浑浊苹果汁加工中苹果PPO热失活条件的研究

研究了热处理苹果汁(加或不加防褐变剂)、苹果浆使其中的PPO完全及部分失活所需要的温度和时间。结果为:在90℃处理苹果汁15s可使其中的PPO完全失活,而对于苹果浆则需要90℃处理20s以上。加了防褐变剂的苹果汁经90℃处理10s可使其中的PPO完全失活;此外,经80℃处理30s以上虽不能使其中的PPO完全失活,但添加的防褐变剂及果汁自身的pH值可抑制残余的PPO从而防止酶促褐变的发生。70℃处理苹果汁40s不能防止其中的酶促褐变。     

臭氧对苹果汁中棒曲霉素的降解效果研究

主要研究臭氧对苹果汁中棒曲霉素(Pat)的降解效果及对果汁品质的影响。研究采用臭氧对水和苹果汁中500、250、200、100、50μg/LPat浓度进行5、10、15、20、30min的降解处理。结果表明,臭氧处理对各浓度的Pat都有降解作用,浓度越低,降解效果越好。随着处理时间延长降解效果越好,15min以后降解率不再增加。臭氧处理15min,50μg/L的Pat降解效率最佳,在该条件下,臭氧对苹果汁的pH、VC含量、可溶性固形物和色值均没有明显的影响,因此,臭氧处理是高效、安全、低廉的Pat降解方法。      

Effect of ascorbic acid on the odours of cloudy apple juice

Ascorbic acid is used in apple juice as an antibrowning agent. This study investigated the effect of ascorbic acid (0.0–0.2% w/v) on the odours of cloudy apple juice using sensory evaluation and gas chromatography (GC). The increase in ascorbic acid concentration in the apple juice resulted in increases in green and unnatural odours and decreases in fresh, fruity and apple-like odours. In the GC determination, 23 volatile compounds were detected in apple juice. Aroma value, which showed the relative importance of volatile compounds, was used to elucidate the changes in odours of apple juice due to the addition of ascorbic acid. The aroma values of hexanal and trans-2-hexenal in the apple juice with 0.2% w/v ascorbic acid increased about 4 and 5-fold from those in the ascorbic acid-free apple juice, respectively. On the other hand, the aroma values of esters insignificantly changed in the apple juice with ascorbic acid. The increases in aroma values of aldehydes corresponded well with the increase in green odour in the apple juice with ascorbic acid.     

影响浊苹果汁混浊稳定性的因素

对影响混浊苹果汁混浊稳定性的因素进行了综述。总体看来,混浊苹果中可溶性果胶的含量,多酚-蛋白质复合物的形成、酚类的氧化聚合和原花青素的聚合都对悬浮颗粒的尺寸有影响。同时,对今后的研究重点进行了讨论。     

混浊苹果汁加工过程中的的酶促褐变及其防止的研究

将几种可用于食品的防褐变剂在苹果破碎时加入,考察了它们对苹果浆和苹果鲜榨汁的防褐变效果及它们之间的协同作用.半胱氨酸、抗坏血酸、曲酸、氯化钠和氯化钙都是较好的防褐变剂.在所测试条件下,抗褐变的能力(褐变抑制率)为0.1%的抗坏血酸＞0.1%的偏重亚硫酸钠＞0.1%的曲酸＞0.1%的氯化钙＞0.005%半胱氨酸＞0.1%氯化钠.它们抗褐变能力都表现为浓度依赖型,特别是抗坏血酸.柠檬酸在所测试条件下没有抗褐变效果.0.044%NaCl+0.0125%Vc的组合较经济且可使果汁40min不变色.果浆脱气可减缓其褐变;减小果汁及果浆与空气的接触面也可防止褐变.     

Aseptically packaged UHPH-treated apple juice: Safety and quality parameters during storage

Ultra-high pressure homogenization (UHPH) at 300 MPa and 4 °C inlet temperature were used to preserve apple juice, and shelf-life evaluation of aseptically packaged juice was investigated. After processing Tetra Brik containers were stored at temperatures of 4, 10, 20 and 30 °C during 60 days. In this article, the effect of processing on the spoilage inactivation was evaluated after processing and during the storage trial. Non-germinated and germinated spores were found in the UHPH-treated juice, being an inactive population during storage. Patulin content was also not modified by UHPH processing, but a significant decrease was observed during storage at 30 °C (P < 0.05). Polyphenoloxidase (PPO) and pectinmethylesterase (PME) activity was not found after UHPH-processing and during storage.A kinetic study of post-processing quality loss was conducted. Vitamin C, chlorogenic acid, total polyphenols and color change were measured during storage study and were used to model the UHPH-treated apple juice shelf-life. Loss of vitamin C was correlated with the hydroxymethylfurfural (HMF) accumulation (0.59, P < 0.05). A limiting quality parameter was polyphenolic content. UHPH-treated apple juice stored at 4 °C was found to show a shelf-life for about 21 months by preserving the color characteristics of the juice with low HMF accumulation. From 15 °C changes in quality parameters were more evident.     

混浊苹果汁加工过程中的酶促褐变及其防止的研究

将几种可用于食品的防褐变剂在苹果破碎时加入,考察了它们对苹果浆和苹果鲜榨汁的防褐变效果及它们之间的协同作用。半胱氨酸、抗坏血酸、曲酸、氯化钠和氯化钙都是较好的防褐变剂。在所测试条件下,抗褐变的能力（褐变抑制率）为:0.1％的抗坏血酸>0.1％的偏重亚硫酸钠>0.1％的曲酸>0.1％的氯化钙>0.005％半胱氨酸>0.1％氯化钠。它们抗褐变能力都表现为浓度依赖型,特别是抗坏血酸。柠檬酸在所测试条件下没有抗褐变效果。0.044％NaCl+0.0125％Vc的组合较经济且可使果汁40min不变色。果浆脱气可减缓其褐变;减小果汁及果浆与空气的接触面也可防止褐变。      

Degradation kinetics of tomato juice quality parameters by ozonation

Tomato juice samples were ozonated with control variables of ozone concentration (1.6–7.8 %w/w) and treatment time (0–10 min). Effects of ozone processing variables on quality parameters of pH, ^oBrix, titratable acidity (TA), cloud value, non-enzymatic browning, colour values ( L *, a *, and b *) and ascorbic acid (AA) content were determined. No significant changes ( P  > 0.05) in pH, ^oBrix, TA, cloud value and Non enzymatic browning (NEB) ( P  ≤ 0.05) were found with ozonation. L *, a * and b * colour values were significantly affected by ozone concentration and treatment time. A significant reduction of AA (96 %) was observed at an ozone concentration of 7.8%w/w and a treatment time of 10 min. Results presented in this study indicate that visual colour and nutritional quality is significantly affected during ozone processing. Thus, the effects of ozonation on the nutritional properties of tomato juice should be considered by processors prior to its adoption as a preservation technique.     

苹果汁的掺假鉴定

从糖、有机酸、氨基酸、稳定性同位素、类黄酮、阳离子及光谱学等方面全面探讨了真假苹果汁的鉴定方法，为苹果汁加工业提出了一系列行之有效的鉴定掺假方法。     

辐照处理对混浊苹果汁有机磷农药降解的影响

研究了辐照处理对混浊苹果汁的品质和降解有机磷农药（毒死蜱、敌敌畏、乙酰甲胺磷、氧化乐果）的作用,并对果汁颜色、V C含量和总酚含量等的变化进行了研究。有机磷农药的测定参考农业部标准（NY/Y761-2004）,并略作改进。结果表明,辐照降解有机磷农药效果较好,降解率从大到小依次为毒死蜱、敌敌畏、乙酰甲胺磷、氧化乐果。辐照剂量小于6kGy时对混浊苹果汁品质无显著负面影响。      

榨前分离苹果清汁中多酚的提取与分析

以榨前分离苹果清汁为样品,优化其多酚的提取和分析方法,与传统工艺下清汁中的多酚进行比较,以明确榨前分离工艺的优势。实验采用超声波辅助提取法优化了多酚提取条件,并优化了苹果清汁多酚的HPLC分析方法。结果表明,提取多酚的最优参数为温度50℃,时间40min,果汁与提取剂之比1∶3;优化多酚的HPLC检测条件为检测波长280nm,流动相甲醇-0.3%冰乙酸水溶液,实验确定的梯度洗脱程序下多酚的分离效果较好。结论是两种工艺下其苹果清汁多酚物质种类无显著差异,但榨前分离苹果汁中多酚的含量比传统工艺果汁减少了23.62%,可以有效降低苹果汁褐变的发生。      

High-pressure treatment of cloudy apple juice

A factorial design with four factors (pressure, holding time, temperature and waiting period between crushing of apple and high-pressure (HP) treatment) was built up to study the effect of HP treatment on pectin methylesterase activity (PME, EC 3.1.1.11) in cloudy apple juice. PME activity was measured by the methanol release during the storage of samples at 4 °C for 1 month. Only the holding time of the treatment and three interactions between factors (holding time×temperature, pressure×waiting and holding time×waiting) had significant effects on the PME level. Increasing the pressure or the holding time at moderate temperatures (15-40 °C) increased the activity. PME purified from apple was pressure stable in the range 100-600 MPa at 25 °C. The soluble pectin content was not changed after HP treatment. The particles size increased with the temperature reached during the treatment, in agreement with a diffusion-limited-aggregation model but were independent of pressure and holding time. In a separate experiment we found a positive correlation between the PME activity and the residual content of the catechins suggesting that polyphenoloxidase (PPO, EC 1.14.18.1) and oxidized polyphenols play a role in the PME activity level after HP treatment.     

苹果浓缩汁后混浊的研究进展

综述了苹果浓缩汁后混浊的反应机理、影响因素及抑制方法。     

Inactivation of polyphenol oxidases in cloudy apple juice exposed to supercritical carbon dioxide

The inactivation of polyphenol oxidase (PPO) in cloudy apple juice exposed to supercritical carbon dioxide (SCCO₂) treatment was investigated. Higher pressure, higher temperature, and longer treatment time caused more inactivation of PPO. The maximum reduction of PPO activity reached more than 60% at 30 MPa and 55 °C for 60 min. The experimental data followed first-order reaction kinetics; the kinetic rate constant k and the decimal reduction time D were closely related to the pressure and temperature of SCCO₂ treatment. Higher pressures or higher temperatures resulted in lower D values (higher k), the D value of PPO was minimized to 145 min treated by the combination of 30 MPa and 55 °C. Activation energy of 18.00 kJ /mol, was significantly reduced by SCCO₂ treatment at 30 MPa, as compared to activation energy of 72.0 kJ/mol for identical treatment at atmospheric pressure. Pressure and temperature sensitivity of kinetic parameters were studied. Z_P at 55 °C was 66.7 MPa and Z_T at 30 MPa was 108 °C.     

Effect of clouding agents on the quality of apple juice during storage

Apple pomace, (AP) was subjected to evaluation as potential source of clouding and antiradical agent in cloudy apple juice (CAJ). The evaluation was carried out in comparison with three hydrocolloids, namely sodium carboxymethyl cellulose (CMC), xanthan (XA), and pectin (P). The quality parameters of cloudy apple juice such as cloud stability, viscosity, phenolic content, sensory evaluation and antioxidant activity had been studied since these parameters control the consumer acceptance of that product. All the analyses were carried out for fresh and treated juices after storage at 4 and 25 °C for two weeks. The cloud stability of juices added decreased quickly and remained more stable than the untreated treatment. However, the hydrocolloids showed significant (P < 0.05) increase in viscosity, they exhibited deterioration in sensory attributes. The results indicated a good correlation between phenolic degradation and the radical scavenging activities.     

Free and bound patulin in cloudy apple juice

During validation of an HPLC-UV method for patulin analysis, a time and concentration dependent recovery of patulin was observed. Spiked cloudy apple juice was analysed on successive days, which resulted in recoveries on day 3 which were up to 20% lower than on day 1. This reduction was caused by an interaction between patulin and the solid parts of cloudy apple juice. Since these solid parts are richer in proteins compared to the liquid phase of cloudy apple juice, and the binding of patulin to proteins has been described in the literature, patulin will most probably interact with the proteins in the solid parts. As a consequence, up to 20% of the present patulin is bound and not detected during HPLC-UV analysis, which can lead to an underestimation on toxicological level.     

Enhanced destruction of spoilage microorganisms in apple juice during continuous flow microwave heating

Destruction kinetics of two selected spoilage microorganisms, Saccharomyces cerevisiae and Lactobacillus plantarum in apple juice were evaluated under continuous flow microwave heating conditions and compared with conventional batch heating in a water bath. Inoculated apple juice was heated in a microwave oven (700 W, 2450 MHz) under continuous-flow conditions to selected exit temperatures (52.5–65°C). Aliquots of inoculated juice were also subjected to batch thermal treatments (50–80°C) in a well-stirred water bath. Time-temperature profiles obtained both during heating and cooling of test samples were used to correct both come-up and come-down times. The time-corrected D-values under microwave heating were 4.8, 2.1 and 1.1 s at 52.5, 55 and 57.5°C, respectively, for S. cerevisiae and 14, 3.8 and 0.79 s at 57.5, 60 and 62.5°C, respectively, for L. plantarum with corresponding z-values of 7 and 4.5°C. D-values under batch thermal heating were 58, 25, 10 and 1.9 s at 50, 55, 60 and 70°C, respectively, for S. cerevisiae and 52, 22, 8.4 and 1.2 s at 55, 60, 70 and 80°C, respectively, for L. plantarum with corresponding z-values of 13.4 and 15.9°C. Microbial destruction thus occurred much faster under microwave heating than under thermal heating suggesting some contributory enhanced effects to be associated with microwave heating.     

浓缩苹果汁加工链中棒曲霉素的动态分析研究

研究了浓缩苹果汁加工过程中各工序对棒曲霉素含量的影响。结果表明,喷淋、拣选、清洗是去除棒曲霉素的关键步骤,去除率为60.18％;吸附树脂对棒曲霉素去除效果显著。此外,研究了加工季节中棒曲霉素的变化规律,为果汁加工厂家建立科学完善的HACCP管理体系提供了理论依据。     

苹果汁中果汁含量测定方法研究

原果汁含量是苹果汁及其饮料的主要质量指标,也是判定苹果汁是否掺假的重要依据。通过对6个产地5个品种自制苹果汁的部分组分进行研究,找出与苹果汁含量有良好定量关系的特征性组分——钾、总磷和氨基酸态氮,以它们作为苹果汁含量测定参数,并且确定了各组分的标准值、权值分配方案及异常数据修正原则。据此,推导出苹果汁含量计算公式;同时按此法对自制的苹果汁和市售的6个品牌的苹果汁进行了果汁含量测定,进一步验证了此方法的可行性。此方法可用于苹果汁果汁含量测定或用于鉴别苹果汁的真伪。