羊毛活性/分散染料染色染料相互作用研究

在一定工艺条件下，用活性染料染羊毛，再用分散染料套染，其K／S值大于单独使用活性和分散染料染色的K／S值之和，活性染料对羊毛起到了改性作用，使分散染料染色湿牢度有显著提高。随着活性染料浓度的增加，分散染料的上染率也增加。用分散染料套染活性染料，其匀染性相对于单独使用活性染料有提高。     

Desorption and transfer processes in different classes of dyes

We report an analytical approach to study dye desorption and transfer processes in aqueous environment. The study was conducted simulating standard laundry washes using two different donor textiles, a polyester textile dyed with Disperse Blue 79 and a cotton textile dyed with Reactive Red 239, and two acceptor textiles, undyed cotton and polyester, respectively. Dye bleeding/solubilization from a donor textile to the solution was investigated through UV–visible absorbance analysis, while the dye absorption onto acceptor textile was quantified by UV–visible reflectance analysis. Dye desorption and transfer processes were investigated in water and surfactant solutions at different concentrations. A desorption and transfer model for the two classes of dyes was hypothesized by performing kinetic experiments. The results show that both processes depend on the presence of surfactants for the disperse dye. Conversely, the presence of surfactants has little effect on the reactive dye. Finally, the presence of an acceptor polyester significantly increases the bleeding of the disperse dye, while the presence of an acceptor textiles less influences the total release of the reactive dye.     

浅谈分散染料与活性染料复配技术

通过溶解度参数预测分散染料之间以及染料与纤维的相互作用,筛选和设计复配染料的组分。通过测试活性染料特征值S、E、R、F以及无机性值(I)/有机性值(O)的比值,决定单一染料的组成。运用上述两种方法预测复配染料中每一染料的性能,再通过应用实验验证,是复配技术最为有效和简便的方法。本文除了为染料企业制造复配染料提供了一项技术,也为染料应用者在三原色以外如何选用拼色中的补充染料提供了可靠的依据。     

Direct Contact Membrane Distillation Applied to Colored Reactive or Disperse Dye Solutions

The influence of dye class and chromogen groups of dyeing wastewaters composed by reactive or disperse dyes with different colors on direct contact membrane distillation (DCMD) was investigated. The state‐of‐the‐art shows that disperse dyes and different dye colors are not studied in DCMD and the application of DCMD for dyeing wastewater treatment is limited to a few publications. High color rejection was obtained and water was recovered at the permeate side for feed solutions containing reactive or disperse dye. Influence of chromogen groups (colors) was not observed, whereas the class dye was decisive for the process performance. Reactive dyes showed higher mean permeate flux due to the repulsion between their anionic groups and the negative surface of the membrane. Partial wetting of larger pores allowed the passage of small disperse dye molecules, reducing color rejection.     

超临界CO2流体中染料溶解度研究进展

综述了超临界CO2流体中染料溶解度的测试装置与方法。分析了超临界CO2流体工艺参数与染料化学结构对分散染料溶解度的影响规律；总结了国内外近二十年的分散染料在超临界CO2流体中溶解度数据，并介绍了分散染料在超临界CO2中的溶解度增溶技术。指出加强染料结构对其溶解性能作用原理及影响规律剖析，超临界CO2中染料溶解行为数据库构建，染料拼色与配色研究三方面为未来的研究重点。     

One‐bath union dyeing of wool/polytrimethylene terephthalate blends†

The one‐bath dyeing of blends of polytrimethylene terephthalate (PTT) staple and wool has been investigated. The exhaustion of selected Terasil disperse dyes on PTT fibre and Lanasol reactive dyes on wool was measured as a function of temperature, together with the cross‐staining of the Terasil dyes on the wool component and the Lanasol dyes on PTT component. Most Terasil disperse dyes achieved satisfactory dye uptake on PTT at 110 °C, whereas on conventional polyester (polyethylene terephthalate) temperatures of up to 130 °C are required. An optimised union‐dyeing technique for wool/PTT blends was developed which minimised the staining of Terasil disperse dyes on wool and produced dyed goods with high levels of wet colour fastness. Carriers were not required to enhance the dyeability of PTT at low temperatures. The wool component appeared to be protected against damage at 110 °C by the reactive dyes. The results indicate the potential for blending PTT fibre and wool to produce fabrics that are easier to dye at lower temperatures than conventional wool/polyester blends.     

The printing of polyester/cellulose blends-a new approach

This paper introduces a new dye system for the printing of polyester/cellulose blends. The new system is based on a combination of disperse dyes containing diester groups and reactive dyes containing a monochloro-s-triazinyl reactive group. By reference to published work on the reaction mechanism of monochloro-s-triazinyl reactive dyes with cellulose the development of a new approach to bring about reactive dye fixation in essentially neutral pH conditions is discussed. Practical application details of the new dye system are emphasised.     

Dye–fibre bond stabilities of some reactive dyes on cotton

Cotton fabric dyed with commercial reactive dyes of the monochloro-s-triazine, bis(monochloro-s-triazine), and bis(monofluoro-s-triazine) type was treated in buffer solutions pH 10 and 12 at 60, 85 and 98°C. Hydrolysis has been investigated using spectrophotometrical measurements of hydrolysed dye at λ_max. The percent of hydrolysed dye was calculated.     

酸性染料可染聚酯纤维的研究

采用对苯二甲酸(PTA)、乙二醇(EG),在三氧化二锑催化的条件下进行酯化反应,然后加入制备好的中间体,进行缩聚反应,合成出了含有酰胺基结构的酸性染料可染聚酯。使用红外光谱对其分子结构进行表征,同时研究了酸性染料可染聚酯的纺丝工艺及染色性能。结果表明:酸性染料可染聚酯分子骨架上含有酰胺基结构;酸性染料可染聚酯纤维的酸性染料上染率可以达到80%以上,分散染料上染率可以达到90%以上,具有较好的酸性染料可染性和分散染料可染性。     

Deep‐coloured polyester/cotton blends with low concentrations of polymethylol dyes by a one‐pass continuous dyeing process

An obvious limitation of the one‐pass continuous dyeing process for polyester/cotton blends is its inability to achieve deep colour depth, which is caused by the low dye fixation yields of commercial reactive dyes. In this study, the performances of polyester/cotton blends dyed with high‐fixation polymethylol dyes and disperse dyes were compared with those of polyester/cotton blends dyed with a mixture of reactive dyes and disperse dyes. Polymethylol dyes were observed to be suitable for dyeing polyester/cotton blends when used in low concentrations; the required concentrations of polymethylol dyes were only 23–58% of the concentrations of commercial reactive dyes required to reach a given colour level on polyester/cotton blends. The wash and crocking fastness of polyester/cotton blends dyed with polymethylol dyes were similar to those of polyester/cotton blends dyed with reactive dyes.     

多活性基活性染料及其拼混应用

活性染料已成为最重要的染料类别，多活性基染料是染料的发展方向。本文叙述了常见几类活性基团的特性以及活性基团间桥接基对染料性能的影响。两类多活性基染料已具有商业价值：根据染料的相客性、染色条件以及染料的结构特性来选择拼混染料。不同类染料可以进行拼混。两种相同活性基团的多活性基染料的拼混可以得到很好的拼混染料，国外已经提出并发表了多种类型的拼混情况。拼混应用已成为活性染料重点研究的方向之一。     

聚对苯二甲酸丙二酯纤维的染色性能

根据Shell公司和Dystar公司的研究,用Optidye系统从分散染料吸附与上染率、染色温度、pH值、匀染性及染色牢度等方面解析了聚对苯二甲酸丙二酯(PTT)纤维的染色性能。PTT纤维在100℃就可染到深色,在60～80℃和90～100℃有两个吸附速度较快区域;PTT纤维属易染型纤维,在最高温度染保持30～40min即可。高温型分散染料在120℃染色,常压100℃染色无需pH值调节。分散染料染色牢度(洗涤、摩擦及耐光)非常好。     

噻唑型偶氮分散染料合成研究

本文以2-氨基-4-氯-5-醛基噻唑为重氮组分合成了一系列含醛基分散染料,进而与合活泼亚甲基的化合物缩合得到一系列含氰乙烯基的分散染料.对染料结构进行了表征,并测试了染料的吸收光谱.结果表明氰乙烯基的引入使得λmax和εmax都有所增大.     

混合染料的相互作用机理研究

利用模拟混合染料废水,分析了阳离子蓝FGL与酸性、活性、直接、阳离子、分散5种染料混合后的颜色变化机理和染料之间的作用。结果表明:阳离子蓝FGL基本上能与含磺酸基的酸性、活性和直接染料按电荷摩尔比发生作用,与同类的染料不会发生反应,与分散橙SE-B也会通过库仑力发生反应。混合液的色度在有沉淀生成时会变小,这样将节约废水处理的成本。     

Developing chromic dyeable PET nanocomposites: The dye absorption and complex formation mechanisms

This research aimed to investigate the possibility of enhancement of polyethylene terephthalate (PET) dyeability using nanotechnology. Different kinds of disperse, acidic, and chromic dyes were used for dyeing of produced PET/silver nanocomposite fine multifilament yarns produced at the take up speeds of 3000 m min⁻¹ and their prepared fabrics. Dyeability improved by using acidic dyes. However, the more promotion effect was achieved by chromic dyes. No effect on absorption of disperse dyes revealed that no physical effect can be considered for dye absorption. The electrostatic interaction between silver and acidic dye molecules and forming the coordinative bonds with chromic dye molecules on nanocomposite yarns and fabrics were concluded and thoroughly discussed. Applying chromic dye with the more potential of creating coordinative bonds intensified the improvement of dyeability. Optimized silver ratio for the dyeability enhancement was affected by the mechanisms of dye absorptions discussed and proven by investigating dye concentrations in the effluent baths after the dyeing processes. It has been found that the steric hindrance is the key factor for absorption of chromic dyes; however, it is different in the case of acidic dyes, well discussed according to the dye absorptions mechanisms. The results can be also considered as evidence to prove forming the coordinative bonds with chromic dye molecules. This has also been confirmed by appearing a bathochromic shift in the absorption peaks by increasing dyeability using chromic dye. © 2012 Wiley Periodicals, Inc. J Appl Polym Sci, 2012     

Influence of Nonionic Surfactant on Hydrolysis of Vinyl Sulfone Reactive Dye

Nonionic surfactants are widely used in reactive dyeing processes, and the interaction between surfactants and reactive dyes affect the hydrolytic property of reactive dyes. In this study, reactive brilliant blue KN‐R (C.I. reactive blue 19) was employed as a model dye, and fatty alcohol polyoxyethylene ether (AEO‐9) was selected as a model nonionic surfactant. The interaction was first investigated in aqueous solutions by a UV‐spectrophotometry method, then the effect of surfactant concentration on the hydrolytic behavior of KN‐R was studied using high performance liquid chromatography method. Below the critical micelle concentration, the surfactant served as dispersant; the hydrolysis of reactive dye was accelerated. However, when the concentration of surfactant was above its critical micelle concentration, the dye was solubilized into the micellar phase, which was revealed from the changes in absorbance intensity and wavelength of the maximum absorbance. This led to slowed hydrolysis of reactive dye. These findings are useful in understanding the effect of concentration of nonionic surfactant on the hydrolysis of vinyl sulfone reactive dyes.     

近年美国染料工业概况

美国染料工业持续下滑,染料产量由2000年的16.6万吨下降到2003年的11.9万吨,占世界染料总量的9.7%,生产的染料有24%出口;其价格连续走低;染料的消费量也逐年下滑,2003年的表观消费量为18.4万吨,折百约为13.2万吨,消费量为世界消费总量的12.7%,其中进口量超过50%,在进口染料中超过40%来自中国和印度。在美国进行化学合成的染料只有酸性和活性,其余均为进口原染料进行加工或商品化,占染料生产量的75%～80%。经过6年的分化重组,美国染料生产商的主体是德司达、汽巴和科莱恩等跨国公司。纺织印染工业萎缩和进口冲击、染料产品利润空间的急剧缩小、环境因素是造成美国染料工业不景气的主要原因。     

Neutral dyeing of wool and wool/polyester blend fabrics using sulphatoethylsulphone reactive‐disperse dyes

Two models of temporarily anionic sulphatoethylsulphone reactive disperse dyes were applied to wool, polyester and wool/polyester blend fabrics at different dyeing pH. Maximum exhaustion values and colour yield were observed at pH 7. The results showed that reactive disperse dyes containing bis‐sulphatoethylsulphone reactive groups were more convenient for neutral dyeing of wool and wool/polyester blend fabrics if compared with a dye containing a mono‐sulphatoethylsulphone group. Excellent to very good wet fastness properties on all dyed fabrics were achieved.     

VIS absorption spectrophotometry of disperse dyes

In the investigations of the dyeing processes, the low solubility of disperse dyes in water represents a practical problem for the determination of dye concentration in dyebaths and waste waters. Therefore the use of an organic solvent which, dissolves disperse dyes, is recommended in visible spectrophotometry of disperse dyes. Three organic solvents (ethanol, N,N-dimethylformamide, acetone) and two disperse dyes, the disazo dye C.I. Disperse Orange 29 and the anthraquinone dye C.I. Disperse Blue 56, were used for spectroscopic analysis in this present work. The absorbance of aqueous dye dispersions and various organic solvent dye solutions was measured to evaluate the effect of the solvent on the shape and intensity of the absorption spectra and on the wavelength shift of maximum absorption. The validity of Beer–Lambert’s law in each system was ascertained. A suggestion is made how VIS absorption spectrophotometry can be used to determine the dye concentration in disperse dyebaths. The addition of organic solvent to the dyebath leads to dye dissolution, and the Beer-Lambert’s law is then fulfilled. The optimum ratio between the dyebath dispersion and the organic solvents for the dyes investigated is also determined.     

Removal of Acidic and Basic Dyes from Water using Crosslinked Polystyrene Based Quaternary Ethyl Piperazine Resin

In this study, a beaded polymer with quaternary amine functions was prepared in two steps, starting from poly (vinyl benzyl chloride-ethylene glycol dimethacrylate) (PVBC) based beads, according to the synthetic protocol; modification of ethyl piperazine with PVBC (EP-PS), and quaternization of ethylpiperazine modified beads with chloroacetic acid (QEP-PS). The QEP-PS resin was used for the removal of reactive red 120 as an acidic dye and malachite green chloride as a basic dye. Dye extraction experiments were carried out simply by contacting wetted sorbent samples with aqueous dye solutions at room temperature. Capacities were determined by colorimetric analysis of the residual dye contents. The resin showed that reasonable high dye sorption capacity (0.34-0.41 g per gram of dry resin) was achieved. The adsorption conditions (initial dye concentration and pH) were varied to evaluate the mechanism of adsorption of both basic dyes and acidic dyes on the prepared resin. This material is also able to remove both the anionic dye and cationic dyes completely even from highly diluted aqueous dye solutions.