Effect of High Hydrostatic Pressure on Cashew Apple (Anacardium occidentale L.) Juice Preservation

ABSTRACT:  High hydrostatic pressure is an alternative to thermal processing to inactivate spoilage and pathogenic microorganisms. Cashew apple juice has a pleasant flavor and is rich in vitamin C. Studies to determine the effect of high pressure on microorganisms in cashew apple juice are still lacking. In this study, the inactivation of natural micropopulation and inoculated Escherichia coli by high pressure was evaluated in fresh cashew apple juice. The microbiological stability of pressure-treated juice was also evaluated. The applied high pressure levels ranged from 250 to 400 MPa for periods of 3 to 7 min. Treatments with 350 MPa for 7 min and 400 MPa for either 3 or 7 min reduced the aerobic mesophilic bacteria count to a level below the detection limit. Pressure treatments were also efficient in inactivating yeast and filamentous fungi. The inoculated E. coli (10⁶ CFU/mL) was reduced to below 10 CFU/mL after a pressure treatment of 400 MPa for 3 min. The inactivation of this microorganism followed a 1st-order reaction kinetics. The decimal reduction time ( D- value) ranged from 1.21 to 16.43 min, while pressure resistance value ( z -value) was 123.46 MPa. Neither natural micropopulation growth nor E. coli repair was observed in postprocessed (400 MPa for 3 min) cashew apple juice kept under refrigerated storage (at 4 °C) during 8 wk. The results of this study demonstrated the efficacy of high-pressure treatment for preserving cashew apple juice.     

Combined treatment of high pressure and heat on killing spores of Alicyclobacillus acidoterrestris in apple juice concentrate

Alicyclobacillus acidoterrestris, a thermoacidophilic and spore-forming bacterium, has been isolated from spoiled acidic juices and is considered to be one of the important target microorganisms in quality control of acidic canned foods. Combined high pressure and heat treatment showed an effectiveness to control A. acidoterrestris spores. However, the effectiveness of the combined treatment may change upon the apple juice concentration. Therefore, the objective of this study was to evaluate different levels of apple juice concentrate for reduction of Alicyclobacillus spores by high pressure and heat. Spores of A. acidoterrestris were inoculated into three different concentrations of apple juice (17.5, 35, and 70 degrees Brix), and subjected to three high-pressure treatments (207, 414, and 621 MPa) at four different temperatures (22, 45, 71, and 90 degrees C). High-pressure treatment (207, 414, and 621 MPa) at 22degrees C did not reduce the level of spores regardless of the apple juice concentration (P > 0.05). In diluted apple juice (17.5 degrees Brix), the combined treatment of high pressure and heat resulted in spore reductions of about 2 log at 45 degrees C, and more than 5 log at higher temperatures (71 and 90 degrees C) in a high-pressure and temperature-dependent manner. For apple juice with a higher concentration (30 degrees Brix), high-pressure treatment showed no effect at 45 degrees C but resulted in about 2 and 4 log reduction at 71 and 90 degrees C, respectively. However, for apple juice concentrate (70 degrees Brix), treatment with heat or high pressure alone, or their combinations showed no inactivation against spores of A. acidoterrestris. It is likely that differences in the water availability explain the greater resistance of spores to high-pressure inactivation in the juice concentrates than in diluted juices. Our results demonstrate that the effect of high pressure combined with heat against spores of A. acidoterrestris was highly dependent on the apple juice concentration.     

Application of a multi-pass high-pressure homogenization treatment for the pasteurization of fruit juices

This work evaluates both the effects of a multiple-pass high-pressure homogenization treatment on the microbial inactivation of selected microbial strains (Saccharomyces cerevisiae, Lactobacillus delbrueckii, Escherichia coli) inoculated into commercial fruit juices (orange, red orange, pineapple) as well as the application of this non-thermal technology to the pasteurization of fresh juices (Annurca apple juice). The pressure level ranged from 50 to 250 MPa, the number of passes from 1 to 5 and the inlet temperature from 2 to 20 °C.Preliminary tests in distilled water showed that the efficiency of the multiple-pass treatment significantly depends on both the homogenizing pressure as well as the microbial species. The subsequent extension of the multiple-pass treatment to the inactivation of S. cerevisiae inoculated into three different fruit juices (orange, red-orange and pineapple juice) highlighted that the inactivation induced by the high pressure treatment did not depend on the properties of the tested juices and was not statistically different from inactivation in water (p value < 0.05). These findings were supported by the comparison of two different mathematical models used to fit the inactivation kinetics, whose fitting parameters were not significantly different for water and the fruit juices for any pressure level applied.Three homogenization passes at 150 MPa and 25 °C, which resulted to be optimal for yeast inactivation in fruit juices, were effective for the stabilization of the endogenous microbial load of fresh Annurca apple juice. The treated apple juice showed a minimum shelf-life of 28 days under refrigerated conditions, during which the natural qualities of the fresh juice were completely preserved.     

Study on the applicability of high-pressure homogenization for the production of banana juices

The aim of this preliminary study was to evaluate the potential applicability of high-pressure homogenization (HPH) for the production of banana juices. To this purpose, a prototype equipment working up to 400 MPa and a lab-scale homogenizer working up to 150 MPa were used. Temperature, microbial load, pectate lyase activity, colour and viscosity of the samples homogenized at increasing pressure were evaluated. Pressures higher than 200 MPa were needed to obtain 4 log unit reduction of total mesophilic bacteria and pectate lyase inactivation. Following HPH, banana juice resulted brighter and less viscous than the untreated one. Data suggest that HPH treatments could be a reliable technological alternative to conventional heat treatments for the production of added-value fruit juices. However, the homogenization design could play a critical role in affecting the product quality attributes. In fact, homogenization performed at the same operative pressure by using different equipment leads to different effects on product quality.     

High-pressure resistance variation of Escherichia coli O157:H7 strains and Salmonella serovars in tryptic soy broth, distilled water, and fruit juice

The effect of high pressure on the log reduction of six strains of Escherichia coli O157:H7 and five serovars of Salmonella enterica was investigated in tryptic soy broth, sterile distilled water, and commercially sterile orange juice (for Salmonella) and apple cider (for E. coli). Samples were subjected to high-pressure processing treatment at 300 and 550 MPa for 2 min at 6 degrees C. Samples were plated onto tryptic soy agar directly after pressurization and after being held for 24 h at 4 degrees C. At 300 MPa, little effect was seen on E. coli O157:H7 strains, while Salmonella serovars varied in resistance, showing reductions between 0.26 and 3.95 log CFU/ml. At 550 MPa, E. coli O157:H7 strains exhibited a range of reductions (0.28 to 4.39 log CFU/ml), while most Salmonella populations decreased beyond the detection limit (> 5-log CFU/ml reduction). The most resistant strains tested were E. coli E009 and Salmonella Agona. Generally, bacterial populations in fruit juices showed larger decreases than did populations in tryptic soy broth and distilled water. E. coli O157:H7 cultures held for 24 h at 4 degrees C after treatment at 550 MPa showed a significant log decrease as compared with cultures directly after treatment (P < or = 0.05), while Salmonella serovars did not show this significant decrease (P > 0.05). All Salmonella serovars tested in orange juice treated at 550 MPa for 2 min at 6 degrees C and held for 24 h showed a > 5-log decrease, while E. coli O157:H7 strains require a higher pressure, higher temperature, longer pressurization, or a chemical additive to achieve a 5-log decrease.     

Potentialities of High-Pressure Homogenization to Inactivate Zygosaccharomyces bailii in Fruit Juices

ABSTRACT: This experimental work was aimed to evaluate the effects of repeated high-pressure homogenization (HPH) treatments at 100 MPa on the inactivation and regrowth of Zygosaccharomyces bailii inoculated in apricot and carrot juices. Thus, the spoilage yeast was inoculated in both the juices at level of about 5 log CFU/g and the 2 systems were treated with a lab-scale Panda homogenizer for 8 passes at 100 MPa. Microbiological and chemico-physical analyses were performed immediately after the treatment and during the juice storage at room temperature. Microbial data highlighted that yeast inactivation increased with the number of passes applied. Eight passes at 100 MPa allowed yeast inactivation higher than 2.5 log CFU/mL regardless of the juice considered. On the contrary, the juice type affected the yeast fate (growth or death) over the storage at 25 °C. In fact, Z. bailii was able to attain the spoilage threshold (6 log CFU/mL) in apricot juice, although with growth kinetics dependent of the survivor levels after HPH treatment. In carrot juice this microorganism was unable to recover over the storage in the most severely treated samples. The HPH treatment had a significant effect on apricot juice pH and viscosity, while no significant effect was observed in carrot juice. The viscosity measurements showed that the application of one pass at 100 MPa resulted in the triplication of apricot viscosity index. No further significant viscosity increase (P > 0.05) was observed increasing the number of passes at 100 MPa. Practical Application: The results obtained in the present study and the proposed technology could be exploited by the industries of the beverage sector to increase the shelf life of these kinds of products. Moreover, from a technological point of view, the increase of viscosity, following the high-pressure homogenization treatment, represents a tool to expand the product gamma without the use of gelling additives or thermal treatments, which are detrimental for the sensorial and nutritional properties of this kind of products.     

胡萝卜苹果复合饮料加工工艺研究

对胡萝卜苹果复合饮料加工工艺进行了研究,通过正交实验得到最佳配方及均质参数为：胡萝卜汁40%、苹果汁20%、蔗糖5%、柠檬酸0.2%、耐酸CMC0.15%、黄原胶0.05%,高压均质压力20MPa,温度70℃,均质2次。     

超高压对澄清苹果汁杀菌效果的研究

为研究澄清苹果汁超高压处理与微生物数量之间的关系,考察了菌落总数、霉菌和酵母菌数在压力100～500 MPa、保压时间5～30 min条件下的变化。结果表明:随着压力的升高和时间的延长,杀菌效果增强;霉菌和酵母菌对压力较为敏感。对不同处理压力下苹果汁杀菌效果进行动力学分析,应用线性模型,绘制杀菌曲线,在5个压力水平下,相关系数R2均大于0.950,证明线性拟合效果良好。     

冷破碎红富士苹果浆发酵低度苹果酒工艺优化

以冷破碎红富士苹果浆为原料发酵制备低度苹果酒,通过分析不同酵母发酵周期的糖度、酒精度、pH和总酸筛选酵母菌株;在此基础上采用单因素与响应面试验以优化发酵工艺,确定冷破碎苹果浆发酵酒的最佳条件,通过分析酒品指标,与苹果清汁发酵酒的品质进行对比。结果表明,冷破碎苹果浆发酵酒的最佳工艺参数为:SY酵母发酵的初始糖度18%、酵母接种量0.1 g/L、发酵温度20℃;苹果浆发酵酒的残糖（7.5±0.46 g/L）、酒精度（7.8±0.1%）分别与苹果清汁发酵酒的残糖（7.3±0.31 g/L）、酒精度（8.0%±0.1%）差异不显著;苹果浆发酵酒的总酚（74.99±1.23 mg/100 mL）和有机酸（5.33±0.01 g/L）等成分含量高于苹果汁发酵酒（总酚47.5±2.2 mg/100 mL,有机酸5.01±0.03 g/L）。该结果可供苹果酒实际生产借鉴,也为苹果加工产业多元化发展提供思路。     

Apple Peel-Based Edible Film Development Using a High-Pressure Homogenization

ABSTRACT:  Biopolymer films were developed from apple peels of apple process co-products and their physical properties were determined. Apple peel-based films with glycerol (23%, 33%, and 44%[w/w, dry basis]) were prepared using high-pressure homogenization (HPH) at different levels of pressure (138, 172, and 207 MPa). An evaluation of the rheological properties (elastic modulus [ G '], viscous modulus [ G "], and viscosity) of the film-forming solutions was performed. For the apple peel films, the water sorption isotherms, the kinetics of water absorption, the water vapor permeability (WVP), the oxygen permeability (OP), and the tensile properties were determined. The  G ' and viscosity of the film-forming solutions decreased significantly with increasing processing pressure ( P  < 0.05). However, no difference was observed in  G " values at different homogenization pressures ( P  > 0.05). The viscosity decreased from 644 to 468 kPa·s as the pressure increased from 138 to 207 MPa at 90 °C. The monolayer water content of the apple peel films decreased with increasing content of glycerol from 23% to 33%. Further increase in glycerol content did not change the monolayer water content. The water diffusion coefficient of the films was highest at the intermediate level of glycerol content. The barrier properties (WVP and OP) of the films increased with increasing level of glycerol, while processing pressure did not influence the gas barrier properties. The films prepared at 207 MPa were less stiff and strong, but more stretchable than those prepared at 138 and 172 MPa.     

Inactivation of Escherichia coli K-12 exposed to pressures in excess of 300 MPa in a high-pressure homogenizer

Homogenization is used widely in the dairy industry to improve product stability and quality. High-pressure homogenization (HPH) of fluid foods up to pressures of 300 MPa has demonstrated excellent potential for microbial inactivation. Microbial inactivation can be enhanced during HPH with the inclusion of antimicrobial compounds. Escherichia coli K-12 cells, grown statically or in chemostat, were exposed to HPH processing pressures of 50 to 350 MPa in the absence or presence of the antimicrobial nisin. Valve temperature was regulated by a water bath and pressure, and temperature data were recorded continuously after process initiation. Survivors were enumerated via plating on nonselective growth media. Pressure and temperature at the valve outlet port exhibited a quadratic relationship (R(2) = 0.9617, P < 0.05). Significant HPH-induced inactivation of the gram-negative microorganism was observed in the range of 100 to 250 MPa. Above 300 MPa, heat was the main factor promoting microbial inactivation, regardless of whether cells were grown in chemostat or statically. Chemostat-grown cells were significantly (P < 0.05) more resistant to HPH processing than were statically grown cells. Data indicate potential synergistic effects of nisin and HPH on the inactivation of bacterial contaminants. This study represents the first report of inactivation of a bacterium with HPH pressures in excess of 300 MPa in the presence and absence of an antimicrobial.     

高压处理对鲜榨苹果汁中微生物和酚类影响的研究

为探讨高压对鲜榨苹果汁中微生物数目和酚类物质含量的影响,对鲜榨苹果汁产品进行了100～800MPa处理。结果表明:200MPa处理后,果汁中酚类物质含量和处理前没有显著差异(P>0.05)。400MPa时,处理后酚类物质相比处理前的有所减少,差异显著(P<0.05);600MPa处理后,各种酚类略有减少,但没有显著差异;压力为800MPa时,各种酚类物质的含量增加。鲜榨苹果汁中的微生物数目都随着压力的增高而降低,当压力升高到300MPa时检测不到霉菌和酵母菌,压力升高到400MPa时检测不到细菌。     

Safety and quality assessment during the ozonation of cloudy apple juice

Traditionally, ozone processing within the food industry has focused on solid foods by either gaseous treatment or washing with ozonized water. However, with the FDA's approval of ozone as a direct additive to food, the potential for liquid applications has emerged. This study investigates the effect of ozone processing on microbial inactivation (E. coli ATCC 25922 and NCTC 12900) and quality parameters (color, phenolic content) of cloudy apple juice. Apple juice samples were ozonated at room temperature (20 ± 1.5 °C) with a generated ozone concentration of 0.048 mg O(3) at a constant flow rate of 0.12 L/min and treatment time of 0 to 10 min. E. coli inactivation kinetics in apple juice were described quantitatively by using the Shoulder log-linear and the Weibull model. Ozone treatment of E. coli in apple juice demonstrate that a desired 5 log reduction can be achieved within 5 min. Apple juice color (L*, a*, and b*) and total phenols were significantly affected by ozone concentration and treatment time.     

沸石负载壳聚糖对高酸苹果发酵酒澄清工艺

以鲁加6 号苹果发酵酒为原料,根据Box-Behnkend 的中心组合试验设计原理,在单因素的基础上采用响应面分析法,建立沸石负载壳聚糖澄清苹果酒的二次多项数学模型,并以苹果酒澄清度为响应值和等高线建立响应面,研究沸石负载壳聚糖添加量、处理时间、处理温度对苹果酒澄清效果的影响。结果表明：沸石负载壳聚糖澄清苹果酒的最佳工艺条件为沸石- 壳聚糖澄清剂添加剂量11.6g/L、处理时间47.6min、处理温度27℃;与常规法澄清苹果酒相比,经过处理的苹果酒澄清度提高了16.8%,可溶性蛋白含量、总酚含量均有显著降低,而总酸、可溶性固形物含量、儿茶素、绿原酸、咖啡酸含量变化不明显,表儿茶素含量降低。     

Inactivation of Escherichia coli (ATCC 4157) in diluted apple cider by dense-phase carbon dioxide

Dense-phase carbon dioxide (CO2) treatments in a continuous flow through system were applied to apple cider to inactivate Escherichia coli (ATCC 4157). A response surface design with factors of the CO2/product ratio (0, 70, and 140 g/kg), temperature (25, 35, and 45 degrees C), and pressure (6.9, 27.6, and 48.3 MPa) were used. E. coli was very sensitive to dense CO2 treatment, with a more than 6-log reduction in treatments containing 70 and 140 g/kg CO2, irrespective of temperature and pressure. The CO2/product ratio was the most important factor affecting inactivation rate of E. coli. No effect of temperature and pressure was detected because of high sensitivity of the cells to dense CO2. Dense CO2 could be an alternative pasteurization treatment for apple cider. Further studies dealing with the organoleptic quality of the product are needed.     

Survival of Escherichia coli O157:H7 and Salmonella in apple cider and orange juice as affected by ozone and treatment temperature

Inactivation of Escherichia coli O157:H7 and Salmonella in apple cider and orange juice treated with ozone was evaluated. A five-strain mixture of E. coli O157:H7 or a five-serovar mixture of Salmonella was inoculated (7 log CFU/ml) into apple cider and orange juice. Ozone (0.9 g/h) was pumped into juices maintained at 4 degrees C, ambient temperature (approximately 20 degrees C), and 50 degrees C for up to 240 min, depending on organism, juice, and treatment temperature. Samples were withdrawn, diluted in 0.1% peptone water, and surface plated onto recovery media. Recovery of E. coli O157:H7 was compared on tryptic soy agar (TSA), sorbitol MacConkey agar, hemorrhagic coli agar, and modified eosin methylene blue agar; recovery of Salmonella was compared on TSA, bismuth sulfite agar, and xylose lysine tergitol 4 (XLT4) agar. After treatment at 50 degrees C, E. coli O157:H7 populations were undetectable (limit of 1.0 log CFU/ml; a minimum 6.0-log CFU/ml reduction) after 45 min in apple cider and 75 min in orange juice. At 50 degrees C, Salmonella was reduced by 4.8 log CFU/ml (apple cider) and was undetectable in orange juice after 15 min. E. coli O157:H7 at 4 degrees C was reduced by 4.8 log CFU/ml in apple cider and by 5.4 log CFU/ml in orange juice. Salmonella was reduced by 4.5 log CFU/ml (apple cider) and 4.2 log CFU/ml (orange juice) at 4 degrees C. Treatment at ambient temperature resulted in population reductions of less than 5.0 log CFU/ml. Recovery of E. coli O157:H7 and Salmonella on selective media was substantially lower than recovery on TSA, indicating development of sublethal injury. Ozone treatment of apple cider and orange juice at 4 degrees C or in combination with mild heating (50 degrees C) may provide an alternative to thermal pasteurization for reduction of E. coli O157:H7 and Salmonella in apple cider and orange juice.     

猕猴桃复合果汁复配工艺研究

以猕猴桃汁和苹果汁为原料,利用两者口味、营养、色泽等方面的互补,探讨了加工高浓度含果肉的猕猴桃复合饮料的最佳复配工艺。结果表明,复合果汁的最佳复配工艺参数为:均质压力50MPa,均质2次,猕猴桃混汁加入量为22．5％(V／V),苹果汁7．5％,白砂糖13％,黄原胶0．01％,CMC-Na 0．24％。     

Inactivation of Escherichia coli inoculated into cloudy apple juice exposed to dense phase carbon dioxide

The inactivation of Escherichia coli in cloudy apple juice by dense phase carbon dioxide (DPCD) was investigated. With CO2 at 20 MPa and 37 degrees C or at 30 MPa and 42 degrees C, the inactivation of E. coli significantly increased (p<0.05) when increasing the exposure time, which conformed to a fast-to-slow two-stage kinetics. The two stages were well fitted to first-order reactions. Higher temperature or pressure significantly enhanced the bactericidal effect of DPCD (p<0.05), the maximum reduction was 7.66 log CFU at 45 MPa and 52 degrees C for 30 min. The survival curves against temperature or pressure were fitted using a linear equation with high regression coefficients (R2>0.94). The temperature inactivation rate (kT) and pressure inactivation rate (kP) were obtained. Higher kT or kP indicated higher susceptibility of E. coli to temperature or pressure. Moreover, there was good linear correlation of kT with pressure (R2=1.00). Also, kP increased with increasing temperature except for 37 degrees C. Greater inactivation of E. coli was obtained with 99.9% CO2 than with 99.5% CO2 or with the initial number of 10(5) CFU/mL than with that of 10(8) CFU/mL at 20 MPa and 37 degrees C.     

Effect of High-Pressure Homogenization on the Structure of Cassava Starch

Cassava starch suspension was homogenized at different pressures (0, 20, 40, 60, 80, and 100 MPa) with a high-pressure homogenizer. To investigate the effect of high-pressure homogenization on the structure of cassava starch, the samples were characterized using microscopy, laser scattering, and X-ray diffraction techniques, with native and heat gelatinized cassava starches as controlled samples. The temperature of starch suspension increased linearly with applied pressure at a rate of 0.187°C/MPa. Microscopy studies showed that cassava starch was partly gelatinized after high-pressure homogenization, and the degree of gelatinization increased with homogenizing pressure. Results of laser scattering measurements suggested a considerable increase in particle size after homogenization at 100 MPa as a result of granule swelling. The X-ray diffraction pattern showed that there was no evident change after homogenization suggesting that the crystalline structure of starch granules was resistant to high-pressure homogenization.     

Effects of various clarification treatments on phenolic compounds and color of apple juice

The purpose of this study was to investigate the changes that occur during conventional clarification using gelatin, bentonite, silica sol, and water-soluble chitosan on the phenolic compounds, antioxidant activity, and color of apple juice. The apple material used in this study was of two varieties: Sampion and Idared. The changes in the polyphenols composition (procyanidins, hydroxycinnamic derivatives, and dihydrochalcones) were monitored through the clarification process. Sampion apple control juices contained more total polyphenols than do Idared apple juices. In Sampion variety apple juice, the dominant polyphenols are the flavan-3-ols (86% of total polyphenols), followed by hydroxycinnamic acids (9.7%), dihydrochalcones (3.0%), and flavonols (1.3%). In Idared apple juice the hydroxycinnamic acids (especially chlorogenic acid) are dominant (about 48% of total polyphenols), followed by flavan-3-ols (40%). However, the concentration of polymeric procyanidins in Sampion apple juices was 62.8 and 46.3% less when the Profloc (chitosan) and gelatin treatments were used, respectively. Aktivbentonit and Puranit (bentonite) supplementary added in juices clarification have some protective effect on polymeric procyanidins only with Profloc treatment. That kind of effect was not observed in Idared apple juices with almost eight times smaller polymeric procyanidins concentration than in Sampion apple juices. The antioxidant activity, measured by the DPPH (1,1-diphenyl-2-picrylhydrazyl radical) method, ranged from 0.20 mg TEAC/mL in Idared apple juice to 0.30 mg TEAC/mL in Sampion apple juice, measured by the ABTS method, from 0.17 to 0.48 mg TEAC/mL, respectively. Clarification of apple juices with chosen clarifying agents has statistically no significant (p>0.05) influence on antioxidant capacity. This study suggests that chitosan can be used as a conventional clarifying aid of apple juices and that treatment has no impact on their biochemical parameters.