Development and optimisation of VFA driven DEAMOX process for treatment of strong nitrogenous anaerobic effluents.

The recently proposed DEAMOX (DEnitrifying AMmonium OXidation) process combines the anammox reaction with autotrophic denitrifying conditions using sulphide as an electron donor for the production of nitrite from nitrate within an anaerobic biofilm. This paper firstly presents a feasibility study of the DEAMOX process using synthetic (ammonia + nitrate) wastewater where sulphide is replaced by volatile fatty acids (VFA) as a more widespread electron donor for partial denitrification. Under the influent N-NH+4/N-NO3(-) and COD/N-NO3(-) ratios of 1 and 2.3, respectively, the typical efficiencies of ammonia removal were around 40% (no matter whether a VFA mixture or only acetate were used) for nitrogen loading rates (NLR) up to 1236 mg N/l/d. This parameter increased to 80% by increasing the influent COD/N-NO3(-) ratio to 3.48 and decreasing the influent N-NH4 +/N-NO3(-) ratio to 0.29. As a result, the total nitrogen removal increased to 95%. The proposed process was further tested with typical strong nitrogenous effluent such as reject water (total N, 530-566 mg N/l; total COD, 1530-1780 mg/l) after thermophilic sludge anaerobic digestion. For this, the raw wastewater was split and partially ( approximately 50%) fed to a nitrifying reactor (to generate nitrate) and the remaining part ( approximately 50%) was directed to the DEAMOX reactor where this stream was mixed with the nitrified effluent. Stable process performance up to NLR of 1,243 mg N/l/d in the DEAMOX reactor was achieved resulting in 40, 100, and 66% removal of ammonia, NOx(-), and total nitrogen, respectively.     

Development of single-stage nitrogen removal using anammox and partial nitritation (SNAP) and its treatment performances.

Single-stage Nitrogen removal using Anammox and Partial nitritation (SNAP) process was newly developed as an economical nitrogen removal process for ammonium rich wastewaters. The experimental studies for the evaluation of SNAP process were carried out using a novel biofilm reactor, in which hydrophilic net-type acryl fiber biomass carrier was applied. This SNAP reactor was operated under operational conditions of pH 7.5-7.7, 35 degrees C and DO 2-3 mg/L, and 60 to 80% of influent NH4-N was removed under loading rate of 0.48 kg-N/m3/d. Through the DNA analysis of the attached sludge, it was made clear that ammonium oxidizing bacteria (AOB) and anammox bacteria coexisted in the attach-immobilized sludge on the acryl fiber biomass carrier. Favorable conditions for the growth of anammox bacteria were created inside attach-immobilized nitrifying sludge. Two kinds of anammox bacteria and two kinds of AOB were detected in the SNAP sludge. Existence ratios of anammox and AOB were estimated to be 15% and 8.7%, respectively, based on the obtained clone numbers. This coexisting condition was confirmed by the FISH image of SNAP sludge and its confocal laser scanning microscope.     

Anammox bacteria enrichment and characterization from municipal activated sludge

A sustainable option for nitrogen removal is the anaerobic ammonium-oxidizing (anammox) process in which ammonium is oxidized to nitrogen gas with nitrite as electron acceptor. Application of this process, however, is limited by the availability of anammox biomass. In this study, two Brocadia-like anammox phylotypes were successfully enriched, detected and identified from an activated sludge taken from a domestic wastewater treatment plant (Minas Gerais, Brazil) employing a Sequencing Batch Reactor (SBR). The dominant phylotype was closely related to 'Candidatus Brocadia sinica', but one clone seemed to represent a novel species for which we propose the name 'Candidatus Brocadia brasiliensis'. Based on Fluorescence in situ hybridization (FISH) analysis, this enrichment led to a relative population size of 52.7% (±15.6) anammox bacteria after 6 months of cultivation. The cultivation process can be divided into three phases: phase 1 (approximately 25 days) was characterized by heterotrophic denitrification metabolism, phase 2 was the propagation phase and phase 3 (from the 87th day onwards), in which significant anammox activity was detected. A long-term performance of the SBR showed a near perfect removal of nitrite based on the influent NO(2)(-)-N concentration of 61-95 mg L(-1). The average ammonia removal efficiency was 90% with the influent NH(4)(+)-N concentration of 55-82 mg L(-1). Therefore, anammox cultivation and enrichment from activated sludge was possible under a controlled environment within 3 months.     

Study on performance of granular ANAMMOX process and characterization of the microbial community in sludge.

Anaerobic Ammonium Oxidation (ANAMMOX) is a novel biological nitrogen removal process, which is regarded as the most economical process at present. In this paper, two lab-scale UASB reactors, one of which was inoculated with the mixture of anaerobic sludge and aerobic sludge, the other with river sediments, were started up, using the inorganic synthetic water containing ammonium and nitrite as influent. After 421 days' and 356 days operation respectively, the ammonium removal efficiencies in two reactors reached 94% and 86% respectively, the total nitrogen volumetric loading rates were 2.5 and 1.6 kgN/m3 x d. ANAMMOX granules were obtained in both reactors; the color of most granules was brown, but some of them were red. Based on the observation and studies on the microstructure of the granules, three kinds of ANAMMOX granular sludge formation mechanisms were proposed: adhering biofilm and disintegrated granular core mechanism, adhering biofilm and inorganic core mechanism and the self-coherence mechanism. For phylogenetic characterization of anaerobic ammonium oxidizers, 16S rDNA approach was performed using Planctomycetales-specific PCR amplification. The dominant anammox bacteria occupied more than 90% of Planctomycetales-specific bacteria, and 27% of all bacteria in reactors. The dominant anammox bacteria distantly related to all currently reported candidate anammox genera. Functional gene of amoA was analyzed to investigate the 'aerobic' ammonium-oxidizing bacteria in beta-Proteobacteria. The 'aerobic' ammonium-oxidizing bacteria were more diverse than anammox bacteria, but most of them clustered in anoxic ammonium-oxidizing Nitrosomonas eutropha/europaea groups. The composition of 'aerobic' ammonium-oxidizing bacteria is only 2% of all of bacteria in reactors.     

Conditions and technologies of biological wastewater treatment in Hungary

A survey has been carried out involving 55 Hungarian wastewater treatment plants in order to evaluate the wastewater quality, the applied technologies and the resultant problems. Characteristically the treatment temperature is very wide-ranging from less than 10 °C to higher than 26 °C. Influent quality proved to be very variable regarding both the organic matter (typical COD concentration range 600-1,200 mg l(-1)) and the nitrogen content (typical NH(4)-N concentration range 40-80 mg l(-1)). As a consequence, significant differences have been found in the carbon availability for denitrification from site to site. Forty two percent of the influents proved to lack an appropriate carbon source. As a consequence of carbon deficiency as well as technologies designed and/or operated with non-efficient denitrification, rising sludge in the secondary clarifiers typically occurs especially in summer. In case studies, application of intermittent aeration, low DO reactors, biofilters and anammox processes have been evaluated, as different biological nitrogen removal technologies. With low carbon source availability, favoring denitrification over enhanced biological phosphorus removal has led to an improved nitrogen removal.     

饮用水处理中不同滤料除氨氮效果及需氧量研究

对比研究了活性无烟煤、活性炭、石英砂以及无烟煤4种滤料过滤去除饮用水中氨氮的效果及其与需氧量的关系。试验结果表明,当氨氮低于2 mg/L时,4种滤料过滤都能够有效去除氨氮,水中溶解氧逐渐耗尽;当氨氮浓度高于2 mg/L时,4种滤料的去除率均有所下降,但相比石英砂和无烟煤而言,活性无烟煤和活性炭过滤能够更有效地去除氨氮。纯氧曝气能够将溶解氧浓度提高到25 mg/L,从而大幅度改善4种滤料对氨氮的去除效果;活性无烟煤和活性炭过滤可将大部分氨氮转化为硝酸盐,但石英砂和无烟煤过滤则会发生亚硝酸盐积累现象。在活性无烟煤和活性炭过滤去除氨氮过程中,氨氮去除量与溶解氧的平均比例为1∶4.25,略低于理论值。这种定量关系对于生物过滤去除氨氮工艺的设计和运行具有指导意义。     

厌氧水解-SNAD工艺处理低碳氮比农村生活污水

为解决农村生活污水的高效除碳脱氮问题,以厌氧水解-同时硝化反硝化厌氧氨氧化(SNAD)工艺处理低C/N比农村生活污水。实验结果表明:水解酸化单元进水C/N比为2∶1时,COD的去除率达到69%;产物VFA主要成分为乙酸、丙酸和正丁酸,平均含量分别为88.4%、6.5%与5.1%,VFAs/COD比为0.74;出水C/N比为3∶5。水解酸化单元出水进入SNAD脱氮单元,通过亚硝化、反硝化与厌氧氨氧化的耦合作用,该单元COD与总氮的去除率分别可达到76.7%和84.1%。厌氧水解-SNAD组合工艺COD与总氮总去除率分别达到92.8%和84.1%。     

Nitrate removal using different carbon substrates in a laboratory model

Agricultural fields have been frequently identified as major contributors of nitrate leaching into surface and ground waters. Tile drains can act as direct pathways, transferring leached nitrate to surface water. Bioreactor filters are useful for the removal of nitrate from drainage waters; however, these filters require an external carbon supply to sustain denitrification. In this study, four organic carbon sources including wood, barley straw, rice husks, and date palm leaf, were used to enhance denitrification and the effects of water velocity and influent nitrate concentration on the nitrate removal were evaluated. Cumulative nitrate removal was highest for the date palm leaf treatments and was lowest for the wood treatments. The effects were in decreasing order for date palm leaf, barley straw, rice husks, and wood, respectively. The performance of the biofilters improved with increasing influent nitrate concentration and decreasing water velocity, allowing for high nitrate removal rates to be achieved. The results showed that all of the treatments had reduced the effluent nitrate concentrations below the USEPA maximum contaminant level for drinking water of 45 mg L(-1) nitrate at the end of the study.     

Anammox process for synthetic and practical wastewater treatment using a novel kind of biomass carriers

The anammox process, as an alternative to conventional nitrogen removal technologies, has abstracted much attention in recent years. In this study, one column-type reactor using a novel support material--net type acrylic fiber (Biofix)--was used for anammox treatment. The Biofix reactor was operated at 25 degrees C (peak summer temperature, 31.5 degrees C). Over 330 days of operation for synthetic wastewater treatment, the nitrogen loading rates of the reactor were increased to 3.6 kg-N/m3/d and T-N removal efficiencies reached to 81.3%. For the practical anaerobic sludge digester liquor treatment, the average TN removal efficiency of 72% was obtained. A protein substance was shown to be the most abundant extracellular polymeric substances (EPS) in the granular sludge with almost two times more in the attached sludge of the Biofix reactor. Considering the EPS levels and observation by scanning electron microscopy, the anammox granules in the Biofix reactor were showing dense state. Results of DNA analyses indicated that the KSU-1 strain might prefer relatively low nutrient levels, while the KU2 strain might be better suited for the high media concentration. Other kinds of bacteria were also identified with the potentials for consuming the dissolved oxygen in the influent and facilitating anammox bacteria surviving under aerobic conditions.     

High strength nitrogen removal from nightsoil and piggery wastes.

Nightsoil and piggery wastes generally present high strength organics and nitrogen. This study evaluated the nitrogen removal characteristics with the existing and modified nightsoil and piggery waste treatment plants. The existing conventional plants showed 20 to 40% nitrogen removal, but the modification with SBR or MLE process could remove effectively both nitrogen and organics with the minimum COD/TN and alkalinity/TN ratios of 6 and 3.6, respectively. Nitrite nitrification and denitrification rates obtainable at higher nitrogen loads were faster than the rates of nitrate nitrification and denitrification resulting in less reactor volume requirement. However, the higher nitrogen loads increased the organic loads resulting in the reactor temperature inhibiting nitrification. Thus, a combined treatment with anaerobic digestion with the adjustment of influent bypass rates was proposed to reduce the reactor temperature and the external carbon requirement. The biological treatment could discharge about 1,100 mg/L soluble COD and 50 mg/L soluble nitrogen, respectively.     

Feasibility study on the removal of nitrous compounds with a hollow-fiber membrane biofilm reactor.

The objective of this study was to develop an integrated nitrogen treatment system using autotrophic organisms. A treatment system consists of an aerobic hollow-fiber membrane biofilm reactor (HfMBR) and anaerobic HfMBR. In the aerobic HfMBR, a mixture gas of air and O2 was supplied through the fibers for nitrification. Denitrification occurred in the anaerobic HfMBR using H2 as the electron donor. The treatment system was continuously operated for 190 days. NH4-N removal efficiencies ranging from 95% to 97% were achieved at NH4-N concentrations of influent ranging from 50 to 100 mg N/L. When glucose was added to the influent, the simultaneous nitrification and denitrification occurred in the aerobic HfMBR, and nitrogen removal rates were changed according to the COD/NH4-N ratio of influent. In the anaerobic HfMBR, autotrophic denitrification using H2 occurred and the removal rates achieved in this study were 23-58 mg N/m2 d. In this study, the achieved removal efficiency was lower than other study findings; however, the result suggested that this hybrid HfMBR system can be used effectively for nitrogen removal in oligotrophic water.     

曝气生物滤池去除有机物及氨氮的影响因素分析

采用以陶粒为填料的曝气生物滤池(BAF)处理生活污水,研究气水比、水力负荷、进水COD和NH3-N负荷对BAF去除COD及NH3-N的影响,分析COD及NH3-N沿滤柱的变化规律。结果表明:当试验进水COD及NH3-N质量浓度分别为300~370mg/L和20~40mg/L时,最佳气水比为4∶1~5∶1,最佳水力负荷为1.0~2.0 m3/(m2.h)。当进水COD负荷为1.69~6.47 kg/(m3.d)时,COD去除率与进水COD负荷成正相关。BAF的硝化性能与进水NH3-N和COD负荷成负相关。     

太阳能曝气人工垂直潜流湿地去除生活污水氮磷的试验研究

利用芦苇和砾石构建太阳能曝气人工垂直潜流湿地处理生活污水。设定水力负荷400 mm/d,气水比10∶1,当进水氨氮(NH₄-N)、总氮(TN)、溶解性反应磷(SRP)和总磷(TP)平均浓度为5.14,7.56,0.40,0.53 mg/L时,引入太阳能曝气后,各自的平均去除率分别提高24.8%,9.4%,15.7%和11.5%。随着气温下降和进水浓度降低,湿地微生物脱氮除磷能力下降,曝气对改善生活污水氮磷去除作用不显著。对试验系统而言,太阳能曝气湿地基本建设费用是无曝气湿地的2.85倍;但以20 a运行为基础折算出的污水处理费比无曝气湿地仅高0.02元/m³。综上,从污染去除性能和污水长期处理费用来看,太阳能曝气湿地在生活污水处理方面具有较好的技术经济优势。     

Factors affecting the activity of anammox bacteria during start up in the continuous culture reactor.

Factors affecting cultivation of extremely slow-growing bacteria (anaerobic ammonium oxidiser, doubling time 11 days) were investigated by using upflow anaerobic sludge blanket (UASB) reactors which can maintain high solid retention time. The effects of concentrations of DO, free ammonia (FA), and nitrite on activation of anammox activity were tested during the start-up period. The reactor was inoculated with granular sludge collected from a full-scale UASB reactor used for treating brewery wastewater, and sludge from a piggery wastewater treatment plant and rotating biological contactor treating sewage. Results of continuous operation showed that concentrations of DO, free ammonia (FA) and nitrite in the reactors played a key role in stimulating the anammox activity during start-up period. It is crucial to keep DO below 0.2 ppm, FA below 2 mg/L and nitrite nitrogen below 35 mg/L to cultivate anammox cells in the continuous bioreactor. When the levels of DO, FA and nitrite in the influent were controlled at less than the inhibition levels, the anammox activity increased gradually in the anaerobic condition. Addition of hydrogen sulphide into the reactor enhanced anammox activity in the continuous culture. Through the SEM, TEM and FISH analysis, anammox bacteria were detected in the granular sludge after 3 months of continuous operation.     

ABR反应器对垃圾渗滤液的处理试验研究

ABR工艺在处理垃圾渗滤液中具有其他厌氧生物反应器所达不到的优点。尤其是对B/C低、氨氮浓度高、COD浓度高的废水处理,通过调节回流比、HRT、碱度等参数后,可以取得很好的处理效果。在本次实验中,HRT控制在18h后明显提高的垃圾渗滤液的可生化性及C/N,使ABR出水CODcr去除率达到75%,C/N为6.72,对后续好氧反应起到了重要作用。在调控一定回流比后,为提供厌氧氨氧化所需的电子受体NO-3和NO-2实现脱氮。反应器在经过120d的培养驯化,氨氮进水为460mg/L,ABR对氨氮的去除率稳定在80%。不同格室的厌氧颗粒污泥都得到很好的驯化并在其合适的环境中发挥各自的功能。     

In-situ characterization of microbial community in an A/O submerged membrane bioreactor with nitrogen removal.

The bacterial community involved in removing nitrogen from sewage and their preferred DO environment within an anoxic/oxic membrane bioreactor (A/O MBR) was investigated. A continuously operated laboratory-scale A/O MBR was maintained for 360 d. At a sludge age of 150 d and a C/N ratio of 3.5, the system was capable of removing 88% of the influent nitrogen from raw wastewater through typical nitrogen removal transformations (i.e. aerobic ammonia oxidation and anoxic nitrate reduction). Characterization of the A/O MBR bacterial community was carried out using fluorescence in situ hybridization (FISH) techniques. FISH results further showed that Nitrosospira spp. and Nitrospira spp. were the predominant groups of ammonia and nitrite oxidizing group, respectively. They constituted up to 11% and 6% of eubacteria at DO below 0.05 mg/l (low DO), respectively, and about 14% and 9% of eubacteria at DO between 2-5 mg/l (sufficient DO), respectively, indicating preference of nitrifiers for a higher DO environment. Generally low counts of the genus Paracoccus were detected while negative results were observed for Paracoccus denitrificans, Alcaligenes spp, and Pseudomonas stutzeri under the low and sufficient DO environments. The overall results indicate that Nitrosospira spp., Nitrospira spp. and members of Paracoccus spp. can be metabolically functional in nitrogen removal in the laboratory-scale A/O MBR system.     

潜流湿地对微污染水体中氮磷去除效果的中试研究

以南京水利科学研究院铁心桥试验基地内象目湖微污染水体为对象,研究总氮大于1.0 m3/(m2·d)的高水力负荷条件下,鹅卵石、陶粒、砾石、钢渣、蛭石、碎石和砂子等多种基质和再力花、芦苇、美人蕉及菖蒲等水生植物组合条件下的垂直流湿地和水平潜流湿地对氮磷的去除效果。试验结果表明:进水总氮浓度在0.793~2.662 mg/L时,种植菖蒲,填料从上到下分别为鹅卵石、碎石、粗砂和细砂的垂直潜流湿地单元(20单元)出水总氮平均浓度最低,为0.905 mg/L;总氮、氨氮和硝态氮平均去除率最高,达80.89%,43.06%和46.32%;总氮浓度从Ⅳ类水体提升至Ⅲ类。进水TP浓度在0.035~1.003 mg/L时,20单元总磷平均去除率最高,为30.59%,价格相对便宜的碎石对磷素的去除效果较好。种植菖蒲及填料组合为鹅卵石、碎石、粗砂和细砂的人工湿地处理单元可以应用于饮用水源地原水等微污染水强化处理。     

Nitrogen removal in maturation ponds: tracer experiments with 15N-labelled ammonia.

A primary maturation pond (M1) was spiked with labelled ammonium chloride (15NH4Cl) to track ammonium transformations associated with algal uptake and subsequent sedimentation. Conventional sampling based on grab samples collected from M1 influent, water column and effluent, and processed for unfiltered and filtered TKN, ammonium, nitrite and nitrate, found low total nitrogen removal (8%) and high ammonium nitrogen removal (90%). Stable isotope analysis of 15N from suspended organic and ammonium nitrogen fractions in M1 effluent revealed that labelled ammonium was mainly found in the organic fraction (69% of the 15N recovered), rather than the inorganic fraction (5%). Algal uptake was the predominant pathway for ammonia removal, even though conditions were favourable for ammonia volatilization (8.9 < pH <10.1 units, 15.2 < temperature <18.8 degrees C). Total nitrogen was removed by ammonia volatilization at 15 g N/ha d (3%), organic nitrogen sedimentation at 105 g N/ha d (20%), and in-pond accumulation due to algal uptake at 377 g N/ha d (71%). Algal uptake of ammonium and subsequent sedimentation and retention in the benthic sludge, after partial ammonification of the algal organic nitrogen, is thus likely to be the dominant mechanism for permanent nitrogen removal in maturation ponds during warm summer months in England.     

SBR法处理煤化工废水中石油烃类的试验研究

采用序批式(SBR)活性污泥法处理煤化工废水.通过分析不同周期、进水浓度、pH、温度、DO与处理效果之间的关系,确定了SBR法处理煤化工废水的的最佳运行参数.试验结果表明,在SBR处理周期为24 h的条件下,进水CODCr为1200～1400 mg/L,石油烃类为50～70 mg/L,pH为6.8～7.1,DO为3.5 mg/L左右,温度约为25℃时,该工艺对CODCr和石油烃类去除效果较好,去除率分别为85％和76％.该工艺具有投资少、操作简单、运行费用低等特点.     

Aeration effect on the efficiency of swine manure treatment in a trickling filter packed with organic materials.

Effect of aeration rate on the removal of organic matter and nitrogen and on the formation of NH3, N2O and N2 was studied for an extensive biofiltration system packed with an organic media, which was used to treat pig manure. The results show high removal of BOD5 and TSS (99 and > or = 98%), independently of the four aeration rate tested (3.4-34 m3/m2 x h). Aeration rate > or = 4.4 m/h resulted in high ammonia stripping during start-up (> or = 1.0 kg NH3-N/m3 of swine manure treated), while using 3.4 m/h only 0.3 kg NH3-N/m3 were stripped. Complete nitrification was achieved after day 100 of operation, except in the biofilter with the lowest aeration rate. Simultaneous denitrification established in all the biofilters. Applying an aeration rate of 9.4 m/h up to 1.2 kg nitrogen was removed in the form of N2 for each m3 of swine manure treated. Contrary to the expectations, N2 formation and release increased with the aeration rate. This particular behaviour seems to be related to the punctual accumulation of water layers inside the biofilters, caused by the air force flowing in the opposite direction to the water flux. N2O production was quite similar in all biofilters (between 0.25-0.36 kg N2O-N/m3 of swine manure treated).