94 (SECV: 0.03) for FFA and M in g/kg, respectively. The accuracy of the NIR calibration models were tested using a validation set, yielding coefficients of correlation (r) and standard errors of prediction (SEP) of 0.98 (SEP: 0.50) and 0.80 (SEP: 0.05) for FFA and M in g/kg, respectively. Poor accuracy (R²<0.80) was obtained for the NIR calibration models developed for PV and AV. The paper demonstrates that fish oil hydrolytic degradation of lipids, which seriously affect oil use and storage under industrial conditions, can be successfully monitored using PLS regression and NIR spectroscopy by the fishmeal industry.     

Composition and organoleptic characteristics of oil from Arbequina olive (Olea europaea L) trees under deficit irrigation

This study evaluated the effects of different regulated deficit irrigation (RDI) strategies applied to olive (Arbequina cultivar) trees on the qualitative and quantitative parameters of the resulting oil during the maximum evaporative demand period for three consecutive crop seasons. Quality indices, fatty acid composition, pigments, colour, α‐tocopherol and phenolic contents, bitter index, oxidative stability and organoleptic properties of the oil were determined. Irrigation did not affect those parameters used as criteria for classifying olive oil in its commercial grades. Only polyphenol and o‐diphenol contents and, consequently, the bitter index and oxidative stability were affected by the RDI strategy, with increasing values as the water applied decreased. Regulated deficit irrigation resulted in important savings in irrigation requirements without detriment to oil quality. © 2002 Society of Chemical Industry     

A chromametric method for the rapid assessment of deep frying oil quality

A rapid chromametric method was developed for the assessment of deep frying oil quality based on the strong correlation between colour index and total polar compounds in deep frying oil. Colour indices of frying oil samples, measured by chromameter, decreased significantly during frying and were strongly correlated with frying time (r ≥ 0.95, p < 0.001). Colour indices of a set of oil samples taken from 0 to 80 h of deep frying were also significantly correlated with total polar compounds of the same samples determined using the official method of the American Oil Chemists' Society (r = 0.96, p < 0.001). The equation for conversion of the colour index (x) to the content of total polar compounds (y) in an oil sample is y = 0.0174x² ? 2.9506x + 124.34. In addition, colour indices of 10 different types of frying oils were strongly correlated with the corresponding contents of total polar compounds in the oils with samples taken from 0 to 80 h of deep frying in duplicate (r = 0.95, p < 0.001, n = 220). The results of colour index analyses agreed well with the results of chemical and sensory analyses of the frying oils tested. This chromametric method is rapid, convenient and reliable. Copyright © 2003 Society of Chemical Industry     

Potential use of extra virgin olive oil in bakery products rich in fats: a comparative study with refined oils

The lipid fraction of bakery products undergoes a significant degradation during baking, with an increase in undesirable oxidised substances, that can act as catalysts for further oxidative reactions during storage reducing the product shelf life. The use of extra virgin olive oil in bakery products rich in fat in place of refined oils was studied, assessing the evolution of the oxidative and hydrolytic degradation during storage. Two‐way analysis of variance, followed by Tukey's HSD test for multiple comparisons, covariance and principal component analyses were carried out to compare the effect of the type of oils. The data obtained showed that the evolution of the oxidation levels in the analysed samples during storage was related to the type of oil used in the production process. Particularly, the use of extra virgin olive oil led to significantly lower values of hydroperoxides, ultraviolet absorption constants, triacylglycerol oligopolymers and oxidised triacylglycerols.     

Solvent and enzyme-aided aqueous extraction of goldenberry (<Emphasis Type="Italic">Physalis peruviana</Emphasis> L<Emphasis Type="Italic">.</Emphasis>) pomace oil: impact of processing on composition and quality of oil and meal

Goldenberry pomace (seeds and skins) represent the waste obtained during juice processing (ca. 27.4% of fruit weight). In the present contribution, the potential of goldenberry pomace for use as a substrate for the production of edible oil was evaluated. Toward developing goldenberry as a commercial crop, the results provide important data for the industrial application of goldenberry. Three extraction methods were checked for the best oil yield. The n-hexane-extractable oil (expressed as SE) content of the raw by-products was estimated to be 19.3%. Enzymatic treatment with pectinases and cellulases followed by centrifugation in aqueous system (expressed as EAE) or followed by solvent extraction (expressed as ESE) was also investigated for recovery of oil from pomace fruit. Enzymatic hydrolysis of pomace followed by extraction with n-hexane reduced the extraction time and enhanced oil extractability up to a maximum of ca. 7.60%. Moreover, enzymation followed by solvent extraction increased the levels of protein, carbohydrates, fiber and ash in the remaining meal. The study covers also the chemical composition and some fractional properties of different pomace extracts (EAE, SE and ESE). Concerning the oil composition, there were relatively no changes noted in the fatty acid pattern of the oils extracted with different techniques. Slight alterations in the amounts of other fat-soluble bioactives (i.e., sterols, tocopherols and phenolics) were recorded. The different pomace oils obtained were tested for their radical scavenging activity toward the stable 1,1-diphenyl-2-picrylhydrazyl radical and their oxidative stability. Generally, the quality of solvent extracted oils (ESE and SE) manifested higher radical scavenging activity and oxidative stability than the enzyme-extracted oil (EAE). The levels of polar lipids, unsaponifiables, peroxides and phenolics in different extracts were associated with oxidative stability and radical scavenging activity.     

Gel Matrix Influence on Hydrolysis of Triglycerides by Immobilized Lipases

The hydrolytic activities and specificities of gel-entrapped C. cylindracae lipase (CCL) and R. arrhizus lipase (RAL) toward olive oil and tributyrin were investigated. Lipases in hydrophobic gels with the longest chain lengths generally displayed highest activity. The optimal temperature was 30–35° for free and 37–40° for gel-entrapped lipases. The ratio of the activity on tributyrin to that of olive oil (expressed as T/O ratio), an indicator of substrate specificity, increased from 0.3 for free lipases to 12.3 ± 2.3 for CCL lipase in ENTP-2000-formed gel and 16.2 ± 0.3 for RAL lipase in ENTP-4000-formed gel.