Lactose oxidase: An enzymatic approach to inhibit Listeria monocytogenes in milk

Listeria monocytogenes is a ubiquitous pathogen that can cause morbidity and mortality in immunocompromised individuals. Growth of L. monocytogenes is possible at refrigeration temperatures due to its psychrotrophic nature. The use of antimicrobials in dairy products is a potential way to control L. monocytogenes growth in processes with no thermal kill step, thereby enhancing the safety of such products. Microbial-based enzymes offer a clean-label approach for control of L. monocytogenes outgrowth. Lactose oxidase (LO) is a microbial-derived enzyme with antimicrobial properties. It oxidizes lactose into lactobionic acid and reduces oxygen, generating H₂O₂. This study investigated the effects of LO in UHT skim milk using different L. monocytogenes contamination scenarios. These LO treatments were then applied to raw milk with various modifications; higher levels of LO as well as supplementation with thiocyanate were added to activate the lactoperoxidase system, a natural antimicrobial system present in milk. In UHT skim milk, concentrations of 0.0060, 0.012, and 0.12 g/L LO each reduced L. monocytogenes counts to below the limit of detection between 14 and 21 d of refrigerated storage, dependent on the concentration of LO. In the 48-h trials in UHT skim milk, LO treatments were effective in a concentration-dependent fashion. The highest concentration of LO in the 21-d trials, 0.12 g/L, did not show great inhibition over 48 h, so concentrations were increased for these experiments. In the lower inoculum, after 48 h, a 12 g/L LO treatment reached levels of 1.7 log cfu/mL, a reduction of 1.3 log cfu/mL from the initial inoculum, whereas the control grew out to approximately 4 log cfu/mL, an increase of 1 log cfu/mL from the inoculum on d 0. When a higher challenge inoculum of 5 log cfu/mL was used, the 0.12 g/L and 1.2 g/L treatments reduced the levels by 0.2 to 0.3 log cfu/mL below the initial inoculum and the 12 g/L treatment by >1 log cfu/mL below the initial inoculum by hour 48 of storage at refrigeration temperatures. After the efficacy of LO was determined in UHT skim milk, LO treatments were applied to raw milk. Concentrations of LO were increased, and the addition of thiocyanate was investigated to supplement the effect of the lactoperoxidase system against L. monocytogenes. When raw milk was inoculated with 2 log cfu/mL, 1.2 g/L LO alone and combined with sodium thiocyanate reduced ~0.8 log cfu/mL from the initial inoculum on d 7 of storage, whereas the control grew out to >1 log cfu/mL from the initial inoculum. Furthermore, in the higher inoculum, 1.2 g/L LO combined with sodium thiocyanate reduced L. monocytogenes counts from the initial inoculum by >1 log cfu/mL, whereas the control grew out 2 log cfu/mL from the initial inoculum. Results from this study suggest that LO is inhibitory against L. monocytogenes in UHT skim milk and in raw milk. Therefore, LO may be an effective treatment to prevent L. monocytogenes outgrowth, increase the safety of raw milk, and be used as an effective agent to prevent L. monocytogenes proliferation in fresh cheese and other dairy products. This enzymatic approach is a novel application to control the foodborne pathogen L. monocytogenes in dairy products.     

Sporulating behavior of Bacillus licheniformis strains influences their population dynamics during raw milk holding

To understand the role of strain variability, population dynamics of 2 strains of Bacillus licheniformis, ATCC 6634 and ATCC 14580, were modeled as a function of temperature (4.0–12.0°C) and duration (0–72 h) using regression analysis. Based on the initial spiking of vegetative cells (approximately 4.0 log cfu/mL) and spores (approximately 2.0 log cfu/mL), regression equations, elucidating B. licheniformis growth behavior during raw milk holding at low temperature, were obtained. Contour plots were developed to determine the time-temperature combinations, keeping the population changes to less than 1.0 log. In vegetative cell spiking study of B. licheniformis ATCC 6634 (S1), cell population changes remained below 1.0 log up to 72 h at 8°C. For B. licheniformis ATCC 14580 (S2), 1.0 log shift was not observed only after 80 h at 8°C, indicating higher multiplication potential of S1 as compared with S2. As S2 was a readily sporulating strain, the vegetative spiking study showed spore formation at different storage temperatures. Evidence of some parallel germination was observed for this strain at 8°C or higher, when raw milk samples were spiked with spores. The experimental values obtained for sporeformers and spore counts were validated with contour plot-generated values. Overall, for raw milk samples predominated by the low sporulating strain, the contour plots suggested holding at 8°C or below for up to 72 h. In the case of the readily sporulating strain (S2), raw milk could be held at 8°C for 80 h, where little or no sporulation is observed. Sporulation behavior, germination and multiplication ability, strain variability, and temperature and duration of holding raw milk influenced the population dynamics of Bacillus species. However, in the presence of equivalent numbers of both types of sporulating strains in raw milk, despite strain variability, holding milk at 8°C for not more than 72 h would keep any cell population changes below 1.0 log. In addition, under these storage conditions, the population would remain as vegetative cells that are likely to be inactivated by pasteurization. The contour plots, so generated, would help predict the population shifts and define optimum holding conditions for raw milk before further processing.     

Evaluation of the effects of ultraviolet light on bacterial contaminants inoculated into whole milk and colostrum,and on colostrum immunoglobulin G

Raw milk and colostrum can harbor dangerous microorganisms that can pose serious health risks for animals and humans. According to the USDA, more than 58% of calves in the United States are fed unpasteurized milk. The aim of this study was to evaluate the effect of UV light on reduction of bacteria in milk and colostrum, and on colostrum IgG. A pilot-scale UV light continuous (UVC) flow-through unit (45 J/cm²) was used to treat milk and colostrum. Colostrum and sterile whole milk were inoculated with Listeria innocua, Mycobacterium smegmatis, Salmonella serovar Typhimurium, Escherichia coli, Staphylococcus aureus, Streptococcus agalactiae, and Acinetobacter baumannii before being treated with UVC. During UVC treatment, samples were collected at 5 time points and bacteria were enumerated using selective media. The effect of UVC on IgG was evaluated using raw colostrum from a nearby dairy farm without the addition of bacteria. For each colostrum batch, samples were collected at several different time points and IgG was measured using ELISA. The UVC treatment of milk resulted in a significant final count (log cfu/mL) reduction of Listeria monocytogenes (3.2 ± 0.3 log cfu/mL reduction), Salmonella spp. (3.7 ± 0.2 log cfu/mL reduction), Escherichia coli (2.8 ± 0.2 log cfu/mL reduction), Staph. aureus (3.4 ± 0.3 log cfu/mL reduction), Streptococcus spp. (3.4 ± 0.4 log cfu/mL reduction), and A. baumannii (2.8 ± 0.2 log cfu/mL reduction). The UVC treatment of milk did not result in a significant final count (log cfu/mL) reduction for M. smegmatis (1.8 ± 0.5 log cfu/mL reduction). The UVC treatment of colostrum was significantly associated with a final reduction of bacterial count (log cfu/mL) of Listeria spp. (1.4 ± 0.3 log cfu/mL reduction), Salmonella spp. (1.0 ± 0.2 log cfu/mL reduction), and Acinetobacter spp. (1.1 ± 0.3 log cfu/mL reduction), but not of E. coli (0.5 ± 0.3 log cfu/mL reduction), Strep. agalactiae (0.8 ± 0.2 log cfu/mL reduction), and Staph. aureus (0.4 ± 0.2 log cfu/mL reduction). The UVC treatment of colostrum significantly decreased the IgG concentration, with an observed final mean IgG reduction of approximately 50%. Development of new methods to reduce bacterial contaminants in colostrum must take into consideration the barriers imposed by its opacity and organic components, and account for the incidental damage to IgG caused by manipulating colostrum.     

Determination and validation of D-values for Listeria monocytogenes and Shiga toxin–producing Escherichia coli in cheese milk

Certain cheeses can be legally produced in the United States using raw milk, but they must be aged for at least 60 d to reduce pathogen risks. However, some varieties, even when aged for 60 d, have been shown to support growth of Listeria monocytogenes or survival of Shiga toxin–producing Escherichia coli (STEC). Thermization, as a subpasteurization heat treatment, has been proposed as a control to reduce the risk of pathogens in raw cheese milk while retaining some quality attributes in the cheese. However, the temperature and time combinations needed to enhance safety have not been well characterized. The objective of this research was to determine and validate decimal reduction values (D-values) for L. monocytogenes and STEC at thermization temperatures 65.6, 62.8, and 60.0°C; a D-value at 57.2°C was also determined for L. monocytogenes only. Nonhomogenized, pasteurized whole-milk samples (1 mL) were inoculated with 8-log cfu/mL L. monocytogenes or STEC (5- or 7-strain mixtures, respectively), vacuum-sealed in moisture-impermeable pouches, and heated via water bath submersion. Duplicate samples were removed at appropriate intervals and immediately cooled in an ice bath. Surviving bacteria were enumerated on modified Oxford or sorbitol MacConkey overlaid with tryptic soy agar to aid in the recovery of heat-injured cells. Duplicate trials were conducted, and survival data were used to calculate thermal inactivation rates. D_65.6°C-, D_62.8°C-, and D_60.0°C-values of 17.1 and 7.2, 33.8 and 16.9, and 146.6 and 60.0 s were found for L. monocytogenes and STEC, respectively, and a D_57.2°C-value of 909.1 s was determined for L. monocytogenes. Triplicate validation trials were conducted for each test temperature using 100 mL of milk inoculated with 3 to 4 log cfu/mL of each pathogen cocktail, A 3-log reduction of each pathogen was achieved faster in larger volumes than what was predicted by D-values (D-values were fail-safe). Data were additionally compared with published results from 21 scientific studies investigating L. monocytogenes and STEC in whole milk heated to thermization temperatures (55.0–71.7°C). These data can be used to give producers of artisanal raw-milk cheese flexibility in designing thermal processes to reduce L. monocytogenes and STEC populations to levels that are not infectious to consumers.     

The behaviour of log phase Escherichia coli at temperatures below the minimum for sustained growth

The behaviour of cold-adapted, log phase Escherichia coli broth cultures during incubation at 2°C or 6°C for upto 8 days, and during subsequent incubation at 12°C, was determined by measurement of absorbance values at 600 nm (A₆₀₀), enumeration of colony forming units (cfu) on plate count agar (PCA) and violet red bile agar (VRBA), and measurement of the length of cells viewed under phase contrast illumination. The A₆₀₀ values and the mean length of cells remained constant for cultures incubated at 2°C; however, numbers of cfu recovered on PCA declined by about 1 log cfu over 8 days, while the numbers of cfu recovered on VRBA declined by about 1 log cfu during the first day, and by about a further log cfu by day 8. For cultures incubated at 6°C, A₆₀₀ values increased about 0·6 log A₆₀₀ units during the first 4 days and declined by less than 0·1 log A₆₀₀ unit during the next 4 days. The numbers of cfu recovered on PCA increased by about 0·5 log cfu unit during the first day at 6°C and declined by about 1 log cfu during the subsequent 7 days. The numbers of cfu recovered on VRBA did not increase during the first day at 6°C, and at that and subsequent times were between 0·3 and 0·8 log cfu less than the log numbers recovered on PCA. The mean lengths of cells declined from 5 to less than 4 μ m during the first day at 6°C, but increased to 8 μ m between the fourth and eighth days, with the mean length of the longest 10% of cells increasing from 6 to 18 μ m. For cultures incubated at 12°C after incubation at 2°C or 6°C for 4 and 8 days, both A₆₀₀ values and enumeration of colonies on PCA indicated the initiation of growth after about 15 h. However, cultures that had been incubated at 2°C proceeded to sustained exponential growth, while cells in cultures that had been incubated at 6°C elongated during incubation at 12°C between 10 and 30 h. The division of elongated cells to cells of normal size resulted in numbers of cfu increasing at rates greater than the exponential growth rate at 12°C. The observations may have implications for the control of mesophilic pathogen proliferation in raw meats and other chilled foods.     

Dynamic kinetic analysis of growth of Listeria monocytogenes in pasteurized cow milk

The objective of this study was to develop a dynamic model for predicting the growth of Listeria monocytogenes in pasteurized cow milk under fluctuating temperature conditions during storage and temperature abuse. Six dynamic temperature profiles that simulated random fluctuation patterns were designed to change arbitrarily between 4 and 30°C. The growth data collected from 3 independent temperature profiles were used to determine the kinetic parameters and construct a growth model combining the primary and secondary models using a 1-step dynamic analysis method. The results showed that the estimated minimum growth temperature and maximum cell concentration were 0.6 ± 0.2°C and 7.8 ± 0.1 log cfu/mL (mean ± standard error), with the root mean square error (RMSE) only 0.3 log cfu/mL for model development. The model and the associated kinetic parameters were validated using the data collected under both dynamic and isothermal conditions, which were not used for model development, to verify the accuracy of prediction. The RMSE of prediction was approximately 0.3 log cfu/mL for fluctuating temperature profiles, and it was between 0.2 and 1.1 log cfu/mL under certain isothermal temperatures (2–30°C). The resulting model and kinetic parameters were further validated using 3 growth curves at 4, 7, and 10°C arbitrarily selected from ComBase (www.combase.cc). The RMSE of prediction was 0.8, 0.4, and 0.5 log cfu/mL, respectively, for these curves. The validation results indicated the predictive model was reasonably accurate, with relatively small RMSE. The model was then used to simulate the growth of L. monocytogenes under a variety of continuous and square-wave temperature profiles to demonstrate its potential application. The results of this study showed that the model developed in this study can be used to predict the growth of L. monocytogenes in contaminated milk during storage.     

Bactericidal activity of lauric arginate in milk and Queso Fresco cheese against Listeria monocytogenes cold growth

Lauric arginate (LAE) at concentrations of 200 ppm and 800 ppm was evaluated for its effectiveness in reducing cold growth of Listeria monocytogenes in whole milk, skim milk, and Queso Fresco cheese (QFC) at 4°C for 15 to 28 d. Use of 200 ppm of LAE reduced 4 log cfu/mL of L. monocytogenes to a nondetectable level within 30 min at 4°C in tryptic soy broth. In contrast, when 4 log cfu/mL of L. monocytogenes was inoculated in whole milk or skim milk, the reduction of L. monocytogenes was approximately 1 log cfu/mL after 24 h with 200 ppm of LAE. When 800 ppm of LAE was added to whole or skim milk, the initial 4 log cfu/mL of L. monocytogenes was nondetectable following 24 h, and no growth of L. monocytogenes was observed for 15 d at 4°C. With surface treatment of 200 or 800 ppm of LAE on vacuum-packaged QFC, the reductions of L. monocytogenes within 24 h at 4°C were 1.2 and 3.0 log cfu/g, respectively. In addition, the overall growth of L. monocytogenes in QFC was decreased by 0.3 to 2.6 and by 2.3 to 5.0 log cfu/g with 200 and 800 ppm of LAE, respectively, compared with untreated controls over 28 d at 4°C. Sensory tests revealed that consumers could not determine a difference between QFC samples that were treated with 0 and 200 ppm of LAE, the FDA-approved level of LAE use in foods. In addition, no differences existed between treatments with respect to flavor, texture, and overall acceptability of the QFC. Lauric arginate shows promise for potential use in QFC because it exerts initial bactericidal activity against L. monocytogenes at 4°C without affecting sensory quality.     

Lactose oxidase: Enzymatic control of Pseudomonas to delay age gelation in UHT milk

Shelf-stable milk is consumed worldwide, and this market is expected to continue growing. One quality challenge for UHT milk is age gelation during shelf life, which is in part caused by bacterial heat-stable proteases (HSP) synthesized during the raw milk storage period before heat processing. Some Pseudomonas spp. are HSP producers, and their ability to grow well at refrigeration temperature make them important spoilage organisms for UHT processors to control. Previous studies have shown that lactose oxidase (LO), a natural and commercially available enzyme that produces hydrogen peroxide and lactobionic acid from lactose, can control bacterial growth in raw milk. In this research, we investigated the ability of LO to control HSP producer outgrowth, and thus delay age gelation in UHT milk. Six strains of Pseudomonas spp. were selected based on their ability to synthesize HSP and used as a cocktail to inoculate both raw and sterile (UHT) milk at a level of 1 × 10⁵ cfu/mL. Groups were treated with and without LO, stored for 4 d at 6°C, and monitored for cell count and pH. Additionally, a sample from each was tested for HSP activity via particle size analysis (average effective diameter at 90° angle and 658 nm wavelength) and visual inspection on each day of the storage period. The HSP activity results were contrasted using Tukey's HSD test, which showed that in UHT milk, a LO treatment (0.12 g/L) effectively prevented gelation as compared with the control. In raw milk, however, a concentration of 0.24 g/L of LO was needed to obtain a similar effect. This test was scaled up to 19-L pilot plant batches of raw milk where they were challenged with Pseudomonas cocktail, treated with LO for 3 d, and then UHT processed. Resulting UHT milk bottles were monitored for gelation. Significant differences in particle size between the LO-treated samples and the control were observed as early as 1 mo after processing, and gelation was not detected in the LO-treated samples through 6 mo of storage. These results demonstrated that LO can be used to delay age gelation in UHT milk induced by HSP-producing Pseudomonas spp., representing an opportunity to improve quality and reduce postproduction losses in the shelf-stable milk market sector.     

Olive oil polyphenol extract inhibits vegetative cells of Bacillus cereus isolated from raw milk

This study was conducted to analyze the antibacterial effect of olive oil polyphenol extract (OOPE) against vegetative cells of Bacillus cereus isolated from raw milk and reveal the possible antibacterial mechanism. The diameter of inhibition zone, minimum inhibitory concentration, minimum bactericidal concentration, and survival counts of bacterial cells in sterile normal saline and pasteurized milk were used to evaluate the antibacterial activity of OOPE against B. cereus vegetative cells. The changes in intracellular ATP concentration, cell membrane potential, content of bacterial protein, and cell morphology were analyzed to reveal possible mechanisms of action. Our results showed the diameter of inhibition zone, minimum inhibitory concentration, and minimum bactericidal concentration of OOPE against B. cereus vegetative cells were 18.44 ± 0.55 mm, 0.625 mg/mL, and 1.25 mg/mL, respectively. Bacillus cereus GF-1 vegetative cells were decreased to undetectable levels from about 8 log cfu/mL after treatments with 0.625 mg/mL of OOPE in normal saline at 30°C for 3 h and in pasteurized milk at 30°C for 10 h. The antibacterial mechanisms of OOPE against B. cereus GF-1 vegetative cells may be due to the reduction of intracellular ATP concentrations, cell membrane depolarization, decrease of bacterial protein content, and leakage from cytoplasm. These findings illustrated that OOPE could be used to prevent the growth of contaminating B. cereus cells in dairy products.     

Probiotic Bifidobacterium animalis ssp. lactis Probio-M8 improves the properties and organic acid metabolism of fermented goat milk

The addition of Bifidobacterium to goat milk has dual effects on health, for which various inherent nutrients of goat milk are retained and live probiotics are provided. We explored the effect of Bifidobacterium animalis ssp. lactis Probio-M8 (Probio-M8) on fermentation characteristics, formation of organic acid, sensory properties, and storage characteristics of fermented goat milk (with added 4.0% sucrose). Addition of Probio-M8 decreased the fermentation time and significantly increased the content of functional organic acids, such as acetic acid, and functional long-chain unsaturated fatty acids, including linoleic acid, α-linolenic acid, and docosahexaenoic acid. Furthermore, the contents of medium-chain and short-chain fatty acids, which are related to “goaty” flavor, were significantly lower in the Probio-M8 treatment compared with the control. The number of living Probio-M8 decreased from 8.27 log cfu/mL (1.80 × 10⁸ cfu/mL) to 7.94 log cfu/mL (0.79 × 10⁸ cfu/mL) after 28 d of storage. Titratable acidity and pH value did not differ between the control group and experimental group (containing Probio-M8). Sensory evaluation indicated a lower goaty flavor and odor in the Probio-M8 fermented milk. Our results suggest that the addition of the probiotic Probio-M8 could improve the sensory, physicochemical, and functional properties of fermented goat milk.     

Short communication: Influence of an aqueous myrrh suspension on yogurt culture bacteria over yogurt shelf life

Myrrh is an essential oil and natural flavoring approved by the US Food and Drug Administration, and it has antibacterial and antifungal activity against pathogens. Our objective was to determine the effect of an aqueous myrrh suspension on Streptococcus thermophilus and Lactobacillus delbrueckii ssp. bulgaricus counts in peptone solution and yogurt, as well as pH and titratable acidity of yogurt during 5 wk of storage at 1 to 4°C. The myrrh suspension (10% wt/vol) was prepared and incorporated into a pure culture dilution in peptone and into yogurt mix at a 1% (vol/vol) level. A control with no myrrh was also prepared, and 3 replications were conducted. Streptococcus thermophilus were enumerated using Streptococcus thermophilus agar with aerobic incubation at 37°C for 24 h, and Lactobacillus delbrueckii ssp. bulgaricus were enumerated using de Man, Rogosa, and Sharpe agar adjusted to pH 5.2, with anaerobic incubation at 43°C for 72 h. During the 8-h period after inoculation, S. thermophilus and L. delbrueckii ssp. bulgaricus counts in peptone solution at 37°C and 43°C, respectively, were not significantly different in the presence or absence of the aqueous myrrh suspension. Counts of S. thermophilus in yogurt containing myrrh (mean ± SD; 4.96 ± 0.58 log cfu/mL) were not significantly different from those in the control yogurt (4.87 ± 0.39 log cfu/mL). The log counts for L. delbrueckii ssp. bulgaricus in yogurt containing myrrh (5.04 ± 1.44 log cfu/mL) and those of the control (5.52 ± 1.81 log cfu/mL) did not differ, and the counts remained within 1 log of each other throughout 5 wk of storage. The pH of the yogurts containing the aqueous myrrh suspension was not significantly different from that of the control yogurts, and their pH values were within 0.1 pH unit of each other in any given week. Titratable acidity values remained steady around 1.1 to 1.2% lactic acid for both yogurt types throughout the storage period, with no significant differences between them. Yogurt culture bacteria can survive in the presence of a myrrh suspension in yogurt with no significant change in pH or titratable acidity. Therefore, it may be beneficial to add an aqueous myrrh suspension to yogurt.     

PROTECTIVE EFFECT OF LYSOSTAPHIN FROM STAPHYLOCOCCUS SIMULANS AGAINST GROWTH OF STAPHYLOCOCCUS AUREUS IN MILK AND SOME OTHER FOOD PRODUCTS

The effect of lysostaphin from Staphylococcus simulans expressed in Escherichia coli TOP10 strain on Staphylococcus aureus used for inoculation of milk, ground pork and mayonnaise salad was investigated. The populations of this pathogen in ultrahigh‐temperature milk preserved at 4C by lysostaphin added up to concentrations of 1.5 or 3.0 µg/mL were reduced by 0.73 and 0.92 log(cfu/mL) in control samples without enzyme addition. The protective influence of lysostaphin was diminished in case of milk storage (20C) prolonged up to 24 h. Furthermore, a final reduction level by 0.92 log(cfu/mL) was achieved after 24 h of pork storage. The smaller and more dependent on enzyme concentration inactivation of S. aureus was observed in the case of the mayonnaise salad, and it led to the conclusion that some food components or proteolytic enzymes originating from other bacteria caused lysostaphin inactivation.     

Behavior of Shiga-toxin-producing Escherichia coli in ewe milk stored at different temperatures and during the manufacture and ripening of a raw milk sheep cheese (Zamorano style)

This study was conducted to assess the survival of 2 wild Shiga toxin-producing Escherichia coli strains (one serotype O157:H7 and one non-O157:H7) in ewe milk stored at different conditions and to examine the fate of the O157 strain during the manufacture and ripening of a Spanish sheep hard variety of raw milk cheese (Zamorano). The strains were selected among a population of 50 isolates, which we obtained from ewe milk, because of their high resistance to 0.3% lactic acid. Both strains were inoculated (approximately 2 log₁₀ cfu/mL) in raw and heat-treated (low-temperature holding, LTH; 63°C/30 min) ewe milk and stored for 5 d at 6, 8, and 10°C and also according to a simulation approach for assessing the effects of failures in the cold chain. The minimum growth temperature for the O157:H7 strain in LTH and raw ewe milk was 8°C. For the non-O157:H7 strain, the lowest temperature showing bacterial growth in LTH ewe milk was 6°C, but it did not grow at any of the tested conditions in raw milk. It appears that the O157 strain was more susceptible to cold stress but was likely a better competitor than the non-O157 strain against the milk autochthonous microbiota. For manufacture of Zamorano cheese, raw milk was inoculated with approximately 3 log₁₀ cfu/mL, and after 2 mo of ripening at 10 to 12°C, the cheeses showed the expected general characteristics for this variety. The O157:H7 strain increased 0.9 log₁₀ cfu/g after whey drainage and during ripening and storage decreased by 2.9 log₁₀ cfu/g. Nevertheless, its detectable level (estimated at 6.2 cfu/g) after 2 mo of ripening suggests that Zamorano cheese manufactured from raw ewe milk contaminated with E. coli O157:H7 could represent a public health concern.     

Psychrotolerant spore-former growth characterization for the development of a dairy spoilage predictive model

Psychrotolerant spore-forming bacteria represent a major challenge regarding microbial spoilage of fluid milk. These organisms can survive most conventional pasteurization regimens and subsequently germinate and grow to spoilage levels during refrigerated storage. To improve predictions of fluid milk shelf life and assess different approaches to control psychrotolerant spore-forming bacteria in the fluid milk production and processing continuum, we developed a predictive model of spoilage of fluid milk due to germination and growth of psychrotolerant spore-forming bacteria. We characterized 14 psychrotolerant spore-formers, representing the most common Bacillales subtypes isolated from raw and pasteurized milk, for ability to germinate from spores and grow in skim milk broth at 6°C. Complete growth curves were obtained by determining total bacterial count and spore count every 24 h for 30 d. Based on growth curves at 6°C, probability distributions of initial spore counts in bulk tank raw milk, and subtype frequency in bulk tank raw milk, a Monte Carlo simulation model was created to predict spoilage patterns in high temperature, short time-pasteurized fluid milk. Monte Carlo simulations predicted that 66% of half-gallons (1,900 mL) of high temperature, short time fluid milk would reach a cell density greater than 20,000 cfu/mL after 21 d of storage at 6°C, consistent with current spoilage patterns observed in commercial products. Our model also predicted that an intervention that reduces initial spore loads by 2.2 Log₁₀ most probable number/mL (e.g., microfiltration) can extend fluid milk shelf life by 4 d (end of shelf life was defined here as the first day when the mean total bacterial count exceeded 20,000 cfu/mL). This study not only provides a baseline understanding of the growth rates of psychrotolerant spore-formers in fluid milk, it also provides a stochastic model of spoilage by these organisms over the shelf life of fluid milk, which will ultimately allow for the assessment of different approaches to reduce fluid milk spoilage.     

Shelf-life storage temperature has a considerably larger effect than high-temperature,short-time pasteurization temperature on the growth of spore-forming bacteria in fluid milk

In the absence of postpasteurization contamination, psychrotolerant, aerobic spore-forming bacteria that survive high-temperature, short-time (HTST) pasteurization, limit the ability to achieve HTST extended shelf-life milk. Therefore, the goal of the current study was to evaluate bacterial outgrowth in milk pasteurized at different temperatures (75, 85, or 90°C, each for 20 s) and subsequently stored at 3, 6.5, or 10°C. An initial ANOVA of bacterial concentrations over 14 d of storage revealed a highly significant effect of storage temperatures, but no significant effect of HTST. At d 14, average bacterial counts for milk stored at 3, 6.5, and 10°C were 1.82, 3.55, and 6.86 log₁₀ cfu/mL, respectively. Time to reach 1,000,000 cfu/mL (a bacterial concentration where consumers begin to notice microbially induced sensory defects in fluid milk) was estimated to be 68, 27, and 10 d for milk stored at 3, 6.5, and 10°C, respectively. Out of 95 isolates characterized with rpoB allelic typing, 6 unique genera, 15 unique species, and 44 unique rpoB allelic types were represented. The most common genera identified were Paenibacillus, Bacillus, and Lysinibacillus. Nonmetric multidimensional scaling identified that Bacillus was significantly associated with 3 and 10°C, whereas Paenibacillus was consistently found across all storage temperatures. Overall, our data show that storage temperature has a substantially larger effect on fluid milk shelf life than HTST and suggests that abuse temperatures (e.g., storage at 10°C) allow for growth of Bacillus species (including Bacillus cereus genomospecies) that do not grow at lower temperatures. This indicates that stringent control of storage and distribution temperatures is critical for producing extended shelf-life HTST milk, particularly concerning new distribution pathways for HTST pasteurized milk (e.g., electronic commerce), and when enhanced control of spores in raw milk is not feasible.     

Dry matter and nutritional losses during aerobic deterioration of corn and sorghum silages as influenced by different lactic acid bacteria inocula

The economic damage that results from aerobic deterioration of silage is a significant problem for farm profitability and feed quality. This paper quantifies the dry matter (DM) and nutritional losses that occur during the exposure of corn and sorghum silages to air over 14 d and assesses the possibility of enhancing the aerobic stability of silages through inoculation with lactic acid bacteria (LAB). The trial was carried out in Northern Italy on corn (50% milk line) and grain sorghum (early dough stage) silages. The crops were ensiled in 30-L jars, without a LAB inoculant (C), with a Lactobacillus plantarum inoculum (LP), and with a Lactobacillus buchneri inoculum (LB; theoretical rate of 1 × 10⁶ cfu/g of fresh forage). The pre-ensiled material, the silage at silo opening, and the aerobically exposed silage were analyzed for DM content, fermentative profiles, yeast and mold count, starch, crude protein, ash, fiber components, 24-h and 48-h DM digestibility and neutral detergent fiber (NDF) degradability. The yield and nutrient analysis data of the corn and sorghum silages were used as input for Milk2006 to estimate the total digestible nutrients, net energy of lactation, and milk production per Mg of DM. The DM fermentation and respiration losses were also calculated. The inocula influenced the in vitro NDF digestibility at 24 h, the net energy for lactation (NE_L), and the predicted milk yield per megagram of DM, whereas the length of time of air exposure influenced DM digestibility at 24 and 48 h, the NE_L, and the predicted milk yield per megagram of DM in the corn silages. The inocula only influenced the milk yield per megagram of DM and the air exposure affected the DM digestibility at 24 h, the NE_L, and the milk yield per megagram of DM in the sorghum silages. The milk yield, after 14 d of air exposure, decreased to 1,442, 1,418, and 1,277 kg/Mg of DM for C, LB, and LP corn silages, respectively, compared with an average value of 1,568 kg of silage at opening. In the sorghum silages, the milk yield, after 14 d of air exposure, decreased to 1,226, 1,278, and 1,250 kg/Mg of DM for C, LB, and LP, respectively. When the estimated milk yield per megagram of harvested DM of corn and sorghum silage were related to mold count, it was shown that the loss of potential milk production occurred when the mold count exceeded 4 log cfu/g of silage, and it was almost halved when the mold count reached values greater than 8 log cfu/g of silage. Inoculation with L. buchneri, at a rate of 1 × 10⁶ cfu/g of fresh forage, enhanced the stability of the silage after exposure to air, and, consequently, contributed to maintaining the nutritional value of the harvested forage over time, for air exposure up to 7 d.     

Investigate the efficacy of UV pretreatment on thermal inactivation of Bacillus subtilis spores in different types of milk

Shortwave ultraviolet (UVC) radiation is commonly used for sterilization of drinking water. However, its low transmittance within opaque liquids limits its use for milk and other liquid food products. The objective of this study was to assess the efficacy of UV pretreatment on thermal inactivation of B. subtilis spores in skim cow milk, whole cow milk and whole sheep milk. In this work, UV treatment was applied by using a coiled tube UV unit with a perfluoroalkoxy tube around a quartz sleeve containing a 254-nm UV lamp. It was observed that UV pretreatment (D _Act 2.37 ± 0.126 J/ml) combined with thermal treatment at 110 °C for 30 s resulted in a reduction of approximately 6 log CFU/mL in bovine skim milk, 2.90 log CFU/ml in whole bovine milk and 1.1 log CFU/ml in ovine milk. The results showed that UV in combination with heat can possibly be an alternative to sterilization of skim milk at lower temperatures compared to ultra high temperature (UHT) treatment (135 °C, 3 s).     

Raw milk from vending machines: Effects of boiling,microwave treatment,and refrigeration on microbiological quality

In Italy, the sale of raw milk from vending machines has been allowed since 2004. Boiling treatment before its use is mandatory for the consumer, because the raw milk could be an important source of foodborne pathogens. This study fits into this context with the aim to evaluate the microbiological quality of 30 raw milk samples periodically collected (March 2013 to July 2013) from 3 vending machines located in Molise, a region of southern Italy. Milk samples were stored for 72 h at 4°C and then subjected to different treatments, such as boiling and microwaving, to simulate domestic handling. The results show that all the raw milk samples examined immediately after their collection were affected by high microbial loads, with values very close to or even greater than those acceptable by Italian law. The microbial populations increased during refrigeration, reaching after 72 h values of about 8.0 log cfu/mL for Pseudomonas spp., 6.5 log cfu/mL for yeasts, and up to 4.0 log cfu/mL for Enterobacteriaceae. Boiling treatment, applied after 72 h to refrigerated milk samples, caused complete decontamination, but negatively affected the nutritional quality of the milk, as demonstrated by a drastic reduction of whey proteins. The microwave treatment at 900 W for 75 s produced microbiological decontamination similar to that of boiling, preserving the content in whey proteins of milk. The microbiological characteristics of raw milk observed in this study fully justify the obligation to boil the raw milk from vending machines before consumption. However, this study also showed that domestic boiling causes a drastic reduction in the nutritional value of milk. Microwave treatment could represent a good alternative to boiling, on the condition that the process variables are standardized for safe domestic application.     

The effect of different precooling rates and cold storage on milk microbiological quality and composition

The objective of this study was to measure the effect of different milk cooling rates, before entering the bulk tank, on the microbiological load and composition of the milk, as well as on energy usage. Three milk precooling treatments were applied before milk entered 3 identical bulk milk tanks: no plate cooler (NP), single-stage plate cooler (SP), and double-stage plate cooler (DP). These precooling treatments cooled the milk to 32.0 ± 1.4°C, 17.0 ± 2.8°C, and 6.0 ± 1.1°C, respectively. Milk was added to the bulk tank twice daily for 72 h, and the tank refrigeration temperature was set at 3°C. The blend temperature within each bulk tank was reduced after each milking event as the volume of milk at 3°C increased simultaneously. The bacterial counts of the milk volumes precooled at different rates did not differ significantly at 0 h of storage or at 24-h intervals thereafter. After 72 h of storage, the total bacterial count of the NP milk was 3.90 ± 0.09 log₁₀ cfu/mL, whereas that of the precooled milk volumes were 3.77 ± 0.09 (SP) and 3.71 ± 0.09 (DP) log₁₀ cfu/mL. The constant storage temperature (3°C) over 72 h helped to reduce bacterial growth rates in milk; consequently, milk composition was not affected and minimal, if any, proteolysis occurred. The DP treatment had the highest energy consumption (17.6 ± 0.5 Wh/L), followed by the NP (16.8 ± 2.7 Wh/L) and SP (10.6 ± 1.3 Wh/L) treatments. This study suggests that bacterial count and composition of milk are minimally affected when milk is stored at 3°C for 72 h, regardless of whether the milk is precooled; however, milk entering the tank should have good initial microbiological quality. Considering the numerical differences between bacterial counts, however, the use of the SP or DP precooling systems is recommended to maintain low levels of bacterial counts and reduce energy consumption.