A comparison between E-beam irradiation and high pressure treatment for cold-smoked salmon sanitation: microbiological aspects

The effectiveness of electron beam irradiation and high pressure treatment for the sanitation of cold-smoked salmon from two points of view, microbial safety and shelf-life extension, was compared. From the response of L. monocytogenes INIA H66a to irradiation, a D value of 0.51 kGy was calculated. For samples stored at 5 °C, 1.5 kGy would be sufficient to attain a Food Safety Objective (FSO) of 2 log₁₀cfu/g L. monocytogenes for a 35-day shelf-life, whereas 3 kGy would be needed in the case of a temperature abuse (5 °C + 8 °C). Pressurization at 450 MPa for 5 min was considered to be an insufficient treatment, since the FSO of 2 log₁₀cfu/g L. monocytogenes was only attained for a shelf-life of 21 days at 5 °C. However, treatment at 450 MPa for 10 min achieved this FSO for samples held during 35 days at 5 °C, or during 21 days under temperature abuse (5 °C + 8 °C) conditions. Irradiation at 2 kGy kept the microbial population of smoked salmon below 6 log₁₀cfu/g after 35 days at 5 °C, with negligible or very light changes in its odor. Pressurization at 450 MPa for 5 min also kept the microbial population below 6 log₁₀cfu/g after 35 days at 5 °C and did not alter odor, but affected negatively the visual aspect of smoked salmon.     

Fat content increases the lethality of ultra-high-pressure homogenization on Listeria monocytogenes in milk

Listeria monocytogenes CCUG 15526 was inoculated at a concentration of approximately 7.0 log₁₀ cfu/mL in milk samples with 0.3, 3.6, 10, and 15% fat contents. Milk samples with 0.3 and 3.6% fat content were also inoculated with a lower load of approximately 3.0 log₁₀ cfu/mL. Inoculated milk samples were subjected to a single cycle of ultra-high-pressure homogenization (UHPH) treatment at 200, 300, and 400 MPa. Microbiological analyses were performed 2 h after the UHPH treatments and after 5, 8, and 15 d of storage at 4°C. Maximum lethality values were observed in samples treated at 400 MPa with 15 and 10% fat (7.95 and 7.46 log₁₀ cfu/mL), respectively. However, in skimmed and 3.6% fat milk samples, complete inactivation was not achieved and, during the subsequent 15 d of storage at 4°C, L. monocytogenes was able to recover and replicate until achieving initial counts. In milk samples with 10 and 15% fat, L. monocytogenes recovered to the level of initial counts only in the milk samples treated at 200 MPa but not in the milk samples treated at 300 and 400 MPa. When the load of L. monocytogenes was approximately 3.0 log₁₀ cfu/mL in milk samples with 0.3 and 3.6% fat, complete inactivation was not achieved and L. monocytogenes was able to recover and grow during the subsequent cold storage. Fat content increased the maximum temperature reached during UHPH treatment; this could have contributed to the lethal effect achieved, but the amount of fat of the milk had a stronger effect than the temperature on obtaining a higher death rate of L. monocytogenes.     

Mixed species biofilms of Listeria monocytogenes and Lactobacillus plantarum show enhanced resistance to benzalkonium chloride and peracetic acid

We investigated the formation of single and mixed species biofilms of Listeria monocytogenes strains EGD-e and LR-991, with Lactobacillus plantarum WCFS1 as secondary species, and their resistance to the disinfectants benzalkonium chloride and peracetic acid. Modulation of growth, biofilm formation, and biofilm composition was achieved by addition of manganese sulfate and/or glucose to the BHI medium. Composition analyses of the mixed species biofilms using plate counts and fluorescence microscopy with dual fluorophores showed that mixed species biofilms were formed in BHI (total count, 8-9 log₁₀ cfu/well) and that they contained 1-2 log₁₀ cfu/well more L. monocytogenes than L. plantarum cells. Addition of manganese sulfate resulted in equal numbers of both species (total count, 8 log₁₀ cfu/well) in the mixed species biofilm, while manganese sulfate in combination with glucose, resulted in 1-2 log₁₀ more L. plantarum than L. monocytogenes cells (total count, 9 log₁₀ cfu/well). Corresponding single species biofilms of L. monocytogenes and L. plantarum contained up to 9 log₁₀ cfu/well. Subsequent disinfection treatments showed mixed species biofilms to be more resistant to treatments with the selected disinfectants. In BHI with additional manganese sulfate, both L. monocytogenes strains and L. plantarum grown in the mixed species biofilm showed less than 2 log₁₀ cfu/well inactivation after exposure for 15 min to 100 μg/ml benzalkonium chloride, while single species biofilms of both L. monocytogenes strains showed 4.5 log₁₀ cfu/well inactivation and single species biofilms of L. plantarum showed 3.3 log₁₀ cfu/well inactivation. Our results indicate that L. monocytogenes and L. plantarum mixed species biofilms can be more resistant to disinfection treatments than single species biofilms.     

Growth characteristics of Listeria monocytogenes as affected by a native microflora in cooked ham under refrigerated and temperature abuse conditions

This study examined the growth characteristics of Listeria monocytogenes as affected by a native microflora in cooked ham at refrigerated and abuse temperatures. A five-strain mixture of L. monocytogenes and a native microflora, consisting of Brochothrix spp., isolated from cooked meat were inoculated alone (monocultured) or co-inoculated (co-cultured) onto cooked ham slices. The growth characteristics, lag phase duration (LPD, h), growth rate (GR, log₁₀ cfu/h), and maximum population density (MPD, log₁₀ cfu/g), of L. monocytogenes and the native microflora in vacuum-packed ham slices stored at 4, 6, 8, 10, and 12 °C for up to 5 weeks were determined. At 4-12 °C, the LPDs of co-cultured L. monocytogenes were not significantly different from those of monocultured L. monocytogenes in ham, indicating the LPDs of L. monocytogenes at 4-12 °C were not influenced by the presence of the native microflora. At 4-8 °C, the GRs of co-cultured L. monocytogenes (0.0114-0.0130 log₁₀ cfu/h) were statistically but marginally lower than those of monocultured L. monocytogenes (0.0132-0.0145 log₁₀ cfu/h), indicating the GRs of L. monocytogenes at 4-8 °C were reduced by the presence of the native microflora. The GRs of L. monocytogenes were reduced by 8-7% with the presence of the native microflora at 4-8 °C, whereas there was less influence of the native microflora on the GRs of L. monocytogenes at 10 and 12 °C. The MPDs of L. monocytogenes at 4-8 °C were also reduced by the presence of the native microflora. Data from this study provide additional information regarding the growth suppression of L. monocytogenes by the native microflora for assessing the survival and growth of L. monocytogenes in ready-to-eat meat products.     

The effect of sodium reduction with and without potassium chloride on the survival of Listeria monocytogenes in Cheddar cheese

Sodium chloride (NaCl) in cheese contributes to flavor and texture directly and by its effect on microbial and enzymatic activity. The salt-to-moisture ratio (S/M) is used to gauge if conditions for producing good-quality cheese have been met. Reductions in salt that deviate from the ideal S/M range could result in changing culture acidification profiles during cheese making. Lactococcus lactis ssp. lactis or Lc. lactis ssp. cremoris are both used as cultures in Cheddar cheese manufacture, but Lc. lactis ssp. lactis has a higher salt and pH tolerance than Lc. lactis ssp. cremoris. Both salt and pH are used to control growth and survival of Listeria monocytogenes and salts such as KCl are commonly used to replace the effects of NaCl in food when NaCl is reduced. The objectives of this project were to determine the effects of sodium reduction, KCl use, and the subspecies of Lc. lactis used on L. monocytogenes survival in stirred-curd Cheddar cheese. Cheese was manufactured with either Lc. lactis ssp. lactis or Lc. lactis ssp. cremoris. At the salting step, curd was divided and salted with a concentration targeted to produce a final cheese with 600 mg of sodium/100 g (control), 25% reduced sodium (450 mg of sodium/100 g; both with and without KCl), and low sodium (53% sodium reduction or 280 mg of sodium/100 g; both with and without KCl). Potassium chloride was added on a molar equivalent to the NaCl it replaced to maintain an equivalent S/M. Cheese was inoculated with a 5-strain cocktail of L. monocytogenes at different times during aging to simulate postprocessing contamination, and counts were monitored over 27 or 50 d, depending on incubation temperature (12 or 5°C, respectively). In cheese inoculated with 4 log₁₀ cfu of L. monocytogenes/g 2 wk after manufacture, viable counts declined by more than 3 log₁₀ cfu/g in all treatments over 60 d. When inoculated with 5 log₁₀ cfu/g at 3 mo of cheese age, L. monocytogenes counts in Cheddar cheese were also reduced during storage, but by less than 1.5 log₁₀ cfu/g after 50 d. However, cheese with a 50% reduction in sodium without KCl had higher counts than full-sodium cheese at the end of 50 d of incubation at 4°C when inoculated at 3 mo. When inoculated at 8 mo postmanufacture, this trend was only observed in 50% reduced sodium with KCl, for cheese manufactured with both cultures. This enhanced survival for 50% reduced-sodium cheese was not seen when a higher incubation temperature (12°C) was used when cheese was inoculated at 3 mo of age and monitored for 27 d (no difference in treatments was observed at this incubation temperature). In the event of postprocessing contamination during later stages of ripening, L. monocytogenes was capable of survival in Cheddar cheese regardless of which culture was used, whether or not sodium had been reduced by as much as 50% from standard concentrations, or if KCl had been added to maintain the effective S/M of full-sodium Cheddar cheese.     

Bactericidal activity of lauric arginate in milk and Queso Fresco cheese against Listeria monocytogenes cold growth

Lauric arginate (LAE) at concentrations of 200 ppm and 800 ppm was evaluated for its effectiveness in reducing cold growth of Listeria monocytogenes in whole milk, skim milk, and Queso Fresco cheese (QFC) at 4°C for 15 to 28 d. Use of 200 ppm of LAE reduced 4 log cfu/mL of L. monocytogenes to a nondetectable level within 30 min at 4°C in tryptic soy broth. In contrast, when 4 log cfu/mL of L. monocytogenes was inoculated in whole milk or skim milk, the reduction of L. monocytogenes was approximately 1 log cfu/mL after 24 h with 200 ppm of LAE. When 800 ppm of LAE was added to whole or skim milk, the initial 4 log cfu/mL of L. monocytogenes was nondetectable following 24 h, and no growth of L. monocytogenes was observed for 15 d at 4°C. With surface treatment of 200 or 800 ppm of LAE on vacuum-packaged QFC, the reductions of L. monocytogenes within 24 h at 4°C were 1.2 and 3.0 log cfu/g, respectively. In addition, the overall growth of L. monocytogenes in QFC was decreased by 0.3 to 2.6 and by 2.3 to 5.0 log cfu/g with 200 and 800 ppm of LAE, respectively, compared with untreated controls over 28 d at 4°C. Sensory tests revealed that consumers could not determine a difference between QFC samples that were treated with 0 and 200 ppm of LAE, the FDA-approved level of LAE use in foods. In addition, no differences existed between treatments with respect to flavor, texture, and overall acceptability of the QFC. Lauric arginate shows promise for potential use in QFC because it exerts initial bactericidal activity against L. monocytogenes at 4°C without affecting sensory quality.     

Heat resistance of Listeria species to liquid whole egg ultrapasteurization treatment

The lethality of ultrapasteurization treatments (70 °C/1.5 min.) applied at constant temperature (isothermal condition) and at a constantly raising temperature of 2 °C/min (non-isothermal condition) in liquid whole egg (LWE) against two strains of Listeria monocytogenes (STCC 5672 and 4032) and one of Listeria innocua has been investigated. Isothermal survival curves up to 71 °C were obtained, which followed first-order inactivation kinetics. The obtained D_t values indicated that L. innocua was significantly (p < 0.05) more heat resistant than L. monocytogenes strains. Non-significant (p > 0.05) differences were observed among z values (12.4 ± 0.4 °C, 13.1 ± 0.4 °C and 12.2 ± 0.7 °C for L. innocua and L. monocytogenes 5672 and 4032, respectively). Based on obtained D_t and z values, isothermal ultrapasteurization treatment (70 °C/1.5 min.) would provide 3.5-, 5.0-, and 6.5-Log₁₀ cycles of L. innocua and L. monocytogenes 5672 and 4032, respectively. Non-isothermal heating lag phase increased the thermotolerance of Listeria species in LWE. The simulated industrial pasteurization treatment for LWE (heating-up phase from 25 to 70 °C followed by 1.5 min. at 70 °C) would attain 5-Log₁₀ reductions of L. monocytogenes 5672 and 4032, and 3.7-Log₁₀ reductions of L. innocua. Therefore, the safety level of industrial ultrapasteurization concerning L. monocytogenes could be lower than that estimated with data obtained under isothermal conditions.     

Efficacy of bacteriophage LISTEXP100 combined with chemical antimicrobials in reducing Listeria monocytogenes in cooked turkey and roast beef

The aim of this study was to verify the effectiveness of the commercially available anti-Listeria phage preparation LISTEX^™P100 in reducing Listeria monocytogenes on ready-to-eat (RTE) roast beef and cooked turkey in the presence or absence of the chemical antimicrobials potassium lactate (PL) and sodium diacetate (SD). Sliced RTE meat cores at 4 and 10 °C were inoculated with cold-adapted L. monocytogenes to result in a surface contamination level of 10³ CFU/cm². LISTEX^TMP100 was applied at 10⁷ PFU/cm² and samples taken at regular time intervals during the RTE product's shelf life to enumerate viable L. monocytogenes. LISTEX^™P100 was effective during incubation at 4 °C with initial reductions of L. monocytogenes of 2.1 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef without chemical antimicrobials (there was no significant difference to the initial L. monocytogenes reductions in the presence of LISTEX^TMP100 for cooked turkey containing PL and roast beef containing SD-PL). In the samples containing no chemical antimicrobials, the presence of phage resulted in lower L. monocytogenes numbers, relative to the untreated control, of about 2 log CFU/cm² over a 28-day storage period at 4 °C. An initial L. monocytogenes cell reduction of 1.5 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef containing no chemical antimicrobials was achieved by the phage at 10 °C (abusive temperature). At this temperature, the L. monocytogenes cell numbers of samples treated with LISTEX™ P100 remained below those of the untreated control only during the first 14 days of the experiment for roast beef samples with and without antimicrobials. On day 28, the L. monocytogenes numbers on samples containing chemical antimicrobials and treated with LISTEX^TMP100 stored at 4 and 10 °C were 4.5 log₁₀ CFU/cm² and 7.5 log₁₀ CFU/cm², respectively, for cooked turkey, and 1.2 log₁₀ CFU/cm² and 7.2 log₁₀ CFU/cm², respectively, for roast beef. In both cooked turkey samples with and without chemical antimicrobials stored at 10 °C, the phage-treated samples had significantly lower numbers of L. monocytogenes when compared to the untreated controls throughout the 28-day storage period (P < 0.0001). For roast beef and cooked turkey containing chemical antimicrobials treated with LISTEX^TMP100 and stored at 4 °C, no more than a 2 log CFU/cm² increase of L. monocytogenes was observed throughout the stated shelf life of the product. This study shows that LISTEX^™P100 causes an initial reduction of L. monocytogenes numbers and can serve as an additional hurdle to enhance the safety of RTE meats when used in combination with chemical antimicrobials.     

Direct application of supercritical carbon dioxide for the reduction of Cronobacter spp. (Enterobacter sakazakii) in end products of dehydrated powdered infant formula

The objective of this study was to develop a viable new method for inactivation of Cronobacter spp. that could be applied directly to dehydrated powdered infant formula (PIF) using supercritical carbon dioxide (SC-CO₂). Samples inoculated with Cronobacter spp. were subjected to SC-CO₂ treatment under various conditions (temperature: 63, 68, and 73°C; pressure: 15, 20, and 25 MPa; time: 10, 20, and 30 min). The survival of Cronobacter spp. was assayed, as were any changes in the quality of the treated PIF. Inactivation of Cronobacter spp. by SC-CO₂ was enhanced as temperature and pressure conditions increased (>6.32 log₁₀ cfu/g). In a validation assay using low-level inoculation (3.21 log₁₀ cfu/g), treatment at 73°C and 15 MPa for 30 min, 20 MPa for 20 and 30 min, or 25 MPa for 20 and 30 min reduced Cronobacter spp. to undetectable levels, with no recovery of cell viability. There was no significant change in water activity, pH, and color of the treated PIF. Overall, the optimum conditions for elimination of Cronobacter spp. were determined to be 73°C and 20 MPa for 20 min. These parameters for effective SC-CO₂ treatment are feasibly applicable to end product of dehydrated PIF. The results of our study may contribute to the development of an efficient method for improving the microbiological safety of PIF.     

Fate of Staphylococcus aureus in cheese treated by ultrahigh pressure homogenization and high hydrostatic pressure

We evaluated the influence of ultrahigh pressure homogenization (UHPH) treatment applied to milk containing Staphylococcus aureus CECT 976 before cheese making, and the benefit of applying a further high hydrostatic pressure (HHP) treatment to cheese. The evolution of Staph. aureus counts during 30 d of storage at 8°C and the formation of staphylococcal enterotoxins were also assessed. Milk containing approximately 7.3 log₁₀ cfu/mL of Staph. aureus was pressurized using a 2-valve UHPH machine, applying 330 and 30 MPa at the primary and the secondary homogenizing valves, respectively. Milk inlet temperatures (T_in) of 6 and 20°C were assayed. Milk was used to elaborate soft-curd cheeses (UHPH cheese), some of which were additionally submitted to 10-min HHP treatments of 400 MPa at 20°C (UHPH+HHP cheese). Counts of Staph. aureus were measured on d 1 (24 h after manufacture or immediately after HHP treatment) and after 2, 15, and 30 d of ripening at 8°C. Counts of control cheeses not pressure-treated were approximately 8.5 log₁₀ cfu/g showing no significant decreases during storage. In cheeses made from UHPH treated milk at T_in of 6°C, counts of Staph. aureus were 5.0 ± 0.3 log₁₀ cfu/g at d 1; they decreased significantly to 2.8 ± 0.2 log₁₀ cfu/g on d 15, and were below the detection limit (1 log₁₀ cfu/g) after 30 d of storage. The use of an additional HHP treatment had a synergistic effect, increasing reductions up to 7.0 ± 0.3 log₁₀ cfu/g from d 1. However, for both UHPH and UHPH+HHP cheeses in the 6°C T_in samples, viable Staph. aureus cells were still recovered. For samples of the 20°C T_in group, complete inactivation of Staph. aureus was reached after 15 d of storage for both UHPH and UHPH+HHP cheese. Staphylococcal enterotoxins were found in controls but not in UHPH or UHPH+HHP treated samples. This study shows a new approach for significantly improving cheese safety by means of using UHPH or its combination with HHP.     

Heat-treatment of bovine colostrum. II: effects of heating duration on pathogen viability and immunoglobulin G

Batches (30-L) of first-milking bovine colostrum, inoculated with Mycoplasma bovis (10⁸ cfu/mL), Listeria monocytogenes (10⁶ cfu/mL), Escherichia coli O157:H7 (10⁶ cfu/mL), Salmonella enteritidis (10⁶ cfu/mL), and Mycobacterium avium subsp. paratuberculosis (Map; 10³ cfu/mL), were heat-treated at 60°C for 120 min in a commercial on-farm batch pasteurizer system. Duplicate 50-mL subsamples of colostrum were collected at 15-min intervals throughout the heat-treatment process for the purpose of bacterial culture and for measurement of IgG concentration (mg/mL) and antibody activity [log₂(bovine viral diarrhea virus type 1 serum neutralization titer)]. Four replicate batches of colostrum were run for each of the 5 pathogens studied. There was no effect of heating moderate- to high-quality colostrum at 60°C for at least 120 min on mean IgG concentration (pre = 60.5 mg/mL; post = 59.1 mg/mL). Similarly, there was no effect of heat-treatment on the mean log₂ bovine viral diarrhea virus type 1 serum neutralization titer (pre = 12.3; post = 12.0). Viable M. bovis, L. monocytogenes, E. coli O157:H7, and S. enteritidis added to colostrum could not be detected after the colostrum was heat-treated at 60°C for 30 min. Average bacteria counts showed that Map was not detected when batches were heated at 60°C for 60 min. Although the authors believe that heat-treating colostrum at 60°C for 60 min should be sufficient to eliminate Map from colostrum in most situations, further research is needed to determine whether these findings may be replicated, given that variability was observed in Map culture results.     

Pasteurization of grapefruit juice using a centrifugal ultraviolet light irradiator

Studies are lacking on the nonthermal pasteurization of liquid foods using UV irradiators that centrifugally form very thin films to overcome the problem of limited penetration depth of UV. Grapefruit juice inoculated with Escherichia coli or Saccharomyces cerevisiae was processed at the following conditions: UV dose 4.8–24 mJ/cm²; treatment time 3.2 s, cylinder rotational speed 450–750 rpm, cylinder inclination angle 15–45°, outlet temperature 11 °C, and flow rate 300 ml/min, and was stored for 35 days. Appropriate dilutions of the samples were pour plated with TSA and TSA + 3% NaCl for E. coli and Sabouraud dextrose agar (SDA) and SDA + 5% NaCl for S. cerevisiae. Nonthermal UV processing at 19 mJ/cm², 450 rpm and 15° reduced E. coli in grapefruit juice by 5.1 log₁₀. A dose of 14 mJ/cm² reduced S. cerevisiae by 6.0 log₁₀. Inactivation increased linearly with increasing UV dose. The inactivations at 600 and 750 rpm were similar, and were better than at 450 rpm. The results at 30° and 45° were similar, and were better than at 15°. The occurrence of sublethal injury in either microorganism was not detected. Storing UV processed grapefruit juice at 4 and 10 °C reduced the surviving E. coli to below 1 log₁₀ cfu/ml in 14 days. Processing UV juice reduced the population of S. cerevisiae to less than 1 log₁₀ cfu/ml where it remained for 35 days during refrigerated storage. These results suggest that grapefruit juice may be pasteurized using a nonthermal UV irradiator that centrifugally forms a thin film.     

Effect of hydrostatic high-pressure processing on the chemical,functional, and rheological properties of starter-free Queso Fresco

Queso Fresco (QF), a popular high-moisture, high-pH Hispanic-style cheese sold in the United States, underwent high-pressure processing (HPP), which has the potential to improve the safety of cheese, to determine the effects of this process on quality traits of the cheese. Starter-free, rennet-set QF (manufactured from pasteurized, homogenized milk, milled before hooping, and not pressed) was cut into 4.5- × 4.5- × 15-cm blocks and double vacuum packaged. Phase 1 of the research examined the effects of hydrostatic HPP on the quality traits of fresh QF that had been warmed to a core temperature of 20 or 40°C; processed at 200, 400, or 600 MPa for 5, 10, or 20 min; and stored at 4°C for 6 to 8 d. Phase 2 examined the long-term effects of HPP on quality traits when QF was treated at 600 MPa for 3 or 10 min, and stored at 4 or 10°C for up to 12 wk. Warming the QF to 40°C before packaging and exposure to high pressure resulted in loss of free whey from the cheese into the package, lower moisture content, and harder cheese. In phase 2, the control QF, regardless of aging temperature, was significantly softer than HPP cheeses over the 12 wk of storage. Hardness, fracture stress, and fracture rigidity increased with length of exposure time and storage temperature, with minor changes in the other properties. Queso Fresco remained a bright white, weak-bodied cheese that crumbled and did not melt upon heating. Although high pressures or long processing times may be required for the elimination of pathogens, cheese producers must be aware that HPP altered the rheological properties of QF and caused wheying-off in cheeses not pressed before packaging.     

Growth potential of Listeria monocytogenes strains in mixed ready-to-eat salads

In this study, a microbiological challenge test in three artificially contaminated retail mixed mayonnaise-based ready-to-eat salads stored at refrigerator temperatures (3 °C and 7 °C) for 48 h was carried out. Shrimp-tomato salad, smoked ham salad and garlic cheese salad were separately contaminated by a suspension of particular Listeria monocytogenes strains. The number of L. monocytogenes, Enterobacteriaceae, staphylococci and total plate count (CFU/g) was determined. Listeria monocytogenes growth potential in the salads was calculated and evaluated.A significant increase in total plate count and L. monocytogenes count throughout storage of all three investigated salads was found. Enterobacteriaceae levels were high at the beginning in all salads but significantly (p < 0.05) decreased throughout the experiment depending on the temperature.All investigated L. monocytogenes strains demonstrated growth at both temperatures but expressed different growth potential. Especially garlic cheese salad and smoked ham salad were able to support the growth of Listeria. Shrimp-tomato salad supported growth the least. The growth potential increased with the increasing temperature and exceeded 0.5 log₁₀ CFU/g in many cases. If the potential for growth is > 0.5 log₁₀ CFU/g, food products can potentially endanger human health. Reference strain (ATCC 7644) showed the least growth potential almost in all cases in comparison with strains isolated from frozen pollock loins and from thermally treated specialty sausage containing preservatives. To eliminate the occurrence of microbiological risks, the shelf-life of the studied salads was estimated.     

Application of high pressure processing to reduce verotoxigenic E. coli in two types of dry-fermented sausage

The effect of high pressure processing (HPP) on the survival of verotoxigenic Escherichia coli (VTEC) in two types of Norwegian type dry-fermented sausages was studied. Two different types of recipes for each sausage type were produced. The sausage batter was inoculated with 6.8 log₁₀ CFU/g of VTEC O103:H25. After fermentation, drying and maturation, slices of finished sausages were vacuum packed and subjected to two treatment regimes of HPP. One group was treated at 600 MPa for 10 min and another at three cycles of 600 MPa for 200 s per cycle. A generalized linear model split by recipe type showed that these two HPP treatments on standard recipe sausages reduced E. coli by 2.9 log₁₀ CFU/g and 3.3 log₁₀ CFU/g, respectively. In the recipe with higher levels of dextrose, sodium chloride and sodium nitrite E. coli reduction was 2.7 log₁₀ CFU/g in both treatments. The data show that HPP has a potential to make the sausages safer and also that the effect depends somewhat on recipe.     

Antibacterial effects of natural tenderizing enzymes on different strains of Escherichia coli O157:H7 and Listeria monocytogenes on beef

This study determined the efficacy of actinidin and papain on reducing Listeria monocytogenes and three mixed strains of Escherichia coli O157:H7 populations on beef. The average reduction of E. coli O157:H7 was greater than that of L. monocytogenes and higher concentrations of either protease yielded greater reduction in bacterial populations. For instance, actinidin at 700 mg/ml significantly (p ≤ 0.05) reduced the population of L. monocytogenes by 1.49 log cfu/ml meat rinse after 3 h at 25 & 35 °C, and by 1.45 log cfu/ml rinse after 24 h at 5 °C, while the same actinidin concentration significantly reduced the populations of three mixed strains of E. coli O157:H7 by 1.81 log cfu/ml rinse after 3 h at 25 & 35 °C, and 1.94 log cfu/ml rinse after 24 h at 5 °C. These findings suggest that, in addition to improving the sensory attributes of beef, proteolytic enzymes can enhance meat safety when stored at suitable temperatures.     

Identification of dairy farm management practices associated with the presence of psychrotolerant sporeformers in bulk tank milk

Some strains of sporeforming bacteria (e.g., Bacillus spp. and Paenibacillus spp.) can survive pasteurization and subsequently grow at refrigeration temperatures, causing pasteurized fluid milk spoilage. To identify farm management practices associated with different levels of sporeformers in raw milk, a bulk tank sample was obtained from and a management and herd health questionnaire was administered to 99 New York State dairy farms. Milk samples were spore pasteurized [80°C (176°F) for 12 min] and subsequently analyzed for most-probable number and for sporeformer counts on the initial day of spore pasteurization (SP), and after refrigerated storage (6°C) at 7, 14, and 21 d after SP. Management practices were analyzed for association with sporeformer counts and bulk tank somatic cell counts. Sixty-two farms had high sporeformer growth (≥3 log cfu/mL at any day after SP), with an average sporeformer count of 5.20 ± 1.41 mean log₁₀ cfu/mL at 21 d after SP. Thirty-seven farms had low sporeformer numbers (<3 log cfu/mL for all days after SP), with an average sporeformer count of 0.75 ± 0.94 mean log₁₀ cfu/mL at 21 d after SP. Farms with >25% of cows with dirty udders in the milking parlor were 3.15 times more likely to be in the high category than farms with ≤10% of milking cows with dirty udders. Farms with <200 cows were 3.61 times more likely to be in the high category than farms with ≥200 cows. Management practices significantly associated with increased bulk tank somatic cell count were a lack of use of the California mastitis test at freshening and >25% of cows with dirty udders observed in the milking parlor. Changes in management practices associated with cow cleanliness may directly ensure longer shelf life and higher quality of pasteurized fluid milk.     

Effects of γ-irradiation on Listeria monocytogenes population,colour, texture and sensory properties of Feta cheese during cold storage

Feta, a white brine cheese, was produced and contaminated with Listeria monocytogenes. Contamination occurred either at the beginning (pre-process contamination) or at the end of Feta manufacturing (post-process contamination). In the first case the milk was contaminated with 10³ cfu/ml, and 2 months later, in the final product, the L. monocytogenes population was approximately 10⁵ cfu/g. In the second case, the brine (NaCl, 7% w/v), in which the Feta was packaged, was contaminated with 10³ cfu/ml. Contaminated Feta samples were vacuum-packaged and exposed to irradiation doses of 1.0, 2.5 and 4.7 kGy and stored at 4 °C for a month. In the pre-process contaminated samples none of the irradiation doses eliminated L. monocytogenes; however the highest dose reduced the viable population to a level which is in compliance with EC regulations. In the post-process contamination, the 2.5 kGy and 4.7 kGy doses reduced L. monocytogenes counts below the detection limit. Irradiation had no effect on the texture of Feta. Irradiation at 4.7 kGy increased Feta's redness and decreased its yellowness and lightness. Sensorial analyses showed that at the 4.7 kGy dose, the aroma profile of Feta was temporarily affected, since it was restored after 30 days of cold storage.     

Synergistic antimicrobial effect of pyrophosphate on Listeria monocytogenes and Escherichia coli O157 in modified atmosphere packaged and refrigerated seabass slices

Effect of pyrophosphate (PP) in combination with modified atmosphere (MAP) (80% CO₂, 10% O₂ and 10% N₂) on the survival of Listeria monocytogenes and Escherichia coli O157 inoculated on seabass slices stored at 4 °C was investigated. PP pretreatment showed the synergistic effect on microbiological inhibition with MAP as evidenced by the lowered TVC and LAB counts, compared with samples stored in air and those kept under MAP. Microbiological changes of seabass slices inoculated with different levels of L. monocytogenes or E.coli O157 (10³ and 10⁵ cfu/g) were monitored during storage. PP pretreatment reduced colony count of E. coli O157 and extended the lag phase of L. monocytogenes. Therefore, MAP in combination with PP pretreatment not only retarded microbiological deterioration of seabass slices but also reduced or inactivated some pathogenic bacteria to some extent.     

A predictive model for heat inactivation of Listeria monocytogenes biofilm on buna-N rubber

The purpose of this study was to develop a predictive model for the heat inactivation of Listeria monocytogenes in monoculture (strains Scott A and 3990) and with competing bacteria (Pseudomonas sp. and Pantoea agglomerans) formed on buna-N rubber with and without the presence of food-derived soil. Biofilms were produced on rubber disks in dilute Tryptic Soy broth (dTSB) with incubation for 48 h at 25 °C. Duplicate biofilm samples were heat treated for 1, 3, 5, and 15 min at 70, 72, 75, 77 and 80 °C and tested for survivors using enrichment media. The experiment was repeated six times. A predictive model was developed and plots were generated showing the percent probability of L. monocytogenes inactivation in biofilms after heat treatment. For example, to achieve a 95% probability level of complete inactivation required heat treatment of 76 °C for 6 min. The predicted model was validated using a five-strain cocktail of L. monocytogenes. The validated prediction model indicates that with proper maintenance of the time/temperature controls L. monocytogenes in biofilms on rubber surfaces will be inactivated. This model can be used as a tool in the selection of hot water sanitation processes for rubber surfaces.