Cu2+印迹交联壳聚糖微球的合成及吸附性能

利用分子印迹技术,以壳聚糖(CS)为功能单体,Cu~(2+)为印迹离子,通过稀氨水固化、环氧氯丙烷交联、盐酸洗脱Cu~(2+),制得了Cu~(2+)印迹交联壳聚糖微球(Cu~(2+)-ICM)。采用FTIR、XRD和FESEM对产品进行了表征,并测定了微球的骨架密度、含水量和交联度。结果表明:交联改性可使微球具有多孔结构和良好的结构稳定性,能够很好地降低CS的酸溶性,提高微球对Cu~(2+)的吸附性能。通过正交实验L_9(3~4)得到Cu~(2+)-ICM的最优制备条件为:CS 1.5 g,环氧氯丙烷2.5 mL,80℃下交联3.0 h,制得的微球对Cu~(2+)吸附量为67.80 mg/g。在单组分体系中考察了微球对Cu~(2+)的吸附性能。结果表明:当微球投加量为50 mg,Cu~(2+)初始质量浓度为338.7 mg/L,pH=5.0时,吸附量为72.80 mg/g。     

壳聚糖/纤维素复合微球对Cu2+的吸附

制备壳聚糖/纤维素(CS/CE)和交联壳聚糖/纤维素(ECS/CE)复合微球,用于吸附重金属离子,考察了微球对Cu2+的吸附性能。溶解性测试表明交联反应可提高微球在酸性介质中的化学稳定性。静态吸附表明,CS/CE和ECS/CE均能有效吸附Cu2+,pH 6附近吸附容量最大。吸附等温线与Langmuir和Freundlich模型均吻合,由Lang-muir模型得到的Cu2+饱和吸附容量分别为38.76 mg/g(CS/CE)和34.13 mg/g(ECS/CE)。CS/CE和ECS/CE对Cu2+的吸附初期为内扩散控制,但后期为配合反应控制。FTIR和X-射线光电子能谱(XPS)分析表明,壳聚糖中的N为Cu2+的主要吸附位,发生表面配合吸附。     

交联壳聚糖多孔微球吸附亮绿的研究

利用液体石蜡作有机分散介质,戊二醛作交联剂,制备了交联壳聚糖多孔微球,采用SEM对壳聚糖微球的形貌、大小进行了表征,研究交联壳聚糖微球对亮绿的吸附性能,探讨交联壳聚糖多孔微球用量、亮绿初始浓度、pH值、吸附时间、吸附温度的影响.结果表明,室温下,交联壳聚糖微球粒径为0.5～1.0 mm,亮绿初始浓度10 mg·L-1,pH=6,振摇30 min时,吸附量达1.22 mg·g-1;CODCr去除率达73%.亮绿初始浓度越大,吸附量越大,吸附速率越大;吸附剂用量越大,平衡吸附量越小,吸附速率越大.交联壳聚糖微球对亮绿具有很高的吸附容量和较快的吸附速率,再生重复使用,其脱色率仍达90%以上.等温吸附较好符合Freundlich方程.     

交联壳聚糖微球树脂对Cu(Ⅱ)吸附性能研究

采用反相悬浮法,以戊二醛为交联剂,以环己烷为致孔剂制备交联壳聚糖微球树脂(CCMR);通过静态吸附试验研究树脂对Cu(Ⅱ)的吸附行为。利用金相显微镜和比表面积仪对交联壳聚糖微球树脂(CCMR)的表观形貌和比表面积进行表征;通过紫外可见光谱考察了Cu(Ⅱ)初始浓度对吸附性能影响,研究其吸附动力学。结果表明,随着致孔剂用量的增加,交联壳聚糖微球树脂比表面积增大,吸附性能增强,其中添加环己烷100 m L,乙酸乙酯5 m L制备交联壳聚糖微球树脂对浓度为8 mg/m L的Cu(Ⅱ)溶液的平衡吸附容量可达190 mg/g,吸附性能较好,吸附过程符合准二级吸附动力学模型。     

硫脲改性壳聚糖对水中Cr(Ⅵ)与Ni~(2+)的吸附性能研究

以壳聚糖和硫脲为原料,经环氧氯丙烷交联,制得硫脲改性壳聚糖颗粒,通过吸附实验考察了pH、吸附时间对Cr(Ⅵ)、Ni2+吸附的影响。结果表明,硫脲壳聚糖颗粒对Ni2+吸附的最佳pH为6,对Cr(Ⅵ)吸附的最佳pH为1,最佳吸附t为2h。利用准一级反应动力学模型和准二级反应动力学模型对实验数据进行拟合,并分别采用Freundlich模型、Langmuir模型对吸附等温线进行拟合。结果表明,吸附符合准二级动力学模型,以化学吸附为主。吸附等温线用Langmuir模型拟合结果最好。在初始质量浓度80mg/L,θ为25℃时,Ni2+,Cr(Ⅵ)的饱和吸附量可达40.98mg/g和33.33mg/g。     

表面修饰聚乙烯亚胺的壳聚糖微球对十二烷基苯磺酸钠的吸附特性

采用乳化交联法制备交联壳聚糖微球(CCS),在其表面接枝聚乙烯亚胺(PEI),得到系列具有不同离子交换容量(IEC)的PEI修饰交联壳聚糖微球(PEI-CCS),对其进行表征,考察了其对十二烷基苯磺酸钠(SDBS)的静态吸附特性. 结果表明,PEI-CCS平均粒径为85 mm,IEC最高达1275 mmol/g,远高于CCS的418 mmol/g. 酸性条件下,PEI-CCS的胺基质子化,带正电荷,能与溶液中的阴离子吸附结合,对SDBS有良好的吸附能力. 吸附过程自发放热,可用准二级动力学模型和Langmuir吸附等温模型描述. PEI-CCS对SDBS的最大吸附量随IEC增加而增大,IEC=1275 mmol/g的PEI-CCS的最大吸附量为1487.61 mg/g,是CCS最大吸附量(510.20 mg/g)的2.92倍,吸附-脱附7次循环后,吸附量下降17.8%. PEI-CCS具有良好的重复使用性.     

磁性复合微球对铬离子的吸附条件研究

以磁性纳米壳聚糖微球为载体,戊二醛为交联剂,采用共价交联法,负载鞘细菌S9构建磁性鞘细菌微球。通过单因素和正交设计实验,对该复合生物微球吸附铬离子的条件进行研究,结果发现磁性复合微球对铬离子的吸附性能明显高于磁性纳米壳聚糖和游离鞘细菌,同时得到最适吸附组合为A1B1C1,即当铬离子初始浓度为40mg/m L,吸附温度30℃,吸附时间30min,磁性复合微球对铬离子的吸附作用最佳,吸附量和吸附率分别为58.16mg/g和44.52%。     

羧甲基壳聚糖微球对曙红Y的吸附研究

以壳聚糖粉末为原料,戊二醛进行交联、羧甲基化,制得羧甲基壳聚糖微球。采用SEM对壳聚糖微球的形貌、大小进行了表征,研究羧甲基壳聚糖微球对曙红Y的吸附性能。探讨吸附剂用量、吸附时间、曙红Y的初始浓度、pH、温度对脱色率的影响,研究吸附等温曲线和动力学方程。实验结果表明,曙红Y初始浓度增加时,吸附量也增加,直到吸附饱和,羧甲基壳聚糖的饱和吸附量为75 mg/g;相同条件下,吸附剂用量增加时,平衡吸附量减小,去除率增加。298 K,吸附剂投加量为1 g,pH=7.0,吸附时间为40 min时,初始浓度为560 mg/L的曙红Y染料的去除率可以达到90%以上。符合Langmuir等温方程和二级吸附动力学方程。     

磁性壳聚糖微球制备及其对Pb2+的吸附性能研究

课题利用化学共沉淀法制备出Fe₃O₄粒子,在壳聚糖溶液中加入Fe₃O₄粒子进行改性,成功制备出磁性壳聚糖微球。课题以Pb²⁺作为吸附目标,探究了磁性壳聚糖微球对Pb²⁺的吸附的最优条件,并对磁性壳聚糖微球进行回收、再利用。结果表明,50 mL,50 mg/L Pb²⁺溶液投加量为150 mg、pH为6、温度35℃、时间为1 h是吸附实验的最佳条件,制备的吸附剂具有较好的吸附量和Pb²⁺去除率,且能够实现回收再生,具有环境友好性。     

纳米四氧化三铁沸石微球吸附废水中铅离子研究

采用纳米Fe_3O_4对人造沸石(NZ)进行改性,研究了吸附剂投加量、废水pH、不同交联剂、离子含量等对改性磁性沸石微球去除废水中Pb~(2+)性能的影响,分析了改性沸石的吸附动力学和吸附等温线。结果表明,在Pb~(2+)溶液pH=3,吸附剂投加量为0.6 g/L条件下,钙交联纳米Fe_3O_4改性沸石微球(Ca-MZS)对溶液中Pb~(2+)的去除率达93.4%,最大吸附量为77.1 mg/g,较NZ的最大吸附量8.02 mg/g有明显提高。Ca-MZS比铁交联纳米Fe_3O_4改性沸石微球(Fe-MZS)的最大吸附量高2.57 mg/g。Ca-MZS对Pb~(2+)的吸附过程符合准2级动力学模型和Freundlich模型。Pb~(2+)溶液分别加入Na~+、K~+时,Ca-MZS对Pb~(2+)去除率分别下降了9.3个、16.1个百分点。     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.     

Methyl 2,4,6-decatrienoates Attract Stink Bugs and Tachinid Parasitoids

Halyomorpha halys (Stål) (Pentatomidae), called the brown marmorated stink bug (BMSB), is a newly invasive species in the eastern USA that is rapidly spreading from the original point of establishment in Allentown, PA. In its native range, the BMSB is reportedly attracted to methyl (E,E,Z)-2,4,6-decatrienoate, the male-produced pheromone of another pentatomid common in eastern Asia, Plautia stali Scott. In North America, Thyanta spp. are the only pentatomids known to produce methyl 2,4,6-decatrienoate [the (E,Z,Z)-isomer] as part of their pheromones. Methyl 2,4,6-decatrienoates were field-tested in Maryland to monitor the spread of the BMSB and to explore the possibility that Thyanta spp. are an alternate host for parasitic tachinid flies that use stink bug pheromones as host-finding kairomones. Here we report the first captures of adult and nymph BMSBs in traps baited with methyl (E,E,Z)-2,4,6-decatrienoate in central Maryland and present data verifying that the tachinid, Euclytia flava (Townsend), exploits methyl (E,Z,Z)-2,4,6-decatrienoate as a kairomone. We also report the unexpected finding that various isomers of methyl 2,4,6-decatrienoate attract Acrosternum hilare (Say), although this bug apparently does not produce methyl decatrienoates. Other stink bugs and tachinids native to North America were also attracted to methyl 2,4,6-decatrienoates. These data indicate there are Heteroptera in North America in addition to Thyanta spp. that probably use methyl 2,4,6-decatrienoates as pheromones. The evidence that some pentatomids exploit the pheromones of other true bugs as kairomones to find food or to congregate as a passive defense against tachinid parasitism is discussed.     

2007～2008年世界塑料工业进展

收集了2007年7月～2008年6月世界塑料工业的相关资料,介绍了2007～2008年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况.按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯·硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、不饱和聚酯树脂、环氧树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍.     

2005～2006年国外塑料工业进展

收集了2005年7月～2006年6月国外塑料工业的相关资料,介绍了2005—2006年国外塑料工业的发展情况。提供了世界塑料产量、消费量及全球各类树脂生产量以及各国塑料制品的进出口情况。作为对比,介绍了中国塑料的生产情况。按通用热塑性树脂（聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂）、工程塑料（聚酰胺、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚）、通用热固性树脂（酚醛、聚氨酯、不饱和树脂、环氧树脂）、特种工程塑料（聚苯硫醚、液晶聚合物、聚醚醚酮）的品种顺序,对树脂的产量、消费量、供需状况及合成工艺、产品开发、树脂品种的延伸及应用的扩展作了详细的介绍。