Induced phosphorus fixation and the effectiveness of phosphate fertilizers derived from Sukulu Hills phosphate rock

A greenhouse study was conducted with two surface, acidic soils (a Hiwassee loam and a Marvyn loamy sand) to measure the effect of increasing P-fixation capacity, on the relative agronomic effectiveness (RAE) of phosphate fertilizers derived from Sukulu Hills phosphate rock (PR) from Uganda. Prior to fertilizer application, Fe-gel was added to increase P-fixation capacity from 4.4 to 14.3% for the Marvyn soil and from 37.0 to 61.5% for the Hiwassee soil. Phosphate materials included compacted Sukulu Hills concentrate PR + Triple superphosphate (CTSP) at a total P ratio of PR:TSP = 50:50; 50% partially acidulated PR (CPAPR) from Sukulu Hills concentrate PR made with H₂SO₄; and Sukulu Hills concentrate PR (PRC) made by magnetically removing iron oxide from raw PR ore. Triple superphosphate (TSP) was used as a reference fertilizer. After adjusting soil pH to approximately 6, P sources were applied at rates of 0, 50, 150, and 300 mg total P kg^–1 soil. Two successive crops of 5 week old corn seedlings (Zea mays L.) were grown. The results show that the RAE of the phosphate materials measured using dry-matter yield or P uptake generally decreased as P-fixation capacity was increased for both soils. CTSP was more effective in increasing dry-matter yield and P uptake than CPAPR. PRC alone was an ineffective P source. Soil chemical analysis showed that Bray 1 and Mehlich 1 extractants were ineffective on the high P-fixation capacity Fe-gel amended Hiwassee soil. Mehlich 1 was unsuitable for soils treated with PRC since it apparently solubilizes unreactive PR. When all of the soils and P sources were considered together, Pi paper was the most reliable test for estimating plant available P.     

Field evaluation of partially acidulated phosphate rocks in a Ferralsol from Cuba

Phosphorus (P) is needed in large areas of developing countries toimprove soil fertility for crop production. The use of phosphate rock (PR) isan alternative to costly soluble P fertilizers, but it is ineffective usuallyin non-acid soils unless it is modified i.e. partially acidulated (PAPR). Alaboratory incubation study using the isotopic exchange kinetic method of³²P and field experiments were undertaken on a neutral Ferralsol ofCuba to evaluate the effectiveness of PAPRs as fertilizers for common bean(Phaseolus vulgaris, L.). Sulfuric-acid based PAPR using40%, 50% and 60% of the acid required to produce singlesuperphosphate were studied. In the laboratory experiment Trinidad de GuedesPAPR was effective in providing P to the soil, through increases inisotopicallyexchangeable P and the percentage of P derived from fertilizer (%Pdff). In the three field experiments carried out to compare the P sources,yields of common bean were increased by PAPR, though the response was less thanwith triple superphosphate (TSP). The relative agronomic effectiveness (RAE) ofPAPR was greater than that of unacidulated PR. Taking into account the RAEvalues and the current cost of the P sources, the choice of Trinidad de GuedesPAPR instead of TSP could be economic, although the RAE value for PAPR waslowerthan that of TSP. This result indicates that PAPR could be used in thesoil understudy to obtain the best economic return. DM yield, P uptake and grain yield ofcommon bean were significantly increased by applying P as 50% PAPR. Lowcost improvement of the agronomic value of PR can be achieved by partialacidulation, so this modification of the phosphate rock show promise forutilization of PR reserves indigenous to developing countries.     

Rape genotypic differences in P uptake and utilization from phosphate rocks in an Andisol of Chile

A main constraint to agricultural productivity in the southern regionsof Chile is the low available soil P exacerbated by the high P sorptioncapacityof the predominant Andisols. Therefore, substantial amounts of P fertilizersmust be applied to obtain optimum growth and crop yields. One cost-effectivestrategy followed to supply P to crops grown in these soils is the directapplication of the local Bahia Inglesa PR source. However, a more sustainablestrategy would be to combine the use of the local PR with the crop species andcultivars that are able to grow in these acid soils and can utilize efficientlyPR. Rape is reported to be very efficient in utilising P from PR sources due toits capacity to exude organic acids to the rhizosphere. Therefore, the presentstudy was conducted to evaluate the ability of five rape cultivars grown in anAndisol of southern Chile in utilising P from two PR sources (Bahia Inglesa andBayovar) and triple superphosphate, a water-soluble P fertilizer. It was foundthat rape was able to absorb significant amounts of P from the PR sources andmuch less from the TSP and soil P. Both Bahia Inglesa and Bayovar PRs werefoundto be as effective as TSP for the rape genotypes in the Andisol Pemehue. Theuseof the ³²P isotope technique enabled to assess the ability of thegenotypes tested to utilize P from the different P fertilizers applied. Thegenotypes G2 and G3 showed increased P acquisition from the PR than thegenotypeG5. Combined utilization of P efficient genotypes and direct application of theBahia Inglesa PR seems to be a promising technology for attaining sustainableagricultural productivity in the Andisols of Chile. Further field trials forvalidating these findings at the level of cropping systems are needed. Thisagronomic testing should be accompanied by in-depth studies to assess therelative importance of the morphological and physiological traits determining ahigher P efficiency.     

Cowpea varietal differences in uptake of phosphorus from Gafsa phosphate rock in a low-P Ultisol

A greenhouse experiment was conducted to evaluate varietal differences in the uptake and availability of P from Gafsa phosphate rock (PR) to five cowpea cultivars grown in a low-P Paleustult soil from Ghana, using the A value technique. The³²P radioisotope used as a tracer was³²P-labelled triple superphosphate (TSP). Each cultivar received sole or a combined application of the two fertilizers (TSP, PR). From these treatments it was possible to estimate for each cultivar, A_R + A_S, A_S and by difference A_R (A_R and A_S stand for A values for phosphate rock and soil, respectively). Using this approach we measured significant genotypic differences in P uptake from PR and A_R values. The ranking of the cultivars in P uptake from PR was the same as for A_R, i.e. Asontem > Vallenga > Soronko > IT81D-1137 > Amantin. Similarly, ranking for uptake from soil P was the same as A_S, i.e. Vallenga, Soronko, IT81D-1137, Asontem and Amantin. Thus although PR could not be labelled directly, using the A value approach it was possible to distinguish between P availability from PR and soil to the plant. The recoveries of applied TSP ranged from 8.0% to 9.4% and those of PR from 2.3% to 3%.The other advantage of the A value method is that it made it possible for the different genotypes tested to be compared directly in units of a standard fertilizer, TSP in this case. Thus for Vallenga in this soil 3.01 kg of P in Gafsa PR was capable of supplying the same amount of P that could be supplied by 1 kg P of TSP; whereas for Amantin a higher amount i.e. 3.5 kg P as Gafsa PR was needed. This information is useful for adjusting application rates to be recommended for different P fertilizer sources in field trials so as to achieve similar effects.     

Evaluating the efficacy of various phosphate fertiliser sources for oil palm seedlings

Isotope dilution techniques were used in a glasshouse experiment to compare seven P sources for oil palm seedlings grown on Rengam series soil (Typic Paleudult). The P sources were triple superphosphate (TSP) and six phosphate rocks from North Carolina, USA (NCPR), Tunisia (Gafsa PR), Jordan (JPR), Morocco (MPR), Christmas Island (CIPR) and China (CPR). The percent P derived from fertilisers (%PdfF) in the 3, 6, 9 and 12 months of growth ranged from 81% to 99%, indicating the poor P supplying power of the soil used. TSP was far superior than PR in supplying the required P at all times of measurement. Total amount of P taken up during the 12 months growing period was equivalent to 15.0% of the added P as TSP, it was 5.2% from NCPR, 4.2% from JPR, 4.1% from MPR, 3.2% from GPR, 4% from CIPR and 2.2% from CPR. The PR effectiveness based on the amounts of fertilizer P taken up by the oil palm seedlings at 12 months of growth was in the sequence of triple superphosphate > North Carolina PR > Gafsa PR Jordan PR Morocco PR Christmas Island PR > China PR. This was due to the reactivity of these P sources when applied into the soil, triple superphosphate being water soluble is immediately available. PR sources reacted with the soil solution with time, making P slowly available. PR solubilised by neutral ammonium citrate (NAC) expressed as percentage of rock was shown to correlate better than 2% citric acid and 2% formic acid with plant P uptake. Thus this method of extracting P from PR can be used as a basis for comparing PR effectiveness to oil palm seedlings.     

Factors affecting the agronomic effectiveness of phosphate rock for direct application

Phosphorus (P) is critically needed to improve soil fertility for sustainable crop production in large areas of developing countries. In recent years, phosphate rock (PR) for direct application has been tested in tropical acid soils as a potential alternative to conventional water-soluble P fertilizers like single superphosphate (SSP) and triple superphosphate (TSP). Some developing countries have PR deposits which, if used to supplement other imported P fertilizers, would allow a saving of much needed foreign exchange. Solubility of P fertilizers is not the only criterion in selection of the most suitable P fertilizer. This paper discusses the results of experiments to compare the relative agronomic effectiveness (RAE) of various PR sources with respect to SSP or TSP as influenced by four important factors: PR sources, soil properties, management practices, and crop species. Under certain conditions, PRs can be agronomically effective.     

Effect of soil pH on the requirement for water-soluble phosphorus in triple superphosphate fertilizers

A greenhouse study was conducted to determine if soil pH affects the requirement for water-soluble P and the tolerance of water-insoluble impurities in TSP fertilizers. Two commercial TSP fertilizers were selected to represent a range in phosphate rock sources and impurities. Phosphate fertilizer impurities were isolated as the water-washed fraction by washing whole fertilizers with deionized water. TSP fertilizers with various quantities of water-soluble P (1.2 to 99% water-soluble P) were simulated by mixing the water-washed fertilizer fractions or dicalcium phosphate (DCP) with reagent-grade monocalcium phosphate (MCP). The fertilizers were applied to supply 40 mg AOAC available P kg^–1 to a Mountview silt loam (fine-silty, siliceous, thermic Typic Paleudults). Wheat (Triticum aestivum (L.)) was harvested at 49 and 84 days after planting. Soil pH values at the final forage harvest were 5.4±0.16 and 6.4±0.15. At a soil pH of 5.4, the TSP fertilizers required only 37% water-soluble P to reach maximum yields while at pH 6.4 the fertilizers required 63% water-soluble P. Results of this study show that higher levels of water -insoluble P can be tolerated in TSP fertilizers when applied to acid soils. Phosphorus uptake was not affected by soil pH, but for the mixtures containing the fertilizer residues the source having the lowest level of Fe and Al had a higher relative agronomic effectiveness.     

Comparison of greenhouse and 32P isotopic laboratory methods for evaluating the agronomic effectiveness of natural and modified rock phosphates in some acid soils of Ghana

Phosphorus deficiency is one of the major constraints for normal plant growth and crop yields in the acid soils of Ghana and therefore addition of P inputs is required for sustainable crop production. This is often difficult, if not impossible for small-scale farmers due to the high cost of mineral P fertilizers and limited access to fertilizer supplies. Direct application of finely ground phosphate rocks (PRs) and their modified forms have been recommended as alternatives for P fertilization. The direct application of the natural and modified PRs to these acid soils implies the need to predict their agronomic effectiveness of the PRs in the simplest and most cost-effective manner. In this study the classical greenhouse pot experiment was compared to the ³²P isotopic kinetics laboratory method for evaluating the agronomic effectiveness of natural and modified Togo PR in six highly weathered Oxisols from southwest Ghana. In the ³²P isotopic kinetics laboratory experiment the six soil samples were each fertilised at the rate of 50 mg P kg^–1 soil in the form of triple superphosphate (TSP), Togo PAPR-50%, and Togo PR, respectively. Controls without P amendment were also included. Isotopic exchange kinetics experiments were carried out on two sets of samples, immediately after P fertilizer additions (without incubation) and after 6 weeks of incubation under wet conditions and at a room temperature of 25 °C. In the greenhouse pot experiment, P fertilizers in the form of Togo PR, Togo PAPR, Mali PR and TSP were each applied to the six soils at rates equivalent to 0, 30, 60, and 120 kg P ha^–1, respectively. The P fertilizers were mixed with the soils and maize (Zea mays L.) variety Obatanpa was grown for 42 days before harvest. The isotopic kinetics data of the control samples indicated that 5 of the studied soils had very low P fertility status as reflected by their low P concentrations in solution (C_P<0.02 mg P l^–1) and low exchangeable P (E₁min < 5 mg P kg^–1). The capacity factor and the fixation index of the soils were variable. Application of water-soluble P as TSP increased both the C_P and E₁ values of all the soils above the critical levels. Togo PR was least effective among the fertilizers tested for all soil soils, except in Boi soil. Acidulation of Togo PR (Togo PAPR-50%) was an effective means to increase its agronomic effectiveness. Direct application of natural Togo PR would be only feasible in the Boi soil series as reflected by its high Pdff% value in soil solution. Incubation with the P fertilizers caused an increase in the soil pH and a decline in the effectiveness of the applied P fertilizers, irrespective of the soil and the fertilizer utilized. Based upon the results of the greenhouse pot experiment, the relative crop response index (RCRI) in terms of increasing dry matter yield and P uptake followed the order of TSP > PAPR = Mali PR >Togo PR = Control. Both the laboratory index, Pdff% in soil solution derived from the isotopic method and the RCRI values obtained from the pot experiment produced similar results in ranking the P fertilizers tested according to their agronomic effectiveness. The isotopic kinetic method may be considered as an alternative to both greenhouse and field methods in the evaluation of agronomic effectiveness of P fertilizers in tropical acid soils when it offers comparative advantages in assessing the soil P status and its changes. But trained staff and adequate laboratory facilities are needed to perform this technique. Also the method can be used as a reference for comparison purposes as in this case. Further research is needed to assess the overall agronomic effectiveness (immediate and residual effects) of PR sources in predominant cropping systems of this region of Ghana.     

Effect of phosphate rock sources on biological nitrogen fixation by soybean

Very little information is available concerning the effect of phosphate rock (PR) sources on biological nitrogen fixation (BNF) in legume crops. In a greenhouse study, the¹⁵N isotopic dilution technique was used to compare the effectiveness of three sources of PR (Hahotoe rock, Togo; Tilemsi rock, Mali; and Sechura rock, Peru) with that of triple superphosphate (TSP) in increasing soybean seed yield and the amounts of N fixed by the soybean crop. The acid Hartsells slit loam was limed to pH 5.2 and incubated with 8.5 mg N kg^–1 as K¹⁵NO₃ and sucrose for 2 months prior to planting. Then fertilizer P was incorporated into the soil at 12.5, 25, 50, and 100 mg P kg^–1 rates.The relative agronomic effectiveness (RAE) of the three PRs with respect to TSP (RAE = 100%) in terms of increasing seed yield was Hahotoe rock = 6.0%, Tilemsi rock = 45.9%, and Sechura rock = 75.2%; this trend followed the same trend as PR reactivity, i.e., Sechura rock > Tilemsi rock > Hahotoe rock. BNF was affected significantly by all the P treatments. Of the total N derived from the three N sources (atmosphere, N_dfa; fertilizer K¹⁵NO₃, N_dff; and soil, N_dfs), N_dfa was highest with TSP and lowest with Hahotoe rock, whereas the reverse was found with N_dfs. Among various plant parts, more N_dfa was translocated and stored in seeds than in stems + leaves and roots. The RAE values of the three PRs with respect to TSP (RAE = 100%) in terms of influencing the amount of BNF were Hahotoe rock = 3.0%, Tilemsi rock = 43.4%, and Sechura rock = 71.2%. A linear relationship was found between the amount of BNF by the whole soybean plant and the soybean seed yield.     

Effects of different phosphate fertilizers on yield of barley and rape seed on reddish brown soils of the Ethiopian highlands

The effectiveness of six phosphorus sources at 4 rates were tested for two seasons on reddish brown soil at Holetta, Ethiopia, using barley (Hordeum vulgare L.) and rape (Brassica napus L.) as test crops. The fertilizer sources include: basic slag (BS), bone meal (BM), Ethiopian rock phosphate (ERP), Gafsa rock phosphate (GRP), triple superphosphate (TSP) and mixture of TSP and GRP in the ratio 1:4 (MIX). Yield, P uptake by both crops as well as available soil P showed a marked response to the application of the various P sources. On continuously cropped field, grain yield increase over the unfertilized plot ranged from 2.5 to 16.4 dt ha^–1 for barley and rape respectively. On newly cleared field no significant effects of the different P sources on barley were observed. On the other hand for rape, a grain yield increase over the unfertilized plot ranging from 10.6 to 17.8 dt ha^–1 was recorded. The highest agronomic effectiveness relative to TSP (RAE) for both crops was obtained with BS. Rape was found to utilize P not only from the reactive rock phosphate (RP) but also from the unreactive one, which had a total P content of only 3% and 0.4% ammonium citrate soluble P. Barley, on the contrary, could not utilize P from this magmatic rock phosphate and failed to grow.     

Enhancing the agronomic effectiveness of natural phosphate rock with poultry manure: a way forward to sustainable crop production

Phosphorus inputs are required in highly weathered tropical soils for sustainable crop production. However, high cost and limited access to mineral P fertilizers limit their use by resource-poor farmers in West Africa. Direct application of finely ground phosphate rock (PR) is a promising alternative but low solubility of PR hampers its use. Co-application of PR with manure could be a low cost means of improving the solubility of natural PR and improve their agronomic effectiveness. Our objective was to quantitatively estimate the enhancement effect of poultry manure on P availability from low reactive PR (Togo phosphate rock) applied to highly weathered soils. We utilized two highly weathered soils from Ghana and Brazil for this greenhouse study. Using ³²P isotopic tracers, the agronomic effectiveness of poultry-manure-amended Togo rock phosphate (TPR) was compared with partially acidulated Togo rock phosphate (PAPR) and triple superphosphate (TSP). Four rates of poultry manure: 0, low (30 mg P kg⁻¹ soil), high (60 mg P kg⁻¹ soil) and very high (120 mg P kg⁻¹ soil) were, respectively, added to a constant amendment (60 mg P kg⁻¹ soil) of the P sources and applied to each pot of 4 kg soil. A Randomized Complete Block Design was used for the greenhouse experiment and Maize (Zea mays L.) was used as a test crop. The plants were grown for 42 days after which the above ground biomass was harvested for analysis. Without poultry manure addition, the agronomic effectiveness, represented by the relative agronomic effectiveness (RAE) and proportion of P derived from fertilizer (% Pdff) was in the order TSP > PAPR > TPR = control (P₀). In the presence of low rate poultry manure addition, the agronomic effectiveness followed the order TSP > PAPR = PR > P₀. However, at the high and very high rates of poultry manure addition, no significant differences in agronomic effectiveness were observed among the P sources, suggesting that at this rate of poultry manure addition, PR was equally as effective as TSP. The study showed that direct application of PR co-applied with poultry manure at a 1:1 P ratio will be a viable option for P replenishment. Thus a combination of PR and poultry manure could be a cost-effective means of ensuring sustainable agricultural production in P-deficient, highly weathered tropical soils.     

Evaluation of the agronomic effectiveness of natural and partially acidulated phosphate rocks in several soils using32P isotopic dilution techniques

The agronomic effectiveness of two natural phosphate rocks (PRs) from North Carolina (USA) and Togo and their 50% partially acidulated products (PAPRs) was evaluated in two greenhouse experiments using³²P isotopic dilution techniques, namely L and A_L values.In the first experiment rye grass was grown in a soil from Ghana. While the proportion of P in the plant derived from the P fertilizer (Pdff) ranged on. the average from about 10% for the PRs up to 80% for the PAPRs, the P fertilizer recovery was less than 1% for a 60-day growth period. In the second experiment, average values of P in the maize plants derived from the PAPRs ranged from 35% to 75% in 3 different soils. Both PRs were ineffective with the exception of North Carolina PR in the Seibersdorf soil. The P fertilizer recovery was 0.25% for the North Carolina PR in this soil whereas the recovery values ranged from 1.2% to 1.6% for the PAPRs.Mean values of the relative fertilizer efficiency estimated from the L values of each soil were less than 1% for the PRs whereas the values for the PAPRs which were dependent on soil type ranged from 20% up to 45%. The coefficient of relative effect of partial acidulation, that was calculated from the ratio of A_L values for PR and PAPR in each soil indicated that partial acidulation increased the effectiveness of the natural PRs in all soils under study.This study showed that the use of³²P isotope dilution techniques allows an accurate measurement of the P availability from natural and modified PR products to crops. Another advantage is that quantitative comparison of the P sources under study, PRs and PAPRs in this case, can be made even in soils where there is no response to the applied P sources.     

Phosphorus availability to irrigated lowland rice as affected by sources,application level and green manure

To evaluate alternative fertilizer phosphorus (P) sources in lowland rice, two field experiments were conducted under irrigated conditions in Quezon Province, Philippines during 1990–1991 crop year. In another field experiment fertilizer P recycling through a green manure crop applied in the succeeding rice, was studied. Addition of fertilizer P increased grain yield by 1.5–2.0 t/ha (46%) in 1990 wet season (WS) and by 1.6–2.1 t/ha (56%) in 1991 dry season (DS). However, fertilizer P source and application level did not effect grain yield significantly. Results indicated that the less water-soluble and less expensive partially acidulated phosphate rock (PAPR), phosphate rock (PR) and less reactive PR were as effective as the more soluble but more expensive triple superphosphate (TSP). The relative effectiveness (RE) of local guano was significantly lower than that of other sources of fertilizer P. Fertilizer P applied to a pre-rice Sesbania rostrata green manure increased rice grain yield by 1.5–1.9 t/ha during 1991 DS. Further, S. rostrata fertilized with Morocco phosphate rock (MPR) gave significantly higher rice grain yield than did rice fertilized with MPR applied alone. In the P source experiments Olsen method and Pi correlated better with growth attributes than Bray 2 P. Phoshours uptake did not differ significantly among P sources and levels. Results suggest that P uptake was improved with green manuring. Correlation analyses revealed a close correlation between P uptake and dry matter yield and P uptake and grain yield.     

Agronomic evaluation of fertilizer products derived from Sukulu Hills phosphate rock

Partial acidulation of phosphate rock (PR) or compaction of PR with soluble P fertilizers can improve the usefulness of unreactive PR for use as P fertilizer. A greenhouse study was conducted to evaluate nonconventional phosphate fertilizers derived from a low reactive Sukulu Hills PR from Uganda. Raw PR (which contained 341.0 g kg^–1 Fe₂O₃), beneficiated or concentrate PR, partially acidulated PR (PAPR) and PR compacted with triple superphosphate (TSP) were evaluated. Compacted materials had a P ratio of PR:TSP = 50:50. PAPR materials were made by 50% acidulation with H₂SO₄. TSP was used as a reference fertilizer. Fertilizers were applied to an acidic (pH = 5.4) Hiwassee loam (clayey, kaolinitic, thermic Rhodic Kanhapludults) at rates of 0, 50, 100, 200, 300 and 400 mg P kg^–1 soil. Two successive corn (Zea mays L.) crops were grown for 6 weeks. Compacted concentrate PR + TSP and raw PR + TSP were 94.4 and 89.7% as effective as TSP, respectively, in increasing dry-matter yields for the first corn crop. PAPR from the concentrate was 54.8% as effective as TSP. Raw PR, concentrate PR and the PAPR from the raw PR were ineffective in increasing dry-matter yields. The same trends were obtained when P uptake was used to compare effectiveness. Ineffectiveness of the raw PR and its corresponding PAPR was attributed to a high Fe₂O₃ content in the raw PR. Bray I and Pi paper were found to be nearly equally suitable at estimating available P in the soils treated with responsive fertilizer materials. Mehlich 1 overestimated available P in soil treated with raw PR, concentrate PR or the PAPR from the raw PR.     

How do soil P tests,plant yield and P acquisition by <Emphasis Type="Italic">Lotus tenuis</Emphasis> plants reflect the availability of added P from different phosphate sources

The relative effectiveness (RE) of each one of three different sources of P—P in solution (Psol), triple superphosphate (TSP) and phosphate rock (PR)—for reflecting the availability of P in a P-deficient soil were assessed by measuring in Lotus tenuis variables associated with growth, organ morphology, and plant tissue P-content together with the amounts of P extracts from soil by two of the currently used soil-P tests—Bray I and Olsen. A hyperbolic equation was used to fit the response curves of each one of those plant variables to added-P. The ratio between the shapes of paired response curves of any P-sources was used to compute the RE and substitution rate (K) of one source relative to the other. More P was needed from TSP and PR compared to Psol-100% soluble P-source. On the average P applications as TSP relative to Psol and PR relative to TSP were only 68 and 63% effective respectively for plant growth. Plant roots were more sensitive than soil-P tests to detect shifts in P-availability from different P-sources. Because soil tests are commonly used to estimate the current P status in soil in order to calculate the optimum application levels of fertilizer P for a crop or pasture, these results would have practical agronomical consequences if reproduced in other cultivated species because they show that the response curve of a plant species as a function of added P and soil test might differ among fertilizer types, measured plant variables, and the test used to measure P availability in the soil.     

Agronomic evaluation of modified phosphate rock products

Phosphorus (P) is critically needed to improve the soil fertility for crop production in large areas of developing countries. The high cost of conventional, water-soluble P fertilizers constrains their use by resource-poor farmers. Finely ground phosphate rock (PR) has been tested and used as a direct application fertilizer on tropical acid soils as a low-cost alternative where indigenous deposits of PR are located. However, direct application of PR with low reactivity or with inappropriate soil/crop combinations does not always give satisfactory results. Partial acidulation of PR (PAPR) or compaction with triple superphosphate (PR + TSP) or single superphosphate (PR + SSP) represent technologies that can be used to produce highly effective P fertilizers from those indigenous deposits. Numerous field trials conducted by IFDC in Asia, sub-Saharan Africa, and Latin America have demonstrated that PAPR at 40-50% acidulation with H₂SO₄ or at 20% with H₃PO₄ approaches the effectiveness of SSP or TSP in certain tropical soils and crops. This paper discusses how the agronomic effectiveness of PAPR is affected by mineralogical composition and reactivity of PR used and by soil properties and soil reactions. The paper also indicates that if a PR has high Fe₂O₃ + Al₂O₃ content, it may not be suitable for PAPR processing because of the reversion of water-soluble P to water-insoluble P during the PAPR manufacturing process. Under these conditions, compaction of PR with water-soluble P fertilizers (e.g. SSP, TSP) at P ratio of approximately 50:50 can be agronomically and economically attractive for utilizing the indigenous PRs in developing countries.     

Partially acidulated phosphate rocks: Controlled release phosphorus fertilizers for more sustainable agriculture

Phosphate rocks partially acidulated either with H₃PO₄ or H₂SO₄ were compared against SSP or TSP as phosphate fertilizers for permanent pasture. Eleven field trials were conducted over periods of up to 6 yrs. Fertilizers were surface applied annually. Initial soil pHw values ranged from 5.5–6.3 and Soil P retention from 25% to 97%. The PRs used for partial acidulation were unground or ground North Carolina PR, ground Khouribga PR, and a blend of ground PRs of North Carolina, Arad and Khouribga PRs. From the DM yields, fertilizer substitution values were calculated: fertilizer substitution value was the ratio of total P applied as superphosphate to total P as PAPR required to produce the same DM yield.Rates of dissolution of the PR component of PAPRs were also determined in soils collected from two trials.Agronomic results demonstrated that 30% acidulated phosphoric PAPRs (about 50% of total P as water-soluble P) were as effective as TSP, when the PR acidulated was from unground North Carolina PR. Results from one field trial indicated that when PAPR was from ground North Carolina PR, 20% acidulated product (water-soluble P 30–40% of total P) was equally effective as TSP. Replacement of ground North Carolina PR by a less reactive Khouribga PR did not appear to decrease the yield. Results indicated that per unit P released into soil solution, PAPRs were more efficient fertilizers than TSP. With annual applications, fertilizer substitution value of PAPR 30% tended to increase with time.Sulphuric PAPRs prepared from North Carolina PR were generally inferior to phosphoric PAPRs containing similar amounts of water-soluble P. This was attributed to the presence of CaSO₄ coatings.Abbreviations DM Dry matter - PAPR Partially acidulated phosphate rock - PR Phosphate rock - SSP Single superphosphate - TSP Triple superphosphate     

Greenhouse evaluation of phosphorus availability from compacted phosphate rocks with urea or with urea and triple superphosphate

The possible effect of urea hydrolysis on the availability of phosphorus (P) from phosphate rock (PR) was evaluated in two greenhouse experiments with maize, using two sources of PR — Pesca (Colombia) and Bayovar (Peru) — representing low and high chemical reactivity, respectively.In Experiment I, on a neutral Josephine silty clay loam (pH 6.2) (Typic Haplozerult), Bayovar PR compacted with urea (Bayovar PR + urea) performed better than Bayovar PR compacted with NH₄Cl (Bayovar PR + NH₄Cl) in increasing dry-matter yield at a rate of 100 mg P kg^–1 but not at rates of 50 and 200 mg P kg^–1. It was also found that the dry-matter yield obtained with compacted Bayovar PR products was significantly higher when the N ratios of urea: NH₄Cl were 1:1 or higher than when the ratios were below 1:1. Although Bray I–P can overestimate available P from PR with respect to that from TSP, a good relationship was observed between Bray I–P and dry-matter yield from various compacted Bayover PR products with a small particle size (–0.43 + 0.15 mm).In Experiment II an acid Bladen sandy loam (pH 4.5) (Typic Albaquult) was used. Finely ground Bayovar PR (– 0.07 mm) was about 66% as effective as TSP in increasing dry-matter yield, whereas Pesca PR was ineffective. When Pesca PR was partially acidulated with H₃PO₄ at 20% level (PAPR), it became 70% as effective as TSP. Granulated PAPR and Pesca PR compacted with TSP (Pesca PR + TSP) were found to be equally effective in increasing dry-matter yield when both products had the same particle size and the same water-soluble and citrate-soluble P as percent of total P, and when prilled urea was used as the N source. However, when urea was compacted with Pesca PR and TSP, the product's effectiveness was further increased by 30% and to the same level as TSP.In summary, the results tend to support the suggestion that urea hydrolysis can be beneficial in increasing the availability of P from PR to plants in soils having medium to high organic matter contents.     

Long-term greenhouse evaluation of partially acidulated phosphate rock fertilizers

The agronomic effectiveness (yield and P uptake) of twelve granular, partially acidulated phosphate rock fertilizers (PAPR) and two finely ground, unacidulated phosphate rocks (PR) were compared to that of a single superphosphate in a long-term greenhouse experiment with lucerne (Medicago sativa L., cv. CUF101), grown in a low P sorbing, moderately acid, sandy loam soil of moderate P status (Paleustaf). The PAPRs were prepared from two unreactive PRs (Christmas Is. A grade and Duchess rock from Queensland) and acidulated at two rates (25% and 50% on a H₂SO₄ to single superphosphate basis) with either H₂SO₄ or H₃PO₄. Additional products included H₂SO₄ PAPRs cogranulated with elemental S (10% w/w).Superphosphate was consistently superior to all PRs and PAPRs in agronomic effectiveness throughout this two-year study. The most effective of the PAPRs were those that were 50% acidulated with H₂SO₄ and cogranulated with elemental S; this type of fertilizer from both rocks was approximately 2/3 as effective as superphosphate when relative agronomic effectiveness indices (RAE) were calculated from cumulative yields. The increase in agronomic effectiveness relative to superphosphate (RAE value) by the partial acidulation of the PR could be attributed to its effect of increasing the P solubility in the PAPR. A curvilinear relationship existed between the RAE values of PRs and PAPRs, measured from cumulative yield or P uptake data, and the percentage of the total P in each fertilizer that was in a soluble (water + citrate soluble) form. Cogranulation with elemental S (10% w/w) significantly displaced this relationship upwards by increasing the RAE of H₂SO₄ PAPRs by more than 50%. The maximum cumulative recovery of applied P by lucerne tops after five bulked harvests (fifteen consecutive harvests) was 61.5%, which occurred at the low application rate of superphosphate. The decline in the substitution value of PRs for superphosphate, that occurred with increasing P rates tended to be offset both by increasing the level of acidulation and by cogranulating the PAPR with elemental S.     

Partial acidulation of an ‘unground’ phosphate rock: II. Plant availability of phosphate

Four greenhouse experiments were conducted using three soils to determine the availability to plants of P from unground North Carolina phosphate rock (PR) treated with 20% to 50% of the H₃PO₄ required for complete acidulation. The influences of soil P retention, P status, the method of preparation of partially acidulated phosphate rocks (PAPRs) and the granule size of the products were investigated. Perennial ryegrass was grown as the test plant for up to 8 months. Triple superphosphate (TSP) was used as the standard fertilizer and unground North Carolina rock was included for comparison.The dry matter yield and P uptake response curves showed that in all experiments PAPRs were markedly superior to the PR. P status of soils appeared to influence the effectiveness of PAPRs to a greater extent than P retention. In soils of low P status the degree of acidulation required for PAPR to be nearly or as effective as TSP was 50% whereas in a soil of high P status even 30% PAPR applied as a maintenance fertilizer was effective. There was a significant positive correlation between water soluble P of fertilizers and P uptake by ryegrass. However, in general PAPRs were more effective per unit of water soluble P than TSP. Granule size (< 1 mm and 1–2 mm) and method of preparation of PAPRs did not alter the effectiveness of PAPRs.