添加淀粉对马铃薯米粉品质的影响

研究3种常用淀粉对马铃薯米粉品质的影响,为马铃薯米粉加工提供参考依据。分别将0%、5%、10%、15%、20%和25%的玉米、小麦和马铃薯淀粉添加到马铃薯全粉占比30%的米粉中,测定米粉蒸煮、色差、质构和拉伸性能指标的变化。结果:添加不同淀粉使得米粉的含水量显著减小(p<0.05);玉米、小麦以及5%~20%马铃薯淀粉可使米粉透射比显著增大(p<0.05);10%玉米淀粉能使碘蓝值显著增大(p<0.05);添加10%玉米、5%小麦以及5%~20%马铃薯淀粉,能使吐浆值显著减小(p<0.05);但3种淀粉对断条率影响均不显著。添加10%玉米、10%小麦和5%马铃薯淀粉能使米粉亮度L*显著减小(p<0.05),色度值a*和b*亦发生不同改变。5%~15%玉米淀粉可有效改善米粉硬度、峰值负载,但添加量达到20%时峰值负载形变量显著减小(p<0.05);小麦淀粉可改善弹性,添加10%~15%可有效改善硬度,15%和20%可改善峰值负载和咀嚼性;马铃薯淀粉可提高米粉硬度,但添加量达20%时米粉变得黏连。在实际生产中建议玉米和小麦淀粉添加量分别为5%和10%。     

Influence of wheat flour substitution with potato pulp on dough rheology,microstructure and noodle quality

The effects of potato pulp (0–40%) on dough rheology and microstructures, as well as noodle quality, were investigated in this study. Substitution of wheat flour with potato pulp led to a decrease in β-sheet content, an increase in α-helix and unordered content for protein in dough, as well as a drop of the storage and loss modulus, which was mainly caused by the weakening of dough gluten strength. Scanning electron microscopy confirmed that the gluten–starch network could no longer to be observed for the formulated dough containing 30–40% potato pulp. Structural damage of dough induced the increases in optimal cooking time, cooking loss and adhesiveness, and a decrease in cohesiveness of cooked noodles. However, the samples with 20% potato pulp addition showed higher values in water absorption, hardness, springiness and chewiness, indicating that noodles with potato pulp content below 20% were acceptable.     

马铃薯全粉在面条中的应用研究

将马铃薯全粉添加到小麦粉中,并辅助添加谷朊粉,制成马铃薯全粉面条。从质构特性、微观结构和面条的理化性质三个层面对三个不同马铃薯全粉添加比例的面条组别进行研究,发现马铃薯全粉对面团的力学性质,面筋网络的形成和构造以及面条的蒸煮参数和外观都会产生一定的影响。结果表明：马铃薯全粉添加量为20%（g/g）,谷朊粉添加为0.03%（g/g）时,总体指标最好;马铃薯全粉对面团的作用具有双向性,马铃薯淀粉对面团的影响偏负向,但是其中的多糖和蛋白质可能对面团和面筋网络有正向影响,同时谷朊粉的添加对面团的稳定性和面条的质量有改善作用。     

不同蛋白对马铃薯面条食用品质的影响

本研究通过在马铃薯面条原料粉中添加一定比例小麦蛋白、花生蛋白、大豆蛋白制作面条,探讨了三种蛋白对马铃薯面条食用品质的影响。结果表明:三种蛋白均会降低马铃薯面条的亮度值,且随蛋白添加量的增加,马铃薯面条亮度值降低,但大豆蛋白对马铃薯面条亮度值的影响小于小麦蛋白和花生蛋白。同时,三种蛋白均可显著改善马铃薯面条的食用品质,降低其蒸煮损失,增强其拉伸阻力、硬度、粘合性和咀嚼性,且小麦蛋白对面条品质的改善作用最为显著,大豆蛋白次之。扫描电镜结果表明,添加小麦蛋白后马铃薯面条面筋网络形成更加致密,空隙率更小。电子鼻检测结果表明,小麦蛋白和花生蛋白对马铃薯面条的气味无显著影响,而大豆蛋白会使马铃薯面条中的氮氧化合物等豆类腥味物质增加。由此可见,三种蛋白中,小麦蛋白对马铃薯面条的食用品质改善效果最佳。     

Characteristics of Noodle Prepared from Orange-fleshed Sweet Potato,and Domestic Wheat Flour

Noodle characteristics prepared from both 100% of domestic and imported wheat flour (as a control) and blended with 40% of orange-fleshed sweet potato paste were studied. The domestic wheat flour had higher protein content (13.8%), compare to imported wheat flour (11.7%), thus giving the highest protein content (18.86%) in noodle prepared from 100% domestic wheat flour. However its noodle colour was disliked due to a lower whiteness level compared to imported wheat flour. Blended 60% of domestic wheat flour with 40% of sweet potato paste could improve the noodle colour acceptance. The noodles prepared from both 100% wheat flours and blended with 40% sweet potato paste had met the national standard quality for moisture and protein content. This suggests that sweet potato paste is promising for noodle ingredients as a wheat flour substitute.     

小麦粉中蛋白质和淀粉含量对面条品质的影响

对小麦粉中的蛋白质和淀粉组分进行了分离,将淀粉含量不同的混合粉制作成面条,分析其质构特性和食用品质。将面条煮制后,对熟面条进行了质构分析,测定了熟面条的硬拉伸性能、剪切性能和蒸煮损失,并进行了感官品质评价。研究结果表明:随着小麦粉中的淀粉含量的增加(蛋白质含量的降低),面条的质构特性、拉伸性能、剪切性能都呈现显著下降的变化趋势(P<0.05),而面条的蒸煮损失显著增加(P<0.05)。此外,面条的感官评价与质构分析的结果相一致。     

Utilization of rice starch with gums in Asian starch noodle preparation as substitute for sweet potato starch

Starch noodles were produced using a medium grain rice starch in the presence of various gums, and physical properties of the noodles were compared with sweet potato starch noodle. Pasting viscosity of the rice starch was lower than that of sweet potato starch (830 vs. 1,618 cp as peak viscosity). The peak viscosity, however, was increased by the addition of gums (0.1% based on dispersion), and especially xanthan was the most effective in increasing the peak viscosity (1,478 cp). The cooking loss for the rice starch noodles (1.5 mg/mL), greater than that for the sweet potato starch noodle (0.2 mg/mL), was effectively reduced to 0.8 and 0.9 mg/mL, respectively, by the addition of locust bean gum (LBG) and curdlan. The addition of LBG or gellen gum also increased the hardness of the rice noodles. Aging (extended retrogradation) the noodles was effective in reducing the cooking loss and improving the textural properties of the rice starch noodles. The combination of the gum addition (like LBG) and aging of the rice starch noodle might be useful for utilizing rice starch as a substitute for sweet potato starch in Asian noodle preparation.     

Studies on noodle quality of potato and rice starches and their blends in relation to their physicochemical, pasting and gel textural properties

The physicochemical, pasting, and gel textural properties of potato and rice starches and their blends were studied in relation to their noodle making performance. Amylose content, swelling power and solubility values of potato starch were significantly (P ≤ 0.05) higher than for rice starch. Pasting properties showed higher peak, final and setback viscosity for potato starch as compared to rice starch. Texture profile analysis revealed that potato starch gel had higher hardness, cohesiveness and chewiness as compared to rice starch gel. Potato starch noodles showed higher cooked weight and cooking loss and were scored higher by sensory panellists especially with respect to transparency and slipperiness. On the other hand, rice starch noodles were more firm with lower cooking loss. Addition of potato starch to rice starch significantly (P ≤ 0.05) affected the noodle characteristics. Among the starch blends studied, blending of potato and rice starch in the ratio of 1:1 resulted in good quality noodles in terms of their lower cooking time, higher cooked weight, transparency and slipperiness. The results revealed the possibility of blending of potato starch with rice starch in equal proportions to produce noodles of acceptable quality.     

三种马铃薯复合变性淀粉对马铃薯面条的物性及品质的影响

将马铃薯全粉与面粉按不同比例配成混合粉以制作面条,并用马铃薯复合变性淀粉提升面条的品质;通过对不同比例混合粉糊化特性,面条断条率、烹调损耗、物性、烹调特性和感官评定的研究,得出制作面条的最优马铃薯全粉:面粉质量比和预糊化交联淀粉、氧化交联淀粉、酯化交联淀粉的添加量。结果表明,最优的质量比为20:80 (w/w);添加马铃薯复合变性淀粉对马铃薯面条的弹性、黏着性等都有显著影响(p<0.05);在烹调实验中,随着预糊化交联淀粉、氧化交联淀粉、酯化交联淀粉的增加,吸水率升高,当三者的添加量分别为5%、4%、5%时,浊度最低;感官评定实验中,当添加5%预糊化交联淀粉、4%氧化交联淀粉、6%酯化交联淀粉时,马铃薯面条的各指标评分之和最高,且分别为:31.2、33.1、34.6。从质构,烹调特性,感官特性等方面综合对比三种马铃薯复合变性淀粉对马铃薯面条的影响,得出6%酯化交联淀粉最适宜。     

慈姑淀粉添加量对鲜面条品质的影响

目的:探究慈姑淀粉对鲜面条品质的影响,将不同比例的慈姑淀粉添加入麦芯粉中制得鲜面条。方法:对所制鲜面条蒸煮特性、色泽、感官品质、质构特性及挥发性风味成分等进行测定。结果:随着慈姑淀粉添加量增多,鲜面条的吸水率、断条率、蒸煮损失率整体呈上升趋势,风味物质、硬度和弹性增大,但咀嚼性、胶黏性、感官品质降低;慈姑淀粉添加量为5%时鲜面条感官品质最佳,其最佳蒸煮时间为4.5 min,面条断条率为0%,蒸煮损失率为5.28%,吸水率为70.09%,色差△E^*为2.31,GC-MS检测表明慈姑淀粉鲜面条中富含烃类、醇类等风味物质。结论:添加适量的慈姑淀粉可以改善鲜面条品质。     

薯类淀粉种类对黄冈鱼面品质的影响

为研究薯类淀粉种类对黄冈鱼面品质的影响,测定了红薯淀粉（SPS1、SPS2、SPS3）、马铃薯淀粉（PS）、木薯淀粉（CS）的理化性质、糊化特性、粒径、溶解度及膨胀度,分析了这些性质与鱼面品质之间的关系。结果表明:不同薯类淀粉的理化性质、糊化特性、粒径、溶解度及膨胀度均存在显著差异（P<0.05）,红薯淀粉的糊化温度（78.37~79.97 ℃）最高,马铃薯淀粉的粒径、溶解度及膨胀度最大。不同薯类淀粉加工鱼面的质构特性、煮制品质、感官评价及色泽均存在显著差异（P<0.05）。红薯淀粉加工鱼面的硬度显著大于马铃薯淀粉、木薯淀粉（P<0.05）,红薯淀粉中SPS3加工鱼面的硬度最大。马铃薯淀粉加工鱼面的拉伸强度、吸水率及煮制损失率最大。SPS2加工鱼面的感官评价最高,CS加工鱼面的最低。不同薯类淀粉加工鱼面干燥前的色泽在亮度、红绿值和白度上差异显著（P<0.05）,但对鱼面干燥后的色泽影响并不明显。根据综合评分的大小对鱼面的品质进行排序为:SPS2>SPS1>SPS3>PS>CS。淀粉的糊化特性、直链淀粉含量、粒径与鱼面的品质具有显著的相关性（P<0.05）。     

天然马铃薯、木薯和玉米淀粉添加对发酵挂面品质的影响

为解决市售发酵挂面存在爽滑性差、粘弹性差、蒸煮时间长的问题,本文以单因素实验的方法,研究了马铃薯淀粉、木薯淀粉和玉米淀粉对发酵挂面蒸煮特性、质构特性以及感官评价的影响.结果表明:添加天然薯类和谷物淀粉均可以改善发酵挂面的蒸煮及质构品质,提高感官评价得分,尤其能够缩短最佳蒸煮时间,同时结合质构和感官实验数据分析,添加10...     

粒度对马铃薯泥面条品质的影响

本研究通过磨浆时间和磨浆强度控制马铃薯泥的粒度,探讨粒度对马铃薯面条的外观色泽、蒸煮品质、质构品质的影响,为马铃薯泥面条的生产提供数据支持。结果表明:随着磨浆强度的增加,时间的延长,马铃薯泥的粒度逐渐变小;马铃薯泥具有明显的双峰粒度分布,大颗粒所占比例比小颗粒所占比例高;马铃薯泥在扫描电镜下,呈片状结构,片与片镶嵌在一起,随着马铃薯粒度的降低,片的厚度不断变薄,片的尺寸也不断变小;随着粒度的降低,马铃薯面条的L*值降低,a*值和b*值升高,面条A的L*、a*、b*值与面条B、C、D、小麦粉面条的对应L*、a*、b*值具有显著性差异(p<0.05),而面条B、C、D的L*值之间没有显著性差异(p>0.05)。随着粒度的降低,马铃薯面条的烹调损失率均呈上升趋势,从9.38%增加至10.16%;马铃薯面条的断裂距离显著高于小麦粉面条(p<0.05),不同粒度的马铃薯面条断裂距离没有显著性差异(p>0.05);马铃薯面条煮后黏度随着粒度的减小而减小;总体来说,马铃薯泥的粒度对其面条的品质显著的影响,粒度中位径d(0.5)为130 μm的马铃薯面条品质好。     

Characteristics of yellow alkaline noodles prepared from Korean wheat cultivar

Physicochemical properties of Korean wheat flours were evaluated to determine the effect of flour characteristics on yellow alkaline noodles by comparing commercial and imported wheat flours. Optimum water absorption, thickness, and color of noodle dough significantly correlated with protein content-related parameters of flour. Korean waxy wheats showed shorter cooking time (8 min) and softer texture of cooked noodles than other Korean wheats. Cooking time significantly correlated with protein content, optimum water absorption, and thickness of noodle dough. Hardness of cooked noodles positively correlated with protein content (r=0.614, p<0.01) and protein content related parameters. Cohesiveness of cooked noodles positively correlated with SDS-sedimentation based on a constant protein weight (r=0.437, p<0.05). Several Korean wheat cultivars showed comparable noodle making properties to commercial flour for yellow alkaline noodles despite of dark noodle color. Wheat cvs. Baekjoong, Jeokjoong, and Ol had softer and more elastic texture than other Korean wheats.     

粒径和面筋蛋白含量对面条中淀粉体外消化性的影响

为研究粒径和面筋蛋白含量对面条中淀粉体外消化性的影响,在不同粒径的小麦面粉中分别添加0%、5%和10%的面筋蛋白制作中式面条,烘干研磨后分离出大颗粒与小颗粒面条,研究面条样品的形貌特征、结构特性热力学特性和淀粉体外消化特性。结果表明,随着面条中面筋蛋白含量增加,面条表面的平滑度增强,糊化温度升高而焓值降低,且蒸煮后面条中形成的面筋网络面积增加。体外消化动力学结果显示随着面粉粒径的减小或面筋蛋白含量的增大,淀粉消化程度降低。     

高添加苦荞面条的配方优化及其抗氧化活性分析

优化高添加苦荞面条的配方并研究其抗氧化活性。采用单因素实验和响应面试验,以综合评分为考察指标,确定高添加苦荞面条的最优配方;测定面团的热机械特性和面条蒸煮特性及其抗氧化活性。结果表明,高添加苦荞面条的最佳配方是:苦荞添加量62%、面粉添加量38%、蔗糖酯添加量0.4%、食用碱添加量0.2%、魔芋胶添加量0.4%、食盐添加量2%。改良组的面团蒸煮稳定性（C4/C3）优于纯小麦面条组,采用该配方制备的高添加苦荞面条（即改良组）综合评分最高。总酚含量及体外抗氧化活性结果显示,改良组面条的总酚含量及抗氧化能力显著高于纯小麦面条（P<0.05）,其中,改良组的总酚含量为9.11 mg GAE/g,DPPH·清除率为70.55%,ABTS+·清除率为87.73%;而纯小麦面条的总酚含量及DPPH·、ABTS+·清除率分别为1.11 mg GAE/g、36.70%、9.10%。通过蒸煮特性结果可以得出,无改良剂的苦荞面条其蒸煮损失率、断条率及面汤浑浊度显著大于纯小麦面条（P<0.05）,而改良组的蒸煮损失率、断条率与纯小麦面条差异不显著（P>0.05）,但面汤浑浊度差异显著。因此,本文优化后的高添加苦荞混合粉具有较高抗氧化活性及面条加工适性。     

薯类粉条中与淀粉相关的结构性质研究

为了解薯类淀粉粉条结构特点,选取3种木薯淀粉(SC9、SC205、LMC),3种淮山淀粉(GY2、SFY、MPY)和1种红薯淀粉(XSSP)制成的粉条为研究对象,对其色泽、微观样貌、结晶结构进行测定和比较。结果表明,各粉条的色泽、微观样貌、结晶结构差异显著。星树红薯粉条色泽最好,而双峰淮山粉条色泽较暗。淮山粉条和红薯粉条存在部分还未完全糊化的淀粉颗粒,呈现出清晰的团粒结构,木薯粉条的糊化程度最高,淀粉的团粒结构已基本消失,SC9木薯粉条可以看到均匀完整的网络结构。粉条的结晶结构均遭到破坏,不同品种薯类粉条的有序结构与无序结构比例有明显差异。     

Effects of different crop starches on the cooking quality of Chinese dried noodles

To investigate the effects of seven starches made from different crop sources on noodle quality, Chinese dried noodles made from various reconstituted flours were prepared and analysed. Potato starch had better solubility and swelling power than the other starches, leading to higher water absorption, cooking loss and breakage ratio of the potato starch noodles. The correlation results unravelled that the cooking breakage ratio of noodles presented positive correlations with solubility, swelling power, peak viscosity (PV), trough viscosity (TV) and final viscosity (FV) values of starches. Besides, the adhesiveness of noodles showed a positive correlation with conclusion temperature (T_c) and setback viscosity (SV) values of starches. Moreover, the peak temperature (T_p) value of starches was negatively correlated with cooking loss; the granule size of starches had a positive correlation with noodles water absorption; and the peak time (PkT) value of starches represented positive relationships with noodles chewiness, shearing force and breaking strength.     

微波调理食品——牛乳鱼糜面条的研制

以鲢鱼、奶粉、土豆淀粉为主要原料,制作牛乳鱼面,研究牛乳鱼面的去腥工艺及配方。并对鲢鱼肉去腥进行研究。通过正交试验、感官评价,得出去腥效果的最佳组合为茶多酚浓度0.5%、浸泡时间20 min、浸泡温度20℃。牛乳鱼面的最佳配方为每百克鲢鱼肉添加鱼汤120 mL、土豆淀粉50 g、食盐3 g、奶粉10 g、海藻酸钠0.4 g。研制出营养丰富、色泽乳白、口味鲜香,富有弹性的新型鱼肉面条。面条经过调味、冷冻后,直接用微波加热即可食用。