Polyphasic approach for differentiating Penicillium nordicum from Penicillium verrucosum

The aim of this research was to use a polyphasic approach to differentiate Penicillium verrucosum from Penicillium nordicum, to compare different techniques, and to select the most suitable for industrial use. In particular, (1) a cultural technique with two substrates selective for these species; (2) a molecular diagnostic test recently set up and a RAPD procedure derived from this assay; (3) an RP-HPLC analysis to quantify ochratoxin A (OTA) production and (4) an automated system based on fungal carbon source utilisation (Biolog Microstation?) were used. Thirty strains isolated from meat products and originally identified as P. verrucosum by morphological methods were re-examined by newer cultural tests and by PCR methods. All were found to belong to P. nordicum. Their biochemical and chemical characterisation supported the results obtained by cultural and molecular techniques and showed the varied ability in P. verrucosum and P. nordicum to metabolise carbon-based sources and to produce OTA at different concentrations, respectively.     

Early detection of Aspergillus carbonarius and A. niger on table grapes: a tool for quality improvement

Aspergillus carbonarius and A. niger aggregate are the main fungal contaminants of table grapes. Besides their ability to cause black rot, they can produce ochratoxin A (OTA), a mycotoxin that has attracted increasing attention worldwide. The objective of this work was to set up a simple and rapid molecular method for the early detection of both fungi in table grapes before fungal development becomes evident. Polymerase chain reaction (PCR)-based assays were developed by designing species-specific primers based on the polyketide synthases (PKS_S) sequences of A. carbonarius and A. niger that have recently been demonstrated to be involved in OTA biosynthesis. Three table grape varieties (Red globe, Crimson seedless, and Italia) were inoculated with A. carbonarius and A. niger aggregate strains producing OTA. The extracted DNA from control (non-inoculated) and inoculated grapes was amplified by PCR using ACPKS2F-ACPKS2R for A. carbonarius and ANPKS5-ANPKS6 for A. niger aggregate. Both primers allowed a clear detection, even in symptomless samples. PCR-based methods are considered to be a good alternative to traditional diagnostic means for the early detection of fungi in complex matrix for their high specificity and sensitivity. The results obtained could be useful for the definition of a ‘quality label’ for tested grapes to improve the safety measures taken to guarantee the production of fresh table grapes.     

The effect of chemical treatment on reduction of aflatoxins and ochratoxin A in black and white pepper during washing

The effect of 18 different chemicals, which included acidic compounds (sulfuric acid, chloridric acid, phosphoric acid, benzoic acid, citric acid, acetic acid), alkaline compounds (ammonia, sodium bicarbonate, sodium hydroxide, potassium hydroxide, calcium hydroxide), salts (acetate ammonium, sodium bisulfite, sodium hydrosulfite, sodium chloride, sodium sulfate) and oxidising agents (hydrogen peroxide, sodium hypochlorite), on the reduction of aflatoxins B₁, B₂, G₁ and G₂ and ochratoxin A (OTA) was investigated in black and white pepper. OTA and aflatoxins were determined using HPLC after immunoaffinity column clean-up. Almost all of the applied chemicals showed a significant degree of reduction on mycotoxins (p?<?0.05). The lowest and highest reduction of aflatoxin B₁, which is the most dangerous aflatoxin, was 20.5%?±?2.7% using benzoic acid and 54.5%?±?2.7% using sodium hydroxide. There was no significant difference between black and white peppers (p?<?0.05).     

Aflatoxins and ochratoxin A in tea prepared from naturally contaminated powdered ginger

The migration of several major mycotoxins, aflatoxins B₁ (AFB₁), B₂, G₁, and G₂ (AFT, total of the aflatoxins) and ochratoxin A (OTA), from naturally contaminated powdered ginger to surrounding liquid (tea) was investigated. The toxins are commonly found in cereal grains and are toxic, carcinogenic and thermostable. Ginger root is widely used for digestive problems. Powdered ginger (2 g) found to contain AFT and OTA was placed in an empty heat sealable tea bag. The tea bag was heat-sealed and used to prepare tea under different conditions: temperature (50 and 100°C), time (5 and 10 min) and volume (100 and 200 ml). The tea bag was placed in hot water and stirred every 1 min for 5 s during the first 5 min of steeping. After steeping, the tea bag was removed and the tea and ginger residue (in the tea bag) were analysed separately for AFT and OTA. After extraction and immunoaffinity column (IAC) clean-up, the isolated AFT and OTA were separated by reversed-phase liquid chromatography and quantified using a fluorescence detector. At 100°C, approximately 30–40% of AFB₁ and AFT and 20–30% of OTA in the contaminated ginger were found in the ginger tea; the total amounts of AFT and OTA in tea varied less than 5% under the three conditions of preparation. At 50°C, about 10% of OTA and AFT were found in tea. This is the first study on the migration of AFT from botanicals to tea. It is also the first to study the distribution of AFT and OTA from powdered ginger to tea and ginger residue.     

Occurrence of ochratoxin A and citrinin in Czech cereals and comparison of two HPLC methods for ochratoxin A detection

The aims of the study were to obtain information about the occurrence of ochratoxin A (OTA) and citrinin (CIT) in cereals harvested in the Czech Republic and to compare two analytical procedures for detecting OTA. A total of 34 cereal samples, including two matrix reference materials (R-Biopharm, Germany), were analysed. The results were compared with the limit for raw cereal grains used as a foodstuff according to Commission Regulation No. 1881/2006, which allows a maximum OTA level of 5 µg kg^?1. Compared were two methods based on the high-performance liquid chromatography principle, one using the immunoaffinity columns OchraTest? (VICAM) and the second based on solvent partition (PART), both followed by fluorescence detection. The highest OTA contents were found in two barley samples. According to the method employed, the results for the first sample (malting barley) were VICAM = 31.43 µg kg^?1 and PART = 44.74 µg kg^?1. For the second sample (feeding barley) they were VICAM = 48.63 µg kg^?1 and PART = 34.40 µg kg^?1. Two samples of bread wheat had an OTA content approaching the legal limit (VICAM = 4.71 µg kg^?1 and PART = 6.03 µg kg^?1; VICAM = 4.12 µg kg^?1 and PART = 3.95 µg kg^?1). CIT was analysed using the PART method only, and its highest content (93.64 µg kg^?1) was found for the malting barley sample with high OTA content (44.74 µg kg^?1 as analysed using PART).     

Validation of a high-performance liquid chromatography analytical method for ochratoxin A quantification in cocoa beans

A validated high-performance liquid chromatography (HPLC) method with fluorescence detection for the quantitative analysis of ochratoxin A (OTA) in cocoa beans is described. OTA was extracted with methanol-3% sodium hydrogen carbonate solution and then purified with immunoaffinity columns before its analysis by HPLC. The validation of the analytical method was based on the following criteria: selectivity, linearity, limit of detection and quantification, precision (within- and between-day variability) and recovery, robustness and uncertainty. Detection and quantification limits were 0.04 and 0.1 μg kg^-1, respectively. Recovery was 88.9% (relative standard deviation = 4.0%). This method was successfully applied to the measurement of 46 cocoa bean samples of different origins. A total of 63% of cocoa bean samples was contaminated with a level greater than the limit of detection. The means and medians obtained for cocoa bean were 1.71 and 1.12 μg kg^-1, respectively. Surveillance controls should be set up in both crops and factories involved in transformation processes to avoid this mycotoxin in final products.     

Ecophysiology of ochratoxigenic Aspergillus ochraceus and Penicillium verrucosum isolates. Predictive models for fungal spoilage prevention - a review

Ochratoxin A (OTA) is a secondary metabolite produced by several species of Aspergillus and Penicillium; among them Aspergillus ochraceus and Penicillium verrucosum are two ochratoxigenic species capable of growing in different climates and thus contamination of food crops with OTA can occur worldwide. OTA can be found in a wide range of foods such as cereals, coffee, cocoa, spices, beer, wine, dried vine fruit, grapes and meat products. OTA is toxic to animals, it presents neurotoxic, immunotoxic and nephrotoxic effects. It has been implicated in a human kidney disorder known as Balkan Endemic Nephropathy. This review focuses on the ecophysiology of ochratoxin-producing Aspergillus ochraceus and Penicillium verrucosum, the effect of environmental factors on their germination, mycelial growth, and OTA production. Knowledge of environmental conditions required for sucessive stages of fungal development represent the first step towards preventing mycotoxin formation. Predictive models for different stages of fungal development are presented, which allow prediction of the time before spoilage as a function of the abiotic factors. Finally, the implications of these studies in management of barley, coffee and grapes are described. This can help to identify the critical control points in their production, storage and distribution processes.     

Validation of the procedure for the simultaneous determination of aflatoxins ochratoxin A and zearalenone in cereals using HPLC-FLD

Method validation for quantitative analysis of aflatoxins (AFs), ochratoxin A (OTA) and zearalenone (ZEA) in cereals using HPLC with fluorescence detector (FLD) is described. Mycotoxins were extracted with methanol?:?water (80?:?20) and purified with a multifunctional AOZ immunoaffinity column before HPLC analysis. The validation of the analytical method was performed to establish the following parameters: specificity, selectivity, linearity, limits of detection (LOD) and quantification (LOQ), accuracy, precision (within- and between-day variability), stability, robustness, measurement of performance, and measurement of uncertainty. Calibration curves were linear (r?>?0.999) over the concentration range, from the LOQ to 26, 40 and 400?ng/g for AFs, OTA and ZEA, respectively. LOD and LOQ were 0.0125 and 0.05?ng/g for aflatoxin B1 (AFB1) and G1 (AFG1), 0.0037 and 0.015?ng/g for aflatoxin B2 (AFB2) and G2 (AFG2), as well as 0.05 and 0.2?ng/g for OTA and 0.5 and 2?ng/g for ZEA, respectively. The mean recovery values were 77–104% for different concentrations of AFs, OTA and ZEA in spiked cereal samples. Both intra- and inter-day accuracy and precision were within acceptable limits. This method was successfully applied for the simultaneous determination of mycotoxins for 60 cereal samples collected from Malaysian markets. Fifty per cent of the cereal samples were contaminated with at least one of these mycotoxins, at a level greater than the LOD. Only one wheat sample and two rice samples were contaminated with levels greater than the European Union regulatory limits for AFs and OTA (4 and 5?ng/g). The means and ranges of mycotoxins obtained for the cereal samples were 0.4?ng/g and 0.01–5.9?ng/g for total AFs; 0.18?ng/g and 0.03–5.3?ng/g for OTA; and 2.8?ng/g and 2.4–73.1?ng/g for ZEA, respectively. The results indicate that the method is suitable for the simultaneous determination of AFs, OTA and ZEA in cereals and is suitable for routine analysis.     

Impact of non-selective fungicides on the growth and production of ochratoxin A by Aspergillus ochraceus and A. carbonarius in barley-based medium

The aim of this study was to assess the influence of the non-selective fungicides mancozeb, copper oxychloride, and sulfur on the growth and capability for producing ochratoxin A (OTA) of ochratoxigenic isolates of Aspergillus carbonarius and A. ochraceus in barley-based medium. Lag phases and growth rates were determined for each fungicide at different doses, at 15°C and 25°C and at 0.97?a_w . Mancozeb at 40?mg?l^?1 inhibited fungal growth and provided lag phases >24 days at 10–20?mg?l^?1 and 15°C. OTA was observed only at 25°C and doses <10?mg?l^?1. At 15°C, copper oxychloride proved inhibitory at 800?mg?l^?1, while at 25°C growth was not delayed and only high doses decreased OTA levels. Sulfur was inhibitory or provided large lag phases at 5–8?g?l^?1 (at 15°C) while at 25°C growth took place even at 8?g?l^?1, although OTA levels were low or undetectable. The antifungal activity decreased in the order mancozeb?>?copper oxychloride?>?sulfur, and was lower at 25°C than at 15°C. OTA accumulation was affected by the type of fungicide, dose, temperature and time. The efficacy of these fungicides on the growth of A. carbonarius and A. ochraceus and OTA production in barley-based medium is assessed for the first time.     

Salting of dry-cured meat - A potential cause of contamination with the ochratoxin A-producing species Penicillium nordicum

Penicillium nordicum is a known contaminant of protein-rich foods and is primarily found on dry-cured meat products. It is an important producer of the mycotoxin ochratoxin A, which has nephrotoxic and cancerogenic activities. Recently a high number of P. nordicum strains was isolated from different dry-cured meat products from one of the Slovenian meat-processing plants. Since we have isolated P. nordicum in high counts also from Artic habitats, such as sea water and sea ice and due to its ability to grow well at low temperatures and at increased salinity, sea salt was suspected as the possible source of P. nordicum. In the present study contamination of meat products, air in the meat-processing plant and sea salt used for salting were analysed. When 50 g of salt sample from a sealed package was dissolved in sterile water and filtered, 12 colonies of P. nordicum were obtained on solid medium incubated at 15 °C, while a salt sample from an open vessel in the meat-processing area developed high, uncountable number of colonies. Amplified fragment length polymorphism analyses of P. nordicum isolates from different sources showed that contamination of meat products via salt was possible. Three selected isolates examined for extrolites all produced ochratoxin A. As contamination of dry-cured meat products with P. nordicum represents a potential health risk for consumers and workers in the meat-processing plants, salt should be taken into account as a potential cause of such contaminations.     

Survey of ochratoxin A and deoxynivalenol in stored grains from the 1999 harvest in the UK

Three hundred and twenty samples from the 1999 UK harvest comprising wheat (201 samples), barley (106) and oats (13) were analysed for ochratoxin A and deoxynivalenol. A small number of organic samples was also obtained. Samples were collected from farms, central stores, mills, maltings and ports from across the UK from February to April 2000. Ochratoxin A and deoxynivalenol analysis was by affinity column clean up and high-performance liquid chromatography with fluorescence and ultraviolet light detection, respectively, with limits of detection of 0.2 and 20 μg kg^-1. The survey found ochratoxin A at below 5 μg kg^-1 in 97% of the samples indicating satisfactory storage conditions. The remaining 3% of the samples contained ochratoxin A at levels between 5.2 and 231 μg kg^-1, but none of these samples was intended for human consumption. Deoxynivalenol was detected in 88% of all samples, with 83% below 100 μg kg^-1; the maximum level was 600 μg kg^-1. Twenty samples containing deoxynivalenol at or above 150 μg kg^-1 by high-performance liquid chromatography were all confirmed by gas chromatography/mass spectrometry. Nivalenol was also detected by gas chromatography/mass spectrometry at levels of 50 μg kg^-1 or higher in 18 of 20 samples where deoxynivalenol was confirmed.     

测定肉串源性成分的液相色谱-串联质谱与聚合酶链式反应方法对比研究

采用液相色谱-串联质谱（liquid chromatography-tandem mass spectrometry,LC-MS/MS）与聚合酶链式反应（polymerase chain reaction,PCR）方法分别对北京市场中的200 个烤肉串样品进行源性成分分析。其中PCR方法按照出入境标准进行操作,LC-MS/MS方法为自建方法,原理是基于测定物种的特异性多肽链进行物种鉴别。结果表明：2 种检测方法所得到的结果一致,肉串总体掺假比例为21%,其中羊肉串掺假比例为28%,牛肉串掺假比例为14%,主要掺假物种为猪和鸭;通过大批量样品实验对比,LC-MS/MS方法的准确性更高,实验操作也更为简便、耗时短、成本低,可用于日常食品的肉源性成分检测。     

扩展青霉DNA提取及PCR检测条件的优化

研究扩展青霉DNA的提取及其聚合酶链式反应(polymerase chain reaction,PCR)检测条件的优化。分别采用玻璃珠法、氯化苄法、玻璃珠+氯化苄法提取扩展青霉菌及对照菌株的基因组DNA,经紫外测定和电泳检测实验,分析提取DNA的质量浓度和纯度;同时,根据扩展青霉多聚半乳糖醛酸酶基因内一段保守序列设计合成一对288bp的扩增引物,并对PCR检测条件进行优化。结果表明：玻璃珠+氯化苄法提取到的DNA质量浓度和纯度较理想,扩展青霉DNA可获得良好的特异性扩增,PCR扩增的最适退火温度为53～59℃,最适引物浓度为0.04～0.16μmol/L,最适模板质量浓度为2.40～5.28μg/mL,dNTPs浓度对PCR扩增影响不大。运用实验所得优化参数检测扩展青霉菌,整个过程仅需3～4h,和传统的培养检测法相比,该方法可有效提高检测效率,可进一步将该方法应用于实践。     

Duplex PCR approach for the detection and quantification of donkey,horse and mule in raw and heat‐processed meat products

Donkey‐related products have been paid more attention for their high nutritional value to human beings. Due to donkey resource scarcity, coupled with gradually increasing market demand, adulterated donkey meat products with other low‐cost animal meat, especially with the similar species horse and mule, are often found in market. Therefore, detection of species fraud in donkey meat products is important for consumer protection and food industries. In this study, a simple and highly specific duplex PCR method, based on the simultaneous amplification of fragments of the mitochondrial ATP synthase subunit 8/6 and ND2, was developed and optimised for the identification of horse, donkey and mule species in raw and heat‐processed meat products. To the best of our knowledge, it was the first time for this strategy applied to these three genetically related animal meat products differentiation to date. The duplex PCR generated a 153‐bp and 83‐bp amplification products for horse and donkey, respectively. While for mule, both of the two length amplification products are appeared on the agarose gel. Target meat species could be detected at a level of 1%, and the results indicated that the duplex PCR assay could be used in the authentification of donkey‐related products with high specificity, cost‐effectiveness and simplicity.     

Effects of selected natural preservatives on the mycelial growth and ochratoxin A production of the food-related moulds Aspergillus westerdijkiae and Penicillium verrucosum

ABSTRACT

The present study examines the influence of the natural preservatives carvacrol, eugenol, trans-cinnamaldehyde and the essential oil (EO) Origanum vulgare on ochratoxin A (OTA) production and the mycelial growth of two food-related moulds, Penicillium verrucosum and Aspergillus westerdijkiae, by broth macro-dilution assay for 21 days. With the addition of ½ minimum inhibitory concentration (MIC) carvacrol, eugenol and O. vulgare EO, the mycelial dry weight of both moulds decreased significantly over the whole incubation period of 7, 14 and 21 days. Trans-cinnamaldehyde slightly stimulated the growth of A. westerdijkiae and P. verrucosum at 14 and 21 days of incubation. Growth inhibition did not accompany inhibition of OTA production. Although the growth of both moulds was inhibited after the addition of ½ MIC carvacrol, eugenol and O. vulgare EO, the OTA production of the strong mycotoxin producer A. westerdijkiae was stimulated. Only trans-cinnamaldehyde inhibited the production of OTA with the addition of ½ MIC. P. verrucosum produced significantly less OTA than A. westerdijkiae, and its mycotoxin production was almost completely inhibited by the addition of ½ MIC of the natural preservatives.     

Polymerase chain reaction (PCR) identification of Penicillium brevicompactum, a grape contaminant and mycophenolic acid producer

Penicillium brevicompactum is a ubiquitous fungal species that contaminates diverse substrates and commodities and produces an array of metabolites toxic to human and animals. The present work has obtained evidence, by liquid chromatography (LC)-ion-trap mass spectrometry, of the ability of P. brevicompactum strains isolated from grapes to produce mycophenolic acid, a potent immunosuppressor. In order to facilitate early diagnosis of this species on commodities for human and animal consumption, a rapid, sensitive and specific polymerase chain reaction (PCR) assay for P. brevicompactum was developed. The specific primers were designed based on the ITS1-5.8S-ITS2ITS (Internal Transcribed Spacers of rRNA genes) multicopy region. This method provides a useful aid to detect the presence of this fungal species in grapes and other commodities in order to prevent the toxins produced entering the food chain.     

Enzyme-assisted extraction for the HPLC determination of ochratoxin A in pork and dry-cured ham

The extraction of ochratoxin A from meat products is generally carried out using chlorinated organic solvents, such as chloroform or methyl chloride, acidified with hydrochloric or o-phosphoric acid. In this study, an innovative method was developed to extract ochratoxin A from pork and dry-cured ham samples. The method was based on an enzyme-assisted extraction with pancreatin in phosphate buffer pH 7.5. Pancreatin hydrolyses the proteins, so that ochratoxin A, kept in the ionised form, is easily extracted by the aqueous solution. After purification through an immunoaffinity column, ochratoxin A is determined by HPLC with fluorescence detection. The average recovery values were higher than 90.0% and the relative standard deviations were below 5.5%. The limits of detection and of quantification were 0.06 and 0.12?µg?kg^?1, respectively. A comparison between the new enzyme-assisted extraction and an established chloroform method was carried out on six naturally contaminated samples of pork and on 40 samples of dry-cured ham. Significantly higher (p?<?0.001) values of ochratoxin A were obtained on dry-cured ham samples by the enzyme-assisted method.     

免疫亲和层析-液相色谱-串联质谱法测定玉米和小麦中的赭曲霉毒素A

目的建立免疫亲和层析净化-液相色谱-串联质谱法测定食品中的赭曲霉毒素A的方法。方法玉米和小麦样品经50%甲醇水溶液(V:V)提取,免疫亲和柱净化后,采用液相色谱-串联质谱法进行测定,外标法定量。结果玉米、小麦添加浓度在1.0~10.0μg/kg时,回收率在70%~100%之间,变异系数小于10%,在2017年度法帕斯国际能力验证中(Food Analysis Performance Assessment Scheme),此方法测定样品中赭曲霉毒素A含量为2.8μg/kg,Z值为-0.4,统计结论为满意。结论该方法简单快速,灵敏度高,定量准确,适合于玉米和小麦中赭曲霉毒素A的检测。     

Influence of roasting and different brewing processes on the ochratoxin A content in coffee determined by high-performance liquid chromatography-fluorescence detection (HPLC-FLD)

A rapid and reliable procedure has been developed for the determination of ochratoxin A (OTA) in green and roasted coffee. The method consists of extraction of the sample with methanol–5% aqueous sodium hydrogen carbonate/1% PEG8000 (20:80), followed by immunoaffinity column (IAC) clean-up and, finally, high-performance liquid chromatography (HPLC) determination with fluorimetric detection. Mean recoveries for green and roasted coffee spiked at different levels ranging from 94 and 105% were obtained. The limit of determination (S/N = 3) was 0.032 ng g^?1 and the precision (within-laboratory relative standard deviation) was 6%. The method described has been used to assess the influence of roasting and different brewing processes on OTA content in commercial lots of green and roasted coffee. The results provided evidence that roasting led to a significant drop on OTA levels (65–100%). Also, the way coffee is prepared affects the OTA content: brewing using a Moka Express (Italian coffee) led to a significant reduction of OTA concentration (50–75%) since hot water stays in contact with coffee for a short time. On the contrary, Turkish coffee-making (infusion for about 10 min) cause poor reduction in OTA.