Chemical and irradiation treatments for killing Escherichia coli O157:H7 on alfalfa,radish, and mung bean seeds

In this study, the effectiveness of dry-heat treatment in combination with chemical treatments (electrolyzed oxidizing [EO] water, califresh-S, 200 ppm of active chlorinated water) with and without sonication in eliminating Escherichia coli O157:H7 on laboratory-inoculated alfalfa, radish, and mung bean seeds was compared with that of dry-heat treatment in combination with irradiation treatment. The treatment of mung bean seeds with EO water in combination with sonication followed by a rinse with sterile distilled water resulted in reductions of approximately 4.0 log10 CFU of E. coli O157:H7 per g. whereas reductions of ca. 1.52 and 2.64 log10 CFU/g were obtained for radish and alfalfa seeds. The maximum reduction (3.70 log10 CFU/g) for mung bean seeds was achieved by treatment with califresh-S and chlorinated water (200 ppm) in combination with sonication and a rinse. The combination of dry heat, hot EO water treatment, and sonication was able to eliminate pathogen populations on mung bean seeds but was unable to eliminate the pathogen on radish and alfalfa seeds. Other chemical treatments used were effective in greatly reducing pathogen populations on radish and alfalfa seeds without compromising the quality of the sprouts, but these treatments did not result in the elimination of pathogens from radish and alfalfa seeds. Moreover, a combination of dry-heat and irradiation treatments was effective in eliminating E. coli O157:H7 on laboratory-inoculated alfalfa, radish, and mung bean seeds. An irradiation dose of 2.0 kGy in combination with dry heat eliminated E. coli O157:H7 completely from alfalfa and mung bean seeds, whereas a 2.5-kGy dose of irradiation was required to eliminate the pathogen completely from radish seeds. Dry heat in combination with irradiation doses of up to 2.0 kGy did not unacceptably decrease the germination percentage for alfalfa seeds or the length of alfalfa sprouts but did decrease the lengths of radish and mung bean sprouts.     

Factors influencing the detection and enumeration of Escherichia coli O157:H7 on alfalfa seeds.

Isolating Escherichia coli O157:H7 from batches of alfalfa seeds used to produce sprouts implicated in human illness has been difficult, perhaps due to nonhomogenous and very low-level contamination and inaccessibility of the pathogen entrapped in protected areas of the seed coat. We evaluated the effectiveness of various treatments in releasing E. coli O157:H7 from seeds. The influence of homogenization (blending or stomaching for 1 or 2 min), rinsing method (shaking for 5 min), soaking time (0. 1, 3, 6, or 15 h), soaking temperature (4 or 21 degrees C), and the addition of surfactants (0.1%, 0.5%, or 1.0% Tween 80 or Span 20) to rinse water was determined. Blending or stomaching for 1 or 2 min, and soaking for 1 h or longer at 4 or 21 degrees C, respectively, resulted in maximum release of E. coli O157:H7 from seeds. Soaking seeds at 37 degrees C for 15 h increased cell populations of E. coli O157:H7 by approximately 3.6 log10 CFU/g, likely due to bacterial growth. The maximum number of cells released from seeds by rinse water containing 1.0% Span 20 was at 21 degrees C, whereas at 37 degrees C, 0.1% or 0.5% Tween 80 was more effective. Detection of E. coli O157:H7 on seeds stored at 37 degrees C for up to 13 weeks and on sprouts derived from these seeds was compared. E. coli O157:H7 inoculated on seeds at 2.0 log10 CFU/g was detected after storage of seeds for up to 8 weeks at 37 degrees C and in sprouts produced from the seeds. The pathogen was not detected on seeds stored for 13 weeks at 37 degrees C and was not isolated from sprouts produced from these seeds. Identifying seed treatment methods that enhance removal of E. coli O157:H7 from alfalfa seeds can aid the isolation and enumeration of the pathogen on seeds. With a combination of optimal conditions for detecting the pathogen, i.e. soaking seeds for 1 h and pummeling seeds for 1 min, an enrichment step in modified tryptic soy broth (TSB), and the use of immunomagnetic beads for separation of E. coli O157:H7 cells, E. coli O157:H7 was detected in alfalfa seeds incubated at 37 degrees C for up to 8 weeks as effectively as in sprouts produced from the seeds.     

Inactivation of Escherichia coli O157:H7 on inoculated alfalfa seeds with ozonated water and heat treatment

Alfalfa seeds inoculated with a five-strain mixture of Escherichia coli O157:H7 were immersed in water containing 4, 8, 10, and 21 ppm of ozone for 2, 4, 8, 16, 32, and 64 min at 4 degrees C. Direct ozone sparging of seeds in water was used as an alternative mode of ozone treatment. Ozone-sparged seeds were also subsequently exposed to heat treatment at 40, 50, and 60 degrees C for 3 h. Populations of E. coli O157:H7 on untreated and treated seeds were determined by spread plating diluted samples on tryptic soy agar supplemented with 50 microg/ml of nalidixic acid. Since E. coli O157:H7 was released from inoculated seeds during treatment with ozone, the rate of release of cells from inoculated seeds soaked in 0.1% peptone water for up to 64 min was also determined. The overall reduction of E. coli O157:H7 on seeds treated with ozonated water without continuous sparging ranged from 0.40 to 1.75 log10 CFU/g (59.6 to 98.2%), whereas reductions for control seeds were 0.32 to 1.03 log10 CFU/g (51.7 to 90.5%). Treatment with higher ozone concentrations enhanced inactivation, but contact time longer than 8 min did not result in significantly higher reductions (P > 0.05). For seeds treated by ozone sparging, a 1.12-log10 CFU/g (92.1%) reduction was achieved using a 2-min contact time, and a 2.21-log10 CFU/g (99.4%) reduction was achieved with a 64-min contact time. The corresponding reductions for control seeds were 0.71 log10 CFU/g (79.5%) and 2.21 log10 CFU/g (99.4%), respectively. Treatment of ozone-sparged seeds at 60 degrees C for 3 h reduced the population to an undetectable level by direct plating (4 to 4.8 log10 CFU/g), although survivors were detected by enrichment. Ozone did not have a detrimental effect on seed germination percentage.     

Comparison of chlorine and a prototype produce wash product for effectiveness in killing Salmonella and Escherichia coli O157:H7 on alfalfa seeds

Outbreaks of Salmonella and Escherichia coli O157:H7 infections associated with alfalfa and other seed sprouts have occurred with increased frequency in recent years. This study was undertaken to determine the efficacy of a liquid prototype produce wash product (Fit), compared with water and chlorinated water, in killing Salmonella and E. coli O157:H7 inoculated onto alfalfa seeds. We investigated the efficacy of treatments as influenced by seeds from two different lots obtained from two seeds suppliers and by two methods of inoculation. The efficacy of treatments was influenced by differences in seed lots and amount of organic material in the inoculum. Significant (alpha = 0.05) reductions in Salmonella populations on seeds treated with 20,000 ppm of chlorine or Fit for 30 min ranged from 2.3 to 2.5 log10 CFU/g and 1.7 to 2.3 log10 CFU/g, respectively. Reductions (alpha = 0.05) in E. coli O157:H7 ranged from 2.0 to 2.1 log10 CFU/g and 1.7 to more than 5.4 log10 CFU/g of seeds treated, respectively, with 20,000 ppm of chlorine or Fit. Compared with treatment with 200 ppm of chlorine, treatment with either 20,000 ppm of chlorine or Fit resulted in significantly higher reductions in populations of Salmonella and E. coli O157:H7. None of the treatments eliminated these pathogens as evidenced by their detection on enrichment of treated seeds. Considering the human health and environmental hazards associated with the use of 20,000 ppm of chlorine, Fit provides an effective alternative to chlorine as a treatment to significantly reduce bacterial pathogens that have been associated with alfalfa seeds.     

Evaluation of various antimicrobial interventions for the reduction of Escherichia coli O157:H7 on bovine heads during processing

The effectiveness of electrolyzed oxidizing water, FreshFx, hot water, DL-lactic acid, and ozonated water was determined using a model carcass spray-washing cabinet. A total of 140 beef heads obtained from a commercial processing line were inoculated with Escherichia coli O157:H7 on the cheek areas. Each head was exposed to a simulated preevisceration wash and then had antimicrobial wash treatments. Hot water, lactic acid, and FreshFx treatments reduced E. coli O157:H7 on inoculated beef heads by 1.72, 1.52, and 1.06 log CFU/cm2, respectively, relative to the simulated preevisceration wash. Electrolyzed oxidizing water and ozonated water reduced E. coli O157:H7 less than 0.50 log CFU/cm2. Hot water, lactic acid, and FreshFx could be used as decontamination washes for the reduction of E. coli O157:H7 on bovine head and cheek meat.     

Thermal inactivation of Salmonella and Escherichia coli O157:H7 on alfalfa seeds

Alfalfa seeds inoculated with five strains of Salmonella or Escherichia coli O157:H7 were subjected to dry heat at 55 degrees C for up to 8 days. Five-log reductions in Salmonella or E. coli O157:H7 on seeds were observed. No pathogens were detected on the sprouted seeds, which were initially inoculated with ca. 2 log CFU/g of Salmonella or more than 8 log CFU/g of E. coli O157:H7. The percentages of germination of the alfalfa seeds did not significantly decrease after 6 days of heating at 55 degrees C. These results showed that heat treatment of alfalfa seeds at 55 degrees C for up to 6 days was effective in enhancing the safety of alfalfa sprouts without affecting germination significantly.     

Efficacy of electrolyzed oxidizing water in inactivating Salmonella on alfalfa seeds and sprouts

Studies have demonstrated that electrolyzed oxidizing (EO) water is effective in reducing foodborne pathogens on fresh produce. This study was undertaken to determine the efficacy of EO water and two different forms of chlorinated water (chlorine water from Cl2 and Ca(OCl)2 as sources of chlorine) in inactivating Salmonella on alfalfa seeds and sprouts. Tengram sets of alfalfa seeds inoculated with a five-strain cocktail of Salmonella (6.3 x 10(4) CFU/g) were subjected to 90 ml of deionized water (control), EO water (84 mg/liter of active chlorine), chlorine water (84 mg/liter of active chlorine), and Ca(OCl)2 solutions at 90 and 20,000 mg/liter of active chlorine for 10 min at 24 +/- 2 degrees C. The application of EO water, chlorinated water, and 90 mg/liter of Ca(OCl)2 to alfalfa seeds for 10 min reduced initial populations of Salmonella by at least 1.5 log10 CFU/g. For seed sprouting, alfalfa seeds were soaked in the different treatment solutions described above for 3 h. Ca(OCl)2 (20,000 mg/liter of active chlorine) was the most effective treatment in reducing the populations of Salmonella and non-Salmonella microflora (4.6 and 7.0 log10 CFU/g, respectively). However, the use of high concentrations of chlorine generates worker safety concerns. Also, the Ca(OCl)2 treatment significantly reduced seed germination rates (70% versus 90 to 96%). For alfalfa sprouts, higher bacterial populations were recovered from treated sprouts containing seed coats than from sprouts with seed coats removed. The effectiveness of EO water improved when soaking treatments were applied to sprouts in conjunction with sonication and seed coat removal. The combined treatment achieved 2.3- and 1.5-log10 CFU/g greater reductions than EO water alone in populations of Salmonella and non-Salmonella microflora, respectively. This combination treatment resulted in a 3.3-log10 CFU/g greater reduction in Salmonella populations than the control (deionized water) treatment.     

Inactivation of E. coli O157:H7 on blueberries by electrolyzed water, ultraviolet light, and ozone

Increased interest in blueberries due to their nutritional and health benefits has led to an increase in consumption. However, blueberries are consumed mostly raw or minimally processed and are susceptible to microbial contamination like other type of fresh produce. This study was, therefore, undertaken to evaluate the efficacy of electrostatic spray of electrolyzed oxidizing (EO) water, UV light, ozone, and a combination of ozone and UV light in killing Escherichia coli O157:H7 on blueberries. A 5-strain mixture of E. coli O157:H7 were inoculated on the calyx and skin of blueberries and then subjected to the treatments. Electrostatic EO water spray reduced initial populations of E. coli O157:H7 by only 0.13 to 0.24 log CFU/g and 0.88 to 1.10 log CFU/g on calyx and skin of blueberries, respectively. Ozone treatment with 4000 mg/L reduced E. coli O157:H7 by only 0.66 and 0.72 log CFU/g on calyx and skin of blueberries, respectively. UV light at 20 mW/cm2 for 10 min was the most promising single technology and achieved 2.14 and greater than 4.05 log reductions of E. coli O157:H7 on the calyx and skin of blueberries, respectively. The combination treatment of 1 min ozone and followed by a 2 min UV achieved more than 1 and 2 log additional reductions on blueberry calyx than UV or ozone alone, respectively. PRACTICAL APPLICATION: Outbreaks of foodborne illnesses have been associated with consumption of fresh produce. Many methods for removing pathogens as well as minimizing their effect on quality of treated produce have been investigated. UV technology and its combination with ozone used in this study to inactive E. coli O157:H7 on blueberries was found effective. Results from this study may help producers and processors in developing hurdle technologies for the delivery of safer blueberries to consumers.     

Efficacy of ozonated and electrolyzed oxidative waters to decontaminate hides of cattle before slaughter

The hides of cattle are the primary source of pathogens such as Escherichia coli O157:H7 that contaminate preevisceration carcasses during commercial beef processing. A number of interventions that reduce hide contamination and subsequent carcass contamination are currently being developed. The objective of this study was to determine the efficacy of ozonated and electrolyzed oxidizing (EO) waters to decontaminate beef hides and to compare these treatments with similar washing in water without the active antimicrobial compounds. Cattle hides draped over barrels were used as the model system. Ozonated water (2 ppm) was applied at 4,800 kPa (700 lb in2) and 15 degrees C for 10 s. Alkaline EO water and acidic EO water were sequentially applied at 60 degrees C for 10 s at 4,800 and 1,700 kPa (250 lb in2), respectively. Treatment using ozonated water reduced hide aerobic plate counts by 2.1 log CFU/100 cm2 and reduced Enterobacteriaceae counts by 3.4 log CFU/100 cm2. EO water treatment reduced aerobic plate counts by 3.5 log CFU/100 cm2 and reduced Enterobacteriaceae counts by 4.3 log CFU/100 cm2. Water controls that matched the wash conditions of the ozonated and EO treatments reduced aerobic plate counts by only 0.5 and 1.0 log CFU/100 cm2, respectively, and each reduced Enterobacteriaceae counts by 0.9 log CFU/100 cm2. The prevalence of E. coli O157 on hides was reduced from 89 to 31% following treatment with ozonated water and from 82 to 35% following EO water treatment. Control wash treatments had no significant effect on the prevalence of E. coli O157:H7. These results demonstrate that ozonated and EO waters can be used to decontaminate hides during processing and may be viable treatments for significantly reducing pathogen loads on beef hides, thereby reducing pathogens on beef carcasses.     

Antimicrobial effect of electrolyzed oxidizing water against Escherichia coli O157:H7 and Listeria monocytogenes on fresh strawberries (Fragaria x ananassa)

ABSTRACT:  Antibacterial activity of electrolyzed oxidizing (EO) water prepared from 0.05% or 0.10% (w/v) sodium chloride (NaCl) solutions against indigenous bacteria associated with fresh strawberries ( Fragaria × ananassa ) was evaluated. The efficacy of EO water and sodium hypochlorite (NaOCl) solution in eliminating and controlling the growth of Listeria monocytogenes and Escherichia coli O157:H7 inoculated onto strawberries stored at 4 ± 1 °C up to 15 d was investigated at exposure time of 1, 5, or 10 min. Posttreatment neutralization of fruit surfaces was also determined. More than 2 log₁₀ CFU/g reductions of aerobic mesophiles were obtained in fruits washed for 10 or 15 min in EO water prepared from 0.10% (w/v) NaCl solution. Bactericidal activity of the disinfectants against L. monocytogenes and E. coli O157:H7 was not affected by posttreatment neutralization, and increasing exposure time did not significantly increase the antibacterial efficacy against both pathogens. While washing fruit surfaces with distilled water resulted in 1.90 and 1.27 log₁₀ CFU/mL of rinse fluid reduction of L. monocytogenes and E. coli O157:H7, respectively, ≥ 2.60 log₁₀ CFU/mL of rinse fluid reduction of L. monocytogenes and up to 2.35 and 3.12 log₁₀ CFU/mL of rinse fluid reduction of E. coli O157:H7 were observed on fruit surfaces washed with EO water and NaOCl solution, respectively. Listeria monocytogenes and E. coli O157:H7 populations decreased over storage regardless of prior treatment. However, EO water and aqueous NaOCl did not show higher antimicrobial potential than water treatment during refrigeration storage.     

Potential application of high hydrostatic pressure to eliminate Escherichia coli O157:H7 on alfalfa sprouted seeds

Sprouts eaten raw are increasingly being perceived as hazardous foods as they have been implicated in Escherichia coli O157:H7 outbreaks where the seeds were found to be the likely source of contamination. The objective of our study was to evaluate the potential of using high hydrostatic pressure (HHP) technology for alfalfa seed decontamination. Alfalfa seeds inoculated with a cocktail of five strains of E. coli O157:H7 were subjected to pressures of 500 and 600 MPa for 2 min at 20 degrees C in a dry or wet (immersed in water) state. Immersing seeds in water during pressurization considerably enhanced inactivation of E. coli O157:H7 achieving reductions of 3.5 log and 5.7 log at 500 and 600 MPa, respectively. When dry seeds were pressurized, both pressure levels reduced the counts by <0.7 log. To test the efficacy of HHP to completely decontaminate seeds whilst meeting the FDA requirement of 5 log reductions, seeds inoculated with a ~5 log CFU/g of E. coli O157:H7 were pressure-treated at 600 and 650 MPa at 20 degrees C for holding times of 2 to 20 min. A >5 log reduction in the population was achieved when 600 MPa was applied for durations of > or =6 min although survivors were still detected by enrichment. When the pressure was stepped up to 650 MPa, the threshold time required to achieve complete elimination was 15 min. Un-inoculated seeds pressure-treated at 650 MPa for 15 min at 20 degrees C successfully sprouted achieving a germination rate identical to untreated seeds after eight days of sprouting. These results therefore demonstrate the promising application of HHP on alfalfa seeds to eliminate the risk of E. coli O157:H7 infections associated with consumption of raw alfalfa sprouts.     

Heat treatments to enhance the safety of mung bean seeds

Salmonella enterica serovars and Escherichia coli O157:H7 have been associated with contaminated seed sprout outbreaks. The majority of these outbreaks have been traced to sprout seeds contaminated with low levels of pathogens. E. coli O157:H7 strains can grow an average of 2.3 log CFU/g over 2 days during seed germination, and Salmonella can achieve an average growth of 3.7 log CFU/g. Therefore, it is important to find an effective method to reduce possible pathogenic bacterial populations on the seeds prior to sprouting. Our objective was to assess the effectiveness of various dry heat treatments on reducing E. coli O157:H7 and Salmonella populations on mung beans intended for sprout production and to determine the effect of these treatments on seed germination. Mung beans were inoculated with five-strain cocktails of E. coli O157:H7 and of Salmonella serovars harboring the green fluorescent protein gene and then air dried overnight. Heat treatments were performed by incubating the seeds at 55 degrees C for various periods of time. Heat-treated seeds were then assessed for the efficacy of the heat treatment and the effects of heat treatment on germination rates. After inoculation and drying, 6 log CFU/g E. coli O157:H7 and 4 log CFU/g Salmonella were detected on the seeds. Following heat treatment, pathogenic bacterial populations on the seeds were below detectable levels (<1 log CFU/g), but the germination rate of the seed was not affected. Thus, the risk of contamination and the presence of pathogens in the finished sprouts were greatly reduced via the seed heat treatment process.     

Inactivation of Escherichia coli O157:H7 and Listeria monocytogenes on plastic kitchen cutting boards by electrolyzed oxidizing water.

One milliliter of culture containing a five-strain mixture of Escherichia coli O157:H7 (approximately 10(10) CFU) was inoculated on a 100-cm2 area marked on unscarred cutting boards. Following inoculation, the boards were air-dried under a laminar flow hood for 1 h, immersed in 2 liters of electrolyzed oxidizing water or sterile deionized water at 23 degrees C or 35 degrees C for 10 or 20 min; 45 degrees C for 5 or 10 min; or 55 degrees C for 5 min. After each temperature-time combination, the surviving population of the pathogen on cutting boards and in soaking water was determined. Soaking of inoculated cutting boards in electrolyzed oxidizing water reduced E. coli O157:H7 populations by > or = 5.0 log CFU/100 cm2 on cutting boards. However, immersion of cutting boards in deionized water decreased the pathogen count only by 1.0 to 1.5 log CFU/100 cm2. Treatment of cutting boards inoculated with Listeria monocytogenes in electrolyzed oxidizing water at selected temperature-time combinations (23 degrees C for 20 min, 35 degrees C for 10 min, and 45 degrees C for 10 min) substantially reduced the populations of L. monocytogenes in comparison to the counts recovered from the boards immersed in deionized water. E. coli O157:H7 and L. monocytogenes were not detected in electrolyzed oxidizing water after soaking treatment, whereas the pathogens survived in the deionized water used for soaking the cutting boards. This study revealed that immersion of kitchen cutting boards in electrolyzed oxidizing water could be used as an effective method for inactivating foodborne pathogens on smooth, plastic cutting boards.     

Efficacy of electrolyzed oxidizing (EO) and chemically modified water on different types of foodborne pathogens

This study was undertaken to evaluate the efficacy of electrolyzed oxidizing (EO) and chemically modified water with properties similar to the EO water for inactivation of different types of foodborne pathogens (Escherichia coli O157:H7, Listeria monocytogenes and Bacillus cereus). A five-strain cocktail of each microorganism was exposed to deionized water (control), EO water and chemically modified water. To evaluate the effect of individual properties (pH, oxidation-reduction potential (ORP) and residual chlorine) of treatment solutions on microbial inactivation, iron was added to reduce ORP readings and neutralizing buffer was added to neutralize chlorine. Inactivation of E. coli O157:H7 occurred within 30 s after application of JAW EO water with 10 mg/l residual chlorine and chemically modified solutions containing 13 mg/l residual chlorine. Inactivation of Gram-positive and -negative microorganisms occurred within 10 s after application of ROX EO water with 56 mg/l residual chlorine and chemically modified solutions containing 60 mg/l residual chlorine. B. cereus was more resistant to the treatments than E. coli O157:H7 and L. monocytogenes and only 3 log10 reductions were achieved after 10 s of ROX EO water treatment. B. cereus spores were the most resistant pathogen. However, more than 3 log10 reductions were achieved with 120-s EO water treatment.     

Roles of oxidation-reduction potential in electrolyzed oxidizing and chemically modified water for the inactivation of food-related pathogens

This study investigates the properties of electrolyzed oxidizing (EO) water for the inactivation of pathogen and to evaluate the chemically modified solutions possessing properties similar to EO water in killing Escherichia coli O157:H7. A five-strain cocktail (10(10) CFU/ml) of E. coli O157:H7 was subjected to deionized water (control), EO water with 10 mg/liter residual chlorine (J.A.W-EO water), EO water with 56 mg/liter residual chlorine (ROX-EO water), and chemically modified solutions. Inactivation (8.88 log10 CFU/ml reduction) of E. coli O157:H7 occurred within 30 s after application of EO water and chemically modified solutions containing chlorine and 1% bromine. Iron was added to EO or chemically modified solutions to reduce oxidation-reduction potential (ORP) readings and neutralizing buffer was added to neutralize chlorine. J.A.W-EO water with 100 mg/liter iron, acetic acid solution, and chemically modified solutions containing neutralizing buffer or 100 mg/liter iron were ineffective in reducing the bacteria population. ROX-EO water with 100 mg/liter iron was the only solution still effective in inactivation of E. coli O157:H7 and having high ORP readings regardless of residual chlorine. These results suggest that it is possible to simulate EO water by chemically modifying deionized water and ORP of the solution may be the primary factor affecting microbial inactivation.     

酸性电解水对成品豆腐的杀菌效果及品质影响研究

本实验将酸性电解水作为成品豆腐的杀菌液,研究酸性电解水对成品豆腐的杀菌效果以及品质的影响。结果表明:酸性电解水浸泡豆腐,有利于减少豆腐的微生物。20min的浸泡时间可以使豆腐的细菌总数从3.64logCFU/g降低到2.34logCFU/g。另外,仪器测定结果表明酸性电解水浸泡对豆腐的硬度影响很小、对色泽稍有影响;感官评价结果表明酸性电解水浸泡基本不影响豆腐的感官品质。     

Reduction of Escherichia coli O157:H7 and Salmonella on laboratory-inoculated alfalfa seed with commercial citrus-related products

Alfalfa sprouts contaminated with the bacterial pathogens Escherichia coli O157:H7 and Salmonella have been the source of numerous outbreaks of foodborne illness in the United States and in other countries. The seed used for sprouting appears to be the primary source of these pathogens. The aim of this study was to determine whether the efficacy of commercial citrus-related products for sanitizing sprouting seed is similar to that of high levels of chlorine. Five products (Citrex, Pangermex, Citricidal, Citrobio, and Environné) were tested at concentrations of up to 20,000 ppm in sterile tap water and compared with buffered chlorine (at 16,000 ppm). Alfalfa seeds were inoculated with four-strain cocktails of Salmonella and E. coli O157:H7 to give final initial concentrations of ca. 9.0 and 7.0 CFU/g, respectively. Treatments (10 min) with Citrex, Pangermex, and Citricidal at 20,000 ppm and chlorine at 16,000 ppm produced similar log reductions for alfalfa seed inoculated with four-strain cocktails of E. coli O157:H7 and Salmonella (3.42 to 3.46 log CFU/g and 3.56 to 3.74 log CFU/g, respectively), and all four treatments were significantly (P<0.05) more effective than the control treatment (a buffer wash). Citrobio at 20,000 ppm was as effective as the other three products and chlorine against Salmonella but not against E. coli O157:H7. Environné was not more effective (producing reductions of 2.2 to 2.9 log CFU/g) than the control treatment (which produced reductions of 2.1 to 2.3 log CFU/g) against either pathogen. None of the treatments reduced seed germination. In vitro assays, as well as transmission electron microscopy, confirmed the antibacterial nature of the products that were effective against the two pathogens and indicated that they were bactericidal. When used at 20,000 ppm, the effective citrus-related products may be viable alternatives to chlorine for the sanitization of sprouting seed pending regulatory approval.     

Pathogen Reduction and Quality of Lettuce Treated with Electrolyzed Oxidizing and Acidified Chlorinated Water

ABSTRACT: The efficacy of electrolyzed oxidizing (EO) and acidified chlorinated water (45 ppm residual chlorine) was evaluated in killing Escherichia coli O157:H7 and Listeria monocytogenes on lettuce. After surface inoculation, each leaf was immersed in 1.5 L of EO or acidified chlorinated water for 1 or 3 min at 22 °C. Compared to a water wash only, the EO water washes significantly decreased mean populations of E. coli O157:H7 and L. monocytogenes by 2.41 and 2.65 log10 CFU per lettuce leaf for 3 min treatments, respectively (p < 0.05). However, the difference between the bactericidal activity of EO and acidified chlorinated waters was not significant (p > 0.05). Change in the quality of lettuce subjected to the different wash treatments was not significant at the end of 2 wk of storage.     

Effects of Ultrasound, Irradiation, and Acidic Electrolyzed Water on Germination of Alfalfa and Broccoli Seeds and Escherichia coli O157:H7

ABSTRACT:  The ability of power ultrasound, acidic electrolyzed water (AEW), and gamma irradiation to inactivate Escherichia coli O157:H7 inoculated onto alfalfa and broccoli seeds was examined. The treatment conditions under which the alfalfa and broccoli seeds treated with sterile deionized water (SW), AEW, ultrasound cleaning tank (UST), ultrasound probe (USP), and irradiation (IR) would retain a germination percentage of >85% were first determined for each disinfection hurdle. E. coli O157:H7 inactivation tests were then conducted with the experimental conditions determined in the germination tests to find out the maximum inactivation ability of each disinfection hurdle. AEW treatment at 55 ^oC for 10 min reduced E. coli O157:H7 population by 3.4 and 3.3 log CFU/g for the alfalfa and broccoli seeds, respectively. IR at 8 kGy resulted in a 5-log reduction with seed germination of >85% for both seed types, but a reduction in the length and thickness of the sprouts was observed. None of the ultrasound treatments achieved over a 2-log reduction in E. coli O157:H7 population without lowering the germination to below 85%. The results of this study demonstrated that AEW and ultrasound, when applied individually or in combination with thermal treatment at 55 ^oC, were not able to deliver a satisfactory inactivation of E. coli O157:H7. A combination of several hurdles must be used to achieve a complete elimination of E. coli O157:H7 cells on alfalfa and broccoli seeds.     

Behavior of enterohemorrhagic Escherichia coli O157:H7 on alfalfa sprouts during the sprouting process as influenced by treatments with various chemicals.

The behavior of Escherichia coli O157:H7 on alfalfa seeds subjected to conditions similar to those used commercially to grow and market sprouts as it is affected by applications of NaOCl, Ca(OCl)2, acidified NaClO2, acidified ClO2, Na3PO4, Vegi-Clean, Tsunami, Vortexx, or H2O2 at various stages of the sprouting process was determined. Application of 2,000 ppm of NaOCl, 200 and 2,000 ppm of Ca(OCl)2, 500 ppm of acidified ClO2, 10,000 ppm of Vegi-Clean, 80 ppm of Tsunami, or 40 and 80 ppm of Vortexx to germinated seeds significantly reduced the population of E. coli O157:H7. With the exception of acidified NaOCl2 at 1,200 ppm, spray applications of these chemicals did not significantly reduce populations or control the growth of E. coli O157:H7 on alfalfa sprouts during the sprouting process. Populations of E. coli on alfalfa sprouts peaked at 6 to 7 log10 CFU/g 48 h after initiation of the sprouting process and remained stable despite further spraying with chemicals. The population of E. coli O157:H7 on sprouts as they entered cold storage at 9 +/- 2 degrees C remained essentially unchanged for up to 6 days. None of the chemical treatments evaluated was able to eliminate or satisfactorily reduce E. coli O157:H7 on alfalfa seeds and sprouts. Observations on the ability of E. coli O157:H7 to grow during production of alfalfa sprouts not subjected to chemical treatments are similar to those from a previous study in our laboratory on the behavior of Salmonella Stanley. Our results do not reveal a chemical treatment method to eliminate the pathogen from alfalfa sprouts. We have demonstrated that currently recommended procedures for sanitizing alfalfa seeds fail to eliminate E. coli O157:H7 and that the pathogen can grow to populations exceeding 7 1og10 CFU/g of sprouts produced using techniques not dissimilar to those used in the sprout industry.