Effect of controlled-release chlorine dioxide on the quality and safety of cherry/grape tomatoes

The effect of controlled-release chlorine dioxide (ClO₂) gas on the food safety and quality of cherry/grape tomatoes was investigated. Whole grape tomatoes artificially inoculated with either Escherichia coli or Alternaria alternata, or whole cherry tomatoes inoculated with Salmonella enterica Newport, were packed in 1-lb clamshells, and stored at 20 °C for 14 days. ClO₂ pouches were attached under the lids with the following four dosages/release rates: single dose slow-release (S), single dose fast-release (F), fast/slow-release combination (FS), and double dose fast-release (FF). The corresponding equilibrium ClO₂ concentration in the headspace was about 2, 4, 6 and 8 ppm, respectively. Treatment with F reduced populations of E. coli and A. alternata by 2.9–4.7, and 1.6 to 4.0 log CFU/g, respectively, within 14 days storage at 20 °C. FS and FF treatments showed little benefit over F. The F and FF treatments reduced population of S. enterica for inoculated cherry tomatoes by 3.28 and 3.80 log CFU/g, respectively, compared to control after 14 days’ storage at 20 °C. ClO₂-treated grape tomatoes retained higher firmness and had less weight loss compared to the control. The results indicate that 2 ppm of ClO₂ (S) in the clamshells did not adequately control microbial populations; the minimum effective concentration of ClO₂ was 4 ppm (F). Higher concentrations provided a small but incremental improvement in ability to control microorganisms. ClO₂ released into packages of cherry tomatoes during storage reduced weight loss, while maintaining firmness.     

The efficacy of chemical sanitizers on the reduction of Salmonella Typhimurium and Escherichia coli affected by bacterial cell history and water quality

Washing fresh produce with potable water helps to remove microorganisms, providing about a 1- to 2-log reduction, but this process can also pose an opportunity for cross-contamination of bacteria in the washing tank. The objective of this study was to evaluate the efficacy of three chemical sanitizers, sodium hypochlorite, chlorine dioxide, and a silver-copper solution on the reduction of S. Typhimurium and extended-spectrum beta-lactamase (ESBL) E. coli as well as to evaluate the impact bacterial cell history and water quality had on sanitizer efficacy. This was investigated with three scenarios representing different contamination routes and history of cells: (i) on starved and non-starved cells in potable water, (ii) on starved and non-starved cells in lettuce wash water and on lettuce leaf punches, and (iii) on non-starved cells in organically loaded process wash water (PWW). Sodium hypochlorite (NaClO) and chlorine dioxide (ClO₂) were more effective in preventing cross-contamination in the potable water than the silver-copper solution. Starved and non-starved bacterial cells displayed minor differences in their susceptibility to sanitizing agents in the (i) potable water and (ii) lettuce wash water demonstrating that other conditions greater influenced sanitizer efficacy. Particularly, the organic load of the water, wash water temperature, and pathogen attachment and release from the produce were shown to affect a sanitizer's efficacy during washing. Furthermore, results emphasize that chemical sanitizer use should focus more on wash water disinfection, rather than produce decontamination, to prevent pathogenic cross-contamination during processing. Future research should investigate the feasibility of ClO₂ application during pilot-scale processing.     

The effect of pulsed UV light on Escherichia coli O157:H7, Listeria monocytogenes,Salmonella Typhimurium,Staphylococcus aureus and staphylococcal enterotoxin A on sliced fermented salami and its chemical quality

Pulsed UV light (PL) applied at a fluence of 3 J/cm² was effective to reduce Listeria monocytogenes, Escherichia coli 0157:H7, Salmonella Typhimurium and Staphylococcus aureus for 2.24, 2.29, 2.25 and 2.12 log CFU/g on the surface of dry fermented salami. Further increase in the fluence of PL treatment did not increase levels of microbial inactivation. However, the time interval between the contamination and PL treatment was found to have a significant impact on the efficacy of PL treatment and should be kept as short as possible. After initial PL treatment slices of fermented salami were packed in vacuum or in 80%CO₂/20%N₂ modified atmosphere and stored at 4 °C to investigate the effect of PL treatment on protein and lipid oxidation as the shelf life of fermented salami is not usually limited by microbial deterioration, but by chemical and sensory alterations. In this study observed lipid oxidation values for PL treated vacuum and modified atmosphere packed fermented salami slices fall within the acceptable threshold for the rancid odor, except for the sample treated with the highest fluence tested (15 J/cm²), packed in modified atmosphere and kept in cold storage for 9 weeks (1.23 mg MDA/kg). All values were below the threshold for rancid flavor, too. The significant rise in protein oxidation of PL treated fermented salami slices, perceived as 28% increase of carbonyl content compared to untreated samples, was observed only after 9 weeks of cold storage in both vacuum and modified atmosphere packed samples. The results of chemical analysis are in agreement with previously published results of sensory analysis. Current results show the applicability of PL to improve microbial safety of sliced fermented salami that are prone to cross-contamination without affecting quality attributes by lipid and protein oxidation.