Effects of interstitial oxygen defects at HfO/sub x/N/sub y//Si interface on electrical characteristics of MOS devices

Effects of the defects at high-/spl kappa/ dielectric/Si interface on the electrical characteristics of MOS devices are important issues. To study these issues, a low defect (denuded zone) at Si surface was formed by a high-temperature annealing in hydrogen atmosphere in this paper. Our results reveal that HfO/sub x/N/sub y/ demonstrates significant improvement on the electrical properties of MOS devices due to its low amount of the interstitial oxygen [O/sub i/] and the crystal-originated particles defects as well as small surface roughness at HfO/sub x/N/sub y//Si interface. The current-conduction mechanism of the HfO/sub x/N/sub y/ film at the low- and high-electrical field and high-temperature (T>100/spl deg/C) is dominated by Schottky emission and Frenkel-Poole (FP) emission, respectively. The trap energy level involved in FP conduction was estimated to be around 0.5eV. Reduced gate leakage current, stress-induced leakage current and defect generation rate, attributable to the reduction of defects at HfO/sub x/N/sub y//Si interface, were observed for devices with denuded zone. The variable rise and fall time bipolar-pulse-induced current technique was used to determine the energy distribution of interface trap density (D/sub it/). The results exhibit that relatively low D/sub it/ can be attributed to the reduction of defects at Si surface. By using denuded zone at the Si surface, HfO/sub x/N/sub y/ has demonstrated significant improvement on electrical properties as compared to SiO/sub x/N/sub y/.     

Electronic properties of partially crystalline SiO/sub x/ suboxide films

Partially crystalline, silicon suboxide (SiO/sub x/, 0相似文献   

Effect of Mg doping on the superconducting properties of Cu/sub 1-x/Tl/sub x/Ba/sub 2/Ca/sub 3-y/Mg/sub y/Cu/sub 4/O/sub 12-/spl delta//

Superconducting properties of Cu/sub 1-x/Tl/sub x/Ba/sub 2/Ca/sub 3-y/Mg/sub y/Cu/sub 4/O/sub 12-/spl delta// (Cu/sub 1-x/Tl/sub x/Mg/sub y/-1234) material have been studied in the composition range y=0,1.5,2.25. The zero resistivity critical temperature [T/sub c/(R=0)] was found to increase with the increased concentration of Mg in the unit cell; for y=1.5 [T/sub c/(R=0)]=131 K was achieved which is hitherto highest in Cu/sub 1-x/Tl/sub x/-based superconductors. The X-ray diffraction analyses have shown the formation of a predominant single phase of Cu/sub 0.5/Tl/sub 0.5/Ba/sub 2/Ca/sub 3-y/Mg/sub y/Cu/sub 4/O/sub 12-/spl delta// superconductor with an inclusion of impurity phase. It is observed from the convex shape of the resistivity versus temperature measurements that our as-prepared material was in the region of carrier over-doping, and the number of carriers was optimized by postannealing experiments in air at 400/spl deg/C, 500/spl deg/C, and 600/spl deg/C. The T/sub c/(R=0) was found to increase with postannealing and the best postannealing temperature was found to be 600/spl deg/C. The mechanism of increased T/sub c/(R=0) is understood by carrying out infrared absorption measurements. It was observed through softening of Cu(2)-O/sub A/-Tl apical oxygen mode that improved interplane coupling was a possible source of enhancement of T/sub c/(R=0) to 131 K.     

ScN/sub x/ gate on atomic layer deposited HfO/sub 2/ and effect of high-pressure wet post deposition annealing

For nMOS devices with HfO/sub 2/, a metal gate with a very low workfunction is necessary. In this letter, the effective workfunction (/spl Phi//sub m,eff/) values of ScN/sub x/ gates on both SiO/sub 2/ and atomic layer deposited (ALD) HfO/sub 2/ are evaluated. The ScN/sub x//SiO/sub 2/ samples have a wide range of /spl Phi//sub m,eff/ values from /spl sim/ 3.9 to /spl sim/ 4.7 eV, and nMOS-compatible /spl Phi//sub m,eff/ values can be obtained. However, the ScN/sub x/ gates on conventional post deposition-annealed HfO/sub 2/ show a relatively narrow range of /spl Phi//sub m,eff/ values from /spl sim/ 4.5 to /spl sim/ 4.8 eV, and nMOS-compatible /spl Phi//sub m,eff/ values cannot be obtained due to the Fermi-level pinning (FLP) effect. Using high-pressure wet post deposition annealing, we could dramatically reduce the extrinsic FLP. The /spl Phi//sub m,eff/ value of /spl sim/ 4.2 eV was obtained for the ScN/sub x/ gate on the wet-treated HfO/sub 2/. Therefore, ScN/sub x/ metal gate is a good candidate for nMOS devices with ALD HfO/sub 2/.     

Low-frequency noise in submicrometer MOSFETs with HfO/sub 2/, HfO/sub 2//Al/sub 2/O/sub 3/ and HfAlO/sub x/ gate stacks

Low-frequency noise measurements were performed on p- and n-channel MOSFETs with HfO/sub 2/, HfAlO/sub x/ and HfO/sub 2//Al/sub 2/O/sub 3/ as the gate dielectric materials. The gate length varied from 0.135 to 0.36 /spl mu/m with 10.02 /spl mu/m gate width. The equivalent oxide thicknesses were: HfO/sub 2/ 23 /spl Aring/, HfAlO/sub x/ 28.5 /spl Aring/ and HfO/sub 2//Al/sub 2/O/sub 3/ 33 /spl Aring/. In addition to the core structures with only about 10 /spl Aring/ of oxide between the high-/spl kappa/ dielectric and silicon substrate, there were "double-gate oxide" structures where an interfacial oxide layer of 40 /spl Aring/ was grown between the high-/spl kappa/ dielectric and Si. DC analysis showed low gate leakage currents in the order of 10/sup -12/A(2-5/spl times/10/sup -5/ A/cm/sup 2/) for the devices and, in general, yielded higher threshold voltages and lower mobility values when compared to the corresponding SiO/sub 2/ devices. The unified number-mobility fluctuation model was used to account for the observed 1/f noise and to extract the oxide trap density, which ranged from 1.8/spl times/10/sup 17/ cm/sup -3/eV/sup -1/ to 1.3/spl times/10/sup 19/ cm/sup -3/eV/sup -1/, somewhat higher compared to conventional SiO/sub 2/ MOSFETs with the similar device dimensions. There was no evidence of single electron switching events or random telegraph signals. The aim of this paper is to present a general discussion on low-frequency noise characteristics of the three different high-/spl kappa//gate stacks, relative comparison among them and to the Si--SiO/sub 2/ system.     

Thermally robust TaTb/sub x/N metal gate electrode for n-MOSFETs applications

In this letter, we study Terbium (Tb)-incorporated TaN (TaTb/sub x/N) as a thermally robust N-type metal gate electrode for the first time. The work function of the Ta/sub 0.94/Tb/sub 0.06/N/sub y/ metal gate is determined to be /spl sim/4.23 eV after rapid thermal anneal at 1000/spl deg/C for 30 s, and can be further tuned by varying the Tb concentration. Moreover, the TaTb/sub x/N-SiO/sub 2/ gate stack exhibits excellent thermal stability up to 1000/spl deg/C with no degradation to the equivalent oxide thickness, gate leakage, and time-dependent dielectric breakdown (TDDB) characteristics. These results suggest that Tb-incorporated TaN (TaTb/sub x/N) could be a promising metal gate candidate for n-MOSFET in a dual-metal gate Si CMOS process.     

Anodic Oxidation of Si in Oxygen/Chlorine Plasma

By adding a few percent of chlorine to oxygen plasma, the anodization rate of Si was enhanced; for example, the rate was doubled for oxygen containing 3-percent chlorine. With a chlorine concentration of 1.5 percent, the density of trap states at the Si-SiO/sub 2/ interface was reduced from 7 X 10/sup 11//cm/sup 2//spl dot/eV to 5 X 10/sup 11//cm/sup 2/ /spl dot/eV at the midgap of Si; after annealing at 800/spl deg/C in argon for 60 min, it was reduced to 8 X 10/sup 10//cm/sup 2//spl dot/eV, and did not return to the original value after heating the specimen to 800/spl deg/C. The density and capture cross section of traps in plasma-anodic oxide were also measured using the constant-current avalanche-injection method. The number of electron traps with small cross sections in plasma-anodic SiO/sub 2/ films was reduced by annealing them at 800/spl deg/C in argon, but SiO/sub 2/ films which were anodized in oxygen/chlorine plasma showed an increase of trap density under the same annealing condition.     

Low-frequency noise in submicrometer MOSFETs with HfO/sub 2/, HfO/sub 2//Al/sub 2/O/sub 3/ and HfAlO/sub x/ gate stacks

Low-frequency noise measurements were performed on p- and n-channel MOSFETs with HfO/sub 2/, HfAlO/sub x/ and HfO/sub 2//Al/sub 2/O/sub 3/ as the gate dielectric materials. The gate length varied from 0.135 to 0.36 /spl mu/m with 10.02 /spl mu/m gate width. The equivalent oxide thicknesses were: HfO/sub 2/ 23 /spl Aring/, HfAlO/sub x/ 28.5 /spl Aring/ and HfO/sub 2//Al/sub 2/O/sub 3/ 33 /spl Aring/. In addition to the core structures with only about 10 /spl Aring/ of oxide between the high-K dielectric and silicon substrate, there were "double-gate oxide" structures where an interfacial oxide layer of 40 /spl Aring/ was grown between the high-K dielectric and Si. DC analysis showed low gate leakage currents in the order of 10/sup -12/ A(2-5 /spl times/ 10/sup -5/ A/cm/sup 2/) for the devices and, in general, yielded higher threshold voltages and lower mobility values when compared to the corresponding SiO/sub 2/ devices. The unified number-mobility fluctuation model was used to account for the observed 1/f noise and to extract the oxide trap density, which ranged from 1.8 /spl times/ 10/sup 17/ cm/sup -3/ eV/sup -1/ to 1, 3 /spl times/ 10/sup 19/ cm/sup -3/ eV/sup -1/ somewhat higher compared to conventional SiO/sub 2/ MOSFETs with the similar device dimensions. There was no evidence of single electron switching events or random telegraph signals. The aim of this paper is to present a general discussion on low-frequency noise characteristics of the three different high-K/gate stacks, relative comparison among them and to the Si-SiO/sub 2/ system.     

Effect of CVD-SiO/sub 2/ film on reliability of GaAs MESFET with Ti/Pt/Au gate metal

The effect of CVD-SiO/sub 2/ films on the reliability of GaAs MESFET with Ti/Pt/Au gate metal was investigated. It was found that the mean time to failure (MTTF) of MESFET with 350/spl deg/C-depositied SiO/sub 2/ was only about one-seventh of that of the ones with 440/spl deg/C-SiO/sub 2/. It was also found that, in the storage test at 300/spl deg/C for 24 hours, diffusion of Pt into GaAs was accelerated when the SiO/sub 2/ deposition temperature was lower than 380/spl deg/C. FT-IR spectra indicated that the lower deposition temperature leads to a higher concentration of the residual hydrogen in SiO/sub 2/. Thermal differential spectrometry (TDS) demonstrated that hydrogen in SiO/sub 2/ could migrate even below 300/spl deg/C. In conclusion, the residual hydrogen in SiO/sub 2/ causes the degradation phenomena.     

Turn-on voltage investigation of GaAs-based bipolar transistors with Ga/sub 1-x/In/sub x/As/sub 1-y/N/sub y/ base layers

The fundamental lower limit on the turn on voltage of GaAs-based bipolar transistors is first established, then reduced with the use of a novel low energy-gap base material, Ga/sub 1-x/In/sub x/As/sub 1-y/N/sub y/. InGaP/GaInAsN DHBTs (x/spl sim/3y/spl sim/0.01) with high p-type doping levels (/spl sim/3/spl times/10/sup 19/ cm/sup -3/) and dc current gain (/spl beta//sub max//spl sim/68 at 234 /spl Omega///spl square/) are demonstrated. A reduction in the turn-on voltage over a wide range of practical base sheet resistance values (100 to 400 /spl Omega///spl square/) is established relative to both GaAs BJTs and conventional InGaP/GaAs HBTs with optimized base-emitter interfaces-over 25 mV in heavily doped, high dc current gain samples. The potential to engineer turn-on voltages comparable to Si- or InP-based bipolar devices on a GaAs platform is enabled by the use of lattice matched Ga/sub 1-x/In/sub x/As/sub 1-y/N/sub y/ alloys, which can simultaneously reduce the energy-gap and balance the lattice constant of the base layer when x/spl sim/3y.     

MOS capacitors on epitaxial Ge-Si/sub 1-x/Ge/sub x/ with high-/spl kappa/ dielectrics using RPCVD

We report the successful growth of MOS capacitor stacks with low temperature strained epitaxial Ge or Si/sub 1-x/Ge/sub x/(x=0.9) layer directly on Si substrates, and with HfO/sub 2/(EOT=9.7 /spl Aring/) as high-/spl kappa/ dielectrics, both using a novel remote plasma-assisted chemical vapor deposition technique. These novel MOS capacitors, which were fabricated entirely at or below 400/spl deg/C, exhibit normal capacitance-voltage and current-voltage characteristics.     

Room-temperature self-organised In/sub 0.5/Ga/sub 0.5/As quantum dot laser on silicon

The first room-temperature operation of In/sub 0.5/Ga/sub 0.5/As quantum dot lasers grown directly on Si substrates with a thin (/spl les/2 /spl mu/m) GaAs buffer layer is reported. The devices are characterised by J/sub th//spl sim/1500 A/cm/sup 2/, output power >50 mW, and large T/sub 0/ (244 K) and constant output slope efficiency (/spl ges/0.3 W/A) in the temperature range 5-95/spl deg/C.     

MIM capacitors using atomic-layer-deposited high-/spl kappa/ (HfO/sub 2/)/sub 1-x/(Al/sub 2/O/sub 3/)/sub x/ dielectrics

Metal-insulator-metal (MIM) capacitors with (HfO/sub 2/)/sub 1-x/(Al/sub 2/O/sub 3/)/sub x/ high-/spl kappa/ dielectric films were investigated for the first time. The results show that both the capacitance density and voltage/temperature coefficients of capacitance (VCC/TCC) values decrease with increasing Al/sub 2/O/sub 3/ mole fraction. It was demonstrated that the (HfO/sub 2/)/sub 1-x/(Al/sub 2/O/sub 3/)/sub x/ MIM capacitor with an Al/sub 2/O/sub 3/ mole fraction of 0.14 is optimized. It provides a high capacitance density (3.5 fF//spl mu/m/sup 2/) and low VCC values (/spl sim/140 ppm/V/sup 2/) at the same time. In addition, small frequency dependence, low loss tangent, and low leakage current are obtained. Also, no electrical degradation was observed for (HfO/sub 2/)/sub 1-x/(Al/sub 2/O/sub 3/)/sub x/ MIM capacitors after N/sub 2/ annealing at 400/spl deg/C. These results show that the (HfO/sub 2/)/sub 0.86/(Al/sub 2/O/sub 3/)/sub 0.14/ MIM capacitor is very suitable for capacitor applications within the thermal budget of the back end of line process.     

Physically based quantum-mechanical compact model of MOS devices substrate-injected tunneling current through ultrathin (EOT /spl sim/ 1 nm) SiO/sub 2/ and high-/spl kappa/ gate stacks

Building on a previously presented compact gate capacitance (C/sub g/-V/sub g/) model, a computationally efficient and accurate physically based compact model of gate substrate-injected tunneling current (I/sub g/-V/sub g/) is provided for both ultrathin SiO/sub 2/ and high-dielectric constant (high-/spl kappa/) gate stacks of equivalent oxide thickness (EOT) down to /spl sim/ 1 nm. Direct and Fowler-Nordheim tunneling from multiple discrete subbands in the strong inversion layer are addressed. Subband energies in the presence of wave function penetration into the gate dielectric, charge distributions among the subbands subject to Fermi-Dirac statistics, and the barrier potential are provided from the compact C/sub g/-V/sub g/ model. A modified version of the conventional Wentzel-Kramer-Brillouin approximation allows for the effects of the abrupt material interfaces and nonparabolicities in complex band structures of the individual dielectrics on the tunneling current. This compact model produces simulation results comparable to those obtained via computationally intense self-consistent Poisson-Schro/spl uml/dinger simulators with the same MOS devices structures and material parameters for 1-nm EOTs of SiO/sub 2/ and high-/spl kappa//SiO/sub 2/ gate stacks on (100) Si, respectively. Comparisons to experimental data for MOS devices with metal and polysilicon gates, ultrathin dielectrics of SiO/sub 2/, Si/sub 3/N/sub 4/, and high-/spl kappa/ (e.g., HfO/sub 2/) gate stacks on (100) Si with EOTs down to /spl sim/ 1-nm show excellent agreement.     

BC high-/spl kappa//metal gate Ge/C alloy pMOSFETs fabricated directly on Si (100) substrates

Buried-channel (BC) high-/spl kappa//metal gate pMOSFETs were fabricated on Ge/sub 1-x/C/sub x/ layers for the first time. Ge/sub 1-x/C/sub x/ was grown directly on Si (100) by ultrahigh-vacuum chemical vapor deposition using methylgermane (CH/sub 3/GeH/sub 3/) and germane (GeH/sub 4/) precursors at 450/spl deg/C and 5 mtorr. High-quality films were achieved with a very low root-mean-square roughness of 3 /spl Aring/ measured by atomic force microscopy. The carbon (C) content in the Ge/sub 1-x/C/sub x/ layer was approximately 1 at.% as measured by secondary ion mass spectrometry. Ge/sub 1-x/C/sub x/ BC pMOSFETs with an effective oxide thickness of 1.9 nm and a gate length of 10 /spl mu/m exhibited high saturation drain current of 10.8 /spl mu/A//spl mu/m for a gate voltage overdrive of -1.0 V. Compared to Si control devices, the BC pMOSFETs showed 2/spl times/ enhancement in the saturation drain current and 1.6/spl times/ enhancement in the transconductance. The I/sub on//I/sub off/ ratio was greater than 5/spl times/10/sup 4/. The improved drain current represented an effective hole mobility enhancement of 1.5/spl times/ over the universal mobility curve for Si.     

High-k Al/sub 2/O/sub 3/ gate dielectrics prepared by oxidation of aluminum film in nitric acid followed by high-temperature annealing

A simple, cost-effective, and room temperature process was proposed to prepare high-k gate dielectrics. An aluminum oxide (Al/sub 2/O/sub 3/) gate dielectric was prepared by oxidation of ultrathin Al film in nitric acid (HNO/sub 3/) at room temperature then followed by high-temperature annealing in O/sub 2/ or N/sub 2/. The substrate injection current behavior and interface trap-induced capacitance were introduced to investigate the interfacial property between the gate dielectric and Si substrate. Al/sub 2/O/sub 3/ gate dielectric MOS capacitors with and without initial SiO/sub 2/ layers were characterized. It was shown that the Al/sub 2/O/sub 3/ gate dielectrics with initial oxide exhibit better electrical properties than those without. The 650/spl deg/C N/sub 2/-POA Al/sub 2/O/sub 3/-SiO/sub 2/ sample with an equivalent oxide thickness of 18 /spl Aring/ exhibits three orders of magnitude reduction in gate leakage current in comparison with the conventional thermal SiO/sub 2/ sample.     

A novel strained Si/sub 0.7/Ge/sub 0.3/ surface-channel pMOSFET with an ALD TiN/Al/sub 2/O/sub 3//HfAlO/sub x//Al/sub 2/O/sub 3/ gate stack

Proof-of-concept pMOSFETs with a strained-Si/sub 0.7/Ge/sub 0.3/ surface-channel deposited by selective epitaxy and a TiN/Al/sub 2/O/sub 3//HfAlO/sub x//Al/sub 2/O/sub 3/ gate stack grown by atomic layer chemical vapor deposition (ALD) techniques were fabricated. The Si/sub 0.7/Ge/sub 0.3/ pMOSFETs exhibited more than 30% higher current drive and peak transconductance than reference Si pMOSFETs with the same gate stack. The effective mobility for the Si reference coincided with the universal hole mobility curve for Si. The presence of a relatively low density of interface states, determined as 3.3 /spl times/ 10/sup 11/ cm/sup -2/ eV/sup -1/, yielded a subthreshold slope of 75 mV/dec. for the Si reference. For the Si/sub 0.7/Ge/sub 0.3/ pMOSFETs, these values were 1.6 /spl times/ 10/sup 12/ cm/sup -2/ eV/sup -1/ and 110 mV/dec., respectively.     

Defect-enhanced visible electroluminescence of multi-energy silicon-implanted silicon dioxide film

White-light and blue-green electroluminescence (EL) of a multirecipe Si-ion-implanted SiO/sub 2/ (SiO/sub 2/:Si/sup +/) film on Si substrate are demonstrated. The blue-green photoluminescence (PL) is enhanced by the reaction of O/sub 3//spl equiv/Si-O-Si/spl equiv/O/sub 3//spl rarr/O/sub 3//spl equiv/Si-Si/spl equiv/O/sub 3/+O/sub interstitial/ during Si implantation. After annealing at 1100/spl deg/C for 180 min, the luminescence at both 415 and 455 nm is markedly enhanced by the complete activation of radiative defects, such as weak oxygen bonds, neutral oxygen vacancies (NOVs), and the precursors of nanocrystallite Si (E'/sub /spl delta// centers). Absorption spectroscopy and electron paramagnetic resonance confirm the existence of NOVs and E'/sub /spl delta// centers. The slowly rising E'/sub /spl delta//-related PL intensity reveals that the formation of nanocrystallite Si (nc-Si) requires longer annealing times and suggests that the activation energy for diffusion of excess Si atoms is higher than that of other defects in ion implanted SiO/sub 2/. The EL from the Ag-SiO/sub 2/:Si/sup +//n-Si-Ag metal-oxide-semiconductor diode changes from deep blue to green as the driving current increase from 0.28 to 3 A. The maximum white-light luminescent power is up to 120 nW at a bias current of 1.25 A.     

High work function Ir/sub x/Si gates on HfAlON p-MOSFETs

We have fabricated the fully silicided Ir/sub x/Si-gated p-MOSFETs on HfAlON gate dielectric with 1.7-nm equivalent oxide thickness. After 950/spl deg/C rapid thermal annealing, the fully Ir/sub x/Si/HfAlON device has high effective work function of 4.9 eV, high peak hole mobility of 80 cm/sup 2//V/spl middot/s, and the advantage of being process compatible to the current VLSI fabrication line.     

Ultrathin Al/sub 2/O/sub 3/ and HfO/sub 2/ gate dielectrics on surface-nitrided Ge

We have studied ultrathin Al/sub 2/O/sub 3/ and HfO/sub 2/ gate dielectrics on Ge grown by ultrahigh vacuum-reactive atomic-beam deposition and ultraviolet ozone oxidation. Al/sub 2/O/sub 3/-Ge gate stack had a t/sub eq//spl sim/23 /spl Aring/, and three orders of magnitude lower leakage current compared to SiO/sub 2/. HfO/sub 2/-Ge allowed even greater scaling, achieving t/sub eq//spl sim/11 /spl Aring/ and six orders of magnitude lower leakage current compared to SiO/sub 2/. We have carried out a detailed study of cleaning conditions for the Ge wafer, dielectric deposition condition, and anneal conditions and their effect on the electrical properties of metal-gated dielectric-Ge capacitors. We show that surface nitridation is important in reducing hysteresis, interfacial layer formation and leakage current. However, surface nitridation also introduces positive trapped charges and/or dipoles at the interface, resulting in significant flatband voltage shifts, which are mitigated by post-deposition anneals.