Bacteriocin production by Enterococcus faecium FAIR-E 198 in view of its application as adjunct starter in Greek Feta cheese making

Bacteriocin production by Enterococcus faecium FAIR-E 198, isolated from Greek Feta cheese, was studied in batch fermentations, under conditions simulating Feta cheese preparation. Maximum enterocin activity and growth rate was obtained in de Man-Rogosa-Sharpe (MRS) broth at 37 degrees C with controlled pH 6.5. The enterocin was produced throughout the growth phase of the microorganism, showing primary metabolite kinetics with a peak activity during the mid-exponential phase. The use of skimmed milk as substrate revealed low enterocin activity. When fermentations were performed in skimmed milk in the presence of rennet, CaCl2, and a mixed starter culture, no enterocin activity was observed, although the examined strain grew well under the above conditions. Finally, when E. faecium FAIR-E 198 was applied as adjunct starter in Feta cheese making, no enterocin activity was detected throughout ripening. Results obtained underline the frequently underestimated finding that in vitro production by novel bacteriocinogenic starter or co-cultures is no guarantee for in situ efficiency. It was concluded that the complex food environment thoroughly interferes with bacteriocin production levels.     

Evaluation of iron‐fortified Feta cheese for physicochemical and sensory properties

Standardised cow's milk (fat 3 g/100 g) was used to manufacture Feta cheese fortified with 40, 60 and 80 mg of iron/kg cheese using ferrous sulphate (FeSO₄), ferric chloride (FeCl₃), ferric pyrophosphate (Fe₄ (P₂O₇)₃) and microencapsulated ferrous sulphate. Chemical composition and sensory characteristics of fortified cheeses were determined after 60 days of ripening, during which the iron content and thiobarbituric acid (TBA) values were measured. The metallic taste, colour, flavour, overall score and TBA values were statistically (P < 0.05) affected by the source and concentration of iron. The best quality was found in cheeses fortified with 40 mg/kg of microencapsulated ferrous sulphate.     

Effect of protective atmospheres on physicochemical,microbiological and rheological characteristics of sliced Mozzarella cheese

Mozzarella cheese slices packaged in bags of polyvinylidene chloride under vacuum (V) and using a gas mixture of equal parts of CO₂ and N₂ (G) were stored at 4 °C for 8 weeks and analysed at different storage times by physicochemical, microbiological and rheological characterization. Expected values of moisture, total nitrogen, soluble nitrogen at pH 4.6, and chloride contents and of pH were observed. The degradation of α_s1-casein was greater than β-casein degradation, while no significant differences were observed due to the packaging methods. Coliform microorganisms were not detected, while levels of moulds and yeasts counts were acceptable. Expected values of total mesophile counts were obtained. The temperature at crossover moduli (T_c) was determined from temperature sweeps carried out by rheometry. Greater values of T_c were observed in samples G. The influence of temperature on complex viscosity was studied by an Arrhenius-type equation. Activation energy values were obtained from the solid-like region (20–40 °C) and liquid-like region (40–60 °C). A more rapid change in viscosity with temperature was observed when storage time increased and when storage method V was used.     

Microflora of Feta cheese from four Greek manufacturers

The components of the microflora of four Feta cheeses, produced by different Greek manufacturers, were determined by culture dependent and independent techniques. Isolates from microbiological media were first grouped by Polymerase Chain Reaction-Denaturing Gradient Gel Electrophoresis (PCR-DGGE) and then representatives of each DGGE group were sequenced for identification purposes. DNA and RNA, extracted directly from the cheese, were subjected to PCR-DGGE. Moreover, Feta cheeses were subjected to FISH analysis in order to identify viable bacterial populations. The microbial ecology, as represented by the Lactic Acid Bacteria (LAB) and yeast populations, was different for the four cheeses. The main LAB species isolated were Lactobacillus plantarum, Lactobacillus brevis, Lactobacillus coryniformis and Lactobacillus fermentum. However, some inconsistencies were observed between the results obtained with the culture dependent and the culture independent approach. In the case of the yeasts, the results obtained by PCR-DGGE compared very well with those obtained by the conventional microbiological analysis and the main species found were Kluyveromyces lactis, Pichia fermentans and C. zeylanoides. FISH analysis highlighted viable but not culturable populations of Streptococcus thermophilus and Lactococcus spp. RAPD-PCR performed on the L. plantarum isolates revealed a cheese specific distribution and a temperature dependent clustering.     

Effect of saffron addition on the microbiological,physicochemical, antioxidant and sensory characteristics of yoghurt

The impact of added saffron on the characteristics of yoghurt was evaluated during storage. The fat content was lower in the saffron yoghurt. All colour variables were significantly affected by saffron and storage. From the 15th day of storage, bacterial numbers in the saffron yoghurt were higher than those of the control yoghurt. Sensory analysis data suggested that colour, odour and texture impacted consistently on the overall acceptability of the saffron yoghurt. Saffron addition significantly increased polyphenol content and antioxidant activity, providing evidence that the enrichment of natural yoghurt with saffron yields an innovative fermented product useful for supplementing antioxidant dietary intake.     

Effect of lactobacillus adjunct cultures on the microbiological and physicochemical characteristics of Roncal-type ewes'-milk cheese

The effect of two different experimental adjunct cultures composed of native facultatively heterofermentative lactobacilli (FHL) on the development of various groups of micro-organisms in Roncal-type ewes' milk cheese was studied. Four cheese batches were manufactured from raw milk (C), pasteurized milk (P), pasteurized milk and an adjunct culture of Lactobacillus paracasei (PP); and pasteurized milk and adjunct culture of Lactobacillus paracasei plus Lactobacillus plantarum (PPP). Retention of the two adjunct cultures in the cheeses was good, and population levels remained constant at around 10(7) cfu g(-1) of cheese throughout ripening. Levels of Enterobacteriaceae and enterococci fell off more abruptly in the batches made with the Lactobacillus adjunct cultures, suggesting competition between the added lactobacilli and those groups of micro-organisms. The inhibitory effect was greater for the adjunct culture composed of L. paracasei plus L. plantarum. Lactococcal levels were higher in the batches made with added FHL, which may be indicative of a synergistic effect between these two groups.     

Effect of draining temperature on the biochemical characteristics of Feta cheese

Two different draining temperatures, 15 and 21°C were applied to five Feta cheese curds made with different starters, containing mesophilic or thermophilic strains or mixtures of them. After 20 h of draining, the pH of curds made with thermophilic starters ranged from 5.28 to 5.49. The draining temperature significantly affected (P<0.05) the pH and the total solids of the cheeses. The inclusion of whey proteins in the cheese curd due to the insufficient draining of cheeses at 15°C, resulted in higher water-soluble nitrogen (WSN), as % of total nitrogen content. Free amino acid contents were significantly affected (P<0.05) by the draining temperature and by the presence of thermophilic lactobacilli in the starter mixture. Draining temperature also significantly affected (P<0.05) residual α_s- and β-casein and the RP-HPLC profiles of the WSN. The C_2:0 to C_8:0 free fatty acids, hardness (kg) and fracturability (kg), as well as the total organoleptic scores, were significantly (P<0.05) higher in feta drained at 21°C.     

The effect of direct acidification on the microbiological,physicochemical and sensory properties of probiotic Minas Frescal cheese

Minas Frescal cheeses produced with the addition of the probiotic culture Bifidobacterium Bb‐12 and without (C1) or with (C2) lactic acid were evaluated in relation to the microbiological, physicochemical and sensory properties. After 28 days of storage, the cheeses without lactic acid showed lower moisture and pH, in addition to higher acidity and syneresis. This behaviour influenced the texture profile of the cheeses, making them harder and chewier. The colour attributes L* and b* diminished during the storage. The majority of the consumers classified the cheeses as having good acceptability and they would buy this type of functional food.     

Microbiological,physicochemical and sensory characteristics of Cameros cheese packaged under modified atmospheres

This study evaluated the shelf-life quality of Cameros cheeses packaged under modified atmospheres. Five different modified atmosphere conditions were studied (carbon dioxide/nitrogen mixtures and vacuum). Control cheeses were packaged in air. The product stored at 3–4°C was evaluated periodically to investigate its sensory quality, microbiological condition and physicochemical characteristics. Weight loss and pH evolution were similar in vacuum and air packaging. Cheeses packaged in 100% CO₂showed the greatest weight losses and lower pH values. CO₂reduced proteolysis and lipolysis during storage in all conditions studied. Fat acidity and NPN/TN values were slightly higher in vacuum than in CO₂, but lower than in air. Modified atmosphere packaging presented an extended shelf life. Those containing CO₂reduced the growth rate of mesophiles, psychrotrophs, Enterobacteriaceae and coliforms, which was lower when the CO₂concentration increased. The lowest microbial counts were at 100% CO₂while vacuum conditions presented microbial counts only slightly lower than the controls. Salmonella spp.,Staphylococcus aureus and Listeria spp. were not found in any of the samples. Faecal coliforms, moulds and yeasts were not detected under CO₂atmospheres or in vacuum. After 7 days of storage, the sensory characteristics of the control cheeses were unacceptable in all the parameters studied. However, the overall score for cheeses stored in 40% and 50% CO₂did not change substantially, retaining a reasonable acceptability until the end of the storage period. The 100% CO₂atmosphere had a very negative effect on sensory quality. With regard to Cameros cheese, packaging in 50%CO₂/50%N₂and 40%CO₂/60%N₂are the most effective for extending shelf life and retaining good sensory characteristics.     

Influence of the starter culture on the microbiological and sensory characteristics of ewe's cheese

Changes which take place in the sensory characteristics of cheeses during ripening are influenced by different factors, involving rennet, starter culture and adventitious contamination of the cheese by non-starter lactic acid bacteria. The objective of this work was to study the influence of the starter on sensory and microbiological ewe's cheese properties during ripening time. Four batches (two with starter added and two without) were manufactured. Milk and cheeses at different stages of ripening were analysed. Cheeses manufactured without adding starter showed a significantly higher level of mesophilic aerobic microflora, lactobacilli, facultatively heterofermentative lactobacilli and enterococci (indigenous microflora) than cheeses manufactured with starter. This study has also shown that adding or not adding starter affects the flavour profile of the cheese. Cheeses with starter added showed greater intensity of the following attributes: refreshing, astringent, sweet; and received lower scores on bitterness. With respect to texture, the said cheeses develop a more homogenous texture and greater elasticity throughout ripening.     

Some physicochemical, microbiological, and sensory properties of tulum cheese produced from ewe's milk via a modified method

The purpose of this research was to investigate an alternative way to manufacture Erzincan tulum cheese in order to shorten production time and improve food safety. By adding 0.5% starter culture ( Streptococcus salivarius ssp. thermophilus and Lactobacillus delbrueckii ssp. bulgaricus cultures at a 1 : 1 ratio) to pasteurized ewe's milk (65°C for 30 min), the required time for manufacturing Erzincan tulum cheese was shortened from the traditional 10–12 days to 2 days. The cheeses manufactured with the modified method were ripened in three different packaging materials: goatskin, plastic, and ceramic. Physicochemical, microbiological, and sensory properties of the Erzincan tulum cheese were obtained during the ripening period at intervals of 2, 30, 60, and 90 days, and compared with those properties of samples manufactured by the traditional method. Significant microbiological and physicochemical differences were found between the modified samples and the traditional samples ( P <  0.01). However, the modified samples and the traditional samples were statistically similar in sensory properties to the exception of the modified sample packaged in plastic.     

Genetic diversity of Enterococcus faecium isolated from Bryndza cheese

One hundred and seventy-six Enterococcus faecium isolates from Slovak dairy product Bryndza were tested for the presence of plasmid DNA. Eighty-two isolates were positive and their plasmid DNA was isolated and digested by EcoRI and HindIII restriction endonucleases. The patterns obtained were compared with those obtained after pulsed-field gel electrophoresis of macrorestriction fragments (PFGE), (GTG)(5)-PCR and ERIC-PCR. All these molecular approaches were applied for the study of genetic variability and determination of strain relatednesses among plasmid-positive isolates of E. faecium. In general, all methods revealed a considerable genetic diversity of E. faecium isolates. Plasmid profiling and ERIC-PCR have offered a higher resolution than PFGE and (GTG)(5)-PCR.     

Effect of whey pH at drainage on physicochemical, biochemical, microbiological, and sensory properties of Mozzarella cheese made from buffalo milk during refrigerated storage

The objective of this research was to determine the effect of drainage pH on physicochemical, biochemical, microbiological and sensory properties of Mozzarella cheese made from buffalo milk during refrigerated storage. Four vats of cheese were made at 4 different whey drainage pH (6.2, 5.9, 5.6, and 5.2). Lower drainage pH caused higher pH 4.4-soluble N and pH 4.4-soluble N:total N. Interaction of drainage pH at d 1 and 30 of storage on all soluble nitrogen fractions was significant. Degradation of caseins in samples made at a drainage pH of 6.2 was lower than that of other cheese samples. The decreasing whey drainage pH significantly increased counts of thermophilic and mesophilic lactobacilli of the samples during refrigerated storage. No coliforms or Escherichia coli were detected in the cheeses. The average sensory property scores of all cheese samples were very close, and, as expected, storage time had a negative effect on all sensory scores.     

A comparison of the chemical,microbiological and sensory characteristics of bovine and ovine Halloumi cheese

Commercial samples of fresh and mature Halloumi cheeses made from ovine or bovine milk were studied in order to establish their chemical, microbiological and sensory characteristics. Significant differences were observed between the two types of Halloumi cheese both when fresh and mature. The free volatile fatty acid (FVFA) content of the cheeses increased with maturation from 483 to 1356 mg kg⁻¹ for the ovine product, but lower values (380–1248 mg kg⁻¹) were found in the bovine cheese. During maturation for 40 days, Enterococcus faecium, which dominated the microflora of fresh ovine cheese, was replaced by lactobacilli, including a new species, Lactobacillus cypricasei, which was not found in the bovine samples. Fewer than 100 cfu g⁻¹ lactic acid bacteria (LAB) were present in the fresh bovine cheeses, but a microflora dominated by lactobacilli developed with time. Yeast counts in the mature ovine and bovine cheeses reached 2.3–2.8×10⁵ cfu g⁻¹ and, as some of the yeasts were proteolytic and/or lipolytic, it was assumed that they were having a positive impact of the flavour of the cheeses. The sensory panel distinguished significant differences in texture and flavour between the fresh and mature samples of both ovine and bovine cheeses and, overall, there was a significant preference for the ovine brand.     

Physicochemical, microbiological and sensory changes during ripening and storage of Xinotyri, a traditional Greek cheese from raw goat's milk

Physicochemical, microbiological and sensory characteristics, evolution of lipolysis monitored by measuring acid degree value (ADV) and the main mineral elements were studied during ripening and storage of artisanal Xinotyri cheese from raw goat's milk. Cheeses were characterized by a high content in total solids (TS; 83%) and fat (59% of TS), and very low pH (4.0), water activity (0.87) and moisture (17%). Protein and salt contents at the end of storage were 31% and 2.8%, respectively. Lipolysis increased, while variations in mineral (Ca, P, Mg and Zn) content were found during ripening and storage. Cheeses were free of Salmonella and Listeria in 25 g, while enterobacteria, pseudomonads, and coagulase-positive staphylococci were < 100 cfu/g. Mesophilic lactic acid bacteria increased above 8 log cfu/g by day 6, but declined by 2–3 logs in the ripened cheese (45 days) and by 3–4 logs during cheese storage at 4°C for up to 180 days.     

Effect of some technological parameters on microbiological, chemical and sensory qualities of Civil cheese during ripening

The objective of this research was to determine the effects of different ripening methods [brine salting, dry salting, incorporating with Lor cheese (LR) and vacuum packaging] of Civil cheeses on its microbiological, chemical and sensory properties. Civil cheeses were analysed on the 2nd, 30th, 60th and 90th day of ripening. Chemical compositions of the cheeses were significantly different. While the highest dry matter and titratable acidity values were determined on dry salted cheeses, the highest fat and fat in dry matter contents were found in Civil cheese ripened together with LR. The water-soluble nitrogen and ripening index values were lower in cheese ripened incorporating with LR. Excessive proteolysis was not seen in any of cheese samples. The ripening in different methods affected microbiological and sensory properties of Civil cheese. Panellists preferred vacuum packaging and dry-salting cheeses compared to the other samples on the 90th day of ripening.     

Effect of ripening time on bacteriological and physicochemical goat milk cheese characteristics

Food Science and Biotechnology - Cheese ripening involves lactose metabolism, lipolysis and proteolysis, which are affected by many factors. The aim of this study was to assess changes due to...