油炸调理肉串过程煎炸条件对大豆油苯并芘含量及理化指标的影响

为探讨大豆油在油炸冷冻调理肉串过程中,加热温度和油炸量对油品质的影响,本实验分别在160、175、190℃温度下,累计油炸处理2、4、6、8、10、12、14 kg调理肉串后,测定煎炸油的苯并芘含量、色泽、酸价、黏度以及过氧化值。结果表明,在不同油炸温度下,随着油炸处理量的增加,大豆油的苯并芘含量逐渐升高,分别达到2.60、3.98、9.54μg/kg,温度越高含量越大。红值和黄值逐渐增加,黏度由0.04 Pa·s逐渐增加至0.12、0.13、0.14 Pa·s,酸价分别增加至0.45、0.47、0.53 mg KOH/g,温度越高,油的颜色越深,黏度越大;过氧化值呈现波动趋势,最大值分别为7.75、10.01、22.26 mmol/kg,温度越高过氧化值越大。因此,油炸加工调理猪肉串过程中应合理控制温度和油炸处理量。     

水分含量对马铃薯淀粉凝胶体系脂肪吸收的影响

以马铃薯淀粉为原材料,与水进行模拟,在180 ℃条件下对马铃薯淀粉凝胶样品进行常压油炸,研究油炸样品中总油脂含量,以及各部分油脂含量的分布情况。结果表明：随着水分含量的增加,马铃薯淀粉凝胶体系油炸样品的总油脂含量、表面油脂含量和表面渗透油脂含量呈逐渐增加的趋势。随着油炸时间的延长,马铃薯淀粉凝胶体系油炸样品的总油脂含量和组织结构油脂含量呈逐渐增加的趋势,表面渗透油脂含量呈逐渐降低的趋势。随着水分含量的增加,表面渗透油脂含量在油炸样品总油脂含量中占据最大部分,其次是组织结构油脂含量,最少的是表面油脂含量。不同部分油脂含量的变化呈现一定的规律性,但变化幅度有一定的差异。     

响应面法优化调理鸡排水油混合油炸工艺

为研究调理鸡排水油混合油炸的最佳工艺条件,在单因素试验的基础上,应用响应面法探讨油炸温度和油炸时间及两者交互作用对调理鸡排水分含量,脂肪含量,黄度(b*)值和感官特性的影响,建立了二次响应预测模型。结果表明:水油混合油炸调理鸡排的最佳工艺参数是油炸温度165℃,油炸时间210 s,在此条件下鸡排的含水量为62.41%,脂肪含量为8.98%,黄度(b*)值为51.04,感官评分为8.87,与模型预测值拟合良好。     

油炸时间和温度对模拟马铃薯片油脂吸收的影响

为了研究油炸时间与温度对油炸样品的油脂吸收的影响,以马铃薯淀粉和水为原料,配制出模拟马铃薯片,以此简单体系为研究对象,采用染色油的方法来测定不同分布的油脂含量,从而得出表面油脂、表面渗透油脂、结构油脂、总油脂的含量。结果表明,样品总油脂和结构油脂含量随着油炸时间的增加而增加,表面渗透油脂含量随着时间的增加先上升后下降,而油炸时间对表面油脂的含量影响不显著。随着油炸温度的上升,总油脂含量显著增加,结构油脂含量呈现上升趋势;在180℃和200℃下,表面油脂含量之间没有显著性差异;140℃和其他温度下的表面渗透油脂含量存在显著差异。     

粉末油脂过氧化值测定中油脂提取方法的研究

建立了测定粉末油脂过氧化值中油脂的提取方法。利用丙酮-水(体积比1∶1)为溶剂,辅以超声破壁处理及加电解质后冷冻离心破乳,提油率可达70%以上。采用低温避光减压脱溶,有效避免了提取油脂过程对过氧化值结果的影响,从而可以反映粉末油脂真实质量水平。该方法提取成本低,使用低毒试剂,更为经济、环保,精密度良好,准确度较高,可应用于粉末油脂中过氧化值的测定。     

油脂饱和度对油炸马铃薯片品质的影响

以玉米油、花生油、大豆油、大豆棕榈调和油、棕榈油5种不同饱和度油脂作为煎炸用油,以马铃薯片为煎炸内容物,于140℃循环煎炸。考察马铃薯片的油脂含量、水分含量、色泽、酥脆性以及感官评分的变化,综合分析油脂饱和度对油炸马铃薯片品质的影响。结果表明:煎炸油脂的饱和度显著影响油炸马铃薯片的品质(p 0.05),随着煎炸油脂饱和度的增加,油炸马铃薯片的油脂含量呈降低的趋势,水分含量呈增加的趋势,L值呈增大的趋势,表明马铃薯片颜色随着煎炸油脂饱和度的增加而越发鲜亮;油炸马铃薯片的酥脆性、感官评分亦随煎炸油脂饱和度的增加呈显著增加的趋势(p 0.05)。由此可知,相对于不饱和度较高的玉米油、花生油、大豆油,饱和度较高的棕榈油更加适合马铃薯片的煎炸。     

冷冻调理贻贝的加工工艺

通过对冷冻调理贻贝加工工艺参数的筛选试验,确定了冷冻调理贻贝的调味料配方、浆液浓度、食用时油炸温度及油炸时间等工艺参数。经分析检测,在-18℃下冻藏6个月后,冷冻调理贻贝仍符合卫生质量要求。     

物料组成对重组马铃薯片油脂吸收的影响

为了研究物料组成对油炸样品油脂吸收的影响,以不同比例的马铃薯淀粉、谷朊粉、大豆分离蛋白和水为原料制备不同体系的重组马铃薯片,采用染色法测定体系中不同类型的油脂的含量,并利用扫描电镜(SEM)和体视显微镜(SM)观察油炸前后的结构特征。结果表明,重组体系中的蛋白质量分数越高,总油脂和结构油脂含量越低,添加谷朊粉的重组体系比添加大豆分离蛋白体系的总油脂含量低10.04%~16.69%。蛋白质的添加均会影响油炸前后的重组马铃薯片的表面及内部结构,且油脂含量随着蛋白质量分数的增加而降低。     

4种亲水多糖对油炸调理鸡排品质的影响

亲水多糖常被用来改善即食类油炸产品的质量.针对油炸调理类产品含油量高的问题,通过向油炸调理鸡排外裹糊中添加黄原胶、海藻酸钠、羟丙基甲基纤维素和魔芋胶4种亲水多糖,探究亲水多糖对二次油炸调理鸡排品质(水分含量、油分含量、色泽、脆性、可冻结水含量及感官评价)的影响.结果 表明:与对照组相比,添加4种亲水多糖可以显著提升油炸...     

低温真空油炸对半干水产品营养成分和食用油品质的影响

研究了在不同温度、真空度及油炸时间条件下,低温真空油炸对半干水产品（半干马面鱼）水分、蛋白质、脂肪含量的变化情况及食用油的过氧化值、酸价和羰基价随油炸温度和时间以及真空度改变的变化规律。结果显示．真空度是影响半干水产品品质的主要因素,但对油炸过程中油脂的稳定性影响非常小,而油炸温度和油炸时间对油炸产品的品质影响相对较小。大豆食用油的过氧化值、酸价和羰基价随油炸温度的升高和时间的延长出现上升的趋势．但幅度很小。在整个真空油炸实验过程中,大豆食用油具有很好的稳定性。     

EVALUATION OF THE TEXTURE OF FRIED POTATOES

Texture of potatoes with different shapes (slices and strips) were evaluated after frying and in some cases after baking. Blanched and unblanched potato slices (Bintje variety) were fried at four oil temperatures: 160, 170, 180 and 190C until reaching a moisture content of ∼1.7%. A puncture test with three point support for the slices was applied to measure the texture of potato chips using the following parameters extracted from the force versus distance curves: maximum force of break (MFB) and deformation of break (DB). These two parameters were useful to follow the changes in texture of the fried slices with moisture content at different frying temperatures. Blanched and unblanched potato strips were partially fried at 160C and 190C for 60, 90 and 120 s. The par-fried potatoes were frozen at -20C for one day after which they were baked at 200C for 15 min. The texture of the baked potato strips was evaluated using a bending test with two support points. From the force versus distance curves, two parameters were extracted: maximum force of deformation (MFD) and maximum deformation (MD). Significant higher MFB and lower DB values (P > 0.1) for unblanched fried slices indicate that these are crispier than blanched chips for moisture contents lower than 4% (6.59 N and 0.62 mm vs 5.74 N and vs 0.75 mm for unblanched and blanched chips, respectively, average values for the four frying temperatures employed). There was no effect of the frying temperature and the pretreatment (blanching or unblanching) on the texture of the frozen par-fried potatoes after baking when compared at the same residual moisture content, but blanched potato strips lost moisture more slowly both in frying and in baking.     

Effects of frying and storage at room temperature on the chemical composition and quality of sweet potato slices

Fried sweet potato slices were prepared from yellow (Mabrouka) and orange (Abees) tubers. Some chemical and organoleptic qualities were studied. Changes in these qualities which occurred during storage for 3 months at room temperature were also investigated. The results obtained led to the following conclusions: 1. Sweet potato slices had moderate amounts of calcium and phosphorus, and there was no significant difference in mineral content between fresh and fried sweet potato slices. 2. Sweet potato slices contained a fair amount of essential amino acids, especially leucin, valine and lysine, whereas tryptophan and sulphur amino acids were the limiting amino acids. 3. Sliced sweet potato of yellow variety (Mabrouka) dipped in water, then deep fried in cotton seed oil at (180 ± 5)°C for 1.25 min was organoleptical proved to be the best compared with those prepared from orange variety (Abees), or of yellow variety but dipped in 1% citric acid. 4. Storage of fried sweet potato slices (Mabrouka) in polyvinyl packages at room temperature led to gradual increases in their moisture content and peroxide value, while carotenoids content decreased. Furthermore, the fried sweet potato slices were acceptable until the 10th week of storage, then a rancid taste begins to appear.     

Effect of osmotic pretreatment and microwave frying on acrylamide formation in potato strips

BACKGROUND: The presence of acrylamide, a probable carcinogen, is currently a major concern relating to the consumption of fried products. Therefore, recent frying studies have focused on ways of reducing the acrylamide content. The main objective of the present study was to determine the effects of microwave frying and osmotic treatment prior to frying on acrylamide formation in potato strips. RESULTS: Potatoes fried using 400 W microwave power for 1.0 min had an 87.85% lower acrylamide content than potatoes fried conventionally for 4.5 min (i.e. an 81.82% reduction in frying time) but a comparable moisture content. The acrylamide content of fried potatoes treated osmotically prior to both microwave and conventional frying was found to be lower than that of fried potatoes not pretreated osmotically. However, the reduction in acrylamide content was lower when osmotic treatment was applied before microwave frying. CONCLUSION: As a result of this study, it was concluded that microwave frying can be an alternative to conventional frying. Copyright © 2007 Society of Chemical Industry     

即烹扇贝冷冻预制菜的质构特性及营养品质评价分析

目的 探讨即烹扇贝冷冻预制菜的质构特性和营养价值。方法 采用不同熟化方式对3种扇贝冷冻预制菜(蒸蒜蓉扇贝、香煎扇贝、烤扇贝)进行处理, 分析熟化后的质构、色差、微观结构、基本营养成分、氨基酸及脂肪酸组成与生扇贝及煮扇贝的差异, 采用相关性分析及主成分分析综合评价扇贝预制菜品质。结果 扇贝冷冻预制菜熟化后硬度、弹性和咀嚼性均显著性增加, 但蒸蒜蓉扇贝和烤扇贝的质构指标均低于煮扇贝和香煎扇贝, 后者肌肉纤维排列更紧密;香煎扇贝、烤扇贝和蒸蒜蓉扇贝的白度值均显著低于煮扇贝和生扇贝; 熟化后扇贝均具有高蛋白低脂肪的特点, 蛋白质含量为20.68~29.79 g/100 g, 粗脂肪含量为0.50~2.26 g/100 g; 氨基酸组成合理, 脂肪酸组成丰富, 必需氨基酸含量在22.05~31.07 g/100g, 烤扇贝具有较高的二十碳五烯酸和二十二碳六烯酸含量; 主成分分析营养价值由高到低为香煎扇贝>烤扇贝>蒜蓉扇贝>煮扇贝>生扇贝。结论 即烹扇贝冷冻预制菜熟化后营养全面, 香煎扇贝质构及营养价值综合评价较高, 本研究为后续开发扇贝产品提供了理论数据。     

The influence of French fries processing on the glycoalkaloid content in coloured-fleshed potatoes

French fries made from coloured-fleshed potatoes may be interesting alternative to the traditional snacks for consumers. However, potatoes contain glycoalkaloids (TGA), so potato tubers and obtained fried snacks should be subjected to comprehensive examination. The aim of this study was to determine the effect of different stages of French fries processing on the content of TGA (α-solanine and α-chaconine) in the red- and blue-fleshed potatoes, in semi-products and ready-to-eat products. It was stated that during the processing of French fries prepared from coloured-flesh potato varieties significantly decreased the content of TGA (α-solanine and α-chaconine) in the samples obtained at different stages of the process compared to the raw material. Potatoes with blue-fleshed of Vitelotte variety and red-fleshed of Highland Burgundy Red variety can be used to French fries processing due to their low content of TGA (in unpeeled and peeled potatoes). However, Blue Congo variety with blue-fleshed should not be applied to French fries processing, because of high TGA content in raw material and first of all in peeled potatoes flesh. The peeling process of coloured-fleshed potatoes decreased in TGA content on average by about 50 %, cutting process on average by about 53 %, whereas blanching on average by about 58 % compared with the raw material. The highest decrease in TGA content was caused by frying process. The mean values were about 97.5 % in ready-to-eat French fries. In French fries after I and II steps of frying, the ratio α-solanine to α-chaconine was lower (1.0:2.0) than in unpeeled potatoes (1.0:2.3).     

The influence of thermal process of coloured potatoes on the content of glycoalkaloids in the potato products

Potato products made from potato varieties with coloured flesh (red and blue-fleshed potatoes) may be an interesting alternative to traditional products. The purpose of this study was to determine the influence of peeling, cooking and frying of red and blue-fleshed potato tubers on the content of glycoalkaloids (α-solanine and α-chaconine) in processed potato products. The material taken for the study consisted of seven coloured potato varieties. French fries and crisps were prepared from two potato variety: Rosalinde and Blue Congo. The content of total glycoalkaloids (TGA) in raw material before and after peeling, in cooked unpeeled and peeled potatoes and also in fried potato products have been determined by HPLC method.     

Use of Yuja (Citrus junos) pectin as a fat replacer in baked foods

Pectin from yuja pomace was incorporated into cake formulations to evaluate the baking performance as a fat replacer. When shortening in cakes was replaced with different levels of pectin gel, cake batter exhibited greater viscosity and less shear-thinning behavior. The viscosities were well characterized using a Power-law model. The specific gravity of cake batter significantly increased with increasing levels of pectin gel (p<0.05) and was highly correlated with the cake volume after baking. Although cakes containing pectin exhibited increased textural hardness, shortening replacement with pectin up to 10% by weight was effective in producing cakes as soft as the control cake without a volume loss. There was an overall tendency that cakes with higher amounts of pectin showed a lighter surface color. Yuja pectin was thus used in cake baking as a fat replacer, producing baked goods with reduced fat and calorie content.     

Effect of Microwave Frying on Acrylamide Generation,Mass Transfer,Color, and Texture in French Fries

The objective of this work was to evaluate the effect of microwave power on acrylamide generation, as well as moisture and oil fluxes and quality attributes of microwave-fried potatoes. Concretely, 25 g of potato strips, in 250 mL of fresh oil (at room temperature), were subjected to three different microwave powers (315, 430, and 600 W) in a conventional microwave oven. Microwave frying resulted in an acrylamide reduction ranged from 37 to 83% compared to deep-oil frying. Microwave-fried French fries presented lower moisture and higher fat content than deep-oil fried potatoes. Concretely, microwave-fried potatoes presented values of moisture and texture more similar to potato chips than French fries, nonetheless with lower fat levels (less than 20 g/100 g wb) and acrylamide content (lower than 100 μg/kg wb) at the reference time. This study presents an alternative way of frying to address the production of healthier potato chips.     

炸制过程中油脂氧化对鱼饼中晚期糖基化终末产物生成的影响

旨在为炸制鱼饼中晚期糖基化终末产物(AGEs)含量的控制提供理论依据和参考,以冷冻鲢鱼糜为原料制作鱼饼,通过分析连续炸制过程中(每3 h炸制1次)鱼饼中AGEs的生成与其理化指标和油脂氧化程度之间的相关性,探讨炸制过程中油脂氧化对鱼饼中AGEs生成的影响。结果表明：鱼饼外层AGEs含量显著高于内层,炸制9～18 h,鱼饼AGEs含量显著高于其他阶段(p<0.05);鱼饼中AGEs含量与水分含量呈极显著负相关,与脂肪含量和丙二醛含量呈极显著正相关,说明水分散失、油脂吸收以及油脂氧化促进了AGEs的生成。综上,在连续炸制过程的中期,鱼饼中水分含量较低,油脂氧化较为严重,AGEs含量较高。     

A novel strategy of acrylamide mitigation in fried potatoes using asparaginase and high pressure technology

The potentiality of high pressure processing (HPP) to possibly enhance diffusion of asparaginase into raw potato sticks, and consequently on reduction of acrylamide levels in fried potatoes was evaluated. Raw potato sticks were immersed in asparaginase (10,000 ASNU/L) and immediately subjected to 0.1, 100, 200 and 400 MPa for 5 min, with total enzymatic reaction times of 5, 10 and 20 min and room temperature. Pressurized raw potato sticks became softer, more flexible, and required lower energy for cutting (up to 47% less); the roughness of potato surface and moisture content were slightly reduced; and the concentration of soluble solids in the exterior solutions increased, indicative of a leaching effect. Due to changes induced by asparaginase and/or HPP on raw potatoes, fried potatoes exhibited higher weight loss after frying, and higher hardness (crispness). The combined treatment with asparaginase and HPP showed to reduce acrylamide levels by 26–47%, while with asparaginase or HPP alone there was no significant reduction.Industrial relevanceHPP is a non-thermal technology that may be used as a pre-treatment for the production of fried potatoes with different/better textural and nutritional properties, as well as to reduce energetic costs of some industrial steps of the production of fried potatoes (for instance, the cutting process and frying time). Also, a combined pre-treatment with HPP and asparaginase may be used as a strategy of acrylamide mitigation in fried potatoes.