Synthesis and Properties of Quaternary Ammonium Surfactants Based on Alkylamine,Propylene Oxide,and 2‐Chloroethanol

New quaternary ammonium salts are synthesized by octylamine, nonylamine, dodecylamine, and hexadecylamine reacting with propylene oxide at a mole ratio of 1:2, followed by reaction with 2‐chloroethanol. By tensiometric measurements of aqueous solutions, their surface activity has been determined. Using the results of these measurements and electroconductometric studies, important parameters such as critical micelle concentration (CMC), efficiency of surfactant adsorption, surface pressure at the CMC, changes of Gibbs free energies for micelle formation, and adsorption were estimated. By application of the Gibbs adsorption isotherm, indices such as maximum surface excess concentration and minimum surface area/molecule at the air–water interface were also calculated. Petroleum‐collecting properties of these surfactants were investigated. Among these quaternary ammonium surfactants, the surfactant based on dodecylamine, propylene oxide, and 2‐chloroethanol exhibits the highest petroleum‐collecting capacity.     

Synthesis and Evaluation of Nonionic Surfactants Derived from Tannic Acid as Corrosion Inhibitors for Carbon Steel in Acidic Medium

Nonionic Schiff base surfactants were synthesized by chemical modification of tannic acid. The surface activities of the synthesized surfactants were determined using surface tension, interfacial tension, and emulsification properties. Thermodynamic parameters of adsorption and micellization of these surfactants showed their tendency towards the two processes with greater predominance of adsorption over micellization. Electrochemical polarization and impedance measurements showed that the surfactants exhibited good tendency towards inhibiting the dissolution of carbon steel in acidic medium. The inhibition efficiencies depend on the chemical structure and concentration of the compounds.     

Synthesis and Physico-Chemical Studies of Ester-Quat Surfactants in the Series of (Dodecanoyloxy)propyl n-Alkyl Dimethyl Ammonium Bromide

Ester-quat surfactants in the series of (dodecanoyl oxy) propyl n-alkyl dimethyl ammonium bromide referred to here as LC₃Cm (where m is the hydrocarbon chain lengths 8, 12 and 14) were synthesized and characterized by the usual spectroscopic methods (NMR, IR, MS…). Their physico-chemical properties were investigated by surface tension and conductimetric measurements. From surface tension measurements, isotherms and thermodynamic adsorption parameters were determined. The critical micelle concentration (CMC), the degree of counter ion dissociation (α) of micelles in the water and the standard Gibbs free energy $( \Updelta G_{\text{m}}^{0}) $ , of micellization were also determined by conductimetric measurements. The results obtained from both methods were compared to the similar surfactants in the series of quaternary ammonium surfactants. Optical microscopy was also used to study the behavior of anhydrous surfactants and the binary water/surfactant system as a function of temperature.     

Surface and Biocidal Properties of Gemini Cationic Surfactants Based on Propoxylated 1,6-Diaminohexane and Alkyl Bromides

Two new classes of gemini cationic surfactants—hexanediyl-1,6-bis[(isopropylol) alkylammonium] dibromide {in the abbreviation form: C_nC₆C_n[iPr-OH] and C_nC₆C_n[iPr-OH]₂; alkyl: C_nH_{2n + 1} with n = 9, 10, 12 and 14}—have been synthesized by interaction of alkyl bromides with N,N′-di-(isopropylol)-1,6-diaminohexane and N,N,N′,N′-tetra-(isopropylol)-1,6-diaminohexane. The surface tension, electrical conductivity, and dynamic light scattering (DLS) techniques were used to investigate the aggregation properties of the gemini cationic surfactants in aqueous solution. The formation of critical aggregates at two concentrations in an aqueous solution from obtained gemini cationic surfactants were determined via the tensiometric method. Thus, these gemini cationic surfactants start to form aggregates at concentrations well below their critical micelle concentrations (CMC). The surface properties and the binding degree (β) of the opposite ion were tested against the length of the surfactant hydrocarbon chain and the number of the isopropylol groups in the head group. By applying the DLS technique, it was explored that how the number of isopropylol groups in gemini cationic surfactants with C₁₂H₂₅ chain affects the sizes of micelles at concentrations greater than CMC. It was discovered that the obtained gemini cationic surfactants have a biocidal character.     

Synthesis,Micellization, and Surface Activity of Novel Linear-Dendritic Carboxylate Surfactants

Two generations of novel linear-dendritic carboxylate surfactants C₁₈-G₁-(COONa)₂ and C₁₈-G₂-(COONa)₄ have been synthesized by the divergent method and their structures are characterized by ¹H Nuclear Magnetic Resonance and Infrared analysis. The electrical conductivity measurement is used to measure the Krafft temperatures of C₁₈-G₁-(COONa)₂ and C₁₈-G₂-(COONa)₄, which are much smaller than those of the corresponding conventional surfactant sodium stearate. The markedly enhanced solubility of two linear-dendritic surfactants is ascribed to the high hydrophilicity of surfactant headgroups induced by the carboxylate and ester groups. The critical micelle concentration (CMC) values obtained from both the electrical conductivity and surface tension measurements indicate that the micellizations of linear-dendritic surfactants become favorable with the increase in the number of the surfactant headgroup. However, the surface activity parameters including the surface tension at the CMC, maximum surface excess, and minimum surface area reveal that C₁₈-G₁-(COONa)₂ exhibits greater efficiency in absorbing at the air/water interface compared to C₁₈-G₂-(COONa)₄, owing to their different steric repulsions of the surfactant headgroups. In addition, C₁₈-G₁-(COONa)₂ and C₁₈-G₂-(COONa)₄ have higher emulsifying ability than the conventional surfactants sodium stearate and sodium octadecyl sulfate.     

Retracted: Synthesis,Characterization, and Surface Activities of Polymeric Cationic Thiol Surfactants in Aqueous Medium

A series of cationic polyurethane surfactants [PQ_8-18] were synthesized by the reaction of alkyl bromoacetate (namely: octyl-, decyl-, dodecyl-, tetradecyl-, hexadecyl-, and octadecyl bromoacetate) as quaternizing agents and modified polyurethane contains tertiary amine species. Modified polyurethane was prepared by the reaction of toluene diisocyanate (TDI) and triethanol amine monomercaptoacetate. The chemical structures of the prepared surfactants were confirmed using elemental analysis, Fourier transform infrared spectroscopy (FTIR), and Proton nuclear magnetic resonance (¹H NMR) spectroscopy. The molecular weight measurements of the prepared polymers showed that the segments of each polymer contain average 10 units of the urethane-triethanol amine mercaptoacetate. The surface activities of the prepared surfactants including: surface tension (γ), effectiveness ( π_cmc), concentration at micelle formation (CMC), efficiency (Pc₂₀), maximum concentration at the interface (Γ_max), and the average area occupied by each surfactant molecule at the interface at equilibrium ( A _min) of surfactants solutions were established at 25°C. The surface tension and the critical micelle concentration values of the prepared surfactants were gradually decreased by the gradual increase of their alkyl chain length. The prepared cationic surfactants showed efficient activity as inhibitors for dissolution of carbon steel in an acidic medium and also as a biocide against the growth of bacteria, fungi, and yeast.     

Synthesis,Characterization, Surface and Biological Activity of Diquaternary Cationic Surfactants Containing Ester Linkage

Two series of diquaternary cationic surfactants designated as E9Nm and E11Nm having two different alkyl chains in their chemical structure were synthesized. The chemical structures of these surfactants were confirmed using elemental analysis, FTIR and ¹H‐NMR spectra. The surface activities of the different surfactants were determined using surface and interfacial tension at 25 °C. The surface parameters including: critical micelle concentration, effectiveness, efficiency, maximum surface excess and minimum surface area were determined. The surface activities of the cationic surfactants were correlated with their chemical structure. The surface activities of the surfactants increased with increasing the hydrophobic chain length. The adsorption and micellization tendencies of the surfactants in solution were determined using the free energies of adsorption and micellization. The synthesized surfactants were evaluated as biocides against bacteria and fungi. Biocidal activity data showed that a gradual increase in the hydrophobic chain length of the surfactant molecules gradually increases the efficiency of these surfactants as biocides.     

Adsorption of Novel Alkylaminoamide Sugar Surfactants at Tailor-made Surfaces

N,N-di(3-aminopropyl)dodecylamine (C12-Y-amine), N-dodecyl-N,N-di[(3-d-gluconylamido)propyl]amine (C12-DGA), N-dodecyl-N,N-bis[(3-lactobionylamido)propyl]amine (C12-DLA), N-dodecyl-N-[(3-lactobionylamido)propyl]amine (C12-LA), and ethoxylated N,N-di(3-aminopropyl)dodecylamine [C12-Y-amine with 4 and 8 ethylene oxide (EO)] have been synthesized, and their physical-chemical properties have been studied. Adsorption was measured at the air–water interface by the du Noüy ring method and at solid surfaces consisting of self-assembled monolayers (SAMs) of alkanethiols on gold using surface plasmon resonance. Results from surface tension measurements showed that adsorption at the air–water interface is pH dependent. At low pH, reduction in surface tension is less pronounced as a result of protonation of the amino groups of the surfactants. At the SAM model surfaces, generated by adsorption of alkanethiols or mixtures of alkanethiols on gold presenting methyl, hydroxyl, and carboxyl groups, the highest amount of adsorbed surfactant was obtained on a surface composed of a mixture of methyl and carboxyl groups. In general, the sugar-derived surfactants, DGA, DLA, and LA, adsorbed less than the ethoxylates. Surfactant biodegradation was investigated by the closed bottle test. Only C12-Y-amine was found to be readily biodegradable. However, the polyol surfactants were more biodegradable than the ethoxylates.

Synthesis,Characterization and Surface Activities of Cationic Polysaccharide (Aloe) Schiff Base Surfactants

Synthesis of cationic polysaccharide (Aloe) Schiff base surfactants was described and their chemical structures were confirmed by using FTIR spectroscopic, H‐NMR and UV analysis. The surface activities of these surfactants were measured, including surface tension, critical micelle concentration, effectiveness, efficiency, maximum surface excess and minimum surface area at 25 °C, interfacial tension and emulsification power at 25 °C. Adsorption and micellization free energies of these amphiphiles in their solutions showed a good tendency towards adsorption at the interfaces.     

Synthesis and Physico-Chemical Properties of Sodium 3-Oxo-2-(3-(4-sulphonatophenyl)triaz-2-enyl)octadecanoate Anionic Surfactant

The novel anionic surfactant sodium 3‐oxo‐2‐(3‐(4‐sulphonatophenyl)triaz‐2‐enyl)octadecanoate (SSTO) was prepared from renewable raw materials; glycine and palmitic acid. Surface and bulk properties of SSTO were investigated by surface tension and electrical conductivity techniques at 298, 308, 318 and 328 K. Surface properties including critical micelle concentration (CMC), maximum surface excess concentration (Γ_max), minimum area per molecule (A_min), surface tension at CMC (γ_CMC), effectiveness of surface tension reduction (Π_CMC), efficiency of surface adsorption (pC₂₀), and degree of counterion dissociation (α) were determined. The thermodynamic parameters of micellization (ΔG°_mic, ΔH°_mic and ΔS°_mic) and adsorption (ΔG°_ad, ΔH°_ad and ΔS°_ad) were also investigated at 298, 308, 318 and 328 K. The effect of 3 wt% n‐propanol, n‐butanol and n‐pentanol on surface tension and conductivity at 298 K was also determined.     

Adsorption and Aggregation Activity of Sodium Dodecyl Sulfate and Rhamnolipid Mixture

Measurements of the surface tension, density and viscosity of sodium dodecyl sulfate (SDS) and rhamnolipid (RL) mixtures were carried out in aqueous solution. From the obtained results, composition of mixed surface layer at the water–air interface, mixed micelles, parameter of intermolecular interactions, activity of SDS and RL in the surface layer and micelles, Gibbs standard free energy of adsorption and micellization as well as Gibbs free energy of SDS and RL mixing in the surface layer and micelles were established. These parameters were discussed in the light of independent adsorption of SDS and RL and the size of their molecules as well as the area in contact with water molecules. A correlation between the number of water molecules in contact with those of SDS and RL and standard free energy of adsorption as well as micellization of these surfactants was observed. A correlation between the apparent and partial molar volumes of RL and SDS in their mixture and size of surfactant molecules as well as the average distance between molecules was also found. The parameter of intermolecular interactions indicates that there is a synergetic effect in the reduction of water surface tension and micelle formation.     

Synthesis,Surface Activities and Toluene Solubilization by Amine-oxide Gemini Surfactants

A series of amine-oxide gemini surfactants featuring amide groups [N, N’-dimethyl-N, N’-bis(2-alkylamideethyl)-ethylenediamine oxide (alkyl = C₁₁H₂₃, C₁₃H₂₇, C₁₅H₃₁, C₁₇H₃₅)] have been synthesized via a three-step synthetic route, and their chemical structures were confirmed by mass spectra, FTIR and ¹H-NMR spectra. The surface activities of these compounds have been measured. The results show that these synthesized amine-oxide gemini surfactants reduced the surface tension of water to a minimum value of approximately 26.91 mN m^?1 at a concentration of 2.92 × 10^?5mol L^?1. Furthermore, their critical micelle concentration (CMC) values and solubilization of toluene decrease with an increase of the hydrophobic chain length from 12 to 18. Isoelectric point measurements revealed that their pI values range from 4.0 to 10.5.     

Synthesis and Surface Activities of Novel Succinic Acid Double-Tailed Sulfonate Fluorinated Surfactants

In this study, four environmentally friendly succinic acid double-tailed sulfonate fluorinated surfactants were synthesized from maleic anhydride, fluoroalkyl alcohols, namely 1-(1H,1H,7H-Dodecafluoroheptyloxy) ethanol, 1-(1H,1H,5H -octafluoropentyloxy) ethanol, 1-(1H,1H,3H-tetrafluoropropoxy) ethanol, and 1-(1H,1H -trifluoroethyoxy) ethanol, and sodium hydrogensulfite. The surfactant structure was characterized by FT-IR, ¹H NMR, and ¹⁹F NMR . Thermogravimetric results showed that the fluorinated surfactants were stable up to relatively high temperature. The Krafft points of the four novel succinic acid double-tailed sulfonate fluorinated surfactants were all below 0 °C. The lowest CMC value for the synthesized four double-tailed fluorine surfactants is about 0.076 mmol L^?1, far less than that of ammonium perfluorooctanoate (PFOA), demonstrating that double-tailed surfactants have higher surface activity than surfactants with one fluoroalkyl chain. The replacement of alkyl groups with oxyethylene groups enhances the hydrophilicity of the obtained fluorinated surfactants. Based on these findings, the synthesized surfactants may be environmentally friendly alternatives to PFOA and exhibit promising potential in industry applications.     

十八烷基己基甲基羧基甜菜碱的合成及性能

以硬脂酸和己酸为原料合成了不对称双长链烷基羧基甜菜碱——十八烷基己基甲基羧基甜菜碱(C18+6B),测定了C18+6B的表面活性,并与总碳原子数相等的对称型双十二烷基甲基羧基甜菜碱(di C12B)进行比较,以了解表面活性剂分子结构对性能的影响。结果表明,C18+6B的表面活性与di C12B基本相当,但水溶性远好于di C12B。作为无碱驱油用表面活性剂,C18+6B对大庆原油来说HLB值略偏高,45℃下单独使用能将大庆原油/地层水界面张力降至10-2m N/m数量级,在大庆油砂上的饱和吸附量比di C12B低30%。C18+6B单独能将C7~C9正构烷烃/大庆地层水界面张力降至10-3m N/m数量级,而通过与亲油性更强的di C12B以及亲水性甜菜碱复配后,能将大庆原油/地层水界面张力降至10-3m N/m数量级,并能显著改善配方的水溶性。     

十八烷基己基甲基羧基甜菜碱的合成及性能

以硬脂酸和己酸为原料合成了不对称双长链烷基羧基甜菜碱——十八烷基己基甲基羧基甜菜碱(C18+6B),测定了C18+6B的表面活性,并与总碳原子数相等的对称型双十二烷基甲基羧基甜菜碱(diC12B)进行比较,以了解表面活性剂分子结构对性能的影响。结果表明,C18+6B的表面活性与diC12B基本相当,但水溶性远好于diC12B。作为无碱驱油用表面活性剂,C18+6B对大庆原油来说HLB值略偏高,45 ℃ 下单独使用能将大庆原油/地层水界面张力降至10-2mN/m数量级,在大庆油砂上的饱和吸附量比diC12B低30%。C18+6B单独能将C7~C9正构烷烃/大庆地层水界面张力降至10-3mN/m数量级,而通过与亲油性更强的diC12B以及亲水性甜菜碱复配后,能将大庆原油/地层水界面张力降至10-3mN/m数量级,并能显著改善配方的水溶性。     

Synthesis,Surface Properties and Effect of an Amino Acid Head Group of 11-(2-Methoxy-4-vinylphenoxy)undecanoicacid-Based Anionic Surfactants

Our present research describes the surface properties of three biobased anionic surfactant synthesized from vinylguaiacol and 11-bromo undecanoic acid. To further improve its hydrophobicity and bioavailability, amino acid head group incorporation was carried out. All these synthesized compounds were thoroughly characterized using NMR and mass spectroscopy. The performance properties such as foaming, wetting, emulsification value and calcium tolerance were evaluated. The studied surfactants possess excellent emulsion stability and moderate calcium tolerance as compared to commercially available surfactant sodium lauryl sulfate (SLS). The micelle formation and the thermodynamics involved at the air–water interface were estimated from surface tension measurements. These surfactants showed a higher tendency towards adsorption at the air–water interface than micellization. Dynamic light scattering and steady state fluorescence anisotropy study were carried out to shed light on the bulk micellization properties of the synthesized surfactant. Along with spherical micelles of <5 nm size, larger aggregates (35–84 nm) were observed with higher anisotropy values. FESEM images further confirmed the larger spherical micelles formed by these surfactants. The surfactants formed chiral aggregates above the critical micelle concentration as indicated by circular dichroism spectra. These surfactants may be suitable candidates for additives to detergents to improve their calcium tolerance especially in the case of hard water. Furthermore, a low foaming ability along with high emulsion stability may find these surfactants to be better replacement of the conventional surfactant used as emulsifiers in many industrial applications.     

Micellization and Adsorption Behaviors of New Reactive Polymerizable Surfactants Based on Modified Nonyl Phenol Ethoxylates

The synthesis and characterization of a series of polymerizable surfactants based on alkyl phenol ethoxylate backbone and carboxylic or anhydride chain ends were investigated. Surface activities of these polymerizable surfactants were investigated to correlate their structure and their performances. The new bifunctional surfmers were prepared by reacting polyoxyethylene 4-nonyl-2-propylene-phenol nonionic reactive surfactants with maleic anhydride. The chemical structure of the prepared surfactants was characterized by ¹³C and ¹H NMR analyses. The surface activities of the modified polymerizable surfactants were measured from the adsorption isotherm measurements which were determined from the relationship between the concentrations and surface tension of surfactants in aqueous medium at different temperatures. Critical micelle concentration (CMC) values were determined for water soluble surfactants. It was found that CMC decreases with the incorporation of the anhydride and acid groups in the chemical structure of polyoxyethylene 4-nonyl -2-propylene-phenol nonionic surfactant. surface-active parameters such as area per molecule at the interface (A _min), surface excess concentration (Γ_max) and the effectiveness of surface tension reduction (π_CMC) were measured from the adsorption isotherms of the modified surfactants. Some thermodynamic data for the adsorption process were calculated and discussed. The data indicated that the new surfmers are more reactive than the simple polyoxyethylene 4-nonyl-2-propylene-phenol and more adsorbed at interfaces. We have performed a preliminary experiment to explore the emulsification efficiency of the newly synthesized reactive surfactants in equal volume oil–water emulsions. Different emulsion types and stabilities were obtained.     

Synthesis and the Structure to Property Relationship of Monoperfluoroalkyl Polyethylene Glycol

Monoprotected polyethylene glycols (PEG) react with epichlorohydrin to furnish PEGylated epoxides. The latter were converted into the corresponding α-(2-F-alkylethyl)thiomethyl polyethylene glycols by treatment with 2-F-alkylethanethiol. Surface activity of the obtained surfactants was investigated by evaluation of PEG and perfluoroalkyl chains length on the critical micelle concentration (CMC), surface and interfacial tensions.     

Thermodynamic Properties of Sulfobetaine-Type Surfactants

Sulfobetaine-type surfactants containing a hydroxy group were synthesized by the reaction of long chain monoalkyl dimethyl tertiary amine with 3-chloro-2-hydroxypropanesulfonic acid sodium salt. The structures were characterized by ¹H NMR and ESI-MS. Their critical micelle concentrations (CMC) in aqueous solution were determined by the plate method in the temperature rang from 298.15 to 328.15 K. The thermodynamic parameters of micellization ( $\Delta G_{\text{mic}}^{\theta}$ , $\Delta H_{\text{mic}}^{\theta}$ and $\Delta S_{\text{mic}}^{\theta}$ ) and surface adsorption ( $\Delta G_{\text{ad}}^{\theta}$ , $\Delta H_{\text{ad}}^{\theta}$ and $\Delta S_{\text{ad}}^{\theta}$ ) were calculated from CMC data. The results showed that the micellization and surface adsorption of these surfactants in aqueous solution was a spontaneous and entropy-driven process. The micellization and surface adsorption became easier when the alkyl chain length increased from 12 carbon atoms to 14. The enthalpy–entropy compensation of micellization and adsorption was investigated. The compensation temperature were found to be (311 ± 2) K for both micellization and adsorption. The $\Delta H_{\text{mic}}^{*}$ and $\Delta H_{\text{ad}}^{*}$ decreased, but the $\Delta S_{\text{mic}}^{*}$ and $\Delta S_{\text{ad}}^{*}$ increased with increasing the hydrophobic chain length from 12 to 14.