A study on optical, thermal, mechanical, dielectric, piezoelectric and NLO properties of unidirectional ammonium chloride added ammonium dihydrogen phosphate crystal

<0 0 1> directed ammonium dihydrogen phosphate single crystal with the addition of 1 mol% of ammonium chloride in the mother solution has been grown by Sankaranarayanan-Ramasamy method. The grown crystal has cylindrical morphology with good optical quality. It has good thermal stability up to 200 °C. Higher mechanical stability was observed in ammonium chloride added crystal compared to pure crystal. Moreover, the addition of ammonium chloride improves the quality and yields highly transparent crystal in minimum duration of growth. Good piezoelectric behaviour was observed for the grown crystal. Low dielectric loss shows that the grown crystal contains minimum defects. The optical transmission study and the powder SHG measurement show the suitability of the ingot for nonlinear optical applications.     

Investigation of SR method grown 0 0 1 directed KDP single crystal and its characterization by high-resolution X-ray diffractometry (HRXRD), laser damage threshold, dielectric, thermal analysis, optical and hardness studies

0 0 1 directed potassium dihydrogen orthophosphate (KDP) single crystal was grown by Sankaranarayanan–Ramasamy (SR) method. The 0 0 1 oriented seed crystals were mounted at the bottom of the platform and the size of the crystals were 10 mm diameter, 110 mm height. Two different growths were tried, in one the crystal diameter was the ampoule's inner diameter and in the other the crystal thickness was less than the ampoule diameter. In the first case only the top four pyramidal faces were existing whereas in the second case the top four pyramidal faces and four prismatic faces were existing through out the growth. The crystals were grown using same stoichiometric solution. The results of the two growths are discussed in this paper. The grown crystals were characterized by high-resolution X-ray diffractometry (HRXRD), laser damage threshold, dielectric, thermal analysis, UV–vis spectroscopy and microhardness studies. The HRXRD analysis indicates that the crystalline perfection is excellent without having any very low angle internal structural grain boundaries. Laser damage threshold value has been determined using Nd:glass laser operating at 1054 nm. The damage threshold for the KDP crystal is greater than 4.55 GW cm⁻². The dielectric constant was higher and the dielectric loss was less in SR method grown crystal as against conventional method grown crystal. In thermal analysis, the starting of decomposition nature is similar in SR method grown KDP crystal and conventional method grown crystal. The SR method grown KDP has higher transmittance and higher hardness value compared to conventional method grown crystals.     

Synthesis, crystal growth and characterization of organic material: N-Bromosuccinimide (NBS) for NLO applications

The organic nonlinear optical crystal of N-Bromosuccinimide (NBS) was grown by slow cooling solution growth technique using methanol as solvent. Single crystal and powder X-ray diffraction (XRD) and Fourier transform infrared (FTIR) spectral analyses were carried out to confirm the NBS crystals. The ultra violet (UV)-Visible and photoluminescence spectral studies were carried out, the green band at 2.02 eV can be attributed to radiative recombination between deep donors and shallow acceptors. The second harmonic generation (SHG) behaviour of NBS was tested by Kurtz-Perry powder technique. The hardness behaviour, laser damage threshold and dielectric characteristics of NBS crystals were studied.     

Unidirectional growth of pure and L-lysine added ADP crystals from aqueous solution

Pure and L-lysine added ammonium dihydrogen phosphate (ADP) crystals were grown in the 〈001〉 direction by Sankaranarayanan-Ramasamy (S-R) method. The grown crystals were characterized by X-Ray diffractometry (XRD), UV-Vis spectroscopy, Fourier Transform Infrared (FT-IR) and Vicker’s Microhardness analysis. XRD spectrum of each of the grown crystals proved its crystallinity. The crystals showed good transparency in the entire visible region. FT-IR spectra of the specimens revealed the presence of functional groups in them. The hardness of the pure and L-lysine added ADP crystals were measured and that of the added one was found higher. Meanwhile, it was found that the ADP crystals (pure and L-lysine added) grown by S-R method had higher hardness compared to ADP crystal grown by conventional method.     

用于连续激光器的磷酸钛氧钾晶体的制备和性能

采用掺杂生长了一系 列用于大功率LD泵浦连续激光器倍频的磷酸钛氧四（KTiOPO4,KTP）,如：Nb:KTP、Na:KTP、Ce:KTP及Rb：KTP、Cs：KTP等,虽然其中一些具有比普通KTP晶体高的效率和抗光损伤阈值,并在4%Nb:KTP中实现了NCPM,但是在大部分掺杂晶体中生长条纹、包裹体均较严重,影响了晶体的均匀性,不适于大功率连续激光器应用,为提高KTP晶体均匀性和抗光损伤阈值,采用特制原料和改进工艺生长了优质KTP晶体,可用于大功率LD泵浦的Nd:YVO4连续激光器倍频,最大的连续绿光输出功率达到5W。     

Optical, structural and microhardness properties of KDP crystals grown from urea-doped solutions

Potassium dihydrophosphate single crystals were grown from aqueous solutions onto a point seed using temperature reduction method by doping with different molar values of urea. The characterization of the grown crystals was made by visible and Fourier transform infrared spectroscopy, Vicker's hardness studies, X-ray powder diffraction, non-linear optical and laser damage threshold measurements. By comparing these crystals with the ones grown from the pure solution, it is shown that 0.2-2.0 M of the urea additive enhances the laser damage threshold and the second harmonic efficiency more than by 25 and 20%, respectively. By means of the Bond method using a multipurpose three-crystal X-ray diffractometer it is shown that the presence of urea additive increases the crystal lattice parameter c of the grown crystals, whereas the lattice parameter a is by an order less sensitive to the changing urea concentration in the solution. The Vicker's hardness studies at room temperature carried out on (1 0 0) and (0 0 1) crystallographic planes show an increased hardness of the doped crystals (grown in the presence of urea additive) on the plane (0 0 1) in comparison with that of pure potassium dihydrophosphate crystal.     

A study on the <Emphasis Type="SmallCaps">l</Emphasis>-lysine-iodic acid: semi organic non linear optical single crystals for electro-optic applications

Non linear optical single crystals of l-lysine-iodic acid (LLI) of dimensions upto 24?×?14?×?5 mm³ have been grown successfully by slow evaporation technique from aqueous solution. The crystal structure of the grown material was solved by single crystal X-ray diffraction analysis and it was found that the LLI crystal belongs to monocinic system with space group P2₁. Functional groups of the grown crystal were identified by Fourier Transform Infrared (FTIR) spectral analysis. The UV–Vis spectral analysis was carried out to measure the transparent range of the LLI crystal which is nearly 85% and the band gap energy is found to be 5.51 eV. Thermal stability and decomposition temperature of LLI crystal was found by means of TGA and DTA analyses. The mechanical behavior of the grown crystal has been employed using Vicker’s micro hardness technique. The Second Harmonic Generation (SHG) efficiency of the crystal was investigated and it was found to be 3.2 times of KDP. The particle size dependent SHG studies of LLI crystals were performed using Nd:YAG laser. The laser damage threshold value of LLI crystal is found to be 8.54 GW/cm². Dielectric study indicates the reasonable dielectric constant and low dielectric loss of LLI crystal which are essential properties to develop optoelectronic devices. The ac and dc electrical conductivity measurements were carried out at various temperatures. Photoconductivity study exhibits the negative photoconductivity nature of the LLI crystal and the results are discussed for the first time.     

Studies on the synthesis, structure, growth and physical properties of an organic NLO crystal: 2-Amino-5-nitropyridinium Phenolsulfonate

A noncentrosymmetric crystal was prepared from 2-amino-5-nitropyridine (2A5NP) and p-Phenolsulfonic acid, which was designed for second harmonic generation. Good quality single crystals of 2-amino-5-nitropyridinium Phenolsulfonate (2A5NPP) were successfully grown by the slow evaporation method with dimensions 10 × 4 × 3 mm³. The unit cell dimensions were determined from single crystal X-ray diffraction studies. The structural perfection of the grown crystals has been analyzed by high-resolution X-ray diffraction (HRXRD) rocking curve measurements. Fourier transform infrared (FTIR) spectral studies have been performed to identify the functional groups. The optical transmittance window and the lower cutoff wavelength of the 2A5NPP have been identified by UV-vis-NIR studies. Thermo gravimetric analysis (TGA) and differential thermal analysis (DTA) were used to study its thermal properties. Powder test with Nd:YAG laser radiation shows a high second harmonic generation. The laser induced surface damage threshold for the grown crystal was measured using Nd:YAG laser.     

Study of pure and l-tartaric acid doped ammonium dihydrogen phosphate single crystals: A novel nonlinear optical non-centrosymmetric crystal

Single crystals of pure and l-tartaric acid (LTA) C₄H₆O₆ doped ammonium dihydrogen phosphate (ADP) (NH₄) H₂PO₄ were grown by slow evaporation solution technique (SEST) at ambient conditions. Powder X-ray diffraction (PXRD) analysis was carried out to confirm the crystal structure and no additional phase was observed due to doping except a systematic variation in peak intensities. Fourier transform infrared spectral analysis was done to examine the presence of various functional groups in the grown crystals. UV–VIS–NIR spectroscopic analysis was carried out to see the change in optical transparency of pure ADP and crystals due to LTA with different doping concentrations. Second harmonic generation (SHG) efficiency measurement was done to examine the enhancement in the nonlinear optical characteristics of the grown crystals. The effect of LTA dopant on crystal morphology, thermal and mechanical properties of ADP have also been presented in this paper. The above studies reveal the effect of incorporation of LTA into the lattice of ADP crystals.     

The growth of benzophenone crystals by Sankaranarayanan–Ramasamy (SR) method and slow evaporation solution technique (SEST): A comparative investigation

Longest unidirectional〈1 0 0〉 benzophenone (BP) crystal having dimension of 1060 mm length and 55 mm diameter was grown by Sankaranarayanan–Ramasamy method. The growth rate was measured by monitoring the elevation of the crystal–solution interface at different temperatures. The high resolution X-ray diffraction and etching measurements indicate that the unidirectional grown benzophenone crystal has good crystalline perfection and less density of defects. The optical damage threshold of SEST and SR grown BP crystals has been investigated and found that the SR grown benzophenone crystal has higher laser damage threshold value than the conventional method grown crystal. Microhardness measurement shows that crystals grown by SR method have a higher mechanical stability than the crystals grown by SEST method. Dielectric permittivity and birefringence are high in SR grown crystal compared to SEST grown BP crystal. The UV–vis-NIR results show that SR method grown crystal exhibits 7% higher transmittance as against crystals grown by conventional method.     

Crystal growth, thermal and optical studies of semiorganic nonlinear optical material: l-lysine hydrochloride dihydrate

Single crystals of l-lysine hydrochloride dihydrate (LLHCD), a nonlinear optical material, have been grown by slow cooling technique from its aqueous solution. LLHCD was found to be highly soluble in water. The grown crystals have been subjected to single crystal X-ray diffraction to confirm the structure and to estimate the lattice parameters. The vibrational structure of the molecule is elucidated from FTIR spectra. Thermal analysis revealed the thermal stability of the grown crystals. The optical transmittance spectrum shows that the material possesses good optical transparency in the entire visible region with a UV cut-off wavelength at 228 nm. The mechanical properties of the grown crystal have been studied using Vicker's microhardness test. The laser damage threshold of 52.25 MW/cm² has been measured by irradiating Q-switched Nd:YAG laser (1064 nm).     

砷酸钛氧铷晶体的生长、缺陷和物理性能的研究

采用熔盐法,我们已生长出RbTiOAsO4大单晶。不同取向的晶片经腐蚀后,利用光学显微术,观察了晶体中的生长缺陷。并首次研究了其电光性能和电学性能。结果表明RTA晶体不仅是优良的光学倍频晶体,而且是优良的电光晶体。     

Studies on the growth and physical properties of nonlinear optical crystal: 2-Amino-5-nitropyridinium-toluenesulfonate

Single crystals of 2-amino-5-nitropyridinium-toluenesulfonate (2A5NPT) were grown by the slow cooling method. The unit cell dimensions were determined from single crystal X-ray diffraction studies. The thermal parameters - thermal diffusivity (α), thermal effusivity (e), thermal conductivity (K) and heat capacity (C_p) of 2A5NPT were measured by an improved photopyroelectric technique at room temperature. Single and multiple shot experiments performed on the grown crystals for the second harmonic of pulsed Nd:YAG laser (532 nm) show that it exhibits a high laser damage threshold which is a favorable property for nonlinear optical applications. Dielectric constant and dielectric loss of the grown crystal were evaluated for the frequency range 1 kHz-1 MHz in the temperature region 40-130 °C. Hardness values were measured using Vickers hardness measurement.     

KDP crystal doped with L-arginine amino acid: growth,structure perfection,optical and strength characteristics

Potassium Dihydrogen Phosphate (KDP) crystal doped with L-arginine (L-arg) amino acid with 1.4 wt% concentration in the solution was grown onto a point seed by the method of temperature reduction. For the first time an attempt was made to grow large-size (7 × 6 × 8 cm³) optically transparent crystals, which allowed to analyze the effect of L-arg additive on the physical properties of the different growth sectors ({100} and {101}) of KDP. The incorporation of L-arg into both growth sectors of the crystal was confirmed by the methods of optical and IR spectroscopy and found to be caused by the ability of the amino acid to form hydrogen bonds with the face {100} and electrostatically interact with the positively charged face {101} of KDP crystal. A slight variation in the unit cell parameters was reported, the elementary cell volume of KDP:L-arg crystal increased in comparison with the one of pure KDP by 2·10⁻² and 2.07·10⁻² Å³ in the sectors {100} and {101}, respectively. It was found that the doping of L-arg enhanced the SHG efficiency of KDP and depended on the crystal growth sectors. The SHG efficiency of KDP:L-arg was by a factor 2.53 and 3.95 higher in comparison with those of pure KDP for {101} and {100} growth sector, respectively. The doping was found to lead to softening of both faces by ∼3–10% and ∼14–17% in the sectors {101} and {100}, respectively. Investigation of the influence of L-arg molecules on the bulk laser damage threshold of the crystals showed that the bulk laser damage threshold of the samples of KDP:L-arg crystal was higher than the one of the pure crystal in the sector {101} and lower in the sector {100}. The correlation between microhardness and laser damage threshold were discussed. The study is helpful for further searching, designing and simulation of hybrid NLO materials.     

Synthesis, structure, growth and physical properties of a novel organic NLO crystal: 1,3-Dimethylurea dimethylammonium picrate

A novel noncentrosymmetric crystal was prepared from 1,3-dimethylurea dimethylammonium picrate, C₁₁H₁₈N₆O₈ (DMUP), which was designed for second harmonic generation. DMUP crystals exist in noncentro symmetric space group Cmc2₁ with unit cell dimensions a = 14.288(4) Å, b = 17.023(5) Å, c = 6.8268(13) Å, α = β = γ = 90° and volume = 1660.5(8) Å³. The crystal structure of DMUP has been determined using single crystal X-ray diffraction studies. The single crystals of DMUP were successfully grown by the slow evaporation method with dimensions 10 mm × 4 mm × 3 mm using dimethylformamide as solvent. The structural perfection of the grown crystals has been analysed by High-resolution X-ray diffraction (HRXRD) rocking curve measurements. Powder test with Neodymium-doped Yttrium aluminum garnet (Nd:YAG) laser radiation shows a high second harmonic generation (SHG). The laser induced surface damage threshold for the grown crystal was measured using Nd:YAG laser.     

Melt growth of novel organic nonlinear optical material and its characterization

Ethyl P-amino benzoate (EPAB) is also known as benzocaine was recently identified as new organic non linear optical (NLO) material which is having nearly six times higher SHG efficiency than that of KDP. Hence, growth of unidirectional EPAB crystal gains importance for phase matching studies and this is the first melt growth report of EPAB single crystal. Seeding with the microtube in the present technique eliminates the need for pre-grown seed and has more probability to grow bulk single crystal. Growth direction of the μT-Cz grown EPAB single crystals was identified as <100> using X-ray powder diffraction studies. Thermal properties and optical transparency of the grown material were analyzed by TG and DTA and UV-VIS spectroscopic studies respectively. Laser damage threshold study shows nearly five times high damage threshold than KDP.     

Studies on lithium l-ascorbate dihydrate: An interesting chiral nonlinear optical crystal

Lithium l-Ascorbate dihydrate (LLA) is a new metal organic nonlinear optical crystal belonging to the saccharide family. Single crystals of LLA were grown from aqueous solution. Solubility of the crystal has a positive temperature coefficient facilitating growth by slow cooling. Rietveld refinement was used to confirm the phase formation. The crystal has prismatic habit with (010), (001) and (10−1) prominent faces. Thermal analysis shows that the crystal is stable up to 102 °C. Transmission spectrum of the crystal extends from 302 nm to 1600 nm. Dielectric spectroscopic analysis revealed Cole–Cole behaviour and prominent piezoelectric resonance peaks were observed in the range of 100–200 kHz. Second harmonic generation (SHG) conversion efficiency of up to 2.56 times that of a phase matched KDP crystal was achieved when the (010) plate of LLA single crystal was rotated about the +ve c axis, by 9.4° in the clockwise direction. We also observed SHG conical sections which were attributed to noncollinear phase matching. The observation of the third conical section suggests very high birefringence and large nonlinear coefficients. A detailed study of surface laser damage showed that the crystal has high multiple damage thresholds of 9.7 GW cm⁻² and 4.2 GW cm⁻² at 1064 nm and 532 nm radiation respectively.     

Structural,linear and nonlinear optical,electrical and NBO reports on 4-aminopyridine-1-ium 4-aminobenzoate single crystal for SHG,optoelectronics and violet laser emission applications

Good quality NLO single crystal 4-aminopyridine-1-ium 4-aminobenzoate (4AP4AB) were grown by slow evaporation method. The Single crystal XRD analysis shows that the 4AP4AB compound belongs to the monoclinic system with non-centrosymmetric group C. Further, the molecular structure and vibrational assignments of the grown crystal were analysed by NMR and Fourier transform infrared (FT-IR) analysis. NBO analysis analysed inter and intramolecular interactions. Optical and thermal stabilities have been characterized by UV–Visible and DSC analysis. Linear optical parameters of the 4AP4AB crystal were quantified and listed by UV–visible study. Vicker's microhardness test at room temperature shows that the hardness number increases with increasing the load. The laser damage threshold (LDT) energy has been measured using an Nd:YAG laser. The impedance analysis recorded the dielectric response of the grown 4AP4AB crystal. The appearance of semicircle in Cole–Cole plot represents the dielectric relaxation and resistivity of the 4AP4AB crystal. Solid-state parameters of 4AP4AB were quantified and listed for the theoretical approaches.

     

Studies on the nonlinear optical single crystal: Ammonium d,l-tartrate (C4H9NO6)

The organic nonlinear optical material ammonium d,l-tartrate single crystal has been successfully grown by slow evaporation solution technique (SEST). The grown crystals were characterized by single crystal XRD and the lattice parameters have been confirmed. The structural perfection of the grown crystal was analyzed by high-resolution X-ray diffraction measurement. The optical transmittance spectrum shows that the material has a good optical transparency in the entire visible region with the UV cut-off wavelength at 234 nm. Thermogravimetric and differential scanning calorimetric measurements were performed to study the thermal properties of the grown crystal. Chemical etching studies were attempted to determine the dislocation density of the grown crystal. Mechanical behavior was assessed using Vickers hardness testing carried out on (0 0 1) crystallographic plane. The Kurtz–Perry powder SHG technique confirms the NLO property of the grown crystal and the efficiency of AMT crystal was found to be 1.3 times that of standard KDP crystal.     

Growth, thermal, dielectric and mechanical studies of triglycine zinc chloride, a semiorganic nonlinear optical material

Triglycine zinc chloride, a semiorganic material, has been grown by slow solvent evaporation technique from a mixture of aqueous solution of glycine and zinc chloride in 2:1 molar ratio at room temperature. The grown crystal is up to the dimension of 45 × 23 × 18 mm³. Characterization of the crystals was made using single-crystal X-ray diffraction for obtaining unit cell parameters. Powder X-ray diffraction was recorded and the major peaks were indexed. Simultaneous thermogravimetric analysis and differential thermal analysis were carried out for the as grown crystals to determine the thermal stability of the crystal. The crystals were further characterized by UV-Vis-NIR transmission spectrum in the range of 200 to 1100 nm. Dielectric constant and dielectric loss measurements were carried out at different temperatures and frequencies. Mechanical studies were carried out on the as grown crystal.