Aero‐Engine DCS Fault‐Tolerant Control with Markov Time Delay Based On Augmented Adaptive Sliding Mode Observer

With a focus on aero‐engine distributed control systems (DCSs) with Markov time delay, unknown input disturbance, and sensor and actuator simultaneous faults, a combined fault tolerant algorithm based on the adaptive sliding mode observer is studied. First, an uncertain augmented model of distributed control system is established under the condition of simultaneous sensor and actuator faults, which also considers the influence of the output disturbances. Second, an augmented adaptive sliding mode observer is designed and the linear matrix inequality (LMI) form stability condition of the combined closed‐loop system is deduced. Third, a robust sliding mode fault tolerant controller is designed based on fault estimation of the sliding mode observer, where the theory of predictive control is adopted to suppress the influence of random time delay on system stability. Simulation results indicate that the proposed sliding mode fault tolerant controller can be very effective despite the existence of faults and output disturbances, and is suitable for the simultaneous sensor and actuator faults condition.     

带有执行器故障的多水面船固定时间分布式滑模协同控制

针对未知环境干扰、未知执行器故障等多水面船协同控制问题,提出一种带有执行器故障的多水面船固定时间分布式滑模协同控制方法,可保证协同控制系统的全局固定时间的稳定性.首先,设计一种固定时间干扰观测器,用于估计集总扰动(包括未知环境扰动和未知执行器故障);其次,引入固定时间非奇异快速终端滑模面,可有效地消除系统的奇异性,改善系统的抖振;然后,提出一种基于固定时间非奇异快速终端滑模面和固定时间干扰观测器的分布式容错控制器,使得收敛时间上界与系统初始状态无关;最后,通过仿真实验验证所提出控制律的有效性.     

Robust Fault‐Tolerant Control of Launch Vehicle Via GPI Observer and Integral Sliding Mode Control

A robust fault‐tolerant attitude control scheme is proposed for a launch vehicle (LV) in the presence of unknown external disturbances, mismodeling dynamics, actuator faults, and actuator's constraints. The input‐output representation is employed to describe the rotational dynamics of LV rendering three independently decoupled second order single‐input‐single‐output (SISO) systems. In the differential algebraic framework, general proportional integral (GPI) observers are used for the estimations of the states and of the generalized disturbances, which include internal perturbations, external disturbances, and unknown actuator failures. In order to avoid the defects of the conventional sliding surface, a new nonlinear integral sliding manifold is introduced for the robust fault‐tolerant sliding mode controller design. The stability of the GPI observer and that of the closed‐loop system are guaranteed by Lyapunov's indirect and direct methods, respectively. The convincing numerical simulation results demonstrate the proposed control scheme is with high attitude tracking performance in the presence of various disturbances, actuator faults, and actuator constraints.     

Distributed fault‐tolerant control design for spacecraft finite‐time attitude synchronization

This paper develops two distributed finite‐time fault‐tolerant control algorithms for attitude synchronization of multiple spacecraft with a dynamic virtual leader in the presence of modeling uncertainties, external disturbances, and actuator faults. The leader gives commands only to a subset of the followers, and the communication flow between followers is directed. By employing a novel distributed nonsingular fast terminal sliding mode and adaptive mechanism, a distributed finite‐time fault‐tolerant control law is proposed to guarantee all the follower spacecraft that finite‐time track a dynamic virtual leader. Then utilizing three distributed finite‐time sliding mode estimators, an estimator‐based distributed finite‐time fault‐tolerant control law is proposed using only the followers' estimates of the virtual leader. Both of them do not require online identification of the actuator faults and provide robustness, finite‐time convergence, fault‐tolerant, disturbance rejection, and high control precision. Finally, numerical simulations are presented to evaluate the theoretical results. Copyright © 2015 John Wiley & Sons, Ltd.     

Finite‐Time Fault‐Tolerant Control for a Class of Non‐Affine Nonlinear System Using Sliding Mode Disturbance Observer

This study investigates a finite‐time fault‐tolerant control scheme for a class of non‐affine nonlinear system with actuator faults and unknown disturbances. A global approximation method is applied to non‐affine nonlinear system to convert it into an affine‐like expression with accuracy. An adaptive terminal sliding mode disturbance observer is proposed to estimate unknown compound disturbances in finite time, including external disturbances and system uncertainties, which enhances system robustness. Controllers based on finite‐time Lyapunov theory are designed to force tracking errors to zero in finite time. Simulation results demonstrate the effectiveness of proposed method.     

Adaptive type-2 fuzzy sliding mode controller for SISO nonlinear systems subject to actuator faults

In this paper, an adaptive type-2 fuzzy sliding mode control to tolerate actuator faults of unknown nonlinear systems with external disturbances is presented. Based on a redundant actuation structure, a novel type-2 adaptive fuzzy fault tolerant control scheme is proposed using sliding mode control. Two adaptive type-2 fuzzy logic systems are used to approximate the unknown functions, whose adaptation laws are deduced from the stability analysis. The proposed approach allows to ensure good tracking performance despite the presence of actuator failures and external disturbances, as illustrated through a simulation example.     

Adaptive disturbance observer‐based finite‐time continuous fault‐tolerant control for reentry RLV

The control effectors of reusable launch vehicle (RLV) can produce significant perturbations and faults in reentry phase. Such a challenge imposes tight requirements to enhance the robustness of vehicle autopilot. Focusing on this problem, a novel finite‐time fault‐tolerant control strategy is proposed for reentry RLV in this paper. The key of this strategy is to design an adaptive‐gain multivariable finite‐time disturbance observer (FDO) to estimate the synthetical perturbation with unknown bounds, which is composed of model uncertainty, external disturbance, and actuator fault considered as the partial loss of actuator effectiveness in this work. Then, combined with the finite‐time high‐order observer and differentiator, a continuous homogeneous second‐order sliding mode controller based on the terminal sliding mode and super‐twisting algorithm is designed to achieve a fast and accurate RLV attitude tracking with chattering attenuation. The main features of the integrated control strategy are that the adaptation algorithm of FDO can achieve non‐overestimating values of the observer gains and the second‐order super‐twisting sliding mode approach can obtain a more elegant solution in finite time. Finally, simulation results of classical RLV (X‐33) are provided to verify the effectiveness and robustness of the proposed fault‐tolerant controller in tracking the guidance commands. Copyright © 2017 John Wiley & Sons, Ltd.     

Robust adaptive fault‐tolerant tracking control of multiple time‐delays systems with mismatched parameter uncertainties and actuator failures

This study deals with the problem of robust adaptive fault‐tolerant tracking for uncertain systems with multiple delayed state perturbations, mismatched parameter uncertainties, external disturbances, and actuator faults including loss of effectiveness, outage, and stuck. It is assumed that the upper bounds of the delayed state perturbations, the external disturbances and the unparameterizable time‐varying stuck faults are unknown. Then, by estimating online such unknown bounds and on the basis of the updated values of these unknown bounds from the adaptive mechanism, a class of memoryless state feedback fault‐tolerant controller with switching signal function is constructed for robust tracking of dynamical signals. Furthermore, by making use of the proposed adaptive robust tracking controller, the tracking error can be guaranteed to be asymptotically zero in spite of multiple delayed state perturbations, mismatched parameter uncertainties, external disturbances, and actuator faults. In addition, it is also proved that the solutions with tracking error of resulting adaptive closed‐loop system are uniformly bounded. Finally, a simulation example for B747‐100/200 aircraft system is provided to illustrate the efficiency of the proposed fault‐tolerant design approach. Copyright © 2014 John Wiley & Sons, Ltd.     

Reaction wheel fault‐tolerant finite‐time control for spacecraft attitude tracking without unwinding

This article proposes fault‐tolerant finite‐time attitude tracking control of a rigid spacecraft actuated by four reaction wheels without unwinding problem in the presence of external disturbances, uncertain inertia parameter, and actuator faults. First, a novel antiunwinding finite‐time attitude tracking control law is derived with a designed control signal which works within a known actuator‐magnitude constraint using a continuous nonsingular fast terminal sliding mode (NFTSM) concept. Second, a finite‐time disturbance observer (FTDO) is introduced to estimate a lumped disturbance due to external disturbances, uncertain inertia parameter, actuator faults, and input saturation. Third, a composite controller is developed which consists of a feedback control based on the continuous NFTSM method and compensation term based on the FTDO. The global finite‐time stability is proved using Lyapunov stability theory. Moreover, the singularity and unwinding phenomenon are avoided. Simulation results are conducted under actuator constraints in the presence of external disturbances, inertia uncertainty, and actuator faults and results are illustrated to show the effectiveness of the proposed method. In addition, to show the superiority of the proposed control method over the recently reported control methods, comparative analysis is also presented.     

航天器自适应快速非奇异终端滑模容错控制

针对存在外部干扰、转动惯量矩阵不确定以及执行器故障的航天器姿态跟踪控制问题,本文提出了基于自适应快速非奇异终端滑模的有限时间收敛故障容错控制方案.通过引入能够避免奇异点,且具有有限时间收敛特性的快速非奇异终端滑模面,设计了满足多约束条件有限时间收敛的姿态跟踪容错控制律,利用参数自适应方法使控制器不依赖转动惯量和外部干扰的上界信息.Lyapunov稳定性分析表明:在存在外部干扰、转动惯量矩阵不确定以及执行器故障等约束条件下,本文设计的控制律能够保证闭环系统的快速收敛性,而且对执行器故障具有良好的容错性能.数值仿真校验了该控制律在姿态跟踪控制中的优良性能.     

Adaptive decentralized fault‐tolerant tracking control for large‐scale nonlinear systems with input quantization

In this paper, an adaptive decentralized tracking control scheme is designed for large‐scale nonlinear systems with input quantization, actuator faults, and external disturbance. The nonlinearities, time‐varying actuator faults, and disturbance are assumed to exist unknown upper and lower bounds. Then, an adaptive decentralized fault‐tolerant tracking control method is designed without using backstepping technique and neural networks. In the proposed control scheme, adaptive mechanisms are used to compensate the effects of unknown nonlinearities, input quantization, actuator faults, and disturbance. The designed adaptive control strategy can guarantee that all the signals of each subsystem are bounded and the tracking errors of all subsystems converge asymptotically to zero. Finally, simulation results are provided to illustrate the effectiveness of the designed approach.     

Third‐order sliding mode fault‐tolerant control for satellites based on iterative learning observer

The attitude fault‐tolerant control problem for a satellite with reaction‐wheel failures, uncertainties, and unknown external disturbances is investigated in this paper. Firstly, an iterative learning observer (ILO) is proposed to achieve fault detection, isolation, and estimation. Secondly, based on the ILO, a third‐order sliding mode controller is proposed to stabilize the satellite attitude rapidly under unknown external disturbances and reaction‐wheel faults. Thirdly, the asymptotically stability of the ILO and the third‐order sliding mode controller is proved by using the Lyapunov stability theory. Finally, simulation results demonstrate that the proposed control scheme is more effective and feasible by comparing with other fault‐tolerant control approach.     

Robust Actuator‐Fault‐Tolerant Control System Based on Sliding‐Mode Observer for Thrust‐Vectoring Aircrafts

In this paper, a robust actuator‐fault‐tolerant control (FTC) system is proposed for thrust‐vectoring aircraft (TVA) control. To this end, a TVA model with actuator fault dynamics, disturbances, and uncertain aerodynamic parameters is described, and a local fault detection and identification (FDI) mechanism is proposed to locate and identify faults, which utilizes an adaptive sliding‐mode observer (SMO) to detect actuator faults and two SMOs to identify and estimate their parameters. Finally, a fault‐tolerant controller is designed to compensate for these actuator faults, disturbances, and uncertain aerodynamic parameters; the approach combines back‐stepping control with fault parameters and a high‐order SMO. Furthermore, the stability of the entire control system is validated, and simulation results are given to demonstrate the effectiveness and potential for this robust FTC system.     

基于super-twisting算法的多航天器姿态有限时间分布式协同控制

针对受外界干扰和执行器故障影响的多航天器姿态协同控制问题,本文设计了一种基于干扰观测器的分布式协同supper-twisting滑模控制器.首先,将各航天器的外界干扰和执行器故障看作一个集总干扰,设计自适应滑模干扰观测器对其进行估计.其次,将supper-twisting算法和积分滑模面相结合,设计一种基于多航天器姿态...     

Robust adaptive fault‐tolerant control of uncertain linear systems via sliding‐mode output feedback

This paper is concerned with the robust adaptive fault‐tolerant compensation control problem via sliding‐mode output feedback for uncertain linear systems with actuator faults and exogenous disturbances. Mismatched disturbance attenuation is performed via H_∞ norm minimization. By incorporating the matrix full‐rank factorization technique with sliding surface design successfully, the total failure of certain actuators can be coped with, under the assumption that redundancy is available in the system. Without the need for a fault detection and isolation mechanism, an adaptive sliding mode controller, where the gain of the nonlinear unit vector term is updated automatically to compensate the effects of actuator faults, is designed to guarantee the asymptotic stability and adaptive H_∞ performance of closed‐loop systems. The effectiveness of the proposed design method is illustrated via a B747‐100/200 aircraft model. Copyright © 2014 John Wiley & Sons, Ltd.     

Adaptive multivariable finite‐time continuous fault‐tolerant control of rigid spacecraft

The problem of fault‐tolerant attitude tracking control for rigid spacecraft in the presence of inertia uncertainties, actuator faults, and external disturbances is investigated in this paper. A novel adaptive finite‐time continuous fault‐tolerant control strategy is developed by combining the fast nonsingular terminal sliding mode surface and the adaptive multivariable super‐twisting algorithm, which improves the robustness while preserving high accuracy and finite‐time convergence. The main features of the control strategy are the double‐layer adaptive algorithm based on equivalent control, which ensures nonoverestimation of the control gain and the continuous controller, which maintains better property of chattering reduction. Finally, the efficiency of the proposed controller is illustrated by numerical simulations.     

Fuzzy adaptive nonlinear sensor‐fault tolerant control for a quadrotor unmanned aerial vehicle

In this paper, a novel fuzzy adaptive nonlinear fault tolerant control design scheme is proposed for attitude dynamics of quadrotor UAV subjected to four sensor faults (bias, drift, loss of accuracy, loss of effectiveness). The sensor faults in Euler angle loop are transformed equivalently into a mismatched uncertainty vector, and other unknown items involving faults, uncertain parameters and external disturbances in angular velocity loop are lumped into an unknown nonlinear function vector. Fuzzy logic systems with adaptive parameters are used to approximate the mismatched uncertainty and lumped nonlinear function vectors. Dynamic surface control is applied to design the fault tolerant controller, and sliding mode control is introduced to improve the control accuracy. All signals of the closed‐loop control system are proved to be semi‐global uniformly ultimately bounded. Simulations demonstrate the effectiveness of the proposed approach for sensor faults.     

航天器执行机构部分失效故障的鲁棒容错控制

针对航天器在轨运行时受到外部干扰以及存在执行机构部分失效故障的问题,提出一种基于白适应滑模控制的鲁棒容错控制方法．该方法利用自适应算法估计执行机构故障的最小值,并通过设计滑模变结构控制器来实现对故障的容错控制以及对干扰的抑制控制,无需精确获得执行机构故障值,从而使得设计的控制器对于故障具有一定的鲁棒性．仿真结果表明了该...     

Fault‐Tolerant Control for Flutter of Airfoil Subject to Input Saturation

In this paper, a fault tolerant control is studied for a two‐dimensional airfoil with input saturation and actuator fault. The dynamic equation of airfoil flutter is firstly established, in which the cubic hard spring nonlinearity of pitch stiffness is considered. Then, an adaptive sliding mode fault tolerant control is derived by using an on‐line updating law to estimate the bound of the actuator fault such that no information about the fault is needed. Furthermore, an auxiliary design system is introduced to resolve actuator saturation in control. Next, Lyapunov stability analysis is carried out to prove that the system is asymptotically stable. Finally, the effectiveness of the proposed controller is verified through numerical simulations. Simulation results indicate that the adaptive sliding mode fault tolerant controller is effective in suppressing airfoil flutter under partial loss of actuator effectiveness performance and input saturation.     

Actuator fault‐tolerant control of ocean surface vessels with input saturation

In this paper, an actuator robust fault‐tolerant control is proposed for ocean surface vessels with parametric uncertainties and unknown disturbances. Using the backstepping technique and Lyapunov synthesis method, the adaptive tracking control is first developed by incorporating the actuator configuration matrix and considering actuator saturation constraints. The changeable actuator configuration matrix caused by rotatable propulsion devices is considered. Next, the actuator fault‐tolerant control is developed for the case when faults occur in propulsion devices of the ocean surface vessel. Rigorous stability analysis is carried out to show that the proposed fault‐tolerant control can guarantee the stability of the closed‐loop system under certain actuator failure. Finally, simulation studies are given to illustrate the effectiveness of the proposed adaptive tracking control and fault‐tolerant control. Copyright © 2015 John Wiley & Sons, Ltd.