Modelling survival kinetics of Staphylococcus aureus and Escherichia coli O157:H7 on stainless steel surfaces soiled with different substrates under static conditions of temperature and relative humidity

The survival of Escherichia coli O157:H7 and Staphylococcus aureus on stainless steel surfaces with Saline Solution (SS), Tryptone Soy Broth (TSB) and meat purge was studied, and based on results, mathematical models describing survival of pathogens as a function of time were proposed. Results indicated that S. aureus was able to survive longer than E. coli O157:H7 in all substrates. The type of substrate had a greater impact on the survival of E. coli O157:H7. This microorganism only remained viable for 8 and 50 h (hours) on surfaces with SS and TSB, respectively while on meat purge, the microorganism could be recovered after 200 h. For S. aureus, SS and TSB led to similar survival times (250 h) whereas on meat purge, survival capacity increased to 800 h. Survival data for S. aureus could be well described by a log-linear model or a Weibull model depending on the type of substrate (R² > 0.85). E. coli O157:H7 displayed an evident tail zone which made the Weibull model more appropriate (R² > 0.94). These survival models may be used in quantitative risk assessment to produce more accurate risk estimates. Finally, the results highlight the importance of performing effective cleaning procedures to prevent cross contamination.     

Survival of Escherichia coli O157:H7 in meat product brines containing antimicrobials

Brine solution injection of beef contaminated with Escherichia coli O157:H7 on its surface may lead to internalization of pathogen cells and/or cross-contamination of the brine, which when recirculated, may serve as a source of new product contamination. This study evaluated survival of E. coli O157:H7 in brines formulated without or with antimicrobials. The brines were formulated in sterile distilled water (simulating the composition of freshly prepared brines) or in a nonsterile 3% meat homogenate (simulating the composition of recirculating brines) at concentrations used to moisture-enhance meat to 110% of initial weight, as follows: sodium chloride (NaCl, 5.5%) + sodium tripolyphosphate (STP, 2.75%), NaCl + sodium pyrophosphate (2.75%), or NaCl + STP combined with potassium lactate (PL, 22%), sodium diacetate (SD, 1.65%), PL + SD, lactic acid (3.3%), acetic acid (3.3%), citric acid (3.3%), nisin (0.0165%) + ethylenediamine tetraacetic acid (EDTA, 200 mM), pediocin (11000 AU/mL) + EDTA, sodium metasilicate (2.2%), cetylpyridinium chloride (CPC, 5.5%), or hops beta acids (0.0055%). The brines were inoculated (3 to 4 log CFU/mL) with rifampicin-resistant E. coli O157:H7 (8-strain composite) and stored at 4 or 15 °C (24 to 48 h). Immediate (0 h) pathogen reductions (P < 0.05) of 1.8 to ≥ 2.4 log CFU/mL were observed in brines containing CPC or sodium metasilicate. Furthermore, brines formulated with lactic acid, acetic acid, citric acid, nisin + EDTA, pediocin + EDTA, CPC, sodium metasilicate, or hops beta acids had reductions (P < 0.05) in pathogen levels during storage; however, the extent of pathogen reduction (0.4 to > 2.4 log CFU/mL) depended on the antimicrobial, brine type, and storage temperature and time. These data should be useful in development or improvement of brine formulations for control of E. coli O157:H7 in moisture-enhanced meat products. PRACTICAL APPLICATION: Results of this study should be useful to the meat industry for developing or modifying brine formulations to reduce the risk of E. coli O157:H7 in moisture-enhanced meat products.     

食品中大肠杆菌O157:H7的预测模型及风险评估

大肠杆菌O157:H7是严重危害人类健康的肠道致病菌,感染剂量极低,低达10个菌体。由该菌引起的食物中毒十分凶险,引起世界各国的重视。该菌引起的感染主要通过食品传播,因此加强食品卫生管理,防止食源性感染和流行尤为迫切。本文就大肠杆菌O157:H7在食品中的预测模型以及风险评估进行了概述。     

Escherichia coli O157:H7 facilitates the penetration of Staphylococcus aureus into table eggs

Abstract: Fresh eggshells collected from a local farm were subjected to different levels of surface contamination with feces containing different levels (3 to 5 log₁₀) of Escherichia coli O157:H7 or Staphylococcus aureus and incubated at 3 different temperatures (10, 25, and 32 °C). The penetration rates of contaminating bacteria were followed throughout the incubation period by tracing bacterial presence in shell, shell membranes, albumen, and yolk. The study revealed the ability of both E. coli O157:H7 and enterotoxigenic S. aureus to grow on shell in feces, penetrate the shell, and move and multiply within egg contents at different rates and periods depending on bacterial type and incubation conditions. High temperatures (25 and 32 °C) increased penetration rate, whereas storage at 10 °C decreased significantly the rate of penetration. High levels of contamination with E. coli O157:H7 also shortened the time needed for the penetration process. Results showed that when eggshells were contaminated with both organisms simultaneously, the penetration of E. coli O157:H7 preceded that of S. aureus and facilitated the invasion of the latter bacteria.     

Effect of irradiation temperature on inactivation of Escherichia coli O157:H7 and Staphylococcus aureus

The resistance of Escherichia coli O157:H7 and Staphylococcus aureus in ground beef to gamma radiation was significantly (P < 0.05) higher at subfreezing temperatures than above freezing. Ground beef was inoculated (ca. 2 x 10(8) CFU/g) with five isolates of either E. coli O157:H7 or S. aureus and subdivided into 25-g samples, vacuum packaged in barrier pouches, and tempered to 20, 12, 4, 0, -4, -12, -20, -30, -40, or -76 degrees C before gamma irradiation. The studies were repeated twice. The D10-values for both of these pathogens increased significantly at subfreezing temperatures, reaching maxima at approximately -20 degrees C. The D10-values for E. coli O157:H7 at 4 and -20 degrees C were 0.39 +/- 0.04 and 0.98 +/- 0.23 kGy, respectively. The D10-values for S. aureus at 0 and -20 degrees C were 0.51 degrees 0.02 and 0.88 +/- 0.05 kGy, respectively.     

三重荧光PCR检测沙门氏菌、金黄色葡萄球菌和大肠埃希氏菌O157:H7

目的 建立一种检验沙门氏菌、金黄色葡萄球菌、大肠埃希氏菌O157:H7的TaqMan探针三重荧光PCR方法.方法 针对沙门氏菌属特异性invA基因、金黄色葡萄球菌rpoB基因、大肠埃希氏菌O157:H7的rfbE基因设计引物与探针,建立三重荧光PCR体系,对引物与探针浓度及退火温度优化,并进行特异性和敏感性研究.结果 ...     

A review of quantitative microbial risk assessment in the management of Escherichia coli O157:H7 on beef

Since Escherichia coli O157:H7 first emerged as a food borne pathogen in the mid 1980s, it has been linked to many cases of food poisoning across the world. While multiple sources and routes of transmission for this pathogen are now recognised, beef and beef products remain an important vehicle of the pathogen and continue to be linked to outbreaks across the developed world. Much research has been directed at E. coli O157:H7 transmission, survival and control in the beef chain and this paper presents an overview of current knowledge on this pathogen in the beef chain from primary production through slaughter, processing, distribution, final preparation and cooking. In order to strategically manage E. coli O157:H7 and to devise approaches to reduce the public health risk posed, many national and international groups have applied quantitative risk assessment techniques to model the risk posed by E. coli O157:H7 in beef, particularly in ground/minced beef which is most often linked with infection. This paper reviews these quantitative risk assessments and their application in managing the risk posed by E. coli O157:H7 in beef.     

适配体结合量子点技术同时检测金黄色葡萄球菌和大肠埃希氏菌O157:H7方法

目的：基于适配体结合量子点技术,建立一种同时针对金黄色葡萄球菌、大肠埃希氏菌O157:H7两种食源性致病菌快速高效、灵敏的检测方法。方法：利用表面增强拉曼光谱技术筛选出与目标菌结合特异性较好的2?种适配体;利用免疫磁珠与适配体偶联技术特异性捕获2?种目标菌;选取不同发光原理的2?种量子点,并结合量子点荧光标记技术构建“磁珠＋目标菌＋量子点”的“三明治结构”,通过对结构条件优化确定2?种目标菌的检出限,并应用到市售无菌牛乳实际样品中进行加标回收率实验。结果：本研究证明所选取的2?条适配体与目标菌的结合具有高特异性,可实现对2?种目标菌的同时检测。对“三明治结构”优化结果表明：2?种目标菌的最佳捕获条件为免疫捕获时间45?min、磁分离时间2?min;适配体最适浓度为400?nmol/L;金黄色葡萄球菌检出限为101?CFU/mL,线性方程为Y=28.51X＋126.67（R2=0.973）;大肠埃希氏菌O157:H7检出限均为102?CFU/mL,线性方程为Y=92.86X－64.67（R2=0.987）,其中,Y为荧光强度,X为细菌菌落数的对数值,拟合度良好。且在牛乳样品中金黄色葡萄球菌和大肠埃希氏菌O157:H7回收率分别为94.6%～102.8%和93.4%～100.4%。结论：本研究所建立的方法能够实现同时对2?种食源性致病菌快速、高效检测,该方法易操作且灵敏度高,在食品加工生产安全检测方面具有良好的应用前景。     

Physiological changes of Escherichia coli O157:H7 and Staphylococcus aureus following exposure to high hydrostatic pressure

Morphological changes and membrane integrity of Escherichia coli O157:H7 and Staphylococcus aureus cells before and after high hydrostatic pressure (HHP) treatments (200–400 MPa) and time (1–5 min), at a constant temperature (40 °C), in peptone water were examined by using scanning electron microscopy (SEM) and fluorescent microscopy, respectively. SEM images showed that unpressurized cells exhibited a smooth surface appearance. E. coli O157:H7 cells exposed to pressure treatments first appeared larger, then with increasing pressure distorted with dimples and pinches. In case of S. aureus, the cells pressurized at low pressure levels did not show any significant change. The surface appearance became rough and cracked when the cells were exposed to higher pressure levels. Images of fluorescent microscopy showed that a small proportion of bacterial cells were not green fluorescent at lower pressure levels. The other part of the cell population was red fluorescent representing dead cells and the number of red fluorescent cells increased with increasing pressure. The cells with a yellowish color showed that varying levels of membrane damage occurred under HHP. The combinations of mild heat, antimicrobial substances and HHP treatment can be used to inactivate food borne pathogens of varying pressure resistance in the food industry for safe processing conditions. However, the resultant damaged cells at different levels should be taken into account during storage to prevent their recovery.     

Fate of Escherichia coli O157:H7 during silage fermentation

The survival characteristics of Escherichia coli O157:H7 in silage derived from contaminated grass were investigated. The survival of other enteric bacteria was also investigated to determine if E. coli O157:H7 demonstrates enhanced acid tolerance in comparison. Samples of chopped grass were treated as follows: (i) no additive (control); (ii) inoculation with E. coli O157:H7 to a final concentration of log10 4.0 CFU g(-1); (iii) addition of an 85% solution of formic acid at 3.0 ml kg(-1) grass; and (iv) addition of both E. coli O157:H7 and formic acid, at the above concentrations. Treated 6-kg grass samples were packed into laboratory silos, sealed, and stored at 15 degrees C for up to 180 days. Individual replicate silos were removed from storage periodically and subjected to microbiological and chemical analyses. Chemical analyses of the silage samples indicated that lactic acid-dominant fermentations, with a rapid drop in pH, occurred. Numbers of enteric bacteria decreased from log10 7.0 to 8.0 CFU g(-1) to undetectable levels within 19 days' storage. E. coli O157:H7 did not survive the silage fermentation process, with numbers declining from approximately log10 4.0 CFU g(-1) to undetectable levels within 19 days of ensiling. The pattern of decline in numbers of E. coli O157:H7 was the same as that for the enteric bacteria, indicating that under the conditions tested, the acid tolerance of E. coli O157:H7 was not significantly different from the acid tolerance of other enteric bacteria. This study found that E. coli O157:H7 did not survive a good silage fermentation process, indicating that properly ensiled grass that is correctly stored is unlikely to be a vector for the transmission of the pathogen among cattle.     

Impact of sodium chloride on Escherichia coli O157:H7 and Staphylococcus aureus analysed using transmission electron microscopy

Abundant literature information is available on sodium chloride, NaCl, as an antimicrobial and a preservative, however, information on NaCl effects on bacterial cell morphology is lacking. The effect of NaCl, on Escherichia coli O157:H7 and Staphylococcus aureus cells individually grown in a laboratory medium was examined using transmission electron microscopy (TEM). Cultures were grown in brain heart infusion (BHI) broth containing dissolved 0%, 5%, or 10% (w/v) commercially obtained fine (FN) and extra coarse (EC) grade granular NaCl. The pathogens were incubated at 35 degrees C for 12 and 24 h. Then, a mixture of five strains of each pathogen per treatment was prepared. Samples were centrifuged, pellets collected, fixed immediately with glutaraldehyde, and prepared for TEM examination. Cells morphology on TEM micrographs verified that the magnitude of morphological damage to E. coli O157:H7 cells was significantly greater than that of S. aureus cells. More cell injury occurred as NaCl concentration increased from 5% to 10%. Generally, S. aureus maintained its cellular structure and no severe cell wall or plasma membrane damage and/or shrinkage was observed. At 10% NaCl, the damage to E. coli O157:H7 cells was extensive, and the pathogen seemed to have lost its cellular integrity. Although NaCl affected the morphology of E. coli O157:H7 and S. aureus, the coarse grade of NaCl seemed to have a milder effect with respect to cell damage, especially on S. aureus. The 24 h-old cultures were more susceptible to NaCl treatment compared to the 12 h-old cells. Thus, the age of the cells has an impact on their resistance to salt--the environmental stressor.     

Modeling heat transfer and inactivation of Escherichia coli O157:H7 in precooked meat products in Argentina using the finite element method

The presence of Escherichia coli is linked with sanitary deficiencies and undercooking of meat products. Recent studies have detected E. coli O157:H7 in black blood sausages. Minimum time-temperature specifications to kill the bacteria were obtained by numerical simulations of the microscopic heat conduction equation using the finite element method, and calculating the temperature profile of the sausage and the population of E. coli at the coldest point during heating. The model was validated by heating sausages in a water-bath. The effects of heat transfer coefficients and water temperatures on the required time to achieve an inactivation value (IV) of 12(log) are reported. Macroscopic heat balances were simultaneously solved to consider the temperature drop in the water batch as a function of the ratio between the mass of thermally treated sausage and the heat capacity of the system.     

A note on Escherichia coli O157:H7 serotype in Turkish meat products

255 minced beef, 101 soudjouk and 50 uncooked hamburger samples were analyzed for the presence of Escherichia coli O157:H7 serotype. m-EC and LST broths were used as selective enrichment media and SMAC agar was used as a selective isolation medium. A total of 3 E. coli O157 were isolated by conventional culture techniques; one from each of minced beef, uncooked hamburger and soudjouk but none were identified as the H7 serotype. For determination of selective media-growing cohabitant bacteria, 2645 isolates were obtained from SMAC agar. Results showed that E. coli type 1, Hafnia alvei and Citrobacter freundii were dominant competitive flora. As selective enrichment broth-growing cohabitant microflora existed at higher levels, it was too difficult to isolate E. coli O157 from these mixed flora. Therefore, conventional methods are not suitable for these types of products, because of isolation difficulties and failure to confirm.     

Evaluation of high hydrostatic pressure sensitivity of Staphylococcus aureus and Escherichia coli O157:H7 by differential scanning calorimetry

Differential scanning calorimetry (DSC) was used to evaluate the relative high hydrostatic pressure (HHP) resistances of bacterial strains from Staphylococcus aureus and Escherichia coli O157:H7 in vivo. The total apparent enthalpy change and thermal stability were two DSC parameters used to compare bacterial strains of untreated control and pressure-treated bacteria. DSC thermograms indicated that ribosomal denaturation appears to be a major factor in cell death by both thermal and high pressure treatments. However, the analysis of calorimetric data for control samples as well as pressure-treated samples clearly showed that the sensitivities of bacteria to various physical stresses can be different. While S. aureus 765 had a relatively higher resistance to thermal treatment in comparison to S. aureus 485, S. aureus 485 was determined to be more resistant to pressure than S. aureus 765. This information can be utilized in the design of processes specific to targeting certain cellular components by using different physical stresses.     

Horizontal transmission of Escherichia coli O157:H7 during cattle housing

Ruminant livestock, particularly cattle, is considered the primary reservoir of Escherichia coli O157:H7. This study examines the transmission of E. coli O157:H7 within groups of cattle during winter housing. Holstein Friesian steers were grouped in six pens of five animals. An animal inoculated with and proven to be shedding a marked strain of E. coli O157: H7 was introduced into each pen. Fecal (rectal swabs) and hide samples (900 cm2 from the right rump) were taken from the 36 animals throughout the study. Water, feed, and gate or partition samples from each pen were also examined. Within 24 h of introducing the inoculated animals into the pens, samples collected from the drinking water, pen barriers, and animal hides were positive for the pathogen. Within 48 h, the hides of 20 (66%) of 30 cohort animals from the six pens were contaminated with E. coli O157:H7. The first positive fecal samples from the noninoculated cohort animals were detected 3 days after the introduction of the inoculated steers. During the 23 days of the study, 15 of 30 cohort animals shed the marked E. coli O157:H7 strain in their feces on at least one occasion. Animal behavior in the pens was monitored during a 12-h period using closed circuit television cameras. The camera footage showed an average of 13 instances of animal grooming in each pen per hour. The study suggests that transmission of E. coli O157:H7 between animals may occur following ingestion of the pathogen at low levels and that animal hide may be an important source of transmission.     

Fate of Escherichia coli O157:H7 in coleslaw during storage

An outbreak of Escherichia coli O157:H7 infection associated with the consumption of coleslaw in several units of a restaurant chain prompted a study to determine the fate of the pathogen in two commercial coleslaw preparations (pH 4.3 and 4.5) held at 4, 11, and 21 degrees C for 3 days. At an initial population of 5.3 log10 CFU/g of coleslaw, E. coli O157:H7 did not grow in either coleslaw stored at the three temperatures. Rather, the population of E. coli O157:H7 decreased by 0.1 to 0.5 log10 CFU/g within 3 days. The greatest reduction (0.4 and 0.5 log10 CFU/g) in population occurred at 21 degrees C, whereas only slight decreases (0.1 to 0.2 log10 CFU/g) occurred at 4 and 11 degrees C. A pH of 4.3 to 4.5 of coleslaw had little effect on reducing E. coli O157:H7 populations. Results suggest that the tolerance of E. coli O157:H7 to acid pH, not temperature abuse, is a major factor influencing the pathogen's fate in restaurant-prepared coleslaw.     

Survival of Escherichia coli O157:H7, Salmonella enteritidis, Staphylococcus aureus, and Listeria monocytogenes in Kimchi

The survival of gram-positive and gram-negative foodborne pathogens in both commercial and laboratory-prepared kimchi (a traditional fermented food widely consumed in Japan) was investigated. It was found that Escherichia coli O157:H7, Salmonella Enteritidis, Staphylococcus aureus, and Listeria monocytogenes could survive in both commercial and laboratory-prepared kimchi inoculated with these pathogens and incubated at 10 degrees C for 7 days. However, when incubation was prolonged, the S. aureus level decreased rapidly from the initial inoculum level to the minimum detectable level within 12 days, whereas Salmonella Enteritidis and L. monocytogenes took 16 days to reach similar levels in commercial kimchi. On the other hand, E. coli O157:H7 remained at high levels throughout the incubation period. For laboratory-prepared kimchi, the S. aureus level decreased rapidly from the initial inoculum level to the minimum detectable level within 12 days, and L. monocytogenes took 20 days to reach a similar level. E. coli O157:H7 and Salmonella Enteritidis remained at high levels throughout the incubation period. The results of this study suggest that the contamination of kimchi with E. coli O157:H7, Salmonella Enteritidis, S. aureus, or L. monocytogenes at any stage of production or marketing could pose a potential risk.     

Modeling the inactivation of Escherichia coli O157:H7 and generic Escherichia coli by supercritical carbon dioxide

In this study, supercritical carbon dioxide (SC-CO(2)) was applied in the inactivation of pathogenic Escherichia coli (E. coli) O157:H7 and generic E. coli. For both strains suspended in physiological saline (PS), colony forming units per ml were reduced by 8 log orders within 15-30 min, in a treatment range of 80-150 bar and 35-45 degrees C. Any significant differences between the two E. coli strains during the inactivation by SC-CO(2) were not noticed. The microbial inactivation curve, which was established by the modified Gompertz model describing the survival rate with treatment time, was divided into three distinct stages. When using cells in PS, k(dm), lambda and t(8) (the time for an 8-log reduction of cell counts) were 0 to 3 min(-1), 8 to 16 min and 11 to 29 min, respectively. The temperature-dependency of the microbial inactivation was verified via the correlation of the logarithm of k(dm) versus the inverse of temperature. We have observed lower inactivation rates in phosphate-buffered saline (PBS) than in PS, the lowered pH, and an increase of UV-absorbing substances in the cell suspension after SC-CO(2) treatment. Also, the deformation and collapse of the SC-CO(2)-treated cells were revealed by scanning and transmission electron microscopy, and the deactivation of cellular enzymes occurred. These all suggest that the inactivation of E. coli O157:H7 and generic E. coli was possibly caused in a concerted manner by acidification, damage to cell membranes and subsequent leakage of cellular materials, and the inactivation of cellular enzymes.     

Protective cultures inhibit growth of Listeria monocytogenes and Escherichia coli O157:H7 in cooked, sliced, vacuum- and gas-packaged meat

Contamination of cooked meat products with Listeria monocytogenes poses a constant threat to the meat industry. The aim of this study was therefore to investigate the use of indigenous lactic acid bacteria (LAB) as protective cultures in cooked meat products. Cooked, sliced, vacuum- or gas-packaged ham and servelat sausage from nine meat factories in Norway were inoculated with 10(3) cfu/g of a mixture of three rifampicin resistant (rif-mutant) strains of L. monocytogenes and stored at 8 degrees C for four weeks. Growth of L. monocytogenes and indigenous lactic acid flora was followed throughout the storage period. LAB were isolated from samples where L. monocytogenes failed to grow. Five different strains growing well at 3 degrees C. pH 6.2, with 3% NaCl, and producing moderate amounts of acid were selected for challenge experiments with the rif-resistant strains of L. monocytogenes. a nalidixic acid/streptomycin sulphate-resistant strain of Escherichia coli O157:H7 and a mixture of three rif-resistant strains of Yersinia enterocolitica O:3. All five LAB strains inhibited growth of both L. monocytogenes and E. coli O157:H7. No inhibition of Y. enterocolitica O:3 was observed. A professional taste panel evaluated cooked, sliced, vacuum-packaged ham inoculated with each of the five test strains after storage for 21 days at 8 degrees C. All samples had acceptable sensory properties. The five LAB strains hybridised to a 23S rRNA oligonucleotide probe specific for Lactobacillus sakei. These indigenous LAB may be used as protective cultures to inhibit growth of L. monocytogenes and E. coli O157:H7 in cooked meat products.