Cheese made from instant infusion pasteurized milk: Rennet coagulation,cheese composition,texture and ripening

Milk subjected to instant infusion pasteurization (IIP) at 72 °C, 100 °C and 120 °C (holding time 0.2 s) exhibited increased rennet coagulation time and decreased curd firming rate for increasing heat treatment temperature, when compared with raw or high temperature short time pasteurized (HTST) milk. However, addition of 4.5 mm or 9.0 mm of calcium restored the impaired rennet coagulation ability. Open texture cheeses produced from IIP milk (100 °C and 120 °C) contained significantly more moisture, had lower pH and shorter texture than similar cheese from IIP at 72 °C and HTST pasteurized milk. Cheese ripening was also affected by heat treatment, and different patterns of casein breakdown and peptide formation resulted from cheeses made from milk treated to IIP at 100 °C and 120 °C compared with cheeses made using IIP at 72 °C or HTST.     

The influence of lactoperoxidase,heat and low pH on survival of acid-adapted and non-adapted Escherichia coli O157:H7 in goat milk

In hot climates where quality of milk is difficult to control, a lactoperoxidase (LP) system can be applied in combination with conventional preservation treatments at sub-lethal levels to inhibit pathogenic microbes. This study investigated the effect of combined heat treatments (55 °C, 60 °C and 72 °C) and milk acidification (pH 5.0) on survival of acid-adapted and non-adapted Escherichia coli O157:H7 strains UP10 and 1062 in activated LP goat milk. Heat treatment at 72 °C eliminated E. coli O157:H7. Acid-adapted strains UP10 and 1062 cells showed resistance to combined LP and heat at 60 °C in fresh milk. The inhibition of acid-adapted and non-adapted E. coli O157:H7 in milk following combined LP-activation, heat (60 °C) and milk acidification (pH 5.0) suggests that these treatments can be applied to reduce E. coli O157:H7 cells in milk when they occur at low numbers (<5 log₁₀ cfu mL^?1) but does not eliminate E. coli O157:H7 to produce a safe product.     

Heat resistance of Lactobacillus paracasei isolated from semi-hard cheese made of pasteurised milk

Nine strains of non-starter Lactobacillus paracasei isolated from semi-hard cheese made of pasteurised milk were selected for their anticlostridial activity. Resistance to thermisation (60 °C, 5 min) and pasteurisation (73 °C, 15 s) was investigated using a submerged-coil apparatus. MRS broth-grown cultures of all nine strains survived thermisation in buffer. The level of resistance to thermisation was strain dependent and lower for freshly grown cells (stationary phase cells) than for resting cells (freshly grown cells kept diluted 10-fold in MRS broth at 17 °C for 6 days). None of the nine Lb. paracasei strains survived or recovered after pasteurisation in buffer when grown in MRS broth, while seven of the nine strains survived pasteurisation in UHT whole milk when grown in milk. Identity of the strains was successfully confirmed during the experiments using repetitive-PCR analysis. The potential of Lb. paracasei strains to survive pasteurisation of cheese milk was demonstrated.     

Effect of heat treatment and casein to whey protein ratio of skim milk on graininess and roughness of stirred yoghurt

The aim of this work was to study how heat treatment and casein (CN) to whey protein (WP) ratio of skim milk affect physical characteristics of stirred yoghurt. Different heat treatments (95 °C/256 s, 110 °C/180 s and 130 °C/80 s) were applied to the yoghurt milk with the CN to WP ratios of 1.5:1, 2:1, 3:1 and 4:1. Physical properties, including graininess and roughness, of stirred yoghurt were determined during storage at 4 °C for 15 days. Visual roughness, number of grains, perimeter of grains, storage modulus, and yield stress decreased, when heating temperature or CN to WP ratio increased.     

Effect of hydrolysis of casein by plasmin on the heat stability of milk

This study examined the effect of hydrolysis of casein by added plasmin (6 mg L⁻¹) on the heat stability of raw, pre-heated, serum protein-free or concentrated skim milk. Plasmin activity markedly affected the heat stability–pH profile of skim milk and serum protein-free milk, apparently by altering the properties of the casein micelles. It is probable that changes in the surface charge of the micelles, as a result of the hydrolysis of caseins, contributed to this effect. Hydrolysis by plasmin reduced the zeta-potential of the casein micelles from ∼−19 to ∼−16 mV. The effect of hydrolysis of casein by plasmin on the heat stability of pre-heated milk was less pronounced, shifting the heat stability–pH profile to more alkaline values; the heat stability of concentrated milk was unaffected by plasmin. A very high (50 mg L⁻¹) level of added plasmin resulted in clearing of the skim milk; the L^* value decreased from ∼75 to ∼35 after 24 h incubation at 37 °C. Clearing was correlated with a change in casein micelle diameter from an initial value of ∼175 to ∼250 nm. It is suggested that plasmin-induced changes in zeta-potential may promote micellar aggregation or changes in micelle stucture.     

High-pressure-induced changes in the rennet coagulation properties of bovine milk

The mechanism of high-pressure (HP)-induced changes in rennet coagulation properties of milk, particularly the role of whey protein-casein micelle associations, was studied. Treatment at 100 or 250 MPa reduced the rennet coagulation time (RCT) of raw skimmed bovine milk, compared with untreated milk. Treatment at 400 MPa had little effect, but at 600 MPa, RCT increased considerably. HP-induced increases in RCT did not occur in serum protein-free milk or milk treated with the sulphydryl-oxidising agent KIO₃, which prevents association of denatured β-lactoglobulin with casein micelles. Treatment at 5 or 10 °C at 250–600 MPa resulted in shorter RCT than treatment at 20 °C. In milk without KIO₃, coagulum strength was highest after treatment at 250 or 400 MPa, whereas in milk with KIO₃ it was highest after treatment at 400 MPa. These results indicate the significance of HP-induced association of whey proteins with casein micelles for rennet coagulation properties of milk.     

Effect of On-Farm Heating and Storage of Milk on Cottage Cheese Yield

Effect of on-farm heat treatment of milk on cottage cheese yields was studied. Fresh, raw milk heated to 74°C for 10 s was cooled and stored for 7 days at 3°C. Control and experimental lots of milk were separated and pasteurized at 72°C for 15 s and were used to make cottage cheese. Microbiological, shelf-life, flavor, and texture studies showed the experimental lots of cheese were as good as or better than control lots. Yield of cottage cheese was significantly higher when made from heated milk.     

Thermal stability of plasminogen activators and plasminogen activation in heated milk

Thermal stabilities of bovine plasminogen (PG) activators, tissue and urokinase type (t-PA and u-PA), and their impact on activation of PG, were studied after application of various heating conditions (65, 75, 85, or 90 °C for 15, 20, or 30 s), in both milk and buffer systems. Both t-PA and u-PA were thermally stable in milk heated at ⩽75 °C. However, almost half of the t-PA activity and 30% of u-PA activity was lost after heating milk at 85 °C for 30 s. A lower heat stability of both t-PA and u-PA was observed in buffer than in milk. The decrease in level of PG was more pronounced than that of active plasmin in milk heated at ⩾85 °C for 30 s; however, the residual level of PG was considerably higher than the residual level of active PL. Overall, results indicated that u-PA plays a more significant role than t-PA in the activation of PG during storage of heated milk.     

Microbiological and physicochemical stability of raw,pasteurised or pulsed electric field-treated milk

Pulsed electric field (PEF) processing was investigated as an alternative dairy preservation technology that would not compromise quality yet maintain safety. PEF processing of raw whole milk (4% fat) was conducted at two processing conditions (30 kV/cm, 22 μs, at either 53 or 63 °C outlet temperature) and compared with two thermal treatments (15 s, at either 63 or 72 °C) and a raw milk control and replicated twice. Milk bottles (2 L) from each treatment were incubated for two weeks, at 4 and 8 °C, and assessed for total plate count, pH, colour, rennetability, plasmin activity and lipid oxidation. The microbial quality of the thermal (72 °C/15 s) and PEF (63 °C) were similar. A drop in pH occurred after a change in counts was observed. Rennetability was not different between the treatments. Short chain acids dominated the volatile profile of the milk samples. Concentration of volatiles derived from microbial activity, namely 2,3-butanedione, acetic acid and other milk lipid derived short chain free fatty acids (e.g. butanoic and hexanoic acids), followed the trend of microbial activity in milk samples.Industrial relevanceResearch on the application of PEF to control spoilage and pathogenic microorganisms and enzyme systems in milk spans a wide array of processing equipment and reaction conditions. While industrial scale PEF processing of liquid milk for preservation and improved quality seems generally possible, substantiation of lower thermal damage under safe and scalable PEF conditions is required to enable economic feasibility.     

Partial renneting of pasteurised bovine milk: Casein micelle size,heat and storage stability

The effects of partial renneting at low temperature on the casein micelle (CM) size and the storage stability of milk were investigated. Low chymosin concentrations (≤ 0.03 IMCU mL^− 1) was applied to pasteurised skim milk at 4 °C and enzyme activity was terminated by thermal application at 60 °C/3 min and 85 °C/30 min, referred to as low heat (LHT) and high heat (HHT) treatment milk, respectively. The addition of rennet with concentrations of 0.01, 0.02 and 0.03 IMCU mL^− 1 for 15 min resulted in κ-casein hydrolysis of 10, 20 and 25%, respectively. Moreover, mean CM size of milk was reduced by up to 10 nm. For LHT milk, the renneted micelles appeared to be stable for up to 17 days, especially in response to the application of 0.01 IMCU mL^− 1 and at a storage temperature of 4 °C. Severe heating at 85 °C/30 min to inactivate the enzyme caused an increase in CM size.     

The use of sedimentation field-flow fractionation in the size characterization of bovine milk fat globules as affected by heat treatment

Size distribution of fat globules affects the appearance, taste and stability of milk and milk-based products. Full-fat, semi-fat and chocolate bovine milk were subjected to heat treatment within a temperature range of 50–125 °C for 1 h. Sedimentation field-flow fractionation was employed to determine the changes in mean particle diameter of milk fat globules as affected by heat treatment. The mean particle diameter of fat droplets increased with increasing heating temperature for most samples. The particle size of fat globules increased on average 40 nm (4.65%) for full-fat and 72 nm (8.52%) for semi-fat milk following the heat treatment (50–125 °C). Chocolate milk exhibited considerable increase in particle size (104 nm, 12.53%) within a certain temperature range (50–110 °C), followed by a decrease in particle size when heated at 125 °C for 1 h. Heat-induced flocculation due to attractive interactions between hydrophobic sites on denatured protein molecules on different droplets was assumed to be mainly responsible for the increases in particle size observed in this study. Extensive heat-induced denaturation of milk proteins was also indicated by Native PAGE. Sedimentation field-flow fractionation proved to be a useful technique for adequately monitoring heat-induced changes in particle size distributions in milk.     

Effect of preheating and other process parameters on whey protein reactions during skim milk powder manufacture

Skim milk powder was manufactured in a milk powder plant using different preheating temperatures, concentrate heating temperatures and spray drying temperatures. Varying the preheating conditions from 70 °C for 52 s to 120 °C for 52 s had a marked effect on the denaturation of $\beta$-lactoglobulin A, $\beta$-lactoglobulin B, $\alpha$-lactalbumin, bovine serum albumin (BSA), and immunoglobulin G. In contrast, varying concentrate heating temperature (65–74 °C) and inlet/outlet air dryer temperature (200/101 °C–160/89 °C) had a minimal effect on whey protein denaturation. Most of the whey protein denaturation and association with the casein micelle occurred in the preheating section of the powder plant. Aggregation of β-lactoglobulin (β-lg) and BSA predominantly involved disulphide bonds. Although, greater than 90% of the β-lg and BSA was denatured after preheating at 120 °C for 52 s, the extent of association with the casein micelle was lower, 50% for β-lg and 75% for BSA.     

Proteolysis and storage stability of UHT milk produced in Turkey

The effect of raw milk quality (total and psychrotrophic bacterial and somatic cell counts, proteinase and plasmin activity) and UHT temperature (145 or 150 °C for 4 s) on proteolysis in UHT milk processed by a direct (steam-injection) system was investigated during storage at 25 °C for 180 d. High proteinase activity was measured in low-quality raw milk, which had high somatic cell count, bacterial count and plasmin activity. The levels of 12% trichloroacetic acid–soluble and pH 4.6-soluble nitrogen in all milk samples increased during storage, and samples produced from low-quality milk at the lower UHT temperature (145 °C) showed the highest values. Bitterness in UHT milk processed from low-quality milk at 145 °C increased during storage; gelation occurred in that milk after 150 d. The RP-HPLC profiles of pH 4.6-soluble fraction of the UHT milk samples produced at 150 °C showed quite small number of peaks after 180 d of storage. Sterilization at 150 °C extended the shelf-life of the UHT milk by reducing proteolysis, gelation and bitterness.     

Influence of processing conditions on reducing γ-aminobutyric acid content during fortified milk production

The work studied the effects of processing conditions on the γ-aminobutyric acid (GABA) loss during fortified milk production. Bovine milk or their proteins/lactose fractions (0.66% whey protein and 2.6% casein or 4.9% lactose, w/v) containing 0.05–1.0% added γ-aminobutyric acid (w/w, based on bulk milk or these fractions) were subjected to a simulated milk technological process as following the sequential preheating (25–60 °C), homogenization (0–20 MPa), and pasteurization (62 °C/30 min, 72 °C/15 s, 95 °C/5 min, and 138 °C/2 s) or their unit processes to treat GABA. The resulting samples were characterized through GABA and lactose concentrations under various processing conditions. The amine and carboxyl groups and the structural characteristics of the resulting protein (lactose) were also examined through their concentrations (for lactose) and mass/spectral analyses, respectively. The results showed that the increase in temperature significantly promoted a reduction in GABA content. Whey protein fractions than caseins were primarily responsible for inducing GABA, whereas lactose had no remarkable effect on it. The rationale for GABA reduction is potential reactions with milk proteins/lactose, which preliminarily confirmed by the measurement of protein modification and lactose mass spectrometry.     

Use of high-pressure-treated milk for the production of reduced-fat cheese

Pasteurized (65°C, 30 min), pressurized (400 MPa, 22°C, 15 min) and pasteurized–pressurized milks were used for reduced-fat (approximately 32% of total solids) cheese production. Pressurization of milk increased the yield of reduced-fat cheese through an enhanced β-lactoglobulin and moisture retention. In addition, pressurisation of pasteurized skim milk improved its coagulation properties. The cheeses made from pasteurized–pressurized and pressurized milks showed a faster rate of protein breakdown than the cheese made from pasteurized milk, that might be mainly attributed to a higher level of residual rennet. Hardness of the experimental cheeses, as determined by both the sensory panel and instrumental analyses, decreased as the moisture content and proteolytic degradation of the cheese increased (pasteurized>pressurized>pasteurized–pressurized). In general terms, pressurization of reduced-fat milk prior to cheese-making improved cheese texture and thus accounted for a higher overall acceptability, except for the cheeses made from pasteurized–pressurized milk at 60 d of ripening, whose acceptability score was adversely affected by bitterness.     

Influence of lupin-based milk alternative heat treatment and exopolysaccharide-producing lactic acid bacteria on the physical characteristics of lupin-based yogurt alternatives

In the present study we investigated the influence of heat treatment of lupin-based (LB) milk alternatives and different exopolysaccharide (EPS)-producing lactic acid bacteria on the physical characteristics of set-type LB yogurt alternatives. LB milk alternatives, obtained from protein isolate of Lupinus angustifolius cv. Boregine, were either pasteurized at 80 °C for 60 s or ultra-high temperature (UHT) heated at 140 °C for 10 s and was fermented with Lactobacillus plantarum TMW 1.460 and 1.1468, Pediococcus pentosaceus BGT B34 and Lactobacillus brevis BGT L150. Fermentation duration was strongly affected by heat treatment: different strains needed between 25 to 35 h in UHT LB milk alternative to reach a pH of 4.5 compared to 14 to 24 h in pasteurized LB milk alternative. EPS extraction revealed slightly higher amounts of EPS for UHT LB yogurt alternatives (~ 0.5–0.9 g/l; pasteurized: ~ 0.4–0.7 g/l). The more intensive heat treatment (UHT) resulted also in better rheological (apparent viscosity, hysteresis loop area, flow point, elastic, viscous and complex modulus) and textural properties (firmness, consistency, cohesiveness and index of viscosity) of the investigated LB yogurt alternatives. Furthermore, LB yogurt alternatives out of UHT milk alternative revealed a lower tendency to syneresis, measured with siphon and centrifugation method. This work contributes to the fundamental knowledge of the textural properties of LB yogurt alternatives.     

Properties of low-fat stirred yoghurts made from high-pressure-processed skim milk

Physical properties of stirred yoghurt made from reconstituted skim milk that was high-pressure (HP)-treated at 100, 250 or 400 MPa, at 25, 70 or 90 °C, for 10 min, prior to inoculation with yoghurt cultures, were studied; portions of milk HP-treated at 25 °C were also heat-treated at 90 °C for 10 min before or after pressure treatment. Control yoghurts were made from skim milk given a heat treatment at 90 °C for 10 min. Fermentation time was not affected by treatment applied to the milk. HP treatment of skim milk at 25 °C, before or after heat treatment, gave stirred yoghurts of similar viscosities to that made from conventionally heat-treated milk. Lower viscosities were obtained when stirred yoghurts were made with milk HP-treated at elevated temperatures. A model is proposed to correlate properties of yoghurt with HP/heat-induced changes in interactions and structures of protein in the milk samples.Industrial relevanceTo meet end user expectations, the dairy industry needs to diversify its product range by tailoring specific functionalities. To meet these expectations, new processing methods such as high-pressure processing are of interest for their potential to achieve specific and/or novel functionalities and/or improve efficiencies, including reduced chemical and water use. In this paper, an investigation of the use simultaneous pressurization and heating of milk before the manufacture of stirred yoghurt is presented.     

Contribution of proteolytic activity associated with somatic cells in milk to cheese ripening

The effect of proteolytic enzymes from somatic cells on cheese quality was studied. In preliminary experiments, milk and two sodium caseinate systems (pH 6.5 and pH 5.2, the latter in the presence of 5% NaCl) were used as substrates to investigate the proteolytic activity of somatic cells recovered from mastitic milk. Urea-polyacrylamide gel electrophoretograms of hydrolysates suggested that somatic cell extracts contributed directly to proteolysis both in buffer and in milk, but that such activity was reduced by batch pasteurisation (63 °C for 30 min). Sodium caseinate was readily hydrolysed by somatic cell extracts; hydrolysis of α_s1-casein was greater at pH 5.2 and increased with level of somatic cells, suggesting that somatic cells contain proteolytic enzymes which are more active at acidic pH values. Subsequently, miniature Cheddar-type cheeses were made from batches of milk to which somatic cells were added (at levels of levels of 3×10⁵ or 6×10⁵ cells mL⁻¹), either before or after pasteurisation. Proteolysis during ripening of cheese (as measured by levels of pH 4.6-soluble nitrogen) increased with somatic cell addition, although this effect was reduced by pasteurisation after cell addition. Somatic cells may also have directly influenced cheese moisture content, which has been established as a principal indicator of quality of Cheddar-type cheese. Proteolytic enzymes of somatic cells from milk were shown to contribute directly to proteolysis in milk and cheese.     

Thermosonication versus thermal processing of skim milk and beef slurry: Modeling the inactivation kinetics of psychrotrophic Bacillus cereus spores

Non-thermal processed foods are generally cold stored and distributed. The use of ultrasound for food preservation has attracted the interest of many research groups. In the current study, the thermosonication (TS, simultaneous ultrasound and thermal process) inactivation of psychrotrophic Bacillus cereus spores was investigated (24 kHz, 210 μm, 0.33 W/mL or W/g). First, the effectiveness of a 1.5 min TS process at 70 °C in skim milk, beef slurry, cheese slurry, and rice porridge was investigated. The TS was more effective than sole thermal treatment in reducing B. cereus spores in rice porridge, beef slurry and cheese slurry by 7, 6, and 4 fold, respectively. Then, the first-order D- and z-values for TS and thermal processing in skim milk and beef slurry, and the best model to fit TS inactivation of B. cereus spores in beef slurry were determined. The D_70 °C-values in skim milk were 2.9 min for TS and 8.6 min for the thermal treatment. And in beef slurry, values of 0.4 min for TS and 2.3 min for thermal were estimated. It was found that the Log-logistic model better described the TS spore inactivation in beef slurry. The ultrasound technology required 20–30 °C lower temperatures for the same spore inactivation, which resulted in better food quality and energy saving gains.     

Evaluation of pulsed electric field and minimal heat treatments for inactivation of pseudomonads and enhancement of milk shelf-life

Pulsed Electric Field (PEF) treatment of milk provides the opportunity to increase the shelf-life of fresh milk for distribution to distant markets. PEF treatments were evaluated in sterile (UHT) milk to determine the inactivation of added spoilage Pseudomonas isolates and the subsequent gains in microbial shelf-life (time taken to reach 10⁷ CFU mL^− 1). Little inactivation of Pseudomonas was achieved at 15 or 40 °C compared with 50 or 55 °C. The greatest inactivation (> 5 logs) was achieved by processing at 55 °C with 31 kV cm^− 1 (139.4 kJ L^− 1). Heat treatment at the application temperature without PEF treatment caused minimal inactivation of Pseudomonas (only 0.2 logs), demonstrating that the inactivation of the Pseudomonas was due to the PEF treatment rather than the heat applied to the milk. At added Pseudomonas levels of 10³ and 10⁵ CFU mL^− 1, the microbial shelf-life of PEF-treated milk was extended by at least 8 days at 4 °C compared with untreated milk. The total microbial shelf-life of the PEF-treated milk was 13 and 11 days for inoculation levels of 10³ and 10⁵ CFU mL^− 1 respectively. The results indicate that PEF treatment is useful for the reduction of pseudomonads, the major spoilage bacteria of milk.Industrial relevancePseudomonads are the major psychrotrophic spoilage microflora of refrigerated, stored HTST pasteurised milk. Long-life (UHT) products are an important component of milk sales in South-East Asia, but in recent years there has been an increasing demand for less processed milk products with extended shelf-life. The recent practice of shipping fresh bulk milk from Australia to South-East Asian countries has necessitated additional heat treatment prior to export and on arrival, to achieve the required shelf-life. Pulsed electric field treatment of HTST milk, applied alone or in combination with mild heat under optimised conditions, offers the opportunity of shelf-life extension, while limiting the reduction in quality attributes of milk associated with more severe additional heat treatments.