REACTIVE EXTRACTION OF LEVULINIC ACID FROM AQUEOUS SOLUTIONS WITH TRI-n-OCTYLAMINE (TOA) IN 1-OCTANOL: EQUILIBRIA,KINETICS, AND MODEL DEVELOPMENT

Levulinic acid, a carboxylic acid containing a ketone structure, can be used as an acidulant in foods and beverages. Reactive extraction is a promising alternative for the recovery of carboxylic acids from aqueous streams. The design of an amine extraction process requires kinetic data for the acid-amine + solvent system used. In this study, equilibrium and kinetic data on the extraction of levulinic acid from aqueous solutions using tri-n-octylamine (TOA) in 1-octanol have been determined. The mass transfer coefficients of levulinic acid, TOA, and 2:1 levulinic acid-amine complex in 1-octanol were calculated from the acetic acid mass transfer coefficient, which was determined by measuring its fluxes of simple diffusion from kerosene to water. Based on the Hatta number and the criterion given by Doraiswamy and Sharma, the reaction regime has been found to be instantaneous reaction regime occurring at the interface on the organic phase side. An extraction model comprising equilibrium complexation constant w.r.t 2:1 levulinic acid-TOA complex formation, K_E2i (14.794 (m³ kmol^?1)²), and complex mass transfer coefficient, k_B2A (2.193 × 10^?6 m s^?1), has been developed.     

REACTIVE EXTRACTION OF SALICYLIC ACID AND D, L PHENYLALANINE IN A STIRRED CELL

Physical and reactive extractions of salicylic acid from the aqueous phase in a stirred cell were investigated theoretically and experimentally. A secondary amine, Amberlite LA 2, was used as the complexing agent for the acid

Reactive extraction of phenylalanine from the aqueous phase was investigated in the same way. For this, a quaternary amine, TOMAC, was used in which the chlorine ion was exchanged by the phenylalanine anion

Because of the instantaneous reaction in both cases, the mass transfer processes are diffusion-controlled. The concentration vs. time curves can be satisfactorily described by the two-film models. The reaction enhances the extraction considerably.     

溶剂萃取法分离提取衣康酸

研究了溶剂萃取法提取衣康酸的工艺 .首先进行了萃取剂的选择 .研究了萃取剂浓度、pH值、萃取温度在不同萃取体系中对萃取衣康酸的影响 .并在实验基础上建立了相应萃取分配的数学模型     

三辛胺萃取草酸的机理

选择草酸稀溶液为萃取对象 ,采用三辛胺 (TOA)为络合剂 ,正辛醇为稀释剂 ,开展了TOA萃取草酸的机理研究 .以红外谱图为分析手段 ,通过测定络合剂及被萃溶质的浓度对萃合物组成的影响 ,得到其萃合物以 1∶1和 1∶2 (酸 :碱 )两种形式存在于有机相中 ;并通过萃取平衡实验 ,获得了TOA萃取草酸的平衡特性 ,进一步验证了萃合物组成 .以此为基础建立了草酸与TOA两种萃合比情况下的数学模型 ,拟合求得了K₁₁及K₁₂ ,其中 1∶2萃合物的化学萃取平衡常数远远小于 1∶1的相应值     

液膜法提取浓缩氨基酸

本文研究了用液膜法提取浓缩谷氨酸。用ＴＯＭＡＣ为载体，ＥＣＡ４３６０Ｊ为表面活性剂，在适当的酸度下，以氯离子的浓度差作推动力，提取率可达６０％，浓缩倍数可达５倍。谷氨酸可以克服１１－１２倍的浓度梯度进行能动的膜输送而进入内相，这比文献报导的数值高出近一倍。     

磷酸三丁酯络合萃取丁酸的研究

用络合萃取法分离极性有机稀溶液 ,具有高效性和高选择性。利用磷酸三丁酯 (TBP)为络合剂 ,分别采用甲苯、异丙基甲酮、正辛醇、煤油作为稀释剂萃取丁酸稀溶液 ,系统研究了不同稀释剂对络合萃取平衡的影响 ,最终从效能、毒性、价格等综合因素考虑 ,选用正辛醇作为稀释剂 ;分析了络合剂浓度、丁酸溶液初始浓度、溶液 pH值以及温度对络合萃取相平衡分配系数的影响 ;利用红外光谱测定了负载有机相中萃合物的结构 ;并进行了有机溶剂的再生研究     

乙醇酸与乙醛酸的萃取分离

以乙醇酸和乙醛酸的稀溶液为分离对象,采用三烷基氧磷 (TRPO)为萃取剂、甲基异丁基酮 (MiBK)为稀释剂,研究了单、双溶质有机酸的萃取分离特性,测定了TRPO、有机酸的浓度等因素对单、双溶质有机酸萃取平衡的影响,在适当假定的基础上,建立了描述TRPO萃取乙醇酸、乙醛酸单、双溶质特性的数学模型.结果表明,随TRPO浓度的增大,分离系数β_{（glycolic /glyoxylic）}由小于1逐渐增大至大于1,乙醇酸与TRPO的萃合物有1∶1和1∶2两种形式,采用单溶质萃取反应平衡常数预测双溶质萃取的结果,预测值与实验值相当接近.同时,还对三烷基胺、磷酸三丁酯等萃取剂分离乙醇酸和乙醛酸的特性进行了讨论.     

草酸与乙醛酸的萃取分离

以草酸和乙醛酸的稀溶液为分离对象 ,采用三辛胺 (TOA)为萃取反应剂、正辛醇为稀释剂 ,研究了单溶质、双溶质有机酸的萃取分离特性 ,测定了溶液pH值、萃取反应剂的浓度等因素对双溶质有机酸萃取的影响 ,提出了萃取的化学反应发生在有机相中的假定 ,建立了TOA萃取草酸的数学模型 .实验结果表明 ,草酸与TOA的萃合物有 1∶1和 1∶2两种形式 .在本实验的条件范围内 ,草酸的分配系数较乙醛酸大 ,且随溶液pH值的增大而下降 ,草酸对乙醛酸的分离系数随pH值的增大而减小 .随萃取反应剂浓度的增大 ,两酸的分配系数皆随之增大 ,分离系数也随之增大 ,而且对于高浓度的萃取反应剂在较高的溶液pH值下草酸仍具有较大的分离系数 .采用单溶质萃取反应平衡常数及纯稀释剂中双溶质的分配系数预测双溶质萃取的结果 ,预测值与实验值相当接近     

Aliquat 336萃取醋酸的平衡特性

选择Aliquat 336为萃取剂 ,氯仿、正辛醇和煤油为稀释剂 ,醋酸稀溶液为分离溶质 ,研究了稀释剂种类、反应剂浓度、水相 pH值、溶质在水相的浓度等因素对醋酸萃取分配系数的影响 ,分析了Aliquat 336萃取醋酸的机理 ,并在此基础上建立了描述萃取平衡的数学模型 .结果表明 :萃取结果基本符合反应剂与稀释剂的简单加和 ;稀释剂对萃取效果的影响显著 ,随Aliquat 336浓度的增大 ,氯仿和煤油为稀释剂时的萃取能力较正辛醇增加得快 ;随 pH值的变化D存在一个最大值 ,该值只与反应剂在有机相中的浓度有关 .Aliquat 336萃取醋酸存在阴离子交换和化学缔合两种机制 ,表观的阴离子交换反应平衡常数K₁在有稀释剂的条件下比纯反应剂时有所增大 ,其中氯仿的影响相对较大 ,表观的化学缔合反应平衡常数K₂ 在有稀释剂的条件下表现为 ,惰性稀释剂煤油对K₂ 的影响不明显 ,氯仿具有强化的作用 ,而正辛醇具有削弱Aliquat 336与醋酸化学缔合的能力 .     

有机磷(膦)酸萃取钴和镍的动力学行为比较

依据实验结果和文献数据讨论了有机磷酸类萃取剂萃取钴及镍的动力学行为.结果表明,有机磷酸酸性强,溶入水相的速度快,则萃取速度亦快,钴和镍的萃取速度差异由溶剂交换速度决定.     

三辛胺萃取草酸的第3相特性

以三辛胺（TOA）萃取草酸时出现第3相的基本规律为研究对象,实验测定了无水溶剂及液液萃取平衡有机相中草酸的溶解度及其随TOA和正辛醇浓度的变化规律.结果显示,正辛醇对草酸及其与TOA形成的缔合物在溶剂中的溶解度影响显著;随正辛醇含量的增加,草酸及其缔合物在溶剂中的溶解度提高,因而溶剂对草酸的萃取能力随之增大;在TOA与草酸以1∶1的化学计量比饱和后,草酸溶解度出现阶跃现象,这与形成草酸二聚体的缔合物有关;相比之下,液液萃取平衡实验中有机相对草酸的溶解度大于无水溶剂的结果,溶剂中水的存在有助于缔合物溶解.同时建立了描述液液萃取平衡有机相中草酸及其缔合物溶解度的数学模型,并通过参数寻优求得了相应的模型参数.     

INFLUENCE OF INTERFACIAL TENSION AND VISCOSITY ON THE BEHAVIOR OF A PACKED COLUMN IN NEAR-CRITICAL FLUID EXTRACTION

Density and viscosity of the coexisting phases and interfacial tension of the following binary systems were measured: pelargonic acid, linoleic acid, oleic acid or stearic acid as subcritical and carbon dioxide as superecritical components. Also the corresponding phase equilibria were investigated at pressures ranging from 2 to 20 MPa and temperatures from 313 K to 393 K. With increasing pressure the concentration of the supercritical component in the liquid phase increases and viscosity and liquid interfacial tension decreases. At greater activities of the dense gases the interfacial tension decreases dramatically to values less than 2 mN/m. If the pressure exceeds a certain limit, a falling film disintegrates into small droplets. The surface excess passes through a maximum at these conditions. At first appearance of instabilities on a falling film, the logarithm of the Reynolds number is a linear function of the logarithm of the film number. Independent of the type of the investigated packings, the number of theoretical stages per meter versus Hodenstein number fall all on the same curve when an extraction is carried out in the droplet regime. Also the logarithm of the capacity of a column al the flooding point versus the logarithm of the density difference between the coexisting phases is a linear function when an extraction is carried out in the droplet regime.     

三辛胺萃取分离乳酸-醋酸

选择三辛胺为络合剂、正辛醇为稀释剂、乳酸和醋酸为被萃溶质 ,系统地研究了水相pH值及络合剂含量对单组分乳酸、醋酸及其混合物萃取特性的影响。在适当假设条件的基础上 ,建立了考虑络合萃取及物理萃取的单组分及双组分体系的相平衡分配系数表达式。在本文的实验条件下 ,随络合剂含量的升高 ,乳酸、醋酸的单组分及其混合物中各组分相平衡分配系数皆升高 ,分离因子 β增大 ;随水相平衡pH值的升高 ,相平衡分配系数均降低 ,分离因子也呈下降的趋势 .采用本文的模型进行模型参数拟合 ,其精度较好。利用单组分的络合反应平衡常数可成功地预测双组分体系中各组分的相平衡分配系数值     

煤的溶剂抽提与抽提物性质的研究

主要介绍了煤的熔剂抽提过程中抽提溶剂的选择（相似相容）和煤种、溶剂、煤的岩相组成、抽提条件等影响抽提率的因素，以及使用柱色谱、薄层色谱和固相萃取等方法对样品进行前处理，并通过质谱、凝胶渗透色谱和液相色谱－质谱联用仪等现代仪器分析手段测定抽提物的组成、结构等的研究方法，揭示了煤中部分有机质的分子结构和分子量分布等性质，综述了近年来煤的溶剂抽提及抽提物表征方面的研究进展。     

三烷基胺(7301)络合萃取对氨基苯磺酸稀溶液

利用三烷基胺 (730 1 )为络合剂 ,在较宽的 pH值条件下实验测定了对氨基苯磺酸稀溶液的萃取相平衡分配系数 ;分析了络合剂浓度、稀释剂种类以及溶液 pH值对络合萃取相平衡分配系数的影响 ;讨论了络合剂萃取对氨基苯磺酸偶极离子的质子转移过程 ,提出了平衡分配系数D值的表达式 .     

超临界CO2萃取单宁酸的研究

研究了从五倍子原料中超临界CO2萃取单宁酸的方法,通过对影响萃取的各种因素的实验,得出了优选的超临界CO2萃取条件为：萃取温度为44℃、压力为25 MPa、夹带剂为乙酸乙酯,萃取120 min效果最佳,得率为57.83%.经测定,萃取得到的单宁酸含量大于96%,本研究为制备高纯度单宁酸提供了一条新的途径.     

超临界CO2萃取单宁酸的研究

研究了从五倍子原料中超临界CO2萃取单宁酸的方法,通过对影响萃取的各种因素的实验,得出了优选的超临界CO2萃取条件为萃取温度为44℃、压力为25 MPa、夹带剂为乙酸乙酯,萃取120 min效果最佳,得率为57.83%.经测定,萃取得到的单宁酸含量大于96%,本研究为制备高纯度单宁酸提供了一条新的途径.     

INFLUENCE OF THE AMMONIUM SALT ANION ON THE SYNERGISTIC SOLVENT EXTRACTION OF LANTHANIDES WITH MIXTURES OF THENOYLTRDJLUOROACETONE AND TRIDECYLAMINE

ABSTRACT

The synergistic solvent extraction of Pr, Gd and Yb with mixtures of thenoyltnfluoroacetone ( HTTA) and primary ammonium salt ( tridecylammonium chloride or perchlorate, TDAH( C1, CI0) in dHhas been studied. The composition of the extracted species have been determined as Ln( TTA)₃ TDAHA( A= CI or CIO⁴ ) The values of the equilibrium constant K_{T. s} have been calculated. The influence of the ammonium salt anion on the extraction process has been discussed. The separation factors of the pairs Gd/ Pr and Yb/ Gd have been determined.     

SOLVENT EXTRACTION OF COBALT AND NICKEL IN BIS (2,4,4-TRI-METHYLPENTYL) PHOSPHINIC ACID, “CYANEX -272”

ABSTRACT A study has been made of the extraction of cobalt and nickel from sulfate solutions into bis(2,4,4 tri-methylpentyl) Phosphinic acid - “Cyanex 272”, diluent Esso solvent DX 3641, for both high and low metal loading in the organic phase. In dilute solution, 0.01 M, extraction constants and enthalpies were determined for both metals. The extraction of cobalt was always favored over that of nickel, increasing with increase in temperature. No structure change with temperature was found for the cobalt-Cyanex complex. Phase modifiers were found to effect the selectivity of “Cyanex 272” for cobalt.

At high metal loading, equilibrium curves for cobalt were fitted using semi-empirical curve fitting, while for nickel a straight line variation was observed. Organic phase polymerization was observed for both metals the degree of aggregation increasing with increase in loading. A step change increase in the viscosity of the organic phase was observed at high cobalt loading. Phase modifiers proved to be ineffective In reducing the increase in organic phase viscosity.