Bactericidal effect of sodium chlorate on Escherichia coli O157:H7 and Salmonella typhimurium DT104 in rumen contents in vitro

Escherichia coli O157:H7 and Salmonella Typhimurium DT104 are important foodborne pathogens affecting the beef and dairy industries and strategies are sought to rid these organisms from cattle at slaughter. Both pathogens possess respiratory nitrate reductase that also reduces chlorate to the lethal chlorite ion. Because most anaerobes lack respiratory nitrate reductase, we hypothesized that chlorate may selectively kill E. coli O157:H7 and Salmonella Typhimurium DT104 but not potentially beneficial anaerobes. In support of this hypothesis, we found that concentrations of E. coli O157:H7 and Salmonella Typhimurium DT104 were reduced from approximately 1,000,000 colony forming units (CFU) to below our level of detection (< or = 10 CFU) following in vitro incubation (24 h) in buffered ruminal contents (pH 6.8) containing 5 mM added chlorate. In contrast, chlorate had little effect on the most probable number (mean +/- SD) of total culturable anaerobes (ranging from 9.9 +/- 0.72 to 10.7 +/- 0.01 log10 cells/ml). Thus, chlorate was bactericidal to E. coli O157:H7 and Salmonella Typhimurium DT104 but not to potentially beneficial bacteria. The bactericidal effect of chlorate was concentration dependent (less at 1.25 mM) and markedly affected by pH (more bactericidal at pH 6.8 than pH 5.6).     

Use of steam condensing at subatmospheric pressures to reduce Escherichia coli O157:H7 numbers on bovine hide.

This study used a laboratory-scale apparatus to apply subatmospheric steam to bovine hide pieces inoculated with Escherichia coli O157:H7 in maximum recovery diluent (MRD) and in high-liquid content and low-liquid content fecal suspensions (HLC fecal and LLC fecal, respectively). The survival of the organism in fecal clods, which were stored for 24 days in a desiccated state, was assessed. Inoculated fecal clods were also treated with subatmospheric steam. Steam treatment at 80 +/- 2 degrees C for 20 s reduced E. coli O157:H7 concentrations on hide inoculated to initial concentrations of approximately 7 log10 CFU/g by 5.46 (MRD inoculum), 4.17 (HLC fecal inoculum), and 5.99 (LLC fecal inoculum) log10 CFU/g. The reductions achieved in samples inoculated with LLC feces were larger than in samples inoculated with HLC feces (P < 0.05). Treatment at 80 +/- 2 degrees C for 10 s resulted in significantly smaller reductions (P < 0.05) on hide pieces of 2.54 (MRD), 1.94 (HLC fecal), and 2.15 (LLC fecal) log10 CFU/g. There were no significant differences among the reductions observed in all inoculum types in samples treated for 10 s. E. coli O157:H7 inoculated in fecal clods to 7.78 log10 CFU/g and stored at 4 or 15 degrees C survived for at least 24 days. Steam treatment (20 s) of 3-day-old clods reduced surviving E. coli O157:H7 numbers from 4.20 log10 CFU/g to below the limit of detection of the assay used (1.20 log10 CFU/g). This study shows that steam condensing at or below 80 +/- 2 degrees C can reduce E. coli O157:H7 when present on bovine hide, reducing the risk of cross contamination to the carcass during slaughter and dressing.     

The survival of Escherichia coli O157:H7 in the presence of Penicillium expansum and Glomerella cingulata in wounds on apple surfaces

The survival of Escherichia coli O157:H7 in the presence of one of two plant pathogens, Penicillium expansum and Glomerella cingulata, in wounds on apples was observed during 14 days storage at room temperature (RT) and at 4 degrees C. The aim of this work was to determine if changes in apple physiology caused by the proliferation of fungal decay organisms would foster the survival of E. coli O157:H7. Trials were performed where (A) plant pathogens (4 log10 spores) were added to apple wounds 4 days before the wounds were inoculated with E. coli O157:H7 (3 log10 CFU g(-1) apple) (both RT and 4 degrees C storage), (B) plant pathogens and E. coli O157:H7 were added on the same day (both RT and 4 degrees C storage), and (C) E. coli O157:H7 was added 2 days (RT storage) and 4 days (4 degrees C storage) before plant pathogens. In all trials E. coli O157:H7 levels generally declined to <1 log10 at 4 degrees C storage, and in the presence of P. expansum at 4 degrees C or RT. However, in the presence of G. cingulata at RT E. coli O157:H7 numbers increased from 3.18 to 4.03 log10 CFU g(-1) in the apple wound during trial A, from 3.26 to 6.31 log10 CFU g(-1) during trial B, and from 3.22 to 6.81 log10 CFU g(-1) during trial C. This effect is probably a consequence of the attendant rise in pH from 4.1 to approximately 6.8, observed with the proliferation of G. cingulata rot. Control apples (inoculated with E. coli O157:H7 only) were contaminated with opportunistic decay organisms at RT during trials A and B, leading to E. coli O157:H7 death. However, E. coli O157:H7 in control apples in trial C, where no contamination occurred, increased from 3.22 to 5.97 log10 CFU g(-1). The fact that E. coli O157:H7 can proliferate in areas of decay and/or injury on fruit highlights the hazards associated with the use of such fruit in the production of unpasteurized juice.     

Escherichia coli O157:H7 populations in sheep can be reduced by chlorate supplementation

Ruminant animals are a natural reservoir of the foodborne pathogen Escherichia coli O157:H7. Some foodborne pathogens (e.g., E. coli) are equipped with a nitrate reductase that cometabolically reduces chlorate. The intracellular reduction of chlorate to chlorite kills nitrate reductase-positive bacteria; however, species that do not reduce nitrate are not affected by chlorate. Therefore, it has been suggested that ruminants be supplemented with chlorate prior to shipment for slaughter in order to reduce foodborne illnesses in human consumers. Sheep (n = 14) were fed a high-grain ration and were experimentally infected with E. coli O157:H7. These sheep were given an experimental product (XCP) containing the equivalent of either 2.5 mM NaNO3 and 100 mM NaCl (control sheep; n = 7) or 2.5 mM NaNO3 and 100 mM NaClO3 (chlorate [XCP]-treated sheep; n = 7). Control and XCP-treated sheep were treated for 24 h; XCP treatment reduced the population of inoculated E. coli O157:H7 (P < 0.05) from 10(2), 10(5), and 10(5) CFU/g in the rumen, cecum, and rectum, respectively, to < 10(1) CFU/g in all three sections of the gastrointestinal tract. The number of sheep testing positive for E. coli O157:H7 was significantly reduced by XCP treatment. In a similar fashion, total E. coli and coliforms were also reduced (P < 0.05) in all three compartments of the intestinal tract. Intestinal pH, total volatile fatty acid production, and the acetate/propionate ratio were unaffected by XCP treatment. On the basis of these results, it appears that chlorate treatment can be an effective method for the reduction of E. coli O157:H7 populations in ruminant animals immediately prior to slaughter.     

Antibacterial effect of monocaprylin on Escherichia coli O157:H7 in apple juice

The antibacterial effect of low concentrations of monocaprylin on Escherichia coli O157:H7 in apple juice was investigated. Apple juice alone (control) or containing 2.5 mM (0.055%) or 5 mM monocaprylin was inoculated with a five-strain mixture of E. coli O157:H7 at approximately 6.0 log CFU/ml. The juice samples were stored at 23 or 4 degrees C for 14 or 21 days, respectively, and the population of E. coli O157:H7 was determined on tryptic soy agar plates supplemented with 0.6% yeast extract. At both storage temperatures, the population of E. coli O157:H7 in monocaprylin-supplemented juice samples was significantly lower (P < 0.05) than that in the control samples. The concentration of monocaprylin and the storage temperature had a significant effect on the inactivation of E. coli O157:H7 in apple juice. Monocaprylin at 5 mM was significantly more effective than 2.5 mM monocaprylin for killing E. coli O157:H7 in apple juice. Inactivation of E. coli O157:H7 by monocaprylin was more pronounced in juice stored at 23 degrees C than in the refrigerated samples. Results of this study indicated that monocaprylin is effective for killing E. coli O157:H7 in apple juice, but detailed sensory studies are needed to determine the organoleptic properties of apple juice containing monocaprylin.     

Inhibition of Salmonella enterica and Escherichia coli O157:H7 on roasted turkey by edible whey protein coatings incorporating the lactoperoxidase system

The effects of whey protein isolate (WPI) coatings incorporating a lactoperoxidase system (LPOS) on the inhibition of Salmonella enterica and Escherichia coli O157:H7 on roasted turkey were studied by testing the initial inhibition as well as the inhibition during storage. The initial antimicrobial effects of WPI coatings incorporating LPOS (LPOS-WPI coatings) were examined with various inoculation levels and LPOS concentrations. LPOS-WPI coatings with 7 and 4% of LPOS demonstrated initial 3- and 2-log CFU/g reductions of S. enterica and E. coli O157:H7, respectively. The antimicrobial effect was observed regardless of whether the turkey was inoculated before or after coating. Storage studies were conducted for 42 days at 4 and 10 degrees C with S. enterica (6.0 log CFU/g)- or E. coli O157:H7 (5.6 log CFU/g)-inoculated sliced turkey. LPOS concentrations for the storage studies of S. enterica and E. coli O157:H7 were 5 and 3% (wt/wt), respectively, in the coating solution and in an LPOS solution for spreading. LPOS-WPI coatings inhibited the growth of both S. enterica and E. coli O157:H7 in turkey at both 4 and 10 degrees C for 42 days. The inhibition was more pronounced when the coating was formed on the surface of the turkey prior to inoculation than when the coating was formed on the inoculated surface. More effective inhibition of S. enterica and E. coli O157:H7 was observed with the LPOS-WPI coatings than with the LPOS solution-spreading treatment. LPOS-WPI coatings also retarded the growth of total aerobes during storage.     

Inhibition of Escherichia coli O157:H7 in ripening dry fermented sausage by ground yellow mustard

Compounds generated by the enzymatic hydrolysis of glucosinolates naturally present in mustard powder are potently bactericidal against Escherichia coli O157:H7. Because E. coli O157:H7 can survive the dry fermented sausage manufacturing process, 2, 4, and 6% (wt/wt) nondeheated (hot) mustard powder or 6% (wt/wt) deheated (cold) mustard powder were added to dry sausage batter inoculated with E. coli O157:H7 at about 7 log CFU/g to evaluate the antimicrobial effectiveness of the powders. Reductions in E. coli O157:H7 populations, changes in pH and water activity (aw), effects on starter culture (Pediococcus pentosaceus and Staphylococcus carnosus) populations, and effects of mustard powder on sausage texture (shear) were monitored during ripening. Nondeheated mustard powder at 2, 4, and 6% in dry sausage (0.90 aw) resulted in significant reductions in E. coli O157:H7 (P < 0.05) of 3.4, 4.4, and 6.9 log CFU/g, respectively, within 30 days of drying. During fermentation and drying, mustard powder did not affect P. pentosaceus and S. carnosus activity in any of the treatments. Extension of drying to 36 and 48 days reduced E. coli O157:H7 by >5 log CFU/g in the 4 and 2% mustard powder treatments, respectively. The 6% deheated mustard powder treatment provided the most rapid reductions of E. coli O157:H7 (yielding <0.20 log CFU/g after 24 days) by an unknown mechanism and was the least detrimental (P < 0.05) to sausage texture.     

Distribution patterns of Escherichia coli O157:H7 in ground beef produced by a laboratory-scale grinder

This study determined the distribution patterns of Escherichia coli O157:1H7 in ground beef when a contaminated beef trim was introduced into a batch of uncontaminated beef trims prior to grinding in a small-scale laboratory grinder. A beef trim (15.3 +/- 2 g) was inoculated with a rifampicin-resistant strain of E. coli O157:H7 (E. coli O157:H7rif) and introduced into a stream of noncontaminated beef (322 +/- 33 g) prior to grinding. Seven inoculum levels (6, 5, and 4 total log CFU [high]; and 3, 2, 1, and 0 total log CFU [low]) were studied in triplicate. E. coli O157:H7rif was not detected in 3.1 to 43% of the ground beef inoculated with the high levels or in 3.4 to 96.9% of the ground beef inoculated with the low levels. For all inoculum levels studied, the five ground beef fractions (each 7.8 +/- 0.6 g) with the highest pathogen levels accounted for 59 to 100% of the total pathogens detected. For all inoculum levels, there was a linear relationship between the quantity of ground beef containing E. coli O157:H7rif and the inoculum level. The quantity of E. coli O157:H7rif in the beef remaining in the grinder was proportional to the inoculum level and was related to the location in the grinder. Different components of the grinder accumulated E. coli O157:H7rif in different quantities, with the most significant accumulation being in the nut (collar) that attaches the die to the blade. This study determined specific distribution patterns of E. coli O157:H7rif after the grinding of a contaminated beef trim along with uncontaminated trims, and the results indicate that the grinding operation should be regarded as a means of distribution of microbial contamination in risk analyses of ground beef operations.     

Direct microscopic observation of lettuce leaf decontamination with a prototype fruit and vegetable washing solution and 1% NaCl-NaHCO3

Efficacy of a prototype, food-grade alkaline surfactant washing solution and 1% NaCl-NaHCO3 (pH 10.0) against Escherichia coli O157:H7 cells on lettuce leaves was evaluated. Lettuce was inoculated with 10(9) CFU/ml of E. coli O157:H7 for 24 +/- 1 h at 4 degrees C. Samples were rinsed and treated with the prototype washing solution containing lauryl sodium sulfate or NaCl-NaHCO3 for 3 min at 22 degrees C. Viability of E. coli O157:H7 cells was examined by plate counts at the surface and cut edge, and by confocal scanning microscopic (CSLM) observation of samples stained with Sytox green and Alexa 594 conjugated antibody against E. coli O157:H7 at intact leaf surface, stomata, and damaged tissue (0 to 10, 30 to 40, and 0 to 40 microm from the cut surface). Although both treatments caused significant log reductions in CFU at the surface and cut edge, log reductions were greater for the prototype washing solution (0.7 to 1.1 log CFU/cm2) than for NaCl-NaHCO3 (0.2 to 0.4 log CFU/cm2) (P < 0.05). Percentage of viability determined by CSLM for prototype washing solution was significantly greater at 30 to 40 microm from cut surfaces than at 0 to 10 and 0 to 40 microm from cut surfaces and intact surfaces (P < 0.05). Stomata provided moderate protection. NaCl-NaHCO3 was less effective than the prototype washing solution, and high percentages of E. coli O157:H7 cells remained viable at all sites except at the surface. The percent viabilities determined by CSLM were not significantly different from those determined by plate counts for NaCl-NaHCO3 treatment (P > 0.05). However, CSLM indicated significantly greater percent viability than plate counts for lettuce treated with the prototype washing solution (P < 0.05). Surfactant-containing washing solutions warrant additional testing for decontamination of fresh produce.     

Interventions for the reduction of Salmonella Typhimurium DT 104 and non-O157:H7 enterohemorrhagic Escherichia coli on beef surfaces

A study was conducted to determine if slaughter interventions currently used by the meat industry are effective against Salmonella Typhimurium definitive type 104 (DT 104) and two non-O157:H7 enterohemorrhagic Escherichia coli (EHEC). Three separate experiments were conducted by inoculating prerigor beef surfaces with a bovine fecal slurry containing Salmonella Typhimurium and Salmonella Typhimurium DT 104 (experiment 1), E. coli O157:H7 and E. coli O111:H8 (experiment 2), or E. coli O157:H7 and E. coli O26:H11 (experiment 3) and spray washing with water, hot water (72 degrees C), 2% acetic acid, 2% lactic acid, or 10% trisodium phosphate (15 s, 125 +/- 5 psi, 35 +/- 2 degrees C). Remaining bacterial populations were determined immediately after treatments (day 0), after 2 days of aerobic storage at 4 degrees C, and after 7, 21, and 35 days of vacuum-packaged storage at 4 degrees C. In addition to enumeration, confirmation of pathogen serotypes was performed for all treatments on all days. Of the interventions investigated, spray treatments with trisodium phosphate were the most effective, resulting in pathogen reductions of >3 log10 CFU/cm2, followed by 2% lactic acid and 2% acetic acid (>2 log10 CFU/cm2). Results also indicated that interventions used to reduce Salmonella Typhimurium on beef surfaces were equally effective against Salmonella Typhimurium DT 104 immediately after treatment and again after long-term, refrigerated, vacuum-packaged storage. Similarly, E. coli O111:H8 and E. coli O26:H11 associated with beef surfaces were reduced by the interventions to approximately the same extent as E. coli O157:H7 immediately after treatment and again after long-term, refrigerated, vacuum-packaged storage. It was also demonstrated that phenotypic characterization may not be sufficient to identify EHECs and that the organisms should be further confirmed with antibody- or genetic-based techniques. Based on these findings, interventions used by the meat industry to reduce Salmonella spp. and E. coli O157:H7 appear to be effective against DT 104 and other EHEC.     

Destruction of Escherichia coli O157:H7 by vanillic acid in unpasteurized juice from six apple cultivars

The behavior of Escherichia coli O157:H7 in Granny Smith, Gala, Empire, McIntosh, Red Delicious, and Golden Delicious apple juice with or without supplementation with 5 or 10 mM vanillic acid was examined over a storage period of 7 days at 4 and 15 degrees C. The consequences of supplementation on sensory difference and preference were also determined by triangle testing. Juices made from the six apple cultivars had pH values ranging between pH 3.13 and 3.92. Vanillic acid exerted a concentration, pH, and time-dependent lethal effect toward E. coli O157:H7 in unpasteurized apple juice. Supplementation with 10 mM vanillic acid led to a 5-logarithm reduction in populations after 7 days at both temperatures, but sensory analysis revealed significant differences from and preference for unsupplemented juices. Supplementation with 5 mM vanillic acid accelerated death of E. coli O157:H7, but population reductions ranged from 5 log CFU/ml in low pH juices to none in high pH juices, particularly at 4 degrees C. No sensory difference or preference was detected in two of the six juices at this level of supplementation.     

Bactericidal effects of Lactobacillus reuteri and allyl isothiocyanate on Escherichia coli O157:H7 in refrigerated ground beef

Two naturally occurring antimicrobial agents were tested in packages of refrigerated ground beef for their ability to reduce the viability of Escherichia coli O157:H7 during storage. Allyl isothiocyanate (AITC) and Lactobacillus reuteri were tested separately and together for their action against a cocktail of five strains of E. coli O157:H7 in ground beef held at 4 degrees C for 25 days. Ground beef prepared from whole, raw inside round beef roasts was inoculated with low (3 log CFU/g) or high (6 log CFU/g) levels of the E. coli O157:H7 mixture. The beef was treated with AITC (about 1,300 ppm), L. reuteri, or both, along with 250 mM of glycerol per kg of meat at two levels (3 and 6 log CFU/g) and according to a design that yielded 8 controls plus 10 different treatments. Samples were analyzed for E. coli O157:H7 survivors, numbers of total bacteria, and lactic acid bacteria on days 0 to 25 at 5-day intervals. L. reuteri at both input levels with glycerol killed E. coli O157:H7 at both inoculated levels before day 20. AITC completely eliminated E. coli O157:H7 at the low-inoculum level (3 log CFU/g) and reduced viability >4.5 log CFU/g at the high-inoculum level (6 log CFU/g) by the end of the storage period. The combination of L. reuteri and AITC did not yield an additive effect against E. coli O157:H7 viability. L. reuteri in the presence of glycerol was highly effective against E. coli O157:H7 in ground beef during refrigerated storage (4 degrees C) in modified atmosphere packages. Sensory testing is planned to evaluate effects of treatments.     

Fate of Escherichia coli O157:H7 during silage fermentation

The survival characteristics of Escherichia coli O157:H7 in silage derived from contaminated grass were investigated. The survival of other enteric bacteria was also investigated to determine if E. coli O157:H7 demonstrates enhanced acid tolerance in comparison. Samples of chopped grass were treated as follows: (i) no additive (control); (ii) inoculation with E. coli O157:H7 to a final concentration of log10 4.0 CFU g(-1); (iii) addition of an 85% solution of formic acid at 3.0 ml kg(-1) grass; and (iv) addition of both E. coli O157:H7 and formic acid, at the above concentrations. Treated 6-kg grass samples were packed into laboratory silos, sealed, and stored at 15 degrees C for up to 180 days. Individual replicate silos were removed from storage periodically and subjected to microbiological and chemical analyses. Chemical analyses of the silage samples indicated that lactic acid-dominant fermentations, with a rapid drop in pH, occurred. Numbers of enteric bacteria decreased from log10 7.0 to 8.0 CFU g(-1) to undetectable levels within 19 days' storage. E. coli O157:H7 did not survive the silage fermentation process, with numbers declining from approximately log10 4.0 CFU g(-1) to undetectable levels within 19 days of ensiling. The pattern of decline in numbers of E. coli O157:H7 was the same as that for the enteric bacteria, indicating that under the conditions tested, the acid tolerance of E. coli O157:H7 was not significantly different from the acid tolerance of other enteric bacteria. This study found that E. coli O157:H7 did not survive a good silage fermentation process, indicating that properly ensiled grass that is correctly stored is unlikely to be a vector for the transmission of the pathogen among cattle.     

In vitro inactivation of Escherichia coli O157:H7 in bovine rumen fluid by caprylic acid

The antibacterial effect of caprylic acid (35 and 50 mM) on Escherichia coli O157:H7 and total anaerobic bacteria at 39 degrees C in rumen fluid (pH 5.6 and 6.8) from 12 beef cattle was investigated. The treatments containing caprylic acid at both pHs significantly reduced (P < 0.05) the population of E. coli O157:H7 compared with that in the control samples. At pH 5.6, both levels of caprylic acid killed E. coli O157:H7 rapidly, reducing the pathogen population to undetectable levels at 1 min of incubation (a more than 6.0-log CFU/ml reduction). In buffered rumen fluid at pH 6.8, 50 mM caprylic acid reduced the E. coli O157:H7 population to undetectable levels at 1 min of incubation, whereas 35 mM caprylic acid reduced the pathogen by approximately 3.0 and 5.0 log CFU/ml at 8 and 24 h of incubation, respectively. At both pHs, caprylic acid had a significantly lesser (P < 0.05) and minimal inhibitory effect on the population of total anaerobic bacteria in rumen compared with that on E. coli O157:H7. At 24 h of incubation, caprylic acid (35 and 50 mM) reduced the population of total anaerobic bacteria by approximately 2.0 log CFU/ml at pH 5.6, whereas at pH 6.8, caprylic acid (35 mM) did not have any significant (P > 0.05) inhibitory effect on total bacterial load. Results of this study revealed that caprylic acid was effective in inactivating E. coli O157:H7 in bovine rumen fluid, thereby justifying its potential as a preslaughter dietary supplement for reducing pathogen carriage in cattle.     

Effect of chemical sanitizer combined with modified atmosphere packaging on inhibiting Escherichia coli O157:H7 in commercial spinach

Escherichia coli O157:H7 contaminated spinach has recently caused several outbreaks of human illness in the USA and Canada. However, to date, there has been no study demonstrating an effective way to eliminate E. coli O157:H7 in spinach. Therefore, this study was conducted to investigate the effect of chemical sanitizers alone or in combination with packaging methods such as vacuum and modified atmosphere packaging (MAP) on inactivating E. coli O157:H7 in spinach during storage time. Spinach inoculated with E. coli O157:H7 was packaged in four different methods (air, vacuum, N(2) gas, and CO(2) gas packaging) following treatment with water, 100 ppm chlorine dioxide, or 100 ppm sodium hypochlorite for 5 min at room temperature and stored at 7+/-2 degrees C. Treatment with water did not significantly reduce levels of E. coli O157:H7 in spinach. However, treatment with chlorine dioxide and sodium hypochlorite significantly decreased levels of E. coli O157:H7 by 2.6 and 1.1 log(10)CFU/g, respectively. Levels of E. coli O157:H7 in samples packaged in air following treatments grew during storage time, whereas levels were maintained in samples packaged in other packaging methods (vacuum, N(2) gas, and CO(2) gas packaging). Therefore there were significant differences (about 3-4 log) of E. coli O157:H7 populations between samples packed in air and other packaging methods following treatment with chemical sanitizers after 7 days storage. These results suggest that the combination of treatment with chlorine dioxide and packaging methods such as vacuum and MAP may be useful for improving the microbial safety of spinach against E. coli O157:H7 during storage.     

VALIDATION OF HEATING CONDITIONS IN PRODUCTION OF DIRECT ACIDIFIED BEEF SUMMER SAUSAGE FOR ELIMINATION OF ESCHERICHIA COLI O157:H7

The effectiveness of a typical production process for eliminating Escherichia coli O157:H7 in directly acidified all‐beef summer sausage was evaluated for formulations of different fat contents (approximately 8 and 17%) and types of direct acidulant (encapsulated citric or lactic acid). Raw batter inoculated with E. coli O157:H7 to an initial level of ca. 7.4 log cfu/g was stuffed into 64‐mm casings and processed according to a thermal processing schedule used by a small commercial processor for directly acidified summer sausage products (maximum internal product temperature of 70C, followed by cold showering). For all‐beef summer sausage, log reductions ranged from 5.3 to 5.5 cfu/g when product reached 64.4C (148F) internal temperature (IT) and 70C (158F) IT, and from 6.3 to 6.5 log cfu/g reductions when product reached 37.8C (100F) IT after thermal processing and cold showering. No differences in E. coli O157:H7 counts were observed for products with different fat or acid contents.     

Inhibition of pathogens on fresh produce by ultraviolet energy

Ultraviolet energy at a wavelength of 253.7 nm (UVC) was investigated for its bactericidal effects on the surface of Red Delicious apples, leaf lettuce and tomatoes inoculated with cultures of Salmonella spp. or Escherichia coli O157:H7. Inoculated samples were subjected to different doses ranging from 1.5 to 24 mW/cm(2) of UVC and enumerated on tryptic soy agar plus 0.05 g/l nalidixic acid to determine effective log reductions of microbial populations. UVC applied to apples inoculated with E. coli O157:H7 resulted in the highest log reduction of approximately 3.3 logs at 24 mW/cm(2). Lower log reductions were seen on tomatoes inoculated with Salmonella spp. (2.19 logs) and green leaf lettuce inoculated with both Salmonella spp. and E. coli O157:H7 (2.65 and 2.79, respectively). No significant statistical difference (p>0.05) was seen in the ability of UVC to inactivate a higher population of either Salmonella spp. or E. coli O157:H7 on the surface of green leaf lettuce. No significant difference was seen among the use of different doses applied to the surface of fresh produce for reduction of E. coli O157:H7 or Salmonella spp. (p>0.05). The use of UVC may prove to be beneficial in protecting the safety of fruits and vegetables in conjunction with Good Agricultural Practices and Good Manufacturing Practices.     

High-pressure resistance variation of Escherichia coli O157:H7 strains and Salmonella serovars in tryptic soy broth, distilled water, and fruit juice

The effect of high pressure on the log reduction of six strains of Escherichia coli O157:H7 and five serovars of Salmonella enterica was investigated in tryptic soy broth, sterile distilled water, and commercially sterile orange juice (for Salmonella) and apple cider (for E. coli). Samples were subjected to high-pressure processing treatment at 300 and 550 MPa for 2 min at 6 degrees C. Samples were plated onto tryptic soy agar directly after pressurization and after being held for 24 h at 4 degrees C. At 300 MPa, little effect was seen on E. coli O157:H7 strains, while Salmonella serovars varied in resistance, showing reductions between 0.26 and 3.95 log CFU/ml. At 550 MPa, E. coli O157:H7 strains exhibited a range of reductions (0.28 to 4.39 log CFU/ml), while most Salmonella populations decreased beyond the detection limit (> 5-log CFU/ml reduction). The most resistant strains tested were E. coli E009 and Salmonella Agona. Generally, bacterial populations in fruit juices showed larger decreases than did populations in tryptic soy broth and distilled water. E. coli O157:H7 cultures held for 24 h at 4 degrees C after treatment at 550 MPa showed a significant log decrease as compared with cultures directly after treatment (P < or = 0.05), while Salmonella serovars did not show this significant decrease (P > 0.05). All Salmonella serovars tested in orange juice treated at 550 MPa for 2 min at 6 degrees C and held for 24 h showed a > 5-log decrease, while E. coli O157:H7 strains require a higher pressure, higher temperature, longer pressurization, or a chemical additive to achieve a 5-log decrease.     

Sensitive detection of Escherichia coli O157:H7 by conventional plating techniques

The direct detection and estimation of concentration of Escherichia coli O157:H7 down to 1 CFU/g of cheese was achieved by conventional plating techniques. Cheese was manufactured with unpasteurized milk inoculated with E. coli O157: H7 at 34 +/- 3 CFU/ml. The numbers of E. coli O157:H7 were monitored during cheese ripening by plating on sorbitol MacConkey agar supplemented with cefixime and potassium tellurite (CT-SMAC) and on CT-O157:H7 ID medium. Using the pour plate method, E. coli O157:H7 colonies could easily be distinguished from non-O157:H7 colonies on CT-O157:H7 ID medium but not on CT-SMAC. Higher numbers of E. coli O157:H7 were detectable with O157:H7 ID medium. Latex agglutination and PCR were used to confirm the identification of typical E. coli O157:H7 colonies, and nontypical colonies as not being E. coli O157:H7. As few as 1 CFU/g of cheese could be detected. E. coli O157:H7 also was detected in deliberately contaminated milk at concentrations as low as 4 CFU/10 ml.     

Inactivation of E. coli O157:H7 on blueberries by electrolyzed water, ultraviolet light, and ozone

Increased interest in blueberries due to their nutritional and health benefits has led to an increase in consumption. However, blueberries are consumed mostly raw or minimally processed and are susceptible to microbial contamination like other type of fresh produce. This study was, therefore, undertaken to evaluate the efficacy of electrostatic spray of electrolyzed oxidizing (EO) water, UV light, ozone, and a combination of ozone and UV light in killing Escherichia coli O157:H7 on blueberries. A 5-strain mixture of E. coli O157:H7 were inoculated on the calyx and skin of blueberries and then subjected to the treatments. Electrostatic EO water spray reduced initial populations of E. coli O157:H7 by only 0.13 to 0.24 log CFU/g and 0.88 to 1.10 log CFU/g on calyx and skin of blueberries, respectively. Ozone treatment with 4000 mg/L reduced E. coli O157:H7 by only 0.66 and 0.72 log CFU/g on calyx and skin of blueberries, respectively. UV light at 20 mW/cm2 for 10 min was the most promising single technology and achieved 2.14 and greater than 4.05 log reductions of E. coli O157:H7 on the calyx and skin of blueberries, respectively. The combination treatment of 1 min ozone and followed by a 2 min UV achieved more than 1 and 2 log additional reductions on blueberry calyx than UV or ozone alone, respectively. PRACTICAL APPLICATION: Outbreaks of foodborne illnesses have been associated with consumption of fresh produce. Many methods for removing pathogens as well as minimizing their effect on quality of treated produce have been investigated. UV technology and its combination with ozone used in this study to inactive E. coli O157:H7 on blueberries was found effective. Results from this study may help producers and processors in developing hurdle technologies for the delivery of safer blueberries to consumers.