Influence of canola-olive oils, rice bran and walnut on functionality and emulsion stability of frankfurters

Fat content of frankfurters (20 g/100 g) was replaced with canola and canola-olive oils. Rice bran (RB) and walnut (WE) were added (2.5 g/100 g) to emulsions as macronutrients. Changes in energy values, color, emulsion stability and lipid oxidation of frankfurters during storage were investigated. ANOVA model was highly significant for color parameters and energy values (P < 0.001). The canola-olive oil replacement led to a high capacity to hold water and fat exudates in frankfurters, reporting higher emulsion stabilization parameters than regular frankfurters. The addition of RB led to an increase of cooking and fat exudates, indicating high emulsion instability possible due to interactions between RB fiber and fat-protein binders. Walnut addition reported low cooking loss values, and a significant capacity for emulsion stabilization in comparison with regular and RB frankfurters. Lipid oxidation increased from days 0-7 in all frankfurters, declining afterwards until end of storage. TBARS was not influenced by type of emulsions control, but significant (P < 0.05) differences were observed in vegetable oil emulsions made with RB; as well as between RB and WE added to either vegetable oil emulsions. These results suggest the use of these natural ingredients as valuable promoters of healthy meat products.     

Effects of replacing pork back fat with vegetable oils and rice bran fiber on the quality of reduced-fat frankfurters

The effects of substituting olive, grape seed, corn, canola, or soybean oil and rice bran fiber on the chemical composition, cooking characteristics, fatty acid composition, and sensory properties of low-fat frankfurters were investigated. Ten percent of the total fat content of frankfurters with a total fat content of 30% (control) was partially replaced by one of the vegetable oils to reduce the pork fat content by 10%. The moisture and ash content of low-fat frankfurters with vegetable oil and rice bran fiber were all higher than the control (P < 0.05). Low-fat frankfurters had reduced-fat content, energy values, cholesterol and trans-fat levels, and increased pH, cooking yield and TBA values compared to the controls (P < 0.05). Low-fat frankfurters with reduced-fat content plus rice bran fiber had sensory properties similar to control frankfurters containing pork fat.     

Characteristics of low-fat meat emulsion systems with pork fat replaced by vegetable oils and rice bran fiber

The effects of vegetable oils prepared from olive, corn, soybean, canola, or grape seed, and rice bran fiber on the composition and rheological properties of meat batters were studied. Pork fat at 30% in the control was partially replaced by one of the vegetable oils at 10% in addition to reducing the pork fat to 10%. The chemical composition, cooking characteristics, texture properties, and viscosity of low-fat meat batters were analyzed. The moisture, protein, ash content, uncooked and cooked pH values, b^∗-value, hardness, cohesiveness, gumminess, chewiness, and viscosity of meat batters with vegetable oil and rice bran fiber were all higher than the control. In addition, batters supplemented with vegetable oil and rice bran fiber had lower cooking loss and better emulsion stability. Low-fat meat batters with reduced pork fat content (10%) and 10% vegetable oil plus rice bran fiber had improved characteristics relative to the regular fat control.     

Avocado, sunflower and olive oils as replacers of pork back-fat in burger patties: effect on lipid composition, oxidative stability and quality traits

The present study investigates the effects of avocado, sunflower and olive oils used as back-fat replacers, on the fatty acid composition, oxidative stability, volatiles profile and color and texture properties of cooked pork patties. The vegetable oils modified the fatty acid profiles of the patties by lowering the percentages of SFA (from 36.96% to ~ 25.30%) and reducing the atherogenic index (from 0.41 to ~ 0.24). Vegetable oils had higher amounts of antioxidant compounds such as tocopherols (10.8-53.9 mg/100 g) than back-fat (5.9 mg/100 g). Consistently, patties manufactured with the oils had significantly lower amounts of lipid and protein oxidation products than control patties. Avocado oil contributed with specific aroma-active terpenes to patties and had a significant impact on particular color and texture parameters. The results from this study highlight the technological applications of the vegetable oils as food ingredients in the design of healthier meat commodities.     

Physicochemical and sensory properties of healthier frankfurters as affected by walnut and fat content

This study evaluates the physicochemical and sensory properties of healthier frankfurters with 25% added walnut (WF) versus low-fat frankfurters (6% pork fat) (LF) and traditional frankfurters (18% pork fat) (NF). Results reveal that cooking losses were unaffected (p ? 0.05) by the formulation of frankfurters. The addition of walnut led to higher (p < 0.05) redness and yellowness values, while colour parameters did not differ significantly between LF and NF sausages. Frankfurters with added walnut (WF) presented higher (p < 0.05) hardness and chewiness values than LF and NF frankfurters. Differences in composition were also accompanied by changes in the microstructure of the gel/emulsions. Frankfurters with added walnut presented a flavour significantly different from meat and scored lower (p < 0.05) on texture preferences. However, all frankfurters scored the same for overall acceptability.     

米糠蛋白酶解产物功能特性及乳液稳定性研究

目的 改善米糠蛋白的溶解性,探讨米糠蛋白乳液的稳定性。方法 选用胰蛋白酶对米糠蛋白进行酶法改性,分析其在不同水解度下(1%、3%、7%)酶解产物的功能特性及不同pH、离子强度和温度对米糠蛋白酶解产物乳液的影响。结果 酶解可显著提高米糠蛋白的溶解性,在水解度7%时的溶解性最高;而酶解产物的起泡性、起泡稳定性、乳化性和乳化稳定性呈现先增加后下降的趋势,并在水解度为3%时达到最大值;经酶解后持油性显著增加(P<0.05),而持水性显著降低(P<0.05)。米糠蛋白及酶解产物乳液在不同pH下平均粒径和电位总体上呈现相似变化趋势,在等电点附近极不稳定,在pH 7～8时乳液趋于稳定;低水解度(1%、3%)的酶解产物乳液对高温和盐离子的抵抗能力高于米糠蛋白。结论 水解度为3%的酶解产物,其功能特性显著提升,制备的乳液在高离子强度和加热条件下较为稳定,该结果为米糠蛋白酶解产物制备食品乳液提供理论依据。     

Effects of rice bran on sensory and physico-chemical properties of emulsified pork meatballs

Four kinds of bran, which are milled from important rice cultivators in Taiwan, have high contents of dietary fiber, fat and protein. The use of rice bran in Kung-wan, an emulsified pork meatball, was investigated. It was found that protein and fat contents, and white index of meatballs decreased as the amount of bran increased. A texture profile analysis (TPA) also indicated the hardness, gumminess and chewiness of the Kung-wan decreased. The sensory scores of taste, texture and overall acceptability of meatballs with less than 10% added bran showed no significant difference from those for meatballs without bran. However, the added amount of 15% enriched meatballs resulted in inferior sensory scores. The bran’s particle size profoundly affected the sensory and physico-chemical properties of the meat products. Meatballs enriched with smaller bran particles possessed higher TPA indices and sensory scores than those added with larger ones. No significant differences in proximate composition, cooking yield, color and sensory quality were found among emulsified meatballs enriched with four different kinds of bran. Conclusively, the suitable amount of rice bran that should be added to emulsified pork meatballs was less than 10% and a smaller particle size would result in better quality.     

Preliminary investigation of the effects of low-level dietary inclusion of fragrant essential oils and oleoresins on pig performance and pork quality

Since the tissue characteristics of monogastric species are readily influenced by the composition of the feeds they consume, the objectives of this preliminary study were to assess the performance of finisher pigs on diets containing 0.05% of essential oils or oleoresins of rosemary, garlic, oregano, or ginger, and to determine the effect of these diets on pork quality. The pigs preferred the garlic-treated diet, and feed intake and average daily gain were significantly increased although no difference in feed efficiency was observed. Carcass and meat quality attributes were unchanged by dietary treatment, although a tendency towards reduction of lipid oxidation was noted in oregano-fed pork. Sensory panelists were unable to detect a flavour/aroma difference between treated and control pork. These results indicate that a higher level of dietary supplementation may be required in order to effect observable differences in pork characteristics.     

不同植物油水包油型乳状液物理特性及氧化稳定性研究

以紫苏油、橄榄油、棕榈油和葵花籽油为油相,以乳清分离蛋白为乳化剂,制备水包油(O/W)型乳状液,研究其粒径、ζ-电位、絮凝指数等物理特性,比较不同乳状液在贮存期间的氧化稳定性。结果显示,4种乳状液中,紫苏油乳状液体积平均粒径D_(4,3)较小(0.824μm),ζ-电位绝对值较大(37.5mV),呈现良好的物理贮存稳定性;但由于油脂中有较高的多不饱和脂肪酸,体系易被氧化。棕榈油乳状液具有良好的氧化稳定性,体系初级和次级氧化产物浓度均最低;但乳状液粒径较大(D_(4,3)为1.845μm),物理稳定性较差。通过内源性荧光测定发现,乳状液中蛋白质氧化与脂质氧化存在一定关联性。     

Effect of enrichment with hemicellulose from rice bran on chemical and functional properties of bread

This paper examines the use of the defatted rice bran hemicellulose B (RBHB), and insoluble dietary fibre (RBDF), as two functional ingredients added to bakery products. The results show that the RBHB from defatted rice bran had high water-binding and swelling capacity. RBHB exhibited high fat binding capacity. However, RBHB was found to be low viscous. Addition of 1%, 2% and 3% RBHB preparation reduced loaf volume significantly and increased the firmness of the breads. Sensory evaluations revealed that breads with 1%, 2%, 3% RBHB and 2%, 4% RBDF were overall acceptable. This confirms that the RBHB and RBDF preparation from defatted rice bran has great potential in food applications, especially in development of functional foods including functional bakery products.     

Effect of modified atmospheres on microbiological, color and sensory properties of refrigerated pork

Pork loin samples were stored (4 °C) in nylon polyethylene plastic bags using different modified atmospheres packaging (MAP): vacuum, 100% CO₂ 99% CO₂ + 1% CO, 100% O₂ or 100% CO followed by vacuum. Throughout the storage period Pseudomonas growth was limited in loins packaged in all MAPs evaluated, except for 100% O₂. Psychrotrophs reached 10⁷ CFU g⁻¹ after 20 days of storage except for the loin samples in 100% O₂ MAP that present count above 10⁸ CFU g⁻¹. The 1% CO/99% CO₂ atmosphere was best for preserving the desirable pork loin color and the L* and a* values remained similar to the fresh meat values using this MAP. Pork loins in 99% CO₂/1% CO MAP obtained the highest consumer acceptance scores after 24 h of storage. These samples and those treated with CO and then vacuum packaged received the greatest acceptance scores even after 20 days of storage.     

Retrogradation properties of high amylose rice flour and rice starch by physical modification

A new physical modification applied to prevent the retrogradation of rice flour and rice starch was investigated. This study examined the retrogradation properties of treated rice flour or rice starch paste by three stirring or heating-stirring, or without. The results proved that the retrogradations of rice flour and rice starch were both not substantially affected by three stirring modifications. However, three heating-stirring treatments had a marked effect on retarding the retrogradation of rice flour, but did not affect that of isolated rice starch. In the differential scanning calorimetry (DSC) analysis, modified rice flour by three heating-stirring exhibited the lowest retrogradation enthalpy (3.04 J/g dry matter) as compared to the control RF (5.93 J/g dry matter) and by three stirring (5.08 J/g dry matter). Meantime, it had almost the least recrystallization of retrogradation by X-ray diffraction (XRD). It was also found through scanning electron microscopy (SEM) that the granule structure of this modified rice flour had a more honeycomb-like structure and the lowest crystallinity as compared to the others.     

Impact of xanthan gum,sucrose and fructose on the viscoelastic properties of agarose hydrogels

Mixed carbohydrate systems are of special interest for the food and non-food industry as they offer a versatile range of unique and novel functional properties. However, intense research is required to understand the complex processes occurring in such systems on a molecular level and to be able to modify them aim-oriented. In food, characteristic properties are based on the physicochemical functions of the biopolymers added. Thus, small deformation tests and moisture analysis have been applied to study the impact of xanthan gum and two types of sugar on the viscoelastic properties, the sol–gel transition and the water holding capacity of 1% agarose hydrogels. Agarose gels are very elastic, turbid and prone to synaeresis, which impinges on their mouth feeling. Additions of xanthan gum revealed less elastic gels with an unaffected water holding capacity. Progressive addition of two different types of up to 40% of sugar yield an increase of the elasticity of agarose gels, whereby sugar concentrations of 60% partially result in a structural breakdown and thus a significant lower network structure but better water holding. In ternary systems, the effect of the sugar concentration and sugar type used is diminished by xanthan gum. The gelation mechanism of agarose gels with a distinct amount of co-solutes is presumably mainly affected by the water shortage evolved from the competition for it of all solutes present.     

Fatty acid and volatile compounds from salami manufactured with yerba mate (Ilex paraguariensis) extract and pork back fat and meat from pigs fed on diets with partial replacement of maize with rice bran

Four batches of salami were manufactured. Back fat and meat from pigs fed on diets with maize or maize partially substituted with rice bran (maize/rice bran, 62/38, w/w) were used to prepare two different batches, M and M/RB, respectively. The other two batches (M-YM or M/RB-YM) were prepared as batch M or M/RB, added a yerba mate (Ilex paraguariensis) extract. Salamis did not show differences in percentual general composition, texture analysis or sensory features. The TBAR values were affected by the storage time. The use of yerba mate extract controlled the lipid oxidation.     

Influence of dietary oils and protein level on pork quality. 1. Effects on muscle fatty acid composition, carcass, meat and eating quality

This study evaluated the effects of three dietary oils - palm kernel (PKO), palm (PO) and soyabean (SBO) - and two protein levels - high (HP) and low (LP) in a 3×2 factorial design involving 60 pigs on growth performance, muscle fatty acid composition and content, carcass, meat and eating qualities. Oil type did not have a significant effect on growth and carcass quality. PKO significantly reduced the polyunsaturated (PUFA) to saturated (SFA) fatty acid (P:S) ratio in longissimus muscle (P<0.001). PKO increased the concentrations of lauric (12:0), myristic (14:0), palmitic (16:0) and stearic (18:0) fatty acids and decreased linoleic acid (18:2). The LP diet increased intramuscular fat (IMF) from 1.7g/100g muscle in HP to 2.9g/100g (P<0.001), increased tenderness by 0.6 units (P<0.01) and juiciness by 0.5 units (P<0.01) on the 1-8 scale, but at the expense of lower daily weight gain (P<0.01), lower feed conversion efficiency (P<0.01), reduced P:S ratio (P<0.001) and increased lipid oxidation (P<0.01). The results suggest that PKO and PO could be used in tropical developing countries as cheaper alternatives to SBO for the production of good quality and healthy pork, but their limits of inclusion need to be determined.     

Physicochemical,rheological and sensory properties of Egyptian Kariesh cheese containing wheat bran

The physicochemical, rheological and sensory properties during the storage of Kariesh cheeses made with 0.1, 0.2, 0.3, 0.4 or 0.5 g wheat bran/100 g milk were evaluated at 0, 7 and 15 days. The cheeses with 0.5 g wheat bran/100 g milk had a significantly (P < 0.01) higher yield and moisture content, and lower pH and protein content than the control. No significant differences (P > 0.01) in salt and ash contents were observed among the cheeses studied. Texture profile analysis showed that the rheological characteristics decreased significantly in cheeses made with wheat bran. These results suggested that wheat bran (up to 0.4%) can be used to produce a fibre fortified Kariesh cheese.