Comparison of electrolyzed oxidizing water with other antimicrobial interventions to reduce pathogens on fresh pork

To date, the effectiveness of electrolyzed oxidizing (EO) water against bacteria associated with fresh pork has not been determined. Using a hand-held, food-grade garden sprayer, distilled water (W), chlorinated water (CL; 25 ppm), 2% lactic acid (LA), acidic EO water (EOA), or "aged" acidic EO water (AEOA; stored at 4 °C for 24 h) was sprayed (15 s) onto pork bellies inoculated with feces containing Listeria monocytogenes (LM), Salmonella typhimurium (ST), and Campylobacter coli (CC). Remaining bacterial populations were determined immediately following treatment, after 2 days of aerobic storage, and again after 5 days of vacuum-packaged, refrigerated storage (day 7). While LA and EOA significantly reduced (p<0.05) populations of CC at days 0 and 7, there was no significant difference (p>0.05) between antimicrobial treatments when applied to pork inoculated with ST or LM. This study demonstrates that a 15-s spray with EOA has the ability to reduce CC associated with fresh pork surfaces. However, longer contact times may be necessary to reduce other microbial contaminants.     

Efficacy of electrolyzed water in inactivating Salmonella enteritidis and Listeria monocytogenes on shell eggs

The efficacy of acidic electrolyzed (EO) water produced at three levels of total available chlorine (16, 41, and 77 mg/ liter) and chlorinated water with 45 and 200 mg/liter of residual chlorine was investigated for inactivating Salmonella Enteritidis and Listeria monocytogenes on shell eggs. An increasing reduction in Listeria population was observed with increasing chlorine concentration from 16 to 77 mg/liter and treatment time from 1 to 5 min, resulting in a maximal reduction of 3.70 log CFU per shell egg compared with a deionized water wash for 5 min. There was no significant difference in antibacterial activities against Salmonella and Listeria at the same treatment time between 45 mg/liter of chlorinated water and 14-A acidic EO water treatment (P > or = 0.05). Chlorinated water (200 mg/liter) wash for 3 and 5 min was the most effective treatment; it reduced mean populations of Listeria and Salmonella on inoculated eggs by 4.89 and 3.83 log CFU/shell egg, respectively. However, reductions (log CFU/shell egg) of Listeria (4.39) and Salmonella (3.66) by 1-min alkaline EO water treatment followed by another 1 min of 14-A acidic EO water (41 mg/liter chlorine) treatment had a similar reduction to the 1-min 200 mg/liter chlorinated water treatment for Listeria (4.01) and Salmonella (3.81). This study demonstrated that a combination of alkaline and acidic EO water wash is equivalent to 200 mg/liter of chlorinated water wash for reducing populations of Salmonella Enteritidis and L. monocytogenes on shell eggs.     

Pathogen Reduction and Quality of Lettuce Treated with Electrolyzed Oxidizing and Acidified Chlorinated Water

ABSTRACT: The efficacy of electrolyzed oxidizing (EO) and acidified chlorinated water (45 ppm residual chlorine) was evaluated in killing Escherichia coli O157:H7 and Listeria monocytogenes on lettuce. After surface inoculation, each leaf was immersed in 1.5 L of EO or acidified chlorinated water for 1 or 3 min at 22 °C. Compared to a water wash only, the EO water washes significantly decreased mean populations of E. coli O157:H7 and L. monocytogenes by 2.41 and 2.65 log10 CFU per lettuce leaf for 3 min treatments, respectively (p < 0.05). However, the difference between the bactericidal activity of EO and acidified chlorinated waters was not significant (p > 0.05). Change in the quality of lettuce subjected to the different wash treatments was not significant at the end of 2 wk of storage.     

Enhancing the bactericidal effect of electrolyzed water on Listeria monocytogenes biofilms formed on stainless steel

Biofilms are potential sources of contamination to food in processing plants, because they frequently survive sanitizer treatments during cleaning. The objective of this research was to investigate the combined use of alkaline and acidic electrolyzed (EO) water in the inactivation of Listeria monocytogenes biofilms on stainless steel surfaces. Biofilms were grown on rectangular stainless steel (type 304, no. 4 finish) coupons (2 by 5 cm) in a 1:10 dilution of tryptic soy broth that contained a five-strain mixture of L. monocytogenes for 48 h at 25 degrees C. The coupons with biofilms were then treated with acidic EO water or alkaline EO water or with alkaline EO water followed by acidic EO water produced at 14 and 20 A for 30, 60, and 120 s. Alkaline EO water alone did not produce significant reductions in L. monocytogenes biofilms when compared with the control. Treatment with acidic EO water only for 30 to 120 s, on the other hand, reduced the viable bacterial populations in the biofilms by 4.3 to 5.2 log CFU per coupon, whereas the combined treatment of alkaline EO water followed by acidic EO water produced an additional 0.3- to 1.2-log CFU per coupon reduction. The population of L. monocytogenes reduced by treatments with acidic EO water increased significantly with increasing time of exposure. However, no significant differences occurred between treatments with EO water produced at 14 and 20 A. Results suggest that alkaline and acidic EO water can be used together to achieve a better inactivation of biofilms than when applied individually.     

Efficacy of electrolyzed oxidizing water in inactivating Salmonella on alfalfa seeds and sprouts

Studies have demonstrated that electrolyzed oxidizing (EO) water is effective in reducing foodborne pathogens on fresh produce. This study was undertaken to determine the efficacy of EO water and two different forms of chlorinated water (chlorine water from Cl2 and Ca(OCl)2 as sources of chlorine) in inactivating Salmonella on alfalfa seeds and sprouts. Tengram sets of alfalfa seeds inoculated with a five-strain cocktail of Salmonella (6.3 x 10(4) CFU/g) were subjected to 90 ml of deionized water (control), EO water (84 mg/liter of active chlorine), chlorine water (84 mg/liter of active chlorine), and Ca(OCl)2 solutions at 90 and 20,000 mg/liter of active chlorine for 10 min at 24 +/- 2 degrees C. The application of EO water, chlorinated water, and 90 mg/liter of Ca(OCl)2 to alfalfa seeds for 10 min reduced initial populations of Salmonella by at least 1.5 log10 CFU/g. For seed sprouting, alfalfa seeds were soaked in the different treatment solutions described above for 3 h. Ca(OCl)2 (20,000 mg/liter of active chlorine) was the most effective treatment in reducing the populations of Salmonella and non-Salmonella microflora (4.6 and 7.0 log10 CFU/g, respectively). However, the use of high concentrations of chlorine generates worker safety concerns. Also, the Ca(OCl)2 treatment significantly reduced seed germination rates (70% versus 90 to 96%). For alfalfa sprouts, higher bacterial populations were recovered from treated sprouts containing seed coats than from sprouts with seed coats removed. The effectiveness of EO water improved when soaking treatments were applied to sprouts in conjunction with sonication and seed coat removal. The combined treatment achieved 2.3- and 1.5-log10 CFU/g greater reductions than EO water alone in populations of Salmonella and non-Salmonella microflora, respectively. This combination treatment resulted in a 3.3-log10 CFU/g greater reduction in Salmonella populations than the control (deionized water) treatment.     

Effectiveness of radiation processing in elimination of Salmonella typhimurium and Listeria monocytogenes from sprouts

The effectiveness of radiation treatment in eliminating Salmonella Typhimurium and Listeria monocytogenes on laboratory inoculated ready-to-eat sprouts was studied. Decimal reduction doses (D10-values) for Salmonella Typhimurium and L. monocytogenes in dry seeds of mung (green gram), matki (dew gram), chana (chick pea), and vatana (garden pea) ranged from 0.189 to 0.303 kGy and 0.294 to 0.344 kGy, respectively. In sprouts made from these seeds, the D10-values ranged from 0.192 to 0.208 kGy for Salmonella Typhimurium and from 0.526 to 0.588 kGy for L. monocytogenes. Radiation treatment with a 2-kGy dose resulted in complete elimination of 10(4) CFU/g of Salmonella Typhimurium and 10(3) CFU/g of L. monocytogenes from all the four varieties of sprouts. No recovery of Salmonella Typhimurium and L. monocytogenes was observed in the radiation treated samples stored at 4 and 8 degrees C up to 12 days. Radiation treatment with 1 kGy and 2 kGy resulted in a reduction of aerobic plate counts and coliform counts by 2 and 4 log CFU/g, respectively; the yeast and mold counts and staphylococci counts decreased by 1 and 2 log CFU/g, respectively. However, during postirradiation storage at 4 and 8 degrees C, aerobic plate counts, coliform counts, yeast and mold counts, and staphylococci counts remained constant throughout the incubation period. This study demonstrates that a 2-kGy dose of irradiation could be an effective method of processing to ensure microbial safety of sprouts.     

Effects of slightly acidic low concentration electrolyzed water on microbiological, physicochemical, and sensory quality of fresh chicken breast meat

Anticmicrobial effect of slightly acidic low concentration electrolyzed water (SlALcEW) and strong acidic electrolyzed water (StAEW) on fresh chicken breast meat was evaluated in this study. Meat samples each of 10 ± 0.2 g in weight and 2.5 × 2.5 cm2 in size were experimentally inoculated with Listeria monocytogenes (ATCC 19115) and Salmonella Typhimurium (ATCC 14028) and subjected to dipping treatment (22 ± 2 °C for 10 min) with SlALcEW and StAEW. Shelf-life study was conducted for inoculated and noninoculated meat samples treated with SlALcEW and StAEW at storage temperatures of 5, 15, and 25 °C. Dipping treatment with electrolyzed water significantly (P < 0.05) reduced the background and inoculated pathogens compared to untreated controls. The reduction of 1.5 to 2.3 log CFU/g was achieved by SlALcEW and StAEW against background flora, L. monocytogenes and Salmonella Typhimurium. There was no significant difference (P > 0.05) between the SlALcEW and StAEW treatments efficacy. Comparing treated samples to untreated controls showed that SlALcEW and StAEW treatments extended the shelf life of chicken meat at different temperatures with marginal changes of sensory quality. Although SlALcEW and StAEW treatments showed similar antimicrobial effects but SlALcEW was more beneficial in practical application for its semineutral pH and low chlorine content. PRACTICAL APPLICATION: Food safety issues have led to development of new sanitizers to eliminate spoilage and pathogenic organisms in food. This study provides the foundation for further application of slightly acidic low concentration electrolyzed water (SlALcEW) as a sanitizing agent in meat industry. SlALcEW can be produced on site on demand and no chemicals are necessary except NaCl solution. It does not leave any residue in food due to low chlorine concentration and it is safe to handle for its semineutral pH.     

Effect of sanitizer treatments on Salmonella Stanley attached to the surface of cantaloupe and cell transfer to fresh-cut tissues during cutting practices

The ability of Salmonella Stanley to attach and survive on cantaloupe surfaces, its in vivo response to chlorine or hydrogen peroxide treatments, and subsequent transfer to the interior tissue during cutting was investigated. Cantaloupes were immersed in an inoculum containing Salmonella Stanley (10(8) CFU/ml) for 10 min and then stored at 4 or 20 degrees C for up to 5 days. Periodically, the inoculated melons were washed with chlorine (1,000 ppm) or hydrogen peroxide (5%), and fresh-cut tissues were prepared. The incidence of Salmonella Stanley transfer from the rinds to the fresh-cut tissues during cutting practices was determined. A population of 3.8 log10 CFU/cm2 of Salmonella Stanley was recovered from the inoculated rinds. No significant (P < 0.05) reduction of the attached Salmonella population was observed on cantaloupe surfaces stored at 4 or 20 degrees C for up to 5 days, and the population was not reduced after washing with water. Salmonella Stanley was recovered in fresh-cut pieces prepared from inoculated whole cantaloupes with no sanitizer treatment. Washing with chlorine or hydrogen peroxide solutions was most effective immediately after inoculation, resulting in an approximate 3.0-log10 CFU/cm2 reduction, and the level of recovered Salmonella population transferred to fresh-cut samples was reduced to below detection. The effectiveness of both treatments diminished when inoculated cantaloupes stored at 4 or 20 degrees C for more than 3 days were analyzed, and the fresh-cut pieces prepared from such melons were Salmonella positive. Salmonella outgrowth occurred on inoculated fresh-cut cubes stored above 4 degrees C.     

Antimicrobial effect of herb extracts against Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella typhimurium associated with beef

The effects of plant extracts against pathogenic bacteria in vitro are well known, yet few studies have addressed the effects of these compounds against pathogens associated with muscle foods. A series of experiments was conducted to determine the effectiveness of a commercially available, generally recognized as safe, herb extract dispersed in sodium citrate (Protecta One) or sodium chloride (Protecta Two) against Escherichia coli O157:H7, Salmonella typhimurium, and Listeria monocytogenes associated with beef. In the first experiment, E. coli O157:H7, Salmonella typhimurium, and L. monocytogenes inoculated onto beef and subjected to surface spray treatments with 2.5% solutions of Protecta One or Protecta Two were not affected by immediate application (day 0) of the herbal extracts. However, after 7 days of storage at 4 degrees C, E. coli O157:H7 was reduced by >1.3 log10 CFU/cm2 by Protecta Two; L. monocytogenes was reduced by 1.8 and 1.9 log10 CFU/cm2 by Protecta One and Protecta Two, respectively; Salmonella typhimurium was not reduced >0.3 log10 CFU/cm2 by either extract by day 7. In the second experiment, 2.5% Protecta Two (wt/vol or wt/wt) added to inoculated lean and adipose beef trim, processed, and packaged as ground beef chubs (80% lean, 20% adipose), did not reduce pathogen populations >0.5 log10 CFU/g up to 14 days at 4 degrees C. In the third experiment, surface spray treatments of beef with 2.5% lactic acid or 2.5% solutions of Protecta One or Protecta Two, vacuum packaged, and stored up to 35 days at 4 degrees C did reduce E. coli O157:H7, L. monocytogenes, and Salmonella Typhimurium slightly. These studies suggest that the use of herb extracts may afford some reductions of pathogens on beef surfaces; however, the antimicrobial activity may be diminished in ground beef by adipose components.     

Internalization of bacterial pathogens in tomatoes and their control by selected chemicals

The effect of different washing or sanitizing agents was compared for preventing or reducing surface and internal contamination of tomatoes by Salmonella Typhimurium and Escherichia coli O157:H7. The tomatoes were inoculated by dipping them in a bacterial suspension containing approximately 6.0 log CFU/ml of each pathogen and then rinsing them with tap water, hypochlorite solution (250 mg/liter), or lactic acid solution (2%, wt/vol). All treatments were applied by dipping or spraying, and solutions were applied at 5, 25, 35, and 55 degrees C. With the exception of the lactic acid dip at 5 degrees C, all treatments reduced both pathogens on the surfaces of the tomatoes by at least 2.9 cycles. No significantly different results were obtained (P > 0.05) with the dipping and spraying techniques. For internalized pathogens, the mean counts for tomatoes treated with water alone or with chlorine ranged from 0.8 to 2.1 log CFU/g. In contrast, after lactic acid spray treatment, all core samples of tomatoes tested negative for Salmonella Typhimurium and, except for one sample with a low but detectable count, all samples tested negative for E. coli O157:H7 with a plate count method. When the absence of pathogens was verified by an enrichment method, Salmonella was not recovered from any samples, whereas two of four samples tested positive for E. coli O157:H7 even though the counts were negative. Few cells of internalized pathogens were able to survive in the center of the tomato during storage at room temperature (25 to 28 degrees C). The average superficial pH of tomatoes treated with tap water, chlorine, or lactic acid was 4.9 to 5.2, 4.1 to 4.3, and 2.5, respectively (P < 0.05), whereas no differences were observed in the internal pH (3.6 to 3.7) of the tomatoes treated with different sanitizers. The general practice in the tomato industry is to wash the tomatoes in chlorinated water. However, chlorine is rapidly degraded by organic matter usually present in produce. Therefore, lactic acid sprays may be a more effective alternative for decontaminating tomato surfaces. The use of warm (55 degrees C) sprays could reduce pathogen internalization during washing.     

Fate of Escherichia coli O157:H7, Salmonella typhimurium DT 104, and Listeria monocytogenes in fresh meat decontamination fluids at 4 and 10 degrees C.

Bacterial pathogens may colonize meat plants and increase food safety risks following survival, stress hardening, or proliferation in meat decontamination fluids (washings). The objective of this study was to evaluate the ability of Escherichia coli O157:H7, Salmonella Typhimurium DT 104, and Listeria monocytogenes to survive or grow in spray-washing fluids from fresh beef top rounds sprayed with water (10 or 85 degrees C) or acid solutions (2% lactic or acetic acid, 55 degrees C) during storage of the washings at 4 or 10 degrees C in air to simulate plant conditions. Inoculated Salmonella Typhimurium DT 104 (5.4 +/- 0.1 log CFU/ml) died off in lactate (pH 2.4 +/- 0.1) and acetate (pH 3.1 +/- 0.2) washings by 2 days at either storage temperature. In contrast, inoculated E. coli O157:H7 (5.2 +/- 0.1 log CFU/ml) and L. monocytogenes (5.4 +/- 0.1 log CFU/ml) survived in lactate washings for at least 2 days and in acetate washings for at least 7 and 4 days, respectively; their survival was better in acidic washings stored at 4 degrees C than at 10 degrees C. All inoculated pathogens survived in nonacid (pH > 6.0) washings, but their fate was different. E. coli O157:H7 did not grow at either temperature in water washings, whereas Salmonella Typhimurium DT 104 failed to multiply at 4 degrees C but increased by approximately 2 logs at 10 degrees C. L. monocytogenes multiplied (0.6 to 1.3 logs) at both temperatures in water washings. These results indicated that bacterial pathogens may survive for several days in acidic, and proliferate in water, washings of meat, serving as potential cross-contamination sources, if pathogen niches are established in the plant. The responses of surviving pathogens in meat decontamination waste fluids to acid or other stresses need to be addressed to better evaluate potential food safety risks.     

Effect of single or sequential hot water and lactic acid decontamination treatments on the survival and growth of listeria monocytogenes and spoilage microflora during aerobic storage of fresh beef at 4, 10, and 25 degrees C

The survival and growth of Listeria monocytogenes and spoilage microflora during storage of fresh beef subjected to different decontamination treatments was studied. Fresh beef inoculated with a five-strain mixture of L. monocytogenes (5.18 log CFU/cm2) was left untreated (control) or was immersed (30 s) in hot water (HW; 75 degrees C), 2% lactic acid (LA; 55 degrees C), hot water followed by lactic acid (HW-LA), or lactic acid followed by hot water (LA-HW) and then stored aerobically at 4, 10, and 25 degrees C for 25, 17, and 5 days, respectively. Initial populations of L. monocytogenes were reduced by 0.82 (HW), 1.43 (LA), 2.73 (HW-LA), and 2.68 (LA-HW) log CFU/cm2. During storage, the pathogen grew at higher rates in HW than in control samples at all storage temperatures. Acid decontamination treatments (LA. HW-LA, and LA-HW) resulted in a weaker inhibition of L. monocytogenes (P < 0.05) at 25 degrees C than at 4 and 10 degrees C. In general, the order of effectiveness of treatments was HW-LA > LA > LA-HW > HW > control at all storage temperatures tested. In untreated samples, the spoilage microflora was dominated by pseudomonads, while lactic acid bacteria, Enterobacteriaceae, and yeasts remained at lower concentrations during storage. Brochothrix thermosphacta was detected periodically in only a limited number of samples. Although decontamination with HW did not affect the above spoilage microbial profile, acid treatments shifted the predominant microflora in the direction of yeasts and gram-positive bacteria (lactic acid bacteria). Overall, the results of the present study indicate that decontamination with LA and combinations of LA and HW could limit growth of L. monocytogenes and inhibit pseudomonads, which are the main spoilage bacteria of fresh beef stored under aerobic conditions. However, to optimize the efficacy of such treatments, they must be applied in the appropriate sequence and followed by effective temperature control.     

Heat shock and cold shock treatments affect the survival of Listeria monocytogenes and Salmonella Typhimurium exposed to disinfectants

The foodborne pathogens Listeria monocytogenes and Salmonella Typhimurium were subjected to heat shock at 48°C for 10 and 30 min, respectively, and then cold shocked at 15°C for 3 h. The effect of these shocks on the viability of test organisms exposed to chlorine dioxide and quaternary ammonium compounds was then determined. After exposure to the disinfectants, the viable population of each test organism, regardless of heat shock or cold shock treatment, decreased as the exposure period was extended. Both heat shock and cold shock treatments reduced the susceptibility of L. monocytogenes to both disinfectants at 25°C. However, for Salmonella Typhimurium, exposure to the chlorine dioxide disinfectant or quaternary ammonium compounds at 25°C significantly reduced (P < 0.05) survival of heat-shocked cells but significantly increased (P < 0.05) survival of cold-shocked cells compared with control cells. Survival of both L. monocytogenes and Salmonella Typhimurium generally was reduced after exposure to disinfectants at 40°C compared with 25°C.     

Viability of Salmonella and Listeria monocytogenes in delicatessen salads and hummus as affected by sodium content and storage temperature

A study was conducted to determine survival and growth behavior of Salmonella and Listeria monocytogenes in commercially prepared mayonnaise-based potato salad, macaroni salad, and coleslaw and in hummus (initial mean pH values were 4.80 to 4.94, 4.18 to 4.31, 3.87, and 4.50 to 4.52, respectively) as affected by sodium concentration (133 to 364, 190 to 336, 146 to 272, and 264 to 728 mg/100 g, respectively) and storage at 4 or 10°C for up to 27 days. Salmonella did not grow in any of the test products. Initial populations (2.02 to 2.38 log CFU/g) decreased in coleslaw to undetectable levels (<1 CFU/25 g) within 13 days and in most formulations of macaroni salad within 20 to 27 days. Salmonella survived in highest numbers in potato salad and hummus. The presence of added sodium in macaroni salad stored at 4°C and hummus stored at 4 or 10°C appeared to protect Salmonella against inactivation. L. monocytogenes, at an initial population of 1.86 to 2.23 log CFU/g, did not grow in test products, but with the exception of coleslaw containing sodium at a concentration used in the standard (control) recipe, this pathogen was detected by direct plating (≥ 1.0 log CFU/g) in all products stored at 4 or 10°C for 27 days. L. monocytogenes populations were significantly (P < 0.05) lower in potato salad and hummus with no added sodium than in test products with added sodium after storage at 4°C. Sodium concentration did not markedly affect aerobic plate counts over the 27-day storage period. Results confirm that the acidic pH of mayonnaise-based salads and hummus is a major factor preventing growth and influencing rates of inactivation of Salmonella and L. monocytogenes. In the absence of added sodium, death of these bacteria may be more rapid. However, in general decreasing or increasing the sodium concentration in selected delicatessen salad and hummus recipes does not markedly affect the behavior of Salmonella and L. monocytogenes when products are stored at 4 or 10°C for up to 27 days.     

Survival and growth of Listeria monocytogenes and Escherichia coli O157:H7 in ready-to-eat iceberg lettuce washed in warm chlorinated water

Cut iceberg lettuce inoculated with Escherichia coli O157:H7 and Listeria monocytogenes before and after washing for 3 min in cold (4 degrees C) and warm (47 degrees C) water containing 100 mg/liter total chlorine was stored at I and 10 degrees C in oxygen-permeable film packages (6,000 to 8,000 cc/m2/24 h). Cold chlorinated water was detrimental to the survival of E. coli O157: H7 and L. monocytogenes at both storage temperatures. In contrast, washing in warm chlorinated water favored the growth of both pathogens in lettuce stored at 10 degrees C. There was no evidence of a relationship between the magnitude of spoilage microflora and the fate of either bacterium.     

Reduction of bacteria on spinach, lettuce, and surfaces in food service areas using neutral electrolyzed oxidizing water

Food safety issues and increases in food borne illnesses have promulgated the development of new sanitation methods to eliminate pathogenic organisms on foods and surfaces in food service areas. Electrolyzed oxidizing water (EO water) shows promise as an environmentally friendly broad spectrum microbial decontamination agent. EO water is generated by the passage of a dilute salt solution ( approximately 1% NaCl) through an electrochemical cell. This electrolytic process converts chloride ions and water molecules into chlorine oxidants (Cl(2), HOCl/ClO(-)). At a near-neutral pH (pH 6.3-6.5), the predominant chemical species is the highly biocidal hypochlorous acid species (HOCl) with the oxidation reduction potential (ORP) of the solution ranging from 800 to 900mV. The biocidal activity of near-neutral EO water was evaluated at 25 degrees C using pure cultures of Escherichia coli, Salmonella typhimurium, Staphylococcus aureus, Listeria monocytogenes, and Enterococcus faecalis. Treatment of these organisms, in pure culture, with EO water at concentrations of 20, 50, 100, and 120ppm total residual chlorine (TRC) and 10min of contact time resulted in 100% inactivation of all five organisms (reduction of 6.1-6.7log(10)CFU/mL). Spray treatment of surfaces in food service areas with EO water containing 278-310ppm TRC (pH 6.38) resulted in a 79-100% reduction of microbial growth. Dip (10min) treatment of spinach at 100 and 120ppm TRC resulted in a 4.0-5.0log(10)CFU/mL reduction of bacterial counts for all organisms tested. Dipping (10min) of lettuce at 100 and 120ppm TRC reduced bacterial counts of E. coli by 0.24-0.25log(10)CFU/mL and reduced all other organisms by 2.43-3.81log(10)CFU/mL.     

Survival and recovery of Escherichia coli O157:H7, Salmonella, and Listeria monocytogenes on lettuce and parsley as affected by method of inoculation, time between inoculation and analysis, and treatment with chlorinated water

The effects of method for applying inoculum and of drying time after inoculation on survival and recovery of foodborne pathogens on iceberg lettuce and parsley were studied. Five-strain mixtures of Escherichia coli O157:H7, Salmonella, or Listeria monocytogenes were applied to lettuce and parsley by dip, spot, or spray inoculation methods. Inocula were dried for 2 h at 22 degrees C or for 2 h at 22 degrees C and then 22 h at 4 degrees C before being treated with water (control) or chlorine (200 microg/ml). Significantly higher populations (CFU per lettuce or parsley sample) of E. coli O157:H7 and Salmonella (alpha = 0.05) were recovered from dip-inoculated produce than from spot- or spray-inoculated produce. This difference was attributed to larger numbers of cells adhering to lettuce and parsley subjected to dip inoculation. Populations of E. coli O157:H7 and Salmonella recovered from lettuce inoculated by spot and spray methods were not significantly different, but populations recovered from spot-inoculated parsley were significantly higher than those recovered from spray-inoculated parsley, even though the number of cells applied was the same. Significantly different numbers of L. monocytogenes were recovered from inoculated lettuce (dip > spray > spot); populations recovered from dip-inoculated parsley were significantly higher than those recovered from spot- or spray-inoculated parsley, which were not significantly different from each other. Populations of pathogens recovered from lettuce and parsley after drying inoculum for 2 h at 22 degrees C were significantly higher than or equal to populations recovered after drying for 2 h at 22 degrees C and then for 22 h at 4 degrees C. Significant differences (water > chlorine) were observed in populations of all pathogens recovered from treated lettuce and parsley, regardless of inoculation method and drying time. It is recommended that spot inoculation with a drying time of 2 h at 22 degrees C followed by 22 h at 4 degrees C be used to determine the efficacy of chlorine and other sanitizers in killing foodborne pathogens on lettuce and parsley.     

Development of a proposed standard method for assessing the efficacy of fresh produce sanitizers

A series of studies was done for the purpose of developing a proposed standard method to evaluate point-of-use home sanitizers for fresh produce. Preliminary experiments were done to determine the survival of Escherichia coli O157:H7, Salmonella, and Listeria monocytogenes after inoculation onto the surface of ripe tomatoes and drying for up to 24 h at 22 +/- 2 degrees C. Within 2 h, the initial population (6.88 log10 CFU/tomato) of E. coli O157:H7 was reduced by approximately 3 log10, while reductions in similar initial populations of Salmonella and L. monocytogenes were approximately 1 and 0.6 log10 CFU/tomato, respectively, after 40 min and 3 h. A pilot study evaluated treatment with 200 ppm free chlorine and a prototype Fit produce wash (Fit) for their efficacy in killing a five-serotype mixture of Salmonella or L. monocytogenes spot inoculated on tomatoes using the proposed inoculation and recovery procedures. Inoculated tomatoes were sprayed with chlorinated water, Fit, or sterile distilled water (control) and hand rubbed for 30 s. Each tomato was then placed in a plastic bag and rinsed with 200 ml of sterile water by vigorously agitating for 30 s to simulate a procedure consumers might use for sanitizing and rinsing produce in a home setting. Each tomato was transferred to a second bag, and 20 ml of sterile 0.1% peptone was added; tomatoes were rubbed by hand for 40 s. Populations of Salmonella or L. monocytogenes in the rinse water and the 0.1% peptone wash solution were determined. Treatment with 200 ppm chlorine and Fit resulted in > or = 3.07 and > 6.83 log10 reductions, respectively, in Salmonella. Treatment with 200 ppm chlorine and Fit reduced the number of L. monocytogenes by > or = 3.33 and > or = 4.96 log10 CFU/tomato, respectively. The proposed standard method for testing the efficacy of point-of-use produce sanitizers needs to be evaluated for reproducibility of results through a larger scale series of experiments.     

Antimicrobial effect of electrolyzed water for inactivating Campylobacter jejuni during poultry washing

The effectiveness of electrolyzed (EO) water for killing Campylobacter jejuni on poultry was evaluated. Complete inactivation of C. jejuni in pure culture occurred within 10 s after exposure to EO or chlorinated water, both of which contained 50 mg/l of residual chlorine. A strong bactericidal activity was also observed on the diluted EO water (containing 25 mg/l of residual chlorine) and the mean population of C. jejuni was reduced to less than 10 CFU/ml (detected only by enrichment for 48 h) after 10-s treatment. The diluted chlorine water (25 mg/l residual chlorine) was less effective than the diluted EO water for inactivation of C. jejuni. EO water was further evaluated for its effectiveness in reducing C. jejuni on chicken during washing. EO water treatment was equally effective as chlorinated water and both achieved reduction of C. jejuni by about 3 log10 CFU/g on chicken, whereas deionized water (control) treatment resulted in only 1 log10 CFU/g reduction. No viable cells of C. jejuni were recovered in EO and chlorinated water after washing treatment, whereas high populations of C. jejuni (4 log10 CFU/ml) were recovered in the wash solution after the control treatment. Our study demonstrated that EO water was very effective not only in reducing the populations of C. jejuni on chicken, but also could prevent cross-contamination of processing environments.     

Viability of Salmonella,Escherichia coli O157:H7, and Listeria monocytogenes in yellow fat spreads as affected by storage temperature

A study was conducted to characterize the survival and inactivation kinetics of a five-serotype mixture of Salmonella (6.23 to 6.55 log10 CFU per 3.5-ml or 4-g sample), a five-strain mixture of Escherichia coli O157:H7 (5.36 to 6.14 log10 CFU per 3.5-ml or 4-g sample), and a six-strain mixture of Listeria monocytogenes (5.91 to 6.18 log10 CFU per 3.5-ml or 4-g sample) inoculated into seven yellow fat spreads (one margarine, one butter-margarine blend, and five dairy and nondairy spreads and toppings) after formulation and processing and stored at 4.4, 10, and 21 degrees C for up to 94 days. Neither Salmonella nor E. coil O157:H7 grew in any of the test products. The time required for the elimination of each pathogen depended on the product and the storage temperature. Death was more rapid at 21 degrees C than at 4.4 or 10 degrees C. Depending on the product, the time required for the elimination of viable cells at 21 degrees C ranged from 5 to 7 days to >94 days for Salmonella, from 3 to 5 days to 28 to 42 days for E. coli O157:H7, and from 10 to 14 days to >94 days for L. monocytogenes. Death was most rapid in a water-continuous spray product (pH 3.66, 4.12% salt) and least rapid in a butter-margarine blend (pH 6.66, 1.88% salt). E. coli O157:H7 died more rapidly than did Salmonella or L. monocytogenes regardless of storage temperature. Salmonella survived longer in high-fat (> or = 61%) products than in products with lower fat contents. The inhibition of growth is attributed to factors such as acidic pH, salt content, the presence of preservatives, emulsion characteristics, and nutrient deprivation. L. monocytogenes did not grow in six of the test products, but its population increased between 42 and 63 days in a butter-margarine blend stored at 10 degrees C and between 3 and 7 days when the blend was stored at 21 degrees C. On the basis of the experimental parameters examined in this study, traditional margarine and spreads not containing butter are not "potentially hazardous foods" in that they do not support the growth of Salmonella, E. coli O157:H7, or L. monocytogenes.