Heat and ultrafiltration extraction of broiler meat carnosine and its antioxidant activity

This study examined the effects of extraction and further ultrafiltration on the carnosine content, antioxidant activity and total iron content of chicken muscle extracts. Fresh breast meat had 7-fold higher carnosine than fresh thigh meat (2900 versus 419μg/g meat, respectively). Carnosine extracts of breast and thigh were prepared by heating at 60, 80 and 100°C, and ultrafiltration (UF) using a 5000MW cut-off. At increasing temperatures, protein concentrations decreased while carnosine, total iron and antioxidant activity increased. Antioxidant abilities of the 80 and 100°C-heated extracts were greater than that of the 60°C extract (p<0.05). The ultrafiltrate from the 80°C-heated extract had approximately 20% higher carnosine, but 40% lower protein and 10-30% lower iron than the 80°C-heated ultrafiltrate. However, compared in terms of carnosine concentration, the meat extracts had greater antioxidant activity than pure carnosine (p<0.05).     

Quality and shelf life evaluation of fermented sausages of buffalo meat with different levels of heart and fat

Investigations were carried to study the effect of heart incorporation (0%, 15% and 20%) and increasing levels of fat (20% and 25%) on physicochemical (pH, moisture content and thiobarbituric acid, TBA number) and microbiological (total plate count and yeast and mold count) quality and shelf life of semi dry sausages of buffalo meat during refrigerated storage (4 °C). Different levels of fat significantly (p < 0.05) increased the pH of the sausage samples. However different levels of heart incorporation did not significantly (p < 0.05) affect pH, moisture content and TBA number of sausage samples. Fresh samples had pH, moisture content and TBA number in the range of 5.15–5.28, 42.4–47.4% and 0.073–0.134 respectively. Refrigerated storage significantly (p < 0.05) increased TBA number of control samples while storage did not significantly (p < 0.05) increase the TBA number of sodium ascorbate (SA) treated samples. Total plate counts of twelve sausage samples were f under the TFTC (too few to count) limit at the initial stage. Incorporation of different levels of heart and also increasing levels of fat did not significantly (p < 0.05) increase the log TPC/g values. Yeast and molds were not detected in twelve samples of semi dry fermented sausages in their fresh condition. Storage revealed that there was a consistent decrease in pH, and moisture content. Refrigerated storage significantly (p < 0.05) reduced both pH and moisture contents. TBA number and total plate counts and yeast and mold counts of controls were found to increase significantly (p < 0.05) during refrigerated storage. However, in SA treated sausage, only TPC and yeast and mold count significantly (p < 0.05) increased during refrigerated storage. Shelf life of the sausages was found to be 60 days under refrigerated storage (4 °C).     

Influence of the oxidative quality of dietary oil on broiler meat storage stability

Broilers were fed a high fat diet containing 11% oil (9% rapeseed oil, 2% soya bean oil) and the oil was given either as fresh (peroxide value of 1 meqv. O₂kg⁻¹ oil) or as highly oxidised (peroxide value of 156 meqv. O₂kg⁻¹ oil). Diets were supplemented with 46 mg all-rac--tocopheryl acetate kg⁻¹ diet, resulting in a tocopherol content of 80.8 mg -tocopherol and 58.6 mg γ-tocopherol per kg diet in the fresh oil diet and of 44.0 mg -tocopherol and 18.3 mg γ-tocopherol per kg diet in the oxidised oil diet, respectively, reflecting the degradation of the natural occurring tocopherols in the oxidised diet. Only minor differences were seen with respect to fatty acid composition in muscles from birds fed the two diets. The oxidation of the dietary oil lowered lipid stability significantly (p < 0.01) in both raw and precooked meats during chill storage, whereas only minor effects on the stability of frozen meat were seen. Tocopherol levels were significantly lower (p < 0.01) in muscles from birds fed the oxidised oil diet, explaining the decreased lipid stability of meat from these birds. Thigh meat was more susceptible to lipid oxidation during storage than breast meat, regardless of dietary treatment, although thigh meat had markedly higher tocopherol levels than breast meat. The molar ratio of PUFA > 18:2 (polyunsaturated fatty acids with three or more double bonds) to -tocopherol was significantly (p < 0.01) higher in thigh meat compared with breast meat, explaining the lower stability of the former during storage.     

Sodium chloride levels in comminuted chicken muscle in relation to processing characteristics and Fresnel reflectance detected with a polarimetric probe

Increasing NaCl from 0 to 2% in comminuted samples of chicken breast meat increased the resistance to compression of cooked samples (r=0.98, p < 0.001), increased water-holding capacity (r=0.95, p < 0.001), decreased cooking losses (r=−0.97, p < 0.001) and decreased paleness (L^*) before and after cooking (r = −0.96 and r=−0.99, respectively, p < 0.001). The decrease in paleness caused by NaCl was associated with an increase in the relative amount of reflected light maintaining its original plane of polarisation, so that NaCl% was correlated with an extinction coefficient for polarised light, r=0.91, p < 0.001. A possible explanation is that myofibrillar proteins may have been dissolved at high levels of NaCl, thus reducing light scattering by myofibrils and allowing more Fresnel reflectance to be detected.     

Chemical, physical and sensory properties of meat from pure and crossbred Podolian bulls at different ageing times

The present study aimed to investigate the effect of crossbreeding with Limousine sires on fatty acid profile, physical and sensory properties of meat produced by Podolian young bulls. Polyunsaturated fatty acid content was influenced by crossbreeding (P < 0.01) with Podolian bulls (P) producing beef characterised by a higher level of unsaturation in comparison with crossbred animals (LP). As a consequence, P/S ratio was significantly higher in meat produced by P animals than LP (P < 0.01). P animals had higher linoleic (P < 0.05), linolenic (P < 0.05), EPA (P < 0.05) and DHA acids (P < 0.001) levels than LP subjects. No breed effect was observed for the ratio n − 6/n − 3 (P > 0.05). WBS force of LD was significantly lower in meat from crossbred subjects (P < 0.05). Both crossbreeding with Limousine and extension of ageing from 2 to 7 days improved LD tenderness as assessed by panel taste (P < 0.001).     

Fatty acids, cholesterol and protein content of nutria (Myocastor coypus) meat from an intensive production system in Uruguay

This study describes the total lipids, protein and fatty acids in the meat, liver, brain and adipose tissue of five male and five female nutria (Myocastor coypus). The animals were reared on a specialized farm in Uruguay. Total lipid content was between 1.41% and 1.84% in males and females. Total cholesterol content was between 70.1 mg and 72.7 mg/100 g of wet tissue. The protein content was between 19.56% and 22.34% in males and females. No significant differences (P > 0.05) were detected between males and females for total lipid, cholesterol or protein. Total, saturated, monounsaturated and polyunsaturated fatty acid values were higher (P < 0.001) in female than in male thigh muscle. Pectoral muscle had more (P < 0.05) saturated and monounsaturated fatty acids in females than in males. Subcutaneous adipose tissue from females had the highest (P < 0.01) total, saturated and monounsaturated but not polyunsaturated fatty acids while abdominal adipose tissue from males had more polyunsaturated fatty.     

Meat quality characteristics of springbok (Antidorcas marsupialis). 4: Sensory meat evaluation as influenced by age, gender and production region

The effects of age, gender and production region on the sensory characteristics of springbok M. longissimus dorsi (LD) were investigated in 19 springbok, which originated from two Nature Reserves in the Free State Province of South Africa and were divided into age (adult, sub-adult) and gender categories. The sensory characteristics evaluated were game meat aroma, juiciness, residual tissue, tenderness and game meat flavour. Age, gender and production region had an effect (P < 0.05) on different sensory ratings of the meat. Whereas production region influenced (P < 0.05) the game meat aroma, initial juiciness, sustained juiciness and residual tissue ratings of the meat, gender and age had a significant effect on only the residual tissue rating of the meat. An interaction (P < 0.01) between age, gender and production region was observed for the tenderness attribute where the males from the Gariep Nature Reserve were the only gender that showed a significantly higher tenderness rating in the sub-adult than in the adult category. Sensory ratings were linearly correlated with certain physical and chemical attributes. Warner–Bratzler shear force (kg/1.27 cm diameter) values were inversely correlated with the sensory attributes of tenderness (r = −0.70, P < 0.01), residual tissue (r = −0.68, P < 0.01) and sustained juiciness (r = −0.43; P < 0.05). Age-related effects on perceived tenderness were minor in comparison with pH effects. As the pH₂₄ of the meat increased, tenderness (r = −0.46, P < 0.05) and sustained juiciness (r = −0.54, P < 0.05) decreased significantly. No significant linear correlations were observed between the intramuscular fat (IMF) content and the sustained juiciness ratings of the meat. It can be concluded that production region had some influence on sensory characteristics of springbok meat, whilst the influence of age and gender were negligible.     

Zn-porphyrin formation in cured meat products: Effect of added salt and nitrite

Zn-porphyrin (Zn-pp) was quantified by fluorescence spectroscopy in the cured and dry cured meat products: Parma ham, Iberian ham, dry-cured ham with added nitrite, cooked ham with added nitrite, raw ham meat, raw bacon and Karree-Speck. The highest amount of Zn-pp was found in dry-cured Parma ham and Iberian ham, while the use of nitrite as curing agent was found to inhibit completely the formation of Zn-pp in meat products. A positive correlation between both Zn content and Fe content and the logarithmic transformed Zn-pp content (measured as fluorescence intensity I_fl) was found for the different cured and dry cured meat products, with correlation coefficients of 0.79 (p < 0.001) and 0.71 (p < 0.01), respectively. Log I_fl correlates best with the Zn content, indicating that the formation of Zn-pp is proportional to the Zn content. A model system with vacuum packed pork in brine with different added levels of sodium chloride with or without nitrite and Zn acetate was investigated in order to further elucidate the mechanism of Zn-pp formation. Zn-pp increased with time (up to 42 days investigated) in non-cured meat and for meat cured solely with NaCl lower than 9%. Addition of nitrite or Zn(II) in the curing brine was found to inhibit formation of Zn-pp confirming the observations from the various cured meat products. It is suggested that a chloride anion assisted dissociation of iron from myoglobin could be rate-determining for Zn-pp formation in meat products.     

Effect of fiber type on postmortem proteolysis in longissimus muscle of Landrace and Korean native black pigs

The current study was conducted to characterize objective meat quality, fiber type and their relations to postmortem proteolysis in longissimus muscle of Landrace and Korean native black (KNP) pigs. Longissimus muscles from each 10 market-weighted male pigs were removed after conventional slaughtering and chilling procedures, and aged for 1 or 7 days at 4 °C to determine WB-shear force, objective meat color, proportion of myosin heavy chain I (MyHC I), intramuscular fat content and rate of proteolysis by a proteomics approach. KNP had a significantly (p < 0.05) higher content of MyHC I, and that concurred with greatly (p < 0.05) higher intramuscular fat content and Hunter a^* value, and significantly (p < 0.05) lower drip loss than those seen in Landrace. One-dimension SDS-PAGE indicated that GAPDH, troponin I and creatine kinase were prominent proteolytic products during chiller ageing. By applying a gel-based proteome analysis, 26 proteins were identified, which showed different degradation properties during ageing between the breeds. Biopsied sample revealed that myosin regulatory light chain 2, myosin light chain isotype v/sb, fatty acid-binding protein and albumin were expressed at a greatly higher level for KNP, but their relation to fiber type (or genetic background) is unclear. It was particular noticeable that different actin isoforms showed various degradation behavior during ageing time.     

Influences of dietary conjugated linoleic acid (CLA) and total lysine content on growth, carcass characteristics and meat quality of heavy pigs

To assess the effects of dietary CLA, lysine and sex on performance, blood metabolites, carcass characteristics, meat quality and skeletal development, seventy-two pigs (initially 105.3 ± 6.6 kg live weight) barrows and gilts, were assigned to one of four diets in a 2 × 2 × 2 factorial arrangement. The diets contained 0% or 0.75% CLA, and 0% or 0.16% of l-lysine–HCl. All pigs were slaughtered at an average weight of 153.4 ± 11.0 kg. Neither CLA nor lysine supplementation influenced growth, blood metabolites or carcass characteristics. CLA reduced (P < 0.05) pH₂₄ and increased (P < 0.01) yellowness (b^*) of the Longissimus muscle. Lysine increased (P < 0.01) pH₂₄ and reduced (P < 0.01) muscle ash content. CLA reduced (P < 0.05) collagen synthesis, and lysine increased (P < 0.05) collagen synthesis in Longissimus muscle, but no influence on intramuscular collagen maturity or muscle hydroxylysylpyridinoline crosslink concentration were observed. In addition, metacarpal bone diameter was reduced (P < 0.05) by CLA. Barrows had higher ADG, final weight (P < 0.01), carcass weight, lean percentage (P < 0.05), serum cholesterol (P < 0.05) and triacylglycerol (P < 0.001) than gilts. Metatarsal diameter was larger in gilts than barrows (P < 0.05).     

Effects of breed and marination on the sensory attributes of pork from Large White and Hampshire-sired pigs

The effects of breed and marination were tested for their effects on meat pH, water holding (marinade uptake and losses) and eating quality (tenderness, juiciness and flavour).

Loins were removed from one side of 20 Large White-sired and 20 Hampshire-sired pigs after slaughter, cut into four pieces and injected to 112% of their initial weight with water, a polyphosphate-containing marinade (pH 7.7) or a high pH marinade (pH 10.3). An uninjected piece of loin served as control. Samples were left overnight and then frozen before being thawed, cooked and assessed by a trained ten member sensory panel using 1–8 category scales.

Hampshires had higher intramuscular fat (0.95%) than Large Whites (0.62%) but otherwise the effects of breed were small compared with marination. Both marinades significantly increased meat pH from 5.5 (control) by 0.2 U, significantly reduced the cooking loss and increased the meat yield from about 80% to 90%. Water-injected samples lost large amounts of added water as drip after thawing and had a yield (76%) similar to the control. Marinaded samples retained more water post-cooking. Both marinades significantly increased tenderness (p < 0.001) and juiciness (p < 0.001) by about 1.0 U compared with the control (4.4 for tenderness and 4.2 for juiciness). Pork flavour, however, was significantly reduced (p < 0.001) and abnormal flavour was significantly increased (p < 0.001) by marination. Tenderness was positively correlated with pH after injection (0.83) and yield (0.75); juiciness was also positively correlated with pH after injection (0.78) and yield (0.87).

The absence of any significant difference in eating quality between control and water-injected samples, and the relatively large effects of marination, suggest that retained water (after cooking) is crucial in determining perceived tenderness and juiciness in pork.     

AMP-activated protein kinase is negatively associated with intramuscular fat content in longissimus dorsi muscle of beef cattle

Marbling, or intramuscular fat, is an important factor in meat quality. As a key regulator of lipid metabolism, AMP activated protein kinase (AMPK) may be associated with intramuscular fat accumulation. Our objective was to evaluate the relationship among AMPK and its associated signaling mediators, with marbling and lean growth in beef cattle. Steers with high intramuscular fat content (High IMF, 5.71 ± 0.36%, n = 5) and low intramuscular fat content (Low IMF, 2.09 ± 0.19%, n = 5) were selected. High IMF was associated with increased tenderness (P < 0.05) and backfat thickness (P < 0.01). Muscle weights were higher in Low compared to High IMF (P < 0.05). High IMF steers had a reduced AMPK activity (P < 0.01), reduced acetyl-CoA carboxylase phosphorylation (P < 0.05), and reduced total mTOR (P = 0.02) content. Data provide evidence that AMPK is involved in IMF deposition in beef cattle.     

Meat quality characteristics of springbok (Antidorcas marsupialis). 1: Physical meat attributes as influenced by age, gender and production region

Springbok is the most extensively cropped game species in South Africa. The effects of age (adult, sub-adult, lamb), gender and production region on the physical attributes (pH₂₄, cooking and drip loss, Warner Bratzler shear force and colour) were determined using samples of the M. longissimus dorsi (LD) muscles of 166 springbok. Stressed animals had a higher (P < 0.05) pH₂₄ (6.3 ± 0.07), as observed in the meat originating from the Caledon region. This meat had lower (P < 0.05) cooking loss (27.2 ± 0.62%) and drip loss (1.8 ± 0.08%) values in comparison to meat originating from the other regions. Inverse correlations were noted between pH₂₄ and drip loss (r = −0.26, P < 0.01) and cooking loss (r = −0.42, P < 0.001). Shear force values (kg/1.27 cm diameter) correlated positively (r = 0.25, P < 0.01) with pH₂₄. Age-related effects on tenderness were small in comparison with pH₂₄ effects. CIELab colorimetric values were typical of game meat and venison (L^* < 40, high a^* and low b^* values). It was noted that pH₂₄ correlated negatively (r = −0.51, P < 0.001) and positively (r = 0.33, P < 0.001) with the hue-angle and the chroma value of colour, respectively. Springbok originating from Caledon had a significantly (P < 0.05) higher a^* value, indicating meat to be more red with higher colour saturation.     

Addition of tea catechins and vitamin C on sensory evaluation, colour and lipid stability during chilled storage in cooked or raw beef and chicken patties

The effects of addition of tea catechins (TC) and vitamin C (VC) on sensory evaluation, colour and lipid stability in cooked or raw beef and chicken meat patties during refrigerated storage were studied. Fresh beef striploin and chicken breast muscles were minced, following removal of external fat and connective tissue. Following mincing, beef and chicken were assigned to one of the following five treatments: control (meat treated with no antioxidant); TC200, meat plus 200 mg TC/kg muscle; TC400, meat plus 400 mg TC/kg muscle; VC200, meat plus 200 mg VC/kg muscle, VC400, meat plus 400 mg VC/kg muscle. Sodium chloride (1%) was added to all samples. Patties (125 g portions), formed from the above-treated minced meat, were oven cooked, cooled, and packaged in 30% CO₂:70% N₂. Fresh raw beef and chicken patties were packaged in 80% O₂:20% CO₂. All samples were stored for up to 7 days under fluorescent lighting at 4 °C. Sensory parameters (colour, flavour, taste, tenderness and overall acceptability) were evaluated on cooked beef and chicken patties after 1, 3 and 6 days of storage. Surface colour (Hunter L, a and b values), and lipid oxidation (2-thiobarbituric acid reactive substances) were measured on days 1, 3 and 6 of storage for cooked meats and on days 2 and 7 for raw beef and chicken. Tea catechins addition (200 or 400 mg/kg) to minced meat caused (P < 0.05) discolouration in cooked beef and chicken meat patties and significantly reduced (P < 0.001) lipid oxidation in cooked or raw beef patties compared to the control. Beef, either raw or cooked, was more susceptible (P < 0.01) to oxidation compared to chicken. Raw meat stored in high oxygen conditions was more susceptible to lipid oxidation than cooked meat stored in anaerobic conditions. Tea catechins treatments (TC200 and TC400) inhibited (P < 0.05) lipid oxidation in raw beef to a greater extent than vitamin C treatments (VC200 and VC400). These results indicate that tea catechins are potent natural antioxidants and exhibit greater antioxidant efficacy compared to vitamin C.     

Effect of grazing pastures of different botanical composition on antioxidant enzyme activities and oxidative stability of lamb meat

The aim of this work was to study the influence of different pastures (Intensive ryegrass, Botanically diverse and Leguminosa rich pastures) on the antioxidant status and oxidative stability of meat from lambs that had been exclusively grazing for three months. Lipid, colour and protein oxidation, -tocopherol content and activity of antioxidant enzymes (superoxide dismutase (SOD), catalase (Cat) and glutathione peroxidase (GSH-Px)) were measured in Longisimus thoracis et lumborum muscle samples taken 1 day after slaughter. Pasture type significantly affected protein oxidation and the activity of GSH-Px, but no significant differences were found for the -tocopherol content, colour and lipid oxidation, and the activities of SOD and Cat. Grazing a Botanically diverse pasture induced significantly higher protein oxidation in meat, as measured by the free thiol and carbonyl contents, compared to a Leguminosa rich or Intensive ryegrass pasture (P < 0.05). The GSH-Px activity was significantly higher in meat from lambs on the Leguminosa rich pasture compared to the other pasture groups (P < 0.01).     

The effect of journey time and stocking density during transport on carcass and meat quality in rabbits

Four hundred and fifty hybrid commercial rabbits (half males and half females) at the end of their productive cycle (82 days old) were transported in cages (98 × 52 × 24 cm, length × width × height) at high or low density (75.5 or 49.0 kg/m² – 15 or 10 animals per cage) on an uncovered truck for 1, 2 or 4 h. Live weight before and after transport as well as slaughter data were recorded for each rabbit. A subset of 180 carcasses were evaluated for meat quality on the basis of meat pH, colour (CIELab system), cooking loss, drip loss and shear force. As a representative of the whole carcass muscle/bone ratio, the left hind leg was separated, dissected and its meat analysed in order to determine its water, protein, ash and lipid content. It was found that a longer journey significantly increases the live weight losses (3.3% vs. 2.0% vs. 1.6% for 4, 2 or 1 h, respectively; P < 0.001), as a result not only of urine and fecal losses, but also of a decrease in carcass weight (P < 0.01) during transport. Ultimate pH (pH_u) was higher and pH drop lower in rabbits transported for 4 h compared to those transported for 2 h (P < 0.05). Moreover, the meat from animals that had undergone the longest journey was more purple-red (P < 0.05), darker (P < 0.0001), and firmer when raw and showed less cooking loss than meat from those that underwent shorter journeys. Transport density did not influence any of the considered parameters and there was no interaction between transport time and density.     

Meat quality of lambs of indigenous dairy Greek breeds as influenced by dietary protein and gastrointestinal nematode challenge

The effect of dietary protein and gastrointestinal (GI) parasitism on growth and meat quality of lambs was assessed using 60 animals. The lambs were randomly allocated to one of three treatment groups (n = 20): group A, which served as control, group B that was regularly treated with albendazole and group C, which was given supplementary feeding with dietary protein. The three groups of lambs grazed into a pasture (Lolium perenne), which was contaminated with L₃ larvae of GI nematodes. Lamb growth and condition score were assessed at 21-day intervals. After 126 days grazing all lambs were slaughtered and their carcasses were assessed for conformation and fatness and their ultimate pH was measured. Four carcasses from each group were randomly selected for meat quality measurements including physical analysis as well as colour, moisture, total fat, protein content and fatty acid composition. Parasitic challenge was assessed by means of faecal egg counts of lambs, pasture larvae and numbers of adult nematodes in the GI tract of lambs at slaughter. Growth rate of group B was higher (P < 0.01) than that of group A and resulted in significantly (P < 0.01) heavier carcasses. The produced carcasses had similar fatness, but differed significantly (P < 0.05), in their conformation; carcasses of group C scored higher than either those of group B or group A, respectively. There was a significant difference in the colour attributes (L^*) with group A being significantly lighter (P < 0.05) and in pH (P < 0.01); Group B had the highest values. Carcasses of group C had the highest (P < 0.05) amounts of intermuscular fat compared to those of group B and A, respectively. The proportion of C16:1n-7 and C18:2n-6 was higher (P < 0.05) in subcutaneous fat tissue whereas the proportion of C18:0 was higher (P < 0.05) in muscle tissue. In conclusion, the present results showed that the increased protein content in the diet of growing lambs, grazing on a pasture infected with GI nematode larvae, resulted in the production of acceptable carcasses.     

Influence of storage period and packaging method on sliced dry cured beef "Cecina de Leon": Effects on microbiological, physicochemical and sensory quality

Quality aspects of sliced dry-cured beef “Cecina de León” preserved in vacuum and gas mixtures (20%/80% CO₂/N₂ and 80%/20% CO₂/N₂) were studied. The evolution of microbiological, physicochemical and sensory parameters were analysed during storage (210 days) at 6 °C. Although microbial counts at 60 days of the gas-packaged samples were lower than the vacuum-packed ones, they were never higher than the spoilage limit (7 log ufc/g). A slight increase (p < 0.05) in pH was observed throughout storage of “Cecina de León” packaged under vacuum and in gas mixtures. However, a decrease (p < 0.05) in a_w was observed during storage of “Cecina de León” packaged under vacuum but a_w did not vary (p > 0.05) during storage in the gas-packaged samples. No changes were observed (p > 0.05) in lightness (L^*), redness (a^*) and yellowness (b^*) in vacuum and gas packaged samples during storage. However, sensorially evaluated colour showed lower values in gas packaged samples during 30 days storage. This difference was decisive in establishing the shelf-life of “Cecina de León” slices preserved in gas mixtures (20%/80% CO₂/N₂ and 80%/20% CO₂/N₂). Therefore, from a microbiological point of view, gas mixtures are more effective in extending the shelf-life of “Cecina de León” slices. It is concluded that vacuum packaging allows longer storage than gas-packaging as it maintains a good visual appearance of “Cecina de León”, the main parameter in consumers’ perception of meat quality.     

Studies on tenderization and preparation of enrobed pork chunks in microwave oven

This study was conducted to develop technology for tenderization and production of enrobed pork chunks in a microwave oven. Meat chunks from shoulder cuts of pork were cured in a solution containing salt, sodium tripolyphosphate and sugar for 48 h at 4 ± 1 °C, enrobed with cream based batter and cooked in a microwave oven at 900 MHz. These enrobed chunks (control) were compared with tenderized (treated) enrobed chunks, for which 7.5% cucumis extract, 9% ginger extract and 0.50% papain powder were incorporated in the standard curing solution. Ginger and papain treatments caused significant (P < 0.01) increases in the moisture content and pH of the cooked products compared to the control and cucumis treated samples. Shear force values were significantly (P < 0.01) lower and overall acceptability scores were significantly (P < 0.01) higher in all treated samples compared to the control. During storage at 4 ± 1 °C, the moisture contents and sensory qualities decreased, but TBARS values and microbial counts increased significantly (P < 0.01). Although all products were acceptable up to 15 days of storage, the ginger treated samples had significantly (P < 0.01) lower TBARS and microbial loads and higher sensory attributes than the control, cucumis and papain treated samples. The magnitude of the storage changes were less and acceptability ranking was higher for the ginger treated samples compared with the others. The results indicated that microwaves could be used for the preparation of enrobed pork chunks. The overall acceptability and shelf life of microwave cooked enrobed pork chunk can be further improved using ginger extract in the curing solution.     

The effect of production system and age on levels of iron, taurine, carnosine, coenzyme Q(10), and creatine in beef muscles and liver

Samples of longissimus (LL) and triceps brachii (TB) muscles from Angus-cross heifers finished either on a high-concentrate ration in Washington, USA, (US cattle, n = 15) or on pasture in New Zealand (NZ cattle, n = 16) were assessed for composition characteristics. Half of the NZ cattle were of a similar age to the US cattle (NZAge) and half were of a similar weight (NZWt). Iron concentration was higher in TB (20.9 vs. 17.5 μg g⁻¹; P < 0.001) and was higher for the NZWt group than the NZAge group or the US cattle. The proportion of iron as haem iron was highest for the NZWt group (87.3%; P < 0.01), but the proportion as soluble haem iron was highest for the US cattle. For a sub-group of 10 pasture-finished cattle, iron levels in cheek muscle were higher than for LL or TB, and liver levels were 66% higher than cheek muscle. The proportion of haem iron, however, was lowest in liver (55.3%) and was lower in cheek muscle (78.4%) than LL or TB. Relative to LL, TB had higher levels of taurine and coenzyme Q₁₀, but lower levels of carnosine, creatine and creatinine, as expected for a muscle with a more aerobic metabolism. These differences were magnified for the even more aerobic cheek muscle. Differences between the two NZ groups were small, but muscles from the US cattle contained less taurine, carnosine, coenzyme Q₁₀, and creatinine. Reasons for these differences in various meat components for similar cattle from different production systems are not clear.