Colour stability of six beef muscles stored in a modified atmosphere mother pack system with oxygen scavengers

Summary The effect of O₂ scavengers on the colour stability of beef in retail overwrap trays within a modified atmosphere mother pack (CO₂/N₂) was assessed. Steaks from six muscles, namely Longissimus dorsi, Psoas major, Semimembranosus, Gluteus medius, Semitendinosus and Biceps femoris were examined. After storage for 2, 4 or 6 weeks mother packs were opened and steak colour was monitored during 96 h of retail display. Redness of all muscles stored with O₂ scavengers was superior to that of steaks stored without O₂ scavengers at all storage times. Hue angle results indicated some metmyoglobin formation in all muscles during storage. Comparisons were made between steaks stored with O₂ scavengers and fresh steaks. Shelf-life values were calculated using the reflectance difference method (R₆₃₀–R₅₈₀). O₂ scavengers did not affect weight loss from the stored steaks.     

EFFECT OF OXYGEN-ENRICHED ATMOSPHERES ON STORAGE QUALITY OF PACKAGED FRESH MEAT

SUMMARY —The extension of fresh meat shelf-life is important from both practical and theoretical points of view. Color is usually used as a measure of fresh meat quality during storage. Beef top-round slices were prepared using sanitary precautions. Meat slices were enclosed in a thermally sealed semi-rigid polyvinyl chloride tray system of special design. Face-to-face meat samples were used to compare the effects of high oxygen with normal air atmospheres. One package from each pair was evacuated and the atmosphere readjusted to approximately 90% oxygen through a septum. Packages were kept at 4 ± 0.5°C and gas chromatographic readings for CO₂, O₂ and N₂ were conducted daily. Spectrophotometric and bacteriological evaluations were made on selected pack ages during storage to determine pigment oxidation and microbial growth. Three experiments each containing six to eight pairs of samples were conducted. The generation of CO₂ was observed in two periods–the first immediately after packaging and lasting for 1–2 days, after which the CO₂ level remained approximately stable up to 8—9 days, when it again started to increase in correspondence with increased bacterial growth. There was more CO₂ produced than O₂ utilized in the stored samples. In the first stage, samples stored in oxygen-enriched atmospheres had higher O₂ uptake than samples stored in air. Microbial growth was similar in both atmospheres. Under conditions of this study, head space enrichment to about 90% oxygen prolonged acceptable meat color when compared with samples stored in an air atmosphere.     

PHYSICAL AND MICROBIAL CHARACTERISTICS OF PORK LOINS IN MODIFIED ATMOSPHERE PACKAGES

Bone-in pork loins (n = 45) were selected from a commercial facility, subjected to one of three gas flush packaging treatments: NC: 75% N₂, 25% CO₂; ONC₁: 45% 0₂, 35% N₂, 20% CO₂; ONC₂: 66% O₂, 9% N₂, 25% CO₂, and stored for 7, 14 or 21 days at 0±2C. After storage, treatment and storage effects on visual evaluations, storage characteristics, microbial analysis and retail display characteristics were determined. The ONC¹ and ONC²treated loins had less discoloration after 21 days than NC treated loins, and NC treated chops had the least desirable retail display characteristics (P < 0.05). Fewer (P < 0.05) lactic acid producing bacteria (day 21) were found on NC treated loins, resulting in chops with a shorter retail shelf-life. These results indicate that higher oxygen levels (45 and 66%) are necessary for the modified atmosphere storage of fresh pork loins for 21 days.     

EFFECT of MODIFIED ATMOSPHERE PACKAGING ON GLUTATHIONE and ASCORBIC ACID CONTENT of ASPARAGUS SPEARS

Asparagus (Asparagus Officinalis L.) spears were packaged in ordinary and microperforated oriented polypropylene (OPP) films and were stored at 15C and 75% RH for up to 10 days. CO₂ concentrations ranged from 15.5 to 23% at 10 days of storage. Weight loss was less than 1.2% in microperforated film packages compared with 15% in air storage under similar conditions. Ascorbic acid content was found to be adversely affected at all the O₂ levels (1–6%) prevailing in microperforated film packages, but it was retained to the extent of 45–55% of its original concentration in ordinary OPP film packaged asparagus. the O₂ concentrations in microperforated film packages were also associated with higher glutathione concentrations in packed asparagus spears. Results of the study indicated that to preserve ascorbic acid and glutathione simultaneously in stored asparagus through MAP under high CO₂ and low O₂ conditions, O₂ concentration levels must be selected between 1 and 6% in such a way so as to get acceptable retention levels of ascorbic acid and glutathione.     

INFLUENCE OF MODIFIED ATMOSPHERE PACKAGING ON GROWTH OF CLOSTRIDIUM PERFRINGENS IN COOKED TURKEY

Clostridium perfringens containing samples of sterile ground turkey were studied to assess growth under modified atmosphere conditions. Samples were packaged under various atmospheres (CO₂/O₂/N₂: 75/5/20, 75/10/15, 75/20/5, 25/20/55, 50/20/30), stored at 4, 15 and 28C, and sampled periodically for growth. Diluted samples were plated on Shahidi Ferguson perfringens agar (Difco Laboratories, Detroit, MI) to determine vegetative cell counts. Temperature abuse (cyclic and static) of the turkey product was also investigated. The results showed that the growth of C. perfringens was slowest under 25–50% CO₂/20% O₂/balance N₂ at 15 and 28C. There was no growth at 4C for up to 28 days. Temperature abuse (28C storage) of refrigerated products for 8 h did not permit C. perfringens growth. Use of 25–50% CO₂/20% O₂/balance N₂ may extend the shelf-life of turkey, but in the absence of proper refrigeration, it cannot be relied upon to eliminate the risk of C. perfringens food poisoning .     

Effect of irradiation and modified atmosphere packaging on the microbiological and sensory quality of pork stored at refrigeration temperatures

The effect of combining low-dose irradiation (1.75 kGy) with modified atmosphere packaging (MAP) on the microbiological and sensory quality of pork chops stored at refrigeration temperatures was studied. The microflora of irradiated MAP pork was almost exclusively composed of lactic acid bacteria, predominantly Lactobacillus spp. Modified atmospheres containing either 25 or 50% CO₂, balance N₂, resulted in the best microbial control in irradiated pork held at 4°C, compared to an unirradiated MAP control, and these atmospheres were subsequently used in sensory studies. The atmosphere containing 25% CO₂ 75% N₂ maintained the uncooked colour and odour of irradiated pork chops more effectively than 50% CO₂ 50% N₂. Therefore packaging in a modified atmosphere containing 25% CO₂, balance N₂, followed by irradiation to a dose of 1.75 kGy is recommended to improve the microbiological and sensory quality of pork chops.     

The Effects of Residual Oxygen on the Storage Life of Retail-Ready Fresh Beef Steaks Masterpackaged Under a CO2 Atmosphere

ABSTRACT:  Retail-packed rump ( Gluteus medius , GM) and striploins ( Longissiumus dorsi, LD) steaks were masterpackaged under carbon dioxide (CO₂) and stored at 1 °C ± 1 °C for 14, 28, 35, and 42 d. A commercial oxygen (O₂) scavenger (ATCO HV1000®, Standa Industrie, Caen, France) was used in the masterpacks to achieve an O₂-free atmosphere. Similar packages without the O₂ scavengers were also prepared. At each storage time, 2 masterpacks of each treatment were opened and the retail trays were placed in a display case at 4 °C ± 2 °C for 1 and 48 h for microbiological and sensorial evaluations. The low growth rate of aerobic psychrotrophic flora on the stored beefsteaks demonstrated the bacteriostatic effect of CO₂ during storage. The maximum level of psychrotrophic aerobic bacteria reached during storage was approximately 10⁶ CFU/g. The steaks stored in masterpacks with scavengers bloomed to the desirable red color associated with freshly cut meat in the display case for all of the storage periods, except in the case of GM steaks, which showed a cycle of transient discoloration. GM and LD steaks were well accepted (65% and 82%, respectively) after 42 d under CO₂ at 1 °C ± 1 °C. The GM and LD steaks stored without the O₂ scavenger showed variable fractions of discoloration that significantly detracted from the appearance of the samples.     

GROWTH/SURVIVAL OF NATURAL FLORA AND LISTERIA MONOCYTOGENES ON REFRIGERATED UNCOOKED PORK AND TURKEY PACKAGED UNDER MODIFIED ATMOSPHERES

Listeria monocytogenes was inoculated onto fresh pork and turkey slices. Inoculated and control samples were packaged under modified atmospheres (100% N₂, and 20%/80% and 40%/60% CO₂O₂) or air in plastic bags of low gas permeability. Samples were stored at 1 and 7C. Samples stored in air showed a similar microbiological pattern to that usually observed in fresh meat stored aerobically. Packaging under modified atmospheres extended the meat shelf-life. Bacterial growth was strongly inhibited at 1C, particularly in samples stored under CO₂/O₂ enriched atmospheres. Temperature and pH were critical factors for L. monocytogenes growth. This pathogen grew only on pork (initial pH 5.3) packaged in air and stored at 7C. No L. monocytogenes growth was observed at 1C in any atmosphere assayed. However, growth on turkey (initial pH 6.0) was marked at 7C in all atmospheres tested, while at 1C, this bacterium grew weakly only on samples stored in air .     

Controlled atmosphere storage to decrease physiological disorders in nectarines

'Fantasia', 'Flavortop', and 'Flamekist' nectarines were examined for their response to controlled atmosphere (CA) storage. All three cultivars stored well for up to 6 weeks at 0°C in an atmosphere of 10% O₂+ 10% CO₂, while some but not all the cultivars also stored well in 2% O₂+ 5% CO₂ or 10% O₂+ 5% CO₂. The physiological storage disorders of internal breakdown and reddening were almost completely absent in nectarines kept in 10% O₂+ 10% CO₂. When 'Flamekist' nectarines from two harvests were stored in 10% O₂+ 10% CO₂ atmosphere for 6 or 8 weeks at 0°C, the fruit from the first harvest was of better quality after post-storage ripening. Although this controlled atmosphere prevented internal breakdown and reddening, after extended storage fruit did not develop the increased soluble solids content or extractable juice during post-storage ripening that occurred in non-stored fruit. Therefore, while preventing storage disorders, CA does not reduce the loss of ripening ability occurring during nectarine storage.     

EFFECT OF MODIFIED ATMOSPHERE PACKAGING ON THE QUALITY OF SMOKED CATFISH

Smoked catfish were inoculated with Listeria ivanovii then packaged under 80% CO₂/20% N₂ (M₁) and 40% CO₂/30%O₂/130% N₂ (M₂) and stored at 2 and 8C. Noninoculated samples packaged under air (A) served as controls. Fillets stored under M₂ at 8C showed the fastest growth of L. ivanovii. L. ivanovii counts in samples stored under M₁ at both temperatures decreased significantly over time. Listeria growth was observed in samples stored under air at 2 and 8C after 2 weeks. APC results were similar to that of Listeria The highest TBA values were observed in M₂-stored samples followed by air-stored samples. Lightness ("L" values) increased significantly, whereas "a" (redgreen) and "b" (blue/yellow) values decreased in all atmospheres at both temperatures over time. The combined use of M₁ and 2C improved the quality of smoked catfish by inhibiting microbial growth and minimizing the extent of lipid oxidation.     

Improved use of oxygen scavengers to stabilize the colour of retail-ready meat cuts stored in modified atmospheres

A series of three experiments were conducted to develop a retail packaging system suitable for use in centralized meat processing and packaging operations using modified atmosphere master packaging (MAP) of display-ready beef and pork cuts. It was shown that oxygen (O₂) scavengers were needed inside retail trays, lidded or over-wrapped trays could be used with equal success but inclusion of a grid inside the retail tray was not required. It was established that a minimum of eight O₂ scavengers with an O₂ absorption rate high enough to achieve an O₂ half-life of 0.6–0.7 h in the pack atmosphere were needed where the O₂ concentration could otherwise remain ≤500 ppm at any time during storage. Composite results from these experiments clearly showed that the best performance resulted from use of hard plastic retail trays containing eight O₂ scavengers, with high O₂ absorption rate, when placed underneath an absorbent pad and over-wrapped with an O₂ permeable film. Small holes in two corners of the O₂ permeable film to permit free exchange of atmospheres within the retail packages facilitated O₂ reduction during MAP storage.     

Storage of common mushroom under controlled atmospheres

The effect of controlled atmosphere (CA) on the shelf-life of the common mushroom ( Agaricus bisporus ) was assessed using six parameters correlated with its commerical qualities. Low CO₂ concentrations (up to 2.5%) reduced brown discolouration compared to the control in air. Higher CO₂ concentrations enhanced both internal and external browning. Low O₂ concentrations reduced growth of micro-organisms, including pseudomonads. Respiration rate, when the mushrooms are placed again in normal air, is proportional to CO₂ concentration during storage suggesting that CO₂ exhibits a phytotoxic effect on mushrooms. A lower mannitol content was noted in mushrooms stored under CA than those stored in air (control). Mushrooms stored in a 5% CO₂ atmosphere for 7 days did not break their veil but their texture was very soft and spongy. Texture losses decreased when CO₂ concentrations increased.     

Respiratory rate and quality changes in fresh-cut pears as affected by superatmospheric oxygen

ABSTRACT:  Changes in the respiration rate of fresh-cut "Flor de Invierno" pears stored under superatmospheric oxygen concentrations were studied and compared to those observed under traditional modified atmosphere packaging conditions. Changes in package headspace O₂ and CO₂ concentrations throughout storage were curve-fitted to nonlinear equations, calculating respiration rates by combining the derivatives of the equations and the gas permeations throughout storage. Moreover, relationships between respiratory activity and quality parameters of fresh-cut Flor de Invierno pears dipped into an antioxidant solution (0.75% N-acetylcysteine and 0.75% glutathione) were assessed. CO₂ production of fresh-cut Flor de Invierno pears stored under 70 kPa O₂ atmospheres was successfully estimated with the proposed mathematical procedure. This method also proved to describe well CO₂ production rates of fresh-cut pears stored under initial 2.5 kPa O₂+ 7 kPa CO₂ or 21 kPa O₂. In addition, a modification of Michaelis–Menten enzyme kinetics was adequate to describe the changes in estimated CO₂ production due to fermentative processes occurring under low oxygen concentrations. Superatmospheric O₂ concentrations seem to promote oxidative processes, which result into a dramatical modification of some quality attributes of fresh-cut pears.     

Effects of gas atmosphere and temperature on the respiration rates of whole and sliced mushrooms (Agaricus bisporus)--implications for film permeability in modified atmosphere packages

ABSTRACT:  An open flowthrough respirometer was used to determine the respiration rates of whole and sliced mushrooms as a function of O₂, CO₂, and storage temperature. Respiration rates were measured under the following O₂ concentrations: 20, 15, 10, 5, and 2% at 5 temperatures (4, 8, 10, 13, and 16 °C). The effects of 5 CO₂ concentrations (0, 2, 5, 10, 15%) at two O₂ levels (2 and 20%) were also examined at these temperatures. Mushroom respiration increased with temperature following an Arrhenius-type relationship; activation energies and corresponding Q₁₀ values were calculated. Lowering the oxygen concentration significantly decreased the respiration rate. The effects of reducing O₂ levels were greater at higher storage temperatures. Both activation energies and Q₁₀ values were lower under reduced O₂ atmospheres compared with those in air. A Michaelis–Menten enzyme kinetics model was evaluated for describing the influence of gas concentrations on respiration rate. The effects of O₂ fitted the O₂ enzyme kinetics model well. CO₂ exhibited small inhibitory effects on respiration of whole and sliced mushrooms, especially at low O₂ concentrations and low temperatures. The enzyme model was used to predict respiration under an optimal modified atmosphere for mushrooms, and the required film O₂ and CO₂ permeabilities were defined for key pack design parameters.     

Influence of Storage Atmosphere and Temperature on Quality Evolution of Cut Belgian Endives

ABSTRACT: An optimal combination of O₂, CO₂, and N₂ for storage of cut Belgian Endive was defined, investigating visual quality aspects. In the experimental design, principles of mixture theory were used. The acceptability of cut endives stored under different gas combinations, selected in the range where both CO₂ and O₂ were varied between 2% and 18%, was evaluated by a consumer panel at different time intervals during storage. The response was modeled with a second-degree polynomial, the response surface pointed in the direction of a gas mixture 10% CO₂, 10% O₂, and 80% N₂ for maximum acceptability or best quality during storage. Repeated experiments, including different varieties from 2 different growers, confirmed the optimal gas concentration, (10% CO₂, 10% O₂, and 80% N₂). In a second step, the effect of temperature on quality degradation of cut endives stored under optimal atmosphere conditions, was quantified using the Arrhenius equation. An activation energy of 16.3 kcal/mol was obtained.     

Effect of carbon monoxide in modified atmosphere packaging, storage time and endpoint cooking temperature on the internal color of enhanced pork

The objective of this research was to evaluate the effects of gas atmosphere, refrigerated storage time, and endpoint temperature on internal cooked color of injection-enhanced pork chops. Enhanced chops were packaged in 0.36% CO/20.34% CO₂ (CO-MAP), 80% O₂/20% CO₂ (HO-MAP), or PVC-overwrapped (PVC-OW; controls), stored at 4 °C for 0, 12, 19 or 26 days, displayed for 2 days then cooked to six endpoint temperatures (54, 60, 63, 71, 77, and 82 °C). L^*, a^*, and b^* values, hue angle and chroma were determined on the internal cut surface of cooked chops. Chops packaged in CO-MAP had the highest a^* values; a^* value began increasing on day 14. The lowest hue angles occurred in chops cooked to lower endpoint temperatures. Chops in CO-MAP had lower hue angles and higher chroma than those in HO-MAP and PVC-OW. Above 71 °C, hue angle and chroma increased. Overall, CO-MAP packaged chops stored for longer time periods then cooked to lower endpoint temperatures appeared reddest. HO-MAP packaged chops were less red, did not change over time, and appeared more well done at lower endpoint temperatures than those in other gas atmospheres. CO-MAP packaged chops retained redness even after cooking at 82 °C.     

Shelf life of Turkish whey cheese (Lor) under modified atmosphere packaging

In this study, the shelf life of Lor cheese stored under different atmosphere compositions was assessed and compared. Lor cheeses were held in four different atmospheres containing: vacuum packaging (VP), 40% CO₂/60% N₂, 60% CO₂/40% N₂ and 70% CO₂/30% N₂ (modified atmosphere packaging). Control cheeses were stored in air. All cheese samples were kept in the refrigerator at 4°C for 45 days and investigated for physicochemical, microbiological and sensory properties. The acidity index value was significantly higher ( P  < 0.05) in the control and vacuum packaged samples than in those stored for the same period under CO₂. Microbiological results showed that modified atmosphere packaging delayed microbial growth compared with air and VP samples. Of the three modified atmospheres, gas mixtures 60% and 70% CO₂ were the most effective for inhibition of growth of micro-organisms. Sensory evaluation (odour and taste) results showed that Lor cheese packaged under modified atmosphere packaging (60% CO₂/40% N₂ and 70% CO₂/30% N₂ ) retained good characteristics for 45 days of storage, while vacuum and control samples were sensorily unacceptable after 10 days of storage.     

Inhibition of Fungal Growth on Wheat and Rye Bread by Modified Atmosphere Packaging and Active Packaging Using Volatile Mustard Essential Oil

ABSTRACT: Wheat and rye bread artificially inoculated with molds were packed in modified atmospheres of 0%, 50%, 75%, or 100% CO₂ balanced with N₂, and 3 levels of residual O₂, 1%, 0.03%, or <0.01%/O₂-absorber, and stored for 30 to 35 d. Modified atmosphere packaging (MAP) was quantitatively more effective for rye bread because fewer mold species grew at elevated CO₂. However, the major rye bread contaminant, Penicillium roqueforti , was the overall most CO₂-resistant mold and only the use of O₂-absorber could prevent growth of this species. On wheat bread, the most CO₂-tolerant mold was Penicillium commune , growing in 99% CO₂ (with high residual O₂), and Aspergillus flavus was the mold species that grew at lowest O₂ in 75% CO₂ treatment. The spoilage yeast/"chalk mold" Endomyces fibuliger was less affected by the different O₂ levels than the true filamentous molds, and none of the tested MAP treatments could prevent growth, but lag-phase was increased with O₂-absorber on wheat bread and decreased with 1% residual O₂ on rye bread. Experiments with volatile mustard oil showed that A. flavus and Eurotium repens were the most mustard oil-resistant species on wheat and rye bread, respectively. A combination strategy with MAP and mustard oil proved most optimal, and total inhibition was achieved with 2 μL mustard oil/rye bread slice and between 2 and 3 μL/wheat bread. Results indicated that the nature and surface area of the product influences effectiveness of active packaging with mustard oil.     

COLOR IMPROVEMENT OF KOSHER BEEF USING SODIUM ASCORBATE AND ERYTHORBATE

The koshering process involves soaking meat in water followed by massive surface salting and rinsing to remove the salt. This process causes undesirable discoloration during storage at 4C, as compared to nonkosher beef (P<0.01). Beef steaks were dipped into sodium ascorbate (SA) or erythorbate (SE) solutions for various time periods. Untreated steaks, from the same cut, served as controls. All samples were packaged into modified atmospheres of 65% O₂ and 35% CO₂. The color of sample was observed periodically during illuminated storage at 4C. The typical red color was maintained at 4C for up to 21 days when the meat was dipped for 1 min in a 2 or 4% SE solution (pH 6.5), packaged in 65% O₂ and 35% CO₂, while the controls showed severe discoloration after 2 to 3 days. The treatment with SE had also a positive effect in reducing initial total microbial counts by 1.5 log CFU/g.     

Microbiological quality of shredded Cheddar cheese packaged in modified atmospheres

The microbiological quality of shredded Cheddar cheese packaged in different modified atmospheres with and without oxygen scavengers included in the packaging film was studied with the aim of determining how modified air packaging would affect the mould species present on shredded Cheddar cheese. The film with oxygen scavengers was more effective than the control film against mould growth, whereas the 73% CO₂/27% N₂ atmosphere resulted in the cheese with the best microbiological qualities. The three modified atmospheres and the packaging film influenced the mycoflora of shredded Cheddar cheese as the mould species isolated initially differed, from those isolated at 16 weeks in the six treatments. This study demonstrated that O₂ scavengers were effective in controlling the growth of moulds on shredded Cheddar cheese.