Determination of trichothecenes in cereals and cereal-based products by liquid chromatography-tandem mass spectrometry

A sensitive, accurate and precise method for the simultaneous determination of nivalenol (NIV), deoxynivalenol (DON), T-2 toxin (T-2) and HT-2 toxin (HT-2) in different food matrices, including wheat, maize, barley, cereal-based infant foods, snacks, biscuits and wafers, has been developed. The method, using liquid chromatography coupled with atmospheric pressure chemical ionization triple quadrupole mass spectrometry (LC-APCI-MS/MS), allowed unambiguous identification of the selected trichothecenes at low µg per kg levels in such complex food matrices. A clean-up procedure, based on reversed phase SPE Oasis® HLB columns, was used, allowing good recoveries for all studied trichothecenes. In particular, NIV recoveries significantly improved compared to those obtained by using Mycosep® #227 columns for clean-up of the extracts. Limits of detection in the various investigated matrices ranged 2.5-4.0 µg kg^-1 for NIV, 2.8-5.3 µg kg^-1 for DON, 0.4-1.7 µg kg^-1 for HT-2 and 0.4-1.0 µg kg^-1 for T-2. Mean recovery values, obtained from cereals and cereal products spiked with NIV, DON, HT-2 and T-2 toxins at levels from 10 to 1000 µg kg^-1, ranged from 72 to 110% with mean relative standard deviation lower than 10%. A systematic investigation of matrix effects in different cereals and cereal products was also carried out by statistically comparing the slopes of standard calibration curve with matrix-matched calibration curve for each of the four toxins and the eight matrices tested. For seven of the eight matrices tested, statistically significant matrix effects were observed, indicating that, for accurate quantitative analysis, matrix-matched calibration was necessary. The method was applied to the analysis of 57 samples of ground wheat originated from South Italy and nine cereal food samples collected from retail markets.     

Determination of trichothecenes in wheat by capillary gas chromatography with flame ionisation detection

Trichothecenes are mycotoxins produced by several fungal genera. The Fusarium species, mainly, can contaminate a wide range of cereals used for human and animal consumption. Trichothecenes are associated with various adverse health effects in animals and humans. Deoxynivalenol (DON) and nivalenol (NIV) are the trichothecenes most commonly found worldwide, although 3-acetyldeoxynivalenol, fusarenon X, T-2 toxin, HT-2 toxin, diacetoxyscirpenol (DAS) and neosolaniol are also found. They are included in the present study. For the determination of these trichothecenes in wheat, a method based on capillary gas chromatography (GC) with flame ionisation detection (FID) has been developed and validated. The trichothecenes are extracted from the sample matrix by acetonitrile/water (84/16, v/v). Two different Mycosep® clean-up columns are used to purify the extract. The extract is evaporated to dryness and the trichothecenes are derivatised to trimethylsilyl ethers at room temperature. The residue is dissolved in iso-octane and washed with water. The final extract is analysed for trichothecenes by GC with FID. Quantification is based on the internal standard α-chloralose. The average recoveries for the trichothecenes range from 79% for NIV to 116% for DAS. The limit of quantification is 75 μg/kg for each of the individual trichothecenes. The GC-FID method produced good results in an intercomparison study of trichothecene analysis within the European Union Standards, Measurements and Testing Programme. A survey was carried out in the Netherlands in 1999 to detect the presence of trichothecenes in imported wheat. A temporary tolerance limit of 500 μg/kg is in effect in the Netherlands for DON in cleaned wheat. Seven of the 22 wheat samples exceeded this limit; one exceeded the limit by more than 100%. Thirteen of the 22 wheat samples exceeded a proposed DON tolerance limit of 120 μg/kg for cleaned wheat. Indeed, 12 samples exceeded the limit by more than 100%. Besides DON, no trichothecenes were found in the wheat samples at levels above the limit of quantification.     

Natural occurrence of Fusarium toxins in oats harvested during five years in an area of southwest Germany.

A total of 56, 56, 54, 51, and 55 oats samples used for feed production were collected randomly after the 1987, 1989, 1990, 1991 and 1992 crops, respectively, from farms located in an area of southwest Germany. Deoxynivalenol (DON), 3- and 15-acetyl-deoxynivalenol (3-, 15-ADON), nivalenol (NIV), fusarenon-X (FUS-X), T-2 toxin (T-2), HT-2 toxin (HT-2) and diacetoxyscirpenol (DAS) were determined by gas chromatography with mass selective detection (GC-MS), zearalenone (ZEA), alpha and beta-zearalenol (alpha-, beta-ZOL) by GC-MS or by HPLC. DON was the major toxin with incidences at 49-85% and mean levels in positive samples of 52-302 micrograms/kg. Incidences of ZEA, 3-ADON, NIV, HT-2, and T-2 were at 20-37, 0-30, 18-67, 0-29, and 27-61%, respectively, with mean levels in positive samples at 8-25, 5-63, 11-192, 205-296, and 20-244 micrograms/kg, respectively. alpha- and beta-ZOL and DAS were not detected in any sample. 15-ADON and FUS-X were assayed in samples from 1987, 1991 and 1992. 15-ADON was detected in 9, 4 and 0% of samples, with an average of 9 and 18 micrograms/kg, respectively; FUS-X was not detected. The incidence and levels of toxins varied from year to year. The correlation between the occurrence of toxins and precipitation is discussed.     

Occurrence of Fusarium species and trichothecenes in Nigerian maize

A total of 180 maize samples meant for human consumption from four maize-producing states of southwestern Nigeria were screened for twelve major Fusarium mycotoxins (trichothecenes). Mycological examination of the samples showed that Fusarium verticillioides was the most commonly isolated fungi (71%), followed by F. sporotrichioides (64%), F. graminearum (32%), F. pallidoroseum (15%), F. compactum (12%), F. equiseti (9%), F. acuminatum (8%), F. subglutinans (4%) and F. oxysporum (1%). The trichothecenes include deoxynivalenol (DON), 3, mono-acetyldeoxynivalenol (3-AcDON), 15, mono-acetyldeoxynivalenol (15-AcDON), nivalenol (NIV), HT-2 toxin (HT-2), neosolaniol (NEO), T-2 toxin (T-2), T-2 tetraol and T-2 triol, diacetoxyscirpenol (DAS), MAS-monoacetoxyscirpenol (MAS) and fusarenone-X. Quantification was by high performance liquid chromatography coupled with mass spectroscopy (HPLC/MS); the detection limits for each of the mycotoxins varied between 20 and 200 microg kg(-1). Sixty six samples (36.3%) were contaminated with trichothecenes, DON (mean: 226.2 microg kg(-1); range: 9.6-745.1 microg kg(-1)), 3-AcDON (mean: 17.3 microg kg(-1); range: 0.7-72.4 microg kg(-1)) and DAS (mean: 16.0 microg kg(-1); range: 1.0-51.0 microg kg(-1)) were detected in 22%, 17% and 9% of total samples respectively. There were no 15-AcDON, NIV, HT-2, NEO, T-2, T-2 tetraol, T-2 triol, MAS and fusarenone-X detected. This is the first comprehensive report about the natural occurrence of DON, AcDON and DAS in maize for direct human consumption in Nigeria.     

Deoxynivalenol and other Fusarium toxins in wheat and rye flours on the Danish market

Information on the contamination of Danish cereals and cereal products with Fusarium toxins is limited and the last survey is from 1984/1985. In the present study, the occurrence of deoxynivalenol (DON), nivalenol (NIV), HT-2 toxin, T-2 toxin and zearalenone (ZON) was investigated in flour of common wheat, durum wheat and rye. The samples were collected from 1998 to 2001 from both mills and the retail market in Denmark. A total of 190 flour samples were analysed for DON and NIV and about 60 samples for HT-2, T-2 toxin and ZON. DON was most frequently detected with an incidence rate of 78% over all samples for all years. The contamination level varied considerably from year to year, and for wheat and rye the highest incidence and DON concentrations were found in samples from the 1998 harvest. There were regular and heavy rainfalls in Denmark during the flowering period of the crops that year, and DON was found in all samples, with mean concentrations in wheat and rye flour of 191 μg kg^-1 (n =14) and 99 μg kg^-1 (n =16), respectively. Comparison of data from each harvest year showed higher contents of DON in samples of wheat (range 20-527 μg kg^-1) than in rye (20-257 μg kg^-1). Contents of NIV, HT-2 toxin and ZON in samples of wheat and rye were generally low, and even in positive samples the contents were close to the detection limit of the methods. The T-2 toxin was detected in only a few of the wheat samples and in low amounts. However, the toxin was found in about 50% of the rye samples collected during 1998-2000, with a mean content of 49 μg kg^-1 (n =25). Durum wheat flour showed the highest DON contamination level, and all samples (n =33) collected during 2000 and 2001 contained DON with means and medians above 1100 μg kg^-1. Over 70% of the samples contained more than 500 μg kg^-1 DON, and the highest observed concentration was 2591 μg kg^-1. The concentration of T-2 toxin in durum wheat flour was also high with five of the 10 analysed samples containing more than 100 g kg^-1.     

Determination of trichothecenes in cereals and cereal-based products by liquid chromatography–tandem mass spectrometry

A sensitive, accurate and precise method for the simultaneous determination of nivalenol (NIV), deoxynivalenol (DON), T-2 toxin (T-2) and HT-2 toxin (HT-2) in different food matrices, including wheat, maize, barley, cereal-based infant foods, snacks, biscuits and wafers, has been developed. The method, using liquid chromatography coupled with atmospheric pressure chemical ionization triple quadrupole mass spectrometry (LC–APCI–MS/MS), allowed unambiguous identification of the selected trichothecenes at low µg per kg levels in such complex food matrices. A clean-up procedure, based on reversed phase SPE Oasis® HLB columns, was used, allowing good recoveries for all studied trichothecenes. In particular, NIV recoveries significantly improved compared to those obtained by using Mycosep® #227 columns for clean-up of the extracts. Limits of detection in the various investigated matrices ranged 2.5–4.0 µg kg^?1 for NIV, 2.8–5.3 µg kg^?1 for DON, 0.4–1.7 µg kg^?1 for HT-2 and 0.4–1.0 µg kg^?1 for T-2. Mean recovery values, obtained from cereals and cereal products spiked with NIV, DON, HT-2 and T-2 toxins at levels from 10 to 1000 µg kg^?1, ranged from 72 to 110% with mean relative standard deviation lower than 10%. A systematic investigation of matrix effects in different cereals and cereal products was also carried out by statistically comparing the slopes of standard calibration curve with matrix-matched calibration curve for each of the four toxins and the eight matrices tested. For seven of the eight matrices tested, statistically significant matrix effects were observed, indicating that, for accurate quantitative analysis, matrix-matched calibration was necessary. The method was applied to the analysis of 57 samples of ground wheat originated from South Italy and nine cereal food samples collected from retail markets.     

Survey of Fusarium toxins in foodstuffs of plant origin marketed in Germany

A total of 219 samples of foodstuffs of plant origin, consisting of grain-based food, pseudocereals and gluten-free food as well as vegetables, fruits, oilseeds and nuts, were randomly collected during 2000 and 2001 in food and health food stores. A spectra of 13 trichothecene toxins including diacetoxyscirpenol (DAS), 15-monoacetoxyscirpenol (MAS), scirpentriol (SCIRP), T-2 and HT-2 toxins (T-2, HT-2), T-2 triol, T-2 tetraol, neosolaniol (NEO) of the A-type as well as deoxynivalenol (DON), 3- and 15-acetyl-DON (3-, 15-ADON), nivalenol (NIV), and fusarenon-X (FUS-X) of the B-type were determined by gas chromatography/mass spectrometry. Analysis of zearalenone (ZEA), alpha- and beta-zearalenol (alpha- and beta-ZOL) was made by high-performance liquid chromatography with fluorescence and UV-detection. Detection limits ranged between 1 and 19 microg/kg. Out of 84 samples of cereal-based including gluten-free foods, 60 samples were positive for at least one of the toxins DON, 15-ADON, 3-ADON, NIV, T-2, HT-2, T-2 tetraol and ZEA, with incidences at 57%, 13%, 1%, 10%, 12%, 37%, 4% and 38%, respectively, whereas SCIRP and its derivatives MAS and DAS, T-2 triol, Fus-X as well as alpha- and beta-ZOL were not detected in any sample of this subgroup. Contents of DON ranged between 8 and 389 microg/kg, for all other toxins determined concentrations were below 100 microg/kg. The pseudocereals amaranth, quinoa and buckwheat were free of the toxins investigated. Ten of 85 samples of vegetables and fruits were toxin positive. ZEA and the type A trichothecenes MAS, SCIRP, DAS, HT-2 were detected in 7, 3, 2, 1 and 1 samples, respectively. Out of 35 samples of oilseeds and nuts, 7 samples were toxin positive. HT-2, T-2 and ZEA were detected in 4, 3 and 4 samples, respectively. In vegetables and fruits as well as in oilseeds and nuts, toxin levels were below 50 microg/kg. None of the B-type trichothecenes analysed was found for both subgroups.     

Removal of common Fusarium toxins in vitro by strains of Lactobacillus and Propionibacterium

This study was conducted to examine the ability of selected strains of Lactobacillus and Propionibacterium to remove common Fusarium toxins, trichothecenes, from liquid media. The trichothecenes studied were deoxynivalenol (DON), 3-acetyldeoxynivalenol (3-AcDON), nivalenol (NIV), fusarenon (FX), diacetoxyscirpenol (DAS), T-2 toxin (T-2) and HT-2 toxin (HT-2). The Lactobacillus rhamnosus strain GG (LGG), Lactobacillus rhamnosus strain LC-705 (LC-705) and Propionibacterium freudenreichii ssp. shermanii JS (PJS) were incubated in PBS buffer containing 20 µg toxin ml -1 for 1h at 37°C, and after centrifugation the concentration of the toxins was measured in the supernatant fraction. Both viable and heat-killed forms of LGG and PJS were more efficient than LC-705 in removing the toxins from the liquid media. LGG and PJS removed four of the seven tested toxins (the removal varying from 18 to 93%) and LC-705 two toxins (10-64%). Of the toxins, 3-AcDON was not removed by any of the bacteria; HT-2 was removed by the non-viable LGG and also slightly by non-viable LC-705; DAS was removed by all three bacteria tested. Binding is postulated as the possible mechanism of the removal, since no difference was observed between the ability of viable and heat-killed bacteria in removing the trichothecenes, and no degradation products of the toxins were detected by gas chromatography (GC)-mass spectrometry (MS) analysis. It is concluded that significant differences exist in the ability of the bacteria to bind trichothecenes in vitro.     

Contents of Fusarium toxins in Finnish and imported grains and feeds

The aim of the present study was to investigate the levels of trichothecenes in representative samples of Finnish and imported cereals and feeds from the 1987 and 1988 crops. Trichothecene concentrations were determined in samples as trimethylsilylether derivatives by a gas chromatograph equipped with a mass selective detector (GC-MSD) using selected ion monitoring (SIM) which proved to be a reliable and sufficiently sensitive technique. Representative samples of Finnish and imported oats, wheat, barley, rye, maize gluten, soy granules, rapeseed, turnip rapeseed, fish meal, poultry feed and pig feed were analysed employing 19-nortestosterone as an internal standard. Almost all grain and feed samples contained deoxynivalenol (DON) from 7 to 300 micrograms/kg and smaller amounts (13-120 micrograms/kg) of 3-acetyldeoxynivalenol (3-AcDON). The most toxic trichothecenes, T-2, HT-2 toxins and nivalenol (NIV) and also zeralenone (ZEN) were found at low concentrations in some samples. Six lots of oats containing 1.3-2.6 mg/kg of DON and 0.2-0.6 mg/kg of 3-AcDON were found in the Finnish grain samples. Silo samples of almost all imported grains contained DON but at levels below 50 micrograms/kg. Imported grains contained no other trichothecenes. DON, 3-AcDON and ZEN were found in imported feedstuffs at low concentrations.     

Effect of time, temperature and solvent on the stability of T-2 toxin, HT-2 toxin, deoxynivalenol and nivalenol calibrants

The influence of solvent, storage time and temperature on the stability of the trichothecene mycotoxins T-2 toxin (T-2), HT-2 toxin (HT-2), deoxynivalenol (DON) and nivalenol (NIV) was investigated. Toxins in acetonitrile, ethyl acetate or as thin film were stored in sealed glass ampoules at -18, 4, 25 and 40°C for up to 24 months. Samples were analysed by HPLC with UV detection. The results show that acetonitrile was the preferred solvent and no significant ( t 0.95 -test) decomposition occurred for any of the four trichothecenes when stored for 24 months at 25°C or 3 months at 40°C. T-2 and HT-2 in ethyl acetate or as thin film were also stable under the same conditions. DON and NIV in ethyl acetate or as thin film were stable for up to 24 months at -18°C, but a significant decomposition of DON and NIV in ethyl acetate was observed for both toxins after 24 months of storage at 4°C and after 12 months at 25°C. When stored as thin film, a significant trend of decomposition of DON occurred after 24 months of storage at 4°C and after 6 months of storage at 25°C. A significant decrease of NIV stored as thin film was observed after 9 months at 25°C. In conclusion, acetonitrile was the most suitable solvent for long-term storage of T-2, HT-2, DON and NIV.     

Incidence of trichothecenes and zearalenone in poultry feed mixtures from Slovakia

A total of 50 samples of poultry feed mixtures of Slovakian origin were analyzed for eight toxicologically significant Fusarium mycotoxins, namely zearalenone (ZON), A-trichothecenes: diacetoxyscirpenol (DAS), T-2 toxin (T-2) and HT-2 toxin (HT-2) and B-trichothecenes: deoxynivalenol (DON), 3-acetyl-deoxynivalenol (3-ADON), 15-acetyl-deoxynivalenol (15-ADON) and nivalenol (NIV). The A-trichothecenes and the B-trichothecenes were detected by means of high pressure liquid chromatography with tandem mass spectrometry detection (HPLC-MS/MS) and gas chromatography electron capture detection (GC-ECD), respectively. Reversed phase-high performance liquid chromatography with a fluorescence detector (RP-HPLC-FLD) was used for ZON detection. The most frequent mycotoxin detected was T-2, which was found in 45 samples (90%) in relatively low concentrations ranging from 1 to 130 microg kg(-1) (average 13 microg kg(-1)), followed by ZON that was found in 44 samples (88%) in concentrations ranging from 3 to 86 microg kg(-1) (average 21 microg kg(-1)). HT-2 and DON were detected in 38 (76%) and 28 (56%) samples, respectively, in concentrations of 2 to 173 (average 18 microg kg(-1)) for HT-2 and 64 to 1230 microg kg(-1) sample (average 303 microg kg(-1)) for DON. The acetyl-derivatives of DON were in just four samples, while NIV was not detected in any of the samples investigated. In as many as 22 samples (44%), a combination of four simultaneously co-occurring mycotoxins, i.e. T-2, HT-2, ZON and DON, was revealed. Despite the limited number of samples investigated during this study poultry feed mixtures may represent a risk from a toxicological point of view and should be regarded as a potential source of the Fusarium mycotoxins in Central Europe. This is the first reported study dealing with zearalenone and trichothecene contamination of poultry mixed feeds from Slovakia.     

A new solid phase extraction clean-up method for the determination of 12 type A and B trichothecenes in cereals and cereal-based food by LC-MS/MS

A new reliable and cost-efficient solid phase extraction-based clean-up method for the determination of 12 type A and B trichothecenes [deoxynivalenol (DON), nivalenol, 3-acetyldeoxynivalenol, 15-acetyldeoxynivalenol, fusarenon-X, T-2 toxin, HT-2 toxin, neosolaniol, monoacetoxy-scirpenol, diacetoxyscirpenol, T-2 triol and T-2 tetraol] in cereals and cereal-based food is presented. Furthermore, the suitability for the simultaneous determination of zearalenone is examined. Toxins were extracted from cereal samples using ACN/water (80/20, v/v), purified by means of a new Bond Elut Mycotoxin column and analyzed via liquid chromatography-electrospray ionization tandem mass spectrometry. Limits of detection were calculated for the matrix wheat and ranged from 0.3 to 5 ng/g, depending on the toxin. Average recovery rates for the tested compounds in seven cereal-based matrices have been determined ranging from 65 to 104%. The relative standard deviations of the complete method ranged from 2.67 (DON, wheat) to 20.0% (T-2 toxin, oats).     

Fusarium toxins in wheat flour collected in an area in southwest Germany

A total of 60 samples of wheat flour were collected during the first 6 months of 1999 from mills and food stores in an area in southwest Germany. Samples included whole-grain and two types of white flour with these three groups characterized by a high, medium and low ash content. The contents of deoxynivalenol (DON), nivalenol (NIV), 3- and 15-acetyldeoxynivalenol, HT-2 toxin (HT-2), T-2 toxin (T-2) and fusarenon-X (FUS-X) were determined by gas chromatography/mass spectrometry, and those of zearalenone (ZEA), alpha- and beta-zearalenol (alpha- and beta-ZOL) by high performance liquid chromatography with fluorescence detection. FUS-X, alpha- and beta-ZOL were not detected in any sample. Based on incidence and level, DON was the predominant toxin followed by NIV and ZEA for all three flour types. The overall degree of toxin contamination was lower with decreasing ash content. This suggests a localization of the toxins analyzed primarily in the outer parts of the original wheat kernels. The median DON content was significantly (P<0.05) higher for wheat flour originating from wheat of conventional than of organic production.     

A survey on the occurrence of Fusarium mycotoxins in Bavarian cereals from the 1987 harvest

Bavarian cereals and wheat flour from the 1987 harvest were analysed for nivalenol (NIV) and deoxynivalenol (DON) using high performance liquid chromatography (HPLC) and for T-2 toxin and zearalenone (ZEA) by enzyme-linked-immunosorbent assay (ELISA). The study included 190 field samples of wheat, barley, rye and oat with visibly damaged ears, 45 samples of wheat intended for feed production and two series of wheat flour (type 550) and whole wheat flour collected in October 1987 and June 1988. The field samples examined showed a high DON contamination of wheat (87%) with an average of 3.96 mg/kg and a maximum of 43.8 mg/kg. Mean levels between 0.33 mg/kg and 0.27 mg/kg DON could be detected in barley, rye and oat. Of the wheat samples, 58% contained ZEA with a maximum of 1.560 mg/kg. The highest levels of ZEA were detected in samples which also showed high concentrations of DON. The NIV and T-2 toxin levels were comparatively low. Thirty percent of the samples showed NIV concentrations between 0.04 mg/kg and 0.29 mg/kg and 38% contained between 0.005 and 0.60 mg/kg of T-2. In the wheat samples for feed production, only DON was detected with an average of 0.190 mg/kg and a maximum of 0.75 mg/kg. The highest DON levels (0.58 mg/kg) from October 1987 were found in the wheat flour samples which were lower than the highest DON concentration (3.24 mg/kg) detected in the samples collected during June 1988. This fact was probably due to a substantial amount of non-contaminated wheat from 1986. The toxin concentrations in the whole wheat flour were not higher than in the type 550 flour.(ABSTRACT TRUNCATED AT 250 WORDS)     

Survey of the presence of the Fusarium mycotoxins nivalenol, deoxynivalenol and T-2 toxin in Korean cereals of the 1989 harvest.

Twenty eight samples of rice, barley, millet, corn and Indian millet harvested in Korea in 1989 were subjected to assay for contamination of nivalenol (NIV), deoxynivalenol (DON) and T-2 toxin by using gas chromatography and gas chromatography-mass spectrometry. Seven samples were found to be positive for NIV and DON in the ranges of 189-624 micrograms/kg and 168-506 micrograms/kg, respectively. Of the contaminated samples, three samples, one barley, one Indian millet and one corn sample were contaminated simultaneously with both NIV and DON. T-2 toxin was not detected in any samples.     

A survey on the occurrence of Fusarium mycotoxins in Bavarian cereals from the 1987 harvest

Summary Bavarian cereals and wheat flour from the 1987 harvest were analysed for nivalenol (NIV) and deoxynivalenol (DON) using high performance liquid chromatography (HPLC) and for T-2 toxin and zearalenone (ZEA) by enzyme-linked-immunosorbent as say (ELISA). The study included 190 field samples of wheat, barley, rye and oat with visibly damaged ears, 45 samples of wheat intended for feed production and two series of wheat flour (type 550) and whole wheat flour collected in October 1987 and June 1988. The field samples examined showed a high DON contamination of wheat (87%) with an average of 3.96 mg/kg and a maximum of 43.8 mg/kg. Mean levels between 0.33 mg/kg and 0.27 mg/kg DON could be detected in barley, rye and oat. Of the wheat samples, 58% contained ZEA with a maximum of 1.560 mg/kg. The highest levels of ZEA were detected in samples which also showed high concentrations of DON. The NIV and T-2 toxin levels were comparatively low. Thirty percent of the samples showed NIV concentrations between 0.04 mg/kg and 0.29 mg/kg and 38% contained between 0.005 and 0.60 mg/kg of T-2. In the wheat samples for feed production, only DON was detected with an average of 0.190 mg/kg and a maximum of 0.75 mg/kg. The highest DON levels (0.58 mg/kg) from October 1987 were found in the wheat flour samples which were lower than the highest DON concentration (3.24 mg/kg) detected in the samples collected during June 1988. This fact was probably due to a substantial amount of non-contaminated wheat from 1986. The toxin concentrations in the whole wheat flour were not higher than in the type 550 flour. The regional distribution of the mean DON concentrations showed the highest levels in Middle and Lower-Franconia.

---

Vorkommen von Fusarium Mykotoxinen in bayerischem Getreide der Ernte 1987

Zusammenfassung Cerealien und Weizenmehle der bayerischen Ernte 1987 wurden mittels hochauflösender Flüssigchromatographie (HPLC) auf Nivalenol (NIV) und Deoxynivalenol (DON) Bowie mit Enzymimmunoassay auf T-2 Toxin und Zearalenon (ZEA) analysiert. Die Untersuchungen umfaßten 190 Feldproben von Weizen, Gerste, Roggen und Hafer, die alle optisch erkennbaren Fusarienbefall aufwiesen, 45 Futterweizenproben Bowie zwei Probenserien von Weizenmehlen der Type 550 und Vollkornweizenmehlen, die im October 1987 und im Juni 1988 gezogenwurden. — Die Untersuchungen der Feldproben ergaben eine hohe DON-Kontamination des Weizens (87%) mit einem durchschnittlichen Gehalt von 3,96 mg/kg und einem Maximalgehalt von 43,8 mg/kg. In Gerste, Roggen und Hafer konnten durchschnittlich zwischen 0,33 mg/kg und 0,27 mg/kg DON-nachgewiesen werden. 58% der Winterweizenproben wiesen Zearalenon mit einem Maximalgehalt von 1,56 mg/kg auf. Die höchsten ZEA-Werte wurden in Proben ermittelt, die gleichzeitig einen hohen DON-Gehalt aufwiesen. Die Konzentrationen von NIV und T-2 Toxin waren vergleichsweise niedrig. 30% der Proben hatten NIV-Gehalte zwischen 0,04 mg/kg und 0,29 mg/kg und 38% enthielten T-2 Toxin zwischen 0,005 mg/kg und 0,06 mg/kg. In den Futterweizenproben konnte DON als einziges Toxin mit einem Gehalt von durchschnittlich 0,19 mg/kg und maximal 0,75 mg/kg festgestellt werden. Die Weizenmehle, die im October 1987 gezogen wurden, wiesen maximal 0,58 mg/kg DON auf. Die Gehalte lagen damit medriger als die der Mehlproben vom Juni 1988, die maximal 3,24 mg/kg und durchschnittlich 0,26 mg/kg DON enthielten. Dieser Sachverhalt könnte auf Anteile von nicht kontaminiertem Weizen der Ernte 86 an den im October gezogenen Mehlproben zurückgeführt werden. Die Toxingehalte der Vollkornmehle waren nicht höher als die der Weizenmehle der Type 550. Die höchsten Durchschnittsgehalte von DON wurden in Mittel- und Unterfranken festgestellt.

     

Less Fusarium infestation and mycotoxin contamination in organic than in conventional cereals

A total of 602 samples of cereals, consisting of organically and conventionally produced barley, oats and wheat, were collected at harvest during 2002–2004 in Norway. Organic and conventional cereals were sampled in comparable numbers regarding cereal species, localisation and harvest time, and analysed for Fusarium mould and mycotoxins. Fusarium infestation and mycotoxin content were dependent on cereal species and varied year-by-year. However, in all cereal species, Fusarium infestation and levels of important mycotoxins were significantly lower when grown organically than conventionally. Concerning the most toxic trichothecenes, HT-2 and T-2 toxin, lower concentrations were found in organic oats and barley. Wheat was not contaminated by HT-2 and T-2, but lower concentrations of deoxynivalenol (DON) and moniliformin (MON) were found when organically produced. For mycotoxins considered to constitute the main risk to humans and animals in Norwegian cereals, i.e. HT-2 in oats and DON in oats and wheat, the median figures (mean levels in brackets) were as follows: HT-2 in organic and conventional oats were <20 (80) and 62 (117) µg/kg, DON in organic and conventional oats were 24 (114) and 36 (426) µg/kg, and DON in organic and conventional wheat were 29 (86) and 51 (170) µg/kg, respectively. Concentrations of HT-2 and T-2 in the samples were strongly correlated (r = 0.94). Other mycotoxins did not show a significant correlation to each other. Both HT-2 and T-2 concentrations were significantly correlated with infestation of F. langsethiae (r = 0.65 and r = 0.60, respectively). Concentrations of DON were significantly correlated with F. graminearum infestation (r = 0.61). Furthermore, nivalenol (NIV) was significantly correlated with infestation of F. poae (r = 0.55) and MON with F. avenaceum (r = 0.37). As lower Fusarium infestation and mycotoxin levels were found in organic cereals, factors related to agricultural practice may reduce the risk of contamination with Fusarium mycotoxins. Studies of these issues will be presented separately.     

Fusarium mycotoxin content of UK organic and conventional barley

Each year (2002–2005), approximately 100 samples of barley from fields of known agronomy were analysed for ten trichothecenes by gas chromatography-mass spectrometry (GC/MS) including deoxynivalenol (DON), nivalenol, 3-acetyl DON, 15-acetyl DON, fusarenone X, T-2 toxin (T2), HT-2 toxin (HT2), diacetoxyscirpenol, neosolaniol, and T-2 triol. Samples were also analysed for moniliformin and zearalenone by high-performance liquid chromatography (HPLC). Of the ten trichothecenes analysed from 446 harvest samples of barley, only two, diacetoxyscirpenol and neosolaniol, were not detected. The concentrations of type A trichothecenes were similar to those that occurred in wheat over the same period, whilst those of type B trichothecenes were markedly lower. Deoxynivalenol was the most frequently detected Fusarium mycotoxin, present above the limit of quantification (10 µg kg^?1) in 57% of samples, and was usually present at the highest concentration. A single sample (0.2%) exceeded the legal limit for DON in unprocessed barley over the 4-year period. Moniliformin and zearalenone were both rarely detected (2% of samples greater than 10 µg kg^?1 for both toxins) with maximum concentrations of 45 and 44 µg kg^?1, respectively. Year and region had a significant effect on DON and HT2 + T2, but there was no significant difference in the concentration of these mycotoxins between organic and conventional samples. Overall, the risk of UK barley exceeding the newly introduced legal limits for Fusarium mycotoxins in cereals intended for human consumption is very low, but the percentage of samples above these limits will fluctuate between years.     

Transfer of Fusarium mycotoxins and ‘masked’ deoxynivalenol (deoxynivalenol-3-glucoside) from field barley through malt to beer

The fate of five Fusarium toxins — deoxynivalenol (DON), sum of 15- and 3-acetyl-deoxynivalenol (ADONs), HT-2 toxin (HT-2) representing the main trichothecenes and zearalenone (ZON) during the malting and brewing processes — was investigated. In addition to these ‘free’ mycotoxins, the occurrence of deoxynivalenol-3-glucoside (DON-3-Glc) was monitored for the first time in a beer production chain (currently, only DON and ZON are regulated). Two batches of barley, naturally infected and artificially inoculated with Fusarium spp. during the time of flowering, were used as a raw material for processing experiments. A highly sensitive procedure employing high-performance liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) was validated for the analysis of ‘free’ Fusarium mycotoxins and DON-conjugate in all types of matrices. The method was also able to detect nivalenol (NIV), fusarenon-X (FUS-X) and T-2 toxin (T-2); nevertheless, none of these toxins was found in any of the samples. While steeping of barley grains (the first step in the malting process) apparently reduced Fusarium mycotoxin levels to below their quantification limits (5–10 µg kg^?1), their successive accumulation occurred during germination. In malt, the content of monitored mycotoxins was higher compared with the original barley. The most significant increase was found for DON-3-Glc. During the brewing process, significant further increases in levels occurred. Concentrations of this ‘masked’ DON in final beers exceeded ‘free’ DON, while in malt grists this trichothecene was the most abundant, with the DON/DON-3-Glc ratio being approximately 5:1 in both sample series. When calculating mass balance, no significant changes were observed during brewing for ADONs. The content of DON and ZON slightly decreased by a maximum of 30%. Only traces of HT-2 were detected in some processing intermediates (wort after trub removal and green beer).     

Transfer of Fusarium mycotoxins and 'masked' deoxynivalenol (deoxynivalenol-3-glucoside) from field barley through malt to beer

The fate of five Fusarium toxins--deoxynivalenol (DON), sum of 15- and 3-acetyl-deoxynivalenol (ADONs), HT-2 toxin (HT-2) representing the main trichothecenes and zearalenone (ZON) during the malting and brewing processes--was investigated. In addition to these 'free' mycotoxins, the occurrence of deoxynivalenol-3-glucoside (DON-3-Glc) was monitored for the first time in a beer production chain (currently, only DON and ZON are regulated). Two batches of barley, naturally infected and artificially inoculated with Fusarium spp. during the time of flowering, were used as a raw material for processing experiments. A highly sensitive procedure employing high-performance liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) was validated for the analysis of 'free' Fusarium mycotoxins and DON-conjugate in all types of matrices. The method was also able to detect nivalenol (NIV), fusarenon-X (FUS-X) and T-2 toxin (T-2); nevertheless, none of these toxins was found in any of the samples. While steeping of barley grains (the first step in the malting process) apparently reduced Fusarium mycotoxin levels to below their quantification limits (5-10 microg kg(-1)), their successive accumulation occurred during germination. In malt, the content of monitored mycotoxins was higher compared with the original barley. The most significant increase was found for DON-3-Glc. During the brewing process, significant further increases in levels occurred. Concentrations of this 'masked' DON in final beers exceeded 'free' DON, while in malt grists this trichothecene was the most abundant, with the DON/DON-3-Glc ratio being approximately 5:1 in both sample series. When calculating mass balance, no significant changes were observed during brewing for ADONs. The content of DON and ZON slightly decreased by a maximum of 30%. Only traces of HT-2 were detected in some processing intermediates (wort after trub removal and green beer).