Effects of liquid smoke on quality characteristics of Turkish standard smoked beef tongue

The purpose of this research was to determine some quality characteristics of beef tongues processed with liquid and vaporous (traditional) smoke. The tongues were divided into two groups; traditional (vaporous) smoking and liquid smoke application groups, and the processed tongues were vacuum packaged and monitored for quality during 30 days of storage at 4±1?°C. All the smoked tongue samples were subjected to chemical, microbiological and organoleptic analysis at 0, 5, 10, 15 and 30 days of storage. The results indicated that despite some favorable results attributed to traditional smoking, liquid smoke application of beef tongue is also possible without causing any major acceptability problems in terms of quality.     

Influence of different smoking techniques on contamination by polycyclic aromatic hydrocarbons in traditional smoked Mozzarella di Bufala Campana

The levels of six polycyclic aromatic hydrocarbons (PAHs) including benzo[a]pyrene and three other PAH were determined in smoked Mozzarella di Bufala Campana. Different smoking techniques were compared to evaluate the risk associated with consumption of these cheeses. Although no maximum limits are set for PAHs in cheese, the levels found in some samples constitute a health risk. In fact, using corrugated cardboard, high levels were detected in the whole product or in the outer part. Also, the use of traditional materials involves the accumulation of PAHs in the outer part, but in the total product concentrations are significantly lower. No contamination was found using liquid smoke.     

Polycyclic aromatic hydrocarbons in smoke from different woods and their transfer during traditional smoking into chorizo sausages with collagen and tripe casings

Polycyclic aromatic hydrocarbons (PAHs), at least those with high molecular mass, are classified as probable human carcinogens by the US Environmental Protection Agency. The importance of the material used to generate smoke is indicated by the attention that the European Union is paying to list the wood that can be used to produce smoking flavour agents. The paper examines the dependence on the nature of the wood used for smoking on the formation of eight PAHs (selected as markers of PAHs) and transfer of these PAHs into traditional Spanish smoked chorizo sausages with collagen and tripe casings. The results showed that the kind of combustion performed on different materials seriously affected the PAH levels in the smoke generated. Ignition and firing of the material with a flame compared with heating produced more PAHs in the smoke. The levels of PAHs found in the meat and in the collagen and tripe casings of the smoked chorizo samples suggest that the collagen-based casings behave as a better barrier to PAHs.     

Organoleptic characterization and PAH content of salmon (Salmo salar) fillets smoked according to four industrial smoking techniques

Four industrial processes for smoking food were studied through their effects on the organoleptic properties of smoked salmon and on the occurrence of 20 polycyclic aromatic hydrocarbons (PAHs) known as being contaminants of smoking processes. The contamination by PAHs of the food might be measured by their corresponding toxic equivalent quantity (TEQ) expressed in µg kg^?1. The results show a significant correlation between the smoking process parameters, the odour of the smoked fish and the presence of PAHs. Smouldering, thermostated plates and friction smoking processes allow smoked fish with very close odorant characteristics to be obtained. However, differences of pyrolysis temperature (between 380 and 500 °C) causes significant differences of PAHs concentration even if the contents are under the legal threshold concerning benzo(a)pyrene (5 µg kg^?1). Smoked fish obtained by liquid smoke vaporisation presented the lowest level of PAHs but benzo(a)pyrene concentration is nevertheless important. The odours brought by the liquid smoke process are more ‘cold smoke’ and ‘vegetal/green’ than the other techniques, which are smokier and fishier. Copyright © 2007 Society of Chemical Industry     

不同类型烟熏香精对西式培根风味的影响

为研究不同类型烟熏香精对西式培根风味的影响,本研究通过感官评价和电子鼻技术对添加不同类型烟熏香精制作的西式培根进行整体风味的分析,利用固相微萃取气相色谱-质谱联用技术研究不同类型烟熏香精对西式培根挥发性风味物质的影响。结果表明,不同类型烟熏香精制作的西式培根与传统西式培根在整体风味和主体风味化合物上进行比较,乐香水溶性烟熏香精（样品5）差异最小,其次为名花烟熏膏香精（样品1）和奇华顿油溶性烟熏香精（样品3）,再次为红箭油溶性烟熏香精（样品2）,而红箭水溶性烟熏香精（样品4）差异最大。乐香水溶性烟熏香精制作的西式培根与传统西式培根（对照样）的挥发性风味物质比较接近,有愈创木酚、4-甲基愈创木酚、苯酚和2,6-二甲基苯酚等35种共有成分。其中酚类物质的种类和传统西式培根相同,而含量是传统的1.22倍,从宏观和微观上都可以达到传统西式培根的风味。     

Consumer perception of smoked Cheddar cheese

Consumer perception of smoked cheese was evaluated through focus groups, surveys, and central location testing. Three focus groups (n = 29) were conducted with consumers of smoked cheese. Subsequently, 2 online surveys were conducted. The purpose of the first survey (n = 1,195) was to understand types of smoked cheeses consumed and if consumers associated specific wood smokes with smoked cheese. Next, an adaptive choice-based conjoint (n = 367) was designed to evaluate consumer perception of different attributes of smoked cheese. Maximum difference scaling and familiarity questions were also included in the adaptive choice-based conjoint survey. Following the surveys, a central location test (n = 135) was conducted with cheeses smoked with 3 different woods at a low and high intensity (6 cheeses total). Hierarchical Bayesian estimation, 1-way ANOVA, agglomerative hierarchical clustering, and 2-way ANOVA (smoke type × intensity level) were used to interpret the collected data. Results from the focus groups indicated that smoked cheese was perceived as an artisan, high-end product and that appearance and price were strong purchase factors. In general, consumers were not aware of how smoked flavor was imparted to cheese, but when informed of the processes, they preferred cold-smoked cheese to the addition of liquid smoke flavor. Results from both surveys confirmed focus group observations. Consumers perceived flavor differences among different wood smokes and smoked products. Method of smoking, smoke intensity, type of wood, and type of cheese were the most important attributes for purchase of smoked cheese. When tasting, consumers differentiated smoke aroma and flavor among cheeses and preferred cherry wood smoked cheeses over apple wood or hickory smoked cheeses. Understanding consumer perceptions of smoked cheese will give insight into the desired experience that consumers expect when purchasing smoked cheese.     

The effect of natural and liquid smokes on the benzo[a] pyrene content and quality parameters of Circassian cheese

The objective of this study was to determine the effects of natural smoke and liquid smoke application methods on quality characteristics of smoked Circassian cheese. The microbial counts of liquid smoked cheeses were found to be higher than naturally smoked cheeses. It can be concluded that although natural smoke inhibited the growth of micro‐organisms more than liquid smoke application, benzo[a]pyrene, an indicator component for polycyclic aromatic hydrocarbons (PAH), was detected on the outer surface of naturally smoked cheeses. Therefore, liquid smoking could be used as an alternative method for smoked Circassian cheese production.     

Cellulose nanoparticles synthesised from potato peel for the development of active packaging film for enhancement of shelf life of raw prawns (Penaeus monodon) during frozen storage

In this study, the cellulose nanoparticles (CNP) isolated from potato peel were used for reinforcement of polyvinyl alcohol (PVA)-based active packaging film. The above film was used to pack the raw prawns (Penaeus monodon) at −20 °C, and the colour change, protein content, TVB-N, TMA and microbial analysis were done at regular interval for prawns stored in CNP-PVA active packaging film. A significant difference was observed in the quality of prawns stored in potato CNP-PVA film compared with prawns packed and stored in polyethylene film. The newly designed active packaging with CNP and fennel seed oil enhanced the shelf life of prawns up to two months for both HOSO (head on shell on) prawn and PD (peeled and deveined) prawn. Hence, the study recommends the potato peel CNP-PVA film with fennel seed oil as better choice to extend the shelf life of the prawns during storage compared with polyethylene packaging.     

Phenols in smoked, cured meats: nitrosation of phenols in liquid smokes and in smoked bacon.

Nitrosation of the phenolic components of liquid smoke preparations has been shown to take place in model systems simulating gastric digestion of smoked bacon. The major products isolated have been shown to be o-nitrophenols formed by oxidation, in the meat system, of the corresponding nitroso derivative. Similar compounds have been shown to be formed in actual samples of liquid smoked and traditionally smoked bacon during processing, frying and simulated digestion.     

EFFECT OF SMOKE SOURCES ON QUALITY AND STORAGE STABILITY OF CATFISH FILLET (Clarias macrocephatus Gunther)

The effect of smoke sources, bagasse and coconut husk, on the chemical composition, acceptability and quality changes of catfish fillets was investigated. Catfish smoked with either of the sources had similar compositions. Catfish fillets smoked with coconut husk attained significantly higher preference scores for color but odor scores were lower compared with those smoked with bagasse (p < 0.05). However, no significant differences in other attributes were observed for fillets smoked by the two different kinds of starting material. Smoked fillets showed lower TBA values, ammonia content, aerobic plant count (APC), yeast and mold than the control throughout 10 weeks of storage at 4C. For the smoked fillets, nonenzymatic browning was prevalent.     

Sous vide pretreatment in cooking sturgeon fish burger: Effects on physicochemical properties and sensory characteristics

The effect of sous vide (SV) pretreatment on the physicochemical (texture, water holding capacity (WHC) and protein modifications) and sensory (appearance, odour, flavour and overall acceptability) properties of sturgeon fish burgers cooked by four common methods (steaming, baking, microwaving and frying) were investigated. The texture analysis results showed that SV combined with transglutaminase could make the structure of cooked fish burgers denser and increase the springiness (ranging from 3.60 to 4.97 mm) and chewiness (ranging from 4.50 to 9.57 N), especially in microwave-cooked samples. In terms of sensory quality, on the one hand, SV could effectively inhibit off-flavours from oxidation and prevents evaporative losses of flavour volatiles (nitrogen oxides, organic sulphur and aromatic compounds) during cooking. On the other hand, the overall acceptability of microwave-cooked sample pretreated with SV was higher than that of other cooking methods, especially compared with steaming (P < 0.05). The above results indicate that it is feasible to obtain common cooked fish burgers with improved physicochemical and good sensory properties using SV pretreatment.     

The effect of drying,pressure and processing time on the quality of liquid‐smoked trout (Salmo gairdnerii) fillets

A new fish smoking process was applied using a combination of liquid smoke and steaming at pressures up to 1 bar above atmospheric. Processing yield, sensory analysis, instrumental colour measurement, available lysine and polynuclear aromatic hydrocarbons (PAHs) were estimated. The losses due to processing were quite reasonable (20.05 ± 4.9% to 23.58 ± 3.9%) and slightly influenced by the process. The fillets processed at 2 bar steam pressure, for 30, 45 or 60 min and previously dried were assessed as highly acceptable regarding their firmness, colour, flavour and acceptability by panellists. The destruction of available lysine was not very high (21.1 ± 8.4%) and it was dependent upon the process. Depending on the method used, very low (0.63–3.2ng g⁻¹) amounts of PAHs were found and were also dependent upon the process. Copyright © 2005 Society of Chemical Industry     

不同形态南美白对虾贮藏特性研究

以养殖南美白对虾为研究对象,分别经去头/去壳处理,对整虾、去头虾和虾仁在(0±0.5)℃贮藏过程中感官评分、气味组成、pH、挥发性盐基氮(TVB-N)、酚氧化酶(PO)活力和细菌总数(APC)的变化情况进行分析。结果表明,不同形态对虾在贮藏过程中的腐败特征明显不同,表现在,感官评分都呈下降趋势,但下降幅度和造成评分下降的原因有所差异;PO活力变化有明显差异,整虾PO活力相对较高,而虾仁基本无PO活力;不同形态对虾在货架期终点时的气味组成也有所不同;TVB-N和APC都呈上升的趋势,在指示货架期终点时表现出较好的一致性,而感官评分相对滞后。综合感官、生化和微生物指标,整虾、去头虾和虾仁在(0±0.5)℃条件下的货架期分别为7、9和11 d。     

Textural and physicochemical changes in salmon (Salmo salar) treated with commercial liquid smoke flavourings

The textural and physicochemical properties of fillets of farmed Atlantic salmon (Salmo salar) treated with two commercial liquid smoke flavourings (LS1 and LS2) were examined after 15, 30 and 45 days of storage at 2 °C in oxygen impermeable bags. Salmon flesh treated with LS1 was characterized by high water-soluble protein, fat and moisture contents, plus low hardness, fracturability, gumminess and chewiness, and a low alkali-insoluble protein content. These characteristics were similar to those of control salmon (not treated with liquid smoke flavouring). Storage time changed these properties similarly in both. Salmon flesh treated with LS2 was characterized by high hardness, fracturability, gumminess, chewiness and alkali-insoluble protein levels, plus low water-soluble protein, fat and moisture contents. Storage time appeared to have a far less important effect on salmon flesh treated with LS2.     

Use of healthier fats in biscuits (olive and sunflower oil): changing sensory features and their relation with consumers' liking

The aim of this study was to evaluate consumer acceptability of biscuits when saturated fat was replaced by olive or sunflower oil and to determine the sensory characteristics responsible for changes in acceptability. Ninety seven consumers evaluated the acceptability of six biscuit samples varying in the fat source (dairy shortening, olive oil and sunflower oil) and fat content (10.6% and 15.6%). Using a Check All That Apply question (CATA), consumers also evaluated sensory properties of biscuits. Results indicated that the replacement of saturated fat (dairy shortening) by vegetable oils had an effect on biscuit acceptability which depended on biscuit fat content. According to biscuits' acceptability data, three different clusters of consumers were identified. By using a multiple factor analysis, the relationship among sensory CATA data and acceptability of each cluster explained the different acceptability patterns of consumers. For most of consumers acceptability was related to attributes “crispy”, “easy to chew” and “biscuit flavour” which, for one group were perceived in shortening biscuits and, for another in both olive and shortening biscuits. However, for the third group of consumers, acceptability was only related to flavour attributes like “roasted flavour” or “biscuit flavour” that were perceived in vegetable oil biscuits which were the preferred biscuits while, shortening biscuits were disliked and perceived as having an “off flavour”.     

Passive smoking as well as active smoking increases the risk of acute stroke

OBJECTIVE: To estimate the relative risk of stroke associated with exposure to environmental tobacco smoke (ETS, passive smoking) and to estimate the risk of stroke associated with current smoking (active smoking) using the traditional baseline group (never-smokers) and a baseline group that includes lifelong non-smokers and long-term (> 10 years) ex-smokers who have not been exposed to ETS. DESIGN AND SETTING: Population-based case-control study in residents of Auckland, New Zealand. SUBJECTS: Cases were obtained from the Auckland stroke study, a population-based register of acute stroke. Controls were obtained from a cross-sectional survery of major cardiovascular risk factors measured in the same population. A standard questionnaire was administered to patients and controls by trained nurse interviewers. RESULTS: Information was available for 521 patients with first-ever acute stroke and 1851 community controls aged 35-74 years. After adjusting for potential confounders (age, sex, history of hypertension, heart disease, and diabetes) using logistic regression, exposure to ETS among non-smokers and long-term ex-smokers was associated with a significantly increased risk of stroke (odds ratio (OR) = 1.82; 95% confidence interval (95% CI) = 1.34 to 2.49). The risk was significant in men (OR = 2.10; 95% CI = 1.33 to 3.32) and women (OR = 1.66; 95% CI = 1.07 to 2.57). Active smokers had a fourfold risk of stroke compared with people who reported they had never smoked cigarettes (OR = 4.14; 95% CI = 3.04 to 5.63); the risk increased when active smokers were compared with people who had never smoked or had quit smoking more than 10 years earlier and who were not exposed to ETS (OR = 6.33; 95% CI = 4.50 to 8.91). CONCLUSIONS: This study is one of the few to investigate the association between passive smoking and the risk of acute stroke. We found a significantly increased risk of stroke in men and in women. This study also confirms the higher risk of stroke in men and women who smoke cigarettes compared with non-smokers. The stroke risk increases further when those who have been exposed to ETS are excluded from the non-smoking reference group. These findings also suggest that studies investigating the adverse effects of smoking will underestimate the risk if exposure to ETS is not taken into account.     

Effects of the smoking process on odour characteristics of smoked herring (Clupea harengus) and relationships with phenolic compound content

The relationship between smoking parameters and odour characteristics, evaluated by a trained sensory panel, were studied on smoked herring. In addition, a possible correlation between the content of 10 phenolic compounds and sensory perceptions was investigated. Five smoking techniques were applied, combining smoke production conditions, performed by pyrolysis of beech wood sawdust or by friction of beech wood log, with smoke deposition, either in a controlled kiln (traditional smoking) or by an electrostatic process. In the fifth smoking technique, a purified condensate of beech smokes was vaporised on fish fillets in the smokehouse. The time of smoking was 3 h for traditional smoking and the liquid smoke atomisation process and 12 min for the electrostatic method. The effects of three smoking temperatures (16, 24, 32 °C) were tested for both the traditional and the liquid smoke atomisation processes, as well as the effect of the position of the exhaust valve in the smokehouse in the case of the traditional method. Two different voltages were applied for the electrostatic process, 37 and 42 kV.     

Some changes in an aqueous liquid smoke flavouring during storage in polythene receptacles

Aqueous liquid smoke produces a brown layer on the wall of the polythene receptacle in which it has been contained. The constituents of this brown layer have been extracted using dichloromethane and were studied by means of gas chromatography/mass spectrometry (GC/MS) and Fourier transform infrared spectroscopy (FTIR). Some changes in the liquid smoke were deduced through comparisons of data from the brown layer with the previously obtained liquid smoke data. Due to interactions between polythene molecules and compounds of the liquid smoke, some of these latter compounds migrate into the wall of the receptacle and are retained there. The extent of these migrations depends on the size of the hydrocarbon part of each compound. However, far from being harmful, this migration is useful, since compounds irrelevant from the point of view of flavour, and harmful to health are the main compounds affected by the retention on the polythene wall. Some of the adsorbed compounds have not previously been reported to be present in liquid smoke.     

The effect of liquid smoking of fillets of trout (Salmo gairdnerii) on sensory,microbiological and chemical changes during chilled storage

The storage time at 4 ± 1 °C of liquid smoked fillets of trout (Salmo gairdnerii) produced with a new smoking technique, using a combination of liquid smoke and steaming at 2 bar pressure for 30, 45 and 60 min, was studied. Maximum total viable counts (TVC) were reached after 25 days in the samples processed for 30 min and after 48 days in those processed for 45 and 60 min. However, panellists rejected the samples long after maximum TVC was observed. The increase of TVC was also confirmed using a particle size analyser, indicating a possible direct detection of microbial growth. A reduction of about 50% in the C22:6n − 3/C16:0 ratio was found across the whole period of storage, indicating lipid oxidation. The hypoxanthine/inosine (Hx/Ino) ratio showed a good relationship with both TVC and sensory results. Thus, when the Hx/Ino ratio was higher than 1.3, the products had reached their maximum acceptable TVC and were approaching their rejection time by the panellists, indicating that the Hx/Ino ratio is a good indicator of the shelf-life of smoked products of trout (S. gairdnerii).     

Cold Smoking of Atlantic Salmon (Salmo salar) Fillets with Smoke Condensate—an Alternative Processing Technology for the Production of Smoked Salmon

ABSTRACT:  Two different protocols for the production of cold smoked salmon were investigated. All fillets were dry salted (18 h, 4 °C) before being allotted to a smoke condensate/liquid smoke protocol (SCP), which included drenching (1 min) in smoke condensate [1:3 (v/v) smoke:water] and drying (150 min, 28.4 ± 2.2 °C) or a wood chips protocol (WCP) that included drying and smoking in a regular smoking chamber (23 °C, 480 min) using wood chips for smoke production. Quality assessments were performed on the smoked fillets at day 0 and after 7, 14, and 31 d of storage (3.4 ± 0.7 °C). Application of the SCP resulted in a significantly higher ( P < 0.01) processing yield (89.6%± 0.7%) as compared to the WCP (88.6%± 0.5%). On day 0, the SCP fillets were significantly ( P < 0.01) less light ( L *) and yellow ( b *) and had a lower chroma ( C *) and hue ( h *) compared to the fillets processed with WCP. From 7 d until the end of storage time, small differences in color were observed. After 31 d of storage, the SCP fillets had a significantly higher ( P < 0.05) intensity of oily texture and lower intensity of salty and smoke taste. Texture profile analysis (TPA) showed few significant differences between the processing protocols, although the WCP fillets were significantly harder than the SCP fillets when recording the force at 60% compression of the fillet height. The use of smoke condensate and drenching technology is a way of producing cold smoked salmon with quality characteristics quite similar to those found in commercial "traditional" products, although processors who want to use this technology have to optimize the drying step and the smoke condensate formulation to their specifications.