(ZrO2)0.96(Y2O3)0.03(Al2O3)0.01陶瓷的制备及性能研究

采用化学共沉淀法制备（ZrO2）0.96（Y2O3）0.03（Al2O3）0.01的粉末, 在不同的升温速率、不同的烧结时间和不同的烧结温度等烧结工艺下制备出（ZrO2）0.96（Y2O3）0.03（Al2O3）0.01三相体系复合陶瓷. 经研究发现, 在升温速率和降温速率均为5 ℃·min^-1 的烧结制度下, 1550 ℃烧结时, 可以得到抗弯强度达998 MPa, 抗热震次数达33次, 相对密度达96%和电性能较好的烧结体.     

Acid dissolution of willemite (Zn,Mn)2 SiO4) and hemimorphite (Zn4Si2O7(OH)2 H2O)

The influence of temperature, pH, acid type, and surface area on the kinetics of the acid dissolution of natural and synthetic willemites and natural hemimorphites has been investigated. Specific rate constants, based upon areas determined by krypton adsorption measurements, were estimated from the experimental data obtained. For both willemite and hemimorphite, the rates of dissolution in different acids are shown to be related to the relative strengths of zinc-acid anion complexes. The reactivity of willemite toward acids increases with increasing replacement of zinc by manganese. Mixed chemical/diffusion control is responsible for the observed rates of willemite dissolution under the conditions studied (HNO₃, HCl, HClO₄, H₃PO₄, H₂SO₄, pH 0.31 to 3.00,T 21 to 94 °C). Estimates of the relative contributions of chemical and diffusional resistances to the overall rate have been made for the dissolution of manganese-free willemite in sulfuric acid solutions. The experimentally measured rates have been demonstrated to be in reasonable agreement with predicted overall dissolution rates. Proposals are made regarding the nature of the diffusion and chemical steps involved in the dissolution process. Hemimorphite was found to be considerably more reactive than willemite and its dissolution is primarily diffusion controlled under the conditions studied (T 20 to 76 °C, pH 2 to 3.5). Formerly a Postgraduate Research Student, Department of Metallurgy and Materials Science, Royal School of Mines, Imperial College, London     

Investigation on pumping oxygen characteristics of (Bi2O3)0.73(Y2O3)0.27 solid electrolyte

(Bi2O3)0.73(Y2O3)0.27 fine powders prepared by wet chemical precipitation method were cold isostatically pressed to form solid electrolyte tubes, and sintered at 900 ℃ for 10 h in the air. Their pumping oxygen characteristics in non-dehydrated Ar gas were investigated, where a ZrO2 (Y2O3 stabilized) oxygen sensor was used to measure the oxygen partial pressure Po2. The results showed that the Po2 value reached magnitudes of 1×10-20-1×10-10 Pa at the applied pumping oxygen voltage of 0.5 V, 1×10-37-1×10-27 Pa at 1.0 V and 1×10-53-1×10-47 Pa at 2.0 V within the temperature range from 550 to 650 ℃. Moreover, no cracks were found in the tested solid electrolyte tubes. Thus, the Bi2O3-Y2O3 system might be used in solid electrolyte oxygen pump for purifying gases.     

Activities of FexO in CaO‐(Na2O)0.1875(K2O)0.0625(Al2O3)0.25(SiO2)0.5‐FexO Pseudo‐Ternary Slags

Activities of Fe_xO in CaO‐(Na₂O)_0.1875(K₂O)_0.0625(Al₂O₃)_0.25(SiO₂)_0.5‐Fe_xO pseudo‐ternary slags were determined at 1673K by using a solid‐oxide galvanic cell; The substitution of (Na₂O)_0.1875(K₂O)_0.0625(Al₂O₃)_0.25(SiO₂)_0.5 for CaO has an effect of raising the Fe_xO activities.     

Mo(Ⅵ)-V(Ⅴ)-H_2O体系的热力学分析

通过热力学计算,绘制Mo(Ⅵ)-V(Ⅴ)-H_2O体系中不同Mo,V浓度下各物质随p H值变化的平衡图(25℃),为现行的钼钒分离技术提供理论依据。对计算结果分析可知,碱性溶液中Mo元素以单钼酸根形式存在,而V元素在弱碱性条件下即聚合为同多钒酸根。由于聚合阴离子与吸附剂的结合能力通常强于单核阴离子,故可从p H=7~8的溶液中实现Mo,V有效分离。当溶液p H值降至中性时,单钼酸根开始聚合成同多钼酸根;而p H值降至弱酸性时,同多钒酸根和同多钼酸根转变成多种钼钒杂多酸根。由于p H=6.5~7的溶液中杂多酸根的比例较少,添加试剂促进杂多酸根的解聚有助于钼钒的分离;p H=2~6的溶液中两者难以分离的原因在于杂多酸根的比例很大。     

Mechanochemical Effects in Ln_2O_3-Ln(OH)_3-(H_2O)(Ln=La,Nd) System

ＭｅｃｈａｎｏｃｈｅｍｉｃａｌＥｆｅｃｔｓｉｎＬｎ２Ｏ３Ｌｎ（ＯＨ）３（Ｈ２Ｏ）（Ｌｎ＝Ｌａ，Ｎｄ）ＳｙｓｔｅｍＤｉｍｉｔｒＴｏｄｏｒｏｖｓｋｙ，ＡｔａｎａｓＴｅｒｚｉｅｖ（ＦａｃｕｌｔｙｏｆＣｈｅｍｉｓｔｒｙ，ＵｎｉｖｅｒｓｉｔｙｏｆＳｏｆｉａ...