Effect of high pressure processing on rheological and structural properties of milk–gelatin mixtures

There is an increasing demand to tailor the functional properties of mixed biopolymer systems that find application in dairy food products. The effect of static high pressure processing (HPP), up to 600 MPa for 15 min at room temperature, on milk–gelatin mixtures with different solid concentrations (5%, 10%, 15% and 20% w/w milk solid and 0.6% w/w gelatin) was investigated. The viscosity remarkably increased in mixtures prepared with high milk solid concentration (15% and 20% w/w) following HPP at 300 MPa, whereas HPP at 600 MPa caused a decline in viscosity. This was due to ruptured aggregates and phase separation as confirmed by confocal laser scanning microscopy. Molecular bonding of the milk–gelatin mixtures due to HPP was shown by Fourier-transform infrared spectra, particularly within the regions of 1610–1690 and 1480–1575 cm⁻¹, which reflect the vibrational bands of amide I and amide II, respectively.     

Effects of different vinification technologies on physico-chemical properties and antioxidant activity of ‘Falanghina’ and ‘Bombino bianco’ wines

The present research was aimed to compare the traditional white vinification with a combined cryomaceration–vinification in reductive conditions, by evaluating their effects on chemical and physical indices and on antioxidant compounds of ‘Falanghina’ and ‘Bombino bianco’, two wine grape cultivars of southern Italy. According to the results, the two cultivars showed similar behaviour in response to the same vinification protocol. The processing conditions mainly affected physico-chemical characteristics such as titratable acidity, pH, SO₂, tartaric and malic acids, phenolic concentrations, and antioxidant activity. Titratable acidity decreased with cryomaceration due to the tartrate precipitation, whereas the malic acid was greatly extracted from pulps and skins. In the reductive conditions applied, the SO₂ was protected by the presence of ascorbic acid; thus, the wines exhibited higher free/total SO₂ ratio. Cryomaceration combined with vinification in reductive conditions allowed a greater extraction of phenolic compounds from skins and, consequently, a greater antioxidant activity compared to the traditional winemaking. This behaviour was due to both the protection exerted by the low temperatures and the solubilisation of proanthocyanidins and flavans reactive with vanillin favoured by the high free SO₂ content.     

Effect of glucono-δ-lactone and κ-carrageenan combined with high pressure treatment on the physico-chemical properties of restructured pork

In this study, response surface methodology (RSM) was used to evaluate the combined effects of NaCl, glucono-δ-lactone (GdL), and κ-carrageenan concentration (0.25%, 0.5%, and 0.75%) on the binding properties of restructured pork under hydrostatic pressure. All the generated RSM models showed no lack-of-fit and significance at the 0.001 level. The addition of both NaCl and GdL had a significant effect on color. A significant decrease in pH was shown when the GdL level increased, and subsequently led to a decrease in WHC. However, increasing the GdL level increased the binding strength. Therefore, the results indicate that a reduction in the NaCl level during meat restructuring, under pressure treatment, can be achieved by using GdL; and even a low GdL concentration allows for palatable binding properties in meat restructuring when κ-carrageenan is added.     

Effect of addition of CO₂ to raw milk on quality of UHT-treated milk

The objective of this study was to evaluate the effect of addition of CO(2) to raw milk on UHT milk quality during storage. Control milk (without CO(2) addition) and treated milk (with CO(2) addition up to pH 6.2) were stored in bulk tanks at 4°C for 6d. After storage, both samples were UHT processed using indirect heating (140°C for 5s). Samples were aseptically packed in low-density polyethylene pouches and stored in the dark at room temperature. Raw milk was evaluated upon receipt for physicochemical composition, proteolysis, lipolysis, standard plate count, psychrotrophic bacteria, and Pseudomonas spp. counts, and after 6d of storage for proteolysis, lipolysis, and microbial counts. After processing, UHT milk samples were evaluated for physicochemical composition, proteolysis, and lipolysis. Samples were evaluated for proteolysis and lipolysis twice a month until 120d. Peptides from pH 4.6-soluble N filtrates were performed by reversed-phase HPLC after 1 and 120d of storage. A split-plot design was used and the complete experiment was carried out in triplicate. The results were evaluated by ANOVA and Tukey's test. After 6d of storage, CO(2)-treated raw milk kept its physicochemical and microbiological quality, whereas the untreated milk showed significant quality losses. A significant increase in proteolysis occurred during 120d of storage in both treatments, but the increase occurred 1.4 times faster in untreated UHT milk than in CO(2)-treated UHT milk. In both UHT milks, the proteolysis was a consequence of the action of plasmin and microbial proteases. However, the untreated UHT milk showed higher microbial protease activity than the treated UHT milk. The addition of CO(2) to the raw milk maintained the quality during storage, resulting in UHT milk with less proteolysis and possibly longer shelf life, which is usually limited by age gelation of UHT milk.     

Effect of κ-carrageenan on milk protein polysaccharide mixtures

The effect of κ-carrageenan (0, 0.025, 0.05%) on phase separation between polysaccharides (0.36% of locust bean gum (LBG), guar gum, or xanthan gum) and milk proteins (from 10.5% skim milk powder) in solution was studied. Xanthan gum was seen to be the most incompatible with milk proteins, followed by guar gum and LBG. Casein micelles were more incompatible with all polysaccharides than whey proteins. Whereas at either concentration κ-carrageenan inhibited visual phase separation, it was seen by transmission electron microscopy that samples with κ-carrageenan showed microscopic phase separation. Samples with 0.05% κ-carrageenan and either LBG or guar gum and all samples with xanthan gum could be described rheologically as weak gels, while those with no or 0.025% κ-carrageenan and either LBG or guar gum could be described as concentrated solutions. Thus, no correlation was seen between the inhibition of macroscopic phase separation by κ-carrageenan and the formation of a weak gel in solution.     

Effect of γ-polyglutamate on the rheological properties and microstructure of tofu

The effects of γ-polyglutamates with different concentrations (0.1%, 0.15%, 0.2%) and molecular weights (high, medium, low) addition on the rheological properties, microstructure, and syneresis of tofu were studied. The addition of γ-polyglutamate increased the gelation time, and decreased the storage modulus (G′) and the loss modulus (G″) of tofu. The molecular weight and concentration of γ-polyglutamate effectively changed the rheological properties of tofu. The network of tofu without γ-polyglutamate addition was constructed by fine strands in a dense arrangement as seen by using scanning electron microscope. However, the addition of γ-polyglutamate reduced the thickness of the strands in tofu network. Tofu syneresis was also reduced by the addition of γ-polyglutamate. Increase the concentration of γ-polyglutamate significantly decreased the syneresis of tofu. This trend was more evident on the tofu with high molecular weight γ-polyglutamate.     

Effect of adzuki bean sprout fermented milk enriched in γ-aminobutyric acid on mild depression in a mouse model

This study focused on the ability of adzuki bean (Vigna angularis) sprout fermented milk, which is rich in γ-aminobutyric acid (GABA), to relieve anxiety and mild depression. A high-yield GABA-producing strain, Lactobacillus brevis J1, from a healthy cow was screened, and its physiological and probiotic properties were evaluated. The effect of adzuki bean sprout fermented milk was investigated in vivo in a chronic depression mouse model. The results showed that Lb. brevis J1 had excellent probiotic properties, grew well at low pH and 3% NaCl, and adhered to the surface of HT-29 cells. The GABA-enriched (241.30 ± 1.62 µg/mL) adzuki bean sprout fermented milk prepared with Streptococcus thermophilus, Lactobacillus bulgaricus, and Lactobacillus plantarum, and Lb. brevis J1 can reduce and possibly prevent mild depression-like symptoms in mice (C57/B6) by increasing social interaction and enhancing the pleasure derived from movement. The research revealed that the GABA_B-cyclic AMP-protein kinase A-cAMP-response element binding protein (GABA_B-cAMP-PKA-CREB) signaling pathway was related to the depression-like symptoms and that levels of 5-hydroxytryptamine, norepinephrine, and dopamine in the hippocampus of mice increased after treatment with the adzuki bean sprout fermented milk. Our results suggest that GABA-enriched dairy products have the potential to prevent or treat mild depression-like symptoms in mice, which suggests a new approach for a dietary therapy to treat chronic social stress.     

Glycosylation of κ-casein: Genetic and nongenetic variation and effects on rennet coagulation properties of milk

The aims of this study were to investigate genetic and nongenetic variation in the degree of glycosylation of κ-casein (κ-CN) and to estimate the effects of glycosylated (G-κCN) and unglycosylated (U-κCN) κ-CN contents on milk coagulation properties of Simmental cows. Measures of contents of the main casein fractions, G-κCN, and U-κCN, and assessment of genotypes at CSN2, CSN3, and BLG were obtained by reversed-phase HPLC analysis of 2,015 individual milk samples. Content of total κ-CN (κ-CNtot, g/L) was the sum of G-κCN and U-κCN, and the glycosylation degree of κ-CN (GD) was measured as the ratio of G-κCN to κ-CNtot. Rennet coagulation time (RCT) and curd firmness were measured by using a computerized renneting meter. Measures of curd firmness were adjusted for RCT before statistical analysis. Variance components of κ-CNtot, G-κCN, U-κCN, and GD were estimated by Bayesian procedures and univariate linear models that included the class effects of the herd-test-day, parity, days in milk, genotypes at milk protein genes, and animal. These class effects, those of G-κCN, U-κCN, and content of other caseins, and the linear effect of milk pH were accounted for by models investigating the influence of κ-CN glycosylation on coagulation properties. The GD ranged from 22 to 76%, indicating that variation in G-κCN depends on the variation both in κ-CNtot and in the efficiency of κ-CN glycosylation. Genotype CSN3 BB exhibited high G-κCN and U-κCN relative to that of CSN3 AA. Heritability of G-κCN, U-κCN, and GD was high and ranged from 0.46 to 0.56. A large proportion of the additive genetic variation in G-κCN and U-κCN was attributable to influence of CSN and BLG, but these genes did not affect variation in GD, and across-genotypes differences in the trait were small or trivial. Average RCT of the milk class having the highest G-κCN was, on average, 2 min (standard deviation 0.5) shorter than that of the lowest class. Conversely, U-κCN and content of other caseins were not associated with any effect on RCT, except for a slight delay in coagulation when U-κCN was very high. Curd firmness increased when the contents of both κ-CN fractions and other caseins increased. This study provides evidence that the positive association between RCT and κ-CN content is exclusively attributable to the glycosylated fraction of the protein. Because exploitable additive genetic variation in G-κCN exists, improvement of κ-CN composition through selective breeding might be an effective way to enhance milk coagulation properties.     

Effect of heat treatments on stability of β-lactams in milk

The presence of residues of antimicrobial substances in milk may have serious toxicological and technical consequences. To date, few studies have been done to evaluate the effect of heat treatments on β-lactam residues in milk. However, the few studies that have been conducted estimate losses of antimicrobial activity under different combinations of temperature and time using microbiological methods. The aims of this study were to calculate the kinetic parameters for the degradation of β-lactam antibiotics in milk and to develop prediction models to estimate the concentration losses of these compounds in conventional dairy heat treatments. To do so, we employed a quantitative HPLC method to calculate losses in concentrations of 10 β-lactam antibiotics in milk with different combinations of temperature and time. Increasing the temperature from 60°C to 100°C decreased the half-life of amoxicillin (372 to 50 min), ampicillin (741 to 26 min), cloxacillin (367 to 46 min), and penicillin G (382 to 43 min). These increases in temperature caused further degradation in cephalosporins, which was accompanied by a decrease in half-life times to reach very low values; for instance, 4, 5, and 6 min for cefoperazone, cephurexime, and cephapirin, respectively. Kinetic equations were applied to different heat treatments used in dairy processing. Heat treatments at high temperatures and long times (e.g., 120°C for 20 min) led to a further degradation of β-lactam antibiotics with percentages close to 100% for cefoperazone and cefuroxime. In contrast, when milk was subjected to heat treatments at lower temperatures and times (e.g., 72°C for 15 s), the degradation of β-lactam in milk did not exceed 1% for the 10 antibiotics tested.     

Diversity analysis and quantification of lactic acid bacteria in traditionally fermented yaks’ milk products from Tibet

Fermented yaks’ milk is a characteristic fermented dairy product with a rich microflora (especially lactic acid bacteria [LAB]), that has been produced by Tibetan people in China throughout history. Systematic analysis of the LAB composition of fermented yaks’ milk from central Tibet is essential. In the present study, 38 samples of fermented yaks’ milk were collected from three regions in central Tibet. From these, a total of 211 isolates of LAB were generated using traditional pure culture methods. To accurately analyze their biodiversity, 16S rRNA gene sequence analysis and denaturing gradient gel electrophoresis (DGGE) were used. The isolates were identified as belonging to six genera and 22 species/subspecies. Among them, Lactobacillus species predominated (117 isolates) accounting for 55.45% of all isolates. Overall, L. delbrueckii subsp. bulgaricus (60 isolates; 28.43% of the total) was the most commonly isolated species of LAB from fermented yaks’ milk from central Tibet. Seven Lactobacillus species and the Bifidobacterium genus were confirmed by quantitative PCR (q-PCR). The q-PCR results showed that the abundance of these groups in fermented yaks’ milk from central Tibet ranged from 1.12 ± 0.36 log cfu/ml (for L. sakei from Ningzhong) to 7.77 ± 0.84 log cfu/ml (for L. helvetivus from Ningzhong). Lactobacillus acidophilus, L. delbrueckii subsp. bulgaricus, L. fermentum, L. helveticus varied in concentration depending on the region. The results indicated that traditional fermented yaks’ milk from different regions of central Tibet have complex compositions of LAB species. The diversity of LAB might be related to geographical origin.     

Effect of barley β-glucan on water redistribution and thermal properties of dough

The effect of adding barley (Hordeum vulgare L.) β-glucan (BBG) to dough on the water redistribution and the thermal properties of dough was studied by TGA and DSC. Combined with LF-NMR to analyse the competition and redistribution mechanism of water at the ¹H level. The mass loss of the dough measured by TGA was reduced by an average of 2.11% with BBG added. BBG increased the water retention of the dough, delayed the water loss process. The LF-NMR results showed that at the same water absorption the T21 of the 3% BBG dough was longer while its T22 was shorter than those of the control. BBG has different effects on the different states of water in the dough. BBG increased the free sulfhydryl content in dough during heating, while the adverse effects of BBG on the biopolymer reactions, such as disulfide bond, could be partially relieved by regulating water content.     

Enrichment of chips with fibre from a tiger-nut (Cyperus esculentus) milk co-product at ‘source of fibre foods’ and ‘high fibre content foods’ levels: impact on processing,physico-chemical and sensory properties

The impact of integrating a tiger-nut milk co-product into the wheat chip production process for enriching fibre content to meet European recommendations for ‘source of fibre foods’ and ‘high fibre content foods’ was studied. Four different flours, based on their composition and particle size, were obtained from the co-product. Wheat flour was substituted at the 5%, 10% and 20% levels with the co-product, and the processing, physico-chemical and sensory properties of chip were studied. In the baking phase, mass loss was more marked for the substituted samples (42%) than the control (34%), but differences diminished after the tempering time (33%) by absorbing moisture from the environment. This effect was related to the increased chips surface (≈43%) in the forming phase because dough retraction decreased. The co-product as a fibre source produced alterations to chip processing and its physico-chemical properties should be taken into account. However, chips positively impacted consumer acceptability.     

Fabrication and evaluation of physicochemical properties of probiotic edible film based on pectin–alginate–casein composite

The objective of this study was to develop a casein-based edible film for the entrapment of probiotic Enterococcus faecium Rp1. Casein, pectin, sodium alginate and glycerol were used to prepare the film. In this study, the physicochemical and morphological properties of casein-based edible film and its impact on the stability of probiotic were evaluated. Surface morphology and properties of the film were tested using a scanning electron microscope, fluorescence microscopy, Raman spectroscopy, Fourier transform infrared spectroscopy and X-ray diffraction. Probiotic-incorporated casein-based edible film showed significant improvement in the antimicrobial and antioxidant properties and enhanced the structural, optical and thermal properties. Furthermore, the film was found to be desirable to carry probiotics, with the viability of 10⁷ CFU mL⁻¹ rate up to 30 days of storage at 4 °C. Hence, the current study suggests a probiotic-incorporated casein-based edible film for active packaging of food products.     

Effect of alkali treatment of lower concentrations on the structure and tensile properties of Pakistan’s coarse cotton fibre

Abstract

Cotton fibres of high Micronaire values are known to have inferior spinning performance. Either reduction of fibres’ fineness or increase in tensile strength is generally expected to improve the spinnability of fibres. In this piece of research, the effects of alkali treatment at lower concentrations (0.75–2.25M) and higher temperatures (70–100?°C) on the cross-section of cotton fibre and on the tensile strength have been investigated. Observations were made using scanning electron microscopy (SEM) and single fibre tensile strength testing. It was found that the roundness of the fibre cross section was improved and the tensile strength of the fibres also increased after treatment with alkali at lower concentration (0.75?M) and relatively lower temperature (70?°C). It is proposed that such changes occurred due to possible cellulose dissolution/transformations. It was thus concluded that the alkali treatment of cotton fibres at lower concentrations (0.75?M) and 70?°C for a shorter period of time (45 mins) could lead to improvement in tensile strength and roundness of fibre cross-section, thereby improving micronaire.     

Effect of sea water on water absorption and flexural properties of?wood-polypropylene composites

The effects of Caspian Sea and Persian Gulf waters on the physical and mechanical properties of wood- polypropylene composites were studied. For physical tests, the composites were immersed in Caspian Sea, Persian Gulf and distilled water and long term water absorption was determined. For mechanical tests, the prepared composites were immersed in Caspian Sea, Persian Gulf and distilled water for 7 or 30 days, removed from water and their flexural properties were measured. The composites immersed in Persian Gulf water exhibited higher water absorption and lower flexural properties than those immersed in Caspian Sea and distilled water, respectively. At higher sawdust content, the type of water is more effective on increasing water absorption and decreasing flexural properties.     

Genetic polymorphism of ovine milk proteins: its influence on technological properties of milk — a review

Current knowledge of the genetic polymorphism in ovine milk proteins including heterogeneity detected and their relationships with the technological properties of milk is reviewed. In the casein fraction a great heterogeneity has been determined either by the presence of genetic variants or other factors such as a discrete phosphorylation level and the coexistence of protein forms of different chain length. In the whey fractions, three genetic variants (A, B, and C) are described for β-lactoglobulin (β-LG), and two for α-lactalbumin (α-LA). The topics discussed include the rennetability of ovine milk, cheese yield and susceptibility of β-LG genetic variants to heat denaturation as well as the findings concerning the relationships between ovine milk protein polymorphism and milk production and composition. However, further investigation is needed in order to better outline the relevant features of polymorphism and technological properties of ovine milk.     

Effect of γ-irradiation on physical quality attributes and identification properties of different sauces

Gamma-irradiated (0, 1, and 10 kGy) ketchup (KTP), barbeque sauce (BBQ), and sweet chili sauce (SWC) were identified using photostimulated-luminescence (PSL) and thermoluminescence (TL) analysis and characterized for physical properties like Brix, consistency, and color. PSL-based screening showed negative results for all nonirradiated samples, while intermediated results were found for irradiated samples. Routine density separation method for mineral extraction provided better TL results; however, alkaline and acid hydrolysis could ease the process with acceptable results. A slight decrease in consistency of all the samples was observed. Brix of KTP remained unchanged, while increase of same was obvious in BBQ and SWC following irradiation. The Hunter L* value of the γ-irradiated sauces decreased except SWC samples, and the a* and b* values showed a general increase compared to the non-irradiated samples. The studied methods have potential to successfully identify and characterize the irradiated sauces for technical and regulatory requirements.     

Effects of marination, cooking and storage on physico-chemical and microbiological properties of ready to eat trout döner kebab

The aim of this work was to investigate the use of rainbow trout (Oncorhynchus mykiss) in ready to eat döner kebab production and determine the effects of marination, cooking and storage conditions (4 and ?18 °C) on physico-chemical and microbiological properties of döner kebab. The raw trout meat, raw, cooked and stored döner kebab samples were subjected to moisture, protein, fat, ash, color, pH, cholesterol, biogenic amines, lipid oxidation, fatty acids profile, texture, microbiological and sensory analysis. The results indicated that the major fatty acids in trout döner kebab were palmitic, stearic, oleic, omega-3 and omega-6 fatty acids and unsaturated fatty acids were higher than saturated fatty acids (p < 0.05). Low biogenic amine and cholesterol contents were determined in döner kebab. It was found that ?18 °C of storage temperature was more effective than 4 °C for inhibition of lipid oxidation and microbial growth in trout döner kebab (p < 0.05). While cooking affected parameters evaluated (p < 0.05), marination did not have any significant effect. The study results indicated that using rainbow trout meat in döner kebab production could be beneficial to provide healthy meat products without posing any acceptability problems in terms of quality factors. This is the first paper to be reported on physico-chemical and microbiological properties of döner kebab produced with rainbow trout and effects of marination, cooking and different storage temperatures on these physico-chemical and microbiological properties.