MICROBIOLOGICAL QUALITY OF THE DAIRY PRODUCT PEDHA AND ITS IMPROVEMENT USING GAMMA RADIATION

Eighteen pedha samples procured from A and B grade retail shops were examined for their overall microbiological quality and for the presence of foodborne pathogens viz. Staphylococcus aureus, Salmonella sp., Coliforms , Listeria monocytogenes, Yersinia enterocolitica and Bacillus cereus. The microbiological quality of pedha samples from B grade shops was very poor as compared to pedha from A grade shop as evidenced by the very high total bacterial counts (6 × 10⁷ cfu/g), high counts of S. aureus (as high as 7 × 10⁶ cfu/g) and presence of coliforms and Listeria and Yersinia sp. in 33% of the samples. All the samples from A grade shops were also positive for S. aureus though negative for coliforms , Yersinia, Salmonella, Listeria and B. cereus. Gamma irradiation of pedha at a dose of 3kGy at 0C reduced overall bacterial load by five log cycles and S. aureus and coliforms could be totally eliminated. However, 5 kGy dose was necessary to eliminate S. aureus if the initial number exceed 1 × 10⁵ cfu/g. Inoculated pack studies confirmed that 3 kGy dose was sufficient for the complete elimination of up to 1 × 10⁵ cfu/g of S. aureus. A dose of 3 kGy had minimal effect on the sensory quality of pedha and even pedha samples irradiated at 5 kGy dose were acceptable. Treatment with 3 kGy dose of gamma radiation totally eliminated S. aureus and coliforms in pedha, thereby ensuring their microbial safety.     

SHELF-LIFE OF FRESH FILLED PASTA. HAZARD ANALYSIS AND CRITICAL CONTROL POINTS OF THE MANUFACTURING PROCESS AND HOUSEHOLD PRACTICES

Hazard Analysis and Critical Control Point (HACCP) approach was used to assess the safety of a fresh filling pasta (ricotta-filled ravioli) manufacturing plant in La Plata region, Argentina. Household practices like cooking and holding meals before serving were also evaluated. Samples of ricotta, main raw material of the filling, showed colony counts of Enterobacteriaceae total microorganisms, molds and yeasts of (5 × 10³-1 × 10⁵), (1x10⁵−1x10⁸) and 1 × 10⁵ CFU/g, respectively. E. coli was also detected in one out of five samples, suggesting a hazardous condition of this raw material. Salmonella spp. was not isolated from any of the dough samples tested. Ricotta filling showed high colony counts of mesophilic microorganisms (6 × 10⁶ CFU/g), Enterobacteriaceae (1 × 10⁵ - 1 × 10⁶ CFU/g), while E. Coli was detected in 20% of the samples. Counts of B. cereus, S. aureus were less than 1 × 10² CFU/g in the analyzed materials. In the finished product (ricotta-filled ravioli), the colony counts of mesophilic microorganisms and Enterobacteriaceae were 3 × 10⁸ and 8 × 10⁵ CFU/g, respectively. Critical Control Points found were cooking and holding time before serving. The implementation of suggested corrections allowed the microbial quality of the final product (ricotta-filled ravioli) to be improved considerably. The growth of total microbial counts during refrigerated storage (0, 4, 8 and 10C) were measured and the shelf-life of ricotta and ricotta-filled ravioli was calculated.     

RADIATION STERILIZATION OF SPICES FOR HOSPITAL FOOD SERVICES AND PATIENT CARE

A survey of the commercial spices used by food services in a typical hospital environment revealed high contamination with microorganisms, i.e., 10⁴ to 10⁷ counts per gram. The predominant microorganisms were as followed (in colony counts/gram): (1) heat-resistant bacterial spores in black pepper, 1 × 10⁷; thyme, 2 × 10⁶; anise, 7 × 10⁴; curry powder, 4 × 10⁵; poultry seasoning, 8 × 10⁴; pickling spice, cardamom, and cumin, 1.5–3 × 10⁴; (2) mixed populations of vegetative cells and bacterial spores in cumin, 1 × 10⁶; (3) molds in cream of tartar, 2 × 10⁴. Sterility of food may be important in a hospital setting, especially in the care of immunocompromised patients. To eliminate the organisms, we recommend radiation treatment, accompanied by appropriate microbiological quality control. On the basis of radiation survival data, the composite natural flora would be reduced to the level of "commercial sterility" (defined as less than 10 organisms per gram((Kiss 1982) by the following minimum radiation doses (in kGy): black pepper, 13; thyme, 13; cumin, 12; anise, 10; curry, 7.3; pickling spice, 7; poultry seasoning, 6; cardamom, 9.4; cream of tartar, 4. For practical purposes, two dose levels can be recommended for treatment of spices in the hospital environment, low = 6–10 kGy and high = 10–15 kGy.     

The distribution of Enterobacteriaceae and some pathogenic micro-organisms in nonbranded white cheese samples sold in Ankara city

In this research, 75 samples of nonbranded white cheese, presented for sale in small markets from various regions and bazaars in Ankara, were studied. Eighty-six isolates, 71 of which are Gram-negative isolates and 15 of which are Gram-positive isolates, were obtained. These isolates were identified by using bioMérieux API20E and classical methods. Total mesophilic bacteria counts and total coliform bacteria counts were carried out for each white cheese sample. The total average mesophilic bacteria of 75 white cheese samples was 15.5 × 10⁵ cfu/g and the total average coliform bacteria were 13.6 × 10⁵ cfu/g.     

Some chemical and microbiological properties of ghee produced in Eastern Anatolia

Some properties of 30 ghee samples produced in Eastern Anatolia in Turkey were evaluated. Lipolytic bacteria and yeast–mould counts ranged from undetectable to 9.9  ×  10⁵ and 6.9  ×  10⁵ cfu/g, respectively. Most of the samples showed higher free fatty acids (FFA) and peroxide values (PV) than the limits mentioned in International Dairy Federation standards. Storage at 5°C for 30 days was not sufficient to stop the lipolytic and yeast–mould growth and lipid oxidation of the samples. Ghee samples with considerably higher trans -C18 : 1 and trans -C18 : 2 fatty acids contents were considered to be adulterated with hydrogenated oils. It is recommended that specific attention should be given to technology transfer and the education of traditional dairy product manufacturers.     

Microbiological quality of ice creams commercialized in some cities in the state of Rio de Janeiro, Brazil

The microbiological quality of 60 ice cream samples of three commercial brands (A, B and C) of various flavours, commercialized in some towns in the State of Rio de Janeiro, Brazil, was evaluated. Total bacteria count (TCB), coliforms at 35°C (CT), coliforms at 44°C (CF) and presence of Staphylococcus aureus were performed on all samples. TCB ranged from 2.0 × 10 ² to 6.9 × 10 ⁵ cfu/mL, CT from < 3–≥ 2400 MPN/mL, CF from < 3–1100 MPN/mL and S. aureus from < 10–1.4 × 10 ⁶ cfu/mL. The level of bacterial contamination found in this study reflects the unhygienic conditions prevalent in manufacturing and storage of ice creams. Actions are thus necessary by the Brazilian regulatory agencies to require the ice cream processing plants to adopt quality guarantee systems, such as good manufacturing practices and hazard analysis and critical control points system.     

MICROBIOLOGICAL STATUS OF EGYPTIAN SALTED MEAT (BASTERMA) AND FRESH SAUSAGE

The microbiological quality of 125 samples of the most popular Egyptian meat products (75 Egyptian fresh sausage "EPS" and 50 basterma) was determined. The aerobic plate count (APC) and Lactobacillaceae count of basterma ranged from 1 × 10⁴ to 9 × 10⁶ CFU/g, respectively . Enterobacteriaceae, mold and yeast counts for basterma were similar (<1 × 10² CFU/g). Artificially contaminated slices of meat and garlic paste of basterma showed that the paste inhibited growth of Salmonella typhimurium. APC and Enterobacteriaceae counts of EFS ranged from 1.1 × 10⁴ to 1 × 10⁸ and from 1 × 10² to 1 × 10⁷ CFU/g, respectively. Nearly 26% and 29% of EFS were positive for Clostridium perfringens and coagulase-positive Staphylococcus aureus, respectively . Salmonella could not be detected in any examined samples. Bacteriologically, EFS might pose a potential health hazard, making it imperative to institute sanitary measures during its production and sale .; Accepted for Publication July 2, 1997     

THE EFFECT OF AEROBIC MESOPHILIC MICROFLORAL LEVELS ON THE ISOLATION OF INOCULATED LISTERIA MONOCYTOGENES STRAIN LM82 FROM SELECTED FOODS

The effect of aerobic mesophilic microfloral concentration on the isolation of Listeria monocytogenes LM82 was studied in 31 (18 cheeses and 7 noncheese) retail foods having standard plate counts of 10¹ to 10⁸ colony forming units (CFU)/g. Foods were spiked with L. monocytogenes and enriched at 30°C for 24 h in a selective enrichment broth used in a U.S. Food and Drug Administration method. Inoculum levels for isolation on modified McBride agar ranged from 0.1 to > 5 × 10³ with a geometric mean value of 5 inoculated CFU/g or 1.4 CFU/g. Pure Enterococcus (Streptococcus) faecalis ( 0 to 6 × 10⁶ inoculated CFU/mL ) in the absence of food matrix had no effect on the enrichment of L. monocytogenes. Ease of isolation of LM82 was independent of the food microflora concentration both generally and in the specific food type of 9 Brie cheeses. Competition, when it occurs, therefore, may be due to specific bacterial competitors rather than bacterial numbers .     

QUANTITATIVE STUDIES OF PROTEOLYTIC AND LIPOLYTIC BACTERIA IN FROZEN MINCED BEEF AND HAMBURGER

Sixty frozen samples (30 hamburger patties and 30 minced meat) purchased from different retail markets in Ismailia, Egypt were examined for incidence of proteolytic and lipolytic bacteria. Mean values of proteolytic psychrophiles in the examined samples of hamburger and minced meat were 2×10⁵ and 6×10⁴, respectively. Lipolytic psychrophiles in hamburger were 8×10⁵ and 3×10⁵ in minced meat. Proteolytic mesophiles in hamburger and minced meat were 6×10⁵ and 5×10⁴, respectively. Mean values of lipolytic mesophiles were 5×10⁴ for hamburger and 5×10³ for minced meat. Proteolytic thermophiles in hamburger and minced meat were 3×10³ and 10³, respectively. Both proteolytic and lipolytic activities were exhibited by various bacteria that were identified.     

HYGIENIZATION OF INDIAN CHICKEN MEAT BY IONIZING RADIATION

Both fresh and frozen chicken meat were evaluated for microbiological status by screening for total bacterial counts and for the presence of pathogens like Enterobacteria , Bacillus cereus, coagulase positive Staphylococci and Salmonella spp. Most of the samples exhibited heavy bacterial contamination (1.2 × 10⁵ - 2.6 × 10⁶/g), mainly with Staphylococcus spp. (1.5 × 10⁴ - 2.8 × 10⁵/g). All the chicken samples also showed the presence of Salmonellae (3 × 10¹ - 2.1 × 10²/g). Among the different serotypes observed in chickens . S. typhimurium was common in fresh as well as frozen chicken. Radicidation at 2 kGy at cryogenic conditions (−40°C) was efficient in eliminating the natural pathogenic contamination of the poultry . Salmonella spp. viz. S. seftenberg and S. typhimurium differed in radiation sensitivity, the D₁₀ values in phosphate buffer (pH 7.2) being 0.25 kGy and 0.12 kGy, respectively. Chicken homogenate (10%) offered approximately 2-fold protection to these cells. Chicken samples artificially inoculated with a heavy inoculum (10⁸ cells/g) of these 2 serotypes required higher gamma radiation doses of 4–5 kGy. The findings suggested that a dose of 2 kGy is adequate for normally contaminated chicken samples, but for the heavily contaminated chicken a dose of 4–5 kGy, depending upon the predominating Salmonella serotype present, is required .     

Rapid dye reduction tests for the determination of microbiological quality of meat

Rapid dye reduction tests have been developed to determine the quality of meat. Three chemical indicators, resazurin and two tetrazolium compounds, were used to correlate the microbial numbers and reduction times in meat samples. Twenty-five surface samples from sheep carcasses were subjected to each reduction test. Total viable counts given were obtained at 37°C. Resazurin reduction time was 90–120 min when the bacterial counts ranged from 1.5×10⁶ to 7.7×10⁶/cm². Samples showing bacterial counts between 1.5×10⁶ and 6.0×10⁶/cm² reduced tetrazolium (NBT) in 360–390 min whereas samples containing bacterial counts of 2.1×10⁶/cm² took 420–450 min to reduce iodophenyl nitrophenyl tetrazolium (INT) dye. Regression equations relating the number of organisms per cm² and reduction time were applied to predict the microbiological quality of meat samples from reduction time data. Among the three dyes, resazurin gave the lowest reduction time.     

INHIBITION OF STAPHYLOCOCCUS AUREUS AND BACILLUS CEREUS ON A VEGETARIAN FOOD TREATED WITH NISIN COMBINED WITH EITHER POTASSIUM SORBATE OR SODIUM BENZOATE

Various amounts of nisin (0, 10³ and 5 × 10³ IU/g) in combination with either potassium sorbate (0, 2, and 3%) or sodium benzoate (0, 0.06 and 0.12%) were tested for effectiveness in inhibiting growth of Staphylococcus aureus C10 and Bacillus cereus B7 inoculated on a vegetarian food. The strains used were isolated from vegetarian foods obtained commercially in Taiwan, and the test food, spice and dried bean curd, was selected for the study based on ability to support the growth of these organisms. After treatment with a preservative combination, the surfaces of sterilized food samples were inoculated, samples were stored in vacuum or nonvacuum packages at either 4C or 30C, and at appropriate times, tested for microbial growth. Growth of both isolates was unaffected by vacuum-packaging treatment; however, a bacteriostatic effect was found at 4C. Data indicated that during the 14-day storage at 4C, vacuum-packaged samples treated with 5 × 10³ IU/g nisin and 0.12% sodium benzoate significantly (p < 0.05) decreased the counts of S. aureus C10 and B. cereus B7 by 2.61 and 3.02 log₁₀ CFU/g, respectively. In the vacuum-packaged samples treated with 5 × 10³ IU/g nisin and 3% potassium sorbate, counts for C10 and B7 were decreased by 2.35 and 2.64 log₁₀ CFU/g, respectively. Thus, the combined treatment extended the shelf-life of the vegetarian food .     

Isolation and characterization of the microbial population of different South African kefir grains

Kefir, a slightly acidic fermented milk, is produced by adding lactic acid bacteria and yeasts, in the form of grains, to milk. The bacteria and yeasts present in the kefir grains are known to vary widely. Selective growth media and morphological and biochemical characteristics were used for the isolation and identification of the microbes present in the grains from eight different sources in South Africa. The kefir grains were activated in milk for only 24 h to prevent any changes in the microbial population of the grains. The microbial numbers varied between 6.4 × 10⁴ and 8.5 × 10 ⁸  cfu/g on the media selective for the bacterial species and between 1.5 × 10 ⁵ and 3.7 × 10 ⁸   cfu/g on the media selective for the yeast species. The bacterial genera that were identified included Lactobacillus , Leuconostoc and Lactococcus and the yeast genera included Zygosaccharomyces , Candida and Saccharomyces . The distribution frequencies of the microbes in the different grains were determined and most of the grains were dominated by two microbial species. No pediococci, acetic acid bacteria or propionibacteria were detected.     

Microbial flora of technological interest in raw ovine milk during 6°C storage

Changes in the microbial flora of ovine milk of medium hygienic quality (initial mean total plate count 3.3  ×  10⁵ cfu/mL) were studied throughout refrigerated storage at 6°C. Total plate counts after 48 h of refrigerated storage (mean count 4.6  ×  10⁵ cfu/mL) were under the current standards in the European Union (EU) for raw ovine milk to be used for cheesemaking after heat treatment. However, after 96 h, mean total plate counts (1.6  ×  10⁷ cfu/mL) were above the standards. Lactococci were found at levels higher than Pseudomonas spp. in milk freshly drawn (54.5% and 3.5% of total plate count, respectively) and after 96 h at 6°C (47.9% and 33.9% of total plate count, respectively). Lactobacilli, enterococci, coliforms and thermodurics were found at values lower than lactococci and Pseudomonas spp., before and after refrigerated storage ( ≤  0.08% of the total plate count). A significant growth ( P  < 0.001) was detected for mesophiles, Pseudomonas spp. and lactococci after 96 h of refrigeration at 6°C; however, thermodurics, coliforms, lactobacilli and enterococci, showed no significant increase ( P  > 0.05). Presumptive Escherichia coli (β-glucuronidase-positive) underwent a decrease throughout storage at 6°C.     

SPOILAGE AND HISTAMINE IN WHOLE PACIFIC HERRING (CLUPEA HARENGUS PALLASI) AND PINK SALMON (ONCORHYNCHUS GORBUSCHA) FILLETS

Fresh pink salmon (Oncorhynchus gorbuscha) fillets and whole Pacific herring (Clupea harengus pallasi) were stored for two weeks at 10C to determine if significant amounts of histamine were produced before the fish spoiled. Spoilage odors in salmon were moderate by day 4 and intense by day 7, while herring had detectable spoilage by day 4 and became potent by day 6. Aerobic bacterial counts increased from 4.0 × 10²/g initially to 3.6 × 10⁸/g in salmon fillets by day 14 and from 2.3 × 10³/g initially to 2.7 × 10⁷/g in whole herring by day 14. Total volatile nitrogen increased from 1.8 to 78.5 mg N/100 g in salmon and 2.2 to 23.6 mg N/100 g in herring. Histamine was not detected in salmon, while concentrations reached 54.9 ppm in herring at day 14. However, herring were considered spoiled by day 6.     

REMOVAL OF SALMONELLA TYPHIMURIUM ATTACHED TO CHICKEN SKIN BY RINSING WITH TRISODIUM PHOSPHATE SOLUTION: SCANNING ELECTRON MICROSCOPIC EXAMINATION

The effect of trisodium phosphate (TSP) on Salmonella typhimurium attached to chicken skin was investigated by using scanning electron microscopy (SEM). Chicken drumsticks were inoculated with Salmonella typhimurium (2 × 10⁸ CFU/mL) for 30 min. Both inoculated and non-inoculated drumsticks were rinsed with 10% TSP solution at 10 or 50C for 15 s, and skin pieces were cut and fixed for SEM examination. For inoculated skins, a significant difference was noticed between TSP-rinsed and control skins (water-rinsed) at both temperatures. While control skins were covered with salmonellae (4 × 10⁵∼ 1 × 10⁶ CFU/cm²) and miscellaneous debris, TSP-rinsed skins, either at 10 or 50C, showed clean skin surfaces (<8×10³ CFU/cm²). For non-inoculated skins, it was difficult to see the difference in the number of attached bacteria due to their low numbers, however, water-rinsed skins still showed the debris on the surface. Above observations suggest that one of the major mechanisms of TSP on salmonellae reduction is detachment of contaminants from the skin surface.     

MICROBIOLOGICAL QUALITY OF TRADITIONAL MARKET CURED FISH IN TANZANIA

The microbiological quality of six varieties of retail market traditionally cured fish in Morogoro, Tanzania was investigated over a five-month period. The fish were contaminated with bacteria and molds at levels of: total aerobes, 10⁶ - 1.7 × 10⁷ c.f.u/g; faecal coliforms, 1.1 × 10¹ - 2.5 × 10³ MPN/g; faecal streptococci, 1.4 × 10¹ - 1.3 × 10³ MPN/g; Staphylococcus aureus, 1.3 × 10³ - 8.6 × 10³ c.f.u/g; Aspergillus flavus group, 2.1 × 10¹ - 2 × 10² c.f.u/g of fish. Of faecal coliform, 45% of the isolates were Escherichia coli. Twenty-five percent of the S. aureus isolates were coagulase positive. Sixteen percent of A. flavus isolates were aflatoxigenic. Aflatoxin contamination ranged from O to 18.5 μg/kg of fish. Insect infestation by Dermestes spp. and mites was observed. The results of this preliminary study emphasize the importance of proper processing and handling offish in the tropics in order to safeguard public health .     

Impact of nitrite on detection of Listeria monocytogenes in selected ready-to-eat (RTE) meat and seafood products

ABSTRACT:  The impact of sodium nitrite (NaNO₂) on detection and recovery of Listeria monocytogenes from select ready-to-eat (RTE) foods including smoked salmon, smoked ham, beef frankfurters, and beef bologna was assessed. Nitrite-containing (NC; 100 to 200 ppm NaNO₂) or nitrite-free (NF) foods were inoculated with a 5-strain cocktail of L. monocytogenes by immersion into Butterfield's buffer solution containing 5.4 to 7.4 × 10³ L. monocytogenes per milliliter. Inoculated products were vacuum-packaged and stored at 5 °C. A weekly comparative analysis was performed for presence of L. monocytogenes using 5 detection methods on products held at 5 °C for up to 8 wk. L. monocytogenes initially present at <100 CFU/g during the first 2 wk of storage increased throughout the study, attaining final populations of approximately 1 × 10⁴ to 1 × 10⁵ CFU/g. Lactic acid bacteria predominated throughout the study in all products. Exposure to NaNO₂ (100 to 200 ppm) resulted in 83% to 99% injury to the L. monocytogenes strains tested. The genetic-based BAX^® System (DuPont™ Qualicon, Wilmington, Del., U.S.A.) and modified USDA/FSIS methods detected 98% to 100% of Listeria -positive food samples and were consistently superior to and significantly different ( P < 0.05) from conventional cultural methods in recovering Listeria from NC samples. Data show that nitrite-induced injury adversely affects detection and recovery of L. monocytogenes from NC food, confirming earlier findings that nitrite-induced injury masks L. monocytogenes detection in NC RTE food products. Nitrite-injured Listeria can subsequently repair upon nitrite depletion and grow to high levels over extended refrigerated storage.     

MICROBIAL ENUMERATION IN READY-TO-EAT FOODS AND THEIR RELATIONSHIP TO GOOD MANUFACTURING PRACTICE

As a contribution to Good Manufacturing Practice (GMP) programs, we have analyzed products produced and offered by ready-to-eat food stores. Two hundred and seventy four samples of a wide variety of foods from 19 different shops were analyzed. Aerobic counts, total coliforms and yeast and molds were enumerated in each sample. Food stores were evaluated using a GMP check-list. They were grouped in three classes: Class III, nonsatisfactory GMP; Class II, partially satisfactory GMP; and Class I, satisfactory GMP. From the results of microorganism counts in the Class I food shops the following maximum counts are proposed for cooked ready-to-eat foods: aerobic colony count: 10⁵ cfu g⁻¹. It is coincident with satisfactory microbiological quality of many category 3 foods drawn up by Public Health Laboratory Service (PHLS).