Microstructural, textural, and sensory characteristics of probiotic yogurts fortified with sodium calcium caseinate or whey protein concentrate

The influence of milk protein-based ingredients on the textural characteristics, sensory properties, and microstructure of probiotic yogurt during a refrigerated storage period of 28 d was studied. Milk was fortified with 2% (wt/vol) skim milk powder as control, 2% (wt/vol) sodium calcium caseinate (SCaCN), 2% (wt/vol) whey protein concentrate (WPC) or a blend of 1% (wt/vol) SCaCN and 1% (wt/vol) WPC. A commercial yogurt starter culture and Bifidobacterium lactis Bb12 as probiotic bacteria were used for the production. The fortification with SCaCN improved the firmness and adhesiveness. Higher values of viscosity were also obtained in probiotic yogurts with SCaCN during storage. However, WPC enhanced water-holding capacity more than the caseinate. Addition of SCaCN resulted in a coarse, smooth, and more compact protein network; however, WPC gave finer and bunched structures in the scanning electron microscopy micrographs. The use of SCaCN decreased texture scores in probiotic yogurt; probably due to the lower water-holding capacity and higher syneresis values in the caseinate-added yogurt sample. Therefore, the textural characteristics of probiotic yogurts improved depending on the ingredient variety.     

Effects of partially replacing skimmed milk powder with dairy ingredients on rheology, sensory profiling, and microstructure of probiotic stirred-type yogurt during cold storage

This study aimed to evaluate the quality of stirred-type skim milk probiotic yogurt fortified by partially replacing skim milk powder (SMP) with whey protein concentrate (WPC) and sodium caseinate (Na-CN) during cold storage for 28 d compared with nonfortified yogurt. The rheological properties (as measured using dynamic oscillation) and sensory profiles of probiotic yogurts were greatly enhanced when SMP (i.e., 45%) was replaced with WPC and Na-CN. Higher values of mechanical parameters related to storage and loss modulus and consistent microstructure were found in the fortified yogurts. The acidification profile was not affected by supplementation of the solids in the milk base, and the viable counts of probiotic microbiota were high and satisfactory. These positive characteristics of probiotic yogurts were maintained until the end of the storage period. The microstructure of the fortified yogurt showed some differences compared with the nonfortified product, which were due to changes in chemical composition of the milk base in addition to the colloidal characteristics of the product.     

蛋白质强化对搅拌型酸奶品质特性的影响

为了研究蛋白质强化对搅拌型酸奶品质特性的影响,以脱脂奶粉(SMP)和乳清浓缩蛋白-80(WPC-80)作为蛋白源,研究了强化不同种类及不同含量(2.7%、3.1%、3.5%、3.9%)的蛋白质强化对搅拌型酸奶感官品质、黏度和持水性的影响。结果表明:用SMP和WPC-80强化原料乳的蛋白质均可提高搅拌型酸奶的感官品质、黏度和持水性;比较同种蛋白源、不同蛋白质强化水平制得的搅拌型酸奶,其组织状态变化明显,风味稍有变化,色泽保持不变;酸奶的黏度和持水性都随蛋白质水平的上升而显著提高。SMP强化蛋白质含量至2.7%时,酸奶的感官品质最好;WPC-80含量则在3.5%时,酸奶的感官品质最好。同一蛋白质水平、不同强化蛋白相比较,WPC-80强化酸奶比SMP有更好的感官品质和更高的持水性,而SMP强化则得到更高的黏度值;从感官评定的黏稠度得分和测得的黏度值对比得出,搅拌型酸奶的黏度并不是越高越好,最佳黏度值在537～712mPa.s之间。实验中搅拌型酸奶的最佳蛋白强化配方为WPC-80强化蛋白质含量3.5%。     

How is an ideal satiating yogurt described? A case study with added-protein yogurts

Protein is recognized as the macronutrient with the highest satiating ability. Yogurt can be an excellent basis for designing satiating food as it is protein-based food product. Five different set-type yogurts were formulated by adding extra skim milk powder (MP), whey protein concentrate (WPC), calcium caseinate (CAS) or a blend of whey protein concentrate with calcium caseinate (CAS–WPC). A control yogurt without extra protein content was also prepared. Differences in sensory perceptions (through CATA questions) were related to the consumers' expected satiating ability and liking scores (of several modalities). In addition, an “Ideal satiating yogurt” was included in the CATA question to perform a penalty analysis to show potential directions for yogurt reformulation and to relate sensory and non-sensory yogurt characteristics to satiating capacity.     

Application of whey protein emulsion gel microparticles as fat replacers in low-fat yogurt: Applicability of vegetable oil as the oil phase

Low-fat, healthy yogurt is becoming increasingly favored by consumers. In the present study, whey protein emulsion gel microparticles were used to improve the quality of low-fat yogurt, and the effects of vegetable oil emulsion gel as a fat substitute on the qualities of low-fat yogurt were investigated, expecting to obtain healthier and even more excellent quality low-fat yogurt by applying a new method. First, emulsion gel microparticles were prepared, and then particle size distribution of emulsion gel and water holding capacity (WHC), textural properties, rheological properties, microstructure, storage stability, and sensory evaluation of yogurt were carried out. The results showed that yogurt with emulsion gel had significantly superior qualities than yogurt made with skim milk powder, with better WHC, textural properties, rheological properties, and storage stability. The average particle size of whey protein-vegetable oil emulsion gel microparticles was significantly larger than that of whey protein-milk fat emulsion gel microparticles, and the larger particle size affected the structural stability of yogurt. The WHC of yogurt made with whey protein-vegetable oil emulsion gel microparticles (V-EY) was lower (40.41%) than that of yogurt made with whey protein-milk fat emulsion gel microparticles (M-EY; 42.81%), and the texture results also showed that the hardness, consistency, and viscosity index of V-EY were inferior to these of M-EY, whereas no significant differences were found in the cohesiveness. Interestingly, the microstructure of V-EY was relatively flatter, with more and finer network branching. The whey separation between V-EY and M-EY also did not show significant differences during the 14 d of storage. Compared with yogurt made with whey protein, vegetable oil, and skim milk powder, the structure of V-EY remained relatively stable and had no cracks after 14 d of storage. The sensory evaluation results found that the total score of V-EY (62) was only lower than M-EY (65) and significantly higher than that of yogurt made with skim milk powder. The emulsion gel addition improved the sensory qualities of yogurt. Whey protein emulsion gel microparticles prepared from vegetable oil can be applied to low-fat yogurt to replace fat and improve texture and sensory defects associated with fat reduction.     

Effects of Polymerized Whey Proteins on Consistency and Water-holding Properties of Goat's Milk Yogurt

ABSTRACT The effects of polymerized whey proteins (PWP) on functional properties of goat's milk yogurt were investigated. PWP were prepared by heating whey protein isolate (WPI) dispersion (8.0% protein, pH 7.0) at 90 °C for 30 min. Three reconstituted goat milk (RGM) (12% total solids [TS] as control; RGM with 2.4% unheated WPI; and RGM with 2.4% PWP) and 1 RGM with 16.7% TS were prepared and inoculated with 0.04% yogurt starter culture. Inoculated milk was incubated at 43 °C for 5 h, cooled to 4 °C in an ice‐water bath, and then placed at refrigerator (4 °C) overnight before testing. Incorporation of PWP significantly (P < 0.001) increased the viscosity (by 80%) and decreased the syneresis (by 25%) of the yogurt samples, whereas addition of unheated WPI did not significantly affect the viscosity and syneresis compared with the control. There were no changes in pH, TS, ash, fat, protein, and lactose contents among yogurt samples except the solids fortified control. Yogurt with 16.7% TS had the lowest syneresis but did not improve in viscosity. Transmission electron microscopy micrographs demonstrated that the microstructure of the goat's milk yogurt gel with PWP was denser than the control. Results of this study indicate that polymerized whey proteins may be a novel protein‐based thickening agent for improving the functional properties of goat's milk yogurt and other similar products.     

Effects of varying time/temperature-conditions of pre-heating and enzymatic cross-linking on techno-functional properties of reconstituted dairy ingredients

The effects of varying time/temperature-conditions of pre-heating and cross-linking with transglutaminase (TG) on the functional properties of reconstituted products from skim milk, WPC and sodium caseinate was analyzed. The degree of cross-linking (DC) of skim milk proteins could be increased from 54.4% to 70.5% by varying process conditions. Thereby the water-holding capacity (WHC) increased from 10% to 20%, while the heat stability decreased. The burning-on was lower than that of the non-treated products at optimum pre-heating conditions (90 °C/30 s). Using sodium caseinate as substrate for TG the DC increased from 39.2% to 100% due to the improvement of the process. As a result the WHC increased by 30% and the heat stability up to 380%. However, the burning-on of casein increased as well. TG-treated sodium caseinate started to gel at 10% protein, whereas untreated sodium caseinate gelled not before 15% protein. The WHC of enzyme-treated whey proteins was lowered. The heat stability of WPC could be doubled by TG-treatment, and the burning-on of the products was, especially at optimum pre-heating conditions, less pronounced. The degree of denaturation of TG-treated whey proteins was 2–5% higher than that of untreated samples.     

FUNCTIONALITY OF MILK PROTEINS AND CORN GERM PROTEIN FLOUR IN COMMINUTED MEAT PRODUCTS1

Effects of corn germ protein flour (CGPF), nonfat dry milk (NFDM), whey protein concentrate (WPC), and sodium caseinate (SC) on quality characteristics of comminuted meat products were studied. Water holding capacity (WHC) was lowest and cooking loss was highest for the control formulation, whereas formulations extended with CGPF and milk proteins were higher in WHC and lower in cooking losses. Shear force and firmness increased as extenders were added, except WPC. All frankfurters with extenders were firmer than the control, except those extended with WPC. Hue angle was highest for samples with CGPF, while no differences were found in hue angle between control and milk proteins containing samples, except samples with WPC. Frankfurters with CGPF and SC add had a stronger atypical aroma than the control. Meaty aroma score was higher for the control than for the other products, except those with WPC. Meaty flavor score was higher for the control than for all other products. The product with CGPF added had a stronger atypical flavor than the control. Frankfurters containing extenders were not as juicy as the all-meat control.     

乳清蛋白粉对凝固型酸奶品质的影响

为提高凝固型酸奶的品质及安全性,将1%、1.5%、2%、2.5%、3%、4%、5%乳清蛋白粉(Whey protein powder,WPP)加入全脂乳粉中生产酸奶,以不添加WPP的凝固型酸奶为对照组,测定酸奶酸度、持水力(WHC)、脱水收缩敏感性(STS)、质构特性、流变学特性和微观结构变化,并进行感官评定,研究不同添加量乳清蛋白粉对凝固型酸奶品质特性的影响,以确定WPP最适添加量。结果表明:随着乳清蛋白粉添加量的增加,酸奶的滴定酸度、持水力、乳酸菌总数、硬度、胶着性、粘弹性、凝胶性逐渐增加,脱水收缩敏感性(STS)逐渐减小;当WPP添加量为2%时,酸奶的持水力、粘弹性都明显提升,STS明显降低,且具有较好的口感、更连续的网络结构,与对照组相比综合品质得到明显提高。     

Effects of polymerized goat milk whey protein on physicochemical properties and microstructure of recombined goat milk yogurt

Goat milk whey protein concentrates were manufactured by microfiltration (MF) and ultrafiltration (UF). When MF retentate blended with cream, which could be used as a starting material in yogurt making. The objective of this study was to prepare goat milk whey protein concentrates by membrane separation technology and to investigate the effects of polymerized goat milk whey protein (PGWP) on the physicochemical properties and microstructure of recombined goat milk yogurt. A 3-stage MF study was conducted to separate whey protein from casein in skim milk with 0.1-µm ceramic membrane. The MF permeate was ultrafiltered using a 10 kDa cut-off membrane to 10-fold, followed by 3 step diafiltration. The ultrafiltration-diafiltration-treated whey was electrodialyzed to remove 85% of salt, and to obtain goat milk whey protein concentrates with 80.99% protein content (wt/wt, dry basis). Recombined goat milk yogurt was prepared by mixing cream and MF retentate, and PGWP was used as main thickening agent. Compared with the recombined goat milk yogurt without PGWP, the yogurt with 0.50% PGWP had desirable viscosity and low level of syneresis. There was no significant difference in chemical composition and pH between the recombined goat milk yogurt with PGWP and control (without PGWP). Viscosity of all the yogurt samples decreased during the study. There was a slight but not significant decrease in pH during storage. Bifidobacterium and Lactobacillus acidophilus in yogurt samples remained above 10⁶ cfu/g during 8-wk storage. Scanning electron microscopy of the recombined goat milk yogurt with PGWP displayed a compact protein network. Results indicated that PGWP prepared directly from raw milk may be a novel protein-based thickening agent for authentic goat milk yogurt making.     

Physiochemical Properties,Microstructure, and Probiotic Survivability of Nonfat Goats’ Milk Yogurt Using Heat‐Treated Whey Protein Concentrate as Fat Replacer

There is a market demand for nonfat fermented goats’ milk products. A nonfat goats’ milk yogurt containing probiotics (Lactobacillus acidophilus, and Bifidobacterium spp.) was developed using heat‐treated whey protein concentrate (HWPC) as a fat replacer and pectin as a thickening agent. Yogurts containing untreated whey protein concentrate (WPC) and pectin, and the one with only pectin were also prepared. Skim cows’ milk yogurt with pectin was also made as a control. The yogurts were analyzed for chemical composition, water holding capacity (syneresis), microstructure, changes in pH and viscosity, mold, yeast and coliform counts, and probiotic survivability during storage at 4 °C for 10 wk. The results showed that the nonfat goats’ milk yogurt made with 1.2% HWPC (WPC solution heated at 85 °C for 30 min at pH 8.5) and 0.35% pectin had significantly higher viscosity (P < 0.01) than any of the other yogurts and lower syneresis than the goats’ yogurt with only pectin (P < 0.01). Viscosity and pH of all the yogurt samples did not change much throughout storage. Bifidobacterium spp. remained stable and was above 10⁶CFU g^‐1 during the 10‐wk storage. However, the population of Lactobacillus acidophilus dropped to below 10⁶CFU g^‐1 after 2 wk of storage. Microstructure analysis of the nonfat goats’ milk yogurt by scanning electron microscopy revealed that HWPC interacted with casein micelles to form a relatively compact network in the yogurt gel. The results indicated that HWPC could be used as a fat replacer for improving the consistency of nonfat goats’ milk yogurt and other similar products.     

Physical properties of yogurt fortified with various commercial whey protein concentrates

The effects of whey protein concentrates on physical and rheological properties of yogurt were studied. Five commercial whey protein concentrates (340 g kg^?1 protein nominal) were used to fortify milk to 45 g protein kg^?1. Fermentation was performed with two different starters (ropy and non‐ropy). Resulting yogurts were compared with a control yogurt enriched with skim milk powder. The water‐holding capacity of the yogurt fortified with skim milk powder was 500 g kg^?1 and ranged from 600 to 638 g kg^?1 when fortified with whey protein concentrates. Significant rheological differences have been noticed between the yogurts fortified with different whey protein concentrates, independent of the starter used. Three whey protein concentrates generated yogurts with a behavior similar to the control. The two others produced yogurt with lower firmness (15 g compared with 17 g), lower Brookfield viscosity (6 Pa s compared with 9 Pa s), lower yield stress (2 Pa compared with 4 Pa), lower complex viscosity (13 Pa s compared with 26 Pa s), and lower apparent viscosity (0.4 Pa s compared with 1 Pa s) than the control, respectively. The yogurts with the lowest firmness and viscosity were produced with concentrates which contained the highest amount of non‐protein nitrogen fraction (160 g kg^?1 versus 126 g kg^?1 of the total nitrogen), and the highest amount of denaturation of the whey protein (262 versus 200 g kg^?1 of the total nitrogen). Copyright © 2004 Society of Chemical Industry     

Influence of fortification with sodium–calcium caseinate and whey protein concentrate on microbiological,textural and sensory properties of set‐type yoghurt

The effect of fortification of yoghurt with sodium–calcium caseinate (SCC) and whey protein concentrate (WPC) on some properties of set‐type yoghurt were investigated. The addition of WPC enhanced the viability of Lactobacillus delbrueckii subsp. bulgaricus more than SCC. The highest firmness values were obtained from SCC‐fortified yoghurts, whereas yoghurts fortified with WPC had the highest water‐holding capacity during storage. The yoghurts fortified with 4% w/w SCC or 4% w/w WPC had the highest viscosity. Yoghurts fortified with 2% w/w SMP, SCC or WPC showed similar taste and overall acceptability scores; however, samples containing 4% w/w SCC or 4% w/w WPC had the lowest scores.     

Effect of Transglutaminase on Physicochemical Properties of Set-style Yogurt

In this study, the effect of some ingredients such as skimmed milk powder, whey, sodium caseinate, calcium caseinate, whey protein concentrate (35, 60 kg/100 kg dry solids), whole milk powder, condensed milk and transglutaminase (TGase) on the properties of set-style yogurt was investigated. These protein and dry matter sources (2%) and TGase (1 U/g milk protein) were added into pasteurized milk and incubated prior to fermentation for 2 h at 40°C. After fermentation, enzyme action was stopped by heating for 1 min at 80°C. The control groups were conducted with addition of these materials into milk without TGase. All of the milk samples were inoculated with yogurt cultures at 45°C, until the pH was dropped to 4.4. Syneresis, gel-strength, acetaldehyde amounts, and the degree of TGase reaction were determined. As a result, yogurt products made from enzyme-treated milk showed increased gel strength and less syneresis. SDS-PAGE results showed that the enzyme TGase produced crosslink formation between different protein fractions of milk. In addition, it was also determined that TGase application caused a decrease in acetaldehyde amounts.     

Comparison of heat and pressure treatments of skim milk, fortified with whey protein concentrate, for set yogurt preparation: effects on milk proteins and gel structure

Heat (85 degrees C for 20 min) and pressure (600 MPa for 15 min) treatments were applied to skim milk fortified by addition of whey protein concentrate. Both treatments caused > 90 % denaturation of beta-lactoglobulin. During heat treatment this denaturation took place in the presence of intact casein micelles; during pressure treatment it occurred while the micelles were in a highly dissociated state. As a result micelle structure and the distribution of beta-lactoglobulin were different in the two milks. Electron microscopy and immunolabelling techniques were used to examine the milks after processing and during their transition to yogurt gels. The disruption of micelles by high pressure caused a significant change in the appearance of the milk which was quantified by measurement of the colour values L*, a* and b*. Heat treatment also affected these characteristics. Casein micelles are dynamic structures, influenced by changes to their environment. This was clearly demonstrated by the transition from the clusters of small irregularly shaped micelle fragments present in cold pressure-treated milk to round, separate and compact micelles formed on warming the milk to 43 degrees C. The effect of this transition was observed as significant changes in the colour indicators. During yogurt gel formation, further changes in micelle structure, occurring in both pressure and heat-treated samples, resulted in a convergence of colour values. However, the microstructure of the gels and their rheological properties were very different. Pressure-treated milk yogurt had a much higher storage modulus but yielded more readily to large deformation than the heated milk yogurt. These changes in micelle structure during processing and yogurt preparation are discussed in terms of a recently published micelle model.     

Effect of Fortification with Various Types of Milk Proteins on the Rheological Properties and Permeability of Nonfat Set Yogurt

ABSTRACT: Yogurt base was prepared from reconstituted skim milk powder (SMP) with 2.5% protein and fortified with additional 1% protein (wt/wt) from 4 different milk protein sources: SMP, milk protein isolate (MPI), micellar casein (MC), and sodium caseinate (NaCN). Heat‐treated yogurt mixes were fermented at 40 °C with a commercial yogurt culture until pH 4.6. During fermentation pH was monitored, and storage modulus (G′) and loss tangent (LT) were measured using dynamic oscillatory rheology. Yield stress (σ_yield) and permeability of gels were analyzed at pH 4.6. Addition of NaCN significantly reduced buffering capacity of yogurt mix by apparently solubilizing part of the indigenous colloidal calcium phosphate (CCP) in reconstituted SMP. Use of different types of milk protein did not affect pH development except for MC, which had the slowest fermentation due to its very high buffering. NaCN‐fortified yogurt had the highest G′ and σ_yield values at pH 4.6, as well as maximum LT values. Partial removal of CCP by NaCN before fermentation may have increased rearrangements in yogurt gel. Soluble casein molecules in NaCN‐fortified milks may have helped to increase G′ and LT values of yogurt gels by increasing the number of cross‐links between strands. Use of MC increased the CCP content but resulted in low G′ and σ_yield at pH 4.6, high LT and high permeability. The G′ value at pH 4.6 of yogurts increased in the order: SMP = MC < MPI < NaCN. Type of milk protein used to standardize the protein content had a significant impact on physical properties of yogurt. Practical Application: In yogurt processing, it is common to add additional milk solids to improve viscosity and textural attributes. There are many different types of milk protein powders that could potentially be used for fortification purposes. This study suggests that the type of milk protein used for fortification impacts yogurt properties and sodium caseinate gave the best textural results.     

Whey protein concentrate and gum tragacanth as fat replacers in nonfat yogurt: chemical, physical, and microstructural properties

The effect of whey protein concentrate (WPC) and gum tragacanth (GT) as fat replacers on the chemical, physical, and microstructural properties of nonfat yogurt was investigated. The WPC (7.5, 15, and 20 g/L) and GT (0.25, 0.5, 0.75, and 1 g/L) were incorporated into the skim milk slowly at 40 to 45°C with agitation. The yogurt mixes were pasteurized at 90°C for 10 min, inoculated with 0.1% starter culture, and incubated at 42°C to pH 4.6, then refrigerated overnight at 5°C. A control nonfat yogurt and control full fat yogurt were prepared as described, but without addition of WPC and GT. Increasing amount of WPC led to the increase in total solids, total protein, acidity, and ash content, whereas GT did not affect chemical parameters. Increasing WPC caused a more compact structure consisting of robust casein particles and large aggregates. Firmness was increased and susceptibility to syneresis was decreased as WPC increased. No significant difference was observed for firmness and syneresis of yogurt fortified with GT up to 0.5 g/L compared with control nonfat yogurt. Increasing the amount of gum above 0.5 g/L produced softer gels with a greater tendency for syneresis than the ones prepared without it. Addition of GT led to the coarser and more open structure compared with control yogurt.     

Association of denatured whey proteins with casein micelles in heated reconstituted skim milk and its effect on casein micelle size

When skim milk at pH 6.55 was heated (75 to 100 degrees C for up to 60 min), the casein micelle size, as monitored by photon correlation spectroscopy, was found to increase during the initial stages of heating and tended to plateau on prolonged heating. At any particular temperature, the casein micelle size increased with longer holding times, and, at any particular holding time, the casein micelle size increased with increasing temperature. The maximum increase in casein micelle size was about 30-35 nm. The changes in casein micelle size were poorly correlated with the level of whey protein denaturation. However, the changes in casein micelle size were highly correlated with the levels of denatured whey proteins that were associated with the casein micelles. The rate of association of the denatured whey proteins with the casein micelles was considerably slower than the rate of denaturation of the whey proteins. Removal of the whey proteins from the skim milk resulted in only small changes in casein micelle size during heating. Re-addition of beta-lactoglobulin to the whey-protein-depleted milk caused the casein micelle size to increase markedly on heat treatment. The changes in casein micelle size induced by the heat treatment of skim milk may be a consequence of the whey proteins associating with the casein micelles. However, these associated whey proteins would need to occlude a large amount of serum to account for the particle size changes. Separate experiments showed that the viscosity changes of heated milk and the estimated volume fraction changes were consistent with the particle size changes observed. Further studies are needed to determine whether the changes in size are due to the specific association of whey proteins with the micelles or whether a low level of aggregation of the casein micelles accompanies this association behaviour. Preliminary studies indicated lower levels of denatured whey proteins associated with the casein micelles and smaller changes in casein micelle size occurred as the pH of the milk was increased from pH 6.5 to pH 6.7.