Effect of 1-methylcyclopropene on tomato flavour components, shelf life and decay as influenced by harvest maturity and storage temperature

BACKGROUND: In Florida, tomatoes are harvested green (GR), which includes mature green (MG) and immature green (IG) fruits, and stored at low temperature (13 °C), resulting in poor flavour. Flavour improvement might be achieved if fruits were harvested with some colour (to eliminate IG fruits) and/or stored at higher temperature with the ripening inhibitor 1‐methylcyclopropene (1‐MCP). RESULTS: ‘Florida 47’ tomatoes were harvested at GR (MG + IG), breaker (BR), turning (TR) and pink (PK) stages, treated (+) or not (?) with 1‐MCP and stored at 13 and/or 18 °C. 1‐MCP treatment resulted in a gain of up to 6 days of shelf life depending on harvest maturity and storage temperature. Storage at 18 °C rather than 13 °C resulted in an increase in internal red colour, soluble solids (SS)/titratable acidity (TA) ratio and levels of many volatiles studied. The shelf life of BR (+) MCP fruits stored at 13 °C was similar to that of MG fruits. IG fruits exhibited lowest levels of SS, TA and ten volatiles compared with BR fruits. CONCLUSION: Harvesting tomatoes with colour (BR), thereby eliminating IG fruits, and treating with 1‐MCP resulted in better quality with adequate shelf life. Published 2011 by John Wiley & Sons, Ltd.     

MODIFICATION OF CONDITIONS AT THE WHOLESALE WAREHOUSE TO IMPROVE QUALITY OF FRESH-MARKET TOMATOES

Previous studies suggested that modification of storage temperatures at the wholesale warehouse could sufficiently retard ripening to permit harvest of fresh-market tomatoes at a later maturity, thus allowing for greater flavor development on the vine. Tomatoes (cvs ‘Celebrity’ and ‘Sunny’) were harvested either at the breaker or pink stages of maturity. Simulated wholesale storage was conducted by holding breaker fruit for 3 days at 12°C or 21°C and pink fruit for 3 days at 5°C or 37°C. Short-term low- and high-temperature storage of pink tomatoes delayed ripening sufficiently to maintain acceptable color and firmness during retail and consumer storage at 21°C for 7 days. Flavor characteristics of tomatoes harvested at the pink stage of maturity were not significantly superior to those of fruit harvested at the breaker stage. Thus, although ripening can be delayed in pink tomatoes during postharvest handling, delaying harvest from the breaker to the pink stage does not offer the flavor advantage to warrant a change in the handling system.     

Quality of Fungicide Treated and Individually Shrink-Wrapped Tomatoes

Fungicide-treated mature green and pink tomatoes were individually shrink-wrapped with plastic films and stored at 13°C and 18°C. Shrink-wrapped pink tomatoes lost less water than unwrapped tomatoes, but there were no significant shelf-life or quality differences. The shelf-life of mature green tomatoes at 18°C, however, was increased 10 days by shrink-wrapping. Color development of wrapped mature green tomatoes at 18°C was delayed. Wrapped fruit at both temperatures were firmer than the controls. Titratable acidities and soluble solids of wrapped fruit were lower than those of the unwrapped fruit at 13°C, while no significant changes were observed in citric acid or monosaccharide concentrations. The differences in titratable acidities and soluble solids in the wrapped and unwrapped fruit stored at 18°C were not significant.     

Effect of Cold and Heat Shock Treatment on the Color Development of Mature Green Tomatoes and the Roles of Their Antioxidant Enzymes

Color is the most important marker of the quality and ripeness of tomato fruits. To study the effect of cold shock treatment (CST; 0 °C, 3 h) and heat shock treatment (HST; 50 °C, 2 min) on the color development of mature green tomatoes and the roles of antioxidant enzymes, we measured color, the levels of malondialdehyde (MDA), ascorbic acid, and antioxidant enzymes at 20 and 10 °C storage conditions. HST retarded the ripening of mature green tomatoes, delayed color development, reduced MDA content, and increased superoxide dismutase (SOD) and peroxidase (POD) activities in tomatoes stored at 20 or 10 °C, as well as increased catalase (CAT) activity in tomatoes stored at 10 °C. In comparison with controls, CST accelerated the development of senescence in mature green tomatoes stored at 20 or 10 °C, which reflects faster color development and higher MDA content, resulting from the low activities of SOD and POD. These results suggested that, with regard to the antioxidant enzymes SOD and POD, CST had a different effect on color development compared with that of HST in mature green tomatoes stored at 20 or 10 °C. Furthermore, these results implied that SOD and POD played significant roles in the antioxidant system in CST- and HST-treated mature green tomatoes stored at 20 or 10 °C, and CAT was the crucial antioxidant enzyme to resist cold storage in HST-treated mature green tomatoes stored at 10 °C.     

Browning Susceptibility and Changes in Composition During Storage of Carambola Slices

Browning and changes in the composition of sliced and whole carambola (Averrhoa carambola L.) fruit during storage were investigated. Susceptibility to browning after slicing, packaging and storage for 4 wk at 4.4°C varied considerably between four cultivars and five selections. There was no difference in browning susceptibility between fruit harvested at mature green or breaker stages of maturity. Freshly sliced carambola browned only slightly when exposed to air, but packaged slices that had been stored for 2 or more wk at 4.4°C browned rapidly (within 6 hr) when exposed to air. Whole fruit stored at 4.4°C for up to 6 wk, then sliced, showed much less susceptibility to browning. Ascorbic acid decreased and polyphenoloxidase activity increased in carambola slices during storage, but less in whole fruit. Treating slices with 1.0 or 2.5% citric acid + 0.25% ascorbic acid (in water) prior to packaging was very effective in limiting browning.     

Abscisic Acid in the Response of ‘Fortune’ Mandarins to Chilling. Effect of Maturity and High-Temperature Conditioning

The possible role of abscisic acid (ABA) and peel colour in chilling tolerance of ‘Fortune’ mandarins has been examined. Fruit stored at 2·5°C, but not at 12°C, showed pitting damage. The degree of damage changed considerably during development and maturity from November until May. Green fruit were more tolerant to chilling injury (CI). After colour break, chilling susceptibility increased from the beginning of December until January and February (the coolest season during the growing period) and declined towards May. This trend did not parallel changes in fruit colour index or free and bound ABA levels, which increased from November until May. At the time of chloroplast transformation to chromoplast a noticeable shift in free but not in bound ABA occurred. During storage, free ABA levels increased in fruits stored at 12°C, but not at 2·5°C. Changes in ABA with storage temperature depended on the stage of maturity of the fruits, but not on their susceptibility to CI. It has also been shown that there was no relationship between ABA content following exposure to 37°C and chilling tolerance. At all stages of maturity, the susceptibility of the fruits to CI and the free ABA levels of the flavedo decreased after conditioning the fruits for 3 days at 37°C. After storage at 2·5°C, the ABA levels of the conditioned fruit were similar or even lower than those of non-conditioned fruit. Treatment of fruit for 3 days with 10 μl litre^-1 ethylene increased free ABA about four times, whereas bound ABA remained nearly constant. This treatment enhanced cold-induced peel damage after prolonged storage. Thus, the ethylene-induced changes in free ABA appear not to be related to the induced changes in chilling susceptibility. The results obtained indicated, therefore, that free and bound ABA appear not to be involved on the adaptative mechanism developed in ‘Fortune’ mandarins to cope with chilling stress. © 1997 SCI.     

Postharvest quality of arazá fruit during low temperature storage

Arazá (Eugenia stipitata Mc Vaugh) fruits at breaker stage of maturity were stored at 7, 10, 12, or 20 °C and 85-90% RH for 2 weeks, with or without an additional simulated shelf-life period (3 days at 20 °C and 70% RH). Some half-yellow (turning) arazá fruit were also stored at 7 or 12 °C. Respiration rate, ethylene production, quality traits and physiological disorders and decay were monitored. Arazá fruit of both stages of maturity showed a climacteric pattern of ripening, with the maximum levels of respiration being reached after 5 days at 20 °C for breaker fruit, while half-yellow fruit ripened totally after one day. Weight loss was the most limiting quality trait for arazá fruit. Chilling injury symptoms included skin scald (only at 7 °C), uneven ripening (at 7 or 10 °C, including uneven softening during storage, particularly in breaker fruit), and slight acidification at 7 °C. Decay in the post-storage shelf-life periods (mainly Gloesporium sp.) was particularly high after storage at 7 °C in breaker fruit. The storage of breaker arazá fruit at 12 °C is recommended because this prevents chilling injury and flesh acidification, and allows normal fruit ripening during a post-storage shelf-life at 20 °C, as revealed by the lower organic acids (mainly malic) content and increased sugar (glucose, fructose and sucrose) content.     

Storage Potential of Tomatoes Harvested at the Breaker Stage using Modified Atmosphere Packaging

Breaker tomatoes sealed in polymeric film (MAP) were stored at 15°C 23 days. A steady state of about 3.5-4.0 % O₂ and CO₂ was established. Mean concentrations of the gases within 24 hr of packaging were minimum 2.5 % O₂ and maximum 8.0% CO₂- Thereafter gas concentration moved gradually to a steady state; no evidence of anoxic conditions occurred. After 23 days of MAP storage fruit ripened normally under ambient conditions. Quality evaluations demonstrated that 15°C MAP storage permitted harvesting of breaker stage of ripeness tomatoes without reducing storage life to an unacceptable duration. MAP delayed changes in acidity, soluble solids, texture, color and polygalacturonase activity and resulted in substantial reduction in fruit weight loss and spoilage as compared to breaker fruit without film packaging.     

Influence of different concentrations of 1-methylcyclopropene on the quality of tomato harvested at different maturity stages

BACKGROUND: A wide range of 1‐methylcyclopropene (1‐MCP) concentrations as well as various treatment durations have been studied in tomatoes by different researchers. However, little is known about interaction of 1‐MCP doses and maturity stages of tomatoes. Therefore the effects of different concentrations of 1‐MCP on storage and postharvest quality of ‘Zorro’ tomatoes harvested at mature green or pink maturity stages were investigated in a 2‐year trial study. RESULTS: Higher concentrations of 1‐MCP delayed and/or inhibited all parameters related to fruit ripening, such as lycopene, chlorophyll, surface color, polygalacturonase (PG) activity and soluble solids content/titratable acidity (SSC/TA), and these effects were greater in tomatoes harvested at the mature green stages. Lower concentrations of 1‐MCP slightly reduced the loss in general quality features compared with untreated tomatoes. CONCLUSION: The results suggest that 1‐MCP, especially at higher doses, is effective for delaying ripening of mature green tomatoes. Mature green fruits treated with 1000 nL L^?1 1‐MCP were stored for 35 days without significant decreases in quality characteristics such as elasticity, surface color and SSC/TA with certain physiological processes (ethylene production, PG activity, lycopene synthesis). Copyright © 2011 Society of Chemical Industry     

Development of chilling injury symptoms in stored tomato fruit (Lycopersicon esculentum Mill)

Mature-green tomato fruit cv Calypso were stored at 5, 7,12 or 19^oC for 0, 3, 9, 12 or 21 days, ripened at 19^oC for 3 or 6 days and analysed for surface colour (a_L/b_L ratio), firmness, and tissue disorganisation in chill-damaged (pitted) and adjacent unpitted tissues. Manifestation of cell disorganisation and death was evident in pitted tissues. Alternaria spp, Stemphylium spp, Penicillium spp and Aureobasidium spp were isolated from pitted tissues. Fruit stored for either 9 or 12 days at 5 or 7°C subsequently ripened to an acceptable colour, but longer storage times inhibited satisfactory colour development. After storage at 12 or 19°C, fruit surface colour improved progressively with time. Loss of fruit firmness was highest at 19°C but decreased with increasing temperature from 5 to 12°C, showing biphasic maxima firmness loss on days 9 and 21. Surface pits occurred at the stem end and in the equatorial region of the fruit. Fruits were also stored at 7, 12 or 19°C for 10 or 20 days and then ripened at 19°C for 10 days before evaluation of visible defects; these were greatest at 7°C followed by 19°C and were lowest at 12°C.     

Shelf Life of Mature Green Tomatoes Stored in Controlled Atmosphere and High Humidity

Freshly harvested mature green tomatoes were washed, sorted and treated with 125 ppm chlorine water. The treated tomatoes were stored at 85% or 98% RH under controlled atmosphere (CA) storage for periods up to 8 wk. The controlled atmosphere was 2.5% O₂, 5.0% CO₂, and N₂ as the balance gas at 12°C. After storing 40 days, the tomatoes were allowed to ripen in air at 23°C. Samples of tomatoes were tested every 3 days to examine changes in quality as determined by visual observation, weight loss, titratable acidity, pH, color and firmness. Weight loss was reduced significantly by CA storage of tomatoes at 98% RH. Tomatoes remained green up to 40 days of storage and changed in color gradually during consecutive storage in atmospheric conditions. Appearance of the tomatoes was acceptable after ripening.     

Maturity‐related chilling tolerance in mango fruit and the antioxidant capacity involved

BACKGROUND: In order to evaluate how effect of mature stage on the chilling tolerance of mangoes (Mangifera indica L. cv. ‘Zihua’) and the mechanism involved, the fruit were categorized into three stages of ripeness: Green (100% green fruit), Preyellow (10–20% yellow fruit) and Yellow (45–55% yellow fruit) after harvest and stored at 2 °C for 12 days and then incubated at 25 °C for 2 days for chilling injury (CI) development. RESULTS: CI index in Preyellow and Yellow fruit was significantly lower than that of the Green fruit, as a rapid increase in ion leakage was observed in the Green fruit. Activities of superoxide dismutase, catalase, ascorbate peroxidase and polyphenoloxidase of Preyellow and Yellow fruit were higher than those of the Green from day 6 to day 12 during cold storage. A lower content of malondialdehyde but higher levels of glutathione and ascorbic acid were maintained in Preyellow and Yellow fruit than that in Green fruit. CONCLUSION: These results suggested that stronger resistance of Preyellow and Yellow mangoes to CI compared to Green fruit was due to their higher antioxidant capacity involved in the tolerance to chilling temperature. Alleviating CI in mangoes during storage may be achieved by storing the fruit when skin colour is beginning to change to yellow from green. Copyright © 2008 Society of Chemical Industry     

Active Packaging of Cardboard to Extend the Shelf Life of Tomatoes

In order to extend the shelf life of fresh tomatoes using biodegradable materials, an active microcorrugated cardboard tray package was tested for use with fresh Cherry tomatoes (Lycopersicon esculentum var. cerasiforme). Active packaging characteristics were achieved by coating the interior surface of the cardboard tray with polylactic acid (PLA; 3% w/v) and, after filling with tomatoes, the tray was wrapped with a low-density polyethylene (LDPE) film of 70 or 20 μm thickness and hermetically heat sealed. Uncoated trays were used as control. The trays of tomatoes were stored at 20?±?0.5 °C and 55?±?2% relative humidity, for 30 days, and the ethylene concentration in the package atmosphere was measured periodically as an indicator of ripeness. The following fruit quality parameters were also studied: weight loss, surface colour, microbial count, firmness, soluble solids and pH. It was demonstrated that the capacity of PLA to adsorb ethylene and water vapour and the thickness of the LDPE film were decisive for controlling the ethylene concentration of the package atmosphere and for preventing condensation of water vapour on the fruit and film. The active packaging configuration and storage conditions used preserved fruit quality for a month, thus extending the useful life of the tomatoes and saving refrigeration costs.     

Alleviation of chilling injury in postharvest tomato fruit by preconditioning with ultraviolet irradiation

BACKGROUND: Tomato fruit is usually stored at low temperatures for delayed ripening and extended shelf life. However, tomato fruit is susceptible to chilling injury when exposed to low temperatures. In this study, the potential effects of preconditioning with UV‐C or UV‐B irradiation on chilling injury of postharvest tomato fruit were investigated. RESULTS: Mature–green tomato fruit were exposed to 4 kJ m^?2 UV‐C or 20 kJ m^?2 UV‐B irradiation and stored for 20 days at 2 °C and subsequently 10 days at 20 °C. UV irradiation was effective in reducing chilling injury index and delaying ethylene peak. Furthermore, UV irradiation preserved storage quality as manifested by reduced weight loss, better retention of firmness, and higher contents of total soluble solids, soluble protein and soluble sugar during subsequent storage at 20 °C. UV‐C irradiation significantly delayed the development of the red colour after 10 days of storage at 20 °C. On the other hand, UV irradiation decreased total phenolics content and antioxidant capacity, suggesting possibly reduced stress response to low temperature resulted from enhanced physiological adaptation by UV preconditioning. CONCLUSION: Our results suggest that preconditioning with UV‐C or UV‐B irradiation in appropriate doses had a positive effect on alleviating chilling injury in postharvest tomato fruit. Copyright © 2012 Society of Chemical Industry     

Nondestructive Determination of Soluble Solids in Tomatoes using Near Infrared Spectroscopy

A nondestructive optical method for determining the soluble solids content of fresh whole tomatoes was investigated. The method, based upon near infrared spectrophotometric techniques, could predict the soluble solids content of tomatoes (r = 0.92, SEC = 0.27°Brix). Tomatoes from more than 30 popular fresh market cultivars at stages of maturity from mature green to ripe red fruit were studied.     

EFFECT OF COLD STORAGE ON THE QUALITY CHARACTERISTICS OF ‘AU-RUBRUM’ PLUMS1

The effect of cold storage (0°C) and maturity on the physical, chemical and sensory characteristics of plums (cv. ‘AU-Rubrum’) was determined. The size, weight, soluble solids and total sugar contents of the more mature fruit were significantly higher (P<0.05) and the “L” and hue angle were significantly lower (P<0.05) than plums in the less mature class. ‘AU-Rubrum’ fruit contained glucose, fructose and sorbitol but had no sucrose. Artificially ripening fruit at 20°C had a significant effect (P<0.01) on all color values for both maturity 1 and 2 fruit. The titratable acidity and sugar contents of the fruit ripened at 20°C were lower for ripened than for unripened fruit. Storage of the plums at 0°C for 5 weeks followed by subsequent ripening at 20°C had no significant effect on physical, chemical or sensory characteristics. Data indicate that ‘A U-Rubrum’ plums which have one-half red ground color (maturity 1) will develop full color and complete the normal ripening process. Data also indicate that the plums can be stored for at least 5 weeks at O°C without loss of quality and that the cultivar has potential for shipping to distant markets.     

Quality improvement and extension of shelf life by 1-methylcyclopropene in plum as affected by ripening stage at harvest

Plum (Prunus domestica L. cv. ‘President’) fruits were harvested at two pre-climacteric stages of ripeness (stage 1 and stage 2), and then treated with 1-methylcyclopropene (1-MCP) at two doses (0.3 and 0.5 μl l⁻¹) followed by 1, 2, 3, 4 and 5 weeks of cold storage and their respective 7 days of shelf life at 20 °C. Both 1-MCP doses were effective in terms of ethylene inhibition during shelf life after cold storage, for both ripening stages. Similarly, lower weight losses, delayed colour changes, reduced softening rate and diminished ripening index were found in 1-MCP treated plums than in controls at both stages of ripeness. Hence, during cold storage and shelf life, the efficacy of 1-MCP on ethylene production, weight loss, pulp firmness and ripening index was dose-dependent, while for colour and respiration rate the dose-dependence was only found during shelf life. The storability of 1-MCP treated plums could be extended up to 4 weeks of cold storage plus 7 days at 20 °C, and only up to 1 week of cold storage plus 7 days at 20 °C for controls. Then, 1-MCP is an effective tool for quality improvement and extension of shelf life in plums, and fruit might be harvested in stage 2 of ripening, at which the most desirable organoleptic attributes had been developed on tree.     

纤维素可食性膜对番茄保鲜贮藏中硬度和色泽的影响

用于食品包装的绿色包装材料之一的可食性包装已逐渐地取代容易产生“白色污染”的不可降解性塑料薄膜。本研究采用羟丙基甲基纤维素 (HPMC)可食性膜 ,将之涂于番茄上 ,然后贮藏于 2 0℃下达 18d ,研究其对番茄硬度和色泽的影响。在贮藏期间 ,所有处理组的番茄的硬度都随着贮放时间的延长而下降。但是 ,施用HPMC可食性膜可以延缓番茄变软。在贮藏日的第 7、13和 18d ,观察到以HPMC涂膜的番茄的硬度都显著性地 (P≤ 0 0 5 )比未涂膜的番茄的硬度大。本研究还证实了HPMC可食性膜可以显著性地 (P≤ 0 0 5 )延缓番茄在 2 0℃贮藏时色泽的变化 ,延迟了番茄从粉红色到红色阶段的后熟。因此 ,HPMC可食性膜可以有效地减慢番茄后熟 ,延长番茄的保存期。同时番茄硬度损失率的减慢 ,可以减少番茄果实运输时因机械损伤导致果实腐败而造成的经济损失。     

The effects of 1-methylcyclopropene treatment on the shelf life and quality of cherry tomato (Lycopersicon esculentum var. cerasiforme) fruit

The use of 1‐methylcyclopropene (1‐MCP) to extend the shelf life of cherry tomato (Lycopersicon esculentum var. cerasiforme) was investigated. Higher concentrations of 1‐MCP delayed the ethylene induced climacteric peaks in mature green (MG) and breaker (BR) fruits. Thirteen days after treatment, control fruits were 55% as firm as fruit treated with 0.11 μL L^?1 1‐MCP. The initiation of fruit softening, chlorophyll degradation and accumulation of lycopene and carotenoids was delayed in treated fruits. Higher 1‐MCP concentrations inhibited the accumulation of lycopene and carotene such that the colour of the fruit did not reach that of control fruit. Treatment of MG cherry tomatoes with 1‐MCP enhanced shelf life optimally, while treatment of BR fruits was beneficial where full colour and high content of lycopene and carotenoids is important. Differentiation of the different stages of ripening before application of 1‐MCP is needed in order to succeed in accomplishing different postharvest objectives.     

Effect of heat treatment and individual shrink packaging on quality and nutritional value of bell pepper stored at suboptimal temperature

The goal of this study was to develop a technology for prolonged storage of pepper fruit at low temperature, based on physical treatments and packaging materials. Physical and compositional changes of red bell pepper fruit (Capsicum annuum L. cv.’Selika’) were monitored during 21 days of cold storage (at 2 °C) plus 3 days at 20 °C (market simulation). Fruits were treated with tap and hot water and stored without packaging or sealing each fruit in individual shrink packaging (Cryovac®). This research revealed that individual shrink packaging following prestorage with hot water rinse (55 °C for 15 s) over brushes, significantly reduced weight loss, softening, decay incidence and chilling injury, while maintaining a quality. The wrapped fruit ripened normally (carotenoid content increased) during shelf‐life period, when shifted to 20 °C after unwrapping. This study showed that antioxidant levels of pepper fruit may be preserved during storage.