CaO-SiO2-Al2O3-Fe2O3渣系脱磷行为

利用Factsage软件计算了Al2O3含量对CaO-SiO2-Al2O3-Fe2O3四元渣系熔点和黏度的影响,并通过实验研究了在1 400℃时,CaO-SiO2-Al2O3-Fe2O3四元渣系对高磷铁水脱磷行为的影响.结果表明:渣中Al2O3的质量分数在3％～6％之间时,随着A12O3含量的增加,渣系的熔化温度迅速降低,进一步增加渣中的A12O3含量,渣系的熔化温度逐渐增加;Al2O3对CaO-SiO2-Al2O3-Fe2O3渣系的黏度影响不大;渣中Al2O3的质量分数在3％～6％之间变化时,渣系脱磷能力变化不是很大,脱磷率维持在91％左右,进一步增加渣系中A12O3的量,脱磷率逐渐下降;Al2O3对脱磷率产生影响可能是其改变了炉渣中液相所占比例,进而影响磷从铁水中向液相渣的传质过程.     

Preparation and Spectra Properties of BaO-Al2O3-P2O5-Sm2O3 System Protection Glasses

The forming-regions of phosphate glasses doped with high Sm2O3 contents were studied by two step melting method. The relationship between absorption spectrum and rare earth contents was also discussed. The spectra of BASP glasses were measured by spectrophotometer. The results show that the forming regions will shrink with the increase of Al2O3 and it is difficult to form glass when [PO4]/[AlO4]＜2. The forming regions tend to be a closed elliptical, and the intensity of characteristic absorption peak increases gradually with the increase of Sm2O3, the absorption lines broadens non-uniformly and there is approximate linear relation between optical density at the 1064 nm wavelength and Sm2O3 content.     

Highly Er3+/Yb3+ Co-Doped Fluoroaluminate Glasses for Microchip Laser at 1.54 μm

A series of highly Er3 /Yb3 co-doped fluoroaluminate glasses were investigated in order to develop a microchip laser at 1.54 μm under 980 nm excitation. Measurements of absorption, emission and up-conversion spectra were performed to examine the effect of concentration quenching on spectroscopic properties. In the glasses with Er3 concentrations below 10% (mol fraction), concentration quenching is low and the Er3 /Yb3 co-doped fluoroaluminate glasses gave stronger fluorescence of 1.54 μm from the 4I13/2→ 4I15/2 transition than those of Er3 singly-doped glasses. In the glass with Er3 concentrations above 10%, concentration quenching of 1.54 μm obviously occurs more than that of the Er3 singly-doped samples because of the back energy-transfer from Er3 to Yb3 . To obtain the highest emission efficiency at 1.54 μm, the optimum in mol fraction when the Er3 concentration is less than 10%.     

Study on thermal expansion behavior of Dy2O3 - Al2O3 - SiO2 glass

Employing Dy2O3, Al2O3, and SiO2 as starting materials, several series of Dy2O3-Al2O3-SiO2 sealing glass were prepared. The relationship between their coefficients of thermal expansion and the contents of Dy2O3, Al2O3, and SiO2 were studied respectively. Experimental results showed that Dy2O3 and Al2O3 had a positive effect on the coefficient of thermal expansion of glass, whereas, SiO2 had a negative effect. The coefficient of thermal expansion of glass showed an apparent linear relation to the contents of these three raw materials, from which an estimation model was built, to calculate the coefficient of thermal expansion of sealing glass. Relative errors of the calculating results to testing results were no more than 2%, which suggested that the estimation model was reasonable. This study provides a good theory reference for the practical utilizing of this sealing material, through which a proper glass composition for good sealing could be easily found.     

CaF2-SiO2-Al2O3-CaO-MgO五元渣系的电导率

 为了系统研究五元含氟渣系各组元对熔渣电导率的影响,根据5因素2次正交旋转回归法设计渣系,使用RTW-10熔渣物性测定仪,采用交流4探针法,测定了1600℃下各渣系的电导率;研究了各组元对含氟渣系电导率的影响。结果表明：当CaF2的含量(质量分数,下同)在10%~75%时,随着Al2O3和SiO2含量的增加电导率逐渐减小,而随着CaF2、MgO和CaO含量的增加电导率逐渐增大;在w(Al2O3)=20%、w(MgO)=10%和w(CaF2)=50%时,当w(CaO)小于7%,随着w(SiO2)的递增电导率逐渐减小,而当w(CaO)大于7%时,随着w(SiO2)的递增电导率逐渐增大;在w(SiO2)=10%、w(MgO)=10%和w(CaF2)=50%时,当w(Al2O3)小于11%时,随着w(CaO)的递增电导率逐渐减小,当w(Al2O3)大于11%,随着w(CaO)的递增电导率逐渐增大。     

Optical Spectroscopy of Er^3＋ and Er^3＋/Yb^3＋ Co-doped Bi2O3-GeO2-B2O3-ZnO Glasses

The （60 - x）Bi2O3 - xGeO2-30B2O3-10ZnO （x = 5, 10, 20, 30 molar percent） glasses doped with Er^3＋ and Er^3＋/Yb^3＋ were fabricated using the melting method. The thermal stability of the glasses was studied with their DTA curves. The results show that the difference between the glass transition temperature and the crystallization onset temperature increases with the increase of GeO2 content, indicating that the thermal stability of the glass has become better. The absorption spectra were recorded and the stimulated emission cross sections were calculated using the McCumber theory. The Ω2, O4, and Ω6 parameters,the transition probability, the radiative lifetime, and the fluorescence branch ratio of Er^3＋ for optical transition were calculated from their absorption spectra in terms of reduced matrix U^（t）（λ = 2, 4, 6） character for optical transitions. The infrared emission of Er^3＋ was measured upon excitation with 970 nm light and the full width at half-maximum （FWHM） was estimated from the emission spectra. The pumping efficiency and the intensity of the emission at the 1.54 μm band of Er^3＋ were enhanced considerably by co-doping Yb^3＋ .     

Phosphorus Capacity of CaO-SiO2-Al2O3-MgO-FexO Slag

The CaO-SiO2-Al2O3-MgO-FexO slag occurs in the production process of Corex ironmaking technology.Most of its metallurgical properties,especially the phosphorus property,are different from the slag produced from blast furnace or converter.In order to explore the dephosphorization ability of CaO-SiO2-Al2O3-MgO-FexO slag,its phosphorus capacity was measured at 1 673 Kby gas-slag-metal equilibrium technique.An iron crucible was used as the reaction vessel,Ag alloy with 0.2% P was used as the metal phase which equilibrated with CaO-SiO2-Al2O3-MgO-FexO slag,and a constant flow of CO-CO2-N2 gas was used to provide oxygen partial pressure in the experiment.The effects of MgO,FexO and basicity on slag phosphorus capacity were investigated by single factor test.The results show that the phosphorus capacity rises firstly and then decreases with increasing MgO content under the condition of basicity 1.3,FexO content of 2% and Al2O3 content of 12%.The phosphorus value reaches maximum as the MgO content is 8%.When the basicity of slag is 1.1,MgO content is 10%,and Al2O3 is 12%,the phosphorus capacity increases with the increase of FexO content.The phosphorus capacity rises linearly when the basicity is increased from 1.1to 1.5.     

MgO-Al_2O_3-SiO_2复合夹杂物对430不锈钢凝固组织的影响

通过真空感应炉试验,研究不同Mg含量处理所获得的不同MgO-Al2O3-SiO2复合夹杂物对凝固组织的影响。试验结果表明,随着钢中Mg含量的增加,铸锭等轴晶率呈现先升高后下降的趋势,而等轴晶尺寸和柱状晶宽度呈现先降低后升高趋势,存在一个最佳的Mg的质量分数范围(5~13)×10-6,铸锭的等轴晶率在70%以上。夹杂物观测并结合热力学计算发现,随着钢中Mg含量的增加,MgO-Al2O3-SiO2复合夹杂物外层逐步析出MgO·Al2O3相;然而,Mg的质量分数高于13×10-6时,夹杂物外层开始析出2MgO·SiO2相。晶面错配度计算表明,MgO·Al2O3与δ-Fe的错配度为1.2%,2MgO·SiO2与δ-Fe的错配度为13%。可以判断,MgO·Al2O3相可促进等轴晶形成,抑制晶粒长大,2MgO·SiO2相则起不到促进形核作用。从而解释了铸锭等轴晶率、晶粒尺寸随Mg含量的变化规律。     

Mechanical Behaviors of ZrO2-Al2O3 Ceramic Composites with Y2O3 as Stabilizer

Forlongthebrittlenessofceramicmaterialshasstoodinthewayofindustrialapplicationanddevelop ment.However ,inrecentyears ,suchprogressasthephasetransformationtougheningofzirconia ,thedis persionofparticletougheningandthefiberorwhiskertougheninghavewellimprove…     

Magnetic Properties and Activity of Pt-Er/γ-Al2O3 Catalysts

A series of Pt-Er/γ-Al2O3 catalysts containing 0.5%(mass fraction) platinum and 0.05%-1.5% Er were prepared by impregnation of γ-Al2O3 supported with different concentrations of erbium chloride solution. The surface properties of the catalysts were studied by methods of temperature programmed reduction and temperature programmed desorption. The magnetic behavior of Pt-Er-γ-Al2O3 catalysts were studied with a Faraday magnetic balance and the results show that the addition of Er can affect the surface properties, the catalytic activities, and magnetic behavior of the reforming catalysts. It is found that there is a corresponding relationship between the susceptibility and selectivity of Pt-Er-γ-Al2O3 catalysts. The experimental results show that Er plays the role of electron promoter.     

等离子喷涂Al2O3涂层CO2连续激光反射性能的研究

采用等离子喷涂法制备了Al2O3涂层,研究了相结构对CO2连续激光反射率的影响。结果表明,Al2O3涂层中的主相为γ-Al2O3,涂层对CO2连续激光的反射率为23.65%±0.80%。γ-Al2O3的激光反射率高于α-Al2O3,主要原因是α-Al2O3和γ-Al2O3的晶体结构不同,在与激光相互作用时,由于γ-Al2O3存在电子轨道交叠,电子带间跃迁能力较强,提高了其对CO2连续激光的反射率。等离子喷涂Al2O3涂层在激光辐照过程中存在γ-Al2O3到α-Al2O3的相变,使得涂层的反射率下降。     

Spectroscopic Properties of Er^3＋-Doped TeO2-WO3-ZnO-ZnF2 Glasses

The Er^3 -doped TeO2-WO3-ZnO-ZnF2(TWZOF) glasses were prepared. The absorption spectra, 1.5μm emission spectra and fluorescence lifetimes of Er^3 , excited at 970nm, were measured. The J-O parameters Ωt(t=2, 4, 6), absorption and emission cross-sections were calculated. The dependence of the 1.5μm emission intensity, fluorescence lifetime and bandwidth of the Er^3 emission upon the contents of ZnF2 in glass were investigated. In TWZOF glass, Er^3 ions had a broad emission profile around 1.5μm with the maximum FWHM of 83nm. With the increasing of the content of ZnF2, the emission intensity at peak wavelength and the fluorescence lifetime of Er^3 at 1.5μm increase.     

CaO-SiO_2-FeO-P_2O_5-Al_2O_3脱磷渣系中组元活度的计算

2CaO·SiO_2-3CaO·P_2O_5含磷固溶体的生成可提高转炉液相渣的脱磷能力,减少渣量.但目前CaO-SiO_2-FeO-P_2O_5-Al_2O_3渣系中各组元活度的变化规律尚不明确,无法为分析含磷固溶体的形成机理提供理论依据.为此,本文依据分子离子共存理论建立了熔渣组元的活度模型,分析了不同条件下组元活度的变化规律.结果表明:随渣中Al_2O_3含量的增加,2CaO·SiO_2、3CaO·P_2O_5、3FeO·P_2O_5的活度逐渐降低;随着碱度的增大,3CaO·P_2O_5的活度升高,2CaO·SiO_2、3FeO·P_2O_5的活度则呈先升高后降低的趋势;随着渣中FeO含量的增加,2CaO·SiO_2、3FeO·P_2O_5及CaO·Al_2O_3的活度逐渐增大,并在w(FeO)为15%时达到最大值,之后逐渐降低;升高温度会导致CaO、3CaO·SiO_2的活度增大,2CaO·SiO_2的活度降低.     

Influence of Composition of Sm2O3-Containing Rare Earth Glass on Its Absorption Spectrum

Lanthanidemetalsarethe 5 7thto 71thelementsintheperiodictable ,thetrivalentionsforlanthanideareofvalenceelectronshell 4f0～ 14 6s2 ,whicharefairlystablewhenthe 4felectronsub layerisemptyoral mostempty ,halffullorfull .Becauseofbigenergydifferencebetweenba…     

TiO2和Al2O3加入量对MgO-Al2O3-TiO2材料烧结性能的影响

以α-Al2O3、TiO2和轻烧MgO为原料,在轻烧MgO含量固定不变的情况下．研究了在1400～1600℃下α-Al2O3和TiO2的加入量对MgO-Al2O3-TiO2材料烧结性能的影响。结果表明：当烧结温度低于1500℃时,随着TiO2含量的增加,Al2O3含量的减少,试样的显气孔率降低,体积密度增加;当烧结温度升高到1600℃时,TiO2的加入使试样的烧结性能稍微变差;且在1600℃保温3h烧后的试样中,随着TiO2含量的增加,Al2O3含量的减少,试样的晶粒尺寸增大,但当Al2O3含量为0时,试样的晶粒尺寸又有所减小。     

二元碱度和Al_2O_3对CaO-SiO_2-FeO-Fe_2O_3-P_2O_5-Al_2O_3-MgO-MnO钢渣中磷酸盐富集的影响

以八元CaO-SiO_2-FeO-Fe_2O_3-P_2O_5-Al_2O_3-MgO-MnO钢渣体系为研究对象,结合热力学计算和实验检测,分析了二元碱度B和Al_2O_3含量对八元钢渣系中磷酸盐富集行为的影响。结果表明:钢渣二元碱度和Al_2O_3含量直接影响钢渣中f-C2S的生成量,进而影响磷酸盐富集相nC_2S-C_3P内P_2O_5的含量。随着二元碱度从1.3提高至2.5,磷酸盐富集率增大,磷酸盐富集相nC2S-C3P中的P_2O_5含量呈现先迅速增大(B从1.3至1.7),然后逐渐减小(B从1.8至2.5)的趋势。当二元碱度和Al_2O_3质量分数分别控制在1.7和12%时,即当满足四元碱度R为1.23时,此八元钢渣体系有较好的磷酸盐富集效果,磷酸盐富集相nC_2S-C_3P内的P_2O_5的质量分数可以达到24.23%。     

CaF2-SiO2-Al2O3-CaO-MgO五元渣系黏度的试验研究

为了研究含氟渣系成分变化对黏度的影响,根据五因素二次正交旋转回归法设计渣系配方,使用RTW-10熔渣物性测定仪,采用旋转柱体法,在1 600～1 300℃降温过程中对CaF2-SiO2-Al2O3-CaO-MgO渣系的黏度进行连续测定;建立了1 600℃下五元含氟渣系黏度的回归模型,研究了各组元对熔渣黏度的影响.结果表明:当CaF2的含量(质量分数,下同)在10％～70％时,随CaF2含量增加,黏度减小,随SiO2、Al2O3和MgO含量增加,黏度增大,CaO易受其他组元的作用而对黏度产生不同影响;在w(SiO2)=10％、w(MgO) =10％和w(CaF2)=50％时,随w(CaO)增加,黏度先增大后减小,w(CaO)=10％时黏度最大.在w(Al2 O3) =20％、w(MgO)=10％和w(CaF2)=50％时,随着w(CaO)增加,当w(SiO2)＜20％时,黏度先增大后减小;当w(SiO2)＞20％时,黏度持续减小.     

����������La2O3-Al2O3-CaF2����������Ũ��ģ��

In order to accurately control the rare earth content in liquid steel in electroslag remelting (ESR) process, according to the ion and molecule coexistence theory (IMCT) of slag structure and corresponding phase diagrams, a thermodynamic calculating model for the evaluation of mass action concentrations (designated by Ni for structure unit i) for La2O3-Al2O3-CaF2 slag system was formulated. The results show that the calculated values of NLa2O3 are in good agreement with the reported measured values, indicating that this calculating model can wholly embody the characteristics of the slag system. The activity of La2O3 decreases with the increasing of the Al2O3 and CaF2 content, and Al2O3 is stronger than CaF2 in decreasing the activity of La2O3. But the activity of La2O3 increase with the increasing in temperature at the composition range of 30% La2O3, 20% Al2O3, 50% CaF2. Above all, the activity of La2O3 in La2O3-Al2O3-CaF2 slag system can be quantitatively analyzed by this thermodynamic model, and this model can provide a theoretical basis for precisely controlling the lanthanum content in molten steel in ESR process.     

Preparation and Thermal Stability of Phosphate System Protection Glasses Doped with Rare Earths

The formation ability and thermal stability of phosphate laser protection glass doped with high Sm2O3 content were discussed. The characteristic temperatures (Tg, Tc, Tm) were measured by DSC and the crystallization parameter β was calculated. The results show that the forming regions would shrink and tend to closed ellipse with increasing of Sm2O3 content. Increasing of BaO/Al2O3 ratio changes the network structure of rare earth glass and improves the thermal stability finally. However, with the increasing of Sm2O3 content, the β increases firstly and then decreases, and finally the thermal stability also increases firstly and then decreases.     

Recycling of High Ferrous Bauxite Reducing Slag for Synthesis of CaAl2 Si2 O8-Al2 O3-CaAl12 O19 Composite

CaAl_2 Si_2 O_8-Al_2O_3-CaAl_(12) O_(19)( CAS_2-Al_2O_3-CA_6) composite was synthesized through reaction sintering alumina and bauxite reducing slag.The CAS_2-Al_2O_3-CA_6 composite was mainly composed of α-Al_2O_3,CAS_2,and CA_6.Gehlenite( Ca_2Al_2 SiO_7,C_2AS) phase was effectively transformed to CAS_2 and CA_6through high-temperature reaction sintering under weak oxidizing atmosphere at 1400 ℃ for 4h.SEM( scanning electron microscopy) and EDS( energy dispersive spectroscopy) analysis indicated that black and needle-shaped Al_2O_3,rhombic or irregular polygonal-shaped Fe Al_2O_4,and glassy phase Ca_2Al_2 SiO_7disappeared after the reaction sintering.The light gray and flaky hexagon crystals of Ca Al_(12)O_(19)(10μm) and the grainy particles of Al_2O_3( 2-7μm) were observed in the CAS_2-Al_2O_3-CA_6 composite.The gray crystals of CAS_2 act as the binding phase and are distributed around CA_6 and Al_2O_3.CAS_2-Al_2O_3-CA_6 composite exhibits high refractoriness and service temperature,which are 1650 ℃ and 1450 ℃,respectively.Reaction sintering of alumina and bauxite reducing slag is a feasible method for the synthesis of CAS_2-Al_2O_3-CA_6 composite.